service equipment
Contents
1. Vacuum gauge combines thermocoupler sensor technology with advanced IC electronics for precise readings and repeatability not found with thermistor sensors or analog meters Precision circuitry to control sensor and then translate sensor input into micron readings Provides accurate readings on job after job from 1999 to 1 micron without calibration Large high contrast digital display for easy reading Female to female coupler to connect sensor into system Powered from one D cell battery Compact design with storage case for sensor cable and hose Rugged molded case protects electronic circuitry and sensor 79RO195 Ls RD 5 11116 O0P Drop Ship Only Thermocouple Sensor No adjustments or warmup Stays calibrated after on off switching and long evacuations Automatic ambient temperature compensation Automatic battery compensation Replaceable thermocouple sensor with inch flare no calibration required Comes with 182 cm 6 ft long sensor cable KY Limited to stock on hand PAGE 579 MISCELLANEOUS A C FLUSH 79R4650 RD 5 10206 0P 128 ounce 1 gallon 6 per case 79R4655 RD 5 10207 0P 32 ounce 1 quart 4 per case COMPRESSOR OIL INJECTOR 79R1710 RD 5 829 1 OP R134q Adding oil to air conditioning compressors is a necessary but slow process The refrigerant charge is wasted and some disassembly is required 7 9R1 700 and 79R1710 is used in conjunction with a gauge manifold assem2. 79R1911 LS RD 5 11562 0P REFRIGERANT IDENTIFIER 30 Ib Tank with float switch 134a 79R3591 Ls RD 5 12321 OP MM 79R1912 Ls RD 5 11563 OP Drop Ship Only 50 Ib Tank only 134a Hand held micro infrared spectrometer digitally displays the percentage of air and I detector that can readily identify and measure alerts you with audible and visual alarms for 79R1914 ts RD 5 11961 OP the percentage of purity of R 134a R 22 and flammable hydrocarbons 30 Ib Tank only 134a R 12 with 98 accuracy It can also detect Operates on 12 volt DC Includes analyzer 79R1920 ES RD 5 11566 0P blends and contaminated refrigerants and o adapters cord and carrying o 7IR1920 ts RD 5 11566 0P 30 Ib Tank only 134a 79R1921 Ls RD 5 11564 0P 30 Ib Tank with float switch R 12 79R1922 LS RD 5 11565 0P 50 Ib Tank only R 12 79R1923 Ls RD 5 11567 0P 50 Ib Tank with float switch R 12 WRAP AROUND HEATER 79R1800 Ls RD 5 11114 OP Wrap Around Heater 115V Used to heat 30 50 and 125 pound refrigerant cylinders Maintains an even temperature for constant positive pressure that speeds transfer of refrigerant for a complete charge every time Expandable wraps around 30 50 and 125 pound refrigerant tanks Thermostat controlled K Limited to stock on hand PAGE 576 SERVICE EQUIPMENT TANKS amp HOSES SERVICE COUPLERS 79R3178 ES RD 5 11102 0P LEAS RD 5 11103 0P Coupler chrome
3. 79R4580 RD 5 7103 0P 8 oz SP15 Pag Oil Use with R 134a Sanden Compressors 221 viscosity 6 per case 79R4585 RD 5 7166 OP RD 5 9635 OP 1 qt Pag Oil Use with R 134a Zexel Seltec Diesel Kiki Compressors 46 viscosity 6 per case 79R4595 RD 5 8062 0P R 134a and R 12 12 oz Ester oil Use with CCI Compressors 12 per case OIL DIPSTICK 79R4597 RD 5 11568 0P Sanden Oil Dipstick MISCELLANEOUS DIAL THERMOMETER FIN COMB 79R1150 RD 5 10209 OP J 79R1255 RD 5 11113 0P 2 dial face with 0 to 220 F range Multi head tools straightens 8 9 10 12 14 and 15 fins per inch Works on radiator evaporator coils and aluminum finned heat exchangers Breaks down easily for tool box storage Compact 10 cm 4 in length l5 TN Mane ot a i 0 INFRARED DYE AIR CONDITIONING THERMOMETER Toes _ SERVICE MANUAL orage 79R5901 RD 5 11043 0P Six per pack 79R5030 f For Ester Oil Six per package RD 5 8039 1M j REFRIGERATION TAPE 2 wide by 14 tape used in covering exposed A C fittings 30 foot roll WIRE LOOM CONDUIT i i S33 SSASARAAAA AKLLLLLLLLLLLLLHLL SUGUUUUUUGeeeeeeuel 79RO125 RD 5 9569 96P 79RO225 RD 5 7357 96P 0 250 inside diameter black wire loom conduit 0 250 inside diameter gray wire loom conduit 79RO138 RD 5 5904 96P EE 79RO241 RD 5 5562 96P 0 375 inside diameter black wire loom conduit 0 413 inside diameter gray wi
