Salad/Sandwich & Big Top Salad/Sandwich Refrigerators
Contents
1. Figure 1 2 Removal of Rear Grill Condenser Unit WARNING Failure to keep condenser clean may cause premature failure of motor compressor which will NOT be covered by warranty Lubrication Unless otherwise specified all Victory refrigerators are equipped with oilless type motors The motor compressor is a sealed unit and is constantly lubricated when in operation The condenser and the evaporator motors are equipped with lifetime oiled bearings which never need to be oiled BEFORE CALLING SERVICE GUIDE FOR COMMON PROBLEMS Caution Disconnect Power Supply Prior to Attempting Any Service Cabinet not running Improper Voltage supplied to cabinet Correct supply voltage Remove extension cords or other equipment on circuit etc Cabinet in defrost cycle Condensing Unit on Excessive amount of warm product Refrigerator or Freezer Allow adequate time for product to cool down runs for prolonged No product in cabinet Load cabinet with product period or continuously Make sure door is closed when not in use Avoid prolonged door Prolonged door opening or door ajar openings Door gasket not sealing properly Check gasket condition Adjust door or replace gasket Dirty Condenser coil Clean the condenser coil Improper air flow around Condensing Insure adequate air space relocate away from heat generating Unit equipment direct sunlight or direct path of air conditioning or heating ducts Evapora2. Refrigeration at its best Installation Operation amp Troubleshooting Instructions Salad Sandwich amp Big Top Salad Sandwich Refrigerators For Models VUR3 BT VUR4 12BT VUR4 18BT VUR5S 18BT VUR5 24BT VUR6 18BT VUR6 24BT VUR6 30BT VUR60 SBS VUR60 SST VUR60 12 VUR 60 16 VUR72 12 amp VUR72 18 A ae Manual Part No 50876902 e Rev 01 Print Date 8 6 02 110 Woodcrest Road Cherry Hill NJ 08003 Phone 856 428 4200 Fax 856 428 7299 Website www victory refrig com E Mail parts victory refrig com e order entry victory refrig com e service victory refrig com PART OF AGA FOODSERVICE GROUP T H A N K Y O U Thank you for purchasing a Victory Refrigeration Salad Sandwich or Big Salad Sandwich Refrigerator This unit has passed our strict Quality Control Inspection and meets the high standards set by Victory Refrigeration You have made a quality investment that with proper maintenance will give you years of service Please read the following installation and maintenance instructions before installing or using your unit If you have any questions please call our Customer Service Department at 856 428 4200 IMPORTANT INFORMATION PLEASE READ e Please read these instructions carefully before installing or using If recommended procedures are not followed warranty claims will be denied e Your Warranty Registration information is located on the next page of this manua
3. hums and trips onlequipment nearby Relocate cabinet or adjacent heat generating equipment overload protector Voltage to cabinet too high ortoolow Check and correct supply voltage Door won t close tight Cabinet is not level Level cabinet by adjusting legs or shimming casters Door not seated properly in hinge Adjust door on hinges by lifting slightly rotating and reseating Condensation on the Facia Heaters are turned OFF M RENE Turn Exterior Condensate Control Switch on Grill to ON position Digital thermometer Cabinet not running or temperature too displaying incorrect Thermometer probe wire disconnected at characters Check Transformer Located in Electrical Box and Battery incorrect power to thermometer unit Located on thermometer behind Grill Display module requires calibration Refer to Users Manual for calibration procedure REPLACEMENT PARTS Undercounter Sandwich Salad Refrigerators PartNo Description VUR60 SBS VUR60 SST Refrigeration Components 50869901 Coil Evaporator Fin to Fin 6 x 3 x 50 50730801 Drier Filter 50870101 Fan Motor Evaporator 50199101 Capillary Tube 10 x 049 R 134A 50306101 Suction Tube 3 8 O D x 60 50870201 Temperature Control Refrigerator 50569502 Thermometer Hanging Stem Electrical Components 50870301 X 50875801 Harness Evaporator Fan Motor X Doors amp Components 10813201 Door Left Hinged X 10813301 Door Right
