User Manual
Contents
1. SEE TO PAGE 12 MANUAL DEFROST MANUAL DEFROST MANUAL DEFROST BUTTON FAN RUNNING DOOR OPENING SEE TO PAGE 11 MANUAL DEFROST 1 If you push MANUAL DEFROST button for 5 seconds the Defrost will start 2 During the Manual Defrost mode the Up Down button for the temperature control can not make the compressor cycle ON or OFF 3 If you want to change the Manual Defrost mode to the normal mode push MANUAL DEFROST button for 5 seconds UP DOWN BUTTON Temperature control button 1 By pushing the up down button you can set the inside temperature level from T to Q 2 If you want lower temperatures push the Down button to be lighted higher level numbers DEFROST 1 The electronic defrost controller is set at the factory to provide a defrost cycle every 6 hours 4 times per a day 2 If it is necessary to change the intervals of defrost due to unusual operating conditions it can be accomplished by adjusting the switch which is located on the inside of the top grille 3 Once all frost is eliminated the temperature continues to rise until it reaches 60 F 15 C When this temperature is sensed by the defrost limit control the defrost control changes to refrigeration mode 4 The panel displays 4 during the defrost cycle i T bd ap 11 INNER TEMPERATURE DISPLAY 1 It displays inside temperature 2 Display range is 50 F to 50 F 45 C 10 C2. Zurbc TOR HARRIS TURER Turbo Air Speeds up the Pace of Innovation Super Deluxe Series Refrigerators amp Freezers Installation and Operation Manual Please read this manual completely before attempting to install or operate this equipment Full Stainless Steel Interior and Exterior SOLID DOOR REFRIGERATORS TSR 23SD TSR 35SD TSR 49SD TSR 72SD SOLID DOOR FREEZERS TSF 23SD TSF 35SD TSF 49SD TSF 72SD www turboairinc com CONTENTS t SPEC IEC ATIONS ce a AA D 5 SERITAL NOMD escent seer ct epee A A EAEE D SNS ONE rtnn 3 A CLEANING A CAUTION EE ee ee 4 5 BASIC OPERATION REA AD OU cee eepee tae cecenentes searaeecceteeceangegeuseeetietseseasseqeeceeeweetaters 5 8 92 FREEZER ee ee 9 12 TROUBLES ONE ee tect EE 13 TT ee US cst eee wee cee E eee 14 16 SPECIFICATIONS Refrigerators MODEL COMPH P VW Hz REFRIGERANT AMPS WEIGHT 115V 60Hz R 134A 274lbs 115V 60Hz R 134A 357lbs TSR 49SD 115V 60Hz 4271bs TSR 72SD 115V 60Hz 602lbs Freezers MODEL COMP H P V Hz REFRIGERANT AMPS WEIGHT TSF 23SD 1 2 115V 60Hz R 404A 7 8A 293lbs TSF 35SD 3 4 115V 60Hz R 404A 10 0A 390lbs TSF 49SD 3 4 115V 60Hz R 404A 10 5A 4571bs TSF 72SD TI5V 6OHZ R 404A 12 7A 639lbs SERIAL NUMBER The serial number is located on the data label inside Please retain the unit s serial number for service purpose INSTALLATION 1 GOOD AIR CIRCULATION Be sure to avoid any partition an
3. REFRIGERATOR TEMP SETTING TEMP CONTROL BUTTON SEE TO PAGE 7 INNER TEMP SEE TO PAGE 8 TEMPERATURE ve TURBO COOLING TURBO COOLING TURBO COOLING BUTTON FAN RUNNING DOOR OPENING SEE TO PAGE 7 TURBO COOLING 1 If you push the T C Turbo Cooling button the compressor will run continuously until D Senser detect 14 F 10 C to bring down the temperature more quickly max comp run time 120 min 2 If you push the T C button again during Turbo Cooling mode the compressor will return to the normal operation 3 During the Turbo Cooling mode works the temperature Up Down button will not affect the compressor s operation UP DOWN BUTTON Temperature control button 1 By pushing the up down button you can set the inside temperature level from 1 to 9 2 If you want lower temperature push the Down button to be lighted higher level numbers INNER TEMPERATURE DISPLAY 1 It displays the inside temperature 2 Display range is 14 F to 69 F 10 C 20 C cloud 3 When the inside temperature is lower than 14 F the panel will display u i ag l and higher than 69 F the panel will display Hi is a FAN RUNNING INDICATOR 1 If the fan motor is running fan running indicator will be turned on 2 Evaporator fan motor is activated when the door both doors for TSR 49SD all three doors for TSR 72SD is closed DOO