4. All with as a compressor model Sanden Zexel Diesel Kiki TV 108 79R4615 RD 5 8961 OP GM A6 R4 DA6 Retro kit Applications Caterillar Deutz Allis Fiat Allis Allis Chalmers Chevy GMC J I Case John Deere Long Massey Ferguson Navistar New Idea Avco Mack Terex All with compressor model GM A6 Frigidaire 79R4625 RD 5 9983 0P Nippondenso Retro kit Applications 1980 to current Ford cars pickups and vans All with compressor models FS6 HR980 FX1 5 FS 10 Frigidaire A6 Nippondenso 6E 6P 1 OP 1 OPA Sanden SD5 SD7 FOR CONVERTING R12 A C SYSTEMS TO ENVIRONMENTALLY SAFE HFC 134A Kits include the minumum components necessary to convert from an R12 system to R134a system Kit includes O rings and gaskets retro charging adapters R12 charging port eliminator cap retrofitted identification label and 80z of Retro A C Ester Oil Used to service air conditioning systems on 1991 and later GM vehicles Convert Your Vehicle s R12 A C System To Ozone Safe R134a Refrigerant NOTE RETRO KITS ARE NOT ENDORSED BY THE COMPRESSOR MANUFACTURERS FLEX HOSES 79RO107 used on low pressure side of R 12 air conditioning recovery systems 79RO109 used on high pressure side Easy retrofit of existing hoses to provide ball valve capability Flexible hose between valve and fitting makes hook up in tight areas much easier PART NUMBERS 79R0107 EY RD 5 11145 OP Blue Flex Hose 1 79RO109 EY RD 5 11146 0P Red Flex Hose 4
5. Shroud SHOWN 60 OF ACTUAL SIZE RD 5 4693 0M Connector Housing 5 Contact Male Spade Switch Body SHOWN 60 OF ACTUAL SIZE RD 5 5078 0M RD 5 5992 0M RD 5 6317 0M RD 5 9017 0M RD 5 3975 0M_ RD 5 5661 0M Terminal Female Terminal Female Terminal Female Terminal Female Terminal Female Housing Connector Weatherpak with Barrel End 280 Series with Square End Micro Pack 100 Metripak 280 with Square Tang f 56 Series Spade Receptacle 1 Contact Female 14 gauge 14 gauge 1 contact 14 gauge 14 gauge Weatherpak Tower SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN 60 OF ACTUAL SIZE o E Taia E man FAEN CONNECTORS RECEPTACLES TERMINALS SEALS LOCKS HOUSINGS Use the RD numbers to order replacement parts Login to www rdac com with your password For additional Electrical Connector Assembly Kits order RD 5 11966 0P ELECTRICAL CONNECTOR ASSEMBLY TOOL KIT The perfect companion to Red Dot s Connector Assembly Kit these are the only tools you ll need to assemble all of the connectors shown above 79R3535 RD 5 12140 0P et eon a T RD 5 12137 0P RD 5 12135 0P peer RD 5 12138 0P RD 5 12136 0P RD 5 12134 0P PAGE 583 SERVICE EQUIPMENT MISCELLANEOUS ORIFICE TUBE REMOVER KIT ADAPTERS AND COUPLER 79R1660 NOSoMmmeteeelem Adapt female quick connect to male thread Designed to remove all necessary parts of complete or dam
6. 2 RD 5 7792 OP Standard Crimp Die 6 Reduced Bead Crimp Die 8 79R1536 RD 5 11227 0P 79R9518 RD 5 8896 0P Standard Crimp Die 8 79R1538 RD 5 11228 0P 79R1518 RD 5 7790 0P Reduced Bead Crimp Die 10 79R1541 RD 5 11229 0P 79R9521 RD 5 8897 0P Reduced Bead Crimp Die 6 79R1546 RD 5 11226 0P 79R9516 RD 5 8895 0P 79R1672 RD 5 11200 0P gt m Bubble Crimp Kit Use with Red Dot Barrier Hose Drop Ship Only 79R1520 RD 5 7731 0P Hydraulic Hand Pump and 6 Hose with Male Quick Disconnect 7 d POWER Team 79R1525 RD 5 7732 0P HYDRAULIC CYLINDER Retro Fit Hydraulic Cylinder for 79R1510 Bubble Crimp Kit with Female Quick Disconnect PAGE 570 SERVICE EQUIPMENT RECOVERY RECYCLING AND RECHARGING SYSTEMS R 134A 79RO120 Ls RD 5 11580 0P Drop Ship Only Air Conditioning Recovery Recycling Unit R 134a 110V 60 Hz Simplest easiest to use air conditioning One touch air purge eliminates non service units on the market today helps condensables in system technicians meet today s fough service One touch oil drain after every service standards tells how much oil is needed to keep Operation is quick and efficient lowers air compressor fully lubricated conditioning service costs Automatic tank full and high pressure shut I Easy to operate just connect quick connect offs couplings to vehicle and push Recovery Shock resistant scales for accurate Recycle switch unit completes recovery chargin
7. 5 8231 0M RD 5 9081 0M RD 5 5660 0M Terminal Male Terminal Male Terminal Male with Pin End Terminal Male Lock Push in Housing Connector Weatherpak 280 Metripak 280 with Blade End 14 16 gauge Metripak 280 with Flat Pin End HD Caterpillar OEM Male Weatherpak I pin with Blade End 14 gauge SHOWN ACTUAL SIZE 14 gauge Green HD Shroud IHC 14 gauge SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN 60 OF ACTUAL SIZE SHOWN ACTUAL SIZE RD 5 5933 0M RD 5 8634 0M Housing Connector Housing Connector 3 Contact Female 1 Contact Female Weatherpak Tower Metripak with Square End SHOWN 60 OF ACTUAL SIZE SHOWN 60 OF ACTUAL SIZE E RD 5 8778 0M Housing Connector 1 Contact Male Metripak 280 HD SHOWN 60 OF ACTUAL SIZE 8 RD 5 5073 0M Housing Connector 2 Contact Male Weatherpak Shroud SHOWN 60 OF ACTUAL SIZE RD 5 5989 0M Housing Connector 2 Contact Male Metripak 280 SHOWN 60 OF ACTUAL SIZE RD 5 6318 0M Housing Connector Female Flat MicroPack 100 6 conductor SHOWN ACTUAL SIZE RD 5 9080 0M Connector Housing 2 Contact Female HD Caterpillar OE SHOWN 60 OF ACTUAL SIZE ug EN RD 5 8591 0M Housing Connector 3 Contact Male Weatherpak
