Home

TECHNICAL MANUAL MANUAL TÉCNICO

image

Contents

1. C 1 3 Ca 5 1 2 40 11 5 1 0 O 0 9 5 5 3 0 8 g 0 0 7 12345 67 8 9 1011 1 4 Cf 1 3 5 12 11 o 1 0 44 0 9 Se r E L E 0 8 07 El 12345 67 8 9 10111 Temperatura de evaporaci n Ca 1 3 1 2 11 8 1 0 E 0 9 0 8 1 2 3 4 5 6 7 8 9 101 SC 0 8 CA 12 11 10 09 L potenza frigorifera O 11 C The cooling capacity and input power correction factors make allowance for the presence of glycol and the different evaporation temperature The correction factors of the water flow rate and the pressure drops are applied directly to the data obtained for operation without glycols The correction factor of the water flow rate is calculated so as to maintain the same At that would be used in the absence of glycols The correction factor of the pressure drop already takes into account the different capacity deriving from the application of the water flow rate correction factor The correction factors of the water flow rate and the pressure drops are applied directly to the data obtained for operation without glycols The correction factors of the cooling and input capacities take into account the presence of glycols 8 ETHYLENE GLYCOL SOLUTION The correction factors of t
2. Qs 40 41 42 43 44 45 12 1 2 LOW NOISE VERSION 46 47 48 49 50 D al Ambient temperatur d b w al Ambient temperatur d b versioni sile rsioni standard Www A odo ve mm ou 1 5 EU ae k rt zm len Je des 45 d 05 40 41 42 43 44 45 46 47 48 49 50 Temperatura dell acqua prodotta al desurriscaldatore At 5 C 12 2 3 Values different from the nominal value Average water temperature C 5 7 9 11 13 15 Multiplicative coefficient 094 1 1 07 113 1 2 1 27 Evaporation Temperature C 1 3 5 7 9 11 Multiplicative coefficient 088 0 94 1 1 06 113 2 0325 0750 25 20 15 10 5 0 2 3 4 5 6 7 8 9 10 11 12 13 14 12 2 4 Values different from the nominal value Average water temperature C 30 40 50 Multiplicative coefficient 1 04 1 02 1 Versione
3. G O G c f vr G o e G Gx ra 2 d Q G o A D gt G 4 o o o la Gx l 191 DISTRIBUTION WEIGHTS PERCENTAGE ON RESTS WITHOUT WATER 00 NRA CENTER OF GRAVITY Gx e Gy WEIGHT 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 o Kg E 910 935 1010 1105 1205 1530 D Kg 7 920 947 1024 1123 1223 1548 T Kg 1005 1030 1115 1230 1330 1655 Gx mm 3 1150 1140 1120 1140 1060 1440 Gy mm 3 570 570 550 550 550 550 NRA A CENTER OF GRAVITY Gx e Gy WEIGHT A Kg 660 690 705 790 980 1005 1080 1165 1345 1530 AD Kg 667 698 714 800 990 1117 1094 1183 1363 1548 AT Kg 705 820 835 920 1115 1140 1215 1305 1485 1655 Gx mm 1 945 940 925 1050 1190 1180 1150 1160 1480 1440 Gy mm 1 550 550 550 550 560 560 550 550 550 550 NRA L CENTER OF GRAVITY Gx e Gy WEIGHT L Kg 625 655 670 750 990 1040 1140 1305 1355 1560 LD Kg 632 663 679 759 1000 1052 1154 1323 1373 1578 LT Kg 670 709 733 813 1085 1135 1245 1430 1480 1685 Gx mm 925 920 905 900 1180 1190 1180 1500 1470 1440 Gy mm 550 550 550 550 560 570 550 550 550 550 NRA H CENTER OF GRAVITY Gx e Gy WEIGHT Kg H Kg 1030 1090 1200 1370 1425 1638 Kg HD Kg 5 1040 1102 1214 1388 1443 1656 Gx mm i 1150 1160 1160
4. Height mm 1606 1606 1606 1606 1875 1875 1875 1875 1875 1875 Width mm 1100 1100 1100 1100 1100 1100 1100 1100 1100 1100 Length mm 2450 2450 2450 2950 2950 2950 2950 3950 3950 4275 EMPTY WEIGHT versions without accumulation and pumps kg 598 623 638 719 950 965 1040 1120 1295 1500 15 16 The devices in their standard configurations are not suitable for installation in salty environments The maximum and minimum limits for the water flow rate to the exchanger are indicated by the curves of the pressure drop diagrams For the operating limits referto the diagrams 61 OPERATING LIMITS Cold mode 6 SELECTION CRITERIA below valid for At 5 C WARNING operation with a processed water temperature of less than 4 C is only allowed for the versions specifically designed for this version YA if you want to operate the machine outside the limits indicated in VERS versioni Y Outside air temp d b C ON the diagram please contact the AERMEC technical commercial office if the machine is positioned in particularly windy areas it 19 necessary to install windbreak barriers to avoid the inconstant operation of the DCPX device estandard 35 42 C high temperature 40 46 C e silenced L 40 46 C heat pump H 40 46 C Operation with glycol water only for versions
5. 1 fr o Temp agua m x 40 C Temp m n agua 4 C 2 Calor bomba de calor Temp agua m x 60 C Temp m n agua 4 C 3 Calor caldera Temp agua m x 85 C Temp m n agua 4 C Altura hidr ulica Hm 30 25 20 15 2 12 25 Calibrado del vaso de expansi n bar 3 2 2 8 2 3 1 8 1 5 Valor de referencia contenido agua 00 2174 2646 3118 3590 3852 Valor de referencia contenido agua 1 2 978 190 1404 11616 1732 Valor de referencia contenido agua 1 3 510 622 732 844 904 Agua glicolada Temp agua C Coeficiente Condici n de de correcci n referencia max min 10 40 2 0 507 1 10 60 2 0 686 2 10 85 2 0 809 3 20 40 6 0 434 1 20 60 6 0 604 2 20 85 6 0 729 3 35 40 6 0 393 1 35 60 6 0 555 2 35 85 6 0 677 3 Condiciones operativas de referencia y H max 1 55 m Ptar H 10 2 0 3 x H 12 25 m Ptar 1 5 bar I H o 3 Ptar 1 5 bar H min 2 NOTA 1 Comprue A be que el utilizador m s alto no supere los 55 metros de desnivel 2 Comprue be que el utilizador m s bajo pueda soportar la presi n global que act a en ese punto Si el valor del ajuste obtenido por el c lculo resultase inferior a 1 5 bar es decir para H lt 12 25 mantener el ajuste est ndar Para las versiones 01 02 03 04 P1 P2 P3 P4 Las prevalen
6. FCGDprF e 1 390 1 310 1 280 1180 H FcGQF 1 1110 FcGQ dC FcG TL dC 1 090 1 000 0 990 0 975 FcG a ia 9 P RDIDAS DE CARGA 9 1 P RDIDAS DE CARGA kP EVAPORADOR a mo Wi ee d 100 Los gr ficos siguientes ilustran los valores de las p rdidas de carga 90 0600 Ri 0700 en kPa en funci n del caudal en 0550 H0650 h El campo de funcionamiento est 80 delimitado por el valor m nimo y gt m ximo de las curvas que indican los l mites de uso de los intercambiadores 60 lado agua evaporadores 50 Las p rdidas de carga de los ap diagramas se refieren a una temperatura media del agua de 10 30 C La siguiente tabla presenta la correcci n que se debe aplicar a 20 las p rdidas de carga a medida que iG cambia la temperatura media del agua 0 o 5 10 15 20 25 30 35 40 50 55 mh Caudal agua m3 h Temperatura media agua C 5 10 15 20 30 40 50 Coeficiente multiplicativo 1 02 1 0 985 0 97 095 0 93 0 91 9 2 P RDIDAS DE CARGA 180 CONDENSADOR kPa 400 Las p rdidas de carga del diagrama precedente s
7. DECLARACI N DE CONFORMIDAD Los que suscriben la presente declaran bajo la propia y exclusiva responsabilidad que el conjunto en objeto definido como sigue Identificaci n del producto ENFRIADORA AIRE AGUA BOMBAS DE CALOR SERIE NRA es conforme a 1 Conforme a la Directiva 97 23 CE y ha sido sometido de acuerdo con el anexo Il de la misma directiva al siguiente procedimiento de valoraci n de conformidad modulo H Con controles efectuados mediante inspecciones del notificado organismo CEC via Pisacane 46 Legnano MI Italy distintivo n mero 1131 2 Proyectado producido y comercializado respetando las siguientes especificaciones t cnicas Normas armonizadas EN 378 Enfriador y bombas de calor requisitos ambientales y de seguridad EN 12735 Copper and copper alloys Seamless round copper tubes for air conditioning and refrigeration UNI 1285 68 C lculo de resistencia de los tubos met licos sometidos a presi n interna 3 Proyectado producido y comercializado de acuerdo con las siguientes directivas comunitarias 98 37 CE Directiva m quinas 2006 95 CE LVD Bevilacqua 26 03 2007 Director Comercial Firma qa 41 42 Este manual y los esquemas el ctricos proporcionados junto con la unidad deben conservarse en un lugar seco para posibles consultas futuras y durante toda la duraci n de la m quina El presente manual de instruccione
8. Ca 1 3 1 2 1 1 0 9 0 8 0 7 0 6 Cf 20 25 30 35 40 Temperatura externa potenza frigorifera 57 72 POTENCIA DE REFRIGERACI N Y ABSORBIDA VERSIONES SILENCIADAS La potencia de refrigeraci n creada y la potencia absorbida en condiciones distintas de las nominales se obtienen multiplicando los valores nominales Pf Pa por los respectivos coeficientes correctivos Cf Ca Los siguientes diagramas permiten obtener los coeficientes correctivos a utilizar para los aparatos en los varios modelos durante el funcionamiento en fr o con cada curva se encuentra correspondientemente indicada la temperatura del aire externo a la cual se refiere LEYENDA Cf Coeficiente correctivo de la potencia de refrigeraci n Ca Coeficiente correctivo de la potencia absorbida NOTA PARA LAS VERSIONES Y con temperaturas inferiores a los 4 C p ngase en contacto con la sede 45 XAAAeAQ QA n RT 40 3 3 2 20 g ite 5 g bd g S v A O PA E et DE DL A 4 6 7 8 9 10 11 12 13 14 15 40 t 35 I 30 I 20 25 20 i 30 15 35 1 40 Cp 1 a A A eee t 0 95
9. Italien Via Roma 44 Tel 39 0442 633111 Telefax 39 0442 93730 39 0442 93566 www aermec com AERMEC COMPANY QUALITY SYSTEM carta riciclata recycled paper papier recycl recycled apier The technical data stated in the following documentation are not binding Aermec reserves the right to carry out modifications considered necessary for improving the product at any time Los datos t cnicos indicados en la siguiente documentaci n no son vinculantes Aermec se reserva la facultad de aportar en cualquier momento todas las modificaciones que considere necesarias para mejorar el producto
10. 0325 0350 0500 0550 0600 0650 0700 0750 8 6A 6A 6A 6A 6A 9A A 4A 6A 6A 8A 6A 6A BA 6A SA SA L 4A 6A 6A 6A 6A 6A 6A 9A 9A 9A H GA GA 8A 8A 6A 6A 6A 9A SA 9A HL 6A 8A 8A 8A 6A 6A 6A 9A 9A 9A 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 25 25 30 35 25 26 25 30 35 35 25 30 30 35 25 30 30 30 35 35 MTC A 35 35 25 30 35 35 30 30 35 35 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 PA a freddo 28 28 28 28 28 28 28 28 28 28 PA a caldo 28 28 28 28 28 28 28 28 28 28 PB 2 2 2 2 2 2 2 2 2 TRB 1 1 1 1 1 1 1 1 1 immediately and identify the cause Reset is manual and only enabled once the pressure drops below the differential value For the set and differential values see the technical manual 17 3 2 Low pressure switch The low pressure switch stops the compressor generating the relative alarm when the suction pressure drops below the set value The control of its correct working can be made after about 5 minutes of operation by slowly closing the tap on the liquid pipe and keeping the low pressure gauge under control checking it intervenes upon reaching the calibrated value WARNING lf the switch does not trip at the calibrated value stop the compressor immediately and identify the cause Reset is manual and only enabled once the pressure rises above the differential value For the set and differential values see the technical manual 171 3 A
11. DAA Los modelos 500 al 750 y los Transductor de alta presi n BOMBA DE CALOR 1 term stato control de temperatura gas de descarga TP1 Transductor de baja presi n TP2 Transductor de alta presi n DCPX Dispositivos de reguci n de la velocidad de los ventilatores pera los modelos dal 500 al 750 HL ENFRIADORES CON ACUMULACI N 1 Resistencia el ctrica anticongelante evapo rador 2 El grupo de bombeo de los refrigeradores con acumulaci n puede ser de alta o baja presi n de descarga 3 como opci n prev una bomba de reserva est dirigida por la tarjeta electr nica que hace girar peri dicamente las bombas presentes de manera que se optimicen las horas de funciona miento 4 Para los modelos con bomba de calor se encuentra a disposici n a pedido una acumu laci n predispuesta para la introducci n de resistencias el ctricas integra tivas CHILLER con recuperaci n parcial D 1 Filtro de agua 2 Fluj stato 3 DCPX 43 44 z 2 3 CONFIGURATORE 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 NRA 0750 campo 8 campo 4 5 6 7 o o L o o o 00 campo 15 16 RADANG 00 Sin Acumulaci n 01 Acumulador y bomba baja prevalencia 02 Acumulador bomba baja prevalencia bomba de reserva 03 Acumulad
12. La prima il clima perille TECHNICAL MANUAL MANUAL T CNICO Air water chillers and heat pumps and condensing units with scroll L compressors Enfriadoras y bombas de calor aire agua y motocondensadores con compresores scroll nra Ria NOT EUROVENT CERTIFIED PERFORMANCE l AERMEC COMPANY QUALITY SYSTEM ISO 9001 2000 n 0128 4 ENEE INRATI 0706 6872009_02 Sostituisce il INRATV 68720 09_01 del 0307 filter AERMEC S P A Gompliance declarationi a ina AAN 1 General Standards sii NR pag 2 Peseription and choice Of Unit ye pag 21 Models available 2 2 VETO Valla a att 221 St nd rd A ee de eine aed ane al ei pag 2 3 Belle TN pag 3 Description A A pag 3 1 Refrigerating Ci dit pag 3 2 Frame A BCE pag 3 3 Hydr ulic ComporientS AAA AA pag 3 4 Safety and control COMPONENtS iii SACO AAA pag 3 5 El ctrical components assorrir nnie i E E E ARR ER AEAT eve ces i ae et pag 4 Accessories and table of possible COMbiNAtiONS mcmicinicninnnnnnn cc pag 5 Technical data 5 2 Reegele PRECARIA ee atei den PIRLA RIT IRREALE A pag 5 3 High efficiency versions pag DA Silenced Me E pag 5 5 Ss eas a ae eee eee De pag 5 6 silenced heat pump Versions 1000 pag 5 7 CAN o ce de pag 5 8 steen pag 6 Selection criteria 61 A A AO pag 6 2 PROL AAA A EEN pag 7 Gorrection coetficients ira i AR LE I N A i pag 8 Ethyleme glyCol SOU A OE p
13. 0 9 l 45 0 85 0 8 0 75 0 7 K f TTT TT 7 Temperatura del agua producida At 5 C Ca 1 20 1 15 1 1 1 05 0 95 0 9 0 85 0 8 Cf potenza frigorifera POTENCIA T RMICA Y ABSORBIDA 73 VERSIONES BOMBA DE CALOR La potencia t rmica producida y la potencia el ctrica absorbida en condiciones diversas de las nominales se obtienen multiplicando los valores nominales Pf Pa que aparecen al pie de la p gina por los respectivos coeficientes correctivos Cf Ca El siguiente diagrama permite obtener los coeficientes correctivos en relaci n con cada curva se indica la temperatura del agua caliente producida a la que se hace referencia asumiendo una diferencia de temperatura del agua entre entrada y salida del condensador igual a 5 C Los rendimientos son en neto de los ciclos de descongelaci n LEYENDA Ct Coeficiente correctivo de la potencia t rmica Ca Coeficiente correctivo de la potencia absorbida 7 4 PARA AT DIFERENTES DEL NOMINAL Para At diferentes de 5 C en el evaporador use la Tab1 para obtener los factores correctivos de la potencia de refrigeraci n y absorbida Para controlar el ensuciamiento de los intercambiadores se utilizan los correspondientes factores de ensuciamiento 7 5 FACTORES DE INCRUSTACI N Las prestaciones indicadas en la tabla se refieren a las condiciones de tubos
14. 1045 1035 1020 1115 1300 1290 1260 1270 1410 1510 Gy mm 550 550 550 550 560 560 550 550 550 550 NRALGENTEROFGRAVITY GxeGy WEIGHT L Kg 775 805 820 900 1150 1200 1320 1485 1535 1740 LD Kg 782 813 829 909 1160 1212 1334 1503 1553 1758 LT Kg 820 859 883 963 1245 1295 1425 1610 1660 1865 Gx mm 1030 1020 1010 995 1290 1290 1280 1430 1400 1510 Gy mm 550 550 550 550 560 580 550 550 550 550 NRA H CENTER OF GRAVITY GxeGy WEIGHT e Kg H Kg gt E E 1190 1250 1380 1550 1605 1818 Kg HD Kg e E 1200 1410 1394 1568 1623 1836 Gx mm 1270 1280 1270 1540 1510 1510 Gy mm e e 540 520 550 550 550 550 NRA HL CENTER OF GRAVITY GxeGy WEIGHT o OSO Kg HL Kg 875 900 920 1110 1200 1260 1390 1560 1615 1818 KgHLD Kg 882 903 929 1019 1209 1270 1402 1574 1633 1836 Gx mm 1150 1140 1125 1120 1270 1280 1270 1540 1510 1510 Gy mm 550 550 550 550 540 520 550 550 550 550 NOTA Le altre versioni con accumulo pre sentano variazioni di peso trascurabili rispetto al modello di riferimento 01 37 20 PERCENTAGE DISTRIBUTION OF WEIGHT ON 38 SUPPORT A E E E Mod 1 version A mm B mm QI 275 L A C 2450 205
15. 2212 Total input power kW 18 2 18 8 21 8 25 8 375 40 4 49 54 6 64 5 672 Water flow rate m3 h 11 39 13 04 1493 1717 21 59 2363 28 21 32 44 36 89 38 05 Pressure drop kPa 17 15 19 19 15 19 18 15 20 18 14 LIGNEE FRIGORIFIQUE Long l nea l qui Z Mod L nea del gas L nea del l quido Gas por metro de l nea l quido 0 C1 c2 C1 Ce C1 c2 0 10 35 35 15 88 15 88 175 175 0275C 10 20 35 35 15 88 5 88 175 175 20 30 35 35 15 88 15 88 175 175 0 10 35 39 18 18 220 220 0300 C 10 20 35 35 18 8 220 220 20 30 35 42 18 18 220 220 0 10 35 33 18 18 220 220 0325 C 10 20 35 35 18 8 220 220 20 30 42 42 18 18 220 220 0 10 35 35 18 18 220 220 0350 C 10 20 35 35 18 8 220 220 20 30 42 42 18 18 220 220 0 10 42 35 22 18 350 220 0500 C 10 20 42 35 22 8 360 220 20 30 42 42 22 18 360 220 0 10 42 35 22 18 360 220 0550 C 10 20 42 35 22 8 360 220 20 30 42 42 22 8 360 220 0 10 42 42 22 22 360 360 0600 C 10 20 42 42 22 22 360 360 20 30 42 42 22 22 360 360 0 10 42 42 22 22 360 360 0650C 10 20 42 42 28 28 590 590 20 30 42 42 28 28 590 590 0 10 42 42 28 28 590 590 0700 C 10 20 42 42 28 28 590 590 20 30 54 54 28 28 590 590 0 10 42 42 28 28 590 590 0750 C 10 20 42 42 28 28 590 590 20 30 54 54 28 28 590 590 Legenda C1 Circuito frigor fi
16. 38 63 4 e 0550 e x2 Std 550 2 x2 38 63 4 0600 x2 Std 600 e 2 x2 38 64 4 0650 lt e x2 Std 650 2 x2 38 64 4 0700 x2 Std 650 2 x3 38 64 4 0750 e x2 Std 750 2 x3 38 64 4 2 NRA LC 0275 s x2 s x2 275 e e 3 16 62 12 E 0300 lt e x2 e x2 300 3 16 62 12 0325 x2 x2 325 3 16 62 12 E 0350 e x2 e x2 325 3 16 x2 82 12 0500 e x2 Std 500 N 2 x2 di serie 63 4 0550 e x2 Std 550 2 x2 di serie 63 4 0600 x2 Std 600 N 2 x2 di serie 64 4 0650 e x2 Std 650 2 x3 di serie 64 4 0700 e x2 Std 650 N 2 x3 di serie 64 4 0750 e x2 Std 750 2 x3 di serie 64 4 1 It must be factory mounted the combination of accessories S a Without storage tank The braces indicate that installation of 51 NOMINAL REFERENCE CONDITIONS The technical data is calculated as follows Cooling mode Temperature water inlet 12 C Temperature of processed water 7 C Ambient air temperature 35 C At 9 Heating mode Temperature of processed water 50 C Ambient air temperature b s 7 C bu 6 C At 5C Sound Power Aermec determines the value of sound power on the basis of measurements performed in compliance with regulation 9614 in respect with that requested by Eurovent certification 1 Sound Pressure Sound pressure in free field on a reflective sur face
