Home

manuale di uso e manutenzione use and maintenance manual

image

Contents

1. Figure 3 Figure 4 73 70097 70099 70100 Figures 3 and 4 illustrate the ZEUZO 20 model but the assembly criteria for the various components is exactly the same 73 2 Part replacement To separate main ADV parts rest the ADV on the propeller flow conveyor on a flat surface so that it is standing with the battery towards the top After removing the shell C remove and put away the battery unscrew the 4 nuts Y and remove the battery support B If the new shell C is of a different size use a PH2 Phillips screw to unscrew the 6 screws X and remove the adapter ring D see fig 4 To reassemble the ADV perform the above operations in reverse order replacing the parts required for the transformation WARNING Screw in the self threading screws X with care do not excessively tighten since they could damage the motor body made of plastic The 4 nuts Y should be adequately tightened In addition to part assembly they guarantee that the motor body is watertight and separate from the battery compartment Ensure that they are correctly tightened Also pay attention to seal gaskets Always keep them clean and lubricated with their relevant housings 74 After sales service The company s after sales service is at your disposal at all times Any requests may be addressed to SUEX srl Submarine Exploration Via Roma 261 35 31020 VILLORBA TV ITALY Telephone 0422 444800 Fax 0422 620684 www suex
2. 49 3 Danger zone and residual hazards The propeller is protected by a surrounding strip but is exposed at both the intake and outflow ends No additional guards have been installed at these points since these would reduce fluid flow considerably drastically reducing the efficiency of motor thrust Entanglement and cut hazards Do not insert any object or body part inside the flow duct that could obstruct the rotating propeller blades When in use besides the hand on the trigger a safety distance of at least 40 cm must be maintained between the divers body and the propeller assembly Back injury hazard When out of the water be careful if lifting the vehicle without any lifting aids Another person s help is recommended Crushing hazard During the closing operation of the main body or of the head cap be careful don t put the fingers bb 49 4 Safety device A torque limiting device is installed between the motor and the propeller When the resistance felt by the propeller exceeds a certain torque this device intervenes preventing the propeller from rotating The device will generate a rhythmic sound signalling its insertion If this situation occurs release the trigger immediately switch off the power by means of the main switch and free the propeller of the foreign body Do not leave the torque limiting device inserted for more than 10 seconds It has been conceived for emergency purposes and may be damaged by pro
3. 6 Ricambi Nella seguente tabella sono elencati i materiali considerati di normale usura Qualsiasi altro componente disponibile su richiesta SUEX AVVISO DI PERICOLO LEGGERE QUANTO SEGUE 70097 70099 70100 LEGGERE ATTENTAMENTE IL MANUALE DI USO E MANUTENZIONE IN OGNI SUA PARTE COMPRESA LA SEZIONE 6 INFORMAZIONI PER LA SICUREZZA E LA SEZIONE 8 USO SUEX srl e consegna all acquirente il veicolo subacqueo di seguito denominato ADV in perfetto stato di manutenzione completo di manuale di uso e manutenzione e assume che chi si appresta ad utilizzare il veicolo subacqueo abbia seguito uno specifico addestramento per la conduzione di veicoli subacquei del genere e di aver conseguito la necessaria certificazione da parte di un agenzia qualificata e assume che chi si appresta ad utilizzare il veicolo subacqueo abbia letto questo il manuale di uso e manutenzione fornito in dotazione nel quale vengono specificati in particolare le modalit di utilizzo del veicolo subacqueo con la specificazione della configurazione corretta dell attrezzatura utilizzata dal subacqueo della posizione che deve assumere il subacqueo durante l utilizzo stesso nonch dell assetto che il veicolo subacqueo deve mantenere durante l immersione che detto veicolo non deve in alcun modo essere unito in modo non facilmente svincolabile al suo utilizzatore gli ambienti in cui l utilizzo del veicolo subacqueo risulta partic
4. CAUTELA Non forzare a fine corsa la manopola del regolatore di velocit il potenziometro all interno potrebbe danneggiarsi 18 SUES 70097 70099 70100 15 Autonomia dati di autonomia forniti sono indicativi e comunque si riferiscono ad un utilizzo con mezzo in perfetta efficienza in ambienti temperati in assenza di correnti a medio carico subacqueo con monobombola o bibombola 12 12 It in perfetto assetto idrodinamico In linea di principio va calcolato il tempo per coprire il percorso di andata e ritorno deve venire inoltre stabilita una RISERVA di autonomia che varier a seconda del tipo di immersione In ogni caso si DEVE programmare l immersione tenendo conto di poter tornare al punto di emersione senza l ausilio del ADV 16 Velocit Come per l autonomia anche la velocit dipende dagli stessi fattori Si dovr considerare la velocit compatibile al tipo di immersione ed adeguandola a quella dei compagni Velocit di discesa L ADV permette una velocit di discesa elevata EVITARE il suo utilizzo per incrementarla in quanto aumentano i problemi legati alla compensazione ed all ambientamento psico fisico Velocit di risalita L ADV NON DEVE ESSERE UTILIZZATO PER LA RISALITA VERTICALE infatti il suo utilizzo in tal senso pu indurre una risalita troppo veloce e quindi POTENZIALMENTE PERICOLOSA pertanto opportuno posizionarlo ove non crei intralcio DOPO AVERLO DISATTIVATO RUO
5. m ae Piombo Pb 27 Condizioni ideali per la ricarica della batteria Temperatura ambiente ammessa da 10 C a 35 C ideale 20 C Opzione di carica lenta quando il caricabatteria lo consente Temperatura della batteria all inizio della ricarica 20 C Condizioni diverse da quelle sopra descritte possono influenzare sensibilmente la ricarica nonch il numero di ricariche possibili con una resa accettabile 24 70097 70099 70100 28 Condizioni ideali per la scarica della batteria Raccomandiamo di utilizzare la batteria ad una temperatura ambiente compresa tra 5 C e 35 C Per evitarne il deterioramento in tempi brevi e la possibile inversione di polarita delle celle la batteria non deve essere in nessun caso mai scaricata del tutto Quando durante l uso dell ADV si notasse un sensibile calo di potenza all elica non insistere con il comando di avvio in quelle condizioni di scarica della A batteria E VIVAMENTE SCONSIGLIATO UTILIZZARE ULTERIORMENTE VEICOLO SUBACQUEO la batteria si sta avviando ad una sovrascarica Durante Plutilizzo dellADV buona norma non procedere costantemente alla massima velocit ma utilizzare il variatore di giri magari sospendendo l avvio frequentemente facendo delle brevi pause in questo modo di d il tempo alla batteria di attuare meglio la reazione chimica necessaria alla generazione della corrente evitando bruschi riscaldamenti delle celle 28 1 Nota importante sul
6. ADV in tale ambiente aumenta il rischio dell immersione stessa Prima dell uso accertarsi che la batteria sia stata ricaricata che i connettori siano collegati e che non vi siano parti elettriche ossidate controllare la chiusura della calotta di prua l integrit del corpo principale soprattutto a seguito di urti o incisioni accidentali il funzionamento del grilletto e dell interruttore generale A questo punto il mezzo pronto per l utilizzo Dopo essere entrati in acqua necessario ruotare l interruttore generale in senso orario in posizione di marcia con la sola forza delle dita non un interruttore a scatto ma il suo comportamento simile ad un rubinetto dell acqua cio necessario pi di un giro completo per chiudere od aprire il contatto Non forzare a fine corsa l interruttore potrebbe danneggiarsi CAUTELA L interruttore generale deve essere ruotato in senso orario in posizione di marcia solamente quando si in acqua far girare lelica in aria pu essere pericoloso e danneggia la tenuta idraulica dell albero motore bb PERICOLO Una volta immersi per azionare lelica necessario tirare verso di s il grilletto integrato nella maniglia rilasciando il grilletto lelica si arresta La velocit pu essere regolata dallo 0 al 100 della velocit massima tramite la manopola di regolazione velocit ruotandola in senso orario la velocit diminuisce in senso antiorario la velocit aumenta
7. La batteria deve essere collegata al caricabatteria per mezzo dell apposito connettore Prima di effettuare la ricarica ASSOLUTAMENTE NECESSARIO estrarre la batteria dall ADV e attendere almeno due ore prima di iniziare il processo di ricarica Durante il processo di ricarica alla batteria non deve essere connesso alcun dispositivo La batteria va conservata fuori dall ADV ed inserita e collegata al motore solo immediatamente prima dell utilizzo va disconnessa ed estratta immediatamente dopo l utilizzo 25 Come ricaricare la batteria PERICOLO PERICOLO gt p Estrarre la batteria dal ADV Posizionarla in un luogo protetto aerato e lontano da cose infiammabili o persone PRIMA collegare il caricabatteria al connettore di ricarica batteria diverso a seconda del modello posto sulla batteria DOPO collegare il caricabatteria alla rete elettrica Attendere la completa ricarica vedi istruzioni caricabatteria Riposizionare la batteria all interno dell ADV prima dell utilizzo In alcuni modelli fisicamente possibile caricare la batteria anche senza estrarla dall ADV sconsigliato in quel caso si raccomanda di posizionare il mezzo in un luogo protetto aerato e lontano da cose infiammabili o persone ed assicurarsi sempre che l interruttore principale dell ADV sia in posizione OFF NON TENTARE DI RICARICARE BATTERIE DANNEGGIATE O CHE PRESENTINO PERDITE DI LIQUIDO OSSIDAZIONI O ALTRI DANNI S
8. alimentazione elettrica e la manopola di regolazione della velocit 7 L involucro esterno costituito dalla calotta di prua 8 sulla quale inserito il volantino di chiusura 9 ed il tubo 10 La calotta inserita nel tubo e trattenuta da un anello interno La tenuta assicurata da delle guarnizioni di tipo O ring SUES 70097 70099 70100 SUES 70097 70099 70100 2 Dati tecnici ADV 20 Dimensioni Lungh x Largh x Alt mm 779x460x364 Peso Kg 36 2 Velocit max m min 60 Autonomia media min 60 Voltaggio V DC 24 Tempo ricarica batterie h 8 Profondit max operativa m 120 ADV 33 Dimensioni Lungh x Largh x Alt mm 1079x460x364 Peso Kg 50 9 Velocit max m min 60 Autonomia media min 60 Voltaggio V DC 24 Tempo ricarica batterie h 10 Profondit max operativa m 120 ADV 42 Dimensioni Lungh x Largh x Alt mm 1219x460x364 Peso Kg 59 Velocit max m min 60 Autonomia media min 60 Voltaggio V DC 24 Tempo ricarica batterie h 12 Profondit max operativa m 120 Calcolata con accumulatori nuovi sfruttati per 80 della loro capacit in esercizio normale non continuo in assetto con bi bombola e GAV SUES 70097 70099 70100 3 Operazioni preliminari Controllare l integrit dell imballo e dei materiali in dotazione vedi cap 5 3 1 Apertura dell involucro Posiz
9. essere un lieve innalzamento della temperatura della batteria Qualora si verificasse un surriscaldamento della batteria o di una parte della stessa interrompere immediatamente il processo di ricarica e sostituirla E normale un riscaldamento della batteria durante la scarica Come per la ricarica anche durante la scarica la batteria subisce un lieve innalzamento della temperatura e valgono le stesse considerazioni fatte sopra Quanto tempo dura in buona efficienza una batteria al piombo se non utilizzata Dipende da molti fattori soprattutto dalla qualit della batteria Di solito una batteria ricaricata almeno ogni tre mesi e non scaricata dura anche cinque anni Quanto tempo dura una batteria utilizzata sui vostri ADV Con un utilizzo sportivo dell ADV ovvero una cinquantina di immersioni all anno usualmente una batteria dura in buone condizioni per un periodo di circa tre anni per un totale di circa 150 ricariche Se utilizzata pi spesso pu arrivare anche a circa trecento utilizzi Quando la batteria esaurita cosa devo farne La batteria va smaltita in un apposito centro di recupero batterie al piombo esauste in tutte le citt vi sono degli appositi centri di raccolta Ho lasciato la batteria in barca e gli agenti marini hanno ossidato i contatti argentati del connettore cosa devo fare Tutti i contatti elettrici che sono all interno del vano batterie dell ADV non devono assolutamente generare scariche elettriche o sc
10. lo scooter acceso e dopo qualche decina di secondi di funzionamento Ogni utilizzatore deve imparare a conoscere il segnale luminoso del dispositivo in quanto impossibile determinare una tabella di durata tra l accensione di un led o l altro essa dipende dal modo di utilizzo dell ADV velocit impostata Sicuramente per l accensione di un solo led deve mettere in avviso il subacqueo che la batteria sta esaurendo la carica e che consigliabile non utilizzare ulteriormente lo scooter Il segnalatore luminoso molto utile anche perch indica che ADV acceso e pronto per l utilizzo 36 70097 70099 70100 35 Accessori opzionali DISPOSITIVO BY PASS Il dispositivo denominato BY PASS un accessorio montato su alcuni modelli a richiesta del cliente Tale dispositivo riconoscibile come um pomello bianco posto sul lato sinistro del gruppo motore esattamente opposto all interruttore generale connette elettricamente in modo diretto la batteria al motore elettrico escludendo qualsiasi altro dispositivo normalmente utilizzato per il funzionamento elettrico dell ADV grilletto regolazione della velocit controllo elettronico L utilizzo di questo dispositivo potenzialmente pericoloso in quanto una volta azionato avvia il motore in modo continuo alla massima potenza e l unico controllo che possiamo effettuare e quello dello spegnimento tramite l interruttore generale o tramite il pomello del by pass ABBANDO
11. never fully deplete the battery since make short dives Should remove the battery after every use and charge it A lead battery has no memory effect it is always best to charge it prolonging accumulator life and ensuring maximum autonomy The battery should be kept off the ADV and inserted and connected to the engine only immediately prior to use It should be disconnected and removed immediately after use Can leave the battery connected to the battery charger for a long period of time After charging our battery chargers enter idle mode and can be left attached to the battery as long as you like They only charge if necessary However it is always best to disconnect them as soon as charging is finished dropped the battery and it has a dented corner Can still use it Obviously this depends on the extent of the dent Lead gel batteries are usually durable however they must be replaced if the case is so damaged that electrolyte leaks In any case a dropped battery may have internal damages to cell connections and replacement is recommended Is battery heating normal when charging Given that a battery should always be charged at room temperature between 15 C and 25 C the battery s temperature may slightly rise during charge Should the battery or a part of it overheat during charge stop charging immediately and replace Is battery heating normal when outputting As with charging battery output slightly raises battery tempera
12. A positioning the vehicle in a dry well ventilated place away from people and flammable materials and make sure the ADV main switch is always OFF OR OTHERWISE DAMAGED BATTERIES DO NOT ATTEMPT TO CHARGE DAMAGED LEAKING RUSTED A SUEX S r l IS AVAILABLE FOR ANY NECESSARY TECHNICAL ASSISTANCE 60 70097 70099 70100 63 Pb gel battery information The battery is generally made up of two single 12 volt batteries connected in sequence to achieve 24 volt voltage Factory assembled they are wired with a power cord and connector for hook up If a perceptible drop in distributed power is noticed during ADV use immediately stop use and turn off using the switch NEVER leave the battery connected to the ADV when not in use Charge the battery at least once a month Charge the battery before each use letting the battery cool if heated before inserting it in the ADV during this phase the battery could release hydrogen which would inevitably accumulate inside the ADV which is air tight Hydrogen accumulation in special conditions could cause accidents with consequent damages to people and property Replace battery at the end of its charge cycles on our machines the lead battery could operate for 150 to 300 cycles depending on use a dead battery in addition to having lost its capacity to store energy inevitably produces hydrogen gas Only use Suex srl approved batteries exclusively charging them with their approved battery cha