8. Blue 244 cm 8 ft 79R3162 09 RD 5 11086 0P Red 457 cm 15 ft 79R3171 DS _RD 5 11096 0P Red 244 cm 8 ft 79R3164 9 RD 5 11088 0P Blue 457cm 15ft 79R3176 9 RD 5 11097 0P Yellow 457 cm 15 ft 79R3166 RD 5 11090 0P Yellow 457 cm 15 ft 79R3174 09 RD 5 11098 0P Blue 457 cm 15 ft 79R3165 3 RD 5 11091 0P Yellow 244 cm 8 ft 79R3172 09 RD 5 11099 0P Red 457 cm 15 ft 79R3161 TS RD 5 11093 OP Red high 244 cm 8 ft 79R3163 RD 5 11092 0P Blue low 244 cm 8 ft K Limited to stock on hand PAGE 577 VACUUM PUMPS amp ACCESSORIES 1 5 CFM VACUUM PUMPS 79R4020 Ls RD 5 11139 0P Vacuum Pump 115V 60 Hz 79R4030 Ls RD 5 11140 0P Vacuum Pump 220V 50 Hz Rated as free air displacement pump Large sight glass for easier monitoring more precise readings Rugged metal construction with no plastic Large oil drain valve for quicker draining Gas ballast soeeds evacuation and keeps to crack or fall off Longer heat dissipation fins for a cooler oil cleaner Oil reservoir port has a wide mouth for running unit Tethered caps stay with the unit easier neater filling doubles as an pump Low operating temperature improves exhaust and is threaded to attach garden efficiency and vacuum Drop Ship Only type hose for exhausting to remote location Low profile on off switch to avoid breakage Large oil reservoir helps reduce operating Vacuum indicator gauge at pump intake temperature and dilute corrosive fitting shows e
9. ER SERVICE METHOD OF S A E J2209 OR J1990 MAY CAUSE INJURY CONSULT SHOP MANUAL ADDITIONAL HEALTH AND SAFETY INFORMATION MAY CAUSE INJURY CONSULT SHOP MANUAL FILL OUT AND ATTACH THIS LABEL TO VEHICLES MAY BE OBTAINED FROM REFRIGERANT FILL OUT AND ATTACH THIS LABEL TO VEHICLES REFRIGERANT RETROFIT LABELS RED DOT CTC ANALYZERS Red Dot Constant Temperature Control CTC analyzers are an 10 K important service tool FOR trouble shooting heater or heater air per panned conditioner systems equipped with the Red Dot CTC or CTC II systems NOTICE RETROFITTED to R 134 a 79R1010 RD 6 4664 0P Retrofit procedure performed to SAE J1661 CAUTION System to be serviced by qualified personnel only CTC Analyzer Retrofit Date Name of company or individual performing retrofit Address City State Zip TA y ___ R I34a Charge Lubricant Type ss Lubricant Amount Auxiliary Label Location oo CTC ANALYZER PAGE 568 SERVICE EQUIPMENT E Z CLIP FITTINGS amp TOOLS 79R8920 RD 5 10717 OP 79R8930 RD 5 10739 OP Connecting Tool Hose Cutter amp Blade maximum hose O D 2 79R893 1 RD 5 10740 OP Replacement Blade for 79R8930 above TOOL KIT STEEL FIELDCASE ESE Sa EE Includes 20 each Clips 6 8 10 12 10 each Cages 6 8 10 12 Connecting Tool 79R8920 Hose Cutter 79R8930 Replacement blade for Hose Cutter RD 5 11372 OP Includes 100 each Clips 6 8 10 12 90 eac
10. K Limited to stock on hand PAGE 582 MISCELLANEOUS ELECTRICAL CONNECTOR ASSEMBLY KIT Plugs for Compressor Clutches Blower Motors Switches Relays Heater A C Units Acutators and more a 79R3532 RD 5 11966 O0P Finally a kit to fit that hard to find plug assembly mad Dot with the right housing terminal seal and lock i that looks and fits like the sealed OE connector Pianino Sos Kit _______ C Assembly Kit Here s what you get 514 BD PO mE e741 gt e7 ee umm RD 5 3992 0M RD 5 10424 0M RD 5 3977 0M RD 5 5077 0M RD 5 6061 0M Connector Male Bullet Connector Male Bullet Receptacle Spade Seal Blue Lock Sealed 1 contact Sealed 1 contact Sealed 1 contact Weatherpak Metripak Metripak TPA 14 16 Gauge 12 gauge 14 16 gauge 12 gauge Blue SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE T RD 5 4438 0M RD 5 5746 0M RD 5 3979 0M RD 5 5988 0M RD 5 8635 0M RD 5 5076 0M Receptacle Bullet Receptacle Bullet Connector Male Spade Seal Gray Lock Housing Connector Sealed 1 Contact Sealed 1 contact Sealed 1 contact Weatherpak Metripak Metripak TPA 2 Contact Female 14 16 Gauge 0 156 dia 12 Gauge 0 180 dia 14 16 gauge 14 18 gauge Volvo Paccar Case OEM Weatherpak Tower SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE SHOWN ACTUAL SIZE Black SHOWN 60 OF ACTUAL SIZE SHOWN ACTUAL SIZE T RD 5 5074 0M RD 5 5990 0M RD 5 6191 0M RD