4. capacity The two 2 year extended compressor warranty applies only to hermetically sealed parts of the compressor and does not apply to any other parts or components including but not limited to cabinet paint finish temperature control refrigerant metering device driers motor starting equipment fan assembly or and other electrical components etcetera 404A 134a Compressor Warranty The five year compressor warranty detailed above will be void if the following procedure is not carefully adhered to 1 This system contains R404A or R134a refrigerant and polyol ester lubricant The polyol ester lubricant has rapid moisture absorbing qualities 2 Drier replacement is very important and must be changed when a system is opened for servicing A620 copper drier or better is highly recommended 3 Micron level vacuums must be achieved to insure low moisture levels in the system 500 microns or lower must be obtained When compressor is grounded suction drier and 620 drier or better must be replaced 5 Compressor must be obtained through Turbo Air unless otherwise specified in writing through Turbo Air s warranty department aN 404A 134a Compressor Warranty Turbo Air s sole obligation under this warranty is limited to either repair or replacement of parts subject to the additional limitations below This warranty neither assumes nor authorizes any person to assume obligations other than those expressly covered by this
5. including but not limited to cabinet paint finish temperature control refrigerant metering device driers motor starting equipment fan assembly any other electrical component etcetera 134A 404A COMPRESSOR WARRANTY The five year compressor warranty detailed above will be voided if the following procedure is not carefully adhered to 1 This system contains R134A refrigerant and polyol ester lubricant The Polyol ester lubricant has rapid moisture absorbing qualities If long exposure to the ambient conditions occur the lubricant must be removed and replaced with new Listed below are the approved lubricants for the Tecumseh compressors 1 ICI Emkarate RL 184 2 Emery 2927 A 3 Mobile Artic 22A Failure to comply with recommended lubricant specification will void the compressor warranty 2 Dryer replacement is very important and must be changed when a system is opened for servicing dryer must be used with XH 9 desiccant 3 Micron level vacuums must be achieved to insure low moisture levels in the system 500 microns or lower must obtained What is NOT covered by this warranty Turbo Air s sole obligation under this warranty is limited to either repair or replacement of parts subject to the additional limitations below This warranty neither assumes nor authorizes any person to assume obligations other than expressly covered by this warranty 1 WARRANTY IS NOT TRANSFERABLE This warranty is not assignable and applies only i
6. that are examined and determined by Turbo Air to have been defective within three 3 year of original installation or thirty nine 39 months after shipment date from manufacturer whichever occurs first shall be repaired or replaced as stated below Turbo Air shall be deemed to have fully complied with its obligation under the foregoing warranties by electing either one of the following procedures at the sole discretion of Turbo Air 1 Furnishing a replacement part freight collect in even exchange for the returned part freight collect 2 Receiving the defective part freight collect repairing it and returning it freight collect ADDITIONAL TWO YEAR COMPRESSOR WARRANTY In addition to the three 3 year warranty stated above Turbo Air warrants its hermetically and semi hermetically sealed compressor to be free from defects in both material and workmanship under normal use and service for a period of two 2 additional years from the date of original installation but not to exceed five 5 years and three 3 months after shipment from manufacturer Compressors determined by Turbo Air have been defective within this extended time period will at Turbo Airs option be either repaired or replaced with a compressor or compressor parts of similar design and capacity The two 2 year extended compressor warranty applies only to hermetically and semi hermetically sealed parts of the compressor and does not apply to any other parts or components