13. IN SUCH ENVIRONMENTS INCREASE DIVING HAZARDS It is important to remember that maximum diving vehicle operating depth refers to the ADV in prime conditions Collisions scratches or deformations significantly reduce this limit Obstructed environments Dives in such environments are already VERY DANGEROUS INCORRECT USE OF THE ADV IN SUCH ENVIRONMENTS INCREASES THE DIVING HAZARDS For example if the control valves are hit accidentally whilst travelling at high speeds these may break with obvious consequences DIVING IN SUCH ENVIRONMENTS REQUIRES ADEQUATE TRAINING BY QUALIFIED AGENCIES It is hereby emphasized that the running time of both the ADV and the breathing gas must be planned in such a manner that every team member has TWICE the necessary resources available It is also obligatory to carry another extra ADV Muddy or suspension filled environments These include those environments obstructed or otherwise in which visibility may suddenly fall to zero due to the suspension that is created by moving the bed sediment Dives in these environments are already VERY DANGEROUS INCORRECT USE OF THE ADV IN SUCH ENVIRONMENTS INCREASES THE DIVING HAZARDS DIVING IN SUCH ENVIRONMENTS REQUIRES ADEQUATE TRAINING BY QUALIFIED AGENCIES For example the rotating propeller that faces downwards can lift a considerable amount of suspension Accidental activation of an emergency ADV in tow may create highly critical situations 56 SUES 70097 70099
14. THE SCCOTER IS NOT IN USE RIMUOVERE LE BATTERIE DOPO L USO REMOVE THE BATTERIES AFTER THE USE NON FUMARE O USARE FIAMME LIBERE DURANTE L APERTURA DO NOT SMOKE AND DO NOT USE OPEN FLAMES DURING THE OPENING PROCEDURE PRIMA DI OGNI IMMERSIONE CONTROLLARE CHE CONNETTORI ELETTRICI SIANO INSERITI CONTROL LARE LE GUARNIZIONI DI TENUTA E ASSICURARSI CHE LO SCOOTER SIA CHIUSO A FONDO BEFORE EVERY DIVE CHECK THAT THE ELECTRICAL CONNECTORS ARE INSERITED PROPERLY CHECK THE GASKETS ENSURE THAT THE SCOOTER IS CLOSED COMPLETELY PER NON DANNEGGIARE LE BATTERIE SPEGNERE SEMPRE DOPO L USO O QUANDO INTERVIENE L AVVISATORE ACUSTICO ALWAYS TURN OFF AFTER THE USE AND WHEN THE WARNING SIREN SOUNDS TO PREVENT DAMAGE TO THE BATTERIES LE BATTERIE VANNO RICARICATE IN LOCALI AERATI NON DEVONO ESSERE RICARICATE ALL INTERNO DI CONTENITORI ERMETICI NON DEVONO ESSERE RICARICATE IN PARALLELO SE PRESENTANO PERDITE DI LIQUIDO O RIGONFIAMENTI NON POSSONO PIU ESSERE UTILIZZATE BATTERIES MUST BE CHARGED IN WELL VENTILATED ROOMS AND MUST NOT BE CHARGED INSIDE AIRTI GHT CONTAINERS THEY MUST NOT BE CHARGED IN PARALLEL DISPOSE OF LEAKY OR SWELLED BATTE RIES NON BAGNARE CONTATTI ELETTRICI DO NOT WET ELECTRICAL CONTACTS NON USARE LO SCOOTER SE NON PERFETTAMENTE FUNZIONANTE DO NOT USE THE SCOOTER IF IT IS NOT PERFECLY OPERATIONAL NON RIMUOVERE QUESTA ETICHETTA sa DO NOT REMOVE THIS LABEL SUBMARINE EXPLORATION WWW SUEX IT ITALY 51 70097 7
15. Vedi ricambi cap 18 Il grilletto di comando si incastra e ADV rimane Spegnere l ADV provare a far scorrere il pistoncino acceso di avviamento comandato dal grilletto per far uscire eventuali corpi estranei riprovare ad accendere Se ADV continua a funzionare va verificato il sistema di avviamento probabilmente ha subito un urto con conseguenti danni operazioni da eseguire in centro di assistenza autorizzata SUEX 21 70097 70099 70100 22 Manutenzione Manutenzione OR tenuta Aprire l ADV togliere con delicatezza l O ring di tenuta facendo molta attenzione a non rigare le superfici di appoggio dell O ring stesso pulire accuratamente la sede solo ed esclusivamente con un pennello o straccio morbido puliti non usare alcun tipo di solvente o alcool rimettere al suo posto la guarnizione lubrificata di olio siliconico non usare altro tipo di olio consigliato quello in bomboletta spray usato abitualmente per le attrezzature subacquee Saltuariamente lubrificare con normale grasso minerale la vite del pomolo di chiusura Non lubrificare mai il movimento del grilletto od il pistoncino magnetico si riempirebbero di sabbia e sporcizia Non lubrificare i contatti elettrici Manutenzione straordinaria Ogni cento ore di utilizzo o almeno ogni due anni consiglata la revisione dell ADV con la verifica delle tenute idrauliche e dei circuiti elettrici SUEX S r l provvede alla completa revisione del vostro ADV c
16. con le pale dell elica in rotazione durante l uso deve PERICOLO essere mantenuta a parte la mano sul grilletto una distanza di sicurezza di almeno 40 cm dall apparato propulsore Rischio di lesioni dorso lombari In superficie usare cautela se il sollevamento del mezzo avviene PERICOLO manualmente senza l ausilio di attrezzi idonei E consigliabile farsi aiutare da una seconda persona Rischio di schiacciamento Durante la fase di chiusura del tubo o della calotta fare attenzione a non PERICOLO interporre le dita 12 4 Dispositivo di sicurezza Tra l apparato motore e lelica vi un dispositivo limitatore di coppia quando la resistenza applicata all elica supera un determinato momento torcente esso scatta impedendo all elica di continuare a girare Il dispositivo produrr un rumore ritmico che avvertir immediatamente A della sua inserzione Non appena si dovesse presentare questa situazione rilasciare immediatamente il grilletto togliere tensione CAUTELA tramite l interruttore sezionatore e liberare l elica dal corpo estraneo non mantenere in funzione continua oltre i 10 secondi il limitatore di coppia concepito per l uso in emergenza ed una inserzione protratta nel tempo ne potrebbe causare il danneggiamento Se le condizioni di utilizzo vi permettono di estrarre il corpo estraneo dall elica durante l immersione in tutta sicurezza fatelo altrimenti abbandonate l ADV per poi ev
17. delle parti 36 2 Sostituzione delle parti 37 ENGLISH VERSION 38 Description and operating principleS nre iii 40 39 40 40 1 40 2 40 3 40 4 41 42 44 45 45 1 46 48 49 49 1 49 2 49 3 49 4 72 72 1 73 73 1 73 2 74 70097 70099 70100 Technical specifications rr rr einen 42 Preliminaryvoperations i urinaria 43 Openingthe lU EE 43 Accessing the Battery EE 44 Inserting the Dattery 2 3 ssid Acie geed EES ae EE EEN ei 46 n Bu CITE 46 Buoyancy AC UStMOM tics cisiisesceciensdsetcsssdesccesandaveccaccusessiacsenssidvancoaaasavesecseccauadsesoadsduacuessucataysasuncessiscscasdeauanessanaae 46 Components aaa 47 Spare Patt E 47 Product identificatioN rrnrrriiiri iii 50 General safety and accident prevention regulations ccseccceeccseeeeeseeeeseeeseeeeeseeeeeeeeeseeesseeeaseeesseeeeseeeseeeenss 50 Tale let weg el EE 51 Using the Vehicle srt eine 52 Warranty 52 Battery WarrantY rin 52 Safety instructions iaianialia iaia 53 WE WR RR OR TRA 53 Equipment configuration and riding positioN i 53 Danger zone and residual hazardS e 54 Safety device ii 54 Handling TTT 54 Using the ADV diving vehicle rrrrrriiiii irene 55 Running Ku TN 55 Speed lane iaia 56 Depth and operating environments nrrrrrrrer
18. lock it to assume a horizontal position An excessively POSITIVE NEGATIVE or decisively tilted position is potentially HAZARDOUS 46 42Components The ADV is delivered complete with the following components Use and maintenance manual Battery charger complete with use and maintenance manual Weights for buoyancy adjustment in seawater According to models ZEUXO 20 20 Ah lead battery ZEUXO 33 33 Ah lead battery ZEUXO 42 42 Ah lead battery 43 Spare parts The following table lists those components most likely to wear PART NO 70197 70202 70012 70104 70105 70093 70036 70203 70204 Any other part is available on request 70097 70099 70100 47 70097 70099 70100 WARNING PLEASE READ THE FOLLOWING CAREFULLY READ THE USE AND MAINTENANCE MANUAL IN ITS ENTIRETY INCLUDING SECTION 6 SAFETY INSTRUCTIONS AND SECTION 8 USING THE ADV The manufacturer SUEX s r l declares that e the ZEUXO Mod Tech Advanced diving vehicle henceforth called ADV shall be delivered to the buyer in perfect working condition complete with its use and maintenance manual e any person attempting to use the diving vehicle shall be deemed to have undergone specific training in the use of similar diving vehicles and to have obtained the necessary certification issued by a qualified agency e any person attempting to use the diving vehicle shall be deemed to have read the use and maintenance manual pro
19. made by unauthorized personnel Defects or damages due to product use in conditions other than those customary Defects or damages due to incorrect controls operations maintenance installation adjustments unauthorized applications or any other alteration or modification of any form Broken or damaged wires or connections unless directly due to material or factory defects Parts removed or repaired by parties other than SUEX S r l that deteriorate correct operations or prevent adequate inspections for warranty service purposes Defects or damages due to humidity liquids or foreign objects introduced within the battery pack Extended wires or with ruined or missing insulation Scratches or damages to any plastic surface and any other external device part due to normal product use by the consumer Temporarily rented products Periodic maintenance and repairs or part replacement due to normal wear or deterioration 52 70097 70099 70100 49Safety instructions 49 1 Training The ADV may be used by technical or recreational divers alike In either case it is assumed that whoever is effecting the dive has obtained the necessary certification issued by qualified certification agencies At any rate use of the ADV implies that the user has undergone specific training that permits him to use the vehicle safely and to fully appreciate its potential Do not forget that the greatest danger is constituted by the underwater environment being expl
20. motore dell ADV puramente indicativa raffigura una parte di esso per puro scopo esplicativo 31 SUES 70097 70099 70100 32 5 Problemi cause e rimedi elica prop lock PROBLEMA CAUSA RIMEDIO E necessario un grande sforzo per ruotare il pomello Il pomello stato danneggiato va sostituito bianco Anche se la spina dell albero nella corretta La spina di trazione stata danneggiata piegata e posizione nella sede dell elica la frizione saltella e lo va sostituita scooter non avanza Il mozzo dell elica stato danneggiato va sostituito Stringendo il pomello bianco gira a vuoto e non ferma E stata impiegata troppa forza nello stringere il l elica pomello e si danneggiato va sostituito Stringendo la vite sul pomello gira a vuoto Il pomello stato danneggiato va sostituito operazioni da eseguire in centro di assistenza autorizzata SUEX Nota Utilizzando l elica prop lock si monta un tipo di elica che di ingombro maggiore rispetto a quella standard il pomello bianco sporge in pi Questo significa che quando appoggiamo lo scooter sul convogliatore in posizione verticale dobbiamo fare maggior attenzione a come lo posizioniamo Eventuali colpi all elica pi sporgente potrebbero danneggiare sia l elica prop lock che lo scooter stesso 33 Accessori opzionali COMANDO N HANDLE 33 1 Descrizione Il dispositivo di comando N Handle stato realizzato per f
21. ricaricandole usando esclusivamente i caricabatteria approvati dalla stessa Quando il caricabatteria non viene usato scollegarlo dalla presa di rete Se non utilizzata una batteria anche completamente carica si scarica lentamente per effetto del fenomeno di autoscarica comunque consigliato ricaricare le batterie nelle 24 ore precedenti l utilizzo Temperature estreme incidono sensibilmente sulla capacit di carica della batteria Lasciare la batteria in ambienti caldi o freddi come ad esempio in un auto completamente chiusa in piena estate o pieno inverno ridurr la capacit e la durata della batteria stessa Cercare sempre di tenere le batterie ad una temperatura compresa tra 15 C e 25 C Il rendimento delle batterie notevolmente ridotto a temperature inferiori a 0 C NON GETTARE LE BATTERIE SUL FUOCO ESPLODONO Non utilizzare la batteria per scopi diversi da quelli prescritti Non utilizzare mai caricabatteria o batterie che risultino danneggiati La custodia degli accumulatori deve avvenire all esterno dell ADV in luogo asciutto umidit relativa 65 5 e temperatura compresa tra i 5 C ed i 25 C con i connettori elettrici lontani da oggetti metallici che possano cortocircuitare i due poli della batteria con grave pericolo di incendio danni a cose e persone Non bagnare i contatti elettrici Disfarsi delle batterie applicando le regolamentazioni locali ad esempio riciclandole Non gettarle tra i rifiuti domestici
22. 0099 70100 46 Using the vehicle The diving vehicle manufactured by SUEX s r l is a vehicle that has been designed and constructed for dive transportation purposes Customers and third parties are forbidden from carrying out any alterations that may substantially modify its intended purpose The vehicle has been designed sized and constructed for the sole purpose described above Any other use or operation that does not comply or agree with the instructions contained in this manual may result in damage to the vehicle This would prevent the conditions for which it has been designed and built from being achieved and may compromise its technical and safety characteristics The manufacturer shall not be liable for damage to persons and or objects deriving from inappropriate use of the vehicle 47 Warranty The product is covered against all manufacturing defects for the period determined by the law in force The warranty shall cease to be effective if use of the vehicle does not comply or agree with that envisaged and described by this manual Improper use negligence and attempts by unauthorized persons to repair or modify the vehicle shall void the warranty see special battery warranty conditions 48 Battery warranty The batteries both Pb and NiMH supplied with our ADV are guaranteed by law excluding Defects due to damages incorrect use accident tampering negligence or neglect and in the event of modifications or repairs
23. 097 70099 70100 34 Accessori opzionali LED VERIFICA CARICA BATTERIA 34 1 Descrizione Sul corpo motore dell ADV posizionato un segnalatore luminoso che indica lo stato di carica della batteria L accensione dei tre led blu completamente automatica e viene gestita da un dispositivo elettronico posto all interno del vano motore che misura la tensione della batteria 34 2 Funzionamento Premesso che il tempo trascorso tra le accensioni dei led pu variare sensibilmente dal tipo di batteria e dalle condizioni di usura della stessa questo dispositivo vuole essere solo ed unicamente di ausilio al subacqueo solo un ulteriore aiuto E assolutamente vietato e sconsigliato programmare l immersione tenendo conto della illuminazione dei led dell indicatore La vera e sicura durata della batteria va verificata tramite lo strumento di burn test accessorio cod 70037 il quale ci indica esattamente quanta energia abbiamo a disposizione nella bateria esaminata Batteria completamente carica 3 led accesi Batteria a circa mezza carica 2 led accesi Batteria in esaurimento 1 led acceso All accensione dell ADV specialmente con batterie Pb e NiMH ache se le batterie non sono completamente cariche molto probabilmente tutti e tre i led si accenderanno questo perche la tensione della batteria a riposo tende a rimanere o superare la tensione nominale La vera tensione della batteria la potremmo leggere solo durante I utilizzo con