11. N 10 F 12 C Description Control Module Kit Suction Tube Control Module Kit sensor Adapter Control Module Kit For day cab with sleeper For day cab without sleeper Prolecht Kit Prolecht Kit SERVICE EQUIPMENT SYSTEM PROTECTION A C TECHNICIAN SOFTWARE Advanced Diagnostics Exhibits visual blink codes providing trouble COMPONENTS Laptop or desktop PC with Intel 486 or shooting diagnostics ACTechnician Software better microprocessor E 5 diagnostic codes to FEATURES Microsoft Windows 95 98 NT 2000 e ata Bus oo Reads available o on the SAE Displays Diagnostic information i us een techn J1708 to both protect and optimize A C Displays Active Fault Codes A om component performance Displays Real Time Pressures 0 Retains Fault Code History a D tea p port or higher resolution monitor REQUIREMENTS SAE J1708 Serial Interfade Adapter My Computer P AJE echo Eor RD 6 5120 0P Doire lf manuf I z With SAE J1708 om ee oe Serial Interface Adapter ei a aH ea RD 6 5120 1P ga enatch ontime __APSICIEEKPAY sr Without SAE J1708 hennon Serial Interface Adapter Neighborhood oe Sc ate ieee ighbo am i So Sz AIC Cycles eS Microsoft Bec Outlook y E Recycle Bin mfn The optional A C Technician Diagnostic Software part number RD 6 5296 0P utilizes CD ROM based software with a SAE J1708 serial interface adapter and
12. OVERY SYSTEM RD 5 11101 OP 79RO160 R 134a Ls Drop Ship Only Quickly recover contaminated known or unknown refrigerants including mixtures and blends Perfect for scavenger work or to protect recover recycle equipment and valuable refrigerant supply Pump straight liquid refrigerant at up to 4 lbs minute vapor at 1 Ib minute Very durable oil less compressor direct drive and permanently lubricated cylinder walls Reliable and lightweight Built in 200 mesh inlet filter to protect from dirty air conditioning systems Easy use two hose setup and on the fly auto purge Recovery capabilities Compressor Dimensions w x x h Refrigerants Voltage Recovery rate Weight Vapor and Liquid applications HP Oil Filled Hermetic 14 2 x 12 2 x 15 x 36cm x 32cm x 38cm R 12 and R 134a 115V 60 Hz single phase Liquid 4 lbs 2 kg per minute maximum Vapor 1 Ibs 0 5 kg per minute maximum 25 Ibs 11 kg PART NUMBERS 79RO165 EY RD 5 11100 0P R 12 Recovery System 79R3165 K RD 5 11091 0P Yellow R 12 Charging Hose 79R1810 EY RD 5 11120 0P Refrigerant Cylinder 30 Ib 79RO160 AY RD 5 11101 OP R 134a Recovery 79R3175 EX RD 5 11094 0P Yellow R 134a Charging Hose ADDITIONAL PARTS FOR 79R0165 79R1820 EY RD 5 11122 0P Refrigerant Cylinder 50 Ib 79R3162 RD 5 11086 0P R 12 Charging Hose Red 457 cm 15 ft 79R3164 EY RD 5 11088 0P R 12 Charging Hose Blue 457 cm 15
13. TING RAAT SE AL MAKES P DOT BUILT 10 SURVIVE Ey ww instrumentSales Bpenfedac 1 800 333 7976 Service EQuioment SERVICE EQUIPMENT SYSTEM PROTECTION PROTECHT SYSTEM Introducing the latest A C system protection technology for use with mobile A C systems The system is comprised of a compact electronic control unit ECU which performs input signal processing A C system diagnostics communication with the vehicle s SAE J1 708 serial bus using SAE J1587 protocol and A C function control through output drivers System Protection Features System Components ee Exhibits visual blink codes providing system protection and troubleshooting diagnostics Limits excessive system pressures Limits excessive clutch cycling to increase the life of compressor and compressor clutch Prevents evaporator freeze up Engages the condenser fan based on real time A C and vehicle operating conditions Prevents the clutch from engaging under low temperatures or lost refrigerant charge conditions Prevents the clutch from engaging under low battery voltage conditions Allows set points to be changed in software to meet specific applications and requirements Transmits A C error and diagnostic codes to the SAE J1 708 Data Bus Reads available information on the SAE J1708 Data Bus to both protect and optimize A C component performance based on vehicle status Displays faults and real time diagnostics with Window
14. aged Knurled fittings for easy connection orifice tube 79R400 79R0105 79R4007 79R4008 PART NUMBERS 79R0105 RD 5 11143 0P Adapter 12 acme female hex to 13mm male R 134a low side R 12 to R 134a 79R4006 RD 5 11148 0P Coupler Converts Standard R 12 flare to R 134a 1 2 acme thread 79R4007 RD 5 11123 0P Adatpter R 12 female QD to 4 male flare 79R4008 RD 5 11138 0P Adapter R 134a 4 female QD to 2 male ACME COMPRESSOR TOOL KIT 79R3000 RD 5 5620 0P Deluxe Sanden Tool Kit For SD 508 and SD 510 COMPRESSORS Contains the following Seal Seat Remover O Ring Remover Clutch Holder Seal Remover Installer Seal Protector Clutch Face Installer Oil Dipstick Internal Snap Ring Plier External Snap Ring Plier Handle Puller Fingers Puller Pilot Puller Plate Assembly Bearing Remover Installer OZSETrMACTOT M IOOFVD PAGE 584
