Instruction guide Likorall 242/243/250 - www.liko.com - Hill-Rom
Contents
1. Type B in accordance with the electrical shock protection class Likorall is equipped with a SFS Single Fault Safety safety drum This patented safety design provides protection against uncontrolled lowering The lift strap has a tenfold safety Likorall 242 243 250 7EN12011 5 rev 6 3 www liko com Measurements C s 1 i ry Lateral view i a CSP Central Suspension Point x y y 5 A G 1 ep ete Overhead view 5 y L J Measurements in mm A B C D H Ee 165 340 250 293 210 335 2050 models 242 R2R 243 250 models 242 Measurements in inch A B C D H iia 6 49 13 38 9 84 11 53 8 67 13 18 80 7 models 242 R2R 243 250 models 242 Minimum distance from ceiling to CSP at maximun lifting height Built in dimension the distance between the attachment point for the lift unit on the carriage and the CSP at maximum lifting height Lifting interval the distance between maximum lifting height and minimum lifting height measured in CSP Assembly a N Handle reinforcement exclusively Likorall 242 S ES Press the reinforcement included in the bag containing the instruction guide labelled Emergency lowering onto the emergency lowering handle i Pi Operation N HandContro2. IR receiver exclusively ES 9 SSP Limit Switch a4 10 Strap stop exclusively Likorall 242 ae 11 Movable strap stop exclusively Likorall 242 lt 12 Hang up HandControl Hanger 13 Mechanical emergency lowering exclusively Likorall 242 14 Latches _ 15 Hand control with wire 18 46 Q link not at Likorall 242 S Technical Data Maximum Likorall 242 200 kg 440 Ibs load Likorall 243 230 kg 507 Ibs Likorall 250 250 kg 550 Ibs Batteries 2 x 12 V 2 4 Ah 2 6 Ah Valve regulated lead acid gel type batteries New batteries are provided by the supplier Battery SMP CC 10 43 24 charger 40 60 Hz max 600 IRC In Rail Charging CHO1 FW7218M 24 100 240 V AC 50 60 Hz max 500 mA Lifting speed 50 mm s 2 inch s 100 240 V AC mA Lifting 2050 mm 80 7 inch interval 242 vertically adjustable Electrical data 24V 12A Lift motor Likorall 242 weight Likorall 242 R2R Likorall 243 Likorall 250 13 0 kg 28 6 lbs 13 2 kg 29 Ibs 12 6 kg 27 7 lbs 12 6 kg 27 7 lbs Emergency Mechanical Likorall 242 lowering device Electrical Likorall 242 R2R Likorall 243 Likorall 250 Intermittent Int Op 10 90 active operation operation max 0 5 min Sound level 49 dB Protection class P 43 Protection class hand control IP 43 Operating forces of controls 5N Ambient Min 10 C Max 40 C temperature Min 50 F Max 104 F lt 3 Intended for indoor use
3. OP lt a A Electrical emergency lowering Carriages with adjustable friction brake Hang up HandControl Emergency lower by pushing The amount of drag along the rail can be Hanger in the button on the end cover adjusted on carriages equipped with a When not in use the hand of the lift Always ensure that the friction brake Turn the brake clockwise control can be hung on emergency lowering is made to for increased resistance and counter the Hang up Hand control a bed wheelchair or other suitable clockwise to reduce resistance hanger location The following carriages have a friction brake prod no 3126011 and 3126015 XN J SSP Limit Switch The lifting motion is stopped electrically with a light touch on the SSP Limit Switch from for instance the strap stops Q link or if the lift strap is subjected to harmful strain for example if it is pulled sideways or folded over during the lifting motion If the SSP Limit Switch is activated so that the lifting motion stops the lift can once again be operated after the lift strap is straight again a short delay in the lifting motion is normal in these cases The SSP Limit Switch protects the lift motor from mechanical strain and it also prevents squeeze injurie Ensure that the lift strap is kept straight and stretched when it runs in and out of the lift motor C J Y a J Indication chargin