17. Kg 1040 1102 1214 1388 1443 1656 Gx mm 1150 1160 1160 1470 1440 1440 Gy mm 540 520 550 550 550 550 A 31 29 31 25 26 26 B E 32 33 31 25 26 26 C 18 18 19 25 24 24 D E E 19 20 19 25 24 24 E e x a Z S E hi F e 3 5 z e S VT 4 4 4 4 4 4 NRA HL CENTER OF GRAVITY Gx e Gy PERCENTAGE DISTRIBUTION OF WEIGHT ON SUPPORT 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 HL Kg 725 750 770 860 1040 1100 1210 1380 1435 1638 HLD Kg 732 758 779 869 1049 1110 1222 1394 1453 1656 Gx mm 1080 1075 1060 1055 1150 1160 1160 1470 1440 1440 Gy mm 550 550 550 550 540 520 550 550 550 550 A 33 33 33 33 31 29 31 25 26 26 B 33 33 33 33 32 33 31 25 26 26 C 17 17 17 17 18 18 19 25 24 24 D 17 17 17 17 19 20 19 25 24 24 E E F E o E e E E E VT 12 12 12 12 4 4 4 4 4 4 Version with hydronic kit and with water 04 NRA CENTER OF GRAVITY Gx e Gy PERCENTAGE DISTRIBUTION OF WEIGHT ON SUPPORT 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 d Kg 910 935 1010 1105 1205 1530 D Kg E E E 920 947 1024 1123 1223 1548 CT Kg 1005 1030 1115 1230 1330 1655 Gx mm 1150 1140 1120 1140 1060 1440 Gy mm 570 570 550 550 550 550 A E 33 33 32 32 33 11 B 30 30 32 32 33 11 E 5 19 19 18 18 17 8 D x 18 19 18 18 17 8 E E 5 2 b E 31 F 31 VT 10 10 10 10 10 11 NRA A CENTER OF GRAVITY Gx e Gy
18. PERCENTAGE DISTRIBUTION OF WEIGHT ON SUPPORT A Kg 1310 1340 1355 1440 1640 1665 1760 1845 2025 2210 AD Kg 1317 1348 1364 1450 1650 1777 1774 1863 2043 2228 AT Kg 1355 1475 1485 2210 1775 1800 1895 1985 2165 2345 Gx mm 1225 215 1205 1300 1540 1540 1500 1490 1670 1440 Gy mm 550 550 550 550 550 560 550 550 550 550 A 25 25 25 28 24 24 25 25 11 11 B 25 25 25 28 23 23 25 25 11 11 E 25 25 25 22 27 27 25 25 9 8 D 25 25 25 22 26 26 25 25 9 8 E E E E E E E 30 31 F 30 31 VT 13 13 13 13 10 10 10 10 11 11 39 NRA L CENTER OF GRAVITY Gx e Gy PERCENTAGE DISTRIBUTION OF WEIGHT ON SUPPORT 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 L Kg 1275 1305 1320 1400 1650 1700 1820 1985 2035 2240 LD Kg 1282 1313 1329 1409 1660 1712 1834 2003 2053 2258 LT Kg 1320 1359 1383 1463 1745 1795 1925 2110 2160 2365 Gx mm 1220 1215 1200 1185 1530 1530 1510 1600 1670 1640 Gy mm 550 550 550 550 560 570 550 550 550 550 A 25 25 26 26 24 25 24 10 10 11 B 25 25 26 26 24 23 24 10 10 11 C 25 25 24 24 26 27 26 E El 8 D 25 25 24 24 26 25 26 9 9 8 E 31 31 31 F 31 31 31 VT 13 13 13 13 10 10 10 11 11 11 NRA H CENTER OF GRAVITY Gx e Gy PERCENTAGE DISTRIBUTION OF WEIGHT ON SUPPORT 0
19. Pr que aparecen al pie de la p gina para los respectivos coeficientes correctivos Ca Cr que se pueden deducir de los siguientes diagramas En coincidencia con cada curva aparece la temperatu ra del agua caliente producida a la cual se refiere asumiendo una diferencia de 5 C entre entrada y salida del recu perador total La potencia frigor fica Pf se obtiene de la diferencia entre potencia t rmica de recuperaci n Pr y potencia absorbida Pa La capacidad de calentamiento dispo nible para la recuperaci n total hace referencia a las condiciones nomina les Temperatura del aire 35 C Agua producida 50 C At 5 C 13 RECUPERACION TOTAL d ol o a oy E L a O W O 1 2 1 1 1 0 9 1 1 1 0 9 0 8 0 7 5 6 7 8 9 10 11 12 13 14 15 C Temperatura del agua refrigerada producida At 5 C Leyenda Cr Coeficiente correctivo de la potencia recuperada Ca Coeficiente correctivo de la potencia el ctrica absorbida 67 68 1311 P RDIDAS DE CARGA Los modelos NRA con recuperaci n total tienen siempre dos recuperado res situados en paralelo Las caracte r sticas de los recuperadores y las curvas de las p rdidas de carga est n indicadas a continuaci n no se consi deran las p rdidas del filtro Para los valores de temperatura del agua producida a una graduaci n distinta de 50 C hay que
20. kg 660 690 705 790 980 1005 1080 1165 1345 1530 gl A TECHNICAL DATA SILENCED VERSIONS L Cooling capacity kW 48 57 65 74 88 SA 115 134 150 161 Total input power kw 21 24 27 31 38 41 50 56 66 71 5 Evaporator water flow rate Vh 8260 9800 11180 12730 15140 16680 19780 23050 2580 27690 Evaporator pressure drop kPa 33 30 30 41 27 22 5 31 5 31 35 5 36 ENERGY INDICES EER W W 2 34 2 38 2 41 2 39 2 30 2 35 2 30 2 40 2 27 2 25 ESEER W W 2 83 2 87 2 90 2 88 2 67 2 75 3 06 3 20 3 05 ELECTRICAL DATA Fuel feed A 3N 400 V 50Hz Total input power A 40 46 50 57 5 66 5 71 9 88 4 99 7 112 3 124 2 Maximum current A 65 68 71 Z 98 104 133 145 148 160 Peak current A 155 161 166 209 215 222 239 250 260 314 COMPRESSOR HEATER Compressor carter heater 2x75 2x75 2x75 2x75 3x75 3x75 4x75 4x75 Type scroll scroll scroll scroll scroll scroll scroll scroll scroll scroll Number ne 2 2 2 2 3 3 4 4 4 4 Number per circuit n n 2 2 2 2 2 2 2 2 3 2 3 2 4 2 4 2 4 2 4 2 4x75 2x75 2 x 130 Type assiale assiale assiale assiale assiale assiale assiale assiale assiale assiale Number n 4 6 6 6 2 2 2 2 3 3 Input current ventilation unit A 3 2 4 8 4 8 4 8 1 2 1 2 1 8 2e 2 4 Input power ventilation unit kW 2 32 5 22 5 22 5 22 0 8 0 8 1 1 2 1 5 Air flow
21. limpios con factor de incrustaci n 1 Para valores diferentes del factor de incrustaci n multiplique los datos de las tablas de prestaciones por los coeficientes indicados Ca 1 1 1 50 0 9 45 g 40 0 8 3 0 7 z T TA ATT 0 6 Ct 10 8 6 4 2 0 2 6 8 10 12 14 16 4 S 35 9 3 40 a 45 Z oa 2 50 D A 42 oO oa 0 9 E E 08 0 7 06 g S E Dd a 10 8 6 4 2 0 2 6 8 10 12 14 16 Temperatura del aire externo b s con 87 de 7441 Factores correctivos para At diferentes del nominal Chiller 3 5 8 10 Factores de correcci n potencia de refrigeraci n 0 99 1 1 02 1 03 Factores de correcci n potencia absorbida 0 99 1 1 01 1 02 751 Factores de incrustaci n K m2 W 0 00005 0 0001 0 0002 Factor de cor potencia de refrigeraci n 1 0 98 0 94 Factores de correcci n potencia absorbida 1 0 98 0 95 59 60 7 6 POTENCIA FRIGORIFICA Y POTENCIA ABSORBIDA UNIDAD CONDENSADORA 275 350 La potencia frigor fica producida y la potencia el ctrica absorbida en con diciones diversas de aquellas de refe rencia se obtienen multiplicando los
22. of the cooling capacity and input power for the flow rates and the pressure drops remember that these coefficients must anyway be multiplied by the nominal value of the sizes examined the lower axis advises the percentage of glycol necessary on the basis of the outside air temperature considered If you want to calculate the percentage of glycol on the basis of the temperature of the processed water you must enter from the right hand axis and once you have intersected the curve trace a vertical line which in turn will intercept all the other curves the points obtained from the upper curves represent the coefficients for the cooling capacity and input power for the flow rates and the pressure drops remember that these coefficients must anyway be multiplied by the nominal value of the sizes examined the lower axis advises the percentage of glycol necessary to produce water at the required temperature Remember that the initial sizes OUTSIDE AIR TEMPERATURE and PROCESSED WATER TEMPERATURE are not directly linked to each other so it is not possible to enter the curve of one of these sizes and obtain the corresponding point on the other curve FCGDprF a FCGDpr b FCGDprF c FoGDpF d FCGDprF e 1 390 1 310 1 280 FcGQF 1180 H 1 1110 FcGQ dC FcG TL dC 1
23. outside air temperature 7 C B S 6 C B U CHECK PARAMETERS NOTE 1 version Y 174 THERMOMAGNETIC SWITCHES FANS 172 THERMOMAGNETIC SWITCHES COMPRESSORS 173 TRANSDUCERS PRESSURE SWITCHES KEY PA High pressure switch PB Low pressure switch TRB Low pressure transducer All units are thoroughly tested in the factory before shipping Nonetheless it is always good practice to check all control and safety systems after a reasonable period of operation All the control operations must be carried out by qualified personnel the wrong settings on the above devices can cause serious damage to the unit 17 31 High pressure switch The high pressure switch stops the compressor generating the relative alarm when the delivery pressure exceeds the set value The control of its correct working can be made by closing the air suction on the exchanger in cold mode and keeping the high pressure gauge under control checking it intervenes upon reaching the calibrated value WARNING lf the switch does not trip at the calibrated value stop the compressor 17 CALIBRATION OF CHECK AND SAFETY PARAMETERS min standard max Set point raffreddamento C 4 61 7 61 14 Set point riscaldamento C 35 48 50 Intervento antigelo C 9 3 4 Differenziale totale 4G 3 10 Autostart auto 0275 0300
24. s detallada haga referencia al manual de uso Tablero mandos a distancia Permite efectuar a distancia las operacio nes de mando del refrigerador magnetot rmico protecci n compre sores magnetot rmico protecci n ventilado res magnetot rmico protecci n auxiliar Termostato control temperatura gas de descarga 3 6 REGULACI N ELECTR NICA tarjeta de microprocesador Compuesta de tarjeta de gesti n y control y de tarjeta de visualizaci n Funciones que 4 ACCESORIOS lleva a cabo e regulaci n temperatura agua entra da evaporador o tambi n en salida seleccionable con termostataci n de hasta 12 niveles y control proporcio nal integral sobre la velocidad de los ventiladores retraso de puesta en marcha com presores e funcionamiento como refrigerador con posibilidad de integraci n de la capacidad de refrigeraci n mediante free cooling e rotaci n secuencia compresores control dispositivo de baja temperatu ra accesorio e C lculo horas de funcionamiento com presores start stop reset memoria permanente de las alarmas autostart despu s de una ca da de la tensi n mensajer a multiling e e funcionamiento con control local o remoto visualizaci n estado de la m quina ON OFF compresores resumen alarmas control alarmas alta presi n flujostato baja presi n anticongelante sobrecarga compre sores sobrecarga ventiladores sobre
25. valores nominales Pf Pa que apare cen al pie de la p gina para los respec tivos coeficientes correctivos Cf Ca El siguiente diagrama permite obte ner los coeficientes correctivos por utilizar para los motocondensadores C en coincidencia con cada curva se encuentra indicada la temperatura del aire externo al cual se refiere LEYENDA Cf Coeficiente correctivo de la potencia frigor fica Ca Coeficiente correctivo de la potencia el ctrica absorbida 7 7 POTENCIA FRIGORIFICA Y POTENCIA ABSORBIDA UNIDAD CONDENSADORA CON SILENCIADOR 500 750 La potencia frigor fica producida y la potencia el ctrica absorbida en con diciones diversas de aquellas de refe rencia se obtienen multiplicando los valores nominales Pf Pa que apare cen al pie de la p gina para los respec tivos coeficientes correctivos Cf Ca El siguiente diagrama permite obte ner los coeficientes correctivos por utilizar para los motocondensadores C en coincidencia con cada curva se encuentra indicada la temperatura del aire externo al cual se refiere LEYENDA Cf Coeficiente correctivo de la potencia frigor fica Coeficiente correctivo de la potencia el ctrica absorbida C 1 3 Ca 5 1 2 40 1
26. wpa 63 10 Acumulador iii ag 64 11 Prevalencias tiles en la instalaci n EEN p g 65 A AAA NA p g 66 13 Recuperaci n de talor totalen e aA Ol RARE RARA p g 67 k L SE Ze CN ele Tute TEE p g 69 15 Datos SOnOrOS AA dede p g 70 A A RO p g 72 17 Calibrado par metros de control y seguridad ENEE p g 73 O ale p g 74 19 PEI DC A A RO RR RA p g 75 20 Distribuci n pesos porcentaje sobre los apoyos para los modelos CON AGUA inician p g 77 Estimado cliente Le agradecemos su elecci n por un producto AERMEC Este producto es el resultado de varios a os de experiencia y de estudios de proyectaci n minuciosos y ha sido construido con materiales de primera calidad y tecnolog a de vanguardia Adem s la marca CE garantiza que los aparatos cumplan los requisitos de la Directiva Europea M quinas por lo que se refiere a la seguridad Nuestro nivel de calidad est sometido a una vigilancia constante por lo que los productos AERMEC son sin nimo de Seguridad Calidad y Fiabilidad Los datos pueden experimentar modificaciones que se consideren necesarias en cualquier momento y sin la obligaci n de aviso previo para la mejora del producto Gracias de nuevo AERMEC S p A AERMEC S p A 137040 Bevilacqua VR Italia Via Roma 44 Tel 39 0442 633111 per il clima Telefax 0442 93730 39 0442 93566 NRA www aermec com info aermec com NRA H MODELO N MERO DE SERIE
27. 0 Presi n sonora 1 dB A 44 0 45 0 45 0 45 0 44 0 44 5 45 5 46 5 48 0 49 0 DIMENSIONES para todos los equipamientos Altura mm 1606 1606 1606 1606 1875 1875 1875 1875 1875 1875 Longitud mm 1100 1100 1100 1100 1100 1100 1100 1100 1100 1100 Longitud mm 2950 2950 2950 2950 2950 2950 2950 3950 3950 4275 PESO en vac o versiones sin acumulador ni bombas kg 725 750 770 860 1040 1100 1210 1380 1435 1638 53 54 ol 7 DATOS T CNICOS VERSION C Potencia de refrigeraci n kw 105 112 133 148 178 190 Potencia absorbida total kW 33 36 44 50 5 56 65 INDICES ENERG TICOS EER W W 2 7 2 7 2 7 257 27 2 9 ESEER W W DATOS ELECTRICOS Alimentaci n A 3N 400 V 50Hz Corriente absorbida total S F A 60 2 66 6 82 2 94 2 103 9 116 Corriente m xima A 98 104 133 145 145 160 Corriente de arranque A 215 222 239 250 257 314 Tipo Scroll Scroll Scroll Scroll Scroll Scroll N mero n 3 3 4 4 4 4 N mero por circuito An E 3 2 3 2 4 2 4 2 4 2 4 2 Resistencia c rter compresores n W 3x75 3x75 4x75 4x75 4x75 2x795 2 x 130 VENTILADORES Tipo Axial Axial Axial Axial Axial Axial N mero n 2 2 2 3 3 3 Corriente absorbida gr ventilaci n A 5 B 5 5 75 Potencia absorbida gr ventilaci n kW 2 8 2 8 2 8 2 8 4 2 Caudal aire m3 h 39200 38500 38700 38700 60900 _ 56000 Potencia sonora dB A 82
28. 0 0001 0 0002 Cooling capacity correction factors 1 0 98 0 94 Imput power correction factors 1 0 98 0 95 19 20 7 6 COOLING AND INPUT CAPACITIES CONDENSING UNIT SIZE 275 350 The cooling capacity and the electri cal input power in conditions other than the reference conditions can be determined by multiplying the nominal values Pf Pa shown at the bottom of the page by the respective corrective coefficients Cf Ca The diagram below enables you to determine the corrective coefficients to use for the condensing units C for each curve the diagram shows the external air temperature to which it refers KEY Cf Cooling capacity correction coefficient Ca Input power correction coefficient 7 7 COOLING AND INPUT CAPACITIES CONDENSING UNIT LOW NOISE SIZE 500 750 The cooling capacity and the electri cal input power in conditions other than the reference conditions can be determined by multiplying the nominal values Pf Pa shown at the bottom of the page by the respective corrective coefficients Cf Ca The diagram below enables you to determine the corrective coefficients to use for the condensing units C for each curve the diagram shows the external air temperature to which it refers KEY Cf Cooling capacity correction coefficient Ca Input power correction coefficient
29. 0 741 712 _ 661 59 2 _ 49 5 0300 760 44 0 65 0 777 749 741 71 7 66 6 59 7 50 0 0325 77 0 45 0 660 798 780 _ 75 8 714 666 600 508 0350 77 0 45 0 660 793 773 755 720 670 598 496 0500 740 142 0 61 0 772 723 701 690 668 623 53 8 0550 745 425 620 789 731 70 7 694 671 62 6 _ 54 0 0600 750 430 620 807 736 713 697 674 626 1540 0650 760 440 62 0 811 73 7 729 713 682 620 5413 0700 77 0 45 0 630 820 765 746 723 168 3 621 53 8 0750 79 47 0 65 0 82 765 773 743 666 69 7 61 Niveles sonoros totales Banda de octava Hz Pot Pressione 125 250 500 1000 2000 4000 8000 asa dBA dB Potencia sonora para frecuencia central de banda dB 10m 1m 0275 0300 0325 0350 0500 825 505 700 184 2 78 6 775 772 76 3 732 164 3 0550 825 505 70 0 841 784 779 776 765 712 623 0600 83 0 510 700 856 788 784 780 770 721 63 0 0650 840 52 0 710 867 807 795 785 778 739 63 5 0700 840 520 700 838 799 797 795 774 729 64 7 0750 840 52 0 71 0 838 799 807 80 77 2 74 3 66 Niveles sonoros totales Banda de octava Hz Pot Pressione _ 125 250 500 1000 2000 4000 8000 CL dB A SB A dB p x otencia sonora para frecuencia central de banda dB 10m 1m 0275 760 440 65 0 772 77 0 741 712 661 59 2 _ 49 5 0300 76 0 44 0 650 1776 749 745 171 5 66 59 7 49 7 0325 770 450
30. 0600 e x2 di serie 600 N 2 x2 di serie 64 4 10 0650 N e x2 di serie 650 e N 2 x3 di serie 64 4 1 0700 e x2 di serie 650 2 x3 di serie 64 4 11 0750 e e x2 di serie 750 N 2 x3 di serie 64 4 1 NRA HL 0275 di serie di serie 275 N 4 di serie 62 12 13 0300 e di serie di serie 300 N 4 di serie 62 12 3 0325 di serie di serie 325 4 di serie 62 12 13 0350 e di serie di serie 325 e e 4 di serie 82 12 3 0500 di serie di serie 500 N 2 x2 di serie 63 4 10 0550 e di serie di serie 550 N e 2 x2 di serie 63 4 U 0600 e di serie di serie 600 N 2 x2 di serie 64 4 10 0650 N di serie di serie 650 N 2 x3 di serie 64 4 1 0700 di serie di serie 650 N 2 x3 di serie 64 4 11 0750 e di serie di serie 750 e e 2 x3 di serie 64 4 1 47 48 MOD ROMEO _ TP1 TP2 DRE AER485 PGS GP DCPX RIF VT NRA A S a C a 0275 x2 x2 275 N 3 16 62 12 13 0300 N x2 x2 300 N 3 16 62 12 3 0325 e x2 x2 325 N 3 16 62 12 13 0350 N x2 x2 325 4 16 x2 82 12 3 0500 e x2 di serie 500 2 x2 38 63 4 10 0550 e s x2 di serie 550 N 2 x2 38 63 4 0 0600 e x2 di serie 600 N 2 x2 38 64 4 10 0650 N e x