15. andle Group surge protector and silicone dampened STANDARD MANIFOLD GAUGES Manifold Gauge Red R 134a 0 to 500 PSI fe 0 to 3447 kPa 79R3127 S Manifold Gauge Blue R 134a 30 to 0 to 120 PSI 206 to 0 to 827 kPa Bold high visibility dials have colored temperature scales for easy reading Flutterless technology and surge protection minimize needle pulsation RD 5 11105 OP RD 5 11106 OP Accuracy 3 2 3 percent Diameter 2 1 2 64 mm Connections 1 8 NPT K Limited to stock on hand PAGE 575 SERVICE EQUIPMENT TANKS amp HOSES REFRIGERANT RECOVERY TANKS R 134A TANKS Drop Ship Only Drop Ship Only FOR R 134A amp R 12 For R 134a refrigerant Used to store recovered refrigerants sens S EL tanks are D O T 79R1810 and 79R1820 are equipped with 3 pin Brad Harrison connector 5 AEE E A ECES aior Gray and yellow color coding recovery and e y ce OWS NONI POI CoR Distinctive blue exterior clearly identifies Cylinders equipped with a protective collar and handle these tanks as R 134a equipment Float switch plug 3 4 Pressure rating 2400 kPa 350 PSI tae 4 PART NUMBERS B L FA 79R1810 E RD 5 11120 0P Cylinder with Float no p g 30 pound LS i 79R 1815 E RD 5 11121 0P Cylinder with Y Valve no float 30 pound 79R1820 AY RD 5 11122 0P Cylinder with Float Ss 50 pound a 79R1825 RD 5 11083 0P Cylinder with Y Valve no float 50 pound 4
16. at 1725 rom Internal capacitor thermal overload Temperature rise 104 F 40 C Voltage single phase 115 Volt 60 Hz or 230 Volt 50 Hz Oil capacity 0 7 liter 24 oz Overall dimensions 15 1 4 x 6 3 2 x 12 38 7 x 17 1 x 30 5 cm Weight 29 5 lbs 13 4 kg K Limited to stock on hand PAGE 578 SERVICE EQUIPMENT VACUUM PUMPS amp ACCESSORIES R134a 3 IN 1 VALVE FOR R 12 VACUUM VACUUM CHARGE RECOVERY CORE TOOL CHARGE VALVE Used as a vacuum monitoring valve 4 side port to attach electronic micron vacuum gauge 79R2925 L5 RD 5 11125 0P for greater accuracy ae Core remover allows evacuation and charge through an unrestricted line for increased speed oe as a vacuum monitoring valve and higher vacuum 4 side port to attach electronic micron Core replacement tool vacuum gauge for greater accuracy Recovery valve core removal allows recovery unit to work at maximum efficiency speeding Core remover allows evacuation and charge through an unrestricted line for recovery process l yp increased speed and higher vacuum PART NUMBERS Core replacement tool 79R2921 EY RD 5 11141 0P Core Remover Recovery valve core removal allows 79R2923 GS RD 5 11142 0P Core Remover recovery unit to work at maximum efficiency speeding recovery process HEAVY DUTY RETROFIT LCD VACUUM GAUGE amp SENSOR ADAPTER KIT 79RO190 Ls RD 5 11115 OP Bi 79R8940 RD 5 9986 0P Drop Ship Only LCD Vacuum Gauge
17. bly It utilizes the pressure differential from the high to the low side of the system to inject 2 oz of oil into the unit K Limited to stock on hand PAGE 580 VACUUM PUMP OIL Use with 79R4010 Promotes internal sealing for good vacuum and absorbs unwanted vapor from evacuated units YELLOW JACKET Regular oil changes SurinBvac promote longer eres vacuum pump life LEAK DETECTOR HEATED ACCUPROBE ELECTRONIC Combines proven technology with user friendly features Santoprene holster provides protection and a comfortable grip Gooseneck probe is 16 long wraps onto the back for storage sensing tip fits into the recessed slot Other features include audible and visual leak indicators volume control and sensitivity selection for most refrigerants including R 134a new blends and substitutes DROPSHIP ONLY 79R3599 LS RD 5 12319 OP PRO ALERT SNIFFER LEAK DETECTOR ne we R REFRIGERANT OIL 79R4550 RD 5 5916 0P L PA ONLY MINERAL OIL quart Quality wax free compressor oil for air conditioning systems Printed calibrations to facilitate measured pouring Viscosity 500 S S U 100 F 6 per case 79R4561 RD 5 9633 0P 12 oz Ester Oil Plastic Bottle 100 viscosity 6 per case 79R4562 RD 5 9634 0P 32 oz Ester Oil Plastic Bottle 100 viscosity 6 per case 79R4563 128 oz Ester Oil Plastic Bottle 100 viscosity 4 per case
