BDV Service Manual - Mass General Biomed
Contents
1. oBDV BLACK DIAMOND VIDEO Service Manual Connection Guide Integrated Digital Surgical Suite Prepared by Matthew Gonsalves Client Massachusetts General Hospital GI Rev 1 0 February 2012 1 Page Service Manual Connection Guide Integrated Digital Surgical Suite Client Massachusetts General Hospital Edition 1 0 February 2012 The Black Diamond Video logo and IDSS are registered trademarks of Black Diamond Video Inc The information contained herein is subject to change without notice All warranties associated with Black Diamond Video products and services are set forth in the warranty statements accompanying such products and services Actions taken based upon the contents of this document should not be construed as constituting an additional warranty Black Diamond Video shall not be liable for errors technical or editorial contained herein For technical support and service contact Black Diamond Video at Black Diamond Video 503 Canal Boulevard Point Richmond California 94804 Phone 510 439 4500 Fax 510 439 4599 Visit us on the web at www blackdiamondvideo com 2 Page Contents OSS RACK ET EE 4 ospital PC Video MRE CT ALON DEE 5 PTOVALION PC UIC CEl Age EE 6 TOUCH Sereen E E E 7 Server Device Communlcations 8 OR Camera NESE CaO EE 9 Picturec and VIC CO CADE Di 10 Audio Matrix Connections s sessssssseersssserrssssreeresssereressssseeresssseereossserressssseesssseeeeesss2. 7 14 21 28 35 42 49 5 Coarse Gain 7 14 21 28 35 42 49 Pod Figure 9 Audio Mixer Configurations via Interact Software 12 Page K Windowing Video Sources Image processing for multi source windowing occurs at the output end of the CXPS router The constructed windowed image is then feed back into an input of the CXPS where it can then be routed to any chosen destination CXPS output Any alterations of the windowing configuration will take place immediately and seamlessly affecting any destination in which windowing is currently routed to Windowing Feedback Loop Image Processing Based Upon Windowing Selection Quad Windowing Figure 10 Multisource Windowing Processing and Display 13 Page K Video Conferencing Audio and video to be conferenced out are input to the AVCX 3U server containing BDV s Sapphire conferencing solution Sapphire QHD1 is compatible with all major conferencing systems that can support SIP and H 323 protocols including Polycom Tandberg Codian and Sony Audio and video communications are achieved over the hospital IS network Audio to Conf Audio from Conf 7 Wired Mics gt H Conf Video Out Sapphire QHD1 Far End Conferencing Solution Bi Directional Audio amp Video a C Procedure Room Conference Room Figure 11 BDV Video Conferencing Connection Diagram 14 Page K Surgical Display Settings All Foreseeso
3. Partners Network Jack below workstation DVI video from PC into CXPS Input Card CAT 5 Video source routable to all BDV destinations BDV RGB DVI Converter 4 V Designated PACS PC display at workstation Figure 2 Partners PC Installation amp Integration in BDV 5 Page K Provation PC Integration The Provation PC supplies an input to and receives an output from the CXPS video router After a series of signal conversions the CXPS output enters as the video input to the PC video capture card and can then be utilized to grab and document images via the Provation software The video output from the PC which includes the video capture card input Provation software is split in two using a VGA splitter One signal enters into a CXPS input port as a routable video source and the other is feed directly to the designated PC workstation display DVI Signal Conditioner and Digital to Analog Converter ummmcheseseen S Designated Provation PC BDV RGB DVI display at workstation Converter geet OPPO eee EE EE EE EE EE EE EE EE E EE EE EE EE EE DVI video from PC into CXPS Input Card Video into PC capture card Video source routable to all BDV destinations Provation PC Figure 3 Provation PC Input Output Video Integration 6 Page Ng K USB Touch Screen amp Printer Extension All touch screen and printer communication is provided over CAT 5 by the single USB
4. port Icron 2101 extender Each touch enabled display is connected to a regional extender REX that is powered from the rack The remote extender is connected to a local extender LEX and terminates at the application server providing the control interface video to the display USB over CAT 5 extension USB HI AVCX Application Server 1U or 3U Figure 4 Touch Screen amp Printer Extension via CAT 5 7 Page e er K Server Device Communications Communication and control of applicable devices is achieved via an 8 port serial breakout cable and card installed in the AVCX 3U control server Each device is connected to a specific breakout cable and controlled communicated to through an RS 232 port and protocols Noted below are the serial breakout cable numbers P connected to each device AVCX 3U Control Server HD Wall Camera HD Boom Camera ClearOne Audio CXPS Video Router Figure 5 Serial Breakout Cable Connection Diagram 8 Page K OR Camera Integration Room 1A has a HD boom mounted and HD wall camera available to view route and control from any of the BDV user control stations The video output feed from each camera is input into the CXPS router and appears on the user interface as a routable source Please note that the HD boom camera video output is RGB and requires conversion to DVI via a BDV RGB DVI converter Camera control is achieved via RS 232 connections from the devi
