Smokenator 1000 Brochure 11511
Contents
1. F with the thermometer placed into the middle of the thigh meat You can also do split chicken halves on the food support grill There are many spice mixtures you can try with chicken Our favorite is always slipped under the skin of the chicken The spice soaks into the meat along with the smoky flavor Brining is not needed for chicken or turkeys if water is kept in the pan 17 Pulled Pork Follow your preparation method and add your rub to the meat the night before Set the Weber to sustain 230 240 F dome temperature It s smart to let the meat warm up to room tempera ture but that is hard to do given that these meats can take over 7 to 9 hours to do Place the pork butt on the food support grill When the pork in deepest part registers between 165 to 170 F about 4 to 5 hours we foil wrap ours and let the Weber run up to the 350 F area till the meat thermometer registers 200 F 1 to 1 5 hours Then we unwrap the meat and set it back into a dry kettle environ ment about 30 minutes to let a crust form You can also just smoke low and slow till the meat reaches 190 200 F It just takes a Jot longer but it can be worth it Brisket It is also a tough cut of meat that is cooked the same way up to 165 F then foil wrapped and brought up to 190 to 200 F Cooking times are about the same as pulled pork but a little less since a brisket is not as thick No foil Expect to cook 7 to 10 hours and for meat to be be a2. Smokenator 1000 Efficient means of converting your Kettle to a full featured Smoker Patent No US 7 832 330 Bl WWW SMOKENATOR COM Congratulations on your purchase of the Smokenator 1000 It is the first product of its kind to efficiently convert a ket tle barbecue into a smoker giving you a smoker that exceeds the traditional vertical water smoker in both performance and cost Features Efficient design Shields food from direct heat radiation Ability to add moisture to cooking environment When properly used can cook food up to 30 faster with same results as traditional vertical smoker Avoids messy clean up associated with vertical smokers With the Smokenator s thoughtful design even a 25 pound turkey can be smoked Using the Smokenator you will be able to control temperature and moisture to achieve a final product that is very well smoked yet moist The Smokenator is well suited for smoking fish especially salmon ribs roasts tri tips chicken and turkey The following instructions describe how to set up the Weber and Smokenator to achieve low and slow temperature consistently Warning When in use all of the Smokenator s surfaces are ex tremely hot Always wear protective gloves or mitts when han dling the Smokenator when it is in use Be especially careful if you are removing the steam pan if it contains water or if you have been partying or drinking Burns are very painf
3. bit drier Our favorite book for sauces marinades dry and wet rubs and mops is Championship Barbecue Sauces By Paul Kirk This book is well written by an accomplished and experienced chef Andy s Rub 1 cup cane sugar Y2 cup seasoned salt 3 tablespoons garlic salt 3 tablespoons celery salt 2 tablespoons onion salt 1 3 cup paprika 2 tablespoons black pepper 1 tablespoon lemon pepper 1 teaspoon ground celery seed 1 teaspoon dry mustard powder 1 teaspoon ground thyme Y teaspoon each of allspice cayenne dried chives 18 This is another rub but a different skew in the last section of the recipe Mitch s Fantastic Barbecue Rub 3 4 cup cane sugar Ys cup light brown sugar 6 tablespoons celery salt Y cup seasoned salt Ya cup onion salt 2 tablespoons garlic salt 1 3 cup paprika 2 tablespoons chili powder 2 tablespoons black pepper 1 tablespoon cayenne 1 teaspoon ground allspice 4 teaspoon ground cloves 2 teaspoon ground bay leaf We like this rub since it has sweet salt and some complex spices If you have questions please email us at info smokenator com or call us at 408 340 3976 Visit the Smokenator Forum at www smokenatorforum proboards com Barbecue Kettle Accessories 6189 Mancuso Street San Jose CA 95120 Good Luck and Thank You for Purchasing the Smokenator 1000 Revised January 15 2011 19
4. for the kettle and my temperature is too low or too high We have had several customers comment that their food took too long to cook This most likely happened because the cus tomer jumped right into low and slow cooking without doing two things 1 They did not make sure they had a dome thermometer 2 They did not do a test run of the settings and tempera tures with just coals and an empty kettle and instead jumped right into cooking their meat 11 How to Calibrate Your Weber Low and Slow The Weber kettle cooker with a Smokenator has six fac tors that can vary and cause temperature to misbehave Amount of fuel Amount of air Pan filled with water or no water Wood chunks Ambient temperature Wind conditions For example if the ambient temperature is 75 F and you have your Weber in a relatively enclosed space unaffected by any breeze two of the variables become constant The Test Run The goal will be to limit all the variables except for one the air vents will be opened and closed to determine the effect Adjust the lower kettle vents to half open and the upper kettle lid vents to 3 16 open Adjust the thermometer so that the tip extends about 1 2 under the kettle lid surface Using either processed lump charcoal as described previously or briquettes put about 20 to 25 percent 12 briquettes into a chimney charcoal ig niter and bring them to a hot red color During the 20 minutes needed to b