18. ft 79R3166 EY RD 5 11090 0P R 12 Charging Hose Yellow 457 cm 15 ft 79R3161 AY RD 5 11093 0P R 12 Charging Hose Blue 244 cm 8 ft 79R3163 HS RD 5 11092 0P R 12 Charging Hose Red 244 cm 8 ft ADDITIONAL PARTS FOR 79R0160 79R1820 FY _RD 5 11122 0P Refrigerant Cylinder 79R3173 HS RD 5 11095 0P R 134a Charging Hose Blue 244 cm 8 ft 79R3171 A RD 5 11096 0P R 134a Charging Hose Red 244 cm 8 ft 79R3176 EY RD 5 11097 0P R 134a Charging Hose Yellow 457 cm 15 ft 79R3174 EY _RD 5 11098 0OP R 134a Charging Hose Blue 457 cm 15 ft 79R3172 RD 5 11099 0P R 134a Charging Hose Red 457 cm 15 ft K Limited to stock on hand PAGE 572 nima SERVICE EQUIPMENT SERVICE EQUIPMENT RECHARGE OIL PUMP 79R1730 ES amp RD 5 11117 0P Used to replace oil in air conditioning system or compressors after oil has been removed A Easily works with system pressures up to 2070 kPa 300 PSI 4 Y Includes bottle with calibration marks hose and low A side R 134a coupler Can be used for R 12 systems use a regular charging hose with 1 4 inch flare fittings Volume per stroke 1 5 ounces System pressures up to 2070 kPa 300 PSN Holds 16 ounces REFRIGERANT FILTER amp PREFILTER SERVICE PARTS FOR 79RO110 EY RD 5 11084 0P Air Conditioning Recovery Recycling Unit R 12 110V 79R0120 EY RD 5 11087 0P Air Conditioning Recovery Recycling Unit R 134a 110V 79R0130 EY RD 5 11089 0P Air Conditioning Recovery Recyclin
19. g and recycle process Built with quality components such as 1 2 hp oil less compressor new advanced shock resistant scale dual protected solenoids and more Vacuum timer allows technician to set time and two stage vacuum pump automatically pulls a deep vacuum Easy to set LCD display simply scroll to correct charge and push charge switch system quickly receives refrigerant Large 75 mm 3 5 in gauges allows technician to easily monitor air conditioning single pass filtering system Built in manifold gauge set Moisture indicator Tank refill adapter Modular design for easy repair Large pneumatic tires Premium hoses approved to SAE2197 standard Fully factory tested Built in accessory and tool storage box system x SPECIFICATIONS Recovery tank One 50 pound Dimensions hxwxd 53 x22 x 27 63 x 68 x 134 cm Weight 120 Ibs 54 kg Vacuum Pump Two stage 6 cfm Hose length 15 ft 4 5 m 1 2 ACME female x 13 mm male adapter 79R0103 79R4006 y 79R0107 l 79R0101 79R0109 SERVICE PARTS 79R0101 EY RD 5 11081 OP Refrigerant Filter 79R0103 RD 5 11082 0P Refrigerant Pre Filter 79R4006 _RD 5 11148 0P 1 4 Female x 4 Male Acme Refill Adapter R 134a 79RO107 HY RD 5 11145 0OP Blue Flex Hose 4 79RO109 EY RD 5 11146 0P Red Flex Hose 4 KY Limited to stock on hand PAGE 571 SERVICE EQUIPMENT RECOVERY RECYCLING AND RECHARGING SYSTEMS PORTABLE REC
20. g Unit R 134a 220V 79RO101 Ls RD 5 11081 OP Refrigerant Filter Capacity 41 cubic inches Color GRAY Dimensions 34 89mm diameter by 91 2 241cm overall length 79RO103 Ls RD 5 11082 OP Refrigerant Prefilter Function Removes moisture and oil breakdown particles Connections Ys male flare x 1 4 female flare Dimensions 4 101mm diameter by 5 143mm overall length KY Limited to stock on hand PAGE 573 CHARGING SCALES DIGITAL ELECTRONIC CHARGING SCALE 79RO170 Ls RD 5 11154 O0P Drop Ship Only Manual Refrigerant Charging Scale Battery Powered Large heavy duty platform and oversized strain gauge bridge for accuracy and repeatability High quality load cell for improved accuracy Retractable 5 coiled cord for easier storage Water amp environment resistance with sealed LCD display and membrane keypad with tactile metal domes Overload Protection 1 2 bold dark numbers for easy reading outdoors Low battery indicator icon on LCD Optional AC power pack eee Measure imperial or metric units o gt ta ts te SE Meets UL and CE requirements ee ag M Compatible with all refrigerants Specifications Capacity 110 Ibs 50kg Resolution 0 1 Ounce 0 01 Pound 0 01kg Accuracy 0 5 0z 0 03 Ib 0 015 kg Total Unit Weight 9 Ibs 4 1 kg Case Size LxWxh 15 x 12 4 x 3 394mm x 311mm x 83mm Platform Size 9 X 9 228mm X 228mm Battery 25 hours continu
21. h Cages 6 8 10 12 50 each O Rings 6 8 10 12 100 each O Ring Nipple 6 8 10 12 Connecting Tool 79R8920 Hose Cutter 79R8930 2 Replacement blades for Hose Cutter EZ CLIP NIPPLE O RINGS 70R8836 70R8838 70R8831 70R8832 RD 5 11461 0M RD 5 11462 0M RD 5 11463 0M RD 5 11464 0M 6 8 10 12 O Rings ship 25 per package CAGES amp CLIPS CAPS Packages of 10 A Threaded protective caps Packages of 20 a Factory No Description Size Factory No Factory No 75R5555 RD 5 11325 0M E Z Clip Low Side Cap 6 70R8806 RD 5 10709 OM 70R8826 RD 5 10713 0M 75R5556 RD 5 11223 0M E Z Clip High Side Cap 8 70R8808 RD 5 10710 0M 70R8828 RD 5 10714 0M 10 7O0R8801 RD 5 10711 0M 70R8821 RD 5 10715 0M 12 70R8802 RD 5 10712 0M 70R8822 RD 5 10716 0M PAGE 569 SERVICE EQUIPMENT SERVICE EQUIPMENT ATCO CRIMP TOOLS 79R1560 RD 5 11225 O0P 79R1565 RD 5 11232 0P Bubble Crimp Kit _ Bubble Crimp Kit with for use with Hydraulic Hand Pump and 6 Hose Air Impact Wrench Drop Ship Only ATCO CRIMP TOOL REPLACEMENT PARTS Description 79R1560 amp 79R1565 79R1510 amp 79R1515 Actuator Screw 79R1502 RD 5 7788 0P Strain Rod Set 2 79R1503 RD 5 7787 OP Latch Plate 79R1504 RD 5 7786 OP Actuator Bar 79R1505 RD 5 848 OP Standard Crimp Die 6 79R1516 RD 5 7789 0P Standard Crimp Die 10 and Reduced 12 79R1531 RD 5 11230 0P 79R1521 RD 5 7791 OP Standard Crimp Die 12 79R1532 RD 5 11231 0P 79R152