24. 70100 32 1 Descrizione L elica a facile sostituzione prop lock consente senza l ausilio di attrezzi di estrarre lelica dallo scooter subacqueo in qualsiasi situazione in caso di avvolgimento di corpi estranei come cime o lenze da pesca o nel caso in cui si voglia sostituire lelica con un altra di forma o numero di pale diversa sia in immersione che a terra Il brevetto SUEX consente di sostituire facilmente l elica senza la dispersione di parti come viti o altro pur mantenendo la frizione di sicurezza costruita al suo interno Come sostituire l elica standard con la Prop Lock Verificare che nella confezione vi sia il seguente materiale Elica completa a 3 4 o 5 pale un pezzo Spina cilindrica 4x40 mm un pezzo Gommino di tenuta spina un pezzo Vite di fissaggio elica un pezzo Attrezzi necessari per lo smontaggio e il rimontaggio delle eliche non forniti chiave fissa o a stella da 10 mm chiave a tubo o a bussola da 10 mm chiave esagonale da 3 mm cacciavite a stella ph2 Smontaggio dell elica standard Svitare ed estrarre completamente il dado 1 Estrarre lelica tirandola verso l esterno Se si oppone una certa resistenza non usare il martello ma prendere l elica con due mani e tirare ulteriormente 28 SUES 70097 70099 70100 Smontaggio del perno filettato standard Svitare ed estrarre completamente il perno filettato standard 2 Montaggio del perno filettato prop lock B
25. 70100 55Flooding of the diving vehicle sinking This is a situation that could occur if the ADV is used incorrectly has suffered a strong collision is not closed properly or is not serviced as it should be In the event of flooding the vehicle will start to show negative buoyancy and will start to sink If total flooding occurs the situation can become POTENTIALLY DANGEROUS since the ADV will become HIGHLY negative from about 12 to 40 kg depending on the model type PULLING YOU DOWNWARDS and MUST THEREFORE BE ABANDONED IMMEDIATELY 56 Precautions for use Do not expose the ADV to solar radiations closed into the car under the sun or exposed to excessive heat max 50 C Overheating and successive deformation may occur to the prejudice of the water tightness of mating surfaces Avoid bumps during the dive Do not use it as a stool Do not stand up on it Do not let it be used by young or inexpert persons Do not charge the batteries with chargers other than those supplied Do not try to stop the propeller manually Do not block the trigger mechanism whilst the ADV is in running mode Do not hurl it from the boat or worse from the shore Do not disassemble it Do not let it run in a dry environment Do not wet electrical contacts Do not short circuit the batter Do not remove the connectors from their leads and do not invert the polarity of the battery connections Check frequentl
26. CUrEZZza rire iii 16 12 1 et e WEE 16 12 2 Configurazione ed assetto di Manovra tatt tnE nnt EAtE EAEn EEEn SE EASE En EnntEnntn nennen anena 16 12 3 Zona pericolosa e rischi residut ennaa 17 12 4 Dispositivo di sicurezza 17 13 Movimentazione 0rrrrrere rire ieri iii iii 18 14 Uso del veicolo subacqueo ADV arri iiiiiiiinni 18 15 Autonomia 16 VU IO Ee e E E tec caste edeces edad ceean acee avec ected sunces aside ceceetacccsued acheceauedueayedeceesdanesuceesasceecetestusetdeese 17 Profondit e ambienti di UtiliZ20 socio cies ccc cencecekaccensoeeseesseesaceanecocrcacesacdnecenseenivsusi docencnsncarseeddersneraceiaaef cesderecnens 19 18 Allagamento del veicolo subacqueo affondamento rrrrrrreriiene ieri iii iii 20 19 Precauzioni d USO WEN 20 20 Pulizia e rimessaggio rarrrrirre rire eee iii 21 21 Problemi cause e rimedi x iici iii iaia iii 21 22 ManNutenzione vrrrrrerresererenee resine nec nezeneneeneenenene nani cane rene neeecioneonenionenenieneenerenze nazione eeieae cienza ne cioneneenia 22 23 Smaltimento e rottamazione rseririeeiee rire iii 22 24 Ricarica della batteria norme generali rrrerrrrirnee iii een 23 25 Come ricaricare la batteri s piaccia 26 Informazioni sulla batteria Pb gel 27 Condizioni ideali per la ricari
27. DV further increases the hazards of the dive itself Before use make sure the battery is charged that connectors are connected and that no electrical parts are rusted Check that the head cap is closed properly check its condition especially following accidental bumps or accidental scratches and make sure that the trigger and main switch are functioning correctly At this point the ADV is ready for use After entering the water and grasping hold of the ADV by means of the tow harness the main switch must be switched on by rotating it clockwise with the fingers only The switch is not a snap switch but behaves just like a water tap i e more than one complete turn is necessary to open or close the contact A CAUTION The main switch must be turned clockwise to running mode only when the ADV is in water Rotating the propeller out of the water may be dangerous and damage the seal of the motor shaft Once in the water the propeller is activated by pulling the trigger AN incorporated on the right manoeuvring handle towards you Releasing the trigger will stop propeller rotation Speed can be regulated from 0 to 100 of the maximum speed using the speed regulator knob turning it clockwise the speed decreases turning it counter clockwise the speed increases Do not force the switch when the end of travel is reached otherwise it could be damaged Do not force the regulator knob when the end of travel is reached otherwise it coul
28. IORMENTE LA BATTERIA E DI SPEGNERE IMMEDIATAMENTE L ADV 25 SUES gt SC 70097 70099 70100 30 Sistema di protezione batteria CUT OFF principio di funzionamento e istruzioni per l uso Il sistema elettronico di protezione della batteria dalla scarica totale accidentale collocato all interno della batteria e collegato in serie tra la batteria e il motore dell ADV La funzione quella di impedire la scarica eccessiva delle celle con possibile pericolo di inversione della polarit di una o pi celle con conseguente possibile distruzione del pacco batterie con potenzialit di creare danni anche gravissimi a cose e o a persone Durante la scarica degli accumulatori la tensione si abbassa fino a raggiungere un valore limite a quel punto il cut off impedisce interrompendo l erogazione della corrente che la batteria possa essere scaricata ulteriormente Quando il cut off interviene la batteria non eroga pi tensione al connettore Per ripristinare la situazione di utilizzo della batteria necessario ricaricarla esclusivamente per mezzo dell apposito caricabatteria vedi manuale utilizzo del caricabatteria e ristabilire il circuito L intervento del cut off da ritenersi eccezionale e tale evento non dovrebbe verificarsi durante il normale utilizzo della batteria in quanto il corretto uso del mezzo non prevede la scarica eccessiva della stessa 30 1 Modalit da seguire in caso di intervento del cut off In caso di interv
29. It illustrates a part of it for pure explanatory purposes 67 SUES 70097 70099 70100 69 5 Prop lock propeller troubleshooting PROBLEM CAUSE SOLUTION Rotating the white knob requires excessive strain The knob was damaged and should be replaced Even if the shaft pin is in the correct position in the The traction pin was damaged bent and should be propeller housing the friction jerks and the scooter replaced does not move forward The propeller hub was damaged and should be replaced The white knob turns freely and does not stop the Too much force was used to tighten the knob and it propeller was damaged It should be replaced The screw on the knob turns freely The knob was damaged and should be replaced operations to be conducted at a authorized SUEX service centre Note The prop lock propeller is larger than a standard propeller the white knob protrudes further This means that the use must pay closer attention when standing the scooter on the flow conveyor in the vertical position Any collisions with the propeller larger could damage both the prop lock propeller and scooter 70 Accessories optional N HANDLE CONTROL 70 1 Description The N Handle control device was created for better ADV manageability in certain conditions The corrugated handle can be installed in three different positions according to hand span The cruise knob lets you block the trigger at the desired
30. LEAKY OR SWELLED BATTE RIES NON BAGNARE I CONTATTI ELETTRICI DO NOT WET ELECTRICAL CONTACTS NON USARE LO SCOOTER SE NON PERFETTAMENTE FUNZIONANTE DO NOT USE THE SCOOTER IF IT IS NOT PERFECLY OPERATIONAL LJ NON RIMUOVERE QUESTA ETICHETTA sa DO NOT REMOVE THIS LABEL SUBMARINE EXPLORATION WWW SUEX IT ITALY 14 70097 70099 70100 9 Uso previsto Il veicolo subacqueo prodotto da SUEX s r l un mezzo progettato e costruito per lo spostamento in immersione Qualsiasi intervento eseguito sul prodotto da parte del cliente o terze parti che modifichi sostanzialmente la destinazione d uso vietato l uso precedentemente descritto Qualsiasi altro uso o qualsiasi operazione non conforme o non corrispondente a quanto indicato nel presente manuale pu comportarne il suo danneggiamento precludendo cos il rispetto delle condizioni per cui stato progettato e costruito con conseguente possibile compromissione delle caratteristiche tecniche e di sicurezza Il costruttore non risponde per danni a persone e o cose derivanti da uso non conforme Il veicolo stato progettato dimensionato e costruito unicamente per 10Garanzia Il prodotto garantito contro i difetti di costruzione per il periodo determinato dalla normativa vigente La garanzia decade per un uso non conforme o diverso da quello previsto o illustrato nel presente manuale Cattivo uso negligenza tentativi di riparazione o modifica da parte di personale non autoriz
31. NATO IN QUALSIASI MOMENTO NON UTILIZZARE SISTEMI DI TRAINO NON FACILMENTE SVINCOLABILI DAL SUBACQUEO 35 1 Funzionamento f SI RICORDA ULTERIORMENTE CHE L ADV DEVE POTER ESSERE Ruotare il pomello dell interruttore generale in senso antiorario ed acceratrsi che l ADV non si avvii Ruotare il pomello del By Pass in senso orario a fondo senza forzare Ruotare il pomello dell interruttore generale in senso orario PADV si avvia in modo continuo Ruotare il pomello dell interruttore generale in senso antiorario per arrestare l ADV Nelle normali condizioni di utilizzo il pomello del dispositivo di By Pass deve essere ruotato SEMPRE E COMPLETAMENTE in senso antiorario fino in fondo AN Nota questo dispositivo da utilizzare solo ed unicamente in reale caso di emergenza ovvero solo in caso di guasto alla parte elettronica e nel caso in cui azionando il grilletto ADV non si avvia Si ricorda che ADV NON E UN MEZZO DI SALVATAGGIO 37 SUES 36 Modularit Molti modelli di ADV della nostra produzione hanno la possibilit di essere facilmente trasformati anche dal cliente in modelli con dimensioni caratteristiche ed autonomie diverse Il sistema adottato per ottenere tale possibilit quello di dividere concettualmente ADV in due parti principali la parte propulsiva motore elettrico ed elica e la parte di alimentazione ovvero la batteria con i rispettivo supporto Le due parti sono contenute in due contenit
32. Suex lt 70097 70099 70100 SUED THE SUBMARINE EXPLORATION COMPANY Z E UXO 20 33 42 MANUALE DI USO E MANUTENZIONE USE AND MAINTENANCE MANUAL 09 2012 SUEX S r l con l intento di migliorare si riserva la facolt di variare senza preavviso quanto descritto nel presente manuale CONSULTARE IL SITO WWW SUEX IT PER LA VERSIONE PIU RECENTE DEL PRESENTE MANUALE SUEX S r l due to constant technological advancement may modify the content of this manual without prior notice TO ENSURE YOUR USER INFORMATION IS UP TO DATE PLEASE DOWNLOAD THE LATEST VERSION OF THIS MANUAL 70097 70099 70100 SOMMARIO 1 Descrizione e principio di funzionamento rrrrrrreriieie iii ieri iii 3 2 Dati teChiIC rire 5 3 Operazioni preliminati nigigiiaia alii ai 6 3 1 Apertura Gell IM eege be ian adap anaa aoao EEEa EELE a ae iee atana 6 3 2 RER E EE 7 3 3 Inserimento della batteria A 9 3 4 Ghiusura dellinvoluero srar ara ara Rn 9 4 Regolazione assetto 111sarrrrirere irene eee iii iii 10 5 Materiale in dotazione rire 10 6 Ricambli uuci iii 7 Identificazione 8 Norme generali di sicurezza e di prevenzione infortuni rrrrriiiire iii iene 13 8 1 Ree WEE E Ee EE 14 9 USO previsto i iii 15 10 EE E 15 11 Garanzia sulla battetria ea aaa 15 12 Informazioni per la SI
33. TANDO L INTERRUTTORE GENERALE IN POSIZIONE OFF ed effettuare la risalita normalmente 17 Profondit e ambienti di utilizzo NON ECCEDERE LA MASSIMA PROFONDITA OPERATIVA In ogni caso l immersione in particolare a quella profondit un attivit MOLTO PERICOLOSA L UTILIZZO SCORRETTO DELL ADV IN TALI AMBIENTI AUMENTA IL RISCHIO DELL IMMERSIONE E importante ricordare che la massima profondit operativa del veicolo subacqueo si riferisce all ADV in perfetta efficienza urti rigature o deformazioni riducono sensibilmente questo limite Ambienti ostruiti L immersione in tali ambienti di per s E MOLTO PERICOLOSA L UTILIZZO SCORRETTO DELL ADV IN TALI AMBIENTI AUMENTA IL RISCHIO DELL IMMERSIONE A titolo di esempio un urto delle rubinetterie mentre si procede in velocit ne potrebbe provocare la rottura con le relative conseguenze L IMMERSIONE IN TALI AMBIENTI PREVEDE ADEGUATI CORSI DI ADDESTRAMENTO TENUTI DA QUALIFICATE AGENZIE Si vuol sottolineare che va pianificata la gestione sia dell autonomia dell ADV che quella del gas in modo che ogni componente della squadra disponga del DOPPIO delle risorse necessarie inoltre obbligatorio equipaggiarsi di altri ADV di scorta 19 SUES 70097 70099 70100 Ambienti melmosi o soggetti a sospensione Sono ambienti ostruiti e non nei quali la visibilit pu azzerarsi repentinamente a causa della sospensione che si crea quando viene smosso il sedimento L immer
34. UCTIONS MANUAL ATTENZIONE ALL ELICA PAY ATTENTION TO THE PROPELLER USARE SOLO IMMERSO OPERATE IMMERSED ONLY NON USARE LO SCOOTER PER AUMENTARE LA VELOCITA DI RISALITA DO NOT USE THE SCOOTER TO INCREASE THE ASCENT SPEED RUOTARE L INTERRUTTORE IN POSIZIONE OFF QUANDO LO SCOOTER NON E UTILIZZATO TURN THE SWITCH OFF WHEN THE SCCOTER IS NOT IN USE RIMUOVERE LE BATTERIE DOPO L USO REMOVE THE BATTERIES AFTER THE USE NON FUMARE O USARE FIAMME LIBERE DURANTE L APERTURA DO NOT SMOKE AND DO NOT USE OPEN FLAMES DURING THE OPENING PROCEDURE PRIMA DI OGNI IMMERSIONE CONTROLLARE CHE CONNETTORI ELETTRICI SIANO INSERITI CONTROL LARE LE GUARNIZIONI DI TENUTA E ASSICURARSI CHE LO SCOOTER SIA CHIUSO A FONDO BEFORE EVERY DIVE CHECK THAT THE ELECTRICAL CONNECTORS ARE INSERITED PROPERLY CHECK THE GASKETS ENSURE THAT THE SCOOTER IS CLOSED COMPLETELY PER NON DANNEGGIARE LE BATTERIE SPEGNERE SEMPRE DOPO L USO O QUANDO INTERVIENE L AVVISATORE ACUSTICO ALWAYS TURN OFF AFTER THE USE AND WHEN THE WARNING SIREN SOUNDS TO PREVENT DAMAGE TO THE BATTERIES LE BATTERIE VANNO RICARICATE IN LOCALI AERATI NON DEVONO ESSERE RICARICATE ALL INTERNO DI CONTENITORI ERMETICI NON DEVONO ESSERE RICARICATE IN PARALLELO SE PRESENTANO PERDITE DI LIQUIDO O RIGONFIAMENTI NON POSSONO PIU ESSERE UTILIZZATE BATTERIES MUST BE CHARGED IN WELL VENTILATED ROOMS AND MUST NOT BE CHARGED INSIDE AIRTI GHT CONTAINERS THEY MUST NOT BE CHARGED IN PARALLEL DISPOSE OF
35. UEX S r l E A DISPOSIZIONE PER L ASSISTENZA TECNICA NECESSARIA 23 70097 70099 70100 26 Informazioni sulla batteria Pb gel La batteria generalmente costituita da due singole batterie da 12 volt collegate in serie per raggiungere la tensione di 24 volt Esse sono assemblate in fabbrica cablate con il cavo di alimentazione e con il connettore per il collegamento Se durante l utilizzo dell ADV si nota un sensibile calo di potenza erogata sospenderne l uso spegnendolo tramite l interruttore Non lasciare MAI la batteria connessa all ADV se non utilizzata Ricaricare la batteria almeno una volta al mese Ricaricare la batteria prima di ogni utilizzo avendo cura di lasciar raffreddare se si dovesse essere intiepidita la batteria prima di inserirla nell ADV durante questa fase la batteria potrebbe rilasciare idrogeno il quale andrebbe inevitabilmente ad accumularsi all interno dell ADV che ermetico Un accumulo di idrogeno in particolari condizioni potrebbe essere causa di incidenti con conseguenti danni a cose e persone Sostituire la batteria che ha terminato i suoi cicli di carica e scarica sulle nostre macchine la batteria al piombo verosimile che possa operare un numero variabile da 150 a 300 cicli dipende molto dal tipo di utilizzo fatto una batteria esausta oltre a non avere pi capacit di immagazzinamento di energia produce inevitabilmente gas idrogeno Utilizzare solo batterie approvate da Suex S r l