31. 0700 86 0 540 730 927 819 807 810 793 744 654 0750 86 0 540 720 927 819 816 813 792 755 665 Total sound levels Octave band Hz A Pow Press 125 250 500 1000 2000 4000 8000 A aera dBA dB TE coustic power by central band frequency dB 10m 1m 0275 760 440 640 766 765 735 745 663 615 Si 0300 760 44 0 650 776 749 745 171 5 66 59 7 49 7 0325 77 0 45 0 660 775 778 761 71 4 668 59 7 50 3 0350 77 0 45 0 65 0 791 UES aa 72 66 9 595 49 3 0500 825 505 700 842 178 6 775 772 763 732 643 0550 825 505 70 0 841 784 779 776 76 5 712 623 0600 83 0 510 700 856 788 _ 78 4 78 77 721 63 0650 84 0 152 0 71 0 86 7 80 7 795 785 778 739 63 5 0700 840 52 0 700 838 799 797 795 774 729 64 7 0750 84 5 52 0 71 0 83 8 799 80 7 80 772 74 3 66 Total sound levels Octave band Hz Pow Press 125 250 500 1000 2000 4000 8000 l aB dBA op SE coustic power by central band frequency dB 10m 1m 0275 760 440 650 772 77 0 741 712 661 59 2 _ 49 5 0300 760 44 0 65 0 777 749 744 71 7 666 59 7 50 0 0325 77 0 45 0 660 798 780 _ 75 8 714 666 600 508 0350 77 0 45 0 660 793 773 755 720 670 598 496 0500 740 142 0 61 0 772 723 701 690 668 623 53 8 0550 745 425 620 789 731 70 7 694 671 62 6 _ 54 0 0600 750 430 620 807 736 713 697 674 626 540 0650 760 440 62 0 811 73 7 729 713 682 620 5413 0700 77 0 45 0 630 820 765 746 723 1
32. 1 06 113 1 2 kPa 0325 0750 25 20 15 lt 10 5 0 4 Caudal agua m3 h 12 2 4 Temperatura del agua C 30 40 50 Factor de correcci n 1 04 1 02 1 La capacidad de calentamiento dispo Temperatura del aire 35 C nible para la recuperaci n total hace Agua producida 45 C referencia a las condiciones nomina At 5 C les Versiones Standard 0275 0300 10325 10350 0500 0550 0600 0650 10700 0750 EE t rmica dispo KW 1 E 03 05 2g 34 38 45 nible Caudal agua m3 h 4 4 3 5 6 6 5 8 Perdida de agua kPa 10 9 5 9 7 8 5 9 Versiones A 0275 0300 0325 10350 0500 0550 0600 0650 0700 0750 Geer E aiia aa ane am 16 18 90 Ian 25 380 34 39 46 Caudal agua m9 h 2 2 2 6 3 39 4 4 4 5 6 65 8 Perdida de agua kPa 9 5 7 5 9 5 12 10 9 5 9 7 9 9 Versiones L 0275 0300 10325 10350 0500 0550 0600 0650 0700 0750 t rmica MEBO ly az 144 16 18 225 J24 29 34 38 40 Caudal agua m3 h 2 2 5 2 7 3 4 4 D 6 6 5 7 Perdida de agua kPa 7 6 7 10 9 5 9 8 5 7 9 7 En caso de funcionamiento con recu peraci n total de calor los rendimien tos de la m quina no dependen de la temperatura del aire externo sino de aquella del agua caliente producida la potencia el ctrica absorbida y la poten cia t rmica de recuperaci n se obtie nen multiplicando los valores Pa
33. 1470 1440 1440 Gy mm l 7 3 540 520 550 550 550 550 NRA HL CENTER OF GRAVITY Gx e Gy WEIGHT Kg HL Kg 725 750 770 860 1040 1100 1210 1380 1435 1638 Kg HLD Kg 732 758 779 869 1049 1110 1222 1394 1453 1656 Gx mm 1080 1075 1060 1055 1150 1160 1160 1470 1440 1440 Gy mm 550 550 550 550 540 520 550 550 550 550 C Kg 940 955 1030 1110 1285 1500 CD Kg 950 967 1044 1128 1303 1303 Gx Kg 2 3 1190 1180 1150 1160 1480 1480 Gy mm lt 560 560 550 550 550 550 CL Kg 598 623 638 719 950 965 1040 1245 1295 1500 CLD Kg 605 631 647 728 960 97 1054 1263 1313 1313 Gx Kg 925 920 905 900 1190 1180 1150 15110 1480 1480 Gy mm 550 550 550 550 560 560 550 550 550 550 Version with hydronic kit and without water 04 o Kg 1070 1095 1190 1285 1385 1807 D Kg 3 E 1080 1107 1204 1303 1403 1825 T Kg z 1165 1190 1295 1410 1510 1932 Gx mm e 3 e 1280 1270 1240 1250 1250 1510 Gy mm a E 560 550 550 550 550 550 NRA A CENTER OF GRAVITY GxeGy WEIGHT e O A Kg 810 840 855 940 1140 1165 1260 1345 1525 1710 AD Kg 817 848 864 950 1150 1277 1274 1363 1543 1728 AT Kg 855 975 985 10710 1275 1300 1395 1485 1665 1845 Gx mm
34. 250 200 150 700 100 650 600 50 550 275 750 0 300 325 500 0 10 20 350 30 40 50 60 Caudal de agua x 1000 I h 65 66 La potencia t rmica que se puede obte ner del desrecalentador se consigue multiplicando el valor nominal Pd indi cado en la tabla que se encuentra abajo de los diagramas paraun oportuno coeficiente Cd Los diagramas permi ten obtener los coeficientes correctivos a utilizar para los enfriadores de los varios modelos en coincidencia con cada curva se encuentra indicada la temperatura del aire externo a la cual se refiere Las p rdidas de carga que aparecen en la tabla se deben de considerar al neto del filtro la cui curva caratteristica e riportata in TAV El valor nominal se refiere a temperatura del aire 35 C agua producida 50 C ATENCION en los modelos con bomba de calor el desrecalentador debe ser intercepta do en el funcionamiento con bomba de calor bajo pena de anulaci n de la garantia Para los valores de la temperatura del agua refrigerada producida diversos de 7 C o para temperaturas de eva poraci n diversas de 5 C utilizar los factores correctivos de la correspon diente tabla adem s de los obtenidos por los gr ficos 12 3 P RDIDAS DE CARGA Los modelos NRA con desrecalenta dores tienen en toda su dimensi n 2 desrecalentadores situados en para lelo NOTE El paralelo hidr ulico est al cuidado del instalador Las caracte
35. 31 31 31 25 26 B 32 32 32 33 30 30 31 31 25 26 C 18 18 18 17 20 20 19 19 25 24 D 18 18 18 17 19 19 19 19 25 24 E 2 S E z 2 2 3 z VT 12 E 1 12 4 4 4 4 4 4 77 NRA L BARICENTRO Gx Gy DISTRIBUCI N PESOS SOBRE LOS APOYOS 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 A Kg 625 655 670 750 990 1040 1140 1305 1355 1560 AD Kg 632 663 679 759 1000 1052 1154 1323 1373 1578 AT Kg 670 709 733 813 1085 1135 1245 1430 1480 1685 Gx mm 925 920 905 900 1180 1190 1180 1500 1470 1440 Gy mm 550 550 550 550 560 570 550 550 550 550 A 32 32 33 33 31 31 31 25 25 26 B 32 32 33 33 30 30 31 25 25 26 E 18 18 17 17 20 20 19 25 25 24 D 18 18 17 17 19 19 19 25 25 24 E 5 o A 2 e VT 12 12 12 12 4 4 4 4 4 4 NRA H BARICENTRO Gx Gy DISTRIBUCI N PESOS SOBRE LOS APOYOS 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 H Kg 1030 1090 1200 1370 1425 1638 HD Kg 1040 1102 1214 1388 1443 1656 Gx mm 1150 1160 1160 1470 1440 1440 Gy mm 540 520 550 550 550 550 A 31 29 31 25 26 26 B E E 32 33 31 25 26 26 C 18 18 19 25 2
36. 325 HL 1100 2950 1606 350 A HL 1100 2950 1606 electric power inlet available on right and left sides 1 Le y 4 A O Mod Minimum technical space d mm s1 s2 s3 s4 clearance altura 800 800 800 1100 3000 NRA 0500 0550 600 650 700 Mod version A mm B mm C mm 500 A L C LC H HL 1100 2950 1875 550 A L C LC H HL 1100 2950 875 600 A L C LC H HL 1100 2950 1875 650 A C 1100 2950 875 700 1100 2950 875 electric power inlet available on right and left sides Le i Lal 4 4 A gd Mod Minimum technical space mm s1 s2 s3 s4 clearance altura 800 800 800 1100 3000 NRA 650 700 750 O a0 L K A B C Mod versioni mm mm _ mm 650 L LC H HL 1100 3950 1875 700 A L C LC H HL 1100 3950 1875 A L C LC H 750 HL 1100 4275 1875 electric power inlet available on right and left sides Mod Minimum technical space mm s1 s2 S3 Bd Clearance altura 800 800 800 1100 3000 35 19 WEIGHTS AND CENTRES OF MASS
37. 47 5 5 2 Input power ventilation unit kW S S i 2 7 2 7 2 7 2 8 2 7 Air flow rate m3 h 37500 37500 37500 35500 34600 56000 EVAPORATORS Type piastre piastre piastre piastre piastre piastre piastre piastre piastre piastre Number n 1 1 1 1 1 1 HYDRAULIC CIRCUIT Water Tank l S S 3 3 500 500 500 500 500 500 Accumulation antifreeze heater _ n xkw 300 300 300 300 300 300 PLUMBING CONNECTIONS STANDARD VERSIONS hydraulic parallel not supplied Hydraulic connections V S 2 2 2 2 2 2 LOW PRESSURE PUMPING UNIT Input power WW 11 11 11 1 5 1 85 3 Input current A lt 214 214 214 2 92 3 60 6 4 Useful pressure pumping kPa 121 112 69 85 103 90 HIGH PRESSURE PUMPING UNIT Input power lt S gt 1 8 1 8 3 7 3 7 3 7 5 5 Input current S S 2 3 60 3 60 721 721 721 11 3 Useful pressure pumping S 186 184 177 163 146 205 SOUND DATA Sounud Power dB A 82 5 82 5 83 0 84 0 86 0 86 0 Sound pressure 1 dB A 50 5 50 5 51 0 52 0 54 0 54 0 DIMENSIONS for all versions Height mm 1875 1875 1875 1875 1875 1875 Width mm 1100 1100 1100 1100 1100 1100 Length mm 2950 2950 2950 2950 2950 4275 EMPTY WEIGHT versions without accumulation and pumps kg 910 935 1010 1105
38. 5 C For the evaporator the Tav 7 4 is used to obtain the correction factors of the cooling and input capacities To take into account the dirtying of the exchangers the relative dirtying factors are used 7 CORRECTION COEFFICIENTS Ca 13 ei 45 LE 40 v 89 1 30 0 9 l 8 25 08 2 o 2 8 l 0 7 3 El 06 6 4 2 0 2 4 6 8 10 12 14 16 1 6 Cf 20 1 5 25 o 5 4 30 I a 3 35 oO 40 1 2 T oO ke Wl 1 l 5 45 0 9 08 l 46 0 7 4 5 3 0 6 g 3 05 3 6 4 2 0 2 4 6 8 10 12 14 16 Temperature of the water produced At 5 C 17 72 COOLING AND INPUT CAPACITIES SILENCED VERSIONS SIZE 500 550 600 700 750 The cooling capacity yielded and the electrical input power in conditions other than rated conditions are obtained by multiplying the rated values Pf Pa by the respective correction coefficients Cf Ca The following diagrams allow you to obtain the correction coefficients to be used for the various versions of the devices in cold mode next to each curve you can see the outside air temperature to which it refers KEY Cf Cooling capacity correction coefficient Ca Input power cor
39. 5 82 5 83 0 84 0 84 0 84 0 Presi n sonora 1 dB A 50 5 50 5 51 0 52 0 52 0 52 0 DIMENSIONES para todos los equipamientos Altura mm 1875 1875 1875 1875 1875 1875 Longitud mm 1100 1100 1100 1100 1100 1100 Longitud mm 2950 2950 2950 3950 3950 4275 PESO en vacio versiones sin acumulador ni bombas kg 940 955 1030 1110 1285 1500 ol 8 DATOS TECNICOS VERSION CL Potencia de refrigeraci n kW 117 134 153 165 Potencia absorbida total kW 40 5 49 55 INDICES ENERG TICOS EER W W 2 9 3 0 3 0 3 0 2 3 2 4 2 4 2 4 2 3 2 3 ESEER W W DATOS EL CTRICOS Alimentaci n A 3N 400 V 50Hz Corriente absorbida total S F A 39 42 7 46 5 55 5 66 71 5 87 8 99 2 111 8 124 Corriente m xima A 65 68 71 TT 98 104 133 145 145 160 Corriente de arranque A 155 161 166 209 215 222 239 250 257 314 Tipo Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll N mero n 2 2 2 2 3 3 4 4 4 4 N mero por circuito wA ee 2 2 2 2 2 2 3 2 3 2 4 2 4 2 4 2 4 2 Resistencia c rter compresores n W 2x75 2x75 2x75 2x75 3x75 3x75 4x75 4x75 4x75 2x75 2 x 130 Tipo Assiale Assiale Assiale Assiale Assiale Assiale Assiale Assiale Assiale Assiale Numero n 4 6 6 8 2 2 2 3 3 3 Corriente absorbida gr ventilaci n A 3 2 4 80 4 80 6 40 1 20 1 20 1 80 2 20 2 40 Potencia absorbida gr ventilaci n kW 0 58 0
40. 550 550 550 550 NRA HL _BARICENTRI Gx e Gy PESI Kg HL Kg 725 750 770 860 1040 1100 1210 1380 1435 1638 Kg HLD Kg 732 758 779 869 1049 1110 1222 1394 1453 1656 Gx mm 1080 1075 1060 1055 1150 1160 1160 1470 1440 1440 Gy mm 550 550 550 550 540 520 550 550 550 550 NRA C BARICENTRO Gx e Gy PESOS 0275 0300 0325 0350 0500 0550 os00 oe50 0700 0750 C Kg 940 955 1030 1110 1285 1500 CD Kg 950 967 1044 1128 1303 1303 Gx Kg 1190 1180 1150 1160 1480 1480 Gy mm 2 560 560 550 550 550 550 NRA CL BARICENTRO Gx e Gy PESOS 0275 0300 0325 0350 0500 0550 o600 0650 0700 0750 CL Kg 598 623 638 719 950 965 1040 1245 1295 1500 CLD Kg 605 631 647 728 960 977 1054 1263 1313 1313 Gx Kg 925 920 905 900 1190 1180 1150 15110 1480 1480 Gy mm 550 550 550 550 560 560 550 550 550 550 Versiones con kit hidr nico y sin agua 04 NRA BARICENTRO Gx e Gy PESOS 0275 0300 0325 0350 0500 osso 0600 0650 0700 0750 S Kg 1070 1095 1190 1285 1385 1807 D Kg 3 1080 1107 1204 1303 1403 1825 OT Kg 1165 1190 1295 1410 1510 1932 Gx mm 1280 1270 1240 1250 1250 1510 Gy mm 560 550 550 550 550 550 NRA A BARICENTRO Gx e Gy PESOS A Kg 810 840 855 940 1140 1165 1260 1345 525 1710 AD Kg 817 848 864 950 1150 1277 1274 1363 1543 1728 AT Kg 855 975 985 10710 1275 1300 1395 1485 665 1845 Gx mm 1045 1035 1020 1115 1300 1290 1260 1270 410 1510 Gy mm 550 550 550 550 560 560
41. 650 2 x3 Std 64 4 11 0750 s x2 Std 750 2 x3 Std 64 4 1 NRA HL 0275 Std Std 275 4 Std 62 12 13 0300 Std Std 300 4 Std 62 12 3 0325 Std Std 325 4 Std 62 12 13 0350 Std Std 325 4 Std 82 12 3 0500 Std Std 500 2 x2 Std 63 4 10 0550 Std Std 550 2 x2 Std 63 4 0 0600 gt Std Std 600 2 x2 Std 64 4 10 0650 Std Std 650 2 x3 Std 64 4 1 0700 Std Std 650 2 x3 Std 64 4 11 0750 Std Std 750 2 x3 Std 64 4 1 MOD ROMEO _ TP1 TP2 DRE AER485 PGS GP DCPX RIF VT NRA A S a C a 0275 x2 x2 275 e e 3 16 62 12 13 0300 lt e x2 e x2 300 3 16 62 12 3 0325 x2 x2 325 3 16 62 12 13 0350 e x2 e x2 325 4 16 x2 82 12 3 0500 lt x2 Std 500 e 2 x2 38 63 4 10 0550 e x2 Std 550 2 x2 38 63 4 O 0600 x2 Std 600 e 2 x2 38 64 4 10 0650 e x2 Std 650 2 x3 38 64 4 O 0700 x2 Std 650 2 x3 38 64 4 11 0750 e x2 Std 750 2 x3 38 64 4 1 NRA C 0275 0300 E 3 S S 0325 0350 lt E 0500 lt x2 Std 500 2 xa
42. 714 800 990 1117 1094 1183 1363 1548 AT Kg 705 820 835 920 1115 1140 1215 1305 1485 1655 Gx mm 945 940 925 1050 1190 1180 1150 1160 1480 1440 Gy mm 550 550 550 550 560 560 550 550 550 550 A 32 32 32 33 31 31 31 31 25 26 B 32 32 32 33 30 30 31 31 25 26 C 18 18 18 17 20 20 19 19 25 24 D 18 18 18 17 19 19 19 19 25 24 E S C z 3 A 5 z 3 VT 12 12 12 12 4 4 4 4 4 4 NRA L CENTER OF GRAVITY Gx e Gy PERCENTAGE DISTRIBUTION OF WEIGHT ON SUPPORT 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 A Kg 625 655 670 750 990 1040 1140 1305 1355 1560 AD Kg 632 663 679 759 1000 1052 1154 1823 1373 1578 AT Kg 670 709 733 813 1085 1135 1245 1430 1480 1685 Ex Imm 1928 920 905 900 1180 1190 1180 1500 1470 1440 Gy mm 550 550 550 550 560 570 550 550 550 550 A 32 32 33 33 31 31 31 25 25 26 B 32 32 33 33 30 30 31 25 25 26 C 18 18 17 17 20 20 19 25 25 24 D 18 18 17 17 19 19 19 25 25 24 E g G o Z o g E 3 VT 12 12 12 12 4 4 4 4 4 4 NRA H CENTER OF GRAVITY Gx e Gy PERCENTAGE DISTRIBUTION OF WEIGHT ON SUPPORT 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 H Kg 1030 1090 1200 1370 1425 1638 HD
43. 79 0 Presi n sonora 1 dB A 44 0 44 0 45 0 45 0 42 0 42 5 43 0 44 0 45 0 470 DIMENSIONES para todos los equipamientos Altura mm 1606 1606 1606 1606 1875 1875 1875 1875 1875 1875 Longitud mm 1100 1100 1100 1100 1100 1100 1100 1100 1100 1100 Longitud mm 2450 2450 2450 2950 2950 2950 2950 2950 3950 4275 PESO en vacio versiones sin acumulador ni bombas kg 625 655 670 750 990 1040 1140 1305 1355 1560 51 52 ol FUNCIONAMIENTO EN FRIO 5 DATOS T CNICOS VERSIONES BOMBA DE CALOR H Potencia de refrigeracion kW 90 100 120 140 158 177 Potencia absorbida total kW 36 38 45 49 59 64 Caudal agua evaporador Lh 15500 17200 2060 24100 27200 30400 P rdida carga evaporador kPa 28 23 33 36 38 43 EER W W 2 5 2 6 2 7 eo 27 2 8 COP W W 2 6 2 7 2 7 2 7 2 6 2 5 ESEER W W 2 9 3 02 3 46 3 75 3 5 Potencia de refrigeraci n kW 102 112 134 155 177 202 Potencia absorbida total kw 39 42 50 57 68 80 Caudal agua evaporador Lh 17500 19300 23100 26700 30400 34700 P rdida carga evaporador kPa 33 27 38 41 44 SEI DATOS EL CTRICOS Alimentaci n A 3N 400 V 50Hz Corriente absorbida total S F A 63 68 82 DE 103 115 5 Corriente absorbida total P d C A 66 73 85 100 112 1375 Corriente m xima A 98 104 133 148 148 160 Corriente de arranque A 215 222 239 253 260 314 RESISTENCIA COMPRESORES Resistencia c rter compresores no W 3x75 Tipo Sroll Sroll Sroll Sroll Srol
44. 87 0 87 116 0 6 0 6 1 21 1 2 Caudal aire m3 h 13720 20450 20450 27300 19000 21100 25000 27100 37600 40000 DATOS SONOROS Potencia sonora dB A 76 0 76 0 770 770 74 0 74 5 75 5 76 0 77 0 79 0 Presi n sonora 1 dB A 44 0 44 0 45 0 45 0 42 0 42 5 43 5 44 0 45 0 470 DIMENSIONES para todos los equipamientos Altura mm 1606 1606 1606 1606 1875 1875 1875 1875 1875 1875 Longitud mm 1100 1100 1100 1100 1100 1100 1100 1100 1100 1100 Longitud mm 2450 2450 2450 2950 2950 2950 2950 3950 3950 4275 PESO en vacio versiones sin acumulador ni bombas kg 598 623 638 719 950 965 1040 1120 1295 1500 55 56 En su configuraci n est ndar los aparatos no son adecuados para una instalaci n en ambiente salino Los l mites m ximos y m nimos para los flujos de agua en el intercambiador se encuentran indicados por las curvas de los diagramas de las p rdidas de carga Para los l mites de funcionamiento consulte los diagramas de abajo v lidos para At 5 C 61 L mites de funcionamiento Funcionamiento en fr o 6 CRITERIOS DE ELECCI N ATENCI N El funcionamiento con temperatura del agua producida inferior a 4 C est permitido s lo para las versiones espec ficamente previstas versi n YA Si se desea que la m quina funcione fuera de los l mites indicados en el diagrama contacte
45. Cooling capacity levels of power Version de 2 3 4 NRA 0275 50 100 NRA 0300 57 43 100 NRA 0325 50 100 NRA 0350 50 100 NRA 0500 39 78 100 NRA 0550 38 76 100 NRA 0600 30 61 80 100 NRA 0650 30 61 80 100 NRA 0700 30 61 80 100 NRA 0750 30 61 80 100 Imput power levels of power Version 1 Da 3 4 NRA 0275 50 100 NRA 0300 57 43 100 NRA 0325 50 100 NRA 0350 50 100 NRA 0500 34 67 100 NRA 0550 3 66 100 NRA 0600 22 43 72 100 NRA 0650 22 43 72 100 NRA 0700 22 43 72 100 NRA 0750 30 61 80 100 Heating capacity levels of power Version d 2 3 a NRA 0275 50 100 NRA 0300 57 43 100 NRA 0325 50 100 NRA 0350 50 100 NRA 0500 37 75 100 NRA 0550 36 73 100 NRA 0600 28 56 78 100 NRA 0650 28 56 78 100 NRA 0700 28 56 78 100 NRA 0750 28 56 78 100 3 2 Imput power Gradini di potenza Version x 23 3 4 NRA 0275 50 100 NRA 0300 57 43 100 NRA 0325 50 100 NRA 0350 50 100 NRA 0500 34 67 100 NRA 0550 31 66 100 NRA 0600 22 43 72 100 NRA 0650 22 43 72 100 NRA 0700 22 43 72 100 NRA 0750 22 43 72 100 KEY processed water temperature The performance refers to the following conditions processed water temperature 7 C outside air temperature 35 C 50 C
