Nokia Lumia 610 RM-835 RM-836 Service Manual L1L2 - Nokia-X
Contents
1. ANTENNA 10028 LU D COVER 10029 T SCREW TORX SIZE 4 10030 BATTERY COVER 10031 Only available Notreuseable Repair swap as assembly after removal only in level 3 2012 Nokia Nokia Internal Use only All Rights Reserved Service Manual Level 1 and 2 Nokia Lumia 610 RM 835 RM 836 Version 1 0 For disassembling you need the Nokia Standard toolkit version 2 You will also need the camera removal tool SS 287 and an AV plug Gling Protect the A COVER with protective film k 0 4 8 Lare Open the BATTERY COVER by pulling it to the direction shown Remove the BATTERY COVER Unscrew the eight Torx size 4 screws in the order shown Do not use them again Discard them Release also both sides of the D COVER with the SRT 6 Lift up the bottom end of the D COVER and pull it to the direction shown The D COVER can now be separated Remove the CAMERA KEY with tweezers Remove the VOLUME KEY with tweezers Use the SS 93 to open the TOUCH PANEL connector Be very careful not to damage the connector or the small components around the connector i Open the DISPLAY connector with the SS 93 Be careful not to damage the connector or components nearby ing the ENGINE BOARD with the sharp end of the SS 93 Open the two shown clips hold n Ate us SENE ar RA RD A LI tion shown The ENGINE BOARD can Irec it to the d Lift2. Standard Toolkit v2 For more information refer to the Service Bulletin SB 011 on Nokia Online Supplier or manufacturer contacts for tool re order can be found in Recommended service equipment document on Nokia Online 2012 Nokia Nokia Internal Use only All Rights Reserved SS 287 Camera removal tool Nokia Care Academy Service Manual Level 1 and 2 Nokia Lumia 610 Product controls and interfaces RM 835 RM 836 Version 1 0 1 Strap holder 2 Nokia AV 3 5 mm connector 3 Micro USB connector 4 Secondary microphone 5 Earpiece 6 Ambient light amp Proximity sensor 7 Touch screen 8 Start key 9 Back key 10 Search key 11 Microphone 12 Camera 13 Camera flash 14 Volume keys 15 Power Lock key 16 Camera key 17 Loudspeaker 2012 Nokia Nokia Internal Use only All Rights Reserved Service Manual Level 1 and 2 Nokia Lumia 610 Service concept RM 835 RM 836 Version 1 0 Flashing concept Service Software Care Dummy Bat tery with power supply via Nokia charger or product specific battery Transceiver On Device Diagnostics Tool ODDT The ODDT is an app for performing basic device hardware troubleshooting at Nokia Care Points The ODDT is not visible on retail phones and it is intended only for use by trained personnel at Nokia Care Points To install the ODDT EH Calculator 1 Enter 634 on the
3. up the bottom end of the ENGINE BOARD and pull now be separated Protect the other side of the A COVER with protective film E 1 Fj Gi Li 3 K Protect the DISPLAY with protective film T ka Release the EARPIECE with the dental tool Be careful not to injure yourself with the sharp end of the dental tool Remove the EARPIECE with tweezers Do not use it again Discard it Remove the EARPIECE adhesive remains from the A COVER Discard them Release the IHF SPEAKER with the SS 93 as shown Remove the IHF SPEAKER and discard it s F Remove the IHF SPEAKER GASKET The IHF SPEAKER GASKET is not reusable Disacrd it Ne s Pu Peed ee afar hae J i 5 M TARATAR ETAT Arun F bi M Remove the AV JACK ADHESIVE from the D COVER Do not use it again an ug m i mak Es i T PEE i Remove the LED FLASH ADHESIVE Discard it Release the LED FLASH RUBBER with the dental tool Be careful not to damage the nearby components Remove the LED FLASH RUBBER with tweezers Remove the CAMERA with the camera removal tool SS 287 Please note that the tool used in this is not SS 287 picture Release also the SHIELDING LID 1 with the SS 93 Remove it with tweezers Do not use it again Discard it Release the LCD CONNECTOR RUBBER with the dental tool Be careful not to damage the nearby components Rem
4. 1 and 2 f Nokia Care Nokia Lumia 610 Version history Academy RM 835 RM 836 Version 1 0 Version Date Description 2012 Nokia Nokia Internal Use only All Rights Reserved
