Platinum™Series XL, 5, 10 Concentrator Information
Contents
1. ee 88 D SECTION GENERAL GUIDELINES 7 a a 9 80 556 SECTION 2 INITIAL Compressor Initial Setup Checklist 10 Choosing needle regt eden 10 Transporting the Compressor 10 Installing the Power Cord eere H Connecting the Compressor to the Concentrator 12 SECTION 3 COMPRESSOR OPERATION 19 Compressor Operation 19 Cylinder Prefill Inspection 19 Connecting Disconnecting the Cylinder to the Sora uM 22 Turning the Compressor On 26 Setting the Flow Knob to the Prescribed Setting 28 CONCENTRATOR WARRANTY 0000000000000000000000 30 Part No 1118354 3 Platinum Series SPECIAL NOTES SPECIAL NOTES Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage Refer to the following table for definitions of the signal words SIGNAL WORD MEANING DANGER Danger indicates an imminently hazardous situation which if not avoided will result in death or serious injury WARNING Warning indicates2. Jo uonoes J9J9 u 4055944109 pug doy pinqay asneux3 e ejdey YeD aauin au sv UlJe v 5507 s13qOW osuss UBBAXO 5P9 U9 19114 WJU JOSSBJAWOD H2949 44931 Vd3H PPD 4 e ejdey ueo SLN3ILVd N33AAL38 HO 310d3H9S ADNVNALNIVW 3AILN3A3Ud ATIVANNY Cosues S LINN 8 2949 3 SAV 081 Au3A3 H204 1 314 ueo 5 JaW s no pesdej3 puoray 921A J9S Jo P1029 no NOILO3dSNI HOV3 NO HOLVH IN3ONOO N39AXO WANILW1d 3HVOVANI QHOO3H AONVNALNIVW 3ALLN3Ad3Hd FIGURE 6 2 Preventive Maintenance Record m 3l Platinum Series Part No 1118353 SECTION 7 TROUBLESHOOTING GUIDE SECTION 7 TROUBLESHOOTING GUIDE SYMPTOM Alarm PROBABLE CAUSE Main Power Loss SOLUTION Insert plug into outlet SHORT BEEPS Power cord NOT 2 Inspect house circuit power switch ON LONG PAUSE plugged in breakers or fuses If problem recurs use a different outlet Concentrator 2 No power at outlet 3 Call Service Provider NOT operating
3. Power Switch ON outlet 3 Internal repairs required 3 Tripped circuit breaker Alarm System Failure la Remove and clean cabinet CONTINUOUS I Unit overheating due filters to blocked air intake Concentrator Ib Move oxygen concentra NOT operating 2 Insufficient power at tor at least three 3 inches away from walls draperies or furniture 2 Do not use extension cords Move to another elec trical outlet or circuit 3 Call Service Provider Platinum Series 32 Part No 1118353 SECTION 7 TROUBLESHOOTING GUIDE SYMPTOM YELLOW or RED LIGHT Illumi nated Alarm CONTINUOUS On red light only Only applies to PROBABLE CAUSE Low oxygen purity 2 Kinked or blocked tub ing cannula or humidi fier 3 Flowmeter set at 0 5 L min for Platinum 5 and L min for Platinum 0 or less 4 Unit overheating due to blocked air intake 5 Insufficient power at outlet SOLUTION Clean or Replace filters 2 Inspect for kinks or block ages Correct clean or replace item Once cor rected turn power OFF for 60 seconds and then turn power back ON 3 Check flowmeter is set to 1 0 L min or more Refer to Recommended Guidelines for Optimum Performance on page 22 4 a Remove and clean cabinet Light Flashing 5LXO and filters IOLXO SensO 6 Internal repairs
4. 2 2 8 required 4b Move concentrator at least three 3 inches from walls draperies and furni ture 5 Do not use extension cords Move to another elec trical outlet or circuit 6 Call Service Provider GREEN LIGHT Internal repairs Call Service Provider with YELLOW required Part No 1118353 33 Platinum Series SECTION 7 TROUBLESHOOTING GUIDE SYMPTOM Alarm RAPID PROBABLE CAUSE LOW FLOW ALARM la Kinked or blocked tubing cannula or humid ifier Ib Flowmeter set at 0 5 L min for Platinum 5 and L min for Platinum 10 or less SOLUTION la Inspect for kinks or blockages Correct clean or replace item Once corrected turn power OFF for 60 seconds and then turn power back ON Ib Reset flowmeter to scribed flowrate If prescribed flowrate is below 0 5 L min use the Pediatric Flowmeter IRCPF 6 Platinum Series 34 Part No 1118353 LIMITED WARRANTY LIMITED WARRANTY NOTE THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4 1975 This warranty is extended only to original purchaser of our products This warranty gives you specific legal rights and you may also have other legal rights which may vary from state to state Invacare Corporation warrants its Platinum Oxygen Concentrator to be free from defects in materials a
5. 4 The humidifier adapter is next to the inlet filter Pull up and remove the humidifier bottle adapter Refer to Detail B in FIGURE 5 3 5 Attach it to the humidifier by turning the wing nut on the humidifier bottle counterclockwise until it is securely fastened Refer to Detail C in FIGURE 5 3 DETAIL A Plate Groove Insert Flat Head Screwdriver Here Filter Access Door DETAIL B Humidifier Bottle Adapter DETAIL Humidifier Bottle Adapter FIGURE 5 3 Attaching the Humidifier Bottle Adapter 6 Attach oxygen tubing from the humidifier bottle to oxygen outlet connector on the oxygen concentrator Platinum Series 24 Part No 1118353 SECTION 5 OPERATING INSTRUCTIONS 7 Attach the cannula patient supply tubing to the humidifier bottle outlet 8 After assembly ensure that oxygen is flowing through the cannula Oxygen Outlet Oxygen Connector Tubing Humidifier Outlet FIGURE 5 4 Attaching the Oxygen Tubing WARNING For optimum performance Invacare recommends that each concentrator be on and running for a minimum of 30 minutes at a time Shorter periods of operation may reduce maximum product life Power Switch NOTE For this procedure refer to FIGURE 5 5 1 Press power switch to on position the panel On Off VO lights and the audible Power Switch alarm will come on for one second indicating that the unit is functioning properl
6. and industry news Invacare can contact you or your provider if servicing is needed on your product It will enable Invacare to improve product designs based on your input and needs Register ONLINE at www invacare com Or Complete form and mail Any registration information you submit will be used by Invacare Corporation only and protected as required by applicable laws and regulations PRODUCT REGISTRATION FORM NAME ADDRESS CITY STATE PROVINCE ZIP POSTAL CODE EMAIL PHONE NO INVACARE MODEL NO SERIAL NO PURCHASED FROM DATE OF PURCHASE Method of purchase check all that apply Medicare Insurance Medicaid Other 2 This product was purchased for use by check one Self Parent Spouse Other 3 Product was purchased for use at Home Facility Other 4 purchased an Invacare product because Price Features list features 5 Who referred you to Invacare products check all that apply Doctor Therapist Friend Relative Dealer Provider Other Advertisement circle one TV Radio Magazine Newspaper No Referral 6 What additional features if any would you like to see on this product 10 Would you like information sent to you about Invacare products that may be available for a particular medical condition 1 Yes No If yes please list any condition s here and we will send you informa
7. at 20 60 relative Temperature humidity Exhaust Platinum 5 and XL Less than Ambient 35 F 19 Platinum 10 Less than Ambient 45 F 25 Oxygen Output Platinum 5 and XL Less than Ambient 4 F 2 C Platinum 10 Less than Ambient 8 F 4 4 Cabinet Impact Resistant flame retardant plastic cab inet that conforms to UL 94 0 Regulatory Listing Double Insulated Product ETL certified complying with UL 1097 ETL certified to CSA C22 2 No 68 Electrical No extension cords Part No 1118353 13 Platinum Series SECTION 4 SPECIFICATIONS Placement No closer than three 3 inches from any wall furniture draperies or similar surfaces Tubing 7 ft cannula with a maximum 50 ft of Crush Proof Tubing DO NOT pinch Platinum 10 Recommended use up to 25 ft high flow tubing with high flow cannula at all flow rates Relative Humidity 20 to 6076 Time of Operation Up to 24 hours per day Recommended Storage and 20 F to 150 F 29 to 65 C at 15 95 Shipping Temperature relative humidity Platinum Series 14 Part No 1118353 NOTES NOTES Part No 1118353 15 Platinum Series NOTES NOTES Platinum Series 16 Part No 1118353 YIM SEJJA REGISTER YOUR PRODUCT The benefits of registering l 2 3 Safeguard your investment Ensure long term maintenance and servicing of your purchase Receive updates with product information maintenance tips