7. 3 When inside temperature is lower than 50 F the panel will display L amp ibs l LI and higher than 50 F the panel will show Hi il II FAN RUNNING INDICATOR 1 If the fan motor is running fan running indicator will be turned on 2 Evaporator fan motor is activated when the door both doors for TSF 49SD all three doors for TSF 72SD is closed DOOR OPENING INDICATOR 1 If any door is opened door opening indicator will be turned on 2 In case that any door was opened around 30 seconds warning beep sound will ring three 3 times 3 In case of passing around 1 minute warning beep sound will ring again five 5 times 4 In case of passing around 5 minutes the beep sound will ring continuously 5 The beep sound will stop immediately if door is closed properly 12 TROUBLESHOOTING SYMPTOMS CAUSES SOLUTIONS Freezer is melting e The controller is set too high to Turn the temperature dial to a food contain food fresh warmer position The unit does not e There is a power connection e Check the power cord and plug in refrigerate at all failure problem it correctly e The unit is in sunlight or near a Check the installation place heating device e Check the condition of stored e The unit contains hot food or too food The unit does not much food Check the position of the temp refrigerate well e The unit door is opened too control dial frequently or left open long The
8. LEAN THE GASKET The door gasket should be cleaned frequently to maintain proper sealing 4 CHECK AFTER CLEANING Check the unit again for safety Check that the unit is operating properly CAUTION 1 POWER CORD Be sure that the power cord is connected to the proper voltage A protected circuit of the correct voltage and amperage must be run for connection of the line cord Turn off the power switch before disconnecting the power cord whenever performing maintenance fucntions or cleaning the refrigerated cabinet Dual voltage freezer TSF 72SD requires receptacle as shown the right sides Compressor warranties are void if compressor burns out due to low voltage BASIC OPERATION TSR 23SD TSR 35SD TSR 49SD TSR 72SD 1 Plug in and turn on the power switch located on the bottom of the top grille right side The Display panel will be lighted and make a beep sound The compressor will begin to run 2 The default temprature setting is No 5 3 The compressor is automatically cycled by the electronic controller PCB D Senser 4 The Defrost cycle is automatically controlled by the R sensor and the PCB 5 Set level toward 1 for higher temperature and toward 9 for lower temperatures 6 The interior light is activated by the rocker switch at the bottom of the grille when the door is opened 7 Evaporator fan motor s will run after all doors are completely closed DISPLAY PANEL OF
9. R OPENING INDICATOR 1 If any door is opened door opening indicator will be turned on 2 In case that any door was opened around 30 seconds warning beep sound will ring three 3 times 3 In case of passing around 1 minute warning beep sound will ring again five 5 times 4 In case of passing around 5 minutes the beep sound will ring continuously 5 The beep sound will stop immediately if door is closed properly BASIC OPERATION TSF 23SD TSF 35SD TSF 49SD TSF 72SD 1 Plug in and turn on the power switch located on the bottom of the top grille right side The Display panel will be lighted and make a beep sound The compressor will begin to run The default temprature setting is No 5 The compressor is automatically cycled by the electronic controller PCB F Senser The Defrost cycle is automatically controlled by the D sensor and the PCB Set level toward 1 for higher temperature and toward 9 for lower temperatures The interior light is activated by the rocker switch at the bottom of the grille when the door is opened Evaporator fan motor s will run after all doors are completely closed Good Air Flow in Freezer unit is critical Be careful to load product so that it neither presses against the back wall reaches within for inches from the evaporator compartment DISPLAY PANEL OF FREEZER TEMP SETTING TEMP CONTROL BUTTON SEE TO PAGE 11 INNER TEMP
10. R WARRANTY AND THE ADDITIONAL TWO 2 YEAR COMPRESSOR WARRANTY AS DESCRIBED ABOVE THESE WARRANTIES ARE EXCLUSIVE AND IN LIEU OF ALL OTHER WARRANTIES INCLUDING IMPLIED WARRANTY AND MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO WARRANTIES WHICH EXTEND BEYOND THE DESCRIPTION ON THE FACE HEREOF Outside U S and Canada This warranty does not apply to and Turbo Air is not responsible for any warranty claims made on products sold or used outside the continent of the United States and Canada New Extended Warranty policy applies to all units sold by Turbo Air starting Dec 1 2012