4. The following mail in form or online registration must be filled out and forwarded to Victory by the installer or customer within 10 days after start up Failure to do this will invalidate the warranties 5 CABINET MODEL NO CABINET SER NO Data plate information WARRANTIES NOT VALID UNLESS REGISTERED AT ood FACTORY WITHIN 10 DAYS AFTER START UP DATE ORIGINAL DATE OF INSTALLATION INSTALLATION NAME STREET CITY ee STATE LL LL L ZIP CODE DISTRIBUTOR S NAME STREET TY STATE 1L ZIP CODE INSTALLATION INSTRUCTIONS Proper installation is the first step to operation We recommend that your Salad Sandwich or Big Salad Sandwich Refrigerator be installed by an authorized Victory Certified Installer Receiving Shipment All units are performance tested and thoroughly inspected prior to shipment Upon leaving the factory all units perfect condition Upon receipt examine the exterior of the shipment packaging for any signs of rough handling If the cabinet is damaged it should be noted on the delivery slip or bill of lading and signed A claim must be filed immediately against the carrier indicating the extent and estimated cost of damage incurred Uncrating Tools Needed 3 4 Box Wrench e Adjustable Wrench Level WARNING Never lay your Salad Sandwich refrigerator down on either its back front or sides This allows comp
5. Hinged X 50866901 Gasket Door X Door Hardware 50866401 50866501 50866601 50866701 50866801 Shelving amp Accessories 09356300 Piaster o 09359901 Post Center Pilaster 50022501 Clip Shelf 50869101 Shelf Epoxy Coated Undercounter Sandwich Salad Refrigerators PartNo Description VUR6 SBS ME Cabinet Miscellaneous 25920301 05320501 05320901 11122701 Assembly Complete Top 50096002 5 Diameter Caster igh Swivel with Brake 50671801 Leg black in color w adjustable leveling toe X C X 11122601 Assembly Complete Top O X O Zo Undercounter Sandwich Salad Refrigerators D Refrigeration Components 50869901 Coil Evaporator Fin to Fin 6 x 3 x 50 50870001 Coil Evaporator Fin to Fin 6 x 3 x 62 50730801 Drier Filter 50870101 Fan Motor Evaporator 50199101 Capillary Tube 10 x 049 R 134A 50306101 Suction Tube 3 8 O D x 60 50870201 Temperature Control Refrigerator 50569502 Thermometer Hanging Stem Electrical Components 50870301 50875801 Harness Evaporator Fan Motor 50875901 Harness Evaporator Fan Motor Doors Components 50866901 Gasket Door Door Hardware 50867001 Gasket Door 50866401 Assembly Power Cartridge 50866501 Bracket Bottom Left Cartridge 50866601 Bracket Bottom Right Cartridge 50866701 Bracket Bottom Left Pivot 50866801 Bracket Bottom Right Pivot
6. Seller shall not be liable for consequential damages of any kind which occur during the course of installation of equipment or which result from the use or misuse by Buyer its employees or others of the equipment supplied hereunder and Buyer s sole and exclusive remedy against Seller for any breach of the foregoing warranty or otherwise shall be for the repair or replacement of the equipment or parts thereof affected by such breach The foregoing warranty shall be valid and binding upon Seller if and only if Buyer loads operates and maintains the equipment supplied hereunder in accordance with the instruction manual provided to Buyer Seller does not guarantee the process of manufacture by Buyer or the quality of product to be produced by the equipment supplied hereunder and Seller shall not be liable for any prospective or lost product or profits of Buyer THE FOREGOING WARRANTY IS EXCLUSIVE AND IN LIEU OF ALL OTHER EXPRESS AND IMPLIED WARRANTIES WHATSOEVER SPECIFICALLY THERE ARE NO IMPLIED WARRANTIES OF MERCHANTABILITY OR OF FITNESS FOR A PARTICULAR PURPOSE The foregoing shall be Seller s sole and exclusive obligation and Buyer s sole and exclusive remedy for any action whether in breach of contract or negligence In no event shall seller be liable for a sum in excess of the purchase price of the item You may register online at www victory refrig com fax this completed page to 856 428 7299 or clip and mail form below to Victory NOTE