4. your Liko Hill Rom product in the document Care and Maintenance at our website www liko com A The lift should not be exposed to running water Service Likorall should be periodically inspected at least once a year A Periodic inspection repair and maintenance should be performed only in accordance with the Liko Service Manual and by personnel authorized by Liko and using original Liko spare parts Service Agreement Liko offers the opportunity to enter into service contracts for the maintenance and periodic inspection of your Liko products Expected Life Time The product has an expected life time of 10 years when correctly handled serviced and periodically inspected in accordance with Liko s instructions Transport and Storage During transportation or when the lift is not to be used for a long time the emergency stop should be engaged The environment where the lift is transported and stored should have a temperature of 10 40 C 50 104 F and a relative humidity of 30 to 75 The air pressure should be 700 1060 hPa Recycling For instructions on how to recycle your Liko product please visit our website www liko com Product Changes Liko s products undergo continuous development which is why we reserve the right to make product changes without prior notice Contact your Liko Hill Rom representative for advice and information about product upgrades Design and Quality by Liko in Sweden Hill Rom s Manag
5. atches are intact missing or damaged latches must always be replaced e the sling s strap loops are correctly connected to the sling bar hooks when the sling straps are extended but before the patient is lifted from the underlying surface A Never leave a patient unattended during a lifting situation C Intertek Likorall have been tested by accredited testing institutes and comply with the requirements for MDD Class 1 products MDD 93 42 EEC Likorall complies with the requirements in EN ISO 10535 2006 IEC 60601 1 IEC 60601 1 2 ANSI AAMI ES60601 1 and CAN CSA C22 2 no 60601 1 A under no circumstances must the lift be modified If you have any questions please contact Liko Hill Rom Particular care must be observed when using strong sources of electromagnetic disturbance such as diathermy etc so that diathermy cables are not positioned on or near the lift If you have questions please consult the responsible assistive device technician or the supplier The lift may not be used in areas where flammable mixtures may occur for example in areas where flammable goods are stored Likorall 242 243 250 7EN120115 rev 6 2 www liko com Definitions g Likorall PEN 1 Connection hand control Z 2 Indication charging 2 3 End cover 2 4 Emergency stop AQ 5 Emergency stop cord D 6 Emergency lowering raising electrical AD 7 Outlet for transfer motor contact rail exclusively ES 8
6. bag Max load 300 kg 660 Ibs Sling Cross bar 450 with Quick release Hook Prod no 3156022 Fixed connection prod no 3156021 Max load 300 kg 660 Ibs Sling Cross bar 670 with Quick release Hook Prod no 3156019 Fixed connection prod no 315601 8 Max load 300 kg 660 Ibs Sling bars with fixed connection can be equipped with Quick release Hook Quick Release Hook Liko s Quick release Hooks are a system for quick change of lifting accessories on Liko s mobile and stationary lifts equipped with the Q link The Quick release Hook can be installed on lifting accessories with a fixed connection mulek iea a niversa The Quick release Hook Universal fits the Universal SlingBar 350 450 and 600 Prod No 3156508 prod no 3156074 3156076 Quick release Hook TDM fits the SlingBar Mini 220 prod no 3156005 Sling Cross bar 450 and 670 prod no 3156021 and 3156018 and Universal TwinBar 670 prod no 3156077 See the Guide to Liko s Quick release Hook System which can be downloaded from our website www liko com or contact Liko Hill Rom for more information bi Hook i about the advantages and uses of the Quick release Hook system Prod No 3156502 gt Likorall 242 243 250 7EN120115 rev 6 9 www liko com Stretcher All stretchers in Liko s product range can be used with Likorall Contact Liko Hill Rom for further information Scale For weighing persons in combination with the Likora
7. ch Developed for users patients who have reduced strength or movement of the hand Easy to install on the hand control 2 button 4 button Fits Likorall hand controls prod no 3126034 3126035 and 3126036 Likorall 242 243 250 7EN120115 rev 6 10 Prod Prod Prod Prod Prod Prod Prod Prod Prod Prod no no no no no no no no no no 3156025 3607001 3156100 3126111 3126044 3126060 3126008 3126009 3107010 3107011 LikoScale 350 Prod No 3156228 www liko com Parking Panel 600 LR MR Parking Panel 1500 LR MR Can be completed with the following accessories Hook for SlingBar Hook for Accessories Bracket for Charger Quick Reference Guide see respective product Prod Prod Prod Prod Prod no 3126075 sr no 3126080 Jis no 3126070 no 3126071 no 3126100 Simple Troubleshooting The lift doesn t work A repeated signal can be heard from the lift The lift stops in the high position The lift does not achieve maximum lifting capacity In event of unusual sounds or any leakage from the lift Likorall 242 243 250 7EN120115 rev 6 gt 11 Check to ensure that the emergency stop button is not pressed in Check that the hand control is correctly connected Charge the battery If the lift still does not work properly please