46. E 80 5 2 60 2 e 2 40 o 5 20 8 ge o 0 a O 10 20 30 40 50 60 70 Water flow rate m3 h Average water temperature C 5 10 15 20 30 40 50 Multiplicative coefficient 1 22 110 1 08 1 06 1 04 1 02 1 ka 30 20 2 1 2 10 D o 10 20 30 Caudal agua m3 h 23 24 The versions with accumulation offer different set ups that vary on the basis of the effective pressure that you want to obtain the characteristics of the pumping unit and the presence or absence of holes for integrative resistance The following tables show the main characteristics of the components of the hydraulic circuit while the graphs on these pages show the relative pressures The accumulation tanks with holes for heaters are equipped with plastic temporary closing plugs WARNING Before start up the installer must assemble the heaters If these heaters are not immediately necessary the plastic plugs must be replaced with suitable metal plugs 101 MAXIMUM WATER CONTENT in the system The table below indicates the maximum water content in litres of the hydraulic system compatible with the capacity of the expansion tank supplied as standard The values shown in the table refer to three conditions of maximum and minimum water temperature lf the effective water content of the hydraulic system including the accumulation tank is greater than that shown in the operational conditions table another additional expansion tank must be install
47. YA Operation with glycol water and DCPX Standard operation Operation with DCPX 2012 3 45 6 7 8 9 101112131415 Processed water temperature C Hot mode 55 50 45 40 35 30 25 Processed water temperature C 20 15 10 5 0 5 10 15 20 25 Outside air temp d b C 6 2 PROJECT DATA 1 only for heat pump versions VERSION e H in heat pump High pressure Low pressure side side Maximum pressure allowed bar 30 28 1 22 Maximum temperature allowed E 120 52 Minimum temperature allowed C 10 16 10 1 71 COOLING AND INPUT CAPACITIES STANDARD VERSIONS HEAT PUMP VERSIONS IN COLD MODE HIGH TEMPERATURE VERSIONS The refrigerating capacity yielded and the input electrical capacity in conditions other than rated conditions are obtained by multiplying the rated values Pf Pa by the respective correction coefficients Cft Cpa The following diagrams allow you to obtain the correction coefficients to be used for the various versions of the devices in cold mode next to each curve you can see the outside air temperature to which it refers KEY Cf Cooling capacity correction coefficient Ca Input power correction coefficient N B FOR VERSIONS Y with temperatures lower than 4 C contact the company headquarters FOR AT OTHER THAN
48. assiale assiale assiale assiale assiale assiale assiale assiale assiale assiale N mero n 4 6 6 6 2 2 2 2 3 3 Corriente absorbida gr ventilaci n A 3 2 4 8 4 8 4 8 1 2 1 2 1 8 2 2 2 4 Potencia absorbida gr ventilaci n kW 2 32 5 22 5 22 5 22 0 8 0 8 1 1 2 1 5 Caudal aire m3 h 14 000 21 000 21 000 20 300 17600 19 600 23 000 40 500 46 350 40 000 EVAPORADORES Tipo piastre piastre piastre piastre piastre piastre piastre piastre piastre piastre N mero n 1 1 d 1 1 1 1 1 1 1 CIRCUITO HIDR ULICO Acumulador de agua 500 500 500 500 500 500 500 500 500 500 Resistencia antihielo acumulador n xkw 300 300 300 300 300 300 300 300 300 300 CONEXIONES HIDRAULICAS paralelo no incluido Conexiones versioni estandard V 2 1 2 GW EW EW 2 1 2 EW EW GW GW EW GRUPO BOMBEO BAJA PREVALE NCIA Potencia absorbida W 075 0 75 075 0 75 11 11 El 15 1 85 3 Corriente absorbida A 1 85 1 85 1 85 214 214 214 214 2 92 3 60 6 4 Presi n til Pa 140 135 126 109 134 123 82 93 117 110 GRUPO BOMBEO ALTA PREVALENCIA Potencia absorbida W 11 11 1 5 1 5 1 8 1 8 3 7 3 7 3 7 5 5 Corriente absorbida A 214 214 2 92 2 92 3 60 3 60 721 721 721 11 3 Presi n til Pa 182 176 171 157 194 192 183 168 154 220 DATOS SONOROS Potencia sonora dB A 76 0 76 0 770 77 0 74 0 74 5 75 0 76 0 77 0
49. defrosting cycles KEY Ct Heating capacity correction coefficient Ca Input power correction coefficient 7 4 FOR AT OTHER THAN NOMINAL For At other than 5 C the Tav 1 is used on the evaporator to obtain the correction factors of the cooling and input capacities To take into account the dirtying of the exchangers the relative dirtying factors are used 75 FOULING FACTORS The performance shown by the table refers to conditions with clean tubes with a fouling factor 1 For other fouling factor values multiply the data of the performance tables by the coefficients given Ca 1 1 1 50 0 9 45 8 40 0 8 8 3 0 7 z Leem OLM E mne 0 6 Ct 10 8 6 4 2 2 4 6 8 10 12 14 16 4 5 42 35 3 40 45 Z 50 o 2 D oO A ge oO Ka u oO Oo 09 O c Q 0 8 0 7 0 6 8 o5 E Dd a 10 8 8 4 2 2 4 6 8 10 12 14 16 Outside air temperature b s with 87 humidity 7441 Correction factors for At other than nominal Chiller 3 5 8 10 Cooling capacity correction factors 0 99 1 1 02 1 03 Imput power correction factors 0 99 1 1 01 1 02 7 51 Fouling factors K m2 W 0 00005
50. factor of directionality Q 2 at 10 metres from the external surface of the unit using the shown is required 5 TECHNICAL DATA C a With storage tank parallel expansion method box method ISO 3744 NOTE The noise data refer to configuration without pump For heat pumps the data refers to functioning in cooling mode E S E ER There is a growing awareness in Europe as well that attention needs to be paid to the electricity consumed by air cond many years now in the not just been about effi itioning machines For United States talk has iciency in the plan con ditions but an assessment index is used that takes account of the marginal operation of the unit under plan conditions and the greater use with partial loads with external air that is less than that planned and in conditions of compres sor capacity control In Europe the proposed EECCAC Energy Efficiency and Certification of Central Air Conditioner has been adopted the ESEER European Seasonal Energy Efficiency Ratio that has the purpose of being able to compare the chillers with each other After estimating the total energy required by the system during summer management kW h the seasonal electrical energy consump tion can be deduced with this formula Input energy Required energy Efficiency index The actual energy calculation can be obtained more accurately by considering 1 The load profile with external temperature 2 The clim
51. la parte superior del tanque se encarga de descar gar eventuales bolsas de aire existente en el mismo Se encuentra interceptada por un grifo de manera de facilitar su eventual sustituci n Grupo de lenado Componente con acumulaci n Est dotado de man metro para la visuali 45 46 zaci n de la presi n de la instalaci n Ecipiente de expansi n Componente con acumulaci n Es del tipo de membrana con precarga de nitr geno V lvula de seguridad circuito hidr ulico Calibrada a 6 Bar interviene descargando la sobrepresi n en caso de presiones an malas 3 4 COMPONENTES DE SEGURIDAD Y DE CONTROL Pres stato de baja No est presente en las versiones de bomba de calor Con ajuste fijo colocado en el lado con baja presi n del circuito de refrigeraci n en caso de presiones de trabajo an malas de tiene el funcionamiento del compresor Pres stato de alta Con ajuste variable colocado en el lado de alta presi n del circuito frigor fico en caso de presiones de trabajo an malas detiene el funcionamiento del compresor Resistencia el ctrica anticongelante In stalada de serie Su funcionamiento es accionado por la sonda anticongelante colocada en el eva porador con placas La activaci n tiene lugar cuando la temperatura del agua es 3 C mientras su desactivaci n se verifica con temperatura del agua de 5 C El software dedicado residente en la tarje ta de regulaci n controla la resiste
52. los modelos con bomba de calor o con recuperaci n total Sirve para detener el gas refrigerante en estado l qui do en caso de que durante su funciona miento la m quina en objeto lo presente en forma abundante 3 3 COMPONENTES HIDR ULICOS Bomba de circulac n Acoplada exclusivamente en el tanque de acuerdo con las caracter sticas de la bom ba escogida ofrece una altura til de de scarga para vencer las p rdidas de carga de la instalaci n Asimismo est prevista la posibilidad de una bomba de reserva La bomba de reserva la dirige la tarjeta electr nica Fluj stato equipados de serie Est encargado de controlar que exista circulaci n de agua En caso contrario bloquea la unidad Filtro agua equipados de serie Permite bloquear y eliminar eventuales impuridades existentes en los circuitos hi dr ulicos En su interior presenta una mal la filtrante con agujeros que no superan el mil metro Es indispensable para evitar gra ves da os al cambiador con placas Tanque de alacenamiento Es de acero y su capacidad de 500 litros Con el objeto de reducir las dispersio nes t rmicas y eliminar el fen meno de la formaci n de condensaci n se a sla mediante material poliuret nico de id neo espesor Monta de serie una resistencia el ctrica anticongelante accionada por la sonda tambi n anticongelante insertada en el tanque V lvula de purga Componente con acumulaci n De tipo autom tico montada en
53. rate m3 h 14 000 21 000 21 000 20 300 17600 19 600 23 000 40 500 46 350 40 000 EVAPORATORS Type piastre piastre piastre piastre piastre piastre piastre piastre piastre piastre Number n 1 1 d 1 1 1 1 1 1 1 HYDRAULIC CIRCUIT Water Tank 500 500 500 500 500 500 500 500 500 500 Accumulation antifreeze heater _ n xkw 300 300 300 300 300 300 300 300 300 300 PLUMBING CONNECTIONS STANDARD VERSIONS hydraulic parallel not supplied Hydraulic connections V 2 1 2 2 1 2 2 1 2 2 1 2 2 1 2 2 1 2 2 1 2 2 1 2 2 1 2 2 1 2 LOW PRESSURE PUMPING UNIT Input power W 0 75 0 75 0 75 0 75 11 11 11 1 5 1 85 3 Input current A 1 85 1 85 1 85 214 214 214 214 2 92 3 60 6 4 Useful pressure pumping Pa 140 135 126 109 134 123 82 93 117 110 HIGH PRESSURE PUMPING UNIT Input power W 11 11 1 5 1 5 1 8 1 8 3 7 3 7 3 7 5 5 Input current A 214 214 2 92 2 92 3 60 3 60 721 721 721 11 3 Useful pressure pumping Pa 182 176 171 157 194 192 183 168 154 220 SOUND DATA Sounud Power dB A 76 0 76 0 770 770 74 0 74 5 75 0 76 0 77 0 79 0 Sound pressure 1 dB A 44 0 44 0 45 0 45 0 42 0 42 5 43 0 44 0 45 0 470 DIMENSIONS for all versions Height mm 1606 1606 1606 1606 1875 1875 1875 1875 1875 1875 Width mm 1100 1
54. vacio versiones sin acumulador ni bombas kg 1030 1090 1200 1370 1425 1638 gl FUNZIONAMENTO A FREDDO 6 DATOS T CNICOS VERSIONES BOMBA DE CALOR HL NOTA Il funzionamento silenziato solo in raffreddamento Potencia de refrigeraci n kw 51 59 67 76 87 96 1113 130 150 154 Potencia absorbida total kW 20 22 25 29 37 40 48 53 63 72 Caudal agua evaporador Vh 8800 10200 11500 13100 15000 16500 19800 22400 25800 26500 P rdida carga evaporador kPa 27 39 35 42 26 22 30 31 34 33 EER W W 2 6 2 7 2 7 2 7 24 24 2 4 25 2 4 2 2 COP W W 2 6 2 7 2 7 2 7 2 6 2 7 2 7 2 7 2 6 2 5 ESEER W W 2 96 31 3 03 3 0 2 75 2 65 3 02 3 06 3 0 Potencia de refrigeraci n kW 58 68 78 88 102 112 134 155 177 202 Potencia absorbida total kw 22 26 29 33 39 42 50 57 68 80 Caudal agua evaporador Vh 10000 11700 13400 15100 17500 19300 23100 26700 30400 34700 P rdida carga evaporador kPa 31 42 38 48 33 27 38 41 44 BS DATOS EL CTRICOS Alimentaci n A 3N 400 V 50Hz Corriente absorbida total S F A 39 41 7 48 5 55 7 65 70 85 96 109 123 Corriente absorbida total P d C A 42 5 48 8 53 5 60 8 66 0 73 0 85 0 100 112 1375 Corriente maxima A 65 68 71 77 98 104 133 148 148 160 Corriente de arranque A 155 161 166 209 215 222 239 253 260 314 Tipo Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Numero n 2 2 2 2 3 3 4 4 4 4 N mero por circuito mt L 2 2
55. 0 4 x 350 AHL 2950 2550 d A E SS B 200 a It e Mod 2 versions A mm B mm D O O A 168 500 L A C LC H HL 2950 2550 5 550 L A C LC H HL 2950 2550 A L 2 600 L A C LC H HL 2950 2550 S i 650 gt A C CL 2950 2550 v O v 700 o 2950 2550 N Gx rd A le K o B p C gt Y G Ra 9 A eh Mod versions A B S mm mm mm mm x f 8 650 L H HL 3936 200 1440 2096 e S 700 L A C LC H HL 3936 200 1440 2096 A 0 D o y 750 L A C LC H HL 4268 532 1440 2096 gi Gx la Versiones sin kit hidr nico con agua 00 NRA BARICENTRO Gx Gy DISTRIBUCI N PESOS SOBRE LOS APOYOS 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 S Kg l z 910 935 010 1105 205 1530 D Kg lt E 920 947 024 1123 223 1548 oT Kg lt lt 1005 1030 115 1230 330 1655 Gx mm E E z 1150 1140 120 1140 060 1440 Gy mm e z 570 570 550 550 550 550 A 3 i Z 33 33 32 32 33 26 B S 30 30 32 32 33 26 C z E z 19 19 8 18 7 24 D 18 19 8 18 7 24 VT E 7 E 4 4 4 4 4 4 NRA A BARICENTRO Gx Gy DISTRIBUCI N PESOS SOBRE LOS APOYOS 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 A Kg 660 690 705 790 980 1005 1080 1165 1345 1530 AD T Kg _ 667 698 714 800 990 1117 1094 1183 1363 1548 AT Kg 705 820 835 920 1115 1140 1215 1305 1485 1655 Gx mm 945 940 925 1050 1190 1180 1150 1160 1480 1440 Gy mm 550 550 550 550 560 560 550 550 550 550 A 32 32 32 33 31
56. 0 o Q Le 300 L A C 2450 2050 x 325 L A C 2450 2050 A 4 2 350 L LC 2450 2050 G v gt 9 o v 275 HL 2950 _ 2550 a 300 HL 2950 2550 p Gx 325 HL 2950 2550 350 AHL 2950 2550 lt E Mod 2 version A mm B mm a 209 Sa 2 mm B mm sE gt X 500 L A C LC H HL 2950 2550 8 a 160 550 L A C LC H HL 2950 2550 600 L A C LC H HL 2950 2550 f 9 650 gt A C CL 2950 2550 G 700 o 2950 2550 Y A 0O G v N e Gx A N Mod version 4 E S E 9 B p C D d A mm mm mm mm S a o o 650 L H HL 3936 200 1440 2096 N s 700 L A C LC H HL 3936 200 1440 2096 i 4 g 750 L A C LC H HL 4268 532 1440 2096 G 1 0 o e S Gx bel Version without hydronic kit with water 00 NRA CENTER OF GRAVITY Gx e Gy PERCENTAGE DISTRIBUTION OF WEIGHT ON SUPPORT 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 S Kg 910 935 1010 1105 1205 1530 D Kg _ lt S 920 947 1024 1123 1223 1548 T Kg 1005 1030 1115 1230 1330 1655 Gx mm E E E 1150 1140 1120 1140 1060 1440 Gy mm 570 570 550 550 550 550 A a E E 33 33 32 32 33 26 B 30 30 32 32 33 26 C E lt S 19 19 18 18 17 24 D 18 19 18 18 17 24 VT 3 E E 4 4 4 4 4 4 NRA A CENTER OF GRAVITY Gx e Gy PERCENTAGE DISTRIBUTION OF WEIGHT ON SUPPORT 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 A Kg 660 690 705 790 980 1005 1080 1165 1345 1530 AD T Kg _ 667 698
57. 0 100 NRA 0500 37 75 100 NRA 0550 36 73 100 NRA 0600 28 56 78 100 NRA 0650 28 56 78 100 NRA 0700 28 56 78 100 NRA 0750 28 56 78 100 Potencia absorbida Niveles de potencia Versiones da 2 3 EN NRA 0275 50 100 NRA 0300 57 43 100 NRA 0325 50 100 NRA 0350 50 100 NRA 0500 34 67 100 NRA 0550 31 66 100 NRA 0600 22 43 72 100 NRA 0650 22 43 72 100 NRA 0700 22 43 72 100 NRA 0750 22 43 72 100 Nota temperatura del agua producida Los rendimientos se refieren a las siguientes condiciones temperatura del agua producida 7 C temperatura de aire externo 35 C 50 C temperatura del externo 7 C B S 6 C B U aire PAR METROS DE CONTROL Notas 1 Versi n Y 151 MAGENTOT RMICOS VENTILADORES 15 2 MAGENTOT RMICOS COMPRESORES 15 3 TRANSDUCTORES PRESOSTATOS Nota PA Presostato de alta presi n PB Presostato de baja presi n TRB Transductor de baja presi n Todas las unidades est n sometidas a test rigurosos en la f brica antes de su env o En cualquier caso es buena costumbre comprobar todos los dispositivos de control y de seguridad despu s de un periodo razonable de funcionamiento Todas las operaciones de control deben ser realizadas por personal cualificado los ajustes err neos de tales dispositivos pueden causar serios da os a la unidad 15 3 1 Presostato de alta presi n El presostato de alta presi n detiene el compresor generando la alarma co
58. 0 52 0 52 0 52 0 DIMENSIONES para todos los equipamientos Altura mm 1606 1606 1606 1606 1875 1875 1875 1875 1875 1875 Longitud mm 1100 1100 1100 1100 1100 1100 1100 1100 1100 1100 Longitud mm 2450 2450 2450 2950 2950 2950 2950 2950 3950 4275 PESO en vacio versiones sin acumulador ni bombas kg 660 690 705 790 980 1005 1080 1165 1345 1530 gl A DATI TECNICI VERSIONI SILENZIATE L Potencia de refrigeraci n kW 48 57 65 74 88 SA 115 134 150 161 Potencia absorbida total kw 21 24 27 31 38 41 50 56 66 71 5 Caudal agua evaporador Vh 8260 9800 11180 12730 15140 16680 119780 23050 2580 27690 P rdida carga evaporador kPa 33 30 30 41 27 22 5 31 5 31 35 5 36 INDICES ENERG TICOS EER W W 2 34 2 38 2 41 2 39 2 30 2 35 2 30 2 40 2 27 2 25 ESEER W W 2 83 2 87 2 90 2 88 2 67 2 75 3 06 3 20 3 05 DATOS EL CTRICOS Alimentaci n A 3N 400 V 50Hz Corriente absorbida total A 40 46 50 57 5 66 5 71 9 88 4 99 7 112 3 124 2 Corriente m xima A 65 68 71 77 98 104 193 145 148 160 Corriente de arranque A 155 161 166 209 215 222 239 250 260 314 RESISTENCIA COMPRESORES Tipo scroll scroll scroll scroll scroll scroll scroll scroll scroll scroll N mero n 2 2 2 2 3 3 4 4 4 4 N mero por circuito nA 2 42 2 2 2 2 2 2 3 2 3 2 4 2 4 2 4 2 4 2 Resistencia c rter compresores n W 2x75 2x75 2x75 2x75 3x75 38x75 4x75 4x75 4x75 2x75 2 x 130 Tipo
59. 0 65 70 75 Water flow m3 h kPa Water flow m3 h 14 REFRIGERANT LINE Mod Liquid line lenght Gas line Liquid line Gas per meter of liquid line C1 c2 C1 C2 C1 c2 0 10 35 35 15 88 5 88 175 175 0275 C 10 20 35 35 15 88 5 88 175 175 20 30 35 35 15 88 15 88 175 175 0 10 35 35 18 18 220 220 0300 C 10 20 35 35 18 8 220 220 20 30 35 42 18 8 220 220 0 10 35 35 18 18 220 220 0325C 10 20 35 35 18 8 220 220 20 30 42 42 18 18 220 220 0 10 35 35 18 18 220 220 0350 C 10 20 35 35 18 8 220 220 20 30 42 42 18 18 220 220 0 10 42 35 22 8 360 220 0500 C 10 20 42 35 22 8 360 220 20 30 42 42 22 18 360 220 0 10 42 35 22 18 360 220 0550 C 10 20 42 35 22 8 360 220 20 30 42 42 22 8 360 220 0 10 42 42 22 22 360 360 0600 C 10 20 42 42 22 22 360 360 20 30 42 42 22 22 360 360 0 10 42 42 22 22 360 360 0650 C 10 20 42 42 28 28 590 590 20 30 42 42 28 28 590 590 0 10 42 42 28 28 590 590 0700C 10 20 42 42 28 28 590 590 20 30 54 54 28 28 590 590 0 10 42 42 28 28 590 590 0750C 10 20 42 42 28 28 590 590 20 30 54 54 28 28 590 590 KEY C1 Cooling circuit 1 C2 Cooling circuit 2 position lower than the condenser the suction line must be provided with siphons to 0 5 lt EVA AO facilitate entraining of oil towards the J ATTS EVARORATEUR compressor Length of the lines is
