Suction Pump F-18 / F-36 F-20 / F-40
Contents
1. F 18 F 36 F 20 F 40 05 0006 Autoclavable 5 32 05 Single head 230 motor for F 18 p SP 32 01 Double head 230V motor 05 0055 Autoclavable set for F 36 5 sc d 05 00552 Disposable set 05 0005 Autoclavable 05 00052 Disposable 05 0015 1LT 05 0001 2LT 05 0002 1LT 2LT D2LT SP 16 01 SP 20 00 SP 38 05 N 09 000 SP 01 18 F 18 UPPER CASE SP 01 36 F 36 UPPER CASE SP 01 00 F 18 amp F 36 LOWER CASE Doc Service Manual F 18 36 20 40 Rev 1 del 20 SEP 2005 Page 7 di 12 FAZZINT Suction Pump Your Health is our aim F 18 F 36 F 20 F 40 yy Service Manual Legenda F 20 F 40 1 Filter 2 Vacuum drive 3 Jar drivetothefilter 4 Silicone tube to the patient 5 Jardrivetothe patient m Suction catheter 14 8 Vacuum regulator 9 Vacuum gauge Service Manual F 18 36 20 40 Rev 1 del 20 SEP 2005 Page 8 di 12 FAZZINT Suction Pump Your Health is our aim kW F 18 F 36 F 20 F 40 General assembly F 20 F 40 05 0006 Autoclavable 05 00062 Disposable 05 0015 05 0005 Autoclavable 05 00052 Disposable SP 32 05 Single head 230V motor for F 20 SP 32 01 Double head 230V motor for F 40 11 05 0001 21 05 0002 1LT D1LT 2LT D2LT p a SP 02 20 20 UPPER CASE SP 02 40 F 40 UPPER CASE 5P 02 002. FAZZINT Suction Pump y Your Health is our aim F 18 F 36 F 20 F 40 Service Manual NOTE This manual is related to the following Equipment Suction Pump F 18 F 36 F 20 F 40 Doc Service Manual F 18 36 20 40 Rev 1 del 20 SEP 2005 Page 1 di 12 Suction Pump Your Health is our aim F 18 F 36 F 20 F 40 Service Manual All medical device equipment and accessories should be in good working order prior to use It is the responsibility of each facility s engineering department to test equipments and routine basis to determine if medical devices are functioning within specifications No device or accessory should be used if a malfunction is suspected The installation operation search for breakdowns and the repair of equipment must only be performed by trained personnel who have sufficient knowledge about the equipment spare parts and the information supplied CAUTIONS BEFORE STARTING TO INSPECT THE DEVICE MAKE SURE IT IS NOT CONNECTED TO THE ELECTRIC POWER SUPPLY NETWORK DO NOT USE THE APPLIANCE IN THE PRESENCE OF INFLAMMABLE AND OR EXPLOSIVE LIQUIDS GASES OR MIXTURES DO NOT LEAVE THE APPLIANCE EXPOSED TO ATMOSPHERIC AGENTS OR HEAT SOURCES USING THE APPLIANCE UNDER DIFFERENT CONDITIONS THAN THOSE SPECIFIED IN THIS HANDBOOK MAY PREJUDICE ITS SAFETY AND ITS TECHNICAL PARAMETERS An educated qualified person has sufficient knowledge or experience to allow him to avoi