7. Remove all food food related items and shelves 2 Discontinue power to refrigeration system by turning temperature control switch or dial knob all the way to the right Remove loose food particles from interior floors walls and ceiling Scrub all interior surfaces with warm detergent solution 100 F 120 F 38 C 39 C and a nylon bristled brush Rinse with clear water and allow to air dry Reinstall shelves Restore power to refrigeration system by turning temperature control switch or dial knob to the right Return food to cabinet when temperature indicator reaches safety zone ooo gt YW Condenser Maintenance To keep your cabinet running efficiently it is recommended that you clean the condenser once every three months However once a month is recommended if the unit is located near cooking equipment which produces grease laden vapors i e fryers grills steam kettles etc Discontinue power to refrigeration system by turning temperature control switch all the way to the left Make sure all doors and food storage lids are closed Pull cabinet forward and remove power cord from receptacle For condensing unit access remove all 1 4 hex head screws off rear grill and pull grill straight out See Fig 1 amp Fig 2 5 Use a vacuum cleaner with proper brush attachments or compressed air to clean the condenser compressor motor and related parts 6 After cleaning reassemble cabinet and properly restore power
8. Shelving amp Accessories 09356301 Pilaster rr Undercounter Sandwich Salad Refrigerators VUR60 12 VUR60 16 VURT2 12 VURT2 16 Cabinet Parts Miscellaneous 05320401 Grill 05320601 Front y O Gril Rear Grill 0 0 0 y X 05320901 05321001 10814201 Assembly Lid with Handle Right Side 10814301 Assembly Lid with Handle Left Side 10814401 Assembly Lid with Handle X 10814501 Assembly Lid with Handle Left amp Right Side 10815601 Assembly Cover Right Side 10815701 Assembly Cover Left Side 10815801 Assembly Cover X 10815901 Assembly Cover Left amp Right Side 11122201 Assembly Complete Top without Cover or Lid X 11122301 Assembly Complete Top without Cover or Lid 11120401 Assembly Complete Top without Cover or Lid 11122901 Assembly Complete Top without Cover or Lid 09356601 Bracket Cutting Board Right Side 09356701 X 50868901 X 50869001 50096002 5 Diameter Caster 6 High Swivel with Brake 50671801 Leg black in color w adjustable leveling toe X X Undercounter Big Top Sandwich Salad Refrigerators PartNo Description Refrigeration Components 50869701 50869701 Coil Evaporator Fin to Fin 6 x 3 x 16 50869801 Coil Evaporator Fin to Fin 6 x 3 x 36 50730801 Drier Filter 50870101 Fan Motor Evaporator 50199104 Capillary Tube 8 x 049 R 134A 50306101 Suctio
9. T 10 Undercounter Big Top Sandwich Salad Refrigerators Description Refrigeration Components 50869901 50870001 50730801 oil Evaporator Fin to Fin 6 x 3 x 50 oil Evaporator Fin to Fin 6 x 3 x 62 rier Filter 50870101 Fan Motor Evaporator 50199101 Capillary Tube 10 x 049 R 134A 50870201 50569502 50306101 Temperature Control Refrigerator Thermometer Hanging Stem Suction Tube 3 8 O D x 60 Electrical Components arness Power arness Evaporator Fan Motor arness Evaporator Fan Motor Doors amp Components oor Left Hinged oor Right Hinged oor Left Hinged oor Right Hinged 50870301 50875801 50875901 10813201 10813301 10813401 10813501 50866901 0867001 Gasket Door Door Hardware 50866401 50866501 50866601 50866701 50866801 ssembly Power Cartridge racket Bottom Left Cartridge racket Bottom Right Cartridge racket Bottom Left Pivot racket Bottom Right Pivot Shelving amp Accessories 09356301 09359901 50022501 50869101 50869201 ost Center Pilaster lip Shelf helf Epoxy Coated helf Epoxy Coated 11 UR5 18BT VUR5 24B VUR6 18BT VUR6 24BT VUR6 30B Undercounter Big Sandwich Salad Refrigerators Description VURS 18BT JVUR5 24BT VUR6 18BT VUR6 24BT VUR6 30B Cabinet Parts Miscellaneous 05320501 Grill 05320601 Grill Front 053209001 Grill Rear 05321001 Grill Rear 10814601 Ass y Lid w Han