22. ous use approximate Battery ov PROGRAMMABLE ELECTRONIC CHARGING SCALE WITH CHARGING MODULE 79R0180 Ls RD 5 11153 0P Drop Ship Only Automatic Refrigerant Charging Scale 110v 50 hz same features as the 79RO170 above with additional capabilities for automated ger sin economical charging Ees n Charging module hooks to scale with coiled cord Simple 3 button operation z Use with all refrigerants Hold resume mode for switching supply tanks in mid charge Automatic hold if refrigerant flow stops Extends solenoid life Schrader valve prevents backflow through solenoid Power pack eliminates battery draw during charging Ayton Refr h G har a Metts K Limited to stock on hand PAGE 574 MANIFOLD GAUGES MANIFOLD GAUGES 79R3120 Ls RD 5 11104 OP Manifold Assembly R 134a 79R3140 Ls RD 5 11085 0P Manifold Assembly R 12 Used to check pressure in R 134a and R 12 movement helps minimize needle pulsation cooling systems for easier more accurate readings Bold easy to read gauges large bold numbers Sliding double O ring pistons with non rotating and colored scales are easy to read design reduces wear and extends Removable Lexan crystals resist breakage service life Gauge cases are color coded red and blue Fast acting valve only 1 2 turns for full flow Pressure tested for reliability SERVICE PARTS Forged brass body with metal valve handles for 79R3135 RD 5 11136 0P Piston durability 7 79R3137 RD 5 11137 0P H
23. re loom conduit 79RO150 NDE MAI Ors RD 5 7171 96P 0 500 inside diameter black wire loom conduit 0 500 inside diameter gray wire loom conduit 79R0258 RD 5 55908 96P 0 625 inside diameter gray wire loom conduit KY Limited to stock on hand PAGE 581 MISCELLANEOUS R 134A RETRO KITS R 12 SERVICE 79R4600 RD 5 8958 0P ADAPTER CCI Tecumseh Retro kit Applications 79R4004 Ls RD 5 11124 OP Allis Chalmers Autocar Brockway Caterpillar Chevy Air Conditioning Adapter GMC Deutz Allis Diamond Rio Fiat Allis Ford FS 6 Nippondenso 6E171 use 4379 RD599830 retro fit kit Ford Sperry Ford Tractor Fox River Freightliner Hesston HFI International Harvester IH Navistar J l Case John Deere Long Kenworth Mack Marmon Massey Ferguson New Holland New Idea Avco Oliver Peterbilt Steiger Versatile Volvo White GM Western Star White Farm All with compressor model Climate Control York Tecumseh 79R4605 RD 5 8960 OP Sanden Seltec Zexel Retro kit Applications Caterpillar Chevy GMC Deutz Allis Euclid Fiat Allis Allis Chalmers Ford FS 6 Nippondenso 6E1 71 use RD 5 9983 0P retro fit kit Ford Sperry Ford Tractor Freightliner Hesston HFI Hino International Harvester IH Navistar Isuzu Iveco J I Case John Deere Kenworth Mack Marmon Mercedes New KaG noit Holland Nissan U D Oliver Peterbilt Steiger Versatile Speer aio pen am PESES Volvo White GM Western Star White Farm
24. runs on any 486 or better computer running Windows 95 or newer PAGE 567 SERVICE EQUIPMENT REFRIGERANT CAUTION LABELS PLEASE NOTE When servicing R 12 and R 134a systems the tools that come in contact with the refrigerant such as gauge sets charging equipment and recovery recycle equipment must be dedicated to one refrigerant or cross contamination may occur 79RO010 RD 5 7105 0M E 79ROO20 RD 5 7106 0M 10 per package 10 per package WARNING CONTAINS R 12 AIR CONDITIONER CAUTION CONTAINS R 134a AIR CONDITIONER A SUBSTANCE WHICH HARMS RED DOT CORP SEATTLE WA MODEL NO AVOID BREATHING A C REFRIGERANT RED DOT CORP SEATTLE WA MODEL NO AND LUBRICANT VAPOR OR MIST PUBLIC HEALTH AND ENVIRONMENT MAXIMUM OPERATING CHARGE Lb oz EXPOSURE MAY IRRITATE EYES NOSE AND THROAT MAXIMUM OPERATING CHARGE Lb oz F REFRIGERANT F REFRIGERANT BY DESTROYING OZONE I ae o nove nsa a MAXIMUM OIL CHARGE Oz FROM A C SYSTEM USE SERVICE EQUIPMENT MAXIMUM OIL CHARGE Oz TO REMOVE R 12 COMPLIES WITH SAE J639 CERTIFIED TO MEET THE REQUIREMENTS OF S A E COMPLIES WITH SAE J639 J2210 FROM THE A C SYSTEM USE CAUTION CAUTION IF ACCIDENTAL SYSTEM DISCHARGE OCCURS SERVICE EQUIPMENT CERTIFIED REFRIGERANT UNDER HIGH PRESSURE SYSTEM TO BE SERVICED VENTILATE WORK AREA BEFORE RESUMING SERVICE REFRIGERANT UNDER HIGH PRESSURE SYSTEM TO BE SERVICED TO MEET THE REQUIREMENTS BY QUALIFIED PERSONNEL ONLY IMPROPER SERVICE METHOD BY QUALIFIED PERSONNEL ONLY IMPROP