60. 00 1480 1670 1640 1640 Gy mm S 540 530 550 550 550 550 A 24 24 25 11 11 11 B lt 25 26 25 11 11 11 C 25 24 25 9 8 8 D 26 26 25 9 8 8 E 30 31 31 F 30 31 31 VT 2 gt 10 10 10 11 11 11 NRA HL BARICENTRO Gx Gy DISTRIBUCI N PESOS SOBRE LOS APOYOS HL Kg 1375 1400 1420 1610 1700 1760 1890 2060 2115 2318 HLD Kg 1382 1403 1429 1519 1709 1770 1902 2074 2133 2363 Gx mm 1330 1320 1310 1305 1500 1500 1480 1670 1640 1640 Gy mm 550 550 550 550 540 530 550 550 550 550 A 28 28 28 28 24 24 25 11 11 11 B 28 28 28 28 25 26 25 11 11 11 C 22 22 22 22 25 24 25 9 8 8 D 22 22 22 22 26 26 25 9 8 8 E S S 30 31 31 F 30 31 31 VT 13 13 13 13 10 10 10 11 11 11 20 2 INSTRUCCIONES PARA EL Utilice cuerdas de la misma longitud los medios a norma de seguridad LEVANTAMIENTO Verifique que todos los paneles est n fuertemente fijados antes de mover la unidad Utilice todos y solamente los puntos de elevaci n indicados e id neas para levantar el peso de la unidad Desplace la unidad con cautela sin movimientos bruscos y verifique que nadie permanezca debajo de la unidad El desplazamiento debe ser realizado por personal calificado y equipado con NOTA Para conocer la posici n de los puntos de fijaci n de los AVX tome como refe rencia el manual de instalaci n 79 AERMEC S p A 37040 Bevilacqua VR
61. 0550 0600 0650 0700 0750 y Kg 910 935 1010 1105 1205 1530 D Kg 920 947 1024 1123 1223 1548 ST Kg 1005 1030 1115 1230 1330 1655 Gx mm 1150 1140 1120 1140 1060 1440 Gy mm 570 570 550 550 550 550 75 76 NRA A BARICENTRO Gx e Gy PESOS A Kg 660 690 705 790 980 1005 1080 1165 1345 1530 AD Kg 667 698 714 800 990 1117 1094 1183 1363 1548 AT Kg 705 820 835 920 1115 1140 1215 1305 1485 1655 Gx mm 945 940 925 1050 1190 1180 1150 1160 1480 1440 Gy mm 550 550 550 550 560 560 550 550 550 550 NRA L BARICENTRO Gx e Gy PESOS L Kg 625 655 670 750 990 1040 1140 1305 1355 1560 LD Kg 632 663 679 759 1000 1052 1154 1323 1373 1578 LT Kg 670 709 733 813 1085 1135 1245 1430 1480 1685 Gx mm 925 920 905 900 1180 1190 1180 1500 1470 1440 Gy mm 550 550 550 550 560 570 550 550 550 550 NRA H BARICENTRO Gx e Gy PESOS Kg H Kg 1030 1090 1200 1370 1425 1638 Kg HD Kg E E o 1040 1102 1214 1388 1443 1656 Gx mm 1150 1160 1160 1470 1440 1440 Gy mm 5 o E 540 520
62. 09 3 20 40 6 0 434 1 20 60 6 0 604 2 20 85 6 0 729 3 35 40 6 0 393 1 35 60 6 0 555 2 35 85 6 0 677 3 Reference working conditions 1 Cooling Max water temp 40 C Min water temp 4 C 2 Heating heat pump Max water temp 60 C Min water temp 4 C 3 Heating boiler Max water temp 85 C Min water temp 4 C 4 gt H max 1 55 m D o cu o KE K I NEEN DER ES u L p o JI H 12 25m E H 19 Oo FRS lt lt H e b C gt H 0m ty gt E D 10 H e gt o H min 2 1 2 Ensure that the highest terminal unit doesn t exceed 55 metres of level difference Ensure that the lowest terminal unit can sup port the global pressure present at that point For the versions 01 02 03 04 P1 P2 P3 P4 The pressures stated here are net of the pressure drop of the heat exchan gers filter accumulation hydraulic parallel They are therefore to be con sidered USEFUL TO THE PLANT NOTE The pressures are calculated in cold mode WITH AT 5 C FOR LOWER AT CONTACT THE ESTABLISHMENT IN THE PRESENCE OF GLYCOLS FOR THE PLANT U
63. 090 1 000 0 990 0 975 FcG a ia 91 PRESSURE DROPS EVAPORATOR The following diagrams show the values of the pressure drops in kPa on the basis of the capacity in I h The operation field is defined by the minimum and maximum values of the curves which indicate the limit of use of the water side heat exchangers evaporators The pressure drops of the diagrams are relative to the average water temperature 10 C The following table shows the correction to apply to the pressure drop when the average water temperature varies 9 2 PRESSURE DROPS CONDENSER The pressure drops of the diagram are relative to an average water temperature of 50 C The following table shows the correction to apply to the pressure drop when the average water temperature varies 9 3 PRESSURE DROPS WATER FILTER 9 PRESSURE DROPS kPa 110 100 90 0600 0550 0650 80 70 60 50 40 30 20 10 Water flow rate m3 h 0700 Average water temperature C 5 10 15 20 30 40 50 Multiplicative coefficient 1 02 1 0 985 0 97 095 10 93 0 91 kPa 180 160 140 120 100
64. 1 5 1 0 O 0 9 5 5 3 0 8 g O 0 7 12345 67 8 9 1011 1 4 Cf 1 3 5 12 11 o 1 0 745 0 9 A r E L E 0 8 07 El 1234567 8 9 10 11 C Temperatura de evaporaci n Ca 1 3 1 2 11 8 1 0 E 0 9 0 8 1 3 6 7 8 9 10 11 C 0 8 1 2 3 4 5 6 7 8 9 CA 12 11 10 09 L potenza frigorifera O 11 C Temperatura de evaporaci n Los factores de correcci n de potencia de refrigeraci n y absorbida tienen en cuenta la presencia de glicol y la diferente temperatura de evaporaci n Los factores de correcci n del caudal del agua y de las p rdidas de carga deben aplicarse directamente a los datos obtenidos para el funcionamiento sin glicol El factor de correcci n del caudal del agua se calcula con el objetivo de mantener el mismo At que se tendr a sin glicol El factor de correcci n de la p rdida de carga ya tiene en cuenta el diferente caudal que se deriva de la aplicaci n del factor de correcci n del caudal del agua Los factores de correcci n del caudal del agua y de las p rdidas de carga deben aplicarse directamente a los datos obtenidos para el funcionamiento sin glicol Los factores de correcci n de la potencia de refrigeraci n y absorbida 8 SOLUCI N DE GLICOL ETILENICO tienen en cuenta la presencia de glicol Los factores de correcci n del caudal del agua y de las p rdidas de carga deben apli
65. 100 1100 1100 1100 1100 1100 1100 1100 1100 Length mm 2450 2450 2450 2950 2950 2950 2950 2950 3950 4275 EMPTY WEIGHT versions without accumulation and pumps kg 625 655 670 750 990 1040 1140 1305 1355 1560 11 ol 5 ECHNICAL DATA HEAT PUMP VERSIONS H Cooling capacity kW 90 100 120 140 158 177 Total input power kW 36 38 45 49 59 64 Evaporator water flow rate Vh 15500 17200 2060 24100 27200 30400 Evaporator pressure drop kPa 28 23 33 36 38 43 ENERGY INDICES EER W W 2 5 2 6 2 7 eo 27 2 8 COP W W 2 6 2 7 2 7 2 7 2 6 2 5 ESEER W W 2 9 3 02 3 46 3 75 3 5 Cooling capacity kW 102 112 134 155 177 202 Total input power kW 39 42 50 57 68 80 Evaporator water flow rate Lh 17500 19300 23100 26700 30400 34700 Evaporator pressure drop kPa 33 27 38 41 44 55 Fuel feed A 3N 400 V 50Hz Total input current only COOLING A 63 68 82 92 103 MB Corrente assorbita totale HEATING A 66 73 85 100 112 1375 Maximum current A 98 104 133 148 148 160 Peak current A 215 222 239 253 260 314 Type Sroll Sroll Sroll Sroll Sroll Sroll Number n 3 3 4 4 4 4 Number per circuit n n 3 2 3 2 4 2 4 2 4 2 4 2 COMPRESSOR HEATER Compressor carter heater no W 3x75 3x75 4x75 4x75 4x75 4 x 130 Type Axial Axial Axial Axial Axial Axia
66. 1100 2950 1875 550 A L C LC H HL 1100 2950 875 600 A L C LC H HL 1100 2950 1875 650 A C 1100 2950 875 700 1100 2950 875 entrada alimentaci n el ctrica disponible a la derecha y a la izquierda Le Q Lo y Ed A Mod Minimum technical space mm s1 s2 S3 Bd clearance 800 800 800 1100 3000 NRA 650 700 750 A B C Mod versions mm mm _ mm 650 L LC H HL 1100 3950 1875 700 A L C LC H HL 1100 3950 1875 A L C LC H 750 1100 4275 1875 HL entrada alimentaci n el ctrica disponible a la An derecha y a la izquierda 4 _ SA 2 Q ch JA L a o A Z SR T e 4 r N Mod Minimum technical space e mm EN s2 s3 s4 clearance o 800 800 800 1100 3000 19 PESOS Y BARICENTROS Q O Q o G 4 G 4 O v G G Gx Gx E Me G G c GER k v o 0 o Gx 191 DISTRIBUCI N PESOS PORCENTAJE SOBRE APOYOS SIN AGUA 00 NRA BARICENTRO Gx e Gy PESOS 0275 0300 0325 0350 0500
67. 1205 1560 10 ol 3 TECHNICAL DATA HIGH EFFICIENCY VERSIONS A Cooling capacity kW 53 62 71 82 98 107 125 142 166 185 Total input power kw 18 21 24 28 34 38 46 53 58 5 64 Evaporator water flow rate Lh 9120 1066 1238 1410 1680 1840 2150 2600 2850 3182 Evaporator pressure drop kPa 40 35 5 36 5 50 33 5 27 37 37 44 47 ENERGY INDICES EER W W 2 94 2 96 2 98 2674 2 83 ema 2 70 2 84 2 89 ESEER W W 3 57 2 83 3 61 3 51 3 48 3 81 3 80 3 98 ELECTRICAL DATA Fuel feed A 3N 400 V 50Hz Total input power A 36 2 41 6 45 4 54 61 7 68 7 84 5 96 7 103 6 115 5 Maximum current A 65 68 71 77 98 104 133 148 148 160 Peak current A 155 161 166 209 215 222 239 253 260 314 Type scroll scroll scroll scroll scroll scroll scroll scroll scroll scroll Number n 2 2 2 2 3 3 4 4 4 4 Number per circuit mor F 2742 2 2 2 2 2 2 3 2 3 2 4 2 4 2 4 2 4 2 Compressor carter heater n W 2x75 2x75 2x75 2x75 3x75 3x75 4x75 4x75 4x75 2x75 2x130 Type Axial Axial Axial Axial Axial Axial Axial Axial Axial Axial Number n 4 6 6 8 2 2 2 3 3 3 Input current ventilation unit A 3 2 4 8 4 8 6 4 5 5 5 5 Za Input power ventilation unit kw 2 32 5 22 5 22 9 28 2 8 2 8 2 8 2 8 4 2 Air flow rate m3 h 138720 20450 20450 27300 35500 35500 35500 35000 54900 56000 EVAPORATORS Typ
68. 2 di serie 650 N 2 x3 38 64 4 0 0700 e x2 di serie 650 2 x3 38 64 4 11 0750 N x2 di serie 750 N 2 x3 38 64 4 1 NRA C 0275 0300 0325 0350 0500 e x2 di serie 500 N 2 x2 38 63 4 0550 N x2 di serie 550 N 2 x2 38 63 4 0600 x2 di serie 600 N 2 x2 38 64 4 0650 N e x2 di serie 650 N 2 x2 38 64 4 0700 e x2 di serie 650 N 2 x3 38 64 4 0750 N e x2 di serie 750 2 x3 38 64 4 NRA LC 0275 x2 x2 275 N 3 16 62 12 0300 x2 x2 300 N 3 16 62 12 0325 x2 e x2 325 7 3 16 62 12 0350 x2 x2 325 3 16 x2 82 12 0500 e x2 di serie 500 2 x2 di serie 63 4 0550 e e x2 di serie 550 N e 2 x2 di serie 63 4 0600 x2 di serie 600 N 2 x2 di serie 64 4 0650 N e x2 di serie 650 N e 2 x3 di serie 64 4 0700 e x2 di serie 650 N 2 x3 di serie 64 4 0750 e x2 di serie 750 2 x3 di serie 64 4 1 n mero indica la cantidad nece S a sin acumulaci n Aplicable s lo en f brica Cuando se encuentra entre par ntesis el 51 CONDICIONES NOMINALES DE REFERENCIA Los datos t cnicos se calculan Durante el enfriamiento Temperatura agua en entrada 12 C Temperatura agua en salida 7 C Temperatura aire externo 35 C At 5 C Durante el calentamiento Temperatura agua en salida 50 C Temp
69. 2 2 2 2 3 2 3 2 4 2 4 2 4 2 4 2 Resistencia c rter compresores n W 2x75 2x75 2x75 2x75 3x75 3x75 4x75 4x75 4x75 2x75 2 x 130 Tipo Axial Axial Axial Axial Axial Axial Axial Axial Axial Axial N mero n 6 8 8 8 2 2 2 3 3 3 Corriente absorbida gr ventilaci n A 4 2 5 6 5 6 5 6 2 4 2 4 2 4 3 5 3 5 Potencia absorbida gr ventilaci n kW 0 87 116 116 116 1 2 1 2 1 2 1 5 1 5 Caudal aire m3 h 21000 28000 _ 28000 28000 25000 26000 28000 34000 38000 42000 Tipo Placas Placas Placas Placas Placas Placas Placas Placas Placas Placas N mero n 1 il 1 1 1 1 1 1 1 1 CIRCUITO HIDR ULICO Acumulador de agua 500 500 500 500 500 500 500 500 500 500 Resistencia antihielo acumulador n x KW 300 300 300 300 300 300 300 300 300 300 CONEXIONES HIDRAULICAS paralelo no incluido Conexiones version estandard Victaulic 2 1 2 2 2 2 21 2 21 2 ENZ 21 2 21 2 ENZ GRUPO BOMBEO BAJA PREVALENCIA Potencia absorbida kw 0 75 0 75 0 75 0 75 11 11 14 1 5 1 85 3 Corriente absorbida A 1 85 1 85 1 85 214 214 214 214 2 92 3 60 6 4 Presi n til sF 134 131 122 105 134 199 60 100 117 120 GRUPO BOMBEO ALTA PREVALENCIA Potencia absorbida kW 11 11 1 5 1 5 1 8 1 8 3 7 3 7 3 7 5 5 Corriente absorbida A 214 214 2192 2 92 3 60 3 60 721 721 721 11 3 Presi n til SF 176 172 168 155 194 189 185 172 154 230 DATOS SONOROS Potencia sonora dB A 76 0 76 0 770 770 76 0 76 5 775 78 5 80 0 81
70. 275 0300 0325 0350 0500 0550 0600 0650 0700 0750 H Kg 1690 1750 1880 2050 2105 2318 HD Kg S i E 1700 1910 1894 2068 2123 2336 Ex mm 1500 1500 1480 1670 1640 1640 Gy mm 540 530 550 550 550 550 A 24 24 25 11 11 11 B 25 26 25 11 11 11 C 25 24 259 9 8 8 D 26 26 25 9 8 8 E 30 31 31 F 30 31 31 VT 10 10 10 11 11 11 NRA HL CENTER OF GRAVITY Gx e Gy PERCENTAGE DISTRIBUTION OF WEIGHT ON SUPPORT HL Kg 1375 1400 1420 1610 1700 1760 1890 2060 2115 2318 HLD Kg 1382 1403 1429 1519 1709 1770 1902 2074 2133 2363 Gx mm 1330 1320 1310 1305 1500 1500 1480 1670 1640 1640 Gy mm 550 550 550 550 540 530 550 550 550 550 A 28 28 28 28 24 24 25 11 11 11 B 28 28 28 28 25 26 25 11 11 11 C 22 22 22 22 25 24 25 9 8 8 D 22 22 22 22 26 26 25 9 8 8 E 30 31 31 F 30 31 31 VT 13 13 13 13 10 10 10 11 11 11 NOTA sentano variazioni di peso trascurabili Le altre versioni con accumulo pre rispetto al modello di riferimento 01 18 2 2 INSTRUCTIONS FOR LIFTING the weight of the unit NOTE Before moving the unit make sure that all the panels are solidly fi xed Use all and only the lifting points indi cated Use ropes of equal lengths and suita ble for lifting Move the unit with caution without jerky movements and do not remain under the unit Movement must be performed by qualifi ed peo
71. 3 Accumulation and high pressure pump 04 Accumulation high pressure pump and reserve pump 05 Accumulation with holes for integrative resistance and low pressure pump 06 Accumulation with holes for integrative resistance low pressure pump and reserve pump 07 Accumulation with holes for integrative resistance high pressure pump 08 Accumulation with holes for integrative resistance high pressure pump and reserve pump 37 400V 50Hz with thermomagnetic switches 4 37 230V 50Hz with thermomagnetic switches 9 37 500V 50Hz with thermomagnetic switches According to PED standards C Condensing without evap Aluminium R Copper EI Tinned copper V Varnished aluminium copper S Standard A High temperature L Standard in Silenced operation Without recoverers D Desuperheater T Total recovery 5 Cooling only H Heat pump 2 Standard Y Version for low temperature of processed water down to 6 C 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 31 COOLING CIRCUIT Compressor Hermetic scroll type compressors fitted with an antifreeze resistor as standard accessory The resistor is powered auto matically when the unit pauses provided the power supply is not turned off The compressor compartment is sound proofed Exchanger air side Features copper tube bu
72. 4 24 D E E E 19 20 19 25 24 24 E lt D a S a E 5 S A A 5 E lt z 2 VT 4 4 4 4 4 4 NRA HL BARICENTRO Gx Gy DISTRIBUCI N PESOS SOBRE LOS APOYOS 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 HL Kg 725 750 770 860 1040 1100 1210 1380 1435 1638 HLD Kg 732 758 LDS 869 1049 1110 1222 1394 1453 1656 Gx mm 1080 1075 1060 1055 1150 1160 1160 1470 1440 1440 Gy mm 550 550 550 550 540 520 550 550 550 550 A 33 33 33 33 31 29 31 25 26 26 B 33 33 33 33 32 33 31 25 26 26 C 17 17 17 17 18 18 19 25 24 24 D 17 17 172 17 19 20 19 25 24 24 E F VT 12 12 12 12 4 4 4 4 4 4 Versiones con kit hidr nico y agua 04 NRA BARICENTRO Gx Gy DISTRIBUCI N PESOS SOBRE LOS APOYOS 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 Kg 910 935 1010 1105 1205 1530 D Kg c E 920 947 1024 1123 1223 1548 Si Kg 005 1030 1115 1230 1330 1655 Gx mm 1150 1140 1120 1140 1060 1440 Gy mm 570 570 550 550 550 550 A E E 33 33 32 32 33 11 B 30 30 32 32 33 11 E E E E E 9 19 18 18 17 8 D 8 19 18 18 17 8 E 31 F 31 VT 0 10 10 10 10 11 NRA A BARICENTRO Gx Gy DISTRIBUCI N PESOS SOBRE LOS APOYOS A Kg 1310 1340 1355 1440 1640 1665 1760 1845 2025 2210 AD Kg 1317 1348 1364 1450 1650 1777 1774 1863 2043 2228 AT Kg 1355 1475 1485 2210 1775 1800 1895 1985 2165 2345 Gx mm 1225 121
73. 45 0 680 776 749 745 715 66 59 7 49 7 0325 770 45 0 690 775 778 761 714 66 8 59 7 50 3 0350 77 0 45 0 69 0 791 US Pos 172 66 9 595 _ 49 3 0500 760 440 630 812 776 723 693 683 639 563 0550 76 5 445 640 810 781 73 7 696 686 635 53 8 0600 77 5 455 650 822 180 5 750 708 68 7 628 546 0650 785 465 650 834 817 755 72 1 696 638 5 55 8 0700 80 0 48 0 67 0 852 826 772 738 _ 71 6 654 571 0750 81 0 49 0 670 852 823 789 753 709 705 619 71 72 16 PARCIALIZACIONES ZS Potencia de refrigeraci n Niveles de potencia Versiones aye 2 3 4 NRA 0275 50 100 NRA 0300 57 43 100 NRA 0325 50 100 NRA 0350 50 100 NRA 0500 39 78 100 NRA 0550 38 76 100 NRA 0600 30 61 80 100 NRA 0650 30 61 80 100 NRA 0700 30 61 80 100 NRA 0750 30 61 80 100 Potencia absorbida Niveles de potencia Versiones 1 2 3 4 NRA 0275 50 100 NRA 0300 57 43 100 NRA 0325 50 100 NRA 0350 50 100 NRA 0500 34 67 100 NRA 0550 31 66 100 NRA 0600 22 43 72 100 NRA 0650 22 43 72 100 NRA 0700 22 43 72 100 NRA 0750 30 61 80 100 Potencia t rmica Niveles de potencia Versiones da 2 3 4 NRA 0275 50 100 NRA 0300 57 43 100 NRA 0325 50 100 NRA 0350 5
74. 5 1205 1300 1540 1540 1500 1490 1670 1440 Gy mm 550 550 550 550 550 560 550 550 550 550 A 25 25 25 28 24 24 25 25 11 11 B 25 25 25 28 23 23 25 25 11 11 E 25 25 25 22 27 27 25 25 9 8 D 25 25 25 22 26 26 25 25 9 8 E E E E 30 31 E 30 31 VT 13 13 13 13 10 10 10 10 11 11 N U Punto de apoyo y orificio correspondiente 78 para AVX presente pero no utilizado NRA L BARICENTRO Gx Gy DISTRIBUCI N PESOS SOBRE LOS APOYOS 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 L Kg 1275 1305 1320 1400 1650 1700 1820 1985 2035 2240 LD Kg 1282 1318 1329 1409 1660 1712 1834 2003 2053 2258 LT Kg 1320 1359 1383 1463 1745 1795 1925 2110 2160 2365 Gx mm 1220 1215 1200 1185 1530 1530 1510 1600 1670 1640 Gy mm 550 550 550 550 560 570 550 550 550 550 A 25 25 26 26 24 25 24 10 10 11 B 25 25 26 26 24 23 24 10 10 11 C 25 25 24 24 26 27 26 9 9 8 D 25 25 24 24 26 25 26 9 9 8 E 31 31 31 F 2 gt 31 31 31 VT 13 13 13 13 10 10 10 11 11 11 NRA H BARICENTRO Gx Gy DISTRIBUCI N PESOS SOBRE LOS APOYOS 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 H Kg l E 1690 1750 1880 2050 2105 2318 HD Kg 1700 1910 1894 2068 2123 2336 Gx mm 1500 15