8. a potentially hazardous situation which if not avoided could result in death or serious injury CAUTION Caution indicates a potentially hazardous situation which if not avoided may result in property damage A DANGER Users MUST NOT SMOKE while using this device Keep all matches lighted cigarettes or other sources of ignition out of the room in which this product is located NO SMOKING signs should be prominently displayed Textiles and other materials that normally would not burn are easily ignited and burn with great intensity in oxygen enriched air Failure to observe this warning can result in severe fire property damage and cause physical injury or death Platinum Series 4 Part No 1118354 HOMEFILL Il INFORMATION HOMEFILL Il INFORMATION Homerill is an accessory device to the oxygen concentrator that enables the patient to refill custom portable oxygen cylinders for personal use WARNING DO NOT install assemble or operate the HomeFill Il compressor without first reading and understanding the compressor owner s manual the concentrator owner s manual and the oxygen cylinder warning label If you are unable to understand the warnings cautions and instructions contact a dealer or technical personnel if applicable before attempting to install this equipment otherwise injury or damage may occur Check all parts for shipping damage In case of damage DO NOT use Contact Invacare for further in
9. equipment DO NOT use any lubricants unless recommended by Invacare For optimum performance Invacare recommends that each concentrator be on and running for a minimum of 30 minutes at a time Shorter periods of operation may reduce maximum product life If the concentrator has a damaged cord or plug if itis not working properly if it has been dropped or damaged or dropped into water call qualified technician for examination and repair Keep the cord away from heated or hot surfaces DO NOT move or relocate concentrator by pulling on the cord NEVER drop or insert any object into any opening NEVER block the air openings of the product or place it on a soft surface such as a bed or couch where the air opening may be blocked Keep the openings free from lint hair and the like Fill humidifier with water to the level shown by the manufacturer DO NOT overfill Keep unit at least three 3 inches away from walls draperies furniture and the like Invacare recommends that Crush Proof oxygen tubing be used with this product and not exceed 50 ft 15 2m in length Recommended use for Platinum 10 is up to 25 ft in length of high flow tubing Platinum Series 6 Part No 1118353 SECTION GENERAL GUIDELINES MAINTENANCE The Invacare Oxygen Concentrator was specifically designed to minimize routine preventive maintenance Only professionals of the healthcare field or persons fully conversant with this process such as
10. 1118353 3 Platinum Series SPECIAL NOTES SPECIAL NOTES Danger indicates an imminently hazardous situation which if not avoided will result in death or serious DANGER injury Warning indicates a potentially hazardous situation which if not avoided could result in death or seri WARNING ous injury Caution indicates a potentially hazardous situation which if not avoided may result in property dam CAUTION age NOTICE The information contained in this document is subject to change without notice DANGER Users MUST not smoke while using this device Keep all matches lighted cigarettes or other sources of ignition out of the room in which this product is located No smoking signs should be prominently displayed Textiles and other materials that normally would not burn are easily ignited and burn with great intensity in oxygen enriched air Failure to observe this warning can result in severe fire property damage and cause physical injury or death Platinum Series 4 Part No 1118353 SECTION GENERAL GUIDELINES SECTION GENERAL GUIDELINES In order to ensure the safe installation assembly and operation of the Platinum concentrator these instructions MUST be followed CAUTION Caution Federal law restricts this device to sale or rental by or on order of a physician or any other practitioner licensed by the law of the State in which he she practices to use or order the use of th
11. 1118354 9 Platinum Series SECTION 2 INITIAL SETUP SECTION 2 INITIAL SETUP NOTE Dealers Only Refer to Dealer Information in Owner s Manual part number 1100873 before performing this procedure Compressor Initial Setup Checklist Before operating the HomeFill II Compressor for the first time complete the following checklist Choose a location for the compressor Transport the compressor to the desired location Connect the power cord to the compressor Connect the compressor to the concentrator Choosing a Location The compressor should be at least three 3 inches away from walls draperies or furniture to ensure sufficient air flow Avoid placing the compressor next to heaters radiators or hot air registers Do not use in a closet The compressor should sit on a hard flat stable surface such as a table Transporting the Compressor A WARNING NEVER transport a compressor with a cylinder connected to or stored on the compressor otherwise injury or damage can occur Platinum Series 10 Part 1118354 SECTION 2 INITIAL SETUP CAUTION When transporting the compressor be careful not to bump the compressor or the connectors into obstacles Otherwise damage to the compressor may occur NOTE For this procedure refer to FIGURE 2 1 1 There are two 2 methods to safely transportthe compressor A One hand Grasp the hand grip at the bottom rear of the compres
12. EPAIR OR REPLACEMENT OF THE DEFECTIVE PRODUCT PERSUANT TO THE TERMS CONTAINED HEREIN THE APPLICATION OF ANY IMPLIED WARRANTY WHATSOEVER SHALL NOT EXTEND BEYOND THE DURATION OF THE EXPRESS WARRANTY PROVIDED HEREIN INVACARE SHALL NOT BE LIABLE FOR ANY CONSEQUENTIAL OR INCIDENTAL DAMAGES WHATSOEVER SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGE OR LIMITATION OF HOW LONG AN IMPLIED WARRANTY LASTS SO THE ABOVE EXCLUSION AND LIMITATION MAY NOT APPLY TO YOU THIS WARRANTY SHALL BE EXTENDED TO COMPLY WITH STATE PROVINCIAL LAWS AND REQUIREMENTS Part No 1118354 3l Platinum Series Invacare Corporation www invacare com USA INVACARE One Invacare Way Elyria Ohio USA 44036 2125 Yes you can 800 333 6900 Technical Services 800 832 4707 Invacare Yes you can the Medallion Design and SensO are registered trademarks of Invacare Corporation Platinum and HomeFill are trademarks of Invacare Corporation 2005 Invacare Corporation Part No 1118354 Rev D 09 05 Asm No 1106444
13. F ANY IMPLIED WARRANTY WHATSOEVER SHALL NOT EXTEND BEYOND THE DURATION OF THE EXPRESS WARRANTY PROVIDED HEREIN INVACARE SHALL NOT BE LIABLE FOR ANY CONSEQUENTIAL OR INCIDENTAL DAMAGES WHATSOEVER SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGE OR LIMITATION OF HOW LONG AN IMPLIED WARRANTY LASTS SO THE ABOVE EXCLUSION AND LIMITATION MAY NOT APPLY TO YOU THIS WARRANTY SHALL BE EXTENDED TO COMPLY WITH STATE PROVINCIAL LAWS AND REQUIREMENTS This product may be manufactured under one or more of the following patents US 5 906 672 and US 5 917 135 Other patents pending Invacare Corporation www invacare com USA Invacare Yes you can SensO INVACARE One Invacare Way Venture and the Medallion Design are ME Elyria Ohio USA registered trademarks of Invacare 44036 2125 Corporation Yes you can 800 333 6900 Platinum HomeFill and Precise Technical Services 800 832 4707 trademarks of Invacare Corporation 9 2005 Invacare Corporation Part No 1118353 Rev E 09 05 Asm No 1106664 Operator s Manual Platinum Series XL 5 Oxygen Concentrators Standard SensO and Homerilf PART TWO HomeFill Il Connection and Use with the Concentrator Invacare 5 Invacare 5 SensO Model IRCSLX Model IRC5LX02 Invacare 10 Invacare 10 with SensO Model IRCIOLX Model IRCIOLX02 User Before using the product read this manual and save for future