3. F 20 amp F 40 LOWER CASE Doc Service Manual F 18 36 20 40 Rev 1 del 20 SEP 2005 Page 9 di 12 FAZZINT Suction Pump Your Health is our aim F 18 F 36 F 20 F 40 yy Service Manual Functional layout Feeding wire Blue Feeding wire Brown Feeding wire Blue Feeding wire Brown UJ IEC double pole switch EC Power inlets AUN 09 I 74 Feeding 50 60 Hz Doc Service Manual F 18 36 20 40 Rev 1 del 20 SEP 2005 Page 10 di 12 FAZZINT Suction Pump y Your Health is our aim F 18 F 36 F 20 F 40 Service Manual Pneumatic circuit m 1 Catheter to the patient 2 Suction regulator 3 Jar 1 O 4 Non rebeathing valve 5 Filter A ww 6 Pump Motor Doc Service Manual F 18 36 20 40 Rev 1 del 20 SEP 2005 Page 11 di 12 r y y FAZZINI Your Health is our aim Suction Pump F 18 F 36 F 20 F 40 Service Manual Correcting Malfunctions Situation Possible Cause Solution a b Equipment will 1 C not turn on d e EN E 2 Suction fault Disconnected or loose cord Faulty wall outlet Fuses are damaged Main rocker switch is damaged I nternal wiring connection are not completed Vacuum r
4. THE OTHER END OF THE LONG TUBE 4 THE PROBE CONNECTOR 6 AND EVENTUALLY THE SUPPLIED PROBE 6 PLUG IN THE POWER CORD TO THE MAIN BUT ONLY AFTER CHECKING THE VOLTAGE IS THE ONE INDICATED BY THE LABEL IN THE BACK OF THE EQUIPMENT 7 PRESS THE ON OFF SWITCH 7 8 ASPIRATION INTENSITY CAN BE VARIED WITH THE RELEVANT CONTROL ON THE FRONT PANEL OF THE APPLIANCE 8 AND CAN BE CHECKED ON THE APPLIANCE FRONT PANEL 9 VACUOMETER 9 IT IS RECOMMENDED TO CARRY OUT A FIRST ASPIRATION CYCLE WITH AT LEAST 500 ML OF WATER ONLY 10 THE ASPIRATED FLUID WILL FLOW IN THE RELEVANT JAR SHOULD THE AMOUNT OF FLUID EXCEED THE JAR S CAPACITY THE OVERFLOW VALVE WILL STOP ASPIRATI ON 11 MMEDIATELY SWITCH OFF THE APPLIANCE BY SETTING THE ON OFF 7 SWITCH ON THE OFF POSITION THE MANUFACTURER ASSEMBLER INSTALLER OR IMPORTER ARE HELD LIABLE FOR THE SAFETY PERFORMANCE AND RELIABILITY OF THE APPLIANCE ONLY IF THE ELECTRIC SYSTEM TO WHICH THE APPLIANCE IS CONNECTED COMPLI ES WITH L D 46 90 ACCESSORIES INCLUDED CODE N DESCRIPTION 05 0001 JAR 1000 ML 05 00552 SET OF TUBES 05 0010 ASPIRATION PROBE CH 14 DISPOSABLE 05 0015 ANTI BACTERIAL HYDROPHOBIC FILTER DISPOSABLE SHOULD ACCESSORIES BE USED OTHER THAN THOSE SUPPLIED BY FAZZINI S R L YOU MUST MAKE SURE THAT THEY HAVE THE SAME CHARACTERISTICS AS THE ORIGINAL ONES NOTE THE SUPPLIED JARS ARE NOT MEANT TO BE USED AS MEASURERS AND PROVIDE ONLY AN INDICATION OF THE CONTAINED QUANTITY OPERATI ONAL STEP
5. BOOK MAY PREJUDICE ITS SAFETY AND ITS TECHNICAL PARAMETERS TECHNICAL DATA F 40 XX MODEL LENGTH WIDTH HEIGHT F 18 XX 260 MM 180 MM 220 MM F 36 XX 260 MM 180 MM 220 MM F 20 XX 350 MM 210 MM 250 MM 4 0 KG 350 MM 210 MM 250 MM 4 5 KG 3 9 KG 230V 50 60Hz 3 4 KG 230V 50 60Hz WEIGHT POWER SUPPLY 230V 50 60Hz 230V 50 60Hz MAX ASPIRATION 0 75 BAR 0 75 BAR 0 75 BAR 0 75 BAR FLOW WITH FILTER 11 L MIN 16 L MIN 11 L MIN 16 L MIN DIRECT MEASUREMENT ON ASPIRATION VENT 18 LT MIN 36 LT MIN 18 LT MIN 36 LT MIN 1 X 1 6A 250V 1 X 1 6A 250V 1 X 1 6A 250V 1 X 1 6A 250V FUSE Doc Service Manual F 18 36 20 40 