75. 5 50 5 51 0 52 0 54 0 54 0 DIMENSIONES para todos los equipamientos Altura mm 1875 1875 1875 1875 1875 1875 Longitud mm 1100 1100 1100 1100 1100 1100 Longitud mm 2950 2950 2950 2950 2950 4275 PESO en vac o versiones sin acumulador ni bombas kg 910 935 1010 1105 1205 1560 49 50 ol 3 DATOS T CNICOS VERSIONES ALTA EFICACIA A Potencia de refrigeraci n kW 53 62 71 82 98 107 125 142 166 185 Potencia absorbida total kW 18 21 24 28 34 38 46 53 58 5 64 Caudal agua evaporador Vn 9120 1066 1238 1410 1680 1840 2150 2600 2850 3182 P rdida carga evaporador kPa 40 35 5 36 5 50 33 5 27 37 37 44 47 INDICES ENERG TICOS EER W W 2 94 2 95 2 96 2 98 2674 2 83 2372 2 70 2 84 2 89 ESEER W W 3 57 3 58 2 83 3 61 3 51 3 48 3 81 3 80 3 98 DATOS EL CTRICOS Alimentaci n A 3N 400 V 50Hz Corriente absorbida total A 36 2 41 6 45 4 54 61 7 68 7 84 5 96 7 103 6 115 5 Corriente m xima A 65 68 71 77 98 104 133 148 148 160 Corriente de arranque A 155 161 166 209 215 222 239 253 260 314 RESISTENCIA COMPRESORES Tipo scroll scroll scroll scroll scroll scroll scroll scroll scroll scroll N mero n 2 2 2 2 3 3 4 4 4 4 N mero por circuito n n 2 2 2 2 2 2 2 2 3 2 3 2 4 2 4 2 4 2 4 2 Resistencia c rter compresores n W 2x75 2x75 2x75 2x75 3x75 13x75 4x75 4x75 4x75 2x75 2x130 Tipo Axial Axial Axial Axial Axial A
76. 550 550 550 550 NRA L BARICENTRO Gx e Gy PESOS L Kg 779 805 820 900 1150 1200 1320 1485 535 1740 LD Kg 782 813 829 909 1160 1212 1334 1503 553 1758 LT Kg 820 859 883 963 1245 1295 1425 1610 660 1865 Gx mm 1030 1020 1010 995 1290 __ 1290 1280 __ 1430 400 1510 Gy mm 550 550 550 550 560 580 550 550 550 550 NRA H BARICENTRO Gx e Gy PESOS Kg H Kg 1190 1250 1380 1550 1605 1818 Kg HD Kg 1200 1410 1394 1568 1623 1836 Gx mm 1270 1280 1270 1540 1510 1510 Gy mm gt E 540 520 550 550 550 550 NRA HL BARICENTRO Gx e Gy PESOS Kg HL Kg 875 900 920 1110 1200 1260 1390 1560 1615 1818 Kg HLD Kg 882 903 929 1019 1209 1270 1402 1574 1633 1836 Gx mm 1150 1140 1125 1120 1270 1280 1270 1540 1510 1510 Gy mm 550 550 550 550 540 520 550 550 550 550 20 DISTRIBUCI N PESOS PORCENTAJE SOBRE APOYO e A d Mod 1 versions A mm B mm 9 LL B Je 275 L A C 2450 2050 i o i 300 L A C 2450 2050 _ 162 325 L A C 2450 2050 o 350 LUC 2450 2050 x j Si Ri il 275 HL 2950 2550 y v 300 HL 2950 2550 i 325 HL 2950 255
77. 660 798 780 758 714 666 600 50 8 0350 770 45 0 66 0 791 777617 Pes We 670 598 _ 49 6 0500 740 142 0 61 0 772 72 3 701 69 0 _ 66 8 623 _ 53 8 0550 745 425 620 789 731 70 7 694 671 62 6 _ 54 0 0600 755 435 630 809 741 718 702 675 621 54 5 0650 760 440 620 811 73 7 729 713 68 2 620 543 0700 77 0 45 0 630 820 765 746 723 168 3 621 53 8 0750 79 0 470 65 0 82 765 773 _ 74 3 666 697 61 Niveles sonoros totales Banda de octava Hz gt Pot Pressione 125 250 500 1000 2000 4000 8000 H dB A dB A dB P E z otencia sonora para frecuencia central de banda dB 10m 1m 0275 0300 0325 0350 0500 83 0 510 700 835 8413 778 777 765 735 659 0550 835 515 710 834 819 793 781 769 732 63 5 0600 845 525 720 848 845 808 795 772 72 7 64 5 0650 85 0 530 710 855 852 808 803 776 729 652 0700 865 545 730 871 85 9 823 818 794 _ 74 6 66 3 0750 87 0 55 0 730 871 85 9 82 9 821 793 756 672 Niveles sonoros totales Banda de octava Hz Pot Pressione _ 125 250 500 1000 2000 4000 8000 HL ES Potenci f ia central de banda dB AG dias otencia sonora para frecuencia cen dB 0275 76 0 440 680 766 765 735 715 663 615 51 0300 76 0
78. 68 3 621 53 8 0750 79 47 0 65 0 82 76 5 773 743 666 69 7 61 Total sound levels Octave band Hz Pow Press 125 250 500 1000 2000 4000 8000 C asa dBA dB Acoustic power by central band frequency dB 10m 1m a iS 0275 0300 0325 0350 0500 825 505 700 184 2 78 6 775 772 76 3 732 164 3 0550 825 505 700 841 784 779 776 765 712 623 0600 83 0 510 700 856 788 784 780 770 721 63 0 0650 840 52 0 710 867 807 795 785 778 739 635 0700 840 520 700 838 799 797 795 774 729 64 7 0750 840 52 0 71 0 1828 799 80 7 80 77 2 74 3 66 Total sound levels Octave band Hz Pow Press 125 250 500 1000 2000 4000 8000 CL dB A dB A dB A l coustic power by central band frequency dB 10m 1m 0275 760 440 65 0 772 770 741 712 661 59 2 _ 49 5 0300 760 440 650 1776 749 745 171 5 66 59 7 49 7 0325 770 450 660 798 780 758 714 666 600 50 8 0350 77 0 45 0 66 0 791 UB Pes We 670 598 49 6 0500 740 42 0 61 0 772 723 701 690 668 623 _ 53 8 0550 745 425 620 789 731 70 7 694 671 62 6 _ 54 0 0600 755 435 630 809 741 718 702 675 621 54 5 0650 760 440 620 811 73 7 729 713 68 2 620 543 0700 77 0 45 0 630 820 765 746 723 168 3 621 53 8 0750 79 0 470 65 0 82 765 773 _ 74 3 666 697 61 30 _ Total sound levels Oc
79. EIGHT versions without accumulation and pumps kg 725 750 770 860 1040 1100 1210 1380 1435 1638 ol 7 TECHNICAL DATA VERSION C Cooling capacity kw 105 112 133 148 178 190 Total input power kW 33 36 44 50 5 56 65 EER W W 2 7 2 7 2 7 2 7 2 7 29 ESEER W W ELECTRICAL DATA Fuel feed A 3N 400 V 50Hz Total input current only COOLING A 60 2 66 6 82 2 94 2 103 9 116 Maximum current A 98 104 133 145 145 160 Peak current A 215 222 239 250 257 314 Type Scroll Scroll Scroll Scroll Scroll Scroll Number n 3 3 4 4 4 4 Number per circuit GEZ E 3 2 3 2 4 2 4 2 4 2 4 2 Compressor carter heater n W 3x75 3x75 4x75 4x75 4x75 2x795 2x 130 Type Axial Axial Axial Axial Axial Axial Number n 2 2 2 3 3 3 Input current ventilation unit A 5 B 5 5 75 Input power ventilation unit kW 2 8 2 8 2 8 2 8 4 2 Air flow rate m3 h 39200 38500 38700 38700 60900 56000 Sound Power dB A 82 5 82 5 83 0 84 0 84 0 84 0 Sound pressure 1 dB A 50 5 50 5 51 0 52 0 52 0 52 0 DIMENSIONS for all versions Height mm 1875 1875 1875 1875 1875 1875 Width mm 1100 1100 1100 1100 1100 1100 Length mm 2950 2950 2950 3950 3950 4275 EMPTY WEIGHT versions without accumulation and
80. MBER COMPLIANCE DECLARATION We the undersigned declare on our own exclusive responsibility that the object in question so defined Product identification AIR WATER chiller HEAT PUMP NRA RANGE is in compliance with 1 Directive 97 23 EC and has been subjected with reference to Attachment Il of the said directive to the following compliance evaluation procedure module H with checks made via inspections by the appointed body CEC via Pisacane 46 Legnano MI Itally identity number 1131 2 Designed produced and marketed in observance of the following technical specifications Harmonised standards EN 378 Refrigerating system and heat pumps Safety and environmental requirements EN 12735 Copper and copper alloys Seamless round copper tubes for air conditioning and refrigeration UNI 1285 68 Calculation of the strength of metal pipes subject to internal pressure 3 Designed produced and marketed in observance of the following EC directives 98 37 EC Machine Directive 2006 95 CE LVD Bevilacqua 26 03 2007 Marketing Director Signature qa This manual This manual and the electrical layouts supplied with the unit must be kept in a dry place for any future consultation and for the lifespan of the machine has been drawn up with the aim of supporting the correct installation of the unit and providing all the indications for the corr
81. Motocondensador base modelo de mo tocondensador Las dimensiones 275 300 325 y 350 se encuentran disponi bles nicamente en el modelo con silen ciador CL Motocondensador con silenciador Las motocondensadoras NRA C no prev n los modelos HC bomba de calor motocon densadora HA motocondensador de alta temperatura YC para baja temperatura del agua producida TC motocondensadores con recuperaci n total motocondensadores con acumulaci n Version Y con producci n de agua a 6 C se encuentra disponible s lo el modelo YA alta temperatura con producci n de agua a 6 C para la configuraci n de todos los dem s modelos Y se recomienda consultar la sede Nota Para los aparatos destinados a fun cionar con baja temperatura del aire in cluso las bombas de calor antes de cada puesta en servicio de la unidad o al finali zar cada periodo de pausa prolongada es de especial importancia que el aceite del c rter compresor haya sido calentado previamente mediante alimentaci n de las correspondientes resistencias el ctricas por un lapso de tiempo de 8 horas por lo menos La resistencia c rter se alimenta autom ticamente con la parada de la uni dad siempre que la unidad sea mantenida bajo tensi n TODOS LOS APARATOS EST N EQUIPADOS DE SERIE 1 resistencia el ctrica anticongelante eva porador 2 resistencia c rter compresor panel de mando a distancia filtro de agua fluj stato
82. SEFUL PRESSURE CONTACT THE ESTABLISHMENT If there should be two pumps in the configuration selected remember always 1 functions and the other is reserve and switch over is electro nic managed by the internal board 11 EFFECTIVE PRESSURE FOR THE SYSTEM 111 LOW PRESSURE PUMPS kPa 250 200 150 100 So 700 275 325 550 350 NA 600 650 50 8 300 500 10 20 30 40 50 Water flow rate x 1000 1 h 11 2 HIGH PRESSURE PUMPS kPa 350 300 250 200 150 700 100 650 600 50 550 275 750 0 300 325 500 0 10 20 350 30 40 50 60 Water flow rate x 1000 1 h 25 26 The heating capacity that can be obtai ned from the desuperheater is calcula ted by multiplying the rated value Pd indicated in the table below the dia grams by a suitable coefficient Cd The diagrams allow t
83. STANDARD T representa la configura ci n m s econ mica obtenida calibrando los cambiadores con paquete aleteado para permitir un correcto funcionamiento del enfriador con temperaturas del aire externo no superiores a 42 C BOMBA DE CALOR BASE H en enfria miento los limitesoperativos llegan hasta una temperatura m xima del aire externo de 46 C Las dimensiones 275 300 325 y 350 se encuentran disponibles nica mente en modelo silencioso NRAH no prev n las siguientes configuracio nes YH bomba de calor con agua producida infe rior a 4 C HC bomba de calor motocondensadora HA bomba de calor en modelo alta tempera tura HT pompa di calore con recupero totale 2 2 VERSIONI DISPONIBILI ESTANDARD BASE representa la configuraci n m s econ 2 2 1 Dotazioni di serie 2 DESCRIPCI N Y ELECCI N DE LA UNIDAD mica obtenida calibrando los cambiadores con paquete aleteado para permitir un correcto funcionamiento del enfriador con temperaturas del aire externo no superio res a 42 C NOTA NRA con producci n de agua a 6 C se en cuentra disponible s lo el modelo YA alta temperatura con producci n de agua a 6 C para la configuraci n de todos los dem s mo delos Y se recomienda consultar la sede ALTA TEMPERATURA s lo model fr o permite mediante la ampliaci n del cam biador con paquete aleteado de extender los l mites operativos llegando hasta una temperat
84. ag 9 Pressure A NN pag 10 AU tados pag 11 Effective pressures for the system pag 12 DesuperhGatenss EE pag 13 leie CN e E EEN pag 14 gt REE AAN ge pag A O pag 16 Capacity Control Pag 17 Calibration of check and Safety parameters pag VI BR en le pag 19 Weights and centres of MAS a ei ii A E A ri pag 20 Distribution weights percentage on rests for models WITH WATER pag INSTRUCTIONS FOR THE SELECTION N 0 0 01 01 O 01 oO D mw 10 11 12 13 14 15 16 16 19 EN 23 24 25 26 27 29 30 32 33 34 36 38 Dear Customer Thank you for choosing AERMEC It is the fruit of many years of experience and special design studies and has been made of the highest grade materials and with cutting edge technology In addition all our products bear the EC mark indicating that they meet the requirements of the European Machine Directive regarding safety The standard of quality is permanently being monitored and AERMEC products are therefore a synonym for Safety Quality and Reliability the obligation for any notice thereof The data may undergo modifications considered necessary for the improvement of the product at any time and without Thank you again AERMEC S p A AERMEC S p A 137040 Bevilacqua VR Italia Via Roma 44 Tel 39 0442 633111 per il clima Telefax 0442 93730 39 0442 93566 www aermec com info aermec com MODEL SERIAL NU
85. atching Modem Enablig Operation El dispositivo ROMEO Remote Overwatching Modem Enablig Operation permite el control remoto del chiller desde un normal tel fono m vil dotado de brow ser WAP as como enviar SMS de alarma o prealarma hasta 3 m viles GSM aunque calor Permite visualizar en el display de la tarje ta de microprocesador el valor de la pre si n de aspiraci n del compresor uno por cada circuito Colocado en el lado de baja presi n del circuito frigor fico detiene el funcionamiento del compresor en caso de presiones de trabajo an malas TP2 Transductor de alta presi n De serie en las dimensiones 500 550 600 650 700 y 750 en todos los mode los con bomba de calor Permite visualizar en el display de la tarjeta de micropro cesador el valor de la presi n de empuje del compresor uno por cada circuito no est n dotados de browser WAP TP1 Transductor de baja presi n de serie en los modelos con bomba de Colocado en el lado de alta presi n del cir cuito frigor fico detiene el funcionamiento del compresor en caso de presiones de trabajo an malas DRE Dispositivo reduccion corriente de arranque Permite la reducci n de la corriente de ar ranque necesaria por la m quina en la fase de puesta en marcha Aplicable s lo en f brica RIF Reponedor en fase de corriente Conectado en paralelo al motor permite una reducci n de la corriente absorbida S lo puede insta larse durante
86. ater for use in bathrooms or other purposes 1 Desuperheater D The desuperheater is also available for heat pump versions limitedly in the co oling function lt must be intercepted in the heating function 2 Total heat recovery T In heat pumps total recovery is only available for the OO versions without hydronic kit CONDENSING UNITS C SILENCED CONDENSING UNITS LC VERSION Y is the version that allows you to produce chilled water below the standard value of 4 C to a minimum of 6 C For lower values contact the company headquarters ONLY THE VERSION YA IS AVAILABLE WARNING For the devices designed to work with a low air temperature and also the heat pumps before starting up the unit or at the end of each period of prolonged disuse it is extremely important for the oil of the compressor carter to be heated beforehand via the power supply to the special heaters for at least 8 hours The carter heater is automatically powered when the unit stops provided that the unit is kept under tension 2 3 CONFIGURATORE 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 NRA 0750 field 8 field 4 5 6 7 o o L o o o 00 field 15 16 field 14 field 13 field 12 field 11 field 10 field 9 00 Without accumulation 01 Accumulation and low pressure pump 02 Accumulation low pressure pump and reserve pump 0
87. atic profile 3 The total number of hours With this data every consultant or designer will be able to his or her evaluations ESEER 3xEER100 33xEER75 41xEER50 23xEER25 100 Acqua uscita e vaporatore AT a pieno carico Carico Temperatura aria esterna 7 C 5 C 25 20 C 100 75 50 35 C 30 C 25 C ol 2 TECHNICAL DATA STANDARD VERSIONS Cooling capacity kw 94 103 120 138 153 180 Total input power kw S A S 36 5 41 48 5 53 5 62 68 Evaporator water flow rate Vh 16170 17720 20640 23740 26320 30960 Evaporator pressure drop kPa S S 31 25 5 34 3 36 2 361 44 ENERGY INDICES EER W W 2 6 2 5 2 5 2 6 2 5 ESEER W W 3 16 3 09 3 47 3 60 3 48 ELECTRICAL DATA Fuel feed A 3N 400 V 50Hz Total input power A 65 72 874 975 108 120 5 Maximum current A 98 104 133 145 145 160 Peak current A 215 222 239 250 257 314 Type scroll scroll scroll scroll scroll scroll Number n 3 3 4 4 4 4 Number per circuit n n 3 2 3 2 4 2 4 2 4 2 4 2 COMPRESSOR HEATER Compressor carter heater 3x75 3x75 4 x 75 4 x 75 4 x 75 2x75 Type assiale assiale assiale assiale assiale assiale assiale assiale assiale assiale Number n S E 2 2 2 2 2 3 Input current ventilation unit A 47 47
88. carga bombas visualizaci n de los siguientes par metros temperatura entrada agua temperatura entrada agua evapora dor temperatura salida agua delta T alta presi n baja presi n tiempo espera de rearranque visualizaci n de alarmas e configuraciones set a sin contrase a set fr o diferencial total b con contrase a set anticongelan te tiempo exclusi n baja presi n lenguaje display c digo de acceso para atenuar las vibraciones producidas durante el funcionamiento por el grupo de ventilaci n y los compresores DCPX Dispositivo para bajas tempera turas con NRA L NRA D Dispositivo baja temperatura para un cor recto funcionamiento en enfriamiento bajo lo 20 C solo para modelos Base y Alta Temperatura Est constituido por una tarjeta electr nica de regulaci n que var a el n mero de vueltas de los ventiladores en base a la presi n de condensaci n le da por el transductor de alta presi n con el objeto de mantenerla suficientemente alta GP Rejilla de protecci n Cada kit comprende dos rejillas se deber n usar dos o tres kit seg n los modelos La utilizaci n del kit protege de choques casuales la bater a externa PGS Peque a ficha por insertar en la tarjeta electr nica de la unidad Permite progra mar dos franjas horarias al d a dos ciclos de encendido y de apagado y de tener programaciones diferenciadas por cada d a de la semana ROMEO Remote Overw
89. carse directamente a los datos obtenidos para el funcionamiento sin glicol El factor de correcci n del caudal del agua se calcula con el objetivo de mantener el mismo At que se tendr a sin glicol Elfactor de correcci n de la p rdida de carga ya tiene en cuenta el diferente caudal que se deriva de la aplicaci n del factor de correcci n del caudal del agua Notas Para facilitar la lectura del gr fico en la p gina siguiente se muestra un ejemplo Utilizando el siguiente diagrama es posible establecer el porcentaje de glicol necesario dicho porcentaje es calculable tomando en consideraci n uno de los siguientes factores En funci n al fluido considerado agua O aire se debe acceder al gr fico por FcGDpF a FcGDpF b FcGDpF c FCGDpF d FcGDpF e FcGQF FcGQ dC FcG f dC o 2 5 b D E c o ei 2 B u emperatura acqua prodotta C Ed Temperatura aria esterna C la parte derecha o izquierda por la intersecci n de las redes temperatura externa o temperatura agua producida y las curvas correspondientes se obtiene un punto a trav s del cual debe pasar la l nea vertical que representa tanto el porcentaje de glicol como los coeficien