14. N Over 85 5LX INDICATORS Status Indicator Lights SYSTEM FAILURE SYSTEM OKAY Flow Range Platinum 5 and XL 0 5 to 5 L min For flowrates less than L min we recommend the use of the Invacare Pediatric Flowmeter IRCPFI6 Accessory Platinum 10 2 L min to 10 L min Low Flow Alarm Platinum 5 0 L min to 0 5 L min Platinum 10 0 L min to L min Rapid Audible Alarm Beeping No Accessories Connected Average Power Platinum 5 and XL 400W Consumption Platinum 10 585W Pressure Relief Mechanism 35 psi 3 5 psi 241 kPa 24 1 kPa Operational at Change in maximum recom 0 7 L min mended flow when back pres sure of 7kPa is applied Platinum Series 12 Part No 1118353 SECTION 4 SPECIFICATIONS Cabinet 2 Outlet HEPA and Compressor Inlet Safety System Current overload or line surge shutdown High temperature compressor shutdown High Pressure Alarm w compressor shut down Low Pressure Alarm w compressor shutdown Battery Free Power Loss Alarm SensO Oxygen System SensO Model Low Flow Alarm 18 3 8 in 3 8 in 46 7 cm cm 26 3 8 in 3 8 in 67 0 cm cm 14 3 8 in 3 8 in 36 5 cm cm Weight Platinum 5 and XL 52 Ibs 2 Ibs 23 6 kg kg Platinum 10 53 Ibs 2 Ibs 24 0 kg kg Shipping Weight Platinum 5 and XL 58 Ibs 2 Ibs 26 3 kg kg Platinum 10 60 Ibs 2 Ibs 27 2 kg kg Operating Ambient 50 F 95 F 10 C 35 C
15. Operator s Manual Platinum Series XL 5 10 Oxygen Concentrators Standard with SensO and HomeFill II PART ONE Concentrator Information Invacare 5 t SensO Invacare 5 Model IRC5LXO2 Model IRC5LX Invacare 10 with SensO Invacare 10 Model IRCIOLXO2 Model IRCIOLX Dealer This manual MUST be given to the end user User Before using this product read this manual and save for future reference For more information regarding Invacare products parts and services please visit www invacare com Yes you can WARNING WARNING DO NOT OPERATE THIS EQUIPMENT WITHOUT FIRST READING AND UNDERSTANDING THIS MANUAL IF YOU ARE UNABLE TO UNDERSTAND THE WARNINGS CAUTIONS AND INSTRUCTIONS CONTACT INVACARE TECHNICAL SERVICES BEFORE ATTEMPTING TO USE THIS EQUIPMENT OTHERWISE SERIOUS INJURY OR PROPERTY DAMAGE MAY RESULT ACCESSORIES There are many different types of humidifiers oxygen tubing cannulas and masks that can be used with this device You should contact your local home care provider for recommendations on which of these devices will be best for you They should also give you advice on the proper usage maintenance and cleaning A WARNING Invacare products are specifically designed and manufactured for use in conjunction with Invacare accessories Accessories designed by other manufacturers have not been tested by Invacare and are not recommended for use with Invacare produ
16. T alter or modify cylinder or related components DO NOT use Oil or Grease Keep cylinder cylinder valve all equipment and connections free of oil and grease to avoid violent ignition resulting in serious bodily injury or death For medical applications Use only as directed by a licensed practitioner Uninterrupted use of high concentrations of oxygen over a long duration without monitoring its effect on oxygen content of arterial blood may be harmful Oxygen Oylinders filled by the Venture HomeFill shall be used for personal use only Not to be filled for resale or use by professional users This cylinder is to be used with the Invacare Venture HomeFill system This cylinder contains 93 3 oxygen produced by an oxygen concentrator using the pressure swing adsorption process DO NOT handle cylinder or use contents until you are professionally trained including emergency procedures Use in accordance with Venture HomeFill Operator s Manual Open valve slowly Close valve after each use and when empty Secure cylinder during storage and use No smoking in cylinder area Keep away from heat flame and spark Keep out of reach of children DO NOT drop Transfilling of this gas is performed by Venture HomeFill Only Cylinders that have been refinished and or exposed to elevated temperatures must be hydrostatically tested before filling Cylinder temperature should not exceed 125 F 52 C Aluminum cylinders subject to the action
17. TION FORM NAME ADDRESS CITY STATE PROVINCE ZIP POSTAL CODE EMAIL PHONE NO INVACARE MODEL NO SERIAL NO PURCHASED FROM DATE OF PURCHASE Method of purchase check all that apply Medicare Insurance Medicaid Other 2 This product was purchased for use by check one Self A Parent A Spouse Ly Other 3 Product was purchased for use at Home A Facility Other 4 purchased an Invacare product because A Price A Features list features 5 Who referred you to Invacare products check all that apply Doctor Therapist Friend Relative Dealer Provider Other LJ Advertisement circle one TV Radio Magazine Newspaper A No Referral 6 What additional features if any would you like to see on this product 10 Would you like information sent to you about Invacare products that may be available for a particular medical condition IJ Yes No If yes please list any condition s here and we will send you information by email and or mail about any available Invacare products that may help treat care for or manage such condition s Would you like to receive updated information via email or regular mail about the Invacare home medical products sold by Invacare s dealers Yes No What would you like to see on the Invacare website Would you like to be part of future online surveys for Invacare products Y
18. Use this product for only intended use as described in this manual DO NOT connect the concentrator in parallel or series with other oxygen concentrators or oxygen therapy devices Use of some administration accessories or certain humidifiers not specified for use with oxygen concentrator may impair the performance In certain circumstances oxygen therapy can be hazardous Invacare recommends that you seek medical advice before using this machine This equipment is to be used as an oxygen supplement and is not considered life supporting or life sustaining Avoid creation of any spark near medical oxygen equipment This includes sparks from static electricity created by any type of friction POLARIZED PLUG INSTRUCTION As a safety feature this appliance has a polarized plug one blade is wider than the other This plug will fit in a polarized outlet only one way If the plug does not fit fully in the outlet reverse the plug If it still does not fit contact a qualified electrician DO NOT attempt to defeat this safety feature Platinum Series 8 Part No 1118353 SECTION 2 FEATURES SECTION 2 FEATURES Oxygen Purity Indicator Lights SensO model only Fault and Power Indicator Lights LX model only Oxygen Outlet Flowmeter Power Switch Circuit Breaker Elapsed Time Meter Cabinet Filter one of two shown ACCESSORIES NOT SHOWN Remote Humidifier Flowmeter Accessory IRCRF5 REAR VIEW Pre
19. anual 1100873 for detailed information on all warnings use and maintenance of the HomeFill Il compressor In order to ensure the safe installation assembly and operation of the HomeFill II Compressor these instructions must be followed Caution Federal law restricts this device to sale by or on order of a physician or any other practitioner licensed by the law of the State in which he she practices to use or order the use of this device WARNING The use of this device is limited to the oxygen patient Cylinders MUST be used ONLY by the oxygen patient and are not to be distributed to any other individual for any purpose Part No 1118354 7 Platinum Series SECTION GENERAL GUIDELINES WARNING The maximum patient flow while filling cylinders with the IOH200 is 3 L min for Platinum 5 and XL 5 L min for Platinum 10 Patients with a higher prescribed flow should not transfill while receiving supplemental oxygen treatment from the Platinum Concentrator NEVER block the air openings of the product or place it on a soft surface such as a bed or couch where the air opening may be blocked Keep the openings free from lint hair and the like DO NOT disassemble There are minimal serviceable parts on the Homerill II Compressor If any service is required contact Invacare Technical Service DO NOT allow oil from your hands or other source to come into contact with the regulator or cylinder valv