36. a non stringere eccessivamente potrebbero danneggiare il corpo motore che in materiale plastico 4 dadi Y vanno stretti adeguatamente essi garantiscono oltre PERICOLO all assemblaggio delle parti anche la tenuta ermetica del corpo motore rispetto al vano batterie controllatene bene l effettiva avvitatura Fare anche attenzione alle guarnizioni di tenuta mantenerle sempre pulite e lubrificate insieme con le rispettive sedi di alloggiamento 39 37 ENGLISH VERSION 70097 70099 70100 38 Description and operating principles The ADV consists of a perfectly watertight streamlined hollow body inside which the electric motor rechargeable batteries and speed reduction gear are housed On the outside two manoeuvring handles 1 are found at the rear one of which has an integrated trigger 2 to control propeller rotation by means of a magnetic reed switch 3 At the front a handle in synthetic material 4 is used for gripping and carrying the vehicle The propeller is located at the rear end and is protected by a surrounding circular strip 5 which constitutes the flow duct Rotation of the propeller generates the propulsive thrust The main switch 6 for turning the power on and off and the speed regulator knob 7 are also found at the rear The hull consists of a fore shell 8 in which the locking wheel 9 is inserted and the main housing 10 The shell is inserted in the tube and held by any internal ring Sea
37. a batteria al massimo della sua scarica perch faccio immersioni brevi devo estrarre ogni volta la batteria e ricaricarla La batteria al piombo non ha nessun effetto memoria meglio ricaricarla sempre si allunga la vita degli accumulatori e si ha la sicurezza di avere la massima autonomia La batteria va conservata fuori dall ADV ed inserita e collegata al motore solo immediatamente prima dell utilizzo e va disconnessa ed estratta immediatamente dopo l utilizzo Posso lasciare la batteria collegata al caricabatteria per lungo tempo nostri caricabatteria a fine ricarica entrano in mantenimento possono essere lasciati attaccati alla batteria per quanto tempo si desideri essi effettuano la ricarica solo se necessaria comunque meglio staccarli non appena terminata la ricarica 26 Mi caduta la batteria al suolo essa presenta uno spigolo ammaccato posso utilizzare ancora la batteria Ovviamente dipende dalle condizioni dell ammaccatura le batterie al piombo gel di solito sono robuste tuttavia esse vanno assolutamente sostituite se l involucro dovesse presentare dei danni tali da far uscire l elettrolita In ogni caso una batteria caduta al suolo potrebbe avere subito dei danni interni alle connessioni tra le celle si consiglia di sostituirla E normale un riscaldamento della batteria durante la ricarica Premesso che la batteria va sempre caricata ad una temperatura ambiente che va da 15 C a 25 C durante la ricarica ci pu
38. a completely automatic tool that simulates electrical ADV absorption during operations and depletes the battery to a set residual voltage When finished the length of output in minutes is displayed This data gives you an idea on battery health letting you plan correct use see burn tester accessories Never use other discharge systems 69 Accessories optional PROP LOCK PROPELLER 69 1 Description The easy to replace prop lock propeller can be removed from the underwater scooter without the use of tools in any situation such as in the event the propeller is wound by foreign objects like fishing lines or hooks or if the diver wants to replace the propeller with one shaped differently or with a different number of blades both underwater and on land The SUEX patent permits the propeller to be easily replaced without losing parts like screws or others still maintaining the safety friction built within How to replace the standard propeller with a Prop Lock propeller Make sure the following material is found in the package Complete 3 4 or 5 blade propeller one piece 4x40 mm cylindrical plug one piece 64 SUES 70097 70099 70100 Rubber plug seal one piece Propeller fastening screw one piece Equipment needed to dismantle and assemble propellers not supplied 10 mm wrench or spanner 10 mm tube or sleeve wrench 3 mm Allen key Ph2 Phillips screwdriver Standard propeller removal Unscrew and com
39. a foot on the propeller guard Rest the hull on the ground preventing dust or sand from entering and clean the OR gasket housing Fig 3 1 43 SUES 70097 70099 70100 40 2 Accessing the battery In ADV models 18 and 28 the single battery pack made up of two 12V batteries connected in series is removed while in ADV models 33 and 42 the 12V batteries are removed singularly due to their weight In the latter case disconnect the wire used to connect the batteries in series The battery pack should always be charged reconnecting the batteries in series WARNING Reconnect the wires always pairing the same colour connectors Firmly disconnect connectors without pulling on the wires unfasten the front Velcro strap and extract the battery WARNING Battery weight is minimum 10 kg Use all precautions to avoid it from falling or causing accidents 44 70097 70099 70100 1 Velcro strap 2 Ballast 3 Battery pack 4 Threaded bushing 5 Ballast for salt water 45 70097 70099 70100 40 3 Inserting the battery Before using the scooter the battery must be replaced in its housing Make sure the rear Velcro strap is closed Insert the battery between the bushings For two separate batteries first insert the bottom one Close the front Velcro strap Connect wires positioning them as previously illustrated Make sure the battery is suitably locked to the support Use the bushings or Velcro s
40. a sua salute PERICOLO Questo segnale avverte che se le operazioni descritte non vengono correttamente eseguite l utente soggetto a possibili rischi che per non comportano danni o lesioni AVVERTENZA Questo segnale avverte che se le operazioni descritte non vengono correttamente eseguite pu conseguirne un danno al mezzo CAUTELA Prima di utilizzare il mezzo leggere attentamente le istruzioni riportate sul presente manuale La presente pubblicazione e di esclusiva propriet di SUEX s r l che ne vieta la riproduzione anche parziale senza precisa autorizzazione scritta NOTA IMPORTANTE Nonostante fare un immersione con l ausilio del ADV subacqueo sia molto divertente e vi sollevi da grosse fatiche non dimenticate mai che un mezzo meccanico e PUO ROMPERSI Non considerate mai ADV come un aiuto in situazioni di pericolo NON E UN MEZZO DI SALVATAGGIO Ricordatevi sempre che potete contare SOLO sulle vostre forze 13 70097 70099 70100 8 1 Targhetta di segnalazione Sul mezzo incollata la seguente etichetta essa non vede essere rimossa ed in caso di illeggibilta va sostituita con una nuova da richiedere alla nostra assistenza La rimozione di questa etichetta comporta la non responsabilit di SUEX S r l per incidenti occorsi in seguito a comportamenti tenuti in contraddizione alle indicazioni in essa riportate IMPORTANTE NOTICE LEGGERE IL MANUALE ISTRUZIONI READ THE INSTR
41. a toy nor a suitable rescue means It s exclusive function is to help expert divers in immersions to cover greater distances than could be normally covered with fins only The ADV and its components specifically the battery and battery charger are intended for adult and expert use after carefully reading these instructions 48 70097 70099 70100 In order to prevent any harm to things or individuals the user of the battery and battery charger supplied with our diving vehicles must first read the use and maintenance manual and strictly observe the indications on correct use and product features preventing inexpert personnel or minors from handling even inadvertently the ADV and supplied instruments According to the battery used our ADV are equipped with a cut off device that protects internal components impeding operations when voltage is too low When this device is triggered it inevitably shuts off This feature must always be kept in mind to avoid any hazards for the diver who when planning a dive will leave sufficient time to surface even without ADV power should the battery due to the amount of time under water die SUEX S r l is not liable for any damages to persons and or property caused by use other than that described in this manual and in neglect of the precautions described herein Due to constant technological developments Suex diving vehicles may be modified at any time without prior notice This manual is not a s
42. acilitare il governo dell ADV in determinate condizioni di utilizzo L impugnatura corrugata pu essere montata in tre posizioni diverse a seconda della grandezza della mano Il pomello cruise permette di bloccare il grilletto nella velocit desiderata Il blocchetto accessori permette di applicare allo scooter supporti strumenti o video Verificare che nella confezione vi sia il seguente materiale Impugnatura un pezzo Viti per fissaggio maniglia e pomolo sinistro 4 pezzi Viti per fissaggio impugnatura 4 pezzi Maniglia destra completa di grilletto un pezzo Supporto accessori un pezzo Pomello sinistro un pezzo 32 70097 70099 70100 Impugnatura Maniglia Grilletto Pomello cruise Supporto accessori Cava per supporto accessori Fermo prima velocit Blocco supporto accessori o NO giS e Attrezzi necessari per l applicazione della maniglia non forniti chiave fissa o a stella da 7 mm chiave fissa o a stella da 8 mm chiave esagonale da 3 mm chiave esagonale da 4 mm cacciavite a croce Ph2 VEDI VIDEO GU WWW SUEX IT PER MONTAGGIO E REGOLAZIONE GRILLETTO NOTA SULLA SICUREZZA Fare molta attenzione all elica in rotazione pericolo di contusioni NOTA IMPORTANTE Non insistete con il funzionamento del ADV al asciutto le tenute CAUTELA dell albero potrebbero danneggiarsi agire solo per piccoli periodi 3 o 5 secondi giusto il tempo per capire se le regolazioni sono state eff
43. age of the vehicle Please read the instructions in this manual carefully before using the vehicle Copyrights for this manual belong exclusively to the company SUEX s r l Reproduction of this document in part or in whole is forbidden unless prior consent is obtained in writing IMPORTANT NOTE Although diving with the ADV is great fun and relieves you of substantial effort do not ever forget that it is a machine and IT CAN BREAK Never consider the ADV to be an aid in dangerous situations IT IS NOT A LIFE SAVING DEVICE Always remember that you can ONLY COUNT ON YOUR OWN STRENGTH 50 70097 70099 70100 45 1 Indicator label The following indicator label is found on the vehicle It should not be removed tampered with or destroyed The user of the vehicle shall be responsible for replacing any worn out or illegible label with a new one it must be requested to our after sales service SUEX S r l will not be liable for damages and accidents happened in consequence of behaviors in contradiction to the indications in it reported IMPORTANTE NOTICE LEGGERE IL MANUALE ISTRUZIONI READ THE INSTRUCTIONS MANUAL ATTENZIONE ALL ELICA PAY ATTENTION TO THE PROPELLER USARE SOLO IMMERSO OPERATE IMMERSED ONLY NON USARE LO SCOOTER PER AUMENTARE LA VELOCITA DI RISALITA DO NOT USE THE SCOOTER TO INCREASE THE ASCENT SPEED RUOTARE L INTERRUTTORE IN POSIZIONE OFF QUANDO LO SCOOTER NON E UTILIZZATO TURN THE SWITCH OFF WHEN
44. batteries This is because idle battery voltage tends to remain or exceed nominal voltage True battery voltage can only be read during use with the scooter on and after several dozen seconds of operations Each user should learn to know the lighted device signal since the time between on led turning on and the next cannot be exactly calculated It depends on how the ADV is used 71 70097 70099 70100 set speed However only one led on should warn the diver that the battery is low and that the scooter should no longer be used The lighted signal is extremely helpful because it indicates that the ADV is on and ready for use 72 Accessories optional BY PASS DEVICE The BY PASS device is an accessory installed on some models upon customer request This device recognizable as a white knob located on the left side of the motor unit exactly opposite the main switch creates a direct electrical connection between the battery and electrical motor by passing any other device usually used for electrical ADV use trigger speed regulator electronic control Use of this device is potentially hazardous since once activated it starts the motor continuously at maximum power and the only control we have is to turn the ADV off using the min switch or by pass knob THE ADV AT ANY TIME DO NOT USE TOW SYSTEMS THAT ARE ALSO REMEMBER THAT YOU MUST BE ABLE TO ABANDON DIFFICULT TO RELEASE 72 1 Operations Rotate the main switch counter clock
45. ca della batteria niiii 28 Condizioni ideali per la scarica della batteria ri 28 1 Nota importante sull esaurimento della batteria 29 Dispositivo di allarme acustico batteria scarica 30 Sistema di protezione batteria CUT OFF principio di funzionamento e istruzioni per l uso 26 30 1 Modalit da seguire in caso di intervento del cut oft 26 31 Batteria Pb gel domande frequenti rrrrrerrrriieeie iii 26 32 Accessori opzionali ELICA PROP LOCK iii 28 32 1 Descrizione ii crrcrrrer err cr er rast rer 28 32 2 Come estrarre l elicapropilock iiiiaa lei ae 31 32 3 Come inserire l elica propiloCk ini 31 32 4 Manutenzione elica prop I0CK ii aa e 31 32 5 Problemi cause e rimedi elica prop och 32 33 Accessori opzionali COMANDO N HANDLE ccseceeeeeeeeeeeeeeeeeeeeeeeeeeeeeeeeeeseeeseeeeaseeeseeeeeseeesseeeaseneneeeenes 32 33 1 DEScrizione E 32 33 2 Utilizzo del dispostivo N FHANDLE ciia i ep EENS 34 33 3 Problemi cause e rimedi dispositivo N HANDLE i 35 34 Accessori opzionali LED VERIFICA CARICA BATTERIA rrrii iii 36 34 1 Descrizione i iaia 36 34 2 FUNZIONAMENTO Riise 36 35 Accessori opzionali DISPOSITIVO BY PASS rrrrriii iii 37 35 1 FunzionameMO tia aiar 36 TE E 36 1 Descrizione
46. cosa che deve avvenire solo in caso di emergenza L utilizzo improprio della frizione di emergenza porta al danneggiamento della stessa con esclusione dalla garanzia 32 2 Come estrarre l elica prop lock Svitare il pomello bianco senso ANTIORARIO fino alla completa estrazione dell elica 32 3 Come inserire lelica prop lock Infilare lelica nell albero motore dell ADV girare lelica in senso ORARIO fino a quando la spina si porta nella corretta posizione di aggancio proseguire ruotando in senso ORARIO il pomello bianco Stringere il pomello CON LA SOLA FORZA DELLE DITA SENZA FORZARE 32 4 Manutenzione elica prop lock L elica prop lock non necessita di manutenzione unica accortezza sar quella di verificare prima dell inserimento nell albero dell ADV che la sede sull alica sia pulita e priva di corpi estranei NOTA IMPORTANTE L ELICA PROP LOCK IMMERSA IN ACQUA AFFONDA DURANTE L OPERAZIONE DI ESTRAZIONE E RICOLLOCAMENTO DELL ELICA IN IMMERSIONE FARE LA MASSIMA ATTENZIONE ESISTE IL POTENZIALE RISCHIO DI PERDERLA CON LA CONSEGUENZA DI NON POTER UTILIZZARE LO SCOOTER SUBACQUEO GARANZIA SULL ELICA PROP LOCK Suex garantisce a vita l elica contro difetti di fabbricazione ad esclusione di errato montaggio errato utilizzo usura e in tutti i casi in cui la rottura dell elica sia dovuta a negligenza o cattivo utilizzo da parte dell utilizzatore Nota la raffigurazione in questo manuale dell albero
47. d be damaged 52 Running time Running time data is indicative and is nevertheless referred to use with a vehicle in perfect running order in moderate environments inthe absence of currents with an average load diver with a single tank or doubles 12 12 It 55 SUES 70097 70099 70100 in perfect buoyancy conditions As a rule the running time should be calculated to cover the descent and ascent An EMERGENCY running time which will vary according to the type of dive must also be established In any case when planning a dive you MUST consider the event of returning to the exit point without the ADV 53 Speed Speed depends on the same factors as running time The speed chosen should be compatible with the type of dive and be adjusted to match that of your buddies Descent rate The ADV allows you to accomplish a fast descent rate AVOID using it to accelerate your descent since problems related to equalising and psychological physical adjustment are increased Ascent rate The ADV MUST NEVER BE USED FOR VERTICAL ASCENTS In fact using it in such a manner may result in an excessively rapid ascent WHICH IS POTENTIALLY DANGEROUS Hence it is better to DEACTIVATE IT BY TURNING THE MAIN SWITCH TO THE OFF POSITION position it out of the way and ascend normally 54 Depth and operating environments DO NOT EXCEED THE MAXIMUM OPERATING DEPTH The dive is already VERY DANGEROUS at that depth INCORRECT USE OF THE ADV