90. cias aqu indicadas son al neto de las p rdidas de carga de intercambiadores filtro acumulador y paralelo hidr ulico por lo tanto se deben considerar TILES PARA LA INSTALACI N NOTA LAS PREVALENCIAS SE CALCULAN EN FR O CON AT 5 C PARA AT INFERIORES CONT CTESE CON LA SEDE EN PRESENCIA DE GLICOL POR LA PREVALENCIA TIL PARA LA INSTALACI N CONT CTESE CON LA SEDE Si en la configuraci n escogida exi sten dos bombas se recuerda que siempre funciona una y la otra es de reserva la conmutaci n es electr nica controlada por la tarjeta inter na 11 PREVALENCIAS TILES PARA LA INSTALACION 111 OMBAS BAJA PREVALENCIA kPa 250 200 150 100 So 700 275 325 550 350 NA 600 650 50 8 300 500 10 20 30 40 50 Caudal de agua x 1000 I h 11 2 BOMBAS ALTA PREVALENCIA kPa 350 300
91. co 1 Ce Circuito frigor fico 2 Si el evaporador esta colocado mas abajo del condensador en la linea aspirante se deber n prever sifones 0 5 Z reg para favorecer el arrastre del aceite J ATTS EVARORATEUR hacia el compresor Por longitud de las limeas se entiende la distancia entre las unidades medidas en la linea del liquido Para ulteriores informaciones consultar la sede 69 70 Potencia sonora Aermec determina el valor de la potencia sonora en base a las medidas efectuadas de acuerdo con la normativa 9614 en conformidad con lo requerido por la certifi caci n Eurovent 1 Presi n sonora Presi n sonora en campo libre sobre plano reflectante factor de direccionalidad Q 2 a 10 m de distancia de la superficie exter na de la unidad con el m todo del paralelo expandido box method ISO 3744 NOTA Condiciones de funcionamiento Agua evaporador in out 12 7 C Aire condensador 35 C NOTA Los datos de las versiones H HL se calculan en frio para el funcionamien to en caliente tome como referencia la version H 15 DATOS SONOROS Niveles sonoros totales Banda de octava Hz Pot Pressione 125 250 500 1000 2000 4000 8000 O anta dB A dB Potenci f i I de ba
92. compruebe que la unidad est apagada generando la correspondiente alarma Despu s de esta operaci n vuelva a llevar el set antihielo a su valor original _ itttiz kbgt l MZiO iiiilypg78oc Vl V te i i _ 73 18 DIMENSIONES NRA 275 300 325 350 versions A L C HL 74 A B C Mod versions mm _ mm mm 275 L A C 1100 2450 1606 300 L A C 1100 2450 1606 325 L A C 1100 2450 1606 350 L C 1100 2450 1606 275 HL 1100 2950 1606 300 HL 1100 2950 1606 325 HL 1100 2950 1606 350 A HL 1100 2950 1606 entrada alimentaci n el ctrica disponible a la derecha y a la izquierda s1 1 Lo 4 A E Mod Minimum technical space mm s1 s2 S3 s4 clearance 800 800 800 1100 3000 NRA 0500 0550 600 650 700 Mod versions A mm B mm C mm 500 A L C LC H HL
93. d when the order is placed MOD _ ROMEO _ TP1 TP2 DRE AER485 PGS GP DCPX RIF VT VERSIONI STANDARD S a Ca 0275 0300 0325 0350 0500 x2 Std 500 2 x2 38 63 4 10 0550 s x2 Std 550 2 x2 38 63 4 10 0600 gt e x2 Std 600 2 x2 38 64 4 10 0650 s x2 Std 650 2 x2 38 64 4 11 0700 x2 Std 650 2 x2 38 64 4 11 0750 s x2 Std 750 2 x3 38 64 4 11 NRA POMPA DI CALORE H 0275 0300 0325 0350 0500 gt Std Std 500 2 x2 38 63 4 10 0550 Std Std 550 2 x2 38 63 4 10 0600 gt Std Std 600 2 x2 38 64 4 10 0650 Std Std 650 2 x3 38 64 4 11 0700 Std Std 650 2 x3 38 64 4 11 0750 Std Std 750 2 x3 38 64 4 11 NRAL 0275 x2 x2 275 3 16 62 12 13 0300 s x2 x2 300 3 16 62 12 3 0325 x2 x2 325 3 16 62 12 13 0350 x2 e x2 325 3 16 82 12 3 0500 e x2 di serie 500 N 2 x2 Std 63 4 10 0550 s x2 Std 550 2 x2 Std 63 4 0 0600 gt e x2 Std 600 2 x2 Std 64 4 10 0650 s x2 Std 650 2 x3 Std 64 4 4 0700 x2 Std
94. e percentage of glycol and the relative correction coefficients will have to pass 81 HOW TO READ THE GLYCOL CURVES The curves shown in the figure summarise a notable quantity of data each of which is represented by a specific curve In order to use these curves correctly it is necessary to make some initial considerations If you want to calculate the percentage of glycol on the basis of the outside air temperature you must enter from the left hand axis and once you have intersected the curve trace a vertical line which in turn will intercept all the other curves the points obtained from the upper curves represent Correction factor of the cooling capacity Correction factor of the input power Correction factor of the pressure drops evaporator average temp 3 5 C DpF b Correction factor of the pressure drops average temp 0 5 C DpF c Correction factor of the pressure drops average temp 5 5 C DpF d Correction factor of the pressure drops average temp 9 5 C DpF e Correction factor of the pressure drops average temp 47 5 C Correction factor of the outputs evaporator average temp 9 5 C Correction factor of the outputs condenser average temp 475 C NOTE Although the graph reaches outside air temperatures of 40 C it is necessary to maintain the machine s operating limits as reference 21 22 the coefficients for the correction
95. e piastre piastre piastre piastre piastre piastre piastre piastre piastre piastre Number n 1 1 1 1 1 1 1 1 1 1 HYDRAULIC CIRCUIT Water Tank 500 500 500 500 500 500 500 500 500 500 Accumulation anti freeze heater _ n xkw 300 300 300 300 300 300 300 300 300 300 PLUMBING CONNECTIONS STANDARD VERSIONS hydraulic parallel not supplied Hydraulic connections V 2 2 2 2 2 2 EW 2 1 2 2 1 2 2 1 2 Input power kW 0 75 0 75 0 75 0 75 11 11 14 1 5 1 85 3 Input current A 1 85 1 85 1 85 214 214 214 214 2 92 3 60 6 4 Useful pressure pumping kPa 122 126 113 gil 112 103 59 76 83 80 HIGH PRESSURE PUMPING UNIT Input power kw 11 11 1 5 1 5 1 8 1 8 3 7 3 7 3 7 5 5 Input current A 214 214 2 92 2192 3 60 3 60 7 21 721 7 21 11 3 Useful pressure pumping kPa 172 162 161 145 180 179 171 158 133 195 SOUND DATA Sounud Power dB A 76 0 76 0 770 770 82 5 82 5 83 0 84 0 84 0 84 5 Sound pressure 1 dB A 44 0 44 0 45 0 45 0 50 5 50 5 51 0 52 0 52 0 52 0 DIMENSIONS for all versions Height mm 1606 1606 1606 1606 1875 1875 1875 1875 1875 1875 Width mm 1100 1100 1100 1100 1100 1100 1100 1100 1100 1100 Length mm 2450 2450 2450 2950 2950 2950 2950 2950 3950 4275 EMPTY WEIGHT versions without accumulation and pumps
96. e refieren a una 140 temperatura media del agua de 50 C La siguiente tabla presenta 120 la correcci n que se debe aplicar a las p rdidas de carga a medida que 100 I cambia la temperatura media del I agua 80 5 2 60 e 2 40 5 20 8 ge c 6 0 a O 10 20 30 40 50 60 70 Caudal agua m3 h Temperatura media agua C 5 10 15 20 30 40 50 Coeficiente multiplicativo 1 22 110 1 08 1 06 1 04 1 02 1 9 3 P RDIDAS DE CARGA ka ag FILTRO AGUA 20 2 1 2 10 D O 10 20 30 Caudal agua m3 h 64 Los modelos con acumulaci n prev n diversas preparaciones que var an en base altura til de descarga que se desea obtener con las caracter sticas del grupo de bombeo y la existencia o no de orificios para resistencia integrativa En las siguientes tablas se evidencian las caracter sticas principales de los componentes del circuito hidr ulico mientras que los gr ficos de estas p ginas indican las correspondientes prevalencias Los tanques de acumulaci n con orificios para resistencia el ctrica se encuentran provistos de tapones de pl stico de cierre provisorio ATENCI N Antes de la puesta en marcha el encargado de la instalaci n deber proceder al montaje de las resistencias el ctricas Si tales resistencias no fueran necesarias de inmediato los tapones en pl stico deber n ser sustituidos con oportunos tapones de metal 101 CONTENIDO M XIMO de agua de la instalaci n En la tabla que sigue se e
97. ect use and maintenance of the device Before proceeding with the installation please read all the information in the manual carefully as well as the procedures necessary for the correct installation and use of the unit Becarefultoadheretotheinstructions in this manual and observe the safety regulations currently in place The device must be installed in compliance with the local legislation currently in force in the country of destination Non authorised tampering with the equipment whether electrical or mechanical will make THE WARRANTY VOID and exclude any liability on the part of the company Check the electrical characteristics shown on the registration plate fig1 before making the electrical connections Read the instructions in the specific section about electrical connections 11 Technical plate 1 GENERAL STANDARDS e If the unit needs to be repaired in all Cases contact a specialised AERMEC After Sales Service centre and only use OEM spare parts e The manufacturer furthermore declines any liability for injury to persons or damage to things resulting from the failure to comply with the information in this manual Permitted uses this series of chillers is suitable for producing cold water to use in hydronic systems designed for air conditioning The units are not suitable for producing hot water for bathrooms Any use other than that permitted or outside the operating limits menti
98. ed measured using the common criteria with reference to the additional volume of water From the following tables it is possible to obtain the values of maximum system content also for other operational conditions with glycol water The values are obtained by multiplying the reference value by the correction coefficient 10 11 Calibration of expansion tank The standard value of pre charge pressure of the two expansion tanks is 1 5 bar while their volume is 24 litres maximum value 6 bar The calibration of the tanks must be regulated on the basis of the maximum difference of level H of the user see figure according to the formula p calibration bar H m 10 2 0 3 For example if the level difference H is 20m the calibration value of the tank will be 2 3 bar If the calibration value obtained from the calculation is lower than 1 5 bar i e for H lt 12 25 maintain the standard calibration 10 ACCUMULATION Hydraulic height Hm 30 25 20 15 2 12 25 Expansion tank calibration bar 3 2 2 8 2 3 1 8 1 5 Reference value water content 100 2174 26646 3118 3590 3852 Reference value water content Il 978 1190 1404 1616 1732 Reference value water content 1 3 510 622 732 844 904 Glycole mix Water temperature C Correction Reference factor condition max min 10 40 2 0 507 1 10 60 2 0 686 2 10 85 2 0 8
99. erativos de la m quina 61 62 curvas superiores representan los coeficientes para la correcci n de la potencia de refrigeraci n y absorbida para los env os y las p rdidas de carga se recuerda que dichos coeficientes se deben multiplicar por el valor nominal del tama o en consideraci n mientras que el eje inferior aconseja el valor porcentual de glicol necesario en funci n a la temperatura del aire externo considerado Si se desea calcular el porcentaje de glicol en base a la temperatura del agua producida se deber entrar desde el eje derecho y una vez intersecada la curva debe trazarse una l nea vertical que interceptar a su vez las otras curvas Los puntos obtenidos de las curvas superiores representan los coeficientes para la potencia de refrigeraci n y absorbida para los env os y las p rdidas de carga se recuerda que dichos coeficientes se deben multiplicar por el valor nominal del tama o en consideraci n mientras que el eje inferior aconseja el valor porcentual de glicol necesario para producir agua a la temperatura deseada Recordamos que los tama os iniciales TEMPERATURAS EXTERIORES y TEMPERATURA AGUA PRODUCIDA no est n directamente relacionados entre s as que no es posible entrar en la curva de uno de estos tama os y obtener el correspondiente punto en otra curva FCGDprF a FCGDpr b FCGDprF c FoGDpF d
100. eratura aire externo b s 7 C b u 6 C At 5 C Potencia sonora Aermec determina el valor de la potencia sono ra en base a las medidas efectuadas de acuerdo con la normativa 9614 en conformidad con lo requerido por la certificaci n Eurovent 1 Presi n sonora Presi n sonora en campo libre sobre plano reflectante factor de direccionalidad Q 2 a 10 m de distancia de la superficie externa de la unidad con el m todo del paralelo expandido saria 5 DATOS T CNICOS C a con acumulaci n box method ISO 3744 NOTA Los datos del ruido se refieren a la configura cidn sin bomba Para las bombas de calor el dato se refiere al funcionamiento durante el enfriamiento ES E E R La atenci n hacia los consumos el ctricos de las m quinas para el acondicionamiento es cada vez m s importante tambi n en Europa En Estados Unidos desde hace muchos a os no se hace referencia a la sola eficiencia en condiciones de proyecto sino que se utiliza un ndice de evalua ci n que toma en cuenta el marginal funciona miento de la unidad en condiciones de proyecto y el mayor uso con cargas parciales con aire externo inferior al de proyecto y en condiciones de parcializaci n de los compresores En Europa se ha adoptado la propuesta EECCAC Energy Efficiency and Certification of Central Air Conditioner y ESEER European Seasonal Energy Efficiency Ratio para poder comparar las enfriadoras entre s Despu s de
101. f the pump to keep the number of working hours even Flow switch Supplied as a standard acces sory Has the job of checking the circulation of water If there is no circulation it blocks the unit Water filter Supplied as a standard acces sory Allows any impurities in the hydraulic cir cuits to be collected and eliminated Inte rior houses a filter mesh with holes not exceeding one millimetre lt is essential to prevent serious damage to the plate heat exchanger Storage tank Steel tank with 500 litre capacity To redu ce heat loss and eliminate the formation of condensation it is insulated with layer of polyurethane material of adequate thickness Equipped as standard with an electric an tifreeze heater controlled by the antifreeze sensor located in the tank Bleed valve version with storage tank Automatic valve fitted in upper section of tank Discharges residual air present in tank lt is intercepted by a tap to facilitate Filling assembly version with storage tank Features pressure gauge for measuring sy stem pressure values Expansion vessel version with storage tank Diaphragm type pre charged with nitrogen Hydraulic circuit safety valve Set to 6 Bar with ductable discharge it in tervenes to discharge excess pressure if the pressure level rises above normal 3 4 SAFETY AND CONTROL DEVICES Low pressure switch Not included in the heat pump version Fixed setting located on the l
102. haber calculado la energ a total requerida por la instalaci n durante la gesti n estival kWh se pueden deducir los consumos de energ a el ctri ca de la temporada con esta f rmula Energ a absorbida Energ a requerida _ ndice de eficiencia El c lculo energ tico real puede obtenerse m s correctamente considerando 1 perfil de carga con temperatura externa 2 perfil climatico 3 Total de horas Con estos datos cada asesor o proyectista puede realizar sus propias evaluaciones ESEER 3xEER100 33xEER75 41xEER50 23xEER25 100 Acqua uscita evaporatore AT a pieno carico Carico Temperatura aria esterna 7 C 5 C 100 75 50 25 35 C 30 C 25 C 20 C ol 2 DATI TECNICI VERSIONI STANDARD Potencia de refrigeraci n kw 94 103 120 138 153 180 Potencia absorbida total kw a S 36 5 41 48 5 53 5 62 68 Caudal agua evaporador Vh 16170 17720 20640 23740 26320 30960 P rdida carga evaporador kPa S S 31 25 5 34 3 36 2 361 44 INDICES ENERG TICOS EER W W 2 6 2 5 2 5 2 6 2 5 27 ESEER W W 316 3 09 3 47 3 60 3 48 DATOS EL CTRICOS Alimentaci n A 3N 400 V 50Hz Corriente absorbida total A 65 72 874 975 108 120 5 Corriente m xima A 98 104 133 145 145 160 Corriente de arranque A i i i 215 222 239 250 257 314 COMPRESORES Tipo scroll scroll scroll scroll scroll scroll N me
103. he correction coefficients to be used for the various versions of chiller to be calculated the external air temperature referred to is indicated in correspondence with each curve The pressure drops you see in the table do not include the filter drop whose curve is indicated in table TAV The nominal value refers to air temperature produced water temperature 35 C 50 C NOTE in the models with heat pump the desu perheater must be intercepted when the heat pump is operating otherwise the guarantee will not be valid For chilled water production at tempe ratures other than 7 C or for evapo ration temperatures other than 5 C use the correction factors in the table provided as well as the ones obtained from the graphs 12 3 PRESSURE DROPS All NRA models with desuperheater are equipped with two desuperhea ters in parallel NOTE The parallel water connections is to be made by the installer Desuperheaters specifications and pressure drop curves are given below For temperatures of produced water other than 50 C multiply the result by the correction factor that can be deter mined from the table at the bottom of the page 12 2 4 The heating capacity available to the total heat recovery is in rated condi tions Air temperature 35 C Water produced 50 C At 5 C 12 DESUPERHEATERS 121 VERSIONI STANDARD VERSIONI ALTA EFFICIENZA 1 5 U vele d
104. he water flow rate and the pressure drops are applied directly to the data obtained for operation without glycols The correction factor of the water flow rate is calculated so as to maintain the same Dt that would be used in the absence of glycols The correction factor of the pressure drop already takes into account the different capacity deriving from the application of the water flow rate correction factor NOTE To make it easier to read the graph an example is given on the next page By using the diagram opposite it possible to establish the percentage of glycol necessary this percentage can be calculated taking into account one of the following factors On the basis of the fluid considered water or air it will be necessary to enter the graph from the right or left side from the intersection of the FcGDpF a FcGDpF b FcGDpF c FcGDpF d FcGDpF e FcGQF FcGQ dC FcG f dC o 2 5 b D E c o ei 2 B u emperatura acqua prodotta C Ed Temperatura aria esterna C outside air temperature or processed water temperature straight lines and the relative curves a point is obtained through which the vertical line that will identify both th