8. contact Liko Hill Rom Charge the battery immediately If the lift still does not work properly please contact Liko Hill Rom N Check to ensure that the emergency stop button is not pressed in Check that the hand control is correctly connected Use the selected mechanical or electrical emergency lowering device to lower the patient onto a firm surface Charge the battery If the lift still does not work properly please contact Liko Hill Rom va Charge the battery If the lift still does not work properly please contact Liko Hill Rom Please contact Liko Hill Rom www liko com Inspection and Maintenance Care and Maintenance For trouble free operation certain details should be checked each day the lift is used e Inspect the lift and check to make sure that there is no external damage e Check the sling bar attachment e Check the lift strap for wear and to ensure the strap is not twisted e Check the functionality of the latches e Check the operation of the lift movement e Check to make sure that the emergency lowering functions correctly e Check that the mechanical emergency lowering functions and that the lifting height is set correctly e Charge the batteries each day the lift is used and check to ensure that the charger works When necessary clean the lift with a moist cloth Find more detailed information regarding cleaning and disinfection of
9. d Liko A D Company Likorall 242 Likorall 242 R2R Likorall 242 243 250 Instruction Guide English 7EN120115 rev 6 2013 11 07 Applies to the following models Prod no 3122009 3122010 Prod no 3122005 3122006 Prod no 3122011 3122012 Prod no 3122007 3122008 Prod no 3123001 3123002 Prod no 3122501 3122502 Prod no 3124050 Likorall 242 S Likorall 242 ES Likorall 242 S R2R Likorall 242 ES R2R Likorall 243 ES Likorall 250 ES Likorall 250 S IRC Product Description Likorall is one of the world s most popular overhead lift motors Likorall is designed and developed for Liko s complete range of fixed installed and free standing lift systems A Liko lift system is always close at hand and easy to use All common lifts and transfers can be performed using Likorall for instance between bed wheelchair to from floor toilet visits gait training and together with stretchers Likorall R2R room to room enables the patient to be moved between two rail systems in separate rooms without connecting rails and without making holes over doors Likorall with the ES designation is prepared for operation with the wireless HandControl Remote IR and in addition a Transfer Motor can be connected for motor driven movement of Likorall ES along the rail Likorall S IRC is prepared for continuous charging through the railsystem by Liko s In Rail charging system IRC Accessories A large and compl
10. ected to the electrical grid 5 The charging starts automatically and a yellow LED indicates that the batteries are charging Green 6 When the battery is fully charged the charger shuts off tore automatically and the yellow LED turns off en Please read the manual before use Battery is charging when yellow led is lit Prod No 3126101 3126104 A The AC connector of the Va charger unit must be easy accessible to the operator NX x lt E AC is connected when green led is lit Alternative charging procedure In Rail Charging Liko s In Rail Charging system is an easy to use charging system When using the In Rail Charging system the lift will charge continously During active lifting the In Rail Charging system will pause and re activate charging automatically after completed operation Indications from IRC Agreen LED light on the lift indicate that the lift is ready to use A yellow LED light on the lift indicate that the lift has low battery capacity contact Liko if the problem persist For more information please contact your Liko reprecentative or visit our website www liko com MultiStation As an alternative to charging via the hand control il the batteries can be charged with a MultiStation installed 2 on the rail system In this case Likorall must be equipped with a contact rail or a transfer motor The Likorall l G batteri