20. ciseRX Pediatric Humidifier Flowmeter Accessory IRCPFI6 Venture Homerill Il home oxygen compressor 0 NOTE This outlet fitting is to be used only for filling oxygen cylinders with the Venture HomeFill II home oxygen compressor The outlet fitting does not affect concentrator performance Refer to the HomeFill II owner s manual part number 1100873 for connection and operating instructions When not in use the plug provided with the Cord Fitting concentrator should be inserted into the outlet fitting For more information about the HomeFill contact your Invacare dealer Part No 1118353 9 Platinum Series SECTION 3 HANDLING SECTION 3 HANDLING The concentrator should always be kept in the upright position to prevent cabinet damage while being transported The shipping container has been designed to assure maximum protection of the concentrator If the concentrator is to be reshipped by common carrier additional cartons are available from Invacare Unpacking NOTE For this procedure refer to FIGURE 3 1 1 Check for any obvious damage to the carton or pw its contents If damage is 2 evident notify the carrier or your local dealer V 2 Remove allloose packing from the carton 3 Carefully remove all the components from the carton FIGURE 3 1 Unpacking NOTE Unless the oxygen concentrator is to be used immediately retain containers and packing materials for storage until us
21. component part s in a manner to avoid shipping damage and to ship the component part s to either Invacare Corporation s plant or service center as specified by Invacare Corporation in advance Defective component part s must be returned for warranty inspection using the serial number as identification within thirty 30 days of return authorization date Do not return products to our factory without prior consent C O D shipments will be refused please prepay shipping charges Platinum Series 30 Part No 1118354 CONCENTRATOR WARRANTY LIMITATIONS AND EXCLUSIONS THE FOREGOING WARRANTY SHALL NOT APPLY TO PRODUCTS SUBJECTED TO NEGLIGENCE ACCIDENT IMPROPER OPERATION MAINTENANCE OR STORAGE SOOT OR SMOKE FILLED ENVIRONMENTS OR OTHER THAN NORMAL APPLICATION USE OR SERVICE OR TO PRODUCTS MODIFIED WITHOUT INVACARE CORPORATION S EXPRESS WRITTEN CONSENT INCLUDING BUT NOT LIMITED TO MODIFICATION THROUGH THE USE OF UNAUTHORIZED PARTS OR ATTACHMENTS OR TO PRODUCTS DAMAGED BY REASON OF REPAIRS MADE TO ANY COMPONENT WITHOUT THE SPECIFIC CONSENT OF INVACARE CORPORATION OR TO PRODUCTS DAMAGED BY CIRCUMSTANCES BEYOND INVACARE CORPORATION S CONTROL THE FOREGOING EXPRESS WARRANTY IS EXCLUSIVE AND IN LIEU OF ANY OTHER WARRANTIES WHATSOEVER WHETHER EXPRESS OR IMPLIED INCLUDING THE IMPLIED WARRANTIES OF MERCHANTIBILITY AND FITNESS FOR A PARTICULAR PURPOSE AND THE SOLE REMEDY FOR VIOLATIONS OF ANY WARRANTY WHATSOEVER SHALL BE LIMITED TO R
22. cts Platinum Series 2 Part No 1118353 TABLE OF CONTENTS ACCESSORIES e 2 SPECIAL NOTES eee oooooosccccccceccccccccs SECTION GENERAL GUIDELINES 5 SECTION 2 52 5 9 SECTION 3 HANDLING 0 uiscera has ate edite puts mus a iod 10 60 10 n 10 SECTION 4 SPECIFICATIONS 0000000000000000000000000 SECTION 5 OPERATING INSTRUCTIONS 21 21 Select Location WD 21 Recommended Guidelines for Optimum Performance 22 Plug Power Cord si ii A ia e 22 Connect Humidifier If So 22 Power 25 FIO Wit 26 SensO Oxygen Purity Indicator If Your Unit Features the O Sensor 00070 27 Initial Startup of the Concentrator 27 Explanation of Oxygen Purity Indicator Lights 27 Indicators If Your Unit Does Not Feature the Sensor 28 SECTION 6 MAINTENANCE 00000000000000000000000000 29 Routine 29 SECTION 7 TROUBLESHOOTING GUIDE 32 LIMITED WARRANTY 000000000000000000000000000000000000 3 5 Part No
23. e compressor inlet fitting will pop out with an audible click when the end of the interconnect hose is properly installed Detail 3 Loop any excess interconnect hose and secure to the back of the concentrator with the fastening straps not shown Platinum Series 12 Part No 1118354 SECTION 2 INITIAL SETUP DETAIL A DETAIL B Insert End of ompressor Interconnect Interconnect Hose into f Hose Inlet Outlet Fitting 1 A 7 CONCENTRATOR TOP VIEW Inlet Fitting m Power Outlet Fitting Cord or DETAIL C Inlet Outlet Fitting Metal Tab the Compressor to the Concentrator Part No 1118354 13 Platinum Series NOTES NOTES Platinum Series 14 Part 1118354 YIM SEJJA REGISTER YOUR PRODUCT The benefits of registering l 2 3 Safeguard your investment Ensure long term maintenance and servicing of your purchase Receive updates with product information maintenance tips and industry news Invacare can contact you or your provider if servicing is needed on your product It will enable Invacare to improve product designs based on your input and needs Register ONLINE at www invacare com Or Complete form and mail Any registration information you submit will be used by Invacare Corporation only and protected as required by applicable laws and regulations PRODUCT REGISTRA
24. e connection These solutions may be flammable and cause injury The HomeFill II is equipped with a high pressure relief valve to ensure the user s safety When activated this safety feature will make an extremely loud noise If this noise occurs turn the unit off and contact your Home Health Care Provider or Service Representative Before moving or repositioning either the compressor or concentrator always disconnect the AC power cords and the interconnect hose between the compressor and concentrator Failure to do so may result in damage to the unit or personal injury Children should always be supervised around the HomeFill II unit When used with the HomeFill table or similar elevated support surfaces a child could pull over any such table causing the unit to fall Failure to observe this warning may result in personal injury or product damage Platinum Series 8 Part No 1118354 SECTION GENERAL GUIDELINES A WARNING Handling Use extreme care when handling and filling an oxygen cylinder Full oxygen cylinders are under pressure and can become a projectile if dropped or mishandled NEVER transport a compressor with a cylinder connected to or stored on the compressor otherwise injury or damage can occur DO NOT store filled oxygen bottles near a furnace hot water tank in the trunk of a car or other high temperature area Storage in areas such as this can result in bursting of the bottle or fire Part No
25. e of the concentrator is required Inspection l Inspect examine exterior of the oxygen concentrator for nicks dents scratches or other damages Inspect all components Storage 1 Store the repackaged oxygen concentrator in a dry area 2 DO NOT place objects on top of repackaged concentrator Platinum Series 10 Part 1118353 SECTION 4 SPECIFICATIONS SECTION 4 SPECIFICATIONS 120 VAC 10 132 VAC 108 VAC 60 Hz Rated Current Input Altitude Platinum 5 and XL Up to 6 000 ft 1828 meters above sea level without degradation of concentration levels From 6 000 ft 1828 meters to 13 129 ft 4000 meters below 9076 efficiency Platinum 10 Up to 4 000 ft 1230 meters above sea level without degradation of con centration levels From 4 000 ft 1230 meters to 13 129 ft 4000 meters below 9076 efficiency Oxygen Output All 5LXO2 5LX models 95 6 to 87 at 0 5 Concentration Levels to 5 L min and all I10LXO2 I OLX models 95 6 to 87 at 2 L to 10 L min Maximum Outlet Pressure 5 0 5 psi 34 5 3 45 kPa NOTE Stated concentration levels achieved after initial warm up period approximately 30 minutes Part No 1118353 Platinum Series SECTION 4 SPECIFICATIONS 5LXO INDICATORS O Purity Indicator Lights SYSTEM FAILURE RED Continuous Audible Below 73 Alarm Sieve GARD Compressor Shutdown 73 to 85 YELLOW SYSTEM OKAY GREE