Rev 1 del 20 SEP 2005 Page 3 di 12 di d FAZZINI Suction Pump Your Health is our aim F 18 F 36 F 20 F 40 Service Manual OPERATI NG THE APPLIANCE IS A PORTABLE ASPIRATOR FOR USE IN MINOR SURGERY AND AI MED AT FREEING THE AIRWAYS FROM ORGANIC SECRETIONS OPERATIONAL TEMPERATURE BETWEEN 0 AND 50 OPERATI ONAL HUMI DI TY BETWEEN 20 AND 90 RU BEYOND 2500 METERS OF HEIGHT THE ASPIRATION FLOW MAY DECREASE 1 TIGHTLY SCREW THE LID ON THE JAR TO GUARANTEE A PERFECT SEAL 2 CONNECT THE SHORT TUBE TO FILTER 1 ON THE ASPIRATION 2 VENT 3 CONNECT THE OTHER END OF THE TUBE TO THE VACUUM 3 VENT WITH THE FLOAT ON THE JAR S LID 4 CONNECT THE LONG TUBE 4 TO THE OTHER PATIENT 5 VENT ON THE JAR S LID VENT WITHOUT FLOAT 5 CONNECT
6. S AT THE END OF THE PROCEDURE NOTE ALWAYS USE INDIVIDUAL PROTECTI ON DEVICES EX LATTICE GLOVES EVERY TIME YOU MAY GET IN CONTACT WITH POTENTIALLY CONTAMINATED PARTS DISCONNECT DISPOSABLE PARTS AND DISPOSE OF THEM CHECK THE GENERAL INTEGRITY OF THE ASPIRATOR CARRY OUT THE FOLLOWI NG CLEANING OPERATI ONS ASPIRATION TUBES SHOULD BE STERILIZED AFTER EACH USE THE FILTER ON THE APPLIANCE IS DISPOSABLE THEREFORE IT IS NECESSARY TO REPLACE IT AFTER EVERY USE DO NOT USE THE ASPIRATOR WITHOUT A FILTER JAR CLEANI NG THE FLUID COLLECTI ON JAR CAN BE AUTOCLAVED AT A TEMPERATURE NOT EXCEEDI NG 1219C OTHERWISE THE JAR CAN BE DISINFECTED WITH DENATURED ALCOHOL OR A HYPO CHLORITE BASED SOLUTION THAT CAN BE EASILY FOUND IN PHARMACI ES MAXIMUM REUSE LIMIT 30 CYCLES Doc Service Manual F 18 36 20 40 Rev 1 del 20 SEP 2005 Page 4 di 12 Suction Pump Your Health is our aim F 18 F 36 F 20 F 40 Service Manual HOW TO CLEAN THE APPLI ANCE DISCONNECT THE APPLIANCE FROM THE ELECTRIC SUPPLY NETWORK AND THEN CLEAN IT WITH A SOFT CLOTH WETTED WITH NON ABRASIVE DETERGENTS PERIODIC MAINTENANCE CHECK ASPIRATOR WAS DESIGNED TO KEEP MAINTENANCE TO A MINIMUM NEVERTHELESS IT 15 NECESSARY TO CARRY OUT A DAILY CHECK BEFORE USING THE APPLIANCE BEFORE CARRYING OUT ANY CHECK DUE TO MALFUNCTIONING OR ANOMALIES CALL THE FAZZINI S R L TECHNICAL SERVICE OR PERSONNEL QUALIFIED BY FAZZINI S R L FAZZINI S R L DOES NOT OFFER ANY WARRANTY ON APPLIANCE
7. THAT UPON INSPECTION BY THE TECHNICAL SERVICE SHOWS SIGNS OF TAMPERING THE OPERATOR MUST EXCLUSIVELY REPLACE THE SUPPLIED ACCESSORIES IF NECESSARY IN LINE WITH THE APPLIANCE S USE INTENSITY ASPIRATION TUBES SHOULD BE STERILIZED AFTER EACH USE IN CASE OF REPAIR THE USER SHOULD CALL FAZZINI S R L TRANSPORTATION COSTS MUST ALWAYS BE AGREED WITH FAZZINI S R L BEFORE SHIPPING FAILED PIECES SHOULD ANY FLUID LEAK IN THE APPLIANCE CALL THE TECHNICAL SERVICE OF FAZZINI S R L FOR MAINTENANCE DO NOT OPEN THE UNIT STORAGE THE ASPIRATOR MUST BE STORED IN A DRY LOCATION PROTECTED FROM ATMOSPHERIC AGENTS STORAGE TEMPERATURE BETWEEN 10 AND 55 RELATIVE HUMIDITY BETWEEN 20 AND 80 