11. ement system are certified in accordance with ISO 9001 and its equivalent for the medical device industry ISO 13485 Hill Rom s Management system is also certified in accordance with environmental standard ISO 14001 A Liko A CED company www liko com Manufacturer Liko AB Nedre vagen 100 SE 975 92 Lulea Sweden info liko se Copyright Liko AB 2013 11
12. es are then charged by parking the lift in the E JAN Ai charging position under the MultiStation see figure A This charging procedure is also suitable when Likorall is operated by HandControl IR Prod No 3126110 Ne S Old batteries are to be deposited at the nearest recycling facility in accordance with local regulations or K Likorall comply with the Directive 2002 96 EC on waste electrical and electronic equipment given to personnel authorized by Liko Hill Rom Likorall 242 243 250 7EN120115 rev 6 7 www liko com Transferring from room to room Liko s R2R Room to Room system is an effective solution for safe and easy transfer of patients between two or more rooms The R2R system is mounted without making openings in walls over doors and full isolation is therefore retained between the rooms supported by the system The transfer is performed in a safe and easy manner with the aid of separate rail systems for each room Liko s R2R system enables linking together two Likorall when transferring from room to room The actual transfer operation between two rooms is performed with a comfortable transition for the patient from one Likorall to another S Lift 2 J Mounting Universal SlingBar R2R Room to Room 1 Move Lift 1 with the patient as close to the door way The Universal SlingBar R2R has a double ho
13. ete range of accessories are available for Likorall including many different sling models in several sizes and designs In this document the person being lifted is referred to as the patient and the person helping is referred to as the caregiver Aisa warning triangle used for situations which require extra care and attention C IMPORTANT Read the instruction guide for both the patient lift and lifting accessories before use Lifting and transferring a person always involves a certain level of risk It is important to completely understand the contents of the instruction guides The equipment should be used only by trained personnel Please contact your Liko Hill Rom representative in the event of any uncertainties or questions Table of Contents Safety IMStMUCHONS soriire ean eaa EEEE E isin ebeeevetaaeeseevtencs 2 Bae o E E E A A A hee E T 3 piena es DE Ei E E A E E a E E E E 3 Measurements cciosiieeieriei eisat aeina EEKEREN NEE AAEE EEE 4 Asse mMDIY rss reteabves etapie eana ced uted eased eN a tet Bias 4 OPS VA OM ae iniia aana besten haaandes chteeve tei later aa Sa 4 Charging the Batteries iissccsccecssacectbeisiccecrsietancev n EEEE f Transferring from room tO r0OM ssseessssssssssrreesssnnnnnrnnnnnnnnnnnnnnnnnnnnnnnnnannnnnnnnnnnnna 8 Maximum LOaren A ET 9 Recommended Lifting ACCESSOLICS saiisine snada 9 Simple Troubleshooting 0 0 00 eeceeceeeeeeeeeee cesta eee eeeeaeeeeeeeaaeeeeeeeaeeeeeeeaaeeeeneeaa 11 Inspec
14. g A Never move the lift by Installation of Latches Likorall indicates in two ways that the pulling the hand control After installation check that the latch locks and runs freely in the battery needs charging ina bay hook sling bar hook e Buzzer sounds when lifting e LED A flashes red when lifting When either of these signals sounds or illuminates the lift should be charged as soon as possible See Charging the batteries page 7 Likorall 242 243 250 7EN120115 rev 6 6 www liko com Charging the Batteries In order to ensure maximum battery life it is important to charge the batteries regularly We recommend that you charge the batteries after use or every night Full charge is achieved after max 8 hours Fully charged batteries will last for approximately 60 lift cycles The lift cannot be charged with the emergency stop engaged NOTE If the lift will not be used for a longer period of time a charging system should be activated to allow the battery to charge or the emergency stop button should be pressed in order to prevent the battery from discharging A Likorall has several charging systems these systems must never be activated parallelly Charging via hand control a gt 1 Check that the emergency stop button is not pressed E 2 Place the hand control in the charger s socket 3 Connect the charger to a 100 240 V AC electric socket 4 Agreen LED illuminates to indicate that the charger is conn