5. hour of smoking turn the turkey breast side up The temperature of the kettle is normally between 225 and 250 F when smoking and using water to keep moisture levels up A turkey can take upwards of 6 to 8 hours to smoke After 4 hours the turkey is well smoked and it can be moved to an oven to complete cooking if you desire If you do this wrap your smoked bird tightly in foil so it doesn t dry out 14 Salmon Salmon is a wonderful fish that smokes really well Lay two sheets of foil on the counter and set the fillet s skin surface down on the foil Salt the exposed side well since having a salty base on the fish brings out the smoke flavor After coating the fish with salt lightly spray with a cooking oil spray Set it on the food support grill Salmon cooks rather quickly in the Weber We generally let the fish remain in the kettle for about 2 hours making sure that the water pan is never empty We don t overload the kettle with a huge number of coals Try 20 briquettes or so and add extra when you see the temperature dropping We also keep the Weber heavily stocked with wood chunks to make sure smoke is always present The result is a pro nounced slightly salty smoky salmon This is not a cold smoke process which takes a lot longer and is done at much lower tem peratures 15 This picture shows three slabs of ribs cooking on the food support grill and on a Hovergrill This is roughly 15 pounds of food Most
6. 12 0 439 1 755 1 317 _ 72 95 0492 1 97 __ 1 476 _ 81 87 0547 2 188 __ 1 641 90 94 1 803 100 00 Charcoal Briquettes or Lump Charcoal All of the original testing was done with Kingsford Char coal Kingsford is a very consistent product from bag to bag and is available in most places It s a decent product that is formulated to start fast and provide enough heat for one decent grilling session It works well for low and slow cooking The biggest complaint about it is the issue of purity Kingsford is an admixture of carbon made from wood and processed mineral char to form nearly pure charcoal sawdust sodium nitrate for easy ignition and some starch to hold it all together Lump charcoal is used by many experienced BBQ Chefs for the simple reason that it is pure wood charcoal derived from hardwood We have found the best way to burn lump in a con trolled manner is to break it up The goal is to make as many pieces close to the size of a briquette or 2 x 2 x 1 5 These pieces are laid down on the coal support grill with smaller chips and wood chunks layered on top of this first layer In our personal experiments breaking up the lump in this manner makes for plenty of surface area to ignite creating the environment for an even and consistent burn rate When using lump charcoal with the Minion method expect burns to last 5 to 6 hours Papasan il Habit aes ale Long Cook Times Set Up and Temperature Ma
7. ature will probably drop to 180 or 190 F when food is added to the grill In this situation you can take no action and let the meat absorb the heat which will take about 60 to 90 minutes Or you can open the vent to 2 opening a doubling of vent surface area which will raise temperature some Do re member to watch the temperature after each adjustment until you know your kettle and how it responds All temperature manage ment is done using the dome temperature Food support grill temperature is 10 to 20 F less than dome temperature rela tively speaking 7 Critical Point When the upper vents are set at 5 16 and dome temperature is 230 240 F the water will be simmer ing not a vigorous boil Until you understand and are familiar with your tools and how fast water evaporates quickly check the water level every 30 minutes This is entirely precautionary at the 5 16 3 8 setting water will last about 70 to 90 minutes Open ing up the upper vents increases heat production and also evapo rates the water faster It is our observation that after about 1 5 to 2 hours smoke production will decrease with the Minion Method We find that stirring the coals will usually help smoke production When this doesn t work we add more wood to keep a light blue smoke vent ing from the dome We strongly advise that every hour you tend to the coals open the kettle lid and use the skewer to shift the coals This ulti mately mean
