license plate bracket and tail section kit - Harley
Contents
1. connector 19 c License plate lamp connector 45 d Tail light connectors 93 4 See Figure 2 Remove two fasteners 12 securing trunk pan to center tail section J03972 5 Remove fasteners 4 securing left and right tail sections to center tail section 6 Remove center tail section from vehicle 7 To further disassemble center tail section refer to TAIL LAMP LICENSE PLATE LAMP ASSEMBLY and TURN SIGNALS in Service Manual ASSEMBLY 1 Install center tail section between left and right tail sec tions 2 See Figure 2 Install fasteners 4 securing left and right tail sections to center tail section but do not tighten 3 Install two fasteners 12 securing trunk pan to center tail section to 48 72 in Ibs 5 4 8 1 Nm 4 Apply Loctite 272 98618 03 to threads of left and right rear tail section fasteners 4 and tighten to 102 112 in Ibs 11 5 12 7 Nm 5 Tighten fasteners 12 securing trunk pan to center tail section to 48 72 in Ibs 5 4 8 1 Nm 6 See Figure 1 Connect the following components a Right turn signal connector 18 b Left turn signal connector 19 c License plate lamp connector 45 d Tail light connectors 93 WARNING Connect positive battery cable first If positive cable should contact ground with negative cable connected the resulting sparks can cause a battery explosion which could result in death or serious injury 00068a 7 Install battery by th2. ee yl SHEET Buell AMERICAN MOTORCYCLES J03972 REV 2006 01 16 LICENSE PLATE BRACKET AND TAIL SECTION KIT GENERAL Kit Number 50779 06Y Models This kit fits 2003 later XB9S and 2004 later XB12S models Additional Parts Required AWARNING The rider s safety depends upon the correct installation of this kit Use the appropriate service manual procedures If the procedure is not within your capabilities or you do not have the correct tools have a Harley Davidson dealer perform the installation Improper installation of this kit could result in death or serious injury 00333a NOTE This instruction sheet references Service Manual information A Service Manual for your model motorcycle is required for this installation and is available from a Harley Davidson dealer Kit Contents There are no Service Parts available with this kit DISASSEMBLY 1 Remove seat following the instructions in the Service Manual PINT N IN Disconnect negative battery cable first If positive cable should contact ground with negative cable con nected the resulting sparks can cause a battery explosion which could result in death or serious injury 00049a 2 See Figure 1 Unthread fastener and remove battery negative cable black from battery negative terminal Refer to BATTERY MAINTENANCE in Service Manual 3 Disconnect the following components a Right turn signal connector 18 b Left turn signal
3. ootrest support fastener no jam nut 2 10 Seat latch assembly 11 Trunk pan assembly 12 Rear trunk pan fastener to center tail section 2 13 Rear shock reservoir bracket 14 Plastic lugs for manufacturing purposes only P O NO Or ONS Figure 2 Tail Frame and Trunk Pan Assembly J03972 3 of 3
4. reading positive red cable into threaded hole first tightening to 72 96 in Ibs 8 11 Nm Refer to BATTERY MAINTENANCE in Service Manual WARNING After installing seat pull upward on seat to be sure it is locked in position While riding a loose seat can shift causing loss of control which could result in death or serious injury 00070b 8 Install seat following the instructions in the Service Manual 1of3 COMPONENTS is02461 Ci Ga MILWAUKEE Ss lll 1 Main harness 9 BAS bank angle sensor connector 134 2 Main harness ground wire GRD 2 10 Left turn signal connector 18 3 Battery ground cable 11 Right turn signal connector 19 4 Battery positive cable 12 License plate lamp connector 45 5 Rear brake light switch connector 121 13 Tail light connectors 93 6 Ground terminals GRD 1 and GRD 3 14 Left and right front trunk pan fasteners 2 7 ECM connectors 10 and 11 15 Left and right rear tail section fasteners 4 8 Fuse block and relay center Figure 1 Main Harness and Electrical Connectors Under Seat J03972 2of3 is02466 Left and right tail section fastener to main frame fuel tank assembly 4 Right tail section Center tail section Center tail section fastener to rear tail section 4 Left tail section Ground terminal fastener 2 Passenger footrest support fastener with jam nut 2 Front trunk pan fastener to side tail section 2 Passenger f
Download Pdf Manuals
Related Search