11. d object which may stop the air flow Be sure that air space is allowed to flow the rear of the unit Turbo Air recommends that the rear of the unit would be no less than 5 inches from the wall PLACE ON STRONG GROUND Be sure that the location be chosen has a storng enough floor to support the total weight of the cabinet and any other contents DO NOT PLAVE NEAR HEAT Be sure to avoid hot corners and locations near stoves High ambient temperature will make much lower cooling efficiency INDOOR USAGE ONLY Be sure to install this unit indoor SO it should prohibit getting wet from the rain STABILIZING Make sure the unit is installed in a stable condition with the front wheels locked while in use LELVELING Be sure that unit levels from the front to the back and side to side UNIT SHOULD BE ON DEDICATED OUTLET PLACE BLACK PLASTIC CONDENSATE PAN THROUGH BACK OR FRONT MAKE SURE PADS ARE INSTALLED UPWARDS A DRAIN HOSE IS IN PAN CLEANING 1 CLEANING THE INTERIOR AND EXPERIOR The interior and exterior of the unit can be cleaned using warm water with soap Don not use an abrasive cleaner becasue it will scratch the stainless steel surface 2 CLEANING THE CONDENSER FINS To maintain proper refrigeration performace the Condenser coil must be free of dust dirt and grease This will require periodic cleaning Condenser fins should be cleaned every three months 90 days or as needed 3 C
12. n favor of the original purchaser user to whom delivered ANY SUCH ASSIGNMENT OR TRANSFER SHALL VOID THE WARRANTIES HEREIN MADE AND SHALL VOID ALL WARRANTIES EXPRESS OR IMPLIED INCLUDING ANY WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE 2 NO CONSEQUENTIAL DAMAGES TURBO AIR IS NOT RESPONSIBLE FOR ECONOMIC LOSS PROFIT LOSS OR SPECIAL INDIRECT OR CONSEQUENTIAL DAMAGES INCLUDING WITHOUT LIMITATION LOSSES OR DAMAGES ARISING FROM FOOD OR PRODUCT SPOILAGE CLAIMS WHETHER OR NOT ON ACCOUNT OF REFRIGERATION FAILURE 3 ALTERATION NEGLECT ABUSE MISUSE ACCIDENT DAMAGE DURING TRANSIT OR INSTALLATION FIRE FLOOD ACTS OF GOD TURBO AIR is not responsible for the repair or replacement of any parts that Turbo Air determines have been subjected after the date of manufacture to alteration neglect abuse misuse accident damage during transit or installation fire flood or an Act of God 4 NO IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO OTHER WARRANTIES EXPRESS IMPLIED OR STATUTORY EXCEPT THE THREE 3 YEAR WARRANTY AND THE ADDITIONAL TWO 2 YEAR COMPRESSOR WARRANTY AS DESCRIBED ABOVE THESE WARRANTIES ARE EXCLUSIVE AND IN LIEU OF ALL OTHER WARRANTIES INCLUDING IMPLIED WARRANTY AND MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO WARRANTIES WHICH EXTEND BEYOND THE DESCRIPTION ON THE FACE HEREOF 5 TRANSPORTATION COSTS Turbo Air will accept parts covered under this warrant
13. nd proper use and maintenance service as specified by Turbo Air and upon proper installation and start up in accordance with the instruction packet supplied with each Turbo Air unit Turbo Air s obligation under this warranty is limited to a period of three 3 year from the date of original installation or 39 months after shipment date from Turbo Air whichever occurs first Any part covered under this warranty that are by Turbo Air to have been defective within three 3 year of original installation or thirty nine 39 months after shipment date from manufacturer whichever occurs first is limited to the repair or replacement including labor charges of defective parts or assemblies The labor warranty shall include standard straight time labor charges only and reasonable travel time as determined by Turbo Air Additional Two Year Compressor Warranty In addition to the three 3 year warranty stated adove Turbo Air warrants its hermetically sealed compressor to be free from defects in both material and workmanship under normal and proper use and maintenance service for a period of two 2 additional years from the date of original installation but not to exceed five 5 years and three 3 months after shipment from the manufacturer Compressor determined by Turbo Air to have been defective within this extended period will at Turbo Air s discretion be either repaired or replaced with a compressor or compressor parts of similar design and