26. emove the cylinder from the compressor cradle 6 Place the fillport covers onto the connector and cylinder fillports NOTE The fillport covers should be used whenever cylinders are not being filled Turning the Compressor On NOTE For this procedure refer to FIGURE 3 5 1 Make sure the concentrator is On Refer to the concentrator Owner s Manual CAUTION The concentrator flow rate to the patient MUST be set at maximum 3 L min or less for Platinum 5 XL and 5 L min for Platinum 10 Otherwise the oxygen level to the compressor will be 9076 and the compressor will not fill the cylinder 2 Set the concentrator flow rate to the patient to L min or less for Platinum 5 XL and 5 L min for Platinum 10 Refer to the concentrator Owner s Manual Part One 3 Make sure the cylinder is connected to the compressor Refer to Connecting the Cylinder to the Compressor on page 22 4 Push the power switch on the control panel to the On position 5 Examine the control panel The following sequence of events should occur A 0 3 minutes The WAIT YELLOW light will be lit while the compressor warms up Platinum Series 26 Part No 1118354 SECTION 3 COMPRESSOR OPERATION B After three 3 minutes The FILLING GREEN light will be on while the cylinder is filling C The FULL GREEN light will be on when the cylinder is finished filling Proceed to STEP 6 NOTE The BELOW NORMAL YELLOW light may come
27. es No User s Year of birth If at any time you wish not to receive future mailings from us please contact us at Invacare Corporation CRM Department 39400 Taylor Parkway Elyria OH 44035 or fax to 877 619 7996 and we will remove you from our mailing list TO FIND MORE INFORMATION ABOUT OUR PRODUCTS VISIT WWW INVACARE COM SALVLS AHLNI qxanivi AHVSS3O3N 39V1SOd ON 9 86 S 0tv HO VIHAA YOTAVL 00768 INJINLH4dAG Wad NOILVAOAHOD JAVOVANI 33SS3HQQV 38 TIIM ADVLSOd HO VIaXT3 961 ON LIINH3d JIV SSVIDISHI4 TVN A1d38 SSANISNG SECTION 3 COMPRESSOR OPERATION SECTION 3 COMPRESSOR OPERATION Compressor Operation Checklist NOTE For this procedure refer to FIGURE 3 1 Each time the HomeFill II Compressor is used to fill a cylinder complete the following checklist Ensure the concentrator has been on for at least thirty 30 minutes Refer to the concentrator Owner s Manual Part One Perform the prefill inspection on the cylinder Connect the cylinder to the compressor Turn the compressor on Examine the indicator lights on the control panel Disconnect and remove the full cylinder Turn the compressor off If filling another cylinder repeat this checklist LDOCOOCUDULCO Cylinder Prefill Inspection WARNING ONLY use cylinders that have the Invacare HomeFill connection and the label shown in FIGURE 3 1 All cyli
28. factory trained personnel should perform preventive maintenance or performance adjustments on the oxygen concentrator RADIO FREQUENCY INTERFERENCE Most electronic equipment is influenced by Radio Frequency Interference RFI Caution should be exercised with regard to the use of portable communications equipment in the area around such equipment TO REDUCE THE RISK OF BURNS ELECTROCUTION FIRE OR INJURY TO PERSONS Avoid using while bathing If continuous usage is required by the physician s prescription The concentrator MUST be located in another room at least seven 7 feet from the bath DO NOT come in contact with the concentrator while wet DO NOT place or store product where it can drop into water or other liquid DO NOT reach for product that has fallen into water Unplug IMMEDIATELY A product should NEVER be left unattended when plugged in This device is to be used only in accordance with the prescription of a physician and this Owner s Manual If at any time the patient or attendant conclude that the patient is receiving an insufficient amount of oxygen the supplier and or physician should be contacted immediately DO NOT change the L min setting on the flowmeter unless a change has been prescribed by your physician or therapist Part No 1118353 7 Platinum Series SECTION GENERAL GUIDELINES Close supervision is necessary when this product is used near children or physically challenged individuals
29. gen delivery systems Your provider will show you how to use your oxygen concentrator He She should be contacted with any questions or problems regarding your oxygen concentrator This owner s manual will tell you about your concentrator and will serve as a reference as you use your concentrator Select a Location You may select a room in your house where using your oxygen concentrator would be most convenient Your concentrator can be easily rolled from room to room on its casters Your oxygen concentrator will perform best when operated under the following conditions Usage in environments other than those described may result in the need for increased equipment maintenance The air intake of the unit should be located in a well ventilated area to avoid airborne pollutants and or fumes Part No 1118353 21 Platinum Series SECTION 5 OPERATING INSTRUCTIONS Recommended Guidelines for Optimum Performance Placement No closer than three 3 inches from the wall furniture draperies or similar surfaces Tubing and Cannula 7 ft cannula with a maximum 50 ft of Crush Proof Tubing DO NOT pinch Platinum 10 Recommended use up to 25 ft high flow tubing with high flow cannula at all flow rates Environment Smoke and soot free No confined spaces Example No closets Relative Humidity 20 to 6076 Time of Operation Up to 24 hours per day Flow Rate Platinum 5 and XL From 0 5 L min to 5 L min For flow rates less tha
30. icators If Your Unit Does Not Feature the O Sensor NOTE For this procedure refer to FIGURE 5 8 LX models indicator Light Explanation RED light Q Total Unit Shut Down Switch immediately to a back up oxygen supply Call supplier IMMEDIATELY GREEN light I O On Off System okay Auto Shut Down Use Backup a Call Supplier Normal 4 GREEN FIGURE 5 8 Indicators If Your Unit Does Not Feature the O Sensor Platinum Series 28 Part No 1118353 SECTION 6 MAINTENANCE SECTION 6 MAINTENANCE NOTE The Invacare concentrators are specifically designed to minimize routine preventive maintenance In places with high dust or soot levels maintenance may need to be performed more often Only authorized or factory trained personnel should perform preventive maintenance on the concentrator Power should be disconnected before beginning preventive maintenance on the Invacare concentrator NOTE At a minimum preventive maintenance MUST be performed according to the maintenance record guidelines Refer to Preventive Maintenance Record on page 31 Routine Maintenance NOTE The following routine maintenance should be performed more frequently See recommended intervals in each section and preventive maintenance record Cleaning the Cabinet Filter NOTE For this procedure refer to FIGURE 6 1 NOTE There are two 2 cabinet filters one 1 located on each side of the cabinet 1 Remove each fi
31. is device A WARNING SECTION I GENERAL GUIDELINES contains important information for the safe operation and use of this product DO NOT use this product or any available optional equipment without first completely reading and understanding these instructions and any additional instructional material such as Owner s Manuals Service Manuals or Instruction Sheets supplied with this product or optional equipment If you are unable to understand the Warnings Cautions or Instructions contact a healthcare professional dealer or technical personnel before attempting to use this equipment otherwise injury or damage may occur Risk of electric shock DO NOT disassemble Refer servicing to qualified service personnel The use of oxygen therapy requires that special care be taken to reduce the risk of fire Any materials that will burn in air and some that will not are easily ignited and burn rapidly in high concentrations of oxygen For safety concerns it is necessary that all sources of ignition be kept away from the product and preferably out of the room in which it is being used NO SMOKING signs should be prominently displayed Part No 1118353 5 Platinum Series SECTION GENERAL GUIDELINES A spontaneous and violent ignition may occur if oil grease or greasy substances come in contact with oxygen under pressure These substances MUST be kept away from the oxygen concentrator tubing and connections and all other oxygen