DISPOSAL WITH REFERENCE TO THE DISPOSAL OF THE APPLIANCE ITS ACCESSORIES AND ITS SINGLE USE DISPOSABLE PARTS PLEASE SEE CURRENT WASTE DISPOSAL REGULATIONS Doc Service Manual F 18 36 20 40 Rev 1 del 20 SEP 2005 Page 5 di 12 FAZZINT Suction Pump Your Health is our aim F 18 F 36 F 20 F 40 yy Service Manual Legenda F 18 F 36 2 Vacuumdrive 3 drivetothefilter 4 Silicone tube to the patient 5 Jardrivetothe patient 6 Suction catheter CH 14 7 Mainswitch 8 Vacuum regulator 9 Vacuum gauge Doc Service Manual F 18 36 20 40 Rev 1 del 20 SEP 2005 Page 6 di 12 p EAGZENE Suction Pump F y Your Health is our aim General assembly F 18 F 36
8. d the dangers presented by electricity whereas an informed trained person is sufficiently informed or works supervised by qualified persons so as to allow him to avoid the dangers presented by electricity e g operators or maintenance staff Doc Service Manual F 18 36 20 40 Rev 1 del 20 SEP 2005 Page 2 di 12 Suction Pump F 18 F 36 F 20 F 40 Service Manual Your Health is our aim WARNINGS BEFORE USING THE APPLIANCE READ THE HANDBOOK WARNINGS THE APPLIANCE MUST BE USED BY QUALIFIED PERSONNEL WARNINGS DO NOT OPEN THIS DEVICE FOR ANY REASON PLEASE CONTACT THE FAZZINI S R L TECHNICAL DIVISION FOR ANY PROBLEM SHOULD ARISE CAUTIONS CAREFULLY FOLLOW THE GUIDELINES WHEN USING THE APPLIANCE DO NOT HANDLE THE APPLIANCE WITH WET OR MOIST HANDS DO NOT HANDLE THE PLUG WITH WET OR MOIST HANDS DO NOT USE THE APPLIANCE UNDER THE SHOWER OR IN THE BATHTUB DO NOT DIP THE APPLIANCE UNDER WATER DO NOT USE THE APPLIANCE IN THE PRESENCE OF INFLAMMABLE AND OR EXPLOSIVE LIQUIDS GASES OR MIXTURES DO NOT LEAVE THE APPLIANCE EXPOSED TO ATMOSPHERIC AGENTS OR HEAT SOURCES DO NOT LET CHILDREN OR INCAPABLE PERSONS USE THE APPLIANCE WITHOUT THE NECESSARY SUPERVISION BEFORE STARTING TO CLEAN THE DEVICE MAKE SURE IT IS NOT CONNECTED TO THE ELECTRIC POWER SUPPLY NETWORK DO NOT USE THE APPLIANCE FOR AIMS OTHER THAN THOSE FORESEEN BY THE MANUFACTURER USING THE APPLIANCE UNDER DIFFERENT CONDITIONS THAN THOSE SPECIFIED IN THIS HAND
9. egulator do not work properly I nternal tubing are not properly connected I nternal tubing are choked Pump fault Doc Service Manual F 18 36 20 40 Rev 1 del 20 SEP 2005 Page 12 di 12 Check connections and reconnect unit Use another wall outlet Check the fuses inside SP 38 02 If fuses are damaged check the electrical insulation on the electrical apparatus I n ON position check the presence of the light if no light is detected replace with a spare switch Open the equipment and verify internal electrical wiring see functional layout Turn the manifold SP 21 Open the equipment and verify internal tubing connection Open the equipment and verify internal tubing bends Open the equipment disconnect the tubing and check the pump
Download Pdf Manuals
Related Search