48. destinati ad un utilizzatore adulto ed esperto che abbia letto attentamente le istruzioni per l uso Al fine di evitare ogni rischio a cose o persone l utilizzatore delle batterie e del carica batterie in dotazione con i nostri veicoli subacquei deve prima aver letto il manuale di uso e manutenzione e dovr attenersi scrupolosamente alle indicazioni sul corretto uso e sulle caratteristiche del prodotto evitando che persone inesperte o minori possano maneggiare anche inavvertitamente l ADV e gli strumenti in dotazione Il nostri ADV a seconda del tipo di batteria utilizzata sono dotati di un dispositivo di cut off che ha lo scopo di tutelare i componenti interni dello stesso impedendone il funzionamento quando la tensione troppo bassa Quando interviene tale dispositivo l ADV inevitabilmente smette di funzionare Questa caratteristica deve essere sempre tenuta presente al fine di non creare in alcun modo pericolo per il subacqueo il quale nel programmare l attivit di immersione terr conto di un tempo sufficiente per risalire in superficie anche in assenza della forza propulsiva dell ADV stesso qualora la carica della batteria a causa del tempo trascorso in acqua stia per esaurirsi SUEX S r l declina ogni responsabilit per qualsiasi danno a persone e o cose derivante da un uso con modalit diverse da quelle indicate nel presente manuale e senza aver adottato le precauzioni ivi descritte A causa del costante s
49. e logoramento o deterioramento 15 70097 70099 70100 12Informazioni per la sicurezza 12 1 Addestramento L ADV pu essere utilizzato indifferentemente da un subacqueo ricreativo o da un subacqueo tecnico in entrambe i casi si d per scontato che chi si appresta ad immergersi abbia conseguito la necessaria certificazione da qualificate agenzie in ogni caso l utilizzo dell ADV presuppone uno specifico addestramento che permetta di utilizzarlo in piena sicurezza e di apprezzarne appieno le potenzialit Non dimentichiamo che il pericolo maggiore dovuto principalmente dall ambiente subacqueo di utilizzo 12 2 Configurazione ed assetto di manovra veicoli subacquei SUEX sono del tipo TOW BEHIND si differenzia dai cos detti ride on top che devono essere cavalcati e quindi l utilizzo ideale richiede che il subacqueo si faccia trainare restando in posizione arretrata rispetto all ADV Attenzione assolutamente vietato vincolare l ADV al subacqueo in modo improprio In ogni momento dovrebbe essere possibile abbandonare l ADV con estrema facilit Nel caso si voglia impiegare un AVVERTENZA dispositivo di traino deve essere utilizzato l accessorio cod 70089 provvisto di sgancio rapido Vedi immagine pagina seguente fig 1 dispositivo agganciato fig 2 dispositivo sganciato Figura 1 Figura 2 La configurazione corretta dell attrezzatura un fattore di cruciale importanza per la sicurezza in immersio
50. e Inserire ed avvitare completamente il perno filettato prop lock a 3 avendo cura di inserire nell albero la parte filettata PIU CORTA Nota per facilitare l operazione di avvitatura e svitatura del perno filettato consigliato utilizzare l apposito utensile cod 70319 All interno dell albero tra la spina di trazione e il perno filettato ci deve essere una molla in gomma verde Questa serve ad impedire che la spina di trazione possa accidentalmente uscire dall albero IMPORTANTE LA SPINA DI TRAZIONE DEVE SPORGERE DALL ALBERO UGUALMENTE DA AMBO I LATI 29 SUES 70097 70099 70100 Prendere lelica prop lock e verificare che la vite 5 sia svitata se non lo fosse svitarla come da figura a fianco deve sporgere di circa 3 mm dal pomello bianco Inserire lelica nell albero del ADV subacqueo controllando che la spina 4 sia inserita nella propria sede sul lato interno dell elica se non lo fosse ruotare l elica CON LE MANI fino a quando non avverr l inserimento SPINA NELLA SEDE MONTAGGIO CORRETTO Avvitare il pomello bianco fino a quando le due superfici A e B coincidono A questo punto tenendo fermo il pomello bianco avvitare la vite 5 fino in fondo a raggiungere il fermo non forzare 30 SUES 70097 70099 70100 NOTA IMPORTANTE Non azionare lo scooter con la spina dell elica non correttamente inserita nella sede si azionerebbe il dispositivo di sicurezza della frizione
51. eeeeenneeneeeesaneeneeeeeaeeseeeeaeaeesseeeeeeeeneeeseneeeeneenes 68 RE de Le RR RR Re RR RA E 68 N HANDEE device USE a i AA eet eri 70 N HANDLE device troubleshooting AA 71 Accessories optional BATTERY CHARGE LEVEL LED srriciiie iii 71 BI 101910 le 71 Operations nate 71 Accessories optional BY PASS DEVICE csseccssessseeseeeeeseeeeeeeeeneeeeeeeeeeeeeneeeaeaeasseeeasneaseeeseeeeeseeedeneeeeenenes 72 Operations talia ieri elit a aa at 72 Modularity i iaiariia ini 73 Seele le EE 73 Part replacement 2 aaralea ilaele 74 After sales SEFVICE rire 74 70097 70099 70100 1 Descrizione e principio di funzionamento L ADV costituito da un corpo cavo perfettamente ermetico dalla forma idrodinamica all interno del quale sono alloggiati il motore elettrico le batterie ricaricabili ed il riduttore di velocit All esterno posteriormente sono presenti due maniglie di manovra 1 in una delle quali integrato il grilletto 2 che comandando un pistoncino magnetico 3 permette il controllo della rotazione dell elica A prua una maniglia in tessuto sintetico 4 viene utilizzata per la presa ed il sollevamento All estremit posteriore situata lelica che girando genera la spinta propulsiva quest ultima protetta da una fascia circolare radiale che costituisce il condotto di flusso 5 Sempre posteriormente sono presenti l interruttore generale 6 che seziona l
52. en easy to hear in both immersion and emersion which automatically sounds when a set voltage considered the minimum for ADV use is reached without further or inappropriately using the battery This alarm is always triggered whether the ADV is in use or accidentally left ON When the siren sounds the ADV may continue to run for several minutes This amount of time varies and depends on several factors such as the power used and battery wear conditions WHEN THIS DEVICE IS TRIGGERED WE HIGHLY RECOMMEND YOU TURN THE ADV OFF IMMEDIATELY SO AS NOT TO FURTHER EXPLOIT THE BATTERY 67 CUT OFF battery protection system operating principle and instructions for use The electronic battery protection system from total accidental depletion is located inside the battery and connected in sequence between the battery and ADV engine 62 70097 70099 70100 Its purpose is to prevent excessive cell depletion that could lead to the polarity inversion of one or more cells with consequent potential battery destruction and possible damages even serious to property and or people When accumulators deplete voltage lowers until it reaches a limit value When this value is reached cut off prevents the battery from further depleting by interrupting power distribution When the cut off is triggered the battery no longer outputs voltage to the connector To continue battery use it must only be charged with the specific battery charger see batter
53. ento del sistema cut off E IMPORTANTE procedere come di seguito 1 Sconnettere il connettore di alimentazione del motore della batteria 2 Estrarre la batteria dall ADV 3 Lasciare la batteria a riposo almeno per 2 ore E il tempo minimo necessario in questo caso per permettere alla batteria di raffreddarsi e riportarsi allo stato di attesa ricarica Collegare il connettore per la ricarica della batteria al caricabatteria Procedere con la ricarica come da manuale istruzioni del caricabatteria NOTA IMPORTANTE Si ricorda ulteriormente che quando interviene il dispositivo di cut off PADV inevitabilmente smette di funzionare Questo evento non deve in alcun modo essere origine di pericolo per il subacqueo il quale avr programmato l attivit di immersione tenendo conto che l utilizzo dell ADV non pu essere considerato come sistema per salvaguardare la propria vita o per togliersi da situazioni di difficolt SUEX S r l declina ogni responsabilit in seguito all intervento del sistema cut off in qualsiasi situazione in situazioni pericolose o in immersioni dove il subacqueo abbia a suo completo rischio affidato il suo ritorno in superficie al mezzo subacqueo da noi costruito Si ricorda che l ADV deve essere considerato come ausilio all immersione e non come mezzo di salvataggio a 31 Batteria Pb gel domande frequenti Utilizzo l ADV molto spesso 2 volte alla settimana o tutti i giorni ma non scarico mai l
54. entualmente recuperarlo in un secondo momento 17 70097 70099 70100 13Movimentazione In qualsiasi situazione di trasporto l ADV deve essere sempre chiuso Il veicolo stato pensato per essere utilizzato in ambiente acquatico quando lo dovete trasportare o caricare in auto data la sua forma ed il suo peso dovete osservare alcune precauzioni Sollevatelo impugnando un supporto del condotto di flusso e la maniglia di prua Durante il trasporto in auto o in barca bloccatelo in modo che non si muova Si consiglia l uso del supporto cod 70068 vedi accessori Suex In barca o gommone non metterlo mai a prua o comunque in posizione tale che possa essere sottoposto a forti scossoni le parti interne potrebbero danneggiarsi Quando si appoggia l ADV al suolo fatelo sempre con delicatezza e quando viene posizionato verticalmente appoggiatelo sulla protezione dell elica curate che sia appoggiato su un piano e che nulla vada a contatto con l ogiva dell elica Se preferite impugnare l ADV per le maniglie di manovra fatelo pure ma cercate di non sollecitarle troppo non sono state realizzate per sopportare carichi eccessivi Non sostenere il peso dell ADV solo con una maniglia PRIMA DI IMBARCARE L ADV A BORDO DI VELIVOLI O MEZZI PUBBLICI INFORMATEVI SULLE NORME PER IL TRASPORTO DELLE BATTERIE 14Uso del veicolo subacqueo ADV L immersione subacquea un attivit potenzialmente pericolosa l utilizzo scorretto dell
55. erimento dell involucro non A fuoriescano i cavi o i connettori potrebbero danneggiarsi Trattenere sempre l involucro durante l inserimento non lasciarlo cadere potrebbe danneggiarsi CAUTELA 70097 70099 70100 4 Regolazione assetto L assetto dell ADV deve essere NEUTRO ovvero ne negativo affondare ne positivo galleggiare ma deve rimanere stabile alla quota desiderata eventualmente leggermente positivo Il mezzo viene fornito con assetto neutro in acqua dolce per compensare la differenza tra impiego in acqua dolce ed impiego in acqua salata viene fornita in dotazione una zavorra consistente in blocchetti da posizionare e fissare su due lati sul disco che separa il vano motore dal vano batterie Se necessario regolare il trim tendenza a puntare verso il fondo con la parte anteriore o posteriore spostando verso prua o verso poppa la batteria avvitando o svitando le boccole filettate impiegate per il suo sostegno e bloccaggio in modo che infine assuma una posizione orizzontale Un assetto eccessivamente POSITIVO NEGATIVO o decisamente inclinato potenzialmente PERICOLOSO 5 Materiale in dotazione L ADV viene fornito con i seguenti materiali in dotazione Manuale di uso e manutenzione Carica batterie completo di manuale di uso e manutenzione Zavorra per assetto in acqua salata A seconda dei modelli ADV 20 Batteria al piombo 20Ah ADV 33 Batteria al piombo 33Ah ADV 42 Batteria al piombo 42Ah
56. esaurimento della batteria Dopo l utilizzo del ADV ricordarsi di interrompere sempre lalimentazione al motore tramite l utilizzo dell interruttore Questo perch il controllo elettronico dell ADV anche se il motore non in funzione ha un piccolissimo consumo energetico che a lungo porta alla scarica della batteria L intervento del dispositivo di cut off elimina la possibilit che la batteria si sovrascarichi ma se per qualche motivo esso non dovesse funzionare il risultato sarebbe quello della completa scarica della batteria con possibile inversione di polarit di qualche cella 29 Dispositivo di allarme acustico batteria scarica Gli ADV Suex sono dotati di un sistema di allarme acustico sibilo continuo facilmente udibile sia in immersione sia in emersione il quale entra in azione automaticamente al raggiungimento di una tensione impostata valore considerato minimo per l utilizzo dell ADV senza sfruttare ulteriormente ed in modo non appropriato la batteria Tale avviso interviene sempre sia che si stia utilizzando l ADV o nel caso che esso possa essere stato dimenticato con il sezionatore in posizione ON Con il segnalatore acustico in funzione l ADV potr rimanere attivo ancora per qualche minuto Questo tempo pu variare molto e dipende da vari fattori come la potenza utilizzata e lo stato di usura delle batterie QUANDO INTERVIENE QUESTO DISPOSITIVO E VIVAMENTE RACCOMANDATO DI NON SFRUTTARE ULTER
57. ettuate regolarmente 33 SUES 70097 70099 70100 AA NOTA SULLA SICUREZZA Il pomello di blocco grilletto cruise deve essere utilizzato solo sotto il massimo controllo della situazione da parte del subacqueo Deve essere possibile in qualunque momento intervenire sul pomello stesso sul grilletto o sull interruttore di accensione dell ADV al fine di evitare qualsiasi tipo di rischio di collisione o di trascinamento del subacqueo in zone pericolose II pomello va utilizzato unicamente per il blocco della prima velocit regolata al massimo al 50 della potenza disponibile Bloccare l avvio dell ADV alla massima potenza potenzialmente pericoloso Durante il normale utilizzo dell ADV il pomello deve essere ruotato completamente in senso antiorario e cos bloccato in modo tale che non vada in alcun modo a fermare il normale ritorno del grilletto Agire sul pomello unicamente con la forza di due dita IN OGNI CASO PRESTARE LA MASSIMA ATTENZIONE DURANTE L UTILIZZO DEL POMELLO DI BLOCCO GRILLETTO IN QUANTO QUESTA OPERAZIONE E SEMPRE PERICOLOSA 33 2 Utilizzo del dispositivo N HANDLE Immergere lo scooter Accendere lo scooter tramite l interruttore principale Impugnare il dispositivo Infilare due dita il dito indice e il dito medio nella sede del grilletto Tirare il grilletto con il dito medio esso si fermer sul fermo prima velocit permettendo di governare lo scooter alla velocit impostata rego
58. evice troubleshooting PROBLEM CAUSE SOLUTION The cruise knob is blocked and will not turn Lubricate the knob screw and try again The scooter does not operate or jerks when the Adjust the magnetic piston to the correct position trigger is pulled fully back The lock screw turns freely The thread was damaged and requires replacement Accessories available for the N HANDLE device can be found at www suex it 71 Accessories optional BATTERY CHARGE LEVEL LED 71 1 Description A lighted signal that indicates the battery charge level is located on the ADV motor body The three blue leds turn on automatically and are managed by an electronic device in the motor compartment that measures battery voltage 71 2 Operations Since the time between one led lighting and the next may vary according to the type of battery and its conditions of use this device is only to be considered an additional assistance to the diver just an additional aid Programming a dive according to indicator leds is strictly prohibited and discouraged True and secure battery duration should be tested by a burn test instrument accessory code 70037 which precisely indicates how much energy is left in the battery Battery fully charged 3 leds on Battery at half charge 2 leds on Battery low 1ledon Even if batteries are not fully charge all three leds will most probably turn on when the ADV is turned on especially with Pb and NiMH
59. ged must be checked The motor may be damaged must be replaced The battery pack may be damaged must be replaced The speed regulation doesn t work The control system may be damaged must be replaced The ADV s running time is visibly diminished The batteries need to be replaced The battery charger is broken or does not work well must be replaced When the main switch is on the ADV runs continuously with no chance of stopping it The control card is damaged must be replaced The motor is noisy The ADV needs to be serviced Vibrations are felt when the propeller rotates The propeller is damaged must be replaced The drive system is damaged needs to be serviced The ADV floods very slowly Replace all the O rings and carefully check that the seating surfaces are not damaged See section 18 Spare Parts The control trigger sticks and the ADV remains running Shut off the ADV try to slide the starting piston driven by the trigger to get out any foreign bodies try to start again If the ADV continues to work the starting system must be verified probably it was damaged by a shock operations to be carried out by SUEX authorised service centres 58 70097 70099 70100 59 Maintenance Lubrication of head cap O ring Open the ADV gently remove the lock O ring being careful not to scratch the O ring support surfaces and clean the seating th