32. lter and clean at least once a week depending on environmental conditions NOTE Environmental conditions that may require more frequent cleaning of the filters include but are not limited to high dust smoking air pollutants etc 2 Clean the cabinet filters with a vacuum cleaner or wash in warm soapy water and rinse thoroughly 3 Dry the filters thoroughly before reinstallation Part No 1118353 29 Platinum Series SECTION 6 MAINTENANCE CAUTION DO NOT operate the concentrator without the filters installed Cabinet Filter located on both ATEN sides of Zm concentrator 6 FIGURE 6 1 Cleaning the Cabinet Filter Cabinet WARNING UNPLUG the concentrator when cleaning To avoid electrical shock DO NOT remove cabinet 1 Clean the cabinet with a mild household cleaner and non abrasive cloth or sponge Humidifier NOTE To clean the oxygen humidifier follow the instructions provided by the manufacturer If none are provided follow these steps 1 Clean the humidifier every day 2 Wash it in soapy water and rinse it with a solution of ten 10 parts water and one 1 part vinegar Rinse thoroughly with hot water and refill with distilled water to the level shown on the humidifier Platinum Series 30 Part No 1118353 SECTION 6 MAINTENANCE WARNING DO NOT overfill humidifier bottle SERIAL NO IRC MODEL NO JENUEW 96
33. n L min use the Pediatric Flowmeter Accessory Platinum 10 From 2 L min to 10 L min NOTE Ensure that your concentrator is at least three 3 inches away from walls draperies or furniture to assure sufficient air flow Avoid deep pile carpets and heaters radiators or hot air registers Plug in Power Cord 1 Plug in power cord to an electrical outlet Connect Humidifier If So Prescribed NOTE For this procedure refer to FIGURE 5 1 FIGURE 5 4 Platinum Series 22 Part No 1118353 SECTION 5 OPERATING INSTRUCTIONS 1 Fill humidifier with distilled water to the level indicated by the manufacturer For Platinum 5 XL recommended humidifiers are Invacare 3260 003 40 or 006 40 A WARNING DO NOT overfill humidifier Replace the humidifier cap and securely tighten DO NOT reverse the oxygen input and output connections Water from the humidifier bottle will travel through the cannula back to the patient Humidifier Bottle FIGURE 5 1 Filling the Humidifier 2 Place the humidifier bottle in the humidifier compartment Humidifier Bottle FIGURE 5 2 Humidifier Compartment 3 Remove the filter access door located on the side of the concentrator Insert a flathead screwdriver in the plate groove on the top edge of the filter access door and gently pry the filter access door open Refer to Detail A in FIGURE 5 3 Part No 1118353 23 Platinum Series SECTION 5 OPERATING INSTRUCTIONS
34. nd workmanship from date of purchase Platinum 5 and XL for a period of five 5 years Platinum 10 for a period of three 3 years The 4 way valve body carries a lifetime warranty from date of purchase DO NOT open or ATTEMPT TO service valve body This will void any and all warranty applicable to the valve body If within such warranty period any such product shall be proven to Invacare Corporation s satisfaction to be defective such product shall be repaired or replaced at Invacare Corporation s option This warranty only applies to the labor for repairs performed by the Invacare Service Department or Invacare Service Centers It does not apply to the labor performed by the purchaser or user This warranty does not include normal wear and tear or shipping charges Invacare Corporation s sole obligation and your exclusive remedy under this warranty shall be limited to such repair or replacement Routine maintenance items such as filters are excluded from this warranty For warranty service please contact Invacare Corporation s service department at the toll free number on the back cover Upon receiving notice of an alleged defect in a product Invacare Corporation will issue a serialized return authorization It shall then be the responsibility of the purchaser to return the entire unit or remove at purchaser s cost the defective component part s identified pack the component part s in a manner to avoid shipping damage and to ship the compo
35. nders MUST be inspected before attempting to fill Otherwise injury or damage may occur Part No 1118354 19 Platinum Series SECTION 3 COMPRESSOR OPERATION The Hydrostatic Testing Date Aluminum cylinders MUST undergo testing every five 5 years A WARNING DO NOT fill cylinders that have not been tested in the past five 5 years Otherwise serious personal may result Contact your dealer for replacement External Examination 1 Examine the outside of the cylinder for the following conditions and replace the cylinder if they exist e Dents or dings e Arc burns e Oil or grease e Any other signs of damage that might cause a cylinder to be unacceptable or unsafe for use N Examine the cylinder for evidence of fire or thermal damage Evidence includes charring or blistering of the paint or other protective coating or heat sensitive indicator If fire or thermal damage is found replace the cylinder 2 Inspect the regulator assembly for the following and replace if found Debris oil or grease e Noticeable signs of damage Signs of corrosion inside the valve Signs of excessive heat or fire damage Platinum Series 20 Part No 1118354 SECTION 3 COMPRESSOR OPERATION Improper filling or abuse of this cylinder or failure to follow these safety instructions may cause serious bodily injury or death High pressure oxidizing gas vigorously accelerates combustion DO NO
36. nent part s to either Invacare Corporation s plant or service center as specified by Invacare Corporation in advance Defective component part s must be returned for warranty inspection using the serial number as identification within thirty 30 days of return authorization date Do not return products to our factory without prior consent C O D shipments will be refused please prepay shipping charges LIMITATIONS AND EXCLUSIONS THE FOREGOING WARRANTY SHALL NOT APPLY TO PRODUCTS SUBJECTED TO NEGLIGENCE ACCIDENT IMPROPER OPERATION MAINTENANCE OR STORAGE SOOT OR SMOKE FILLED ENVIRONMENTS OR OTHER THAN NORMAL APPLICATION USE OR SERVICE OR TO PRODUCTS MODIFIED WITHOUT INVACARE CORPORATION S EXPRESS WRITTEN CONSENT INCLUDING BUT NOT LIMITED TO MODIFICATION THROUGH THE USE OF UNAUTHORIZED PARTS OR ATTACHMENTS OR TO PRODUCTS Part No 1118353 35 Platinum Series DAMAGED BY REASON OF REPAIRS MADE TO ANY COMPONENT WITHOUT THE SPECIFIC CONSENT OF INVACARE CORPORATION OR TO PRODUCTS DAMAGED BY CIRCUMSTANCES BEYOND INVACARE CORPORATION S CONTROL THE FOREGOING EXPRESS WARRANTY IS EXCLUSIVE AND IN LIEU OF ANY OTHER WARRANTIES WHATSOEVER WHETHER EXPRESS OR IMPLIED INCLUDING THE IMPLIED WARRANTIES OF MERCHANTIBILITY AND FITNESS FOR A PARTICULAR PURPOSE AND THE SOLE REMEDY FOR VIOLATIONS OF ANY WARRANTY WHATSOEVER SHALL BE LIMITED TO REPAIR OR REPLACEMENT OF THE DEFECTIVE PRODUCT PERSUANT TO THE TERMS CONTAINED HEREIN THE APPLICATION O