15. l i ft i fi Remote IR Button functions a O Lifting movement Up Down E oo joe Movement direction Transfer motor 2 Control Switch system liko Like QLiko 2liko Fits Likorall All ES ES ES ES J Hand Control Likorall Likorall is operated with a light push on the buttons of the hand control The arrow directions should be the same as the direction shown in the illustration The movement ceases when the button is released For the Likorall ES there is a number of hand controls to choose from depending on how the lift and rail system are equipped and an IR hand control for wireless operation If needed the lifting motion can also be controlled without hand control via the buttons and respectively on the end cover of the lift see page 6 Likorall 242 243 250 7EN120115 rev 6 4 www liko com Activate G Emergency stop For emergency stop pull the red emergency stop cord To reset turn the button in the direction of the arrows The red cord on the lift motor s end cover is intended for use if an emergency situation occurs Q link Quick Release Hook Lifting accessory with quick release hook Likorall 242 R2R 243 ES 250 ES A Before lifting check that Push down the red catch and connect the quick release hook to the Q link Release the Quick release Hook is and check that the catch locks in order to
16. ll we recommend LikoScale 350 This can easily be installed with the LikoScale Adapter Kit Please contact Liko Hill Rom for more information Liko Support Springs for bounce and gait training Is used in order to produce a softer springy motion during gait training The springs are available in two sizes short prod no 3156512 and long prod no 3156511 These springs are intended for patient weights up to 70 kg 154 Ibs For patient weights up to 100 kg 220 Ibs prod no 3156513 short Also see the instruction guide for Liko MasterVest models 60 and 64 or Liko LiftPants model 92 for more information Liko Bathing Chair Contact Liko Hill Rom for further information SlingBar Cover Paddy 30 Fits Universal SlingBars 350 450 and 600 as well as SlingBar Slim 350 Hang up HandControl Hanger Sold in set of 10 pcs Multi Connector Intended for installation on Likorall for control of switches and or if the rail system is equipped with a MultiStation for charging via the rail Transfer motor Likorall ES Fits Likorall with ES designation Max 250 kg 550 Ibs HandControl Remote IR Likorall with ES designation can be equipped with a wireless hand control IR The hand control operates normally within a range of 0 5 meters 0 196 inch from the lift Quick Release Carriage LR Fits the Quick release Adapter LR prod no 3126009 Quick Release Adapter LR Fits Quick Release Carriage LR prod no 3126008 Easy Swit
17. ll Rom representative if you have any questions Recommended Lifting Accessories A Using lifting accessories other than those approved can entail a risk The Liko assortment contains many sling bars slings stretchers scales and other accessories to solve most lifting needs Below is a list of lifting accessories suitable for Likorall To select suitable slings and other lifting accessories please see the Lifting accessories brochure For additional guidance in selecting a sling study the instruction guide for the respective sling models Here you will also find guidance for combining Liko s sling bars with Liko s slings Contact yourLiko Hill Rom representative or visit www liko com for advice and information on Liko s product range SlingBar Mini 220 Prod no 3156005 i Max load 205 kg 450 Ibs Universal SlingBar 350 with Quick release Hook Prod no 3156084 Cr Fixed connection prod no 3156074 Max load 300 kg 660 Ibs ea Universal SlingBar 450 with Quick release Hook Prod no 3156085 EA Fixed connection prod no 3156075 Max load 300 kg 660 Ibs E oo 4 Universal SlingBar 600 with Quick release Hook Prod no 3156088 Fixed connection prod no 3156076 Max load 300 kg 660 Ibs Lp Universal SlingBar 670 Twin with Quick release Hook Prod no 3156087 f Fixed connection prod no 3156077 Max load 300 kg 660 Ibs Universal SideBars 450 Prod no 3156079 including