8. during a cook temperature drops by 10 F open up the upper vent about 1 16 to 1 8 If there is no response in 10 min utes stir the coals and check the condition of the unburned char coal If cavity is low on coals about 5 hours replenish figuring 8 10 briquettes are burned in an hour When adding unlit coals you can see a drop in dome tem perature as the water evaporates and the more volatile components of charcoal ignite This effect lasts for about 15 minutes you can compensate a bit if you want but we usually don t worry about it 4 The following table shows the relationship between the maximum width of the ellipse seen between the two arrows in the picture on page 4 and is the actual opening and its relation ship to the total venting area of the 4 holes You see that the rela tionship is not a one to one basis One open hole on the Weber is about 0 60 square inches and 0 58 is very near one open hole or a setting of 5 16 We have found that choking the upper vent to 3 16 will allow a burn to proceed A common pencil has a di ameter of 30 5 16 is 0 31 square inch Once you discover how damping works in your kettle you can whittle a stick or find various pencils of varying widths to set your vents 5 16 is your initial starting point os 0 422 osie 175 0 146 0 583 __0 438_24 21 0 235 0 941 0 708 39 12 0 284 1 134 0 852 47 15 0 334 1 336 __ 1 002 _ 65 53 0386 1 543 _ 1 158 64
9. gage to initially set the lower vents An issue that raises concern is temperature control The reason why the Weber with the Smokenator is so stable is due to water absorbing heat energy allowing the vents to be open more this allows more control Without water the kettle is harder to control Since it has such a low air intake ash build up interferes with efficient burning If you are going to do this let the kettle come to temperature at 1 4 opening Then using the table use the halving and doubling of openings to control temperature We usually don t smoke without water since the results are superior in terms of tenderness and moisture content of the meat or poultry when using water We will use dry setting for finish of brisket and pulled pork Dry Environment Settings There is no guarantee that the temperatures cited below will be exact since every kettle is different Start with the lowest set ting first so that you understand how your particular kettle func tions at the base line and work un to wider openings 200 z HOA y 9 3 Ounces of wood chips 1 3 8 sto 1 5 8 high _ pelouze The picture above shows the cross section size of wood chunks All chunks are 1 3 8 to 1 5 8 high We never soak them We try to avoid using wood chips since they can introduce huge amount of smoke and turn food harsh Use these sparingly until you get a handle on smoke production What if I use the initial settings
10. is results in a hot kettle that cools slowly It take over 40 minutes to cool down to 230 F Just be careful to close the upper lid the right way all the time For users who are completely new to temperature manage ment we recommend that you do a test run Start a session with out cooking any food and follow the Minion Method to see how your Weber functions You will be glad you did and your anxiety level will be much less when you actually do those ribs or roast The directions outlining the Minion Method start with a fire that is under performing and letting the upper vent supply the right amount of oxygen to bring the kettle up to the right temperature 9 What to Expect The Smokenator creates a huge amount of humidity in the kettle If you are used to other methods of low and slow cook ing the results in the Smokenator when followed at 230 F dome temperature will be very moist and tender It is possible to control the degree of juicy ness By removing water in the last hour you can place a dryer finish on the outside of the meat keep ing a juicy interior If you want deep interior dryness then keep water in the pan for 1 4 of the cooking time to enhance smoke ring flavor Using the Smokenator Without Water In this situation you will have to close the upper vents down to 1 8 to 3 16 Secondly the lower vents will have to be closed down even more in order to control excess air entering Use an 8d nail as a
11. nagement A loaded Smokenator box will fuel a cook of about 6 hours if the dome temperature is kept near 230 F This six hour time is valid for briquettes and varies for lump charcoal The idea was introduced by Ray Minion on The BBQ Forum The concept is simple Pack the Smokenator to the maximum with up to 60 charcoal briquettes 50 work just fine or your processed lump charcoal and about 5 7 oz of wood Remove about 16 briquettes 20 if ambient is under 50 degrees and light them in a chimney starter never use petroleum based charcoal starter fluid When they are about three quarters lit after 15 20 min using Kingsford a bit longer for Royal Oak set them back into Smokenator Use skewer provide to arrange coals Set the water pan in place and fill with water Set food support grill in place if not doing a turkey Put kettle lid in place and set the upper vents to 5 16 Let the kettle come up to temperature Place the food on the grill once dome temperature is up to 220 230 F Food support temperature is about 210 F Place lid on the kettle with the upper vent opposite the Smokenator Make sure your upper vent is set to 5 16 This is a critical setting and the start point amp amp When you put cold food having a temperature of 50 F on the Hovergrill in the kettle fully expect the temperature not to stay at 230 F dome at the beginning of the cook Dome temper