5. Nokia Care Academy Service Manual for L1 and L2 Nokia Lumia 610 RM 835 RM 836 Key features Most affordable Nokia Lumia yet Updated Windows Phone operating system e 8 GB internal mass memory e 3 7 WVGA 800 x 480 pixels LCD TFT display lone 120 Solder components Service devices Product controls and interfaces m _ sr WT M I all p Phone reset 2012 Nokia Nokia Internal Use only All Rights Reserved Service Manual Level 1 and 2 I Nokia Care Nokia Lumia 610 Exploded view Academy RM 835 RM 836 Version 1 0 A COVER ASSEMBLY A 10001 10003 TOUCH PANEL G G A COVER 10001 10002 N EARPIECE 10003 gt DISPLAY 10007 KEY LED RUBBER LIGHT SWAP PACKAGE g 10009 I0008 10019 f SECONDARY MIC RUBBER DISPLAY CONDUCTIVE TAPE 10008 10010 ANTENNA RUBBER T W LIGHT SWAP PWB 10014 10018 SHIELDING LID 2 LCD Seien RUBBER T 10016 gt LED FLASH RUBBER SHIELDING LID 1 10017N 10015 TOUCH PANEL lt s CONNECTOR RUBBER SIM TAPE 10012 10013 POWER KEY a 10006 e Va KEY VOLUME KEY 10004 CAMERA 10020 ww LED FLASH A D COVER ASSEMBLY b 10021 10029 J ig LED FLASH ADHESIVE 10026 IHF SPEAKER ig AV JACK j 10921 10023 IHF SPEAKER GASKET d 10022 idi AV JACK ADHESIVE 10024 MAIN ANTENNA 10027 aa w i Ga BT GPS WLAN
6. RM 836 Version 1 0 Fasten the eight Torx size 4 screws to the torque of 9 Ncm in the order shown 2012 Nokia Nokia Internal Use only All Rights Reserved Service Manual Level 1 and 2 Nokia Lumia 610 RM 835 RM 836 Version 1 0 Grounding Grounding spring spring PAD3901 PAD3911 Say 6 4 105 REV OD 05 CORPER 2 MJ 94 VENDOR LANE 2011 127 PAD3902 Grounding spring USB LED flash LED flash Fuse connector connector F1601 PD2302 PD2301 SK3703 PAD3501 BT WLAN GPS SK3704 Solder components Grounding Grounding Grounding Search key Start key spring spring spring LED LED PAD3906 PAD3904 PAD3910 LED3 705 ILED3701 PAD3903 IPAD3905 PAD3907 LED3 702 Grounding Grounding Grounding Back key spring spring spring LED BT WLAN GPS RF antenna RF antenna Grounding antenna connector spring connector spring connector spring PAD3502 PAD3202 PAD3201 SH1 1 URW YTYTYTU Jn 3 al ii ie EEEE m i ci m SERERE Ps BBE m is LES ee Se E Bii T HIE EH J as E TT sali L LEO LM Hf F E P JETTIITE cor WNTI SK3701 SK3702 Camera switch Volume Volume Power up switch down switch switch 2012 Nokia Confidential All Rights Reserved antenna connector Service Manual Level 1 and 2 Nokia Lumia 610 Service devices RM 835 RM 836 Version 1 0 CA 190CD Service cable AC 50 USB charger Nokia
7. on screen keypad Calendar m Alarms 2 Diagnostics app appears in Apps list To remove the ODDT 1 Tap and hold Diagnostics 2 Tap uninstall PS Transfer Note always uninstall the tool before returning the phone to the n Diagnostics consumer For more information on using the ODDT see KICS TR2816 ME Help How to e Internet Explorer 2012 Nokia Nokia Internal Use only All Rights Reserved Service Manual Level 1 and 2 Nokia Lumia 610 Phone reset RM 835 RM 836 Version 1 0 Hardware reset If the phone hardware is jammed you should first recommend that the consumer performs a hardware reset The hardware reset does not reset the Windows Live ID or remove any consumer data To perform a hardware reset remove the battery and reinsert it Boot up the phone normally Software operating system OS reset The software operating system OS reset returns the phone to its out of the box state Note that this procedure erases all consumer data Always first try to perform a hardware reset About menu Use this procedure if the consumer knows the lock code This procedure warns the consumer about data loss SETTINGS Tap Settings gt About gt reset your phone about Note Nokia Lumia 610 does not support OS reset using hardware keys more info zx 5 f f ALMANA WL Im your phone 2012 Nokia Nokia Internal Use only All Rights Reserved Service Manual Level
8. ove it with tweezers Do not use it again Discard it LP ii Jr E 1 4 K s 3 Release the TOUCH PANEL CONNECTOR RUBBER with the dental tool Be careful not to damage the nearby components Remove it with tweezers Do not use it again Discard it Lift up the SIM TAPE with the dental tool Be careful not to damage the nearby components Remove it with tweezers Do not use it again Discard it Release the ANTENNA RUBBER with the dental tool Be careful not to damage the nearby components Remove it with tweezers Discard it Release the SECONDARY MIC RUBBER with the dental tool Be careful not to damage the SECONDARY MIC or any nearby components Remove it with tweezers Do not use it again Release the KEY LED RUBBER with the dental tool Be careful not to damage the nearby components Remove it with tweezers Do not use it again Discard it Release one corner of the DISPLAY CONDUCTIVE TAPE with the dental tool Be careful not to damage the ENGINE BOARD Slowly peel off the DISPLAY CONDUCTIVE TAPE The DISPLAY CONDUCTIVE TAPE is not reusable Discard it Remove the DISPLAY CONDUCTIVE TAPE adhesive remains from the engine board with the SS 93 The Nokia Lumia 610 disassembly procedure is complete END OF DISASSEMBLY 2012 Nokia Nokia Internal Use only All Rights Reserved Service Manual Level 1 and 2 Nokia Lumia 610 Assembly steps RM 835
Download Pdf Manuals
Related Search