37. of fire or heated to temperatures in excess of 350 F must be withdrawn from service and condemned by trained personnel DO NOT use caustic paint strippers Valve and safety relief devices must be removed and replaced by trained and authorized personnel DO NOT alter or change valve assembly DO NOT REMOVE THIS PRODUCT LABEL Lake Mary Blvd Sanford FL 32773 Not for Commercial Resale 1 800 832 4707 Part Number 1125090 Rev B 11 04 FIGURE Cylinder Prefill Inspection Part No 1118354 21 Platinum Series SECTION 3 COMPRESSOR OPERATION Connecting Disconnecting the Cylinder to the Compressor Connecting the Cylinder to the Compressor A WARNING DO NOT modify ANY connections on the HomeFill Il compressor NEVER use tools of any kind to connect disconnect the cylinder and the compressor Otherwise severe injury and or damage may occur DO NOT drop oxygen cylinders Use both hands when handling transporting oxygen cylinders Otherwise injury or damage may occur DO NOT use a liquid leak detector to test for leaks NOTE For this procedure refer to FIGURE 3 2 and FIGURE 3 3 1 Examine the cylinder gauge If the cylinder pressure is less than 1500 psig proceed to STEP 2 FIGURE 3 3 NOTE If the cylinder pressure is greater than 1500 psig DO NOT attempt to top off this cylinder It may not fill 2 Setthe regulator flow dial on the cylinder to Off FIGURE 3 3 3 Remove the cylinder and c
38. on if the oxygen level from the concentrator has not yet reached or drops below 90 The compressor will begin or resume filling when the oxygen level reaches 90 If light does not go Off within ten 10 minutes refer to the troubleshooting section on page NOTE If the ATTENTION RED light and audible alarm are on Refer to Troubleshooting Cylinder Fill times on page 31 of the HomeFill operator s manual part number 1100873 6 Remove the full cylinder Refer to Disconnecting the Cylinder from the Compressor on page 25 Part No 1118354 27 Platinum Series SECTION 3 COMPRESSOR OPERATION ATTENTION BELOW FULL RED Light and NORMAL GREEN Light Audible Alarm YELLOW Light Control Panel m INVACARE VENTURE HOMEFILL Il ATTENTION 02 BELOW NORMAL OPERATING INSTRUCTIONS FULL See Operator s Manual A WARNING RISK OF FIRE Keep matches lighted cigarettes and all other sources of ignition out of the room in which this product is located Textiles oil and other combustibles are easily ignited and burn with great intensity in oxygen enriched air A CAUTION RISK OF ELECTRICAL SHOCK DO NOT remove cover refer servicing to qualified service personnel CAUTION Federal law restricts this device to sale by or on the order of a physician or any other practitioner licensed 0 by the law of the state in which he practices to use or order the use of
39. onnector fillport covers if present CAUTION DO NOT connect the outlet cannula connection to the HomeFill II unit otherwise the conserving cylinder will not work properly 4 Momentarily push DOWN on the outer ring sleeve of the connector fillport to reset the connector as shown in FIGURE 3 2 Platinum Series 22 Part No 1118354 SECTION 3 COMPRESSOR OPERATION NOTE If the outer ring sleeve is in the UP position GREEN dots not visible the connector fillport will not be able to accept the cylinder fillport Pushing DOWN momentarily will reset the connector fillport GREEN dots visible to accept the cylinder fillport PUSH Outer Ring Sleeve DOWN Connector Fillport GREEN Dots BEFORE b COUPLING CYLINDER FIGURE 3 2 Resetting Connector Fillport 5 Grasp the cylinder regulator assembly in the area behind the cylinder gauge FIGURE 3 3 6 Position the cylinder in the compressor cradle FIGURE 3 3 7 Align the cylinder fillport with the connector fillport FIGURE 3 3 8 Pull UPon the outer ring sleeve of the connector fillport while pushing DOWN on the cylinder regulator assembly to couple the cylinder fillport into the connector fillport FIGURE 3 3 NOTE The cylinder is properly connected when an audible click is heard Part No 1118354 23 Platinum Series SECTION 3 COMPRESSOR OPERATION Compressor Cylinder Regulator Assembly Cylinder Fillpo
40. reference Dealer This manual MUST be given to the end user For more information regarding Invacare products parts and services INVACARE please visit www invacare com Yes you can WARNING WARNING DO NOT OPERATE THIS EQUIPMENT WITHOUT FIRST READING AND UNDERSTANDING THIS MANUAL IF YOU ARE UNABLE TO UNDERSTAND THE WARNINGS CAUTIONS AND INSTRUCTIONS CONTACT INVACARE TECHNICAL SERVICES BEFORE ATTEMPTING TO USE THIS EQUIPMENT OTHERWISE SERIOUS INJURY OR PROPERTY DAMAGE MAY RESULT ACCESSORIES There are many different types of humidifiers oxygen tubing cannulas and masks that can be used with this device You should contact your local home care provider for recommendations on which of these devices will be best for you They should also give you advice on the proper usage maintenance and cleaning A WARNING Invacare products are specifically designed and manufactured for use in conjunction with Invacare accessories Accessories designed by other manufacturers have not been tested by Invacare and are not recommended for use with Invacare products NOTICE The information contained in this document is subject to change without notice NOTE Updated versions of this manual are available on www invacare com Platinum Series 2 Part No 1118354 TABLE OF CONTENTS ACCESSORIES 2 SPECIAL 0 55 HOMEFILL INFORMATION
41. rt Connector Fillport Outer Ring Sleeve Cylinder Gauge Regulator Regulator Cylinder Fow Dial Cylinder Outlet Cannula Gauge Connection Cylinder Fillport Compressor Power Cradle Switch Connector 7 jA Outer Ring Fillport 2 Sleeve NOTE Fillport covers not shown for clarity FIGURE 3 3 Connecting the Cylinder to the Compressor Platinum Series 24 Part No 1118354 SECTION 3 COMPRESSOR OPERATION Disconnecting the Cylinder from the Compressor A WARNING NEVER use tools of any kind to connect disconnect the cylinder and the compressor Otherwise severe injury and or damage may occur NOTE For this procedure refer to FIGURE 3 4 1 Press the compressor power switch to the Off position 2 Grasp the cylinder regulator assembly in the area behind the cylinder gauge 3 With the other hand grasp the outer ring sleeve of the connector fillport and push DOWN 4 Liftupon the cylinder regulator assembly to remove from the connector fillport A Cvlinder Regulator A E Assembly PUSH DOWN Cylinder ge G auge Cds Outer Ring Sleeve Compressor Piper Connector Fillport FIGURE 3 4 Disconnecting the Cylinder from the Compressor Part No 1118354 25 Platinum Series SECTION 3 COMPRESSOR OPERATION 5 When the cylinder fillport is disconnected from the connector fillport release the outer ring sleeve of the connector fillport and use two hands to r
42. sor Hand Grip Hand Grip B Two hands Grasp the hand grips on the Hand Grip sides of the FIGURE 2 1 Transporting compressor the Compressor Installing the Power Cord NOTE For this procedure refer to FIGURE 2 2 1 Ensure the compressor is ona hard flat stable surface such as a table 2 Plug the power cord into the electric connector in the back of the compressor 3 Plug the opposite end of the power cord into the wall outlet Part No 1118354 Platinum Series SECTION 2 INITIAL SETUP Wall Compressor Outlet REAR Power Cord C NEW 4 EY Electrical Connection NOTE This product has a polarized plug one blade is wider than the other As a safety feature this plug will fit in a polarized outlet only one way If the plug does not fit fully in the outlet reverse the plug If it still does not fit contact a qualified electrician DO NOT attempt to defeat this safety feature FIGURE 2 2 Installing the Power Cord Connecting the Compressor to the Concentrator NOTE For this procedure refer to FIGURE 2 3 1 Insert one 1 end of the interconnect hose into the outlet fitting on the back of the concentrator Detail A 2 Insert the opposite end of the interconnect hose into the inlet fitting on the side of the compressor Detail B NOTE The metal tabs on the concentrator outlet fitting and th