12. of your cooking is done on the food support grill where the temperature is about 210 220 F when the dome tem perature is 230 240 F In this example ribs have to be rotated about midway through the typical 4 hour cook from the Hovergrill to the food support grill Customers have reported using two rib rack smok ing 8 racks of spare ribs 4 on lower 4 on upper grill It took about 7 hours Www amazingribs com is a great site for pointers Craig Goldwyn is one of the best in providing clear and concise direc tions in preparing ribs right Finishing off The high humidity output keeps ribs moist An hour before the ribs are done we recommend that you remove the water and operate in dry mode low and slow This will put a dryer finish on the ribs 16 Chicken The Smokenator does chicken right The results will pretty much astound you with the moistness of the meat If you have ever cooked chicken and it comes out dry you know the feel ing You take a bite and all the moisture is sucked out of your tongue Chewing dry chicken is like chewing a dry sponge A pair of chickens either halved or whole take about four and a half hours at 230 240 F The pan is always filled with wa ter through the entire process Note that these birds are in a roasting pan raised up 3 above the coal support grill Always check your chicken with a meat thermometer that has been cali brated so that you know it is accurate Chicken is done at 170
13. ring the igniter coals to a good burn pack the Smokenator with the remaining coals 40 briquettes You are providing an unlimited source of fuel When the ignition coals are red hot and well lit place them into the Smokenator Push the coals into the sides to allow the water pan to fit into the Smokenator Then place the water pan in the Smokenator and fill with water Place the upper lid over the kettle bottom with the upper vent opposite the Smokenator It will take about 10 15 minutes for the water and kettle to heat up Let the unit come to a stable temperature and let it stay at that temperature for 10 20 minutes so you know for sure that it is at the steady state temperature Make a note of the temperature Open the lid fill the pan with water stir the coals to knock off ash and put the kettle lid back on Adjust the upper vents to 5 16 and the temperature will rise Wait for 20 to 30 minutes and watch where the temperature settles to 12 Repeat the procedure of knocking the ash off the coals fill ing the pan again with water and replacing the lid now open the upper vents to 8 16 Again wait till it is clear that temperature has stabilized You may want to play with your Weber and close the vents to the 5 16 setting and see what happens in your kettle A regular Weber with minimal leaks set with upper vents at 5 16 and lower vents better than 3 8 should reach steady state temperature with
14. s a more even and controllable temperature The first hour the Smokenator cavity is still very full but you knock the ash off the charcoal and keep its surface area exposed to air If you have a one touch system at about 4 hours sweep the ash out of the kettle This can be done with the lid closed Many people worry about lifting the kettle lid and losing temperature We don t worry about it too much At the most the lid is off for only about 2 minutes The food doesn t lose tempera ture since it is mostly water Put a thermometer into a quart of your hottest tap water and watch how fast the temperature drops in 2 minutes it s not very much Kettle dome temperature recovers in 5 to 10 minutes Shorter Cook Times and More Observations in Temperature Management We would recommend using the Minion method exclu sively If you cook only for a couple hours closing off the upper and lower vents will save your unburned charcoal and wood chunks for the next time You can place fewer briquettes in the cavity for shorter cooks at the start up just make sure there are unlit coals on the floor of the charcoal support grill and proceed as the section on the Minion Method outlines Figure 10 briquettes at start up plus 10 per hour as a rule of thumb The Smokenator set up consumes about 8 to 10 bri quettes every hour to keep temperature at 230 240 F We would recommend that if you have a very long cook such as a turkey or pork b