10. ak the gasket in warmwater to make it more pliable Align new gasket frame on the door retainer strip Starting at one corner press each corner of the gasket into the retainer strip Once started the gasket can be easily inserted around the entire perimeter of the door by simply press rolling into place Door Gasket amp Retainer Strip Installation Checklist After the cabinet has been installed leveled and cleaned as described refer to the following checklist prior to start up Check for proper electrical hook up check exposed refrigeration line connections for leaks Make sure refrigeration lines are not dented kinked or rubbing Check condenser fan for freedom to rotate without striking any stationary members Check that cabinet is level Product Load After the refrigerator has been started and reaches the proper storage temperatures food may be loaded For optimum energy efficiency we recommend allowing a 1 1 2 clearance between the interior cabinet wall and product load PERIODIC MAINTENANCE Cabinet Cleaning Victory Refrigeration recommends periodic internal and exterior cleaning as outlined below Daily Exterior Cleaning 1 Clean surface with a sponge and cleaning solution Use a non abrasive cleaner that does not contain chlorine 2 Polish with a soft cloth wiping with the grain of the metal 3 Once a week wipe with a film cutting agent to maintain shine Weekly Interior Cleaning 1
11. cabinets with shelves are supplied with pilasters and shelf clip supports Shelves are easily installed by inserting the shelf support clips into the pilasters so they fit tightly Align the shelf so the smaller fill wires run from front to rear and rest the shelf on the clips Electric Supply Wiring should be done by a qualified electrician in accordance with local electrical codes A separate ground wire must be supplied for all installations A properly wired refrigerator will assure proper operation Electrical supply requirements are on the cabinet serial data plate located on the upper left interior tank wall inside the cabinet lt is recommended that a direct properly protected line of the proper size wire be installed from the main supply to your refrigerator To assure that the correct voltage is being supplied while the refrigerator is in operation take a voltage reading at the compressor motor electrical connections or as close to the compressor motor as possible All refrigerator electrical systems are internally grounded Temperature Control Temperature control should be set to maintain a temperature of 36 F 2 2 C to 38 F 3 3 C for refrigerators Installing Replacement Door Gasket if required Removing Beginning at one corner pry gasket loose from the retaining strip Peel remainder of gasket from the door and discard Replacing Before replacing be sure the gasket and door are at room temperature If necessary so
12. dle Right Side of 6 30BT 10814701 Ass y Lid w Handle Left Side of 6 30BT 10816001 Assembly Cover X X X 10816101 Assembly Cover X X 11122401 Assembly Complete Top without Cover or Lid 11122501 Assembly Complete Top without Cover or Lid 11123001 Assembly Complete Top without Cover or Lid d 11123101 Assembly Complete Top without Cover or Li 11123901 Assembly Complete Top without Cover or Lid 09356601 racket Cutting Board Right Side 09356701 50868901 oard 10 Cutting 50869001 oard 10 Cutting W X X X 50096002 5 Diameter Caster 6 High Swivel with Brake 50671801 Leg black in color wl adjustable leveling toe 12 WIRING DIAGRAM VUR Salad Sandwich amp Big Top Salad Sandwich 115V 60HZ 1Ph 115 VAC 15 AMP SUPPLY CORD EV FAN DESEE i EVAP WHIT LEE 0 FAN 97 HI k WHIT ram P WHEN TIED e n t EVAP Wt FAN 4 p WHEN SEI EVAP WH 3 FAN 5 P WIEN 5 7 COMP TEMP I LUN 1 PUL COND FAN ne A VA NA AAA lt a C BBN ERN A BEN A A 42 MULLIUN HEATER WHEI INHI REI BEN LUN HEA WHEN HSFN 13 Refrigeration at its best Victory Refrigeration Inc 110 Woodcrest Road Cherry Hill NJ 08003 3648 Tel 856 428 4200 Fax 856 428 7299 Web