5. ce to a serial breakout cable on the AVCX 3U server HD Wall Camera Camera Control Box Video HD SDI Output Control RS 232 LYO ae SCS SYSTEM SELECT Ol Video DVI Output Control RS 232 To Rack UPS Power To Rack UPS Power RGB to DVI Converter Te s gl ga g Gel 7 L L e Into CXPS DVI Input Port Figure 6 Camera Control Video Connections 9 Page K Picture and Video Capture Active video sources can be sent to either the print destination for capturing stills or the record destination for recordings The print and record destinations correspond to specific output ports on the CXPS that feed into capture cards located inside the AVCX 3U server The capture cards are programmed specifically for the incoming CXPS output and store the image and video files on a local 1 Tb hard drive Capturing stills and recordings can also be remotely trigger via 3 5 mm stereo cables from the trigger enabled device to BDV accessory inputs located on the boom Trigger Connections on Boom Print Input Device Capture Cards CXPS DVI EE 1 TBHDD for Local Storage Seea f Sept grs D Figure 7 Capturing Stills Recording Video with Remote Trigger 10 Page P K Audio Matrix Connections Audio inputs and outputs are all connected to a central audio mixer The mixer comes with software that enables
6. eeeee 11 ClearOne Audio Matrix Configuration cccccsscccsssecccesececescceseesceeeeecesseecessegeeeesecessuaees 12 Windowing Video Sources 13 Vago Come ren e EE 14 SUPEICAIDISOIAY SEINES scsicsaaitvesdncmcavaninsoisnteonsvisnntewepanandevendmesdiavessdeyeanaretciasicdvenceedieveapacees 15 VIE DIG OIAy Se CUM EE EE A E E E E E 16 31Page K IDSS Rack Layouts The IDSS rack is comprised of 4 customizable modules Video Audio Print Record and Video Teleconferencing all controlled by an intuitive touch panel interface The components included in your customized versions of Black Diamond Video s IDSS solution are depicted below Pedi Endoscopy Rack GI Rack CXPS Video Router Network Switch AVCX 3U Control Server ClearOne Audio Mixer Sampson Amplifier Cooling Fans PowerVar Isolation Transformer UPS Figure 1 Example IDSS Rack Layouts at MGH Endoscopy 4 Page K Hospital PC Video Integration Each hospital provided PC that is integrated as an input into a Black Diamond equipped room is connected as depicted below The video output signal from each PC is split with one signal connecting to a designated PC display and the other feeding into an input port on the CXPS video router Network and power supply are connected at ports located underneath the workstation desk Partners PC PACS Power from PC Power A into outlet below A workstation TUTE CAT 5 cable into
7. n 26 surgical touch and non touch displays have adjustable display input and viewing properties To access the display adjustment interface press the MENU button on the lower front right side of the display Below is a listing of the default settings used by BDV for all Foreseeson displays Due to the length of video cable to the displays a signal conditioner box is installed prior to DVI signal termination at the display P e0 LED signal P a 8 confirmation 2 DVI signal conditioner located on the rear of i each surgical display Power When LED light is OFF monitor is ON Menu To access display adjustment interface PIP Must be set to OFF DVI DIGITAL Video Input Must be set to DVI DIGITAL Figure 12 Foreseeson Surgical Display Settings MENU ADJUST MENU SETTINGS Brightness 50 Image Size Full Contrast 50 Gamma 2 2 Backlight 100 Filter Normal Over Scan 0 MENU COLOR TEMP Image Setting Preset 1 Zoom Pan Color Temp C1 Freeze Frame OFF MENU IMAGE MENU PIP Red 50 Green 50 PIP Mode Single Blue 50 I5 Page K Wall Display Settings All Samsung 55 wall displays have adjustable display input and viewing properties To access the display adjustment interface press the MENU button on the lower front right side of the display or on the provided remote control Below is a listing of the default settings used by BDV for all Samsung wall displays Due to the length of video cable to
8. programming of inputs output gating as seen below To access matrix gating controls click the ClearOne mixer icon in the center of the screen after connecting to and launching device software The provided software Interact can be downloaded on the product website www clearone com The diagram below depicts audio connections and channel gating in Pediatric Endoscopy room 1A Into AVCX via Audio Breakout Conferencing Out R Conferencing Out L Provation PC a ClearOne Audio Matrix Configuration Channel Gated Figure 8 Audio Mixer Connections and Gating Diagram 11 1Page K ClearOne Audio Matrix Configuration Further adjustments can be made to the in room audio via the provided audio mixer software Input audio course and fine gains processing power and gating can be adjusted by clicking on the microphone icon next to the list of available inputs Output audio levels can also be adjusted by clicking on the output icon located next to the list of available outputs Audio Output Level Gain Adjustments Power Mute Options Output Settings Gain Adjustments Power Mute Options Input Options Audio Input Level Conferencing Out L Model 0O 7 14 21 28 35 42 49 56 5B Mic5 AuxR Connected to E Coarse Gain Make Model A 7 14 21 zez ee Mice aux t D E Coarse Gain PN ase anes CL Rs A DI D
9. the display a signal conditioner box is installed prior to DVI signal termination at the display TUELL z o REE c a LED signal confirmation Du signal conditioner located on the rear of 1 each wall display Power When LED light is OFF monitor is ON Menu To access display adjustment interface Source Must be set to HDMI Figure 13 Samsung Wall Display Settings MENU MODE ADVANCED MENU MODE PICTURE OPTIONS SETTINGS Digital Noise Filter OFF Black Tone OFF MPEG Noise Filter OFF Dynamic Contrast OFF HDMI Black Level LOW Shadow Detail O Edge Enhancement OFF MENU PICTURE Expert Pattern OFF RGB Mode OFF Brightness 45 Color Space Native Sharpness 0 Flesh Tone 0 Contrast 100 LED Motion OFF Backlight 20 Gamma 0 Color 50 16 Page
Download Pdf Manuals
Related Search