18. ok with as possible Lower the lift as far as possible bearing Quick release The double hook has protection against in mind the patient s comfort unintentional detachment a N Lift 2 gt Lift 2 J 2 Move Lift 2 as close to the door opening as possible 3 Raise Lift 2 The patient is successively moved Lower the lift strap from Lift 2 a sufficient length to the next room and finally suspended in Lift 2 and connect the Q link to the Universal SlingBar R2R only When the pressure is relieved from the lift Check that the safety latches on the R2R connector strap for Lift 1 disconnect the lift strap from function properly the Universal SlingBar R2R and the transfer can be carried out in the next room NOTE To free the Q link from the Universal SlingBar R2R it may be necessary to let out additional strap from Lift 1 Likorall 242 243 250 7EN120115 rev 6 8 www liko com Maximum Load Different maximum loads may apply to different products on the assembled lift system lift sling bar sling and any other accessories used For the assembled lift system the maximum load is always the lowest maximum load rating for any of the components For example a Likorall which is approved for 200 kg 440 Ibs can be equipped with a sling bar which is approved for 300 kg 660 Ibs In this case the maximum load of 200 kg 440 Ibs applies to the assembled lift system Study the markings on the lift and lifting accessories or contact your Liko Hi
19. prevent involuntary unhooking from the correctly attached to the Q link Read more about Liko s Quick release Hook system on page 9 Q link see illustration above g N Figure 1 Figure 2 Me Lift correctly Mechanical emergency lowering Likorall 242 S ES Before each lift make sure that 1 Move the emergency lowering handle up and down the Sling loops at opposite sides of the Sling until the patient has been lowered and the lift strap are at the same height is completely slack Always ensure that the all the Sling loops are fastened securely in to emergency lowering is made to a bed wheelchair the Sling bar hooks or other suitable location the Sling bar is level during the lift see Figure 1 2 After mechanical emergency lowering has been i performed resetting adjustment of the lifting height is Alt Sling bar is not level see Figure 2 lower required the user to a firm surface and adjust according to the Sling in use Instruction Guide A An improper lift can be uncomfortable for the user and cause damage to the lift equipment see Figure 2 Lower the sling bar so that the lift strap is completely slack Hold down the emergency lowering handle halfway Simultaneously tighten the lift strap by turning the black wheel counter clockwise with the other hand Repeat until the desired height has been achieved Likorall 242 243 250 7EN120115 rev 6 5 www liko com g obeo
20. tion and Maintenance ceccecceeceececeeeeeeeeeeeeeeceeeaecaeeeeeeeeeeeeeeeeenaes 12 NOTE This instruction guide contains important information for users of the product All those who use the product should review and fully understand the contents of the instruction guide Remember to keep the instruction guide in a place where it is always available to those using the product Safety Instructions A Installation of Likorall to carriages shall be made by personnel authorized by Liko in accordance with the installation instructions and recommendations for the current lift system Before using the lift the first time make sure that Before lifting always ensure that e the lifting accessories are properly attached to the lift the lift strap is not twisted or worn and can move in and e the batteries have been charged for at least 8 hours outor ne HEISely you have read the instruction guide for the lift and he iMingaccessores are not damaged lifting accessories e the lifting accessory is correctly and securely applied to e personnel using the lift are informed of the correct the patient in order to prevent injuries use of the lift and lifting accessories e the lifting accessories are properly attached to the lift the lifting accessory is selected appropriately in e the lifting accessories hang vertically and can move terms of type size material and design with regard freely to the patient s needs e the sling bar l
Download Pdf Manuals
Related Search