13. l Please complete the card and submit it to Victory Refrigeration within 10 days of installation Failure to properly register equipment can void the warranty e Victory Refrigeration reserves the right to change specifications and product design without notice Such revisions do not entitle the buyer to corresponding changes improvements additions or replacements for previously purchased equipment e A detailed Owners Manual with a troubleshooting guide parts lists and additional information can be ordered from the factory or may be downloaded free from the website at www victory refrig com LIMITED WARRANTY Continental USA Only The Seller warrants to the original purchaser equipment manufactured by Seller to be free from defects in material and workmanship for which it is responsible The Seller s obligation under this warranty shall be limited to replacing or repairing at Seller s option without charge F O B Sellers factory any part found to be defective and any labor and material expense incurred by Seller in repairing or replacing such part such warranty to be limited to a period of 90 days from date of purchase or 120 days from date of shipment from Seller s factory whichever is earlier provided terms of payment have been fully met All labor shall be performed during regular working hours Overtime premium charges will be at Buyer s expense In addition to the above Seller will replace any part deemed by it to be defective witho
14. n Tube 3 8 O D x 60 50870201 Temperature Control Refrigerator 50569502 Thermometer Hanging Stem d Electrical Components 50870301 50870301 Harness Power 50875601 Harness Evaporator Fan Motor 50875701 Harness Evaporator Fan Motor Doors amp Components 10813201 10813201 Door Left Hinged Door Right Hinged Door Left Hinged Door Right Hinged 50866901 Gasket Door 50867001 Gasket Door Door Hardware Assembly Power Cartridge Bracket Bottom Left Cartridge Bracket Bottom Right Cartridge Bracket Bottom Left Pivot Bracket Bottom Right Pivot Shelving amp Accessories 09356301 09356301 Post Center Pilaster Clip Shelf Shelf Epoxy Coated Shelf Epoxy Coated VUR3 BT ees 7 25 59 l VUR4 12BT VUR4 18BT Undercounter Big Top Sandwich Salad Refrigerators Cabinet Parts Miscellaneous 10814601 Assembly Lid with Handle 10814701 Assembly Lid with Handle 10816001 Assembly Cover 10816101 Assembly Cover 11121101 Assembly Complete Top without Cover or Lid 11121701 Assembly Complete Top without Cover or Lid 11121801 Assembly Complete Top without Cover or Lid 09356601 Bracket Cutting Board Right Side 09356701 Bracket Cutting Board Left Side 50868701 Board 10 Cutting 50868801 Board 10 Cutting 50096002 5 Diameter Caster 6 Hig 50671801 Leg black in color w adjustable leveling toe VUR3 BT VUR4 12BT_ VUR4 18B
15. nd suitably strong enough to support the combined weights of the cabinet plus the maximum product load 3 Ventilation The air cooled self contained refrigeration system requires a sufficient amount of cool clean air Avoid placing the refrigerator cabinet near heat generating equipment such as ovens ranges heaters fryers steam kettles etc and out of direct sunlight Avoid locating the self contained refrigerator cabinet in an unheated room or where the room temperature may be below 55 F 4 Ambient Temperature Salad Sandwich and Big Top Salad Sandwich refrigerators are approved for operation under NSF 7 41 F in maximum ambient of 86 F Installing Casters or Legs Salad Sandwich or Big Top Salad Sandwich refrigerator cabinets are shipped with 1 2 single stud mounted casters or legs Refer to installation instructions that are packed with casters legs Leveling Cabinets must be leveled when installed Failure to level your cabinet may result in doors not sealing closing properly or condensate water not draining properly Refer to leveling instructions that are packed with casters legs Cabinet Cleaning Prior to placing your new Salad Sandwich refrigerator and all shelves pan dividers and food storage pans into operation it is advisable that the interior be washed thoroughly with a mild detergent and water solution Rinse with clear water and a sanitizing solution Allow cabinet to air dry Installing Shelves All