15. simmering water at about 230 240 F dome tem perature If your kettle is at 260 F at this setting then you proba bly have a leak in the lid base seal If you suspect you have a leaky lid to kettle bottom purchase about 4 1 5 Binder clips these work really well as clamps We know this sounds tedious to do but knowing how your Weber works will pay off in confidence give you better timing and will allow you to focus on something other than temperature management like consuming your favorite beverage and having fun It will leave you rested to enjoy the fruits of your culinary intention Link to the Minion Method http www virtualweberbullet com fireup2 html minion Placement of a Taylor Bi Metal Candy Thermometer Model 5911N cost at Ace Hardware is typically less than 10 00 Turkey The Smokenator was originally designed to allow a huge turkey to be smoked The set up for doing a turkey is very simple Place a medium coating of salt dry rub or spices on the skin of the turkey If you use salt lightly spray some cooking oil spray on the skin to ensure that the salt adheres to the skin This provides the smoke a means to transfer flavor into the meat Place the turkey breast side down in a small roasting pan that will fit in the kettle Raise the pan about 3 inches off of the coal supporting grill Try using two upside down bread pans wrapped in foil Rotate the turkey 180 degrees every hour At the end of the second
16. tly use the lower vent fully open and have no problem regulating temperature The lower vent gap can be varied to compensate for a leaky kettle You can calibrate the vanes on the Weber Gold s ash catcher and can regulate tempera ture via the lower vent On the less expensive Weber Silver model it s difficult to set the vents with any precision Regardless of model we use the upper vent to control temperature in the ket tle It is the most reliable when running dry the lower is set very narrow Set lower full open for most kettles a Minimum is about 3 8 5 16 IS EQUVALENT TO AN OPEN AREA OF 0 58 SQ INCHES This photo shows the setting of the upper vent system Charcoal is very sensitive to fluctuations in oxygen A gap of 5 16 in the upper vent as shown will maintain a temperature of about 230 F dome temperature 210 F food support grill tem perature depending on ambient temperature 70 90 F humidi ty and smaller cooking loads You will vary temperature by opening and closing this vent To double the air intake from the 5 16 setting open the vent to 8 16 To increase the air intake 50 more open the vent from 8 16 to 11 16 The outer bound ary for our management of low and slow is 11 16 Temperature control can be maintained by using these three settings and the 3 16 setting You will need a thermometer set in the dome vent see pic ture on page 13 for thermometer set up If
17. ul Items included Smokenator 1000 Baffle Stainless Steel Pan 12 Skewer for Pushing Coals Installing the Smokenator Starting with a clean kettle lid make sure the interior of the kettle top is brushed clean of accumulated smoke flakes Keep the lower kettle free of accumulated smoke residue ash and soot This keeps each smoking session free of harshness Arrange the coal support grill 1 the lower grill support rods so that the base of the baffle fits in between the main rods 1 of the coal support grill The top outer edge of the Smokenator 2 is supported by two of the upper cooking grill s support tabs 3 Arrange the baffle so that the bent tabs of the baffle 4 are positioned directly over the kettle tabs 3 that are used to support the cooking grill This allows the baffle to be lightly secured to the kettle Key 1 Lower Grill 2 Outer Edge 3 Support Tabs 4 Kettle Tab 5 Water Pan Setting Up the Weber Vents to Cook Low and Slow The approach to smoking low and slow requires setting up the draft restriction on the Weber kettle As you know the We ber has two controllable vents a lower and an upper vent Shown below is a photograph of the lower vent system Take a common pencil place it in the slot where the arrows are in the photograph and slide the vane or spoke against the pencil the re sult is about a 3 8 gap in each lower vent which is the mini mum setting We curren
18. utt that at 5 hours you refill the cavity with briquettes and add wood chunks according to what you are cooking Beef doesn t need heavy smoke If you use lump you might have to replenish sooner If there are less than 8 briquettes by weight in the cavity the temperature will not be sustained and will drop Vent setting management If you load the kettle with cold meat on the food support grill and the Hovergrill the dome temperature as mentioned will drop to 180 190 F If for time reasons you decide to compen sate for this drop in temperature and open the vents to full open several things will happen First it increases the amount of steam produced in the kettle and this steam condenses on the colder food warming it Secondly this causes more coals to ignite as temperature moves near 210 220 F We advise closing the upper vents to 5 16 to choke the fire If you don t you risk creating a mass of charcoal generating too much heat causing the internal temperature to over shoot This leaves you with a hot kettle that is slow to cool and the water pan furiously boiling As long as water is in the pan humidity is maintained water will eventually evapo rate and the temperature will spike to over 330 340 F On occasion we have set the upper lid askew This floods the kettle with air and the rise in temperature will cause water to evaporate very quickly 15 minutes or so and then the tempera ture spikes to over 340 F Th
Download Pdf Manuals
Related Search