25. s based Red Dot s A C Technician software Freightliner FLD Electronic Control Unit ECU Electronic High Side Pressure Transducer provides real time pressure readings Refrigerant Charge Sensor Wire Harness System Function Performance Low Battery Voltage Detection Clutch Cycling Limiting High Side Pressure Measurement High Side Pressure Limiting Condenser Fan Control Low Temperature Lock Out Compressor Clutch Diagnostics sensor Diagnostics Data Bus Communications Changing out the receiver drier after Prolecht Installation is recommended Freightliner FLN Replacing the receiver drier after ProTecht installation is recommended 7 Freightliner Century Class PRE 1 01 Rage For cabs manufactured before Jan 2001 Mack CH Vision with A Pads Volvo VN with A Pads PAGE 566 Parts No Factory No 71R8902 RD 6 5125 O0P 71R8910 RD 2 3765 1P 71R8902 RD 6 5125 O0P 71R8915 RD 2 3775 1P 71R8903 RD 6 5144 OP 71R8920 RD 3 10551 2P 71R8925 RD 3 10051 3P 71R8922 RD 6 5189 0P 71R8912 RD 6 5 1 88 OP Low and Lost Refrigerant Charge Detection ProlECHT e Silow Blink Refrigerant Charge Sensor Pressure Transducer Se RED DOT m Protection amp Diagnostics CORPORATION Unit Functioning Properly Low Voltage Low Charge Lost Charge Check A C Clutch Check Sensors Fast Blink 1 Blink 2 Blinks 3 Blinks 4 Blinks PATENT PENDING ONLY VALID FOR UNDERHOOO TEMPERATURES GREATER THA
26. vacuation progress at a contaminants glance electronic gauge then provides Pump rating 1 5 cfm Field rating 15 microns Intake 1 4 flare and 2 ACME thread Motor 1 6 horsepower at 1725 rom Internal capacitor thermal overload Temperature Rise 104 F 40 C Voltage single phase 115 Volt 60 Hz or 220 Volt 50 Hz Oil capacity 24 oz 0 7 liter Dimensions 101 2 x 5 8 x 91 4 26 67 x 12 95 x 23 37 cm 4 0 CFM VACUUM PUMPS 79R4040 Ls RD 5 11118 0P Vacuum Pump 115V 60 Hz 79R4050 Ls RD 5 11119 0P Vacuum Pump 230V 50 Hz Rated as free air displacement pump Large sight glass for easier monitoring more precise readings Rugged metal construction with no plastic Large oil drain valve for quicker draining Gas ballast soeeds evacuation and keeps to crack or fall off Longer heat dissipation fins for a cooler oil cleaner Oil reservoir port has a wide mouth for running unit Tethered caps stay with the unit easier neater filling doubles as an pump Low operating temperature improves exhaust and is threaded to attach garden efficiency and vacuum Drop Ship Only type hose for exhausting to remote location Low profile on off switch to avoid breakage Large oil reservoir helps reduce operating Vacuum indicator gauge at pump intake temperature and dilute corrosive fitting shows evacuation progress at a contaminants glance electronic gauge then provides Pump rating 4 cfm Field rating 15 microns Intake 1 4 and 1 2 ACME thread Motor 3 horsepower
27. with Coupler chrome with blue anodized body low side to 14 mm red anodized body high side to 14 mm Couplers interface with R 134a service ports Quick easy connect disconnect Control valve allows access to system even at working Couplers interface with R 134a service ports Quick easy connect disconnect T pressures Control valve allows access to system even at working pressures Integral safety sleeve holds Integral safety sleeve holds coupler securely to service port coupler securely to service port High flow characteristics High flow characteristics 79R4005 RD 5 8329 0P Retrofit R 12 Vacuum Pump to R 134a R 12 AIR CONDITIONING CHARGING HOSES Proven performance Double barrier protection for R 12 and R 134a Nylon permeation barrier meets U L requirements for R 12 R 134a R 22 and R 503 refrigerants Moisture barrier provides improved resistance to moisture contaminates expensive refrigerant sealRight fittings immediately trap refrigerant in hose when disconnected 45 end allows easier connection in tight areas Gaskets resist deterioration from R 12 and R 134a refrigerants and oil R 134A AIR CONDITIONING CHARGING HOSES 1 4 hoses for R 134a refrigerant 1 2 Acme fitting meets SAE requirements Double barrier protection Threads 1 2 Acme female 14 mm Acme male PART NUMBERS 79R3175 3 RD 5 11094 0P Yellow 244 cm 8 ft PART NUMBERS 79R3173 09 RD 5 11095 0P
Download Pdf Manuals
Related Search