16. ressor oil into the refrigerant lines which can damage the compressor at start up If the unit is laid down it must be set upright for a minimum of 12 hours before starting the compressor Failure to adhere to the above recommendation will void the warranty 1 Remove and discard all cardboard crating packaging material tape and interior components 2 Move cabinet as close to final location as possible before removing skid 3 Remove the shipping skid by tipping the cabinet forward Remove the shipping bolts with 3 4 box wrench while the cabinet is held in one direction Repeat this procedure while the cabinet is held in the opposite direction 4 Use extreme caution when removing the wooden skid especially when the last bolt is removed If not properly blocked the skid will fall to the floor Locating Your New Salad Sandwich or Big Top Salad Sandwich Refrigerator Consider the following when selecting a location cabinet 1 Clearance Salad Sandwich and Big Salad Sandwich refrigerator cabinets do not require a clearance between the back of the cabinet and neighboring wall The front grill is designed to guarantee sufficient air circulation to the condensing unit However it will greatly improve the cabinet s ability to be consistently energy efficient if there is air flowing through the slates of the rear grill that conceals the condensing unit 2 Floor Load The floor on which the cabinet will rest must be free of vibration a
17. tor coil blocked with ice Turn unit off and allow coil to defrost Make sure thermostat is not set too cold and that door gasket is sealing properly Refrigerator or Freezer Thermostat set too high Set thermostat to lower temperature Refer to Users Manual cabinet temperature too Poor air circulation in cabinet Re arrange product to allow proper air circulation high Exterior Thermometer out of calibration Refer to Users Manual for calibration procedure Excessive amount of warm product in Prolonged door openings or door s ajar Make sure door s are closed when not in use Avoid prolonged door openings Dirty condenser coil Clean the condenser coil Insufficient clearance around cabinet or Insure adequate air space relocate away from heat generating excessively high ambient temperature equipment ovens fryers etc and out of direct sunlight Evaporator coil blocked with ice Turn unit off and allow coil to defrost Make sure thermostat is not set too cold Also check gasket condition Cabinet is noisy Part s loose Locate and tighten loose part s Insure tubing is free from contact with other tubing or Tubing Vibrating components Refrigerator is freezing Thermostat is set too low Set thermostat to higher temperature product Cabinet overloaded with product Remove or rearrange product Refrigerator or Freezer Dirty Condenser coil Clean the condenser coil Compressor will not Excessive heat generated from start
18. ut charge for such replacement except labor charges such warranty to be limited to period of one year from date of purchase or 13 months from date of shipment of the equipment from Seller s factory Proof of purchase must be supplied to Seller to validate warranty This warranty is valid only if equipment is properly installed started up and checked out by the dealer or Victory authorized Service agent Removal or alteration of the serial data plate from any equipment shall be deemed to release Seller from all warranty obligations or any other obligations expressed or implied This warranty does not cover Thermostat Defrost Timer calibration and or adjustment freight damage normal maintenance items outlined Owner s Manual adjustment of door mechanisms or replacement of light bulbs fuses or batteries Any repairs or replacement of defective parts shall be performed by Seller s authorized service personnel Seller shall not be responsible for any costs incurred if the work is performed by other than Seller s authorized service personnel Reimbursement claims for part s or labor service costs must be made in writing Model cabinet serial numbers and installation location must be shown on the claim A receipt from the servicing agency must accompany the claim together with full details of the service problems diagnosis and work performed Victory reserves sole discretion whether further documentation on a claim is to be submitted
19. www victory refrig com E mail service victory refrig com or parts victory refrig com
Download Pdf Manuals
Related Search