43. struction NOTICE The Homerill Il compressor is for use with specially designed Invacare Platinum 5 10 and XL HomeFill 11 compatible concentrators The concentrator can be set to the following maximum flowrates when operating with HomeFill compressor Platinum 5 and XL 3 L min or less Platinum 10 5 L min or less To determine if your concentrator is HomeFill Il compatible examine the lower right corner of the rear of the concentrator for an outlet fitting refer to illustration on next page Part No 1118354 5 Platinum Series HOMEFILL Il INFORMATION TOP VIEW Outlet Fitting Power Cord Concentrator Platinum Series 6 Part No 1118354 SECTION GENERAL GUIDELINES SECTION GENERAL GUIDELINES WARNING SECTION IMPORTANT SAFEGUARDS contains important information for the safe operation and use of this product DO NOT use this product or any available optional equipment without first completely reading and understanding these instructions and any additional instructional material such as Owner s Manuals Service Manuals or Instruction Sheets supplied with this product or optional equipment If you are unable to understand the Warnings Cautions or Instructions contact a health care professional dealer or technical personnel before attempting to use this equipment otherwise injury or damage may occur NOTICE Refer to Homerill Il Compressor Owner s M
44. this device AIT FILLING 9 WAIT FILLING Power Switch YELLOW Light GREEN Light FIGURE 3 5 Turning the Compressor On Setting the Flow Knob to the Prescribed Setting NOTE For this procedure refer to FIGURE 3 6 1 Attach the nasal cannula to the outlet fitting of the cylinder 2 Turn the flow knob to the L min setting prescribed by your physician or therapist Platinum Series 28 Part No 1118354 SECTION 3 COMPRESSOR OPERATION A WARNING As changing the L min setting on the flow knob will affect the dose of oxygen delivered DO NOT readjust the L min setting unless directed by your physician or therapist 3 To turn the flow of oxygen Off turn the flow knob counter clockwise to the Off position Outlet Fitting How Knob Prescribed Setting FIGURE 3 6 Setting the Flow Knob to the Prescribed Setting NOTICE Refer to Homerill II Compressor Owner s Manual 1100873 for detailed information on all warnings use and maintenance of the HomeFill 1 compressor Part No 1118354 29 Platinum Series CONCENTRATOR WARRANTY CONCENTRATOR WARRANTY NOTE THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4 1975 This warranty is extended only to original purchaser of our products This warranty gives you specific legal rights and you may also have other legal rights which may vary from state to state Invacare Corporation warrants i
45. tion by email and or mail about any available Invacare products that may help treat care for or manage such condition s Would you like to receive updated information via email or regular mail about the Invacare home medical products sold by Invacare s dealers Yes No What would you like to see on the Invacare website Would you like to be part of future online surveys for Invacare products Yes No User s Year of birth If at any time you wish not to receive future mailings from us please contact us at Invacare Corporation CRM Department 39400 Taylor Parkway Elyria OH 44035 or fax to 877 619 7996 and we will remove you from our mailing list TO FIND MORE INFORMATION ABOUT OUR PRODUCTS VISIT WWW INVACARE COM SALVLS AHLNI qxanivi AHVSS3O3N 39V1SOd ON 9 86 S 0tv HO VIHAA YOTAVL 00768 INJINLH4dAG Wad NOILVAOAHOD JAVOVANI 33SS3HQQV 38 TIIM ADVLSOd HO VIaXT3 961 ON LIINH3d JIV SSVIDISHI4 TVN A1d38 SSANISNG SECTION 5 OPERATING INSTRUCTIONS SECTION 5 OPERATING INSTRUCTIONS Introduction Your oxygen concentrator is intended for individual use in the home It is an electronically operated device that separates oxygen from room air It provides high concentration of oxygen directly to you through a nasal cannula Clinical studies have documented that oxygen concentrators are therapeutically equivalent to other types of oxy
46. ts Platinum Oxygen Concentrator to be free from defects in materials and workmanship from date of purchase Platinum 5 and XL for a period of five 5 years Platinum 10 for a period of three 3 years The 4 way valve body carries a lifetime warranty from date of purchase DO NOT OPEN OR ATTEMPT TO SERVICE VALVE BODY This will void any and all warranty applicable to the valve body If within such warranty period any such product shall be proven to Invacare Corporation s satisfaction to be defective such product shall be repaired or replaced at Invacare Corporation s option This warranty only applies to the labor for repairs performed by the Invacare Service Department or Invacare Service Centers It does not apply to the labor performed by the purchaser or user This warranty does not include normal wear and tear or shipping charges Invacare Corporation s sole obligation and your exclusive remedy under this warranty shall be limited to such repair or replacement Routine maintenance items such as filters are excluded from this warranty For warranty service please contact Invacare Corporation s Service Department at the toll free number on the back cover Upon receiving notice of an alleged defect in a product Invacare Corporation will issue a serialized return authorization It shall then be the responsibility of the purchaser to return the entire unit or remove at purchaser s cost the defective component part s identified pack the
47. urity of oxygen generated by the oxygen concentrator If purity falls below factory preset standards indicator lights on the control panel will illuminate Initial Startup of the Concentrator NOTE Concentrator may be used during the initial start warm up time approximately 30 min while waiting for the O purity to reach maximum When the unit is turned on the GREEN light will come on SYSTEM OK O greater than 85 After five 5 minutes the oxygen sensor will be operating normally and will control the indicator lights depending on oxygen concentration values Explanation of Oxygen Purity Indicator Lights NOTE For this procedure refer to FIGURE 5 7 GREEN light Normal Operation YELLOW light Call supplier IMMEDIATELY You may continue to use the concentrator unless instructed otherwise by your supplier Be certain that backup oxygen is nearby RED light Q Total unit shutdown Switch IMMEDIATELY to backup oxygen supply Call supplier IMMEDIATELY GREEN light with YELLOW light flashing Call supplier IMMEDIATELY Oxygen sensor malfunctioning you may continue to use the concentrator Part No 1118353 27 Platinum Series SECTION 5 OPERATING INSTRUCTIONS OXYGEN PURITY Auto Shut Down Use Backup RED gt Supplier Below Normal N YELLOW Normal Os GREEN FIGURE 5 7 SensO Oxygen Purity Indicator If Your Unit Features the O Sensor Feature Ind
48. y After one second only the GREEN system ok power light will stay FIGURE 5 5 Power Switch on Part No 1118353 25 Platinum Series SECTION 5 OPERATING INSTRUCTIONS Flowrate NOTE For this procedure refer to FIGURE 5 6 1 Turn the flowrate knob to the setting prescribed by your physician or therapist A WARNING DO NOT change the L min setting on the flowmeter unless a change has been prescribed by your physician or therapist NOTE To properly read the flowmeter locate the prescribed flowrate line on the flowmeter Next turn the flow knob until the ball rises to the line Now center the ball on the L min line prescribed 2 Ifthe flowrate the flowmeter ever falls below 0 5 L min for Platinum 5 1 L min for Platinum 10 for more than about one minute the LOW FLOW alarm will be triggered This is a rapid beeping of the audible alarm Check your tubing or accessories for blocked or kinked tubing or a defective humidifier bottle After rated flow is restored more than 0 5 L min for Platinum 5 1 L min for Platinum 10 the LOW FLOW audible alarm will go off NOTE The use of some accessories such as the pediatric flowstand and the HomeFill II compressor will deactivate the Low Flow Alarm Ball FIGURE 5 6 Flowrate Platinum Series 26 Part No 1118353 SECTION 5 OPERATING INSTRUCTIONS SensO Oxygen Purity Indicator If Your Unit Features the O Sensor Feature This feature monitors the p
Download Pdf Manuals
Related Search