60. harge start 20 C Conditions other than those described above may significantly influence charging as well as the number of possible charges with acceptable yield 65ldeal battery depletion conditions We recommend using discharging batteries at a room temperature between 5 C and 35 C To avoid short term deterioration and potential cell polarity inversion the battery should never in any case fully deplete When during ADV use a significant propeller power drop is noted do not insist on using the ignition in these battery depletion conditions CONTINUING _DIVING VEHICLE USE IS HIGHLY DISCOURAGED the battery is about to short During ADV use it is best not to constantly drive at maximum speed but to use the rpm regulator suspending frequent starts making brief pauses to give the battery time to better conduct the chemical reaction required to generate power avoiding abrupt cell heating 65 1 Important note on battery depletion After ADV use always remember to cut off motor power using the switch This is because the ADV electronic control even if the motor is not running consumes a small amount of energy which in the long term depletes the battery The cut off device prevents the battery from overheating but if for any reason it malfunctions the battery would die and the polarity of some cells may invert 66 Battery depleted alarm siren device Suex ADVs are equipped with an alarm siren system continuous sir
61. ignition at maximum power is potentially hazardous During normal ADV use the knob must be fully rotated counter clockwise and locked in place so that it does not stop normal trigger return in any way Only use the knob with two fingers IN ANY CASE PAY THE UTMOST ATTENTION DURING TRIGGER LOCK KNOB USE SINCE THIS OPERATION IS ALWAYS HAZARDOUS 70 2 N HANDLE device use Submerge the scooter Turn on the scooter using the main switch Grasp the device Insert two fingers your index and middle fingers around the trigger Pull the trigger with your middle finger It will stop at the first speed to let you drive the scooter at the set speed adjustable using the knob e Pullthe trigger fully back using your index finger and the scooter will run at maximum power e Release the trigger at any time to stop the scooter Accessory support The purpose of the accessory support is to be able to attach any object that may be useful during dives on the handle For this reason SUEX has created some supports to be used with normal wrist or console tools Support use Loosen the lock screw and insert the support Tighten the lock screw only using two fingers Always make sure the screw is fully screwed in when the support is not used NOTE do not force the lock screw Maintenance The N HANDLE does not require special maintenance Follow the ADV s general maintenance instructions 70 SUES 70097 70099 70100 70 3 N HANDLE d
62. iiie eine 56 Flooding of the diving vehicle SINKINQ rriiiiii inni 57 Precautions TOF USE cain 57 Gleaning and Ke Ed LTE 57 Troubleshooting rrrrrirrne ieri iii iii 58 Maintenance ica 59 Disposal and scrapping riiii iii 59 Battery charge general rules vrenrrrcrennere cia neneeaenze renne nere rione cena eaneneneene cecina nici cane re ace nei nciane oneri renienee 60 How to charge the battery Pb gel battery information Ideal battery Charging conditions serre iii 62 Ideal battery depletion conditions tree iii 62 Important note on battery depletion iii 62 Battery depleted alarm siren device nre 62 CUT OFF battery protection system operating principle and instructions for use 62 Procedure to follow in the event the cut off device is triggered i 63 Pb gel battery frequently asked Qquestions ritiri iii 63 Accessories optional PROP LOCK PROPELLER rrie iii 64 RE ie le EE 64 How to remove the prop lock propeller nenna 67 How to insert the prop lock propeller nnana 67 Prop lock propeller maintenance 67 Prop lock propeller troubleshooting AA 68 Accessories optional N HANDLE CONTROL sccceseeesseeeeeeeee
63. intillii proprio per la possibile presenza di idrogeno Il connettore va immediatamente sostituito assistenza suex Ho erroneamente tirato i cavi della batteria e si danneggiato l isolamento posso sostituirli o basta che provveda ad isolarli nuovamente con del nastro adesivo cavi danneggiati vanno assolutamente sostituiti un corto circuito tra di essi potrebbe anche far esplodere la batteria con conseguenze gravi per cose e persone assistenza suex Ho visto che la batteria costituita da due elementi commerciali da 12 volt cadauno incollati e collegati in serie per ottenere 24 volt la mia batteria danneggiata posso assemblarmi in casa una nuova batteria utilizzando il connettore ed i cavi della vecchia La SUEX S r l non autorizza e non consiglia di assemblare in casa le batterie questo per diversi motivi tra i quali l utilizzo di batterie di primaria marca e capacit Tuttavia nel caso l utente esperto volesse cimentarsi in questo tentativo si raccomanda di utilizzare sempre batterie nuove e della stessa marca mai assemblare batterie di marca o usura diversa La SUEX S r l in ogni caso non si assume nessuna responsabilit sul funzionamento dell ADV o di eventuali incidenti o danni dovuti a batteria assemblate dal cliente Voglio aumentare la velocit dell ADV posso aggiungere una terza batteria magari anche pi piccola per incrementare la tensione e far girare il motore elettrico pi veloce No La batteria p
64. ionare ADV in posizione verticale con la prua verso l alto appoggiato su una superficie piana Ruotare in senso antiorario il volantino Fig 3 1 e continuare nella rotazione fino a quando l involucro non si sia staccato dal gruppo propulsore Fig 3 2 Afferrare la fascia di prua Estrarre l involucro sollevandolo verso l alto se necessario trattenere al suolo il gruppo propulsore appoggiando un piede sulla protezione dell elica Appoggiare l involucro estratto evitando che si insinui all interno polvere o sabbia in modo particolare curare la pulizia della sede della guarnizione OR Fig 3 1 Deve essere aperto SUES 70097 70099 70100 3 2 Accesso alla batteria Nei modelli ADV 18 e 28 si estrae un unico pacco batterie composto da due batterie da 12V collegate in serie mentre nei modelli ADV 33 e 42 si estraggono le batterie da 12V singolarmente a causa del loro peso in quest ultimo caso necessario scollegare il cavo impiegato per comporre il collegamento in serie Il pacco batterie va ricaricato sempre ricollegando le batterie in serie ATTENZIONE Ricollegare i cavi accoppiando sempre i connettori di colore uguale Staccare i connettori con decisione e senza strappare i cavi slacciare la fascia di velcro anteriore estrarre la batteria ATTENZIONE Il peso della batteria minimo di 10 Kg usare tutte le precauzioni del caso per non farla cadere o per non generare infortuni 70097 70099 70100 1 Fa
65. it E mail info suex it This use and maintenance manual is the exclusive property of SUEX S r l Any unauthorized reproduction even partial is prohibited For that not foreseen by this manual please refer for affinity to civil code regulations while any disputes shall be submitted to the Court of Treviso 74 CE conformity 70097 70099 70100 SUED THE SUBMARINE EXPLORATION COMPANY SUEX S r l Via Roma 261 35 31020 Villorba TV Italy International Phone 39 0422 444849 FAX 39 0422 620604 Contact Email info suex it www suex it www suex eu DECLARATION OF CONFORMITY SUEX S r l Declare under our sole responsibility as Distributor that the product Underwater Scooter model Zeuxo 20 33 42 Complies with regulations Machinery Directive 2006 95 CE Electromagnetic Compatibility EMC 2004 108 CE and declares that the following rules are applied UNI EN ISO 14151 1 2007 UNI EN ISO 12100 1 2009 UNI EN ISO 61000 6 4 UNI EN ISO 61000 6 1 CEI EN 60034 1 CEI EN 60335 1 Villorba january 01th 2009 The administrator Giuseppe Fenu 75
66. l is ensured by O ring type gaskets 40 SUES 70097 70099 70100 41 SUES 70097 70099 70100 39Technical specifications ADV 20 Size Length x breadth x height mm 779x460x364 Weight Kg 36 2 Max speed m min 60 Running time min 60 Voltage V DC 24 Charging time h 8 Maximum operating depth m 120 ADV 33 Size Length x breadth x height mm 1079x460x364 Weight Kg 50 9 Max speed m min 60 Running time min 60 Voltage V DC 24 Charging time h 10 Maximum operating depth m 120 ADV 42 Size Length x breadth x height mm 1219x460x364 Weight Kg 59 Max speed m min 60 Running time min 60 Voltage V DC 24 Charging time h 12 Maximum operating depth m 120 Calculated using new batteries using 80 of their capacity in normal non continuous working conditions with dual tank and GAV settings 42 SUES 70097 70099 70100 40 Preliminary operations Check the integrity of the shipping carton and that of the components supplied refer to section 5 40 1 Opening the hull Stand the ADV vertically on a level surface with the front at the top Rotate the hand wheel counter clockwise Fig 3 1 and continue rotating until the hull detaches from the propulsion unit Fig 3 2 Hold the front part Extract the hull lifting it upwards If necessary hold the propulsion unit on the ground by placing
67. labile tramite apposito pomello e Tirare il grilletto a fondo utilizzando il dito indice e lo scooter funzioner alla massima potenza e Rilasciare il grilletto in qualsiasi momento per fermare lo scooter Supporto accessori Il supporto accessori serve per poter applicare alla maniglia qualsivoglia oggetto che possa essere utile durante l immersione A tal scopo esistono alcuni supporti che SUEX a realizzato con l intento di poter utilizzare i normali strumenti da polso o da consolle Utilizzo del supporto Allentare la vite di blocco e inserire il supporto Serrare la vite di blocco con la sola forza di due dita Mantenere sempre avvitata a fondo la vite quando non si utilizza il supporto NOTA non forzare la vite di blocco Manutenzione La maniglia N HANDLE non necessita di particolari manutenzioni seguire le norme generali di manutenzione dell ADV 34 70097 70099 70100 33 3 Problemi cause e rimedi dispositivo N HANDLE PROBLEMA CAUSA RIMEDIO Il pomello cruise si bloccato non gira Lubrificare la vite del pomello e riprovare Premendo a fondo il grilletto lo scooter non funziona Bisogna regolare la corretta posizione del pistoncino o funziona a intermittenza magnetico Stringendo la vite di blocco gira a vuoto La filettatura stata danneggiata va sostituita Sul sito web www suex it potete trovare alcuni accessori da utilizzare con il dispositivo N HANDLE 35 SUES 70
68. longed use If conditions allow you to remove the foreign body safely during the dive then do so Otherwise let go of the ADV and pick it up later 50Handling In every transport condition the ADV must be always closed The vehicle has been conceived for use in water environments When transporting it or loading it onto a car some precautions need to be taken due to its shape and weight Lift it holding a flow conduit support and front handle Whilst transporting it by car or by boat make sure it is blocked in a secure position The use of the support cod 70068 is advised see Suex accessories 54 70097 70099 70100 Do not position the ADV at the front of boats or dinghies or in positions where it would be subjected to harsh jolting the inner parts may be damaged When the ADV is laid on the ground always do so gently and when it is placed in the upright position rest it on the propeller guard Always make sure that the surface is flat and that nothing comes into contact with the propeller hub If you prefer to grip the ADV from the maneuvering handles do so but do not overstress them they were not designed to bear excessive loads Do not carry the entire weight of the ADV on only one handle BEFORE EMBARKING THE ADV ON AIRPLANES OR PUBLIC TRANSPORTATION VEHICLES PLEASE READ THE REGULATIONS ON BATTERY TRANSPORT 51 Using the ADV diving vehicle Underwater diving is a potentially dangerous activity and incorrect use of the A
69. ne e diventa essenziale quando ci si immerge con l ADV In linea di principio il tipo ed il posizionamento dell attrezzatura deve garantire una perfetta idrodinamicit e non presentare elementi sporgenti o penzolanti 16 SUES gt SC 70097 70099 70100 La posizione del subacqueo in immersione dovr essere tendenzialmente orizzontale assetto e galleggiamento che derivano sempre da una corretta configurazione dell attrezzatura e da un adeguato addestramento ai fini della sicurezza dell autonomia della velocit e del comfort in navigazione Prestare la massima attenzione nel disporre l attrezzatura con particolare cura riguardo a fruste erogatori bombole al fianco manometri A consolle avvisatori acustici lampade e relativi cavi reel evitando che penzolino e quindi possano venire a contatto con l elica o impigliarsi inavvertitamente sul fondale o sul compagno creando situazioni di PERICOLO pericolo anche grave 12 3 Zona pericolosa e rischi residui L elica protetta mediante una fascia circolare esterna radiale per esposta sia dal lato aspirazione che dal lato espulsione In corrispondenza di tali zone non sono state poste ulteriori protezioni perch ridurrebbero notevolmente il passaggio del fluido nel condotto riducendo drasticamente il rendimento del sistema propulsivo Rischio di impigliamento e taglio Non introdurre alcun oggetto o parte del corpo all interno del condotto di flusso a contatto
70. nni o inesperti Non trasportarlo smontato o aperto Non ricaricare le batterie con un caricabatterie diverso da quello in dotazione Non tentare di fermare l elica con le mani Non bloccare il grilletto di avvio con marcia inserita Non lanciarlo dalla barca o dalla riva Nonsmontarlo Non farlo funzionare a secco in superficie Non bagnare i connettori elettrici Non cortocircuitare la batteria Non staccare i cavi dal connettore od invertirne la polarit Verificare spesso il fissaggio della fascia di tessuto a prua e che non sia danneggiata una sua improvvisa rottura potrebbe essere causa di CAUTELA incidenti Non bagnare le parti interne dell ADV e le batterie 20 70097 70099 70100 20Pulizia e rimessaggio Dopo l uso l ADV deve essere sciacquato con acqua dolce per lo sporco pi resistente pu essere usato anche del detergente neutro prima di aprirlo importante eliminare ogni residuo di salsedine e sabbia In particolar modo deve essere pulito e liberato da residui il pistoncino di comando collegato al grilletto Non usare solventi od idrocarburi Deve essere riposto possibilmente in luogo fresco pulito ed areato in posizione verticale con la prua verso l alto la batteria deve essere tolta ricaricata e conservata anch essa al riparo dal gelo e dall eccessivo calore Attenzione che l accidentale contatto con oggetti metallici all interno del connettore non la cortocircuitino Il v
71. olantino di apertura dell involucro deve essere allentato Nota importante togliere sempre le batterie dopo l uso 21 Problemi cause e rimedi PROBLEMA CAUSA RIMEDIO L ADV non funziona allo spostamento del grilletto Aprire ADV controllare che le batterie siano cariche l elica non gira e che i connettori siano inseriti e non danneggiati poi riprovare Nonostante le batterie siano state caricate ed i Il sistema di controllo potrebbe essere danneggiato connettori siano inseriti l ADV non funziona va verificato Il motore elettrico potrebbe essere fuori uso va sostituito La batteria potrebbe essere danneggiata va sostituita La regolazione della velocit non funziona Il sistema di controllo potrebbe essere danneggiato va sostituito L autonomia dell ADV vistosamente diminuita Le batterie sono da sostituire Il caricabatterie rotto o non funziona correttamente va sostituito Alla chiusura dell interruttore generale ADV Il sistema di controllo si danneggiato va sostituito funziona sempre non Ce modo di fermarlo Il motore rumoroso L ADV va revisionato L elica stata danneggiata sostituirla Si avvertono delle vibrazioni al girare dell elica Il sistema di trasmissione danneggiato va revisionato Sostituire tutte le guarnizioni di tenuta e guardare L ADV si allaga molto lentamente attentamente che le sedi interne del tubo non siano rigate