14. temp dial is not on the correct position e The condenser is clogged e The floor is too weak or the e Check the installation and leveling feet is set incorrectly adjust the tray position e The back side of the unit is too close to the wall e The tray is not in the correct position There is a loud noise There are dew drops High moisture air can produce Wipe with a dry cloth on the unit exterior dewdrops during rainy season There are dew drops The door is opened too Keep the door closed to on the unit interior frequently or left open long remove dewdrops e Damp food is stored The door d t The door is bent e Level the unit again iain ahaa e The unit is a levelling failure Reposition the gasket close tightly The door gasket has come out The following points are not malfunctions e A water flowing sound can be heard when the compressor stops This is the sound of REFRIGERANT flowing e The compressor does not run against defrosting function 13 Zurbo Bir MANUFACTURING COMPANY THREE YEAR WARRANTY Turbo Air warrants to the original purchaser of every new Turbo Air refrigerated unit the cabinet and all parts thereof to be free from defects in material or workmanship under normal use and service for a period of three 8 year from the date of original installation or 39 months after shipment date from Turbo Air whichever occurs first Any parts covered by this warranty
15. warranty NO CONSEQUENTIAL DAMAGES TURBO AIR IS NOT RESPONSIBLE FOR ECONOMIC LOSS PROFIT LOSS OR SPECIAL INDIRECT OR CONSEQUENTIAL DAMAGES INCLUDING WITHOUT LIMITATION LOSSES OR DAMAGES ARISING FROM FOOD OR PRODUCT SPOILAGE REGARDLESS OF WHETHER OR NOT THEY RESULT FROM REFRIGERATION FAILURE WARRANTY IS NOT TRANSFERABLE This warranty is not assignable and applies only in favor of the original purchaser user to whom delivered ANY SUCH ASSIGNMENT OR TRANSFER SHALL VOID THE WARRANNTIES HEREIN AND SHALL VOID ALL WARRANTIES EXPRESS OR IMPLIED INCLUDING ANY WARRANTY OF MERCHANTABILITY OR LABOR COVERAGE FOR COMPONENT FAILURE OR OTHER THE WARRANTY PACKET PROVIDED WITH THE UNIT ALTERATION NEGLECT ABUSE MISUSE ACCIDENT DAMAGE DURING TRANSIT OR INSTALLATION FIRE FOOD ACTS OF GOD Turbo Air is not responsible for the repair or replacement of any parts that Turbo Air determines have been subjected after the date of manufacture to alteration neglect abuse misuse accident damage during transit or installation fire flood or act of GOD IMPROPER ELECTRICAL CONNECTIONS TURBO AIR IS NOT RESPONSIBLE FOR THE REPAIR OR REPLACEMENT OF FAILED OR DAMAGED COMPONENTS RESULTING FROM ELECTRICAL POWER FAILURE THE USE OF EXTENSION CORDS LOW VOLTAGE OR VOLTAGE DROPS TO THE UNIT NO IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO OTHER WARRANTIES EXPRESSED IMPLIED OR STATUTORY EXCEPT THE THREE 3 YEAR PARTS amp LABO
16. y freight collect provided that shipment has received prior approval Turbo Air is not responsible for any other transporation costs but will ship freight collect pars either repaired or replaced under these warranties 6 WARRANTY CLAIMS All claims should include model number of the cooler the serial number of the cabinet proof of purchase date of installation and all pertinent information supporting the existence of the alleged defect Any action or breach of these warranty provisions must be commenced within three 3 year after that cause of action has accrued hurbe TOR MANOIR TURER 4184 E Conant St Long Beach CA 90808 TEL 310 900 1000 FAX 310 900 1077 TOLL FREE 1 800 627 0032 U S A amp Canada Website www turboairinc com Warranty Claims All claims for parts or labor must be made directly thorough Turbo Air All claims should include model number of the unit the serial number of the cabinet proof of purchase date of installation and all pertinent information supporting the alleged defect In case of compressor replacement under warranty either compressor or compressor tag must be returned to Turbo Air along with above listed information Failure to comply with warranty policies will result in voiding claims Three Year Parts amp Labor Warranty Turbo Air warrants all new refrigerated components the cabinet and all parts to be free from defects in materials or workmanship under normal a
Download Pdf Manuals
Related Search