72. olarmente pericoloso quali nell immersione profonda negli ambienti ostruiti melmosi o soggetti a sospensione le specifiche precauzioni da adottare nel caso di immersioni in tali ambienti e la necessit di aver seguito adeguati corsi di addestramento tenuti da qualificate agenzie i comportamenti da evitare in quanto pericolosi quali a mero titolo di esempio l utilizzo del veicolo subacqueo per incrementare la velocit di discesa o di risalita e assume quindi che l utilizzatore abbia ricevuto compiuta informazione sulla manutenzione sul corretto uso e sulle caratteristiche del prodotto alle quali lo stesso si dovr attenere scrupolosamente e Pertanto qualsiasi danno a persone o cose conseguente a difetti di manutenzione del veicolo subacqueo o ad un suo utilizzo con modalit diverse da quelle indicate nel presente manuale o senza le precauzioni ivi descritte non potr essere casualmente ricondotto a difetti del prodotto La Suex Srl declina ogni responsabilit per perdite o danni subiti da terze persone derivanti dall utilizzo di questo veicolo subacqueo L ADV non un giocattolo n un mezzo idoneo al salvataggio La sua funzione esclusivamente quella di ausilio al sub esperto nelle sue immersioni al quale consente di coprire una distanza maggiore rispetto a quella percorribile col solo uso delle pinne L ADV 11 70097 70099 70100 edi suoi componenti nel caso specifico la batteria ed il caricabatteria sono
73. on spedizione in tutto il mondo NOTA Utilizzando i lubrificanti spray arieggiare abbondantemente l interno dell involucro in modo tale che non vi ristagnino gas propellenti AVVERTENZA SONO quasi sempre infiammabili 23 Smaltimento e rottamazione Questo apparecchio costruito parzialmente con materiali riciclabili Quando le condizioni di utilizzo non sono pi soddisfacenti sotto il punto di vista della sicurezza o l assistenza ritiene che non possa pi essere utilizzato ADV deve essere demolito Deve essere smontato e separato nelle sue parti le parti in plastica vanno depositate in appositi contenitori per la raccolta del materiale plastico le parti metalliche portate presso un centro di raccolta materiali metallici Particolare cura va posta nello smaltimento degli accumulatori essi sono altamente inquinanti per l ambiente vanno obbligatoriamente per AVVERTENZA legge portati in un centro di raccolta accumulatori usati NON DISPERDERE NELL AMBIENTE ALCUNA PARTE DEL MEZZO IN PARTICOLAR MODO GLI ACCUMULATORI 22 SUES 70097 70099 70100 24 Ricarica della batteria norme generali LEGGERE ATTENTAMENTE IL MANUALE DI ISTRUZIONI DEL CARICABATTERIA La batteria va ricaricata solo tramite l apposito carica batteria in dotazione La ricarica deve avvenire in luogo coperto ed aerato lontano da oggetti o liquidi infiammabili in locali non frequentati da persone e tantomeno dentro il luogo di abitazione
74. or spent batteries PLEASE SAFEGUARD YOUR SURROUNDINGS ALL VEHICLE PARTS AND THE BATTERY PACKS IN PARTICULAR SHOULD BE DISPOSED OF ACCORDING TO LOCAL DISPOSAL REGULATIONS 59 SUES gt SC 70097 70099 70100 61 BEER charge general rules CAREFULLY READ THE BATTERY CHARGER INSTRUCTIONS MANUAL The battery should only be charged with the specifically supplied battery charger Charge the battery in a well ventilated covered area away from flammable objects or liquids away from crowded rooms and in no way in the home The battery must be connected to the charger using the specific connector REMOVE THE BATTERY from the ADV and wait at least two hours before charging Do not connect any device to the battery when charging The battery should be kept off the ADV and only inserted and connected to the engine immediately before use it should be disconnected and removed immediately after use 62 How to charge the battery Remove the battery from the ADV Place it in a protected well ventilated area away from people and flammable materials FIRST connect the battery charger to the battery charge connector varies according to the model on the battery NEXT connect the battery charger to the mains Wait until fully charged see battery charger instructions Replace the battery in the ADV before use it from the ADV discouraged In this case we recommend Some models let you physically charge the battery without removing
75. ored 49 2 Equipment configuration and riding position SUEX diving vehicles are TOW BEHIND type as opposed to a ride on top which must be straddled and ideally the diver should be towed behind the ADV Attention The ADV should not be improperly bound to the diver The user should be able to abandon the ADV at all times and with extreme ease If you want to use a towing device the fast release fitting cod 70089 must be used See images on the following page Fig 1 hooked device Fig 2 unhooked device Figure 5 E z Figure 6 Correct equipment configuration is a crucial factor for safe diving in general and becomes vital when diving with the ADV As a rule the type and position of the diving equipment should guarantee perfect streamlining and no elements should protrude or be left dangling The divers position during the dive must be more or less horizontal posture and buoyancy always derive from correct equipment configuration and adequate training This ensures safety longer running times speed and riding comfort 53 70097 70099 70100 Be especially careful when setting out your equipment especially as regards hoses regulators pony bottles pressure gauges audible alarms flashlights and pertinent cables reels etc making sure they do not dangle and that they cannot come into contact with the propeller or entangle themselves on the bottom or on your buddy creatin possibly serious hazard situations
76. ori che una volta assemblati assieme costituiscono l ADV nella sua integrit rendendo l insieme ermetico 70097 70099 70100 36 1 Descrizione delle parti Il gruppo propulsore A vedi fig 3 e 4 collegato al supporto delle batterie B tramite 4 dadi autobloccanti Y facilmente svitabili con una chiave fissa da 10 mm In alcuni modelli viene utilizzato l anello adattatore D fissato con 6 viti X al propulsore A per compensare i diversi diametri del corpo C e collegare in modo ermetico il gruppo propulsore A con il corpo C Figura 3 Figura 4 38 70097 70099 70100 Nella figure 3 e 4 si porta come esempio il modello ZEUXO 20 ma il principio di assemblaggio dei vari componenti esattamente lo stesso 36 2 Sostituzione delle parti Per effettuare la separazione delle parti principali dell ADV posizionare ADV appoggiato sul convogliatore dell elica su di una superficie piana in modo che sia in posizione verticale con la batteria verso l alto Dopo aver tolto l involucro C estrarre e mettere da parte la batteria svitare i 4 dadi Y e togliere il supporto batteria B Se il nuovo involucro C ha dimensioni diverse svitare con un cacciavite a croce PH2 anche le 6 viti X e sfilare l anello adattatore D vedi fig 4 Per riassemblare ADV procedere in modo esattamente inverso sostituendo le parti necessarie alla trasformazione ATTENZIONE Le viti autofilettanti X vanno riavvitate con cautel
77. oroughly only by means of a clean brush or soft cloth Do not use any type of solvent or alcohol Apply silicone oil to the O ring and return it to its place Do not use any other type of oil We recommend the aerosol spray type which is usually used for diving equipment Occasionally lubricate the lock knob screw with normal mineral grease Never lubricate trigger or magnetic piston movement They would fill of sand and dirt Do not lubricate electrical contacts Supplementary maintenance Every hundred hours of use or at least every two years we recommend you overhaul the ADV checking hydraulic seals and electrical circuits SUEX S r l fully overhauls your ADV with shipping throughout the world NOTE using spray lubricants it is important to air the inside of the ADV In this way the propelling gas go away for the most part are 60 Disposal and scrapping This apparatus is partly constructed with recyclable materials When the ADV can no longer be used safely or when the service centre deems it no longer suitable for use the ADV must be scrapped The ADV must be disassembled and divided into distinct parts Plastic parts must be deposited in the relative plastic waste containers and metal parts must be taken to a collection centre for metal waste Special care must be taken when disposing of battery packs since these contain LEAD which is highly polluting to the environment Batteries must be taken to a collection centre f
78. pletely remove the nut 1 Remove the propeller pulling it outwards If difficult to remove do not use a hammer but grasp the propeller with two hands and pull harder Removing the standard threaded pin Unscrew and completely remove the standard threaded pin 2 Prop lock threaded pin assembly lt 4 Insert and fully screw in the threaded prop lock pin 3 being careful to insert the SHORTER threaded part in the shaft 65 SUES 70097 70099 70100 Note to make screwing and unscrewing the threaded pin easier we recommend using the specific tool code 70319 A green rubber spring should be found in the shaft between the traction pin and threaded pin Its purpose is to prevent the traction pin from accidentally exiting the shaft IMPORTANT THE TRACTION PIN SHOULD EQUALLY PROTRUDE FROM BOTH SIDES OF THE SHAFT Grasp the prop lock propeller and make sure the screw 5 is loose If not loosen it as illustrated It should protrude about 3 mm from the white knob Insert the propeller in the underwater ADV shaft make sure the plug 4 is inserted in its housing on the internal side of the propeller If this is not the case rotate the propeller WITH YOUR HANDS until inserted PLUG IN THE ASSEMBLY HOUSING CORRECT 66 SUES gt 5C 70097 70099 70100 Screw in the white knob until the two surfaces A and B are aligned At this point hold the white knob still and fully screw in the screw 5
79. resente sullo scooter quella adatta allo scopo Ogni manomissione o modifica a totale responsabilit di chi la effettua Posso utilizzare batterie diverse da quelle date in dotazione per esempio al posto di una batteria al piombo due batterie al NiMH collegate in parallelo No Le batterie non vanno MAI collegate in parallelo la pi carica andrebbe a caricare la pi scarica e il fenomeno avviene senza regolazione di corrente con tutta quella disponibile scatenando effetti che potrebbero essere devastanti NON COLLEGARE LE BATTERIE IN PARALLELO Devo scaricare saltuariamente la batteria fino al massimo della scarica No Le batterie al piombo non hanno effetto memoria ogni scarica un ciclo di vita in meno e basta Come faccio a conoscere l efficienza della batteria Se devo programmare un immersione come posso avere la certezza che la batteria carica mi dia una determinata autonomia Per questo scopo esiste uno strumento completamente automatico che simula l assorbimento elettrico dell ADV durante il funzionamento e scarica la batteria fino alla tensione residua programmata Al termine su un display compare la durata in minuti della scarica In base a quel dato possibile conoscere lo stato di salute della batteria e programmarne il corretto utilizzo vedi accessori burn tester Non utilizzare altri sistemi di scarica 70097 70099 70100 27 SUES 32 Accessori opzionali ELICA PROP LOCK 70097 70099
80. rgers When the battery charger is not in use disconnect it from the power socket Even when not in use a fully charged battery slowly dies due to the self discharge phenomenon charging the batteries within 24 hours of use is recommended Extreme temperatures significantly affect battery charge capacity Leaving the battery in hot or cold climates such as for example a closed car in mid summer or mid winter reduces battery capacity and life Always try to keep batteries at a temperature between 15 C and 25 C Battery performance is significantly reduced at temperatures lower than 0 C DO NOT THROW BATTERIES IN FIRES THEY EXPLODE Do not use the battery for purposes other than those prescribed Never use damaged battery chargers or batteries Accumulators must be kept outside the ADV in dry locations relative humidity 65 5 and at a temperature between 5 C and 25 C with the electric connectors away from metallic objects that can short circuit the two battery poles with serious fire hazard damages to people and property Do not wet electrical contacts Dispose of batteries observing local regulations such as for example recycling them Do not dispose of batteries with domestic waste Ja aw Piombo Pb 61 SUES 70097 70099 70100 64ldeal battery charging conditions Admitted room temperature from 10 C to 35 C ideal 20 C Slow charge option when permitted by the charger Battery temperature at c
81. scia in velcro 2 Zavorra 3 Pacco batterie 4 Boccola filettata 5 Zavorra per acqua salata 70097 70099 70100 3 3 Inserimento della batteria Prima dell utilizzo dello scooter la batteria deve essere riposizionata nel proprio alloggiamento Verificare che la fascia di velcro posteriore sia chiusa Inserire la batteria tra le boccole nel caso di due batterie separate inserire prima quella inferiore Chiudere la fascia di velcro anteriore Connettere i cavi posizionandoli come da immagini precedenti Verificare che la batteria sia opportunamente bloccata al supporto eventualmente agire sulle boccole o sulle fascie di velcro 3 4 Chiusura dell involucro Appoggiare lo scooter su un piano in verticale con lelica verso il basso Controllare attentamente che la guarnizione OR di chiusura sia inserita nella propria sede pulita ed adeguatamente lubrificata con olio siliconico Verificare la pulizia anche della bocca dell involucro eventualmente utilizzate un pennello asciutto per eliminare polvere o sabbia Inserire l involucro dall alto afferrandolo per la fascia di prua e orientandolo in modo tale che la fascia si venga a trovare nella posizione corretta Accompagnare l involucro per tutta la discesa fino a farlo combaciare con il blocco motore Ruotare in senso orario il volantino fino a chiusura completa senza stringere troppo Con la sola forza di due dita dispositivo brevettato Accertarsi che durante l ins
82. sequence for 24 volt My battery is damaged Can assemble a new one using the connectors and wires from the old one Suex S r l does not authorize or recommend do it yourself battery assembly for various reasons including the use of leading brand and capacity batteries However if an expert user insists on this attempt always using new batteries of the same brand and never combining different branded or worn batteries is recommended SUEX S r l in any case is not liable for ADV operations or any accidents or damages due to customer assembled batteries want to increase ADV speed Can I add a third battery even a smaller one to increase voltage and increase engine rpm No The battery is the best for scooter purposes Whoever tampers with or modifies the battery is fully liable Can use batteries other than those supplied like for example two NiMH connected in parallel instead of a lead battery No Batteries should NEVER be connected in parallel A greater input would create a greater output and this would occur without any voltage regulation with all that available triggering effects that could be devastating NEVER CONNECT BATTERIES IN PARALLEL Should usually fully deplete batteries No Lead batteries have no memory effect Each depletion is one less life cycle How can tell what the battery efficiency is If have to plan a dive how can be sure that the battery charge provides a certain autonomy For this reason there is
83. sione in questi ambienti di per s E MOLTO PERICOLOSA IL NON CORRETTO UTIILIZZO DELL ADV IN TALI AMBIENTI POTREBBE AUMENTARE IL RISCHIO DELL IMMERSIONE L IMMERSIONE IN TALI AMBIENTI PREVEDE ADEGUATI CORSI DI ADDESTRAMENTO TENUTI DA QUALIFICATE AGENZIE A titolo di esempio l elica in movimento orientata verso il fondo pu sollevare una notevole quantit di sospensione L avviamento accidentale di un ADV di riserva che si sta trainando pu creare situazioni di serio pericolo 18Allagamento del veicolo subacqueo affondamento E un ipotesi che potrebbe verificarsi soprattutto a seguito di un uso improprio di un forte urto subacqueo di una non corretta chiusura di una inefficiente manutenzione In caso di allagamento il mezzo comincer ad assumere un assetto negativo e quindi ad affondare In caso di allagamento totale la situazione pu diventare POTENZIALMENTE PERICOLOSA in quanto ADV assumer un FORTE assetto negativo da circa 12 a 40 kg a seconda del modello TRASCINANDOVI VERSO IL FONDO e pertanto DOVRA ESSERE IMMEDIATAMENTE ABBANDONATO 19Precauzioni d uso Non tenere l ADV esposto alla radiazione solare chiuso in auto al sole o esposto al calore eccessivo max 50 C si potrebbe surriscaldare deformandosi e gli accoppiamenti non potrebbero pi garantire l ermeticit Evitare urti durante l immersione Non usarlo come sgabello Non salirci sopra con i piedi Non farlo usare a minore
84. speed The accessory kit lets you attach tool or video supports to your scooter Make sure the following material is found in the package Handle one piece Handle and left knob fastening screws 4 pieces Grip fastening screws 4 pieces Right handle complete with trigger one piece Accessory support one piece Left knob one piece 68 70097 70099 70100 9 Grip 10 Handle 11 Trigger 12 Cruise knob 13 Accessory support 14 Accessory support groove 15 First speed stop 16 Accessory support lock Equipment needed to assemble the handle not supplied 7 mm wrench or spanner 8 mm wrench or spanner 3 mm Allen key 4 mm Allen key PH2 Phillips screwdriver WATCH THE VIDEO AT WWW SUEX IT FOR TRIGGER ASSEMBLY AND REGULATION SAFETY NOTE Pay careful attention to the rotating propeller trauma risk IMPORTANT NOTE AN Do not insist with ADV operations on land shaft seals may be damaged see instruction manual Only operate for short periods 3 or 5 seconds in order to understand whether regulations are correct 69 SUES SAFETY NOTE 70097 70099 70100 The trigger lock knob cruise must only be used under the divers maximum control The knob trigger or ADV ignition switch must be usable at all times to avoid any type of collision or driver dragging risks in hazardous areas The knob must only be used to lock first speed adjusted to 50 of available power at best Locking ADV
85. traps for assistance 40 4 Closing the hull Place the scooter on a vertical surface with the propeller at the bottom Carefully check that the closing OR gasket is inserted in its housing clean and adequately lubricated with silicon oil Check hull mouth cleaning Use a dry brush to eliminate dust or sand Insert the hull from the top holding the front strap and directing it so that the strap fits into the correct position Accompany the hull downwards until it fits the motor unit Rotate the hand wheel clockwise until fully closed without over tightening Only use your hands Patented device Make sure that wires and connectors do not protrude when inserting the hull They could be damaged Always hold the hull during assembly never let it fall It could be damaged CAUTELA 41Buoyancy adjustment The ADV should have NEUTRAL buoyancy i e it should neither be negative sinking nor positive floating but should remain stable at the desired depth or slightly floating The scooter is supplied with fresh water neutral settings to compensate the difference between fresh and salt water use a ballast with blocks to be positioned and fastened on the two sides and on the disk that separates the motor compartment from the battery compartment is supplied If necessary adjust trim tendency for the front or rear to point down moving the battery towards the front or rear tightening or loosening the threaded bushings used to support and
86. ture therefore the same conditions apply as above How long does good lead battery efficiency last if not used This depends on many factors especially the quality of the battery Usually a battery charged at least every three months and never depleted can last up to five years How long does a battery used on your ADV last 63 SUES 70097 70099 70100 With sporting ADV use or about fifty dives a year a battery usually lasts in good condition for about three years and a total of about 150 charges If used more often it can even be used about three hundred times When the battery is dead what should I do with it The battery should be disposed of in a specific depleted lead battery recycling center There are specific collection centers in every city left the battery on the boat and sea elements rusted the silver plated connector contacts What should do All electrical contacts inside the ADV battery case should never generate electrical shocks or sparks due to the presence of hydrogen The connector should be replaced immediately Suex customer service pulled the battery wires by mistake and damaged the insulation Do I have to replace them or can insulate them with tape Damaged wires must be replaced A wiring short circuit could even make the battery explode creating serious hazards to people and property Suex customer service noticed that the battery is made up of two 12 volt retail elements glued and connected in
87. ubstitute manual for an adequate course held by certified agencies on the correct use of ADV on dives 49 70097 70099 70100 Introduction This manual contains the instructions and important warnings concerning the diving vehicles ADV manufactured by SUEX S r l Observance of the instructions contained in this manual will allow you to carry out use and maintenance operations safely while guaranteeing optimal vehicle operation and reduced running costs The company Suex s r l is not liable for damage resulting from negligence on behalf of the user or from failure to observe these instructions 44 Product identification The machine has been marked with a hot pressed serial number generally located in the body on the battery and engine body This number is to be quoted whenever technical assistance or spare parts are required 45 General safety and accident prevention regulations Pay special attention to the hazard signs in this manual There are 3 levels of hazard signs N This sign is a warning that failure of the user to adhere to the described operations will expose him to health hazards that may lead to serious or permanent harm This sign is a warning that failure of the user to adhere to the described operations will expose him to possible health hazards that shall not however lead to serious or permanent harm This sign is a warning that failure of the user to adhere to the described operations may lead to dam
88. until it hits the stop do not force 9 IMPORTANT NOTE Do not start the scooter with the propeller plug incorrectly inserted in the housing This would trigger the friction safety device which should only occur in the event of emergency Improper emergency friction use damages the friction and voids the warranty 69 2 How to remove the prop lock propeller Unscrew the white knob COUNTER CLOCKWISE until the propeller is fully removed 69 3 How to insert the prop lock propeller Insert the propeller on the ADV engine shaft Turn the propeller CLOCKWISE until the plug is in the correct fastening position Continue rotating the white knob CLOCKWISE Tighten the knob WITH YOUR FINGERS ONLY WITHOUT FORCING 69 4 Prop lock propeller maintenance The prop lock propeller does not require maintenance However make sure the propeller housing is clean and free of foreign objects before inserting it on the ADV shaft IMPORTANT NOTE THE PROP LOCK PROPELLER SINKS WHEN SUBMERGED IN WATER WHEN REMOVING AND REPLACING THE PROPELLER UNDERWATER BE CAREFUL SINCE YOU COULD RISK LOSING IT AND CONSEQUENTLY LOSE USE OF YOUR UNDERWATER SCOOTER PROP LOCK PROPELLER WARRANTY Suex guarantees the propeller for life against factory defects except for incorrect assembly incorrect use wear and all cases in which propeller faults are due to negligence or poor use Note The illustration of the ADV motor shaft in this manual is purely indicative
89. vided and hence the instructions contained within in particular how to use the diving vehicle with details regarding the diver s correct equipment configuration the divers posture during use the position that must be maintained by the diving vehicle during the dive and that the vehicle must not be bound with systems hard to release to its user in any way whatsoever the environmental conditions where use of the diving vehicle is especially dangerous such as deep water dives obstructed environments muddy or suspension filled environments the special precautions to be adopted when dives are effected in such environments and the need of having undergone suitable training held by qualified agencies dangerous behaviour that is to be avoided such as for example use of the diving vehicle to accelerate the descent or ascent rate e it is therefore assumed that the user has been fully informed on how to use and maintain the product as well as of its technical characteristics and that he shall scrupulously abide by these rules e t hence follows that any damage to persons or objects deriving from incorrect maintenance of the diving vehicle or from its use other than as stipulated by this manual or without the precautions described within cannot be attributed to defects of the product The company Suex S r l is not liable for losses or damages suffered by third persons consequent to the use of this diving vehicle The ADV is not
90. viluppo tecnologico i veicoli subacquei suex potranno essere modificati in ogni momento senza preavviso Il presente manuale non un manuale sostitutivo di un adeguato corso tenuto da agenzie certificate circa il corretto utilizzo dell ADV durante l immersione 12 70097 70099 70100 Premessa Questo manuale contiene le istruzioni e le avvertenze importanti riguardantidei i veicoli subacquei ADV prodotti da SUEX S r l L osservanza delle istruzioni contenute nel presente manuale consente di operare durante le fasi di uso e manutenzione in condizioni di sicurezza garantendo nel contempo il regolare funzionamento e l economia del mezzo Suex s r l declina ogni responsabilit per danni AVVERTENZA conseguenti a negligenza o alla mancata osservanza di queste istruzioni 7 Identificazione Sulla macchina stato apposto un numero di matricola impresso generalmente all interno del corpo sulla batteria e sul corpo motore In caso di necessit per richiesta di intervento di assistenza o per la fornitura di ricambi deve essere citato il numero riportato 8 Norme generali di sicurezza e di prevenzione infortuni Prestare particolare attenzione ai segnali di pericolo riportati in questo manuale segnali di pericolo sono di 3 livelli Questo segnale avverte che se le operazioni descritte non sono correttamente eseguite l utente sottoposto a rischi che potrebbero recare danni o lesioni con conseguenze anche gravi per l
91. wise and make sure the ADV does not start Fully rotate the By Pass knob clockwise without forcing Rotate the main switch clockwise The ADV starts in continuous mode Rotate the main switch counter clockwise to stop the ADV In normal operating conditions the By Pass device knob should be ALWAYS FULLY rotated counter clockwise Note This device should only be used in the event of real emergency meaning if electronics malfunction and the ADV cannot be started with the trigger Do not forget that THE ADV IS NOT A LIFE SAVING VEHICLE 72 SUES gt SC 73 Modularity Many of our ADVs can be easily transformed by our customers into models with different characteristics and autonomy The system adopted to achieve this possibility is that of conceptually dividing the ADV in two main parts the propulsion part electrical motor and propeller and the power part meaning the battery with its relevant support The two parts are contained in two containers which once assembled create the entire ADV making it watertight 70097 70099 70100 73 1 Part descriptions The propulsion unit A see figures 3 and 4 is connected to the battery support B by 4 self locking nuts Y easily removable with a 10 mm spanner In some models an adapter ring D is used and secured with 6 screws X to the propulsion A to compensate for the varying body diameters C and create a watertight connection between the propulsion unit A and body C
92. y charger instruction manual and restore the circuit The cut off device should only trigger in exceptional cases and this event should not occur during normal battery use since correct use does not include excessive depletion 67 1 Procedure to follow in the event the cut off device is triggered In the event the cut off system triggers IT IS IMPORTANT you proceed as follows 6 Disconnect the engine battery power connector 7 Remove the battery from the ADV 8 Let the battery rest for at least 2 hours This is the minimum time required in this case for the battery to cool and return to awaiting charge conditions 9 Connect the battery charge connector to the battery charger 10 Charge following the instructions in the battery charger manual IMPORTANT NOTE Also remember that the ADV inevitably stops running when the cut off device is triggered This event is not hazardous to the diver in any way since the dive was planned taking DANGER into account that ADV use is not considered a safety device or rescue means SUEX S r l is not liable after the cut off system triggers in any situation in hazardous situations or immersions where the driver at his full risk confided on surfacing by using our manufactured under water vehicle Please remember that the ADV must be considered as an immersion aid and not as a rescue vehicle 68 Pb gel battery frequently asked questions often use the ADV twice a week or every day but
93. y that the forward handle in fabric is secure and sound lts sudden rupture could lead to serious accidents Do not wet the inside of the ADV and the battery 57 Cleaning and overhaul After use the ADV must be rinsed thoroughly with fresh water A neutral detergent may be used for more stubborn dirt Before opening the ADV it is important to remove all traces of salt In particular the magnetic reed connected to the trigger must be cleaned thoroughly and all grit and sand particles removed Do not use any solvents or petroleum based products The ADV must be stored in a cool clean and ventilated place in an upright position with the nose facing upwards The battery must be removed charged and stored away from frosty conditions or excessive heat Make sure that the connectors do not come into contact with metal objects inside the ADV or the battery will be shorted The wheel for opening the head cap must be loosened such that the gasket is in view 57 70097 70099 70100 Important note always remove the battery after the use 58 Troubleshooting PROBLEM POSSIBLE CAUSE TREATMENT The ADV does not run When the trigger is activated the propeller does not turn Open the ADV check that the batteries are charged and that the connectors are inserted and undamaged then try again Although the battery pack has been charged and the connectors are inserted the ADV does not run The control system may be dama
94. zato fanno decadere le condizioni di garanzia vedi le speciali condizioni di garanzia della batteria 11Garanzia sulla batteria Le batterie in dotazione ai nostri ADV sono garantite a termine di legge ad esclusione di Difetti dovuti a danneggiamenti errato utilizzo incidenti manomissione negligenza o incuria e in caso di alterazioni o riparazioni effettuate da persone non autorizzate Difetti o danni risultanti da un utilizzo del prodotto in condizioni diverse da quelle abituali Difetti o danni derivanti da errati controlli operazioni manutenzione installazione adattamenti applicazioni non autorizzate o da qualsiasi altra alterazione o modifica di qualsiasi genere Rottura o danni a cavi o connessioni se non dovute direttamente a difetti di materiali o lavorazione Prodotti smontati o riparati da altri diversi da SUEX S r l in maniera tale da menomare la corretta funzionalit o impedire un adeguata verifica e collaudo al fine di soddisfare la richiesta di intervento in garanzia Difetti o danni dovuti ad umidit liquidi o corpi estranei immessi all interno del pacco batterie Cavi che siano allungati o abbiano l isolamento rovinato o mancante Graffi o danni ad ogni superficie di plastica e ad ogni altra parte esterna dell apparecchio dovuti al normale utilizzo del prodotto da parte del consumatore Prodotti affittati su base temporanea Manutenzione periodica e riparazione o sostituzione di parti dovute ad un normal

Download Pdf Manuals

image

Related Search

Related Contents

Samsung SDH-W10Z  Bosch GBM 6 RE  PM 211AA    DTHC-SETUP/INSTALL MANUAL CandCNC  Operación con seguridad  

Copyright © All rights reserved.
Failed to retrieve file