105. ie de enfriadoras en cuesti n es id nea para producir agua fr a a utilizar en instalaciones hidr nicas con finalidad de acondicionamiento Las unidades no son adecuadas para producir agua caliente sanitaria Queda prohibido cualquier uso distinto del permitido o fuera de los l mites de funcionamiento citados en el manual si antes no ha sido acordado con la empresa La garant a no cubre el pago de los da os causados por una instalaci n defectuosa por parte del instalador La garant a no incluye el pago de da os derivados de un uso inapropiado de la unidad por parte del usuario La casa fabricante no se considera responsable de accidentes que afecten al instalador o al usuario y que deriven de una instalaci n o un uso indebido de la unidad La instalaci n del aparato deber realizarse de manera que sean posibles la reparaci n y o el mantenimiento del mismo La garant a del aparato no cubrir en ning n caso los costes derivados del uso de escaleras autom ticas andamios o cualquier otro sistema de elevaci n necesario para realizar las operaciones cubiertas por la garant a La garant a no es valida en los siguientes casos silos servicios y reparaciones han sido efectuados por personal y empresas no autorizados sila unidad ha sido reparada o modificada anteriormente con piezas de repuesto no originales si no se ha realizado un mantenimiento adec
106. intended as the distance between the units measured on the liquid line For more information consult our head office Sound power Aermec determines the sound power value on the basis of measurements carried out in agreement with 9614 regulations in compliance with that requested by the Eurovent certification 1 Sound pressure Sound pressure in a free field on a reflec ting surface directionality factor Q 2 at 10 mt from the external surface of the unit using the parallel expanded method box method ISO 3744 KEY Functioning conditions Water evaporator in out 12 7 C Air condenser 35 G NOTE The data of the H HL versions are calculated in cold mode and refer to the H version 15 SOUND DATA Total sound levels Octave band Hz Pow Press 125 250 500 1000 2000 4000 8000 O eg dB A dB Acousti b l band f dB A coustic power by central band frequency dB 0275 0300 0325 0350 0500 825 505 700 843 78 6 775 772 763 732 648 0550 825 505 700 828 790 790 784 764 718 629 0600 83 0 510 71 0 86 0 798 785 782 774 734 649 0650 84 0 52 0 71 0 85 2 804 791 782 783 746 65 3
107. is only in cooling Cooling capacity KW 51 59 67 76 87 96 115 130 150 154 Total input power kW 20 22 25 29 37 40 48 53 63 72 Evaporator water flow rate Vh 8800 10200 11500 13100 15000 16500 19800 22400 25800 _ 26500 Evaporator pressure drop kPa 27 39 35 42 26 22 30 31 34 33 ENERGY INDICES EER W W 2 6 2 7 2 7 2 7 24 24 2 4 25 2 4 2 2 COP W W 26 27 2 7 2 7 2 6 2 7 27 2 7 2 6 25 ESEER W W 2 96 31 3 03 3 0 2 75 2 65 3 02 3 06 3 0 Cooling capacity kW 58 68 78 88 102 112 134 155 177 202 Total input power kw 22 26 29 33 39 42 50 57 68 80 Evaporator water flow rate Lh 10000 11700 13400 15100 17500 19300 23100 26700 30400 34700 Evaporator pressure drop kPa 31 42 38 48 33 27 38 41 44 BS Fuel feed A 3N 400 V 50Hz Total input current only COOLING A 39 41 7 48 5 55 7 65 70 85 96 109 123 Corrente assorbita totale HEATING A 42 5 48 8 53 5 60 8 66 0 73 0 85 0 100 112 137 5 Maximum current A 65 68 71 Til 98 104 133 148 148 160 Peak current A 155 161 166 209 215 222 239 253 260 314 Type Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Number n 2 2 2 2 3 3 4 4 4 4 Number per circuit AA IE 2 2 2 2 2 2 3 2 3 2 4 2 4 2 4 2 4 2 Compressor carter heater n W 2x75 2x75 2x75 2x75 3x75 3x75 4x75 4x75 4x75 2x75 2 x 130 Type Axial Axial Axial Axial Axial Axial Axial Axial Axial Axial Number n 6 8 8 8 2 2 2 3 3 3 Input current ventilation uni
108. l Number n a 2 2 2 3 3 Input current ventilation unit A 4 8 4 8 4 8 7 7 Input power ventilation unit kW gt 2 7 2 7 2 7 4 05 4 05 Air flow rate m3 h 39500 39000 38500 60000 60000 60000 Type Plate Plate Plate Plate Plate Plate Number n 1 1 1 1 1 1 Water tank 500 500 500 500 500 500 Accumulation anti freeze heater n x kW 300 300 300 300 300 300 PLUMBING CONNECTIONS STANDARD VERSIONS hydraulic parallel not supplied Hydraulic connections Victaulic 21 2 2 2 2 Va 2 Ia LOW PRESSURE PUMPING UNIT Input power kW 11 11 11 1 5 1 85 3 Input current A 214 214 214 2192 3 60 6 4 Useful pressure pumping SF 128 116 69 80 99 95 HIGH PRESSURE PUMPING UNIT Input power kW 18 1 8 3 7 3 7 3 7 5 5 Input current A 3 60 3 60 721 721 721 11 3 Useful pressure pumping SF 193 187 177 160 142 210 Sound Power dB A 83 0 83 5 84 5 85 0 86 5 870 Sound pressure 1 dB A 51 0 51 5 52 5 53 0 54 5 55 0 DIMENSIONS for all versions Height mm 1875 1875 1875 1875 1875 1875 Width mm 1100 1100 1100 1100 1100 1100 Length mm 2950 2950 2950 3950 3950 4275 EMPTY WEIGHT versions without accumulation and pumps kg 1030 1090 1200 1370 1425 1638 gl 6 TECHNICAL DATA HEAT PUMP VERSIONS HL NOTE Silenced functioning
109. l Sroll N mero n 3 3 4 4 4 4 N mero por circuito n n 3 2 3 2 4 2 4 2 4 2 4 2 Tipo Axial Axial Axial Axial Axial Axial N mero n 2 2 2 2 3 3 Corriente absorbida gr ventilaci n A 4 8 4 8 4 8 7 7 Potencia absorbida gr ventilaci n kW 27 2 7 BA 4 05 4 05 Caudal aire m3 h 39500 39000 38500 60000 60000 60000 EVAPORADORES Tipo Placas Placas Placas Placas Placas Placas N mero n Al 1 al 1 1 1 CIRCUITO HIDR ULICO Acumulador de agua 500 500 500 500 500 500 Resistencia antihielo acumulador n x KW 300 300 300 300 300 300 CONEXIONES HIDR ULICAS paralelo no incluido Conexiones version estandard Victaulic 21 2 2 2 2 2 1 6 21 8 GRUPO BOMBEO BAJA PREVALENCIA Potencia absorbida kW 11 11 11 1 5 1 85 3 Corriente absorbida A 214 214 214 2 92 3 60 6 4 Presi n til SF 128 116 69 80 99 95 GRUPO BOMBEO ALTA PREVALENCIA Potencia absorbida kW 1 8 1 8 3 7 3 7 3 7 5 5 Corriente absorbida A 3 60 3 60 721 7 21 7 21 11 3 Presi n til SF 193 187 177 160 142 210 DATOS SONOROS Potencia sonora dB A 83 0 83 5 84 5 85 0 86 5 870 Presi n sonora 1 dB A 51 0 51 5 52 5 53 0 54 5 55 0 DIMENSIONES para todos los equipamientos Altura mm 1875 1875 1875 1875 1875 1875 Longitud mm 1100 1100 1100 1100 1100 1100 Longitud mm 2950 2950 2950 3950 3950 4275 PESO en
110. l reset es manual y s lo se puede realizar cuando la temperatura desciende por debajo del valor diferencial Para los valores de configuraci n y diferencial consultar el manual t cnico 15 3 2 Presostato de baja presi n El presostato de baja presi n detiene el compresor generando la alarma correspondiente cuando la presi n de env o supera el valor de la configuraci n El control de su correcto funcionamiento puede realizarse despu s de unos 5 minutos de funcionamiento cerrando lentamente el grifo en la tuber a del l quido y manteniendo bajo control el man metro de baja presi n compruebe la intervenci n en correspondencia del valor de calibrado ATENCI N en el caso de una falta de intervenci n inmediatamente el compresor y comprobar las causas El reset es manual y s lo se puede realizar cuando la presi n sube por encima del valor diferencial Para los valores de configuraci n y diferencial consultar el manual t cnico 15 1 3 Control antihielo El control antihielo gestionado por la regulaci n electr nica y por la sonda de temperatura situada a la salida del evaporador tiene la funci n de prevenir la formaci n de hielo cuando el caudal de agua es demasiado bajo El control de su correcto funcionamiento puede hacerse aumentando progresivamente el set antihielo hasta superar la temperatura de salida del agua y manteniendo controlada la temperatura del agua con un term metro de buena precisi n
111. la fase de fabricaci n del pro ducto por lo que debe solicitarse al realizar el pedido MOD _ ROMEO _ TP1 TP2 DRE AER485 PGS GP DCPX RIF VT VERSIONI ESTANDARD S a C a 0275 0300 0325 0350 0500 x2 di serie 500 N 2 x2 38 63 4 10 0550 N e x2 di serie 550 N 2 x2 38 63 4 10 0600 e x2 di serie 600 2 x2 38 64 4 10 0650 x2 di serie 650 e 2 x2 38 64 4 11 0700 e x2 di serie 650 N 2 x2 38 64 4 11 0750 e s x2 di serie 750 N 2 x3 38 64 4 11 NRA BOMBA DE CALOR H 0275 0300 0325 0350 0500 di serie di serie 500 2 x2 38 63 4 10 0550 N di serie di serie 550 N e 2 x2 38 63 4 10 0600 e di serie di serie 600 2 x2 38 64 4 10 0650 di serie di serie 650 N 2 x3 38 64 4 11 0700 di serie di serie 650 N 2 x9 38 64 4 11 0750 N di serie di serie 750 N e 2 x3 38 64 4 11 NRA L 0275 x2 x2 275 3 16 62 12 13 0300 N x2 x2 300 N 3 16 62 12 3 0325 x2 x2 325 3 16 62 12 13 0350 N x2 x2 325 g 3 16 82 12 3 0500 e x2 di serie 500 N 2 x2 di serie 63 4 10 0550 e e x2 di serie 550 N e 2 x2 di serie 63 4 U
112. la oficina t cnica VERSI N versiones Y comercial AERMEC Si la m quina se instala en zonas con mucho viento hay que preparar cortavientos para evitar un funcionamiento inestable del dispositivo DCPX est ndar 35 42 C e alta temperatura 40 46 C e silenciada L 40 46 C Bomba de calor H 40 46 C Temp aire externo b s C LEYENDA 1 Funcionamiento con agua glicolada s lo para versiones YA 2 Funcionamiento con agua glicolada y DCPX Funcionamiento Est ndar Funcionamiento con DCPX 2 0123 45 6 7 8 9 101112131415 Temperatura agua producida C Funcionamiento en calor 55 50 C 45 40 35 30 25 Temperatura agua producida 20 0 5 10 15 Temp aire externo b s C 6 2 DATOS DE PROYECTO 1 S lo para las versiones de bomba de calor VERSI N H en bomba de calor Lado alta Lado baja presi n presi n Presi n m xima admisible bar 30 28 1 22 Temperatura m xima admisible C 120 52 Temperatura minima admisible C 10 16 10 1 71 POTENCIA DE REFRIGERACI N Y ABSORBIDA VERSIONES EST NDAR VERSIONES BOMBA DE CALOR EN FUNCIONAMIENTO EN FR O VERSIONES ALTA TEMPERATURA La potencia de refrigeraci n creada y la potencia absorbida en condiciones di
113. multiplicar el resultado obtenido por el factor de correcci n el cual se puede encontrar en la tabla al final de la p gina 13 1 1 0325 0750 Caudal de agua m3 h NOTE El paralelo hidr ulico est al cuidado lemperatune deltegua i So AD S del instalador Factor correcci n 1 04 1 02 1 Las p rdidas de carga de los diagramas precedentes son relativas a una tem peratura media del agua de 50 C La siguiente tabla indica la correcci n por aplicara las p rdidas de carga al variar de la temperatura media del agua Para los valores de la temperatura del Temperatura del agua C 5 7 9 11 13 15 agua refrigerada producida diversos Factor de correcci n 0 94 1 1 07 113 1 2 1 27 de 7 C o para temperaturas de eva poraci n diversas de 5 C utilizar los Temperatura de evaporaci n C 1 3 5 7 9 11 factores correctivos de la correspon Factor de correcci n 0 88 1094 1 106 113 1 2 diente tabla adem s de los obtenidos por los gr ficos H o Ken SE 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 Total rec capacity kW 66 2 75 8 86 8 99 8 125 5 1374 164 1886 214 5
114. n machine status display compressors ON OFF alarm summary alarm control high pressure flow switch low pressure anti freeze compressor overload fan overload pumps overload N display of the following parame ters inlet water temperature evapora tor inlet water temperature outlet water temperature delta T high pressure low pressure restart delay time N alarm display N settings a without password set cooling total differential b with password set anti freeze low pressure off time display language access code The main functions controlled by the microprocessor are described below for more information refer to the user manual DCPX Dispositivo per basse tempe rature Fitted as standard in sizes 500L 550L 600L 650L 700L 750L and in all models with Desuperheater D Low temperature device designed to ensure correct operation during cooling cycles below 20 C only for Standard and High Temperature ver sions Comprises an electronic regu lation card that adjusts the ventilator speed according to the condensation pressure read by the high pressure transducer to keep it sufficiently high GP Protective grille Each kit contains two grills it will be necessary to use two or three kits according to the model This kit is used to protect the external battery from accidentalknocks PGS Board designed for installation on the unit microprocessor Used to program two time set
115. ncia el ctrica V lvula de seguridad circuito frigor fico Calibrada a 30 Bar interviene descargan do la sobrepresi n en caso de presiones an malas TP1 transductores de baja presi n de serie en la bombas de calor accesorio en AER485 MODBUS Este accesorio permite la conexi n de la unidad con sistemas de supervisi n BMS con est ndar el ctrico RS485 y protocolo de tipo MODBUS Tarjeta para sistemas AVX Soportes antivibradores Grupo de antivibradores a montar abajo de la bancada en chapa de la unidad en los puntos ya predispuestos los cuales sirven las versiones de fr o TP2 transductor de alta presi n de serie en la bombas de calor en 500 550 600 650 700 y 750 solo fr o se encuentran provistos de serie de transductor de alta presi n 3 5 COMPONENTES EL CTRICOS Cuadro el ctrico Contiene la secci n de potencia y la ges ti n de los controles y seguridades Est de acuerdo con las normas CEl 60204 1 y con las Directivas respecto a la compa tibilidad electromagn tica EMC 89 336 CEE y 92 31 CEE Seccionador su jetapuerta Se puede acceder al cuadro el ctrico si se quita tensi n mediante la palanca de apertura del propio cuadro Durante las intervenciones de mantenimiento es posi ble bloquear dicha palanca con uno o m s candados para impedir una indeseada puesta en funcionamiento de la m quina Teclado de mando Permite el completo control del equipo Para una descripci n m
116. ncuentra indicado el contenido m ximo en litros de agua de la instalaci n hidr ulica compatible con la capacidad del recipiente de expansi n suministrado de serie Los valores que aparecen en la tabla se refieren a tres condiciones de temperatura m xima y m nima del agua Si el contenido de agua efectivo de la instalaci n hidr ulica incluso el tanque de acumulaci n es superior al que resulta en la tabla con las condiciones operativas se deber instalar un ulterior vaso de expansi n adicional dimensionado utilizando los habituales criterios relacionados con el volumen de agua adicional Mediante las siguientes tablas se pueden obtener los valores de contenido m ximo de la instalaci n tambi n para otras condiciones de funcionamiento con agua glicolada Los valores se obtienen multiplicando el valor de referencia por el coeficiente de correcci n 10 11 Calibrado vaso de expansi n El valor est ndar de presi n de precarga de los dos vasos de expansi n es igual a 1 5 bar mientras que su volumen es de 24 itros valor m ximo 6 bar El calibrado del dep sito se debe regular de acuerdo con el desnivel m ximo H de a unidad v ase figura seg n la f rmula p calibrado bar H m 10 2 0 3 Por ejemplo si el valor del desnivel H es igual a 20 m el valor del calibrado del deposito ser de 2 3 bar 10 ACUMULACI N
117. nda dB To otencia sonora para frecuencia central de banda dB 0275 0300 0325 0350 0500 825 505 700 843 78 6 775 772 76 3 732 648 0550 825 505 700 828 790 790 784 764 718 629 0600 83 0 510 _ 71 0 860 798 785 782 774 734 649 0650 84 0 52 0 71 0 85 2 804 791 782 783 746 653 0700 860 540 730 927 819 807 810 793 744 654 0750 86 0 540 720 927 819 816 813 792 755 665 Niveles sonoros totales Banda de octava Hz d Pot Pressione _ 125 250 500 1000 2000 4000 8000 A dB A dB A dB p A otencia sonora para frecuencia central de banda dB 10m 1m 0275 760 440 640 766 765 735 715 663 615 51 0300 76 0 44 0 650 776 749 745 171 5 66 59 7 49 7 0325 770 45 0 660 _ 775 778 761 714 668 59 7 _ 50 3 0350 77 0 45 0 65 0 791 UES SOTA Le 66 9 595 49 3 0500 825 505 700 842 178 6 775 772 763 173 2 643 0550 825 505 70 0 841 784 779 776 76 5 712 623 0600 83 0 510 700 856 788 _ 78 4 78 77 721 63 0650 84 0 152 0 71 0 86 7 80 7 795 785 778 739 63 5 0700 840 52 0 700 838 799 797 795 774 729 164 7 0750 84 5 52 0 71 0 83 8 799 80 7 80 772 74 3 66 Niveles sonoros totales Banda de octava Hz Pot Pressione 125 250 500 1000 2000 4000 8000 H dB A dB A dB lt A 5 otencia sonora para frecuencia central de banda dB 10m 1m 0275 760 440 65 0 772 77
118. ndle with alumi nium fins fixed by mechanical expansion of tubes High efficiency type splined pipe and corrugated fins for heat pump smooth pipe and turbo fins for cooling only version Exchanger water side Plate type AISI 316 with double cooling circuit and alternating water freon circuits Insulated externally with closed cell mate rial to reduce heat loss Liquid separator heat pump versions only Located on the compressor suction side to offer protection against possible returns of liquid refrigerant flooded starting and operation in the presence of liquid Drier filter Mechanical filter made from ceramic and hygroscopic material designed to capture impurities and all residual moisture in the cooling circuit Liquid indicator Indicates the level of the coolant gas char ge and the presence of moisture in the cooling circuit Thermostatic valve The valve with equaliser at the evaporator outlet regulates gas flow to the evaporator according to the thermal load ensuring a sufficient degree of superheating of intake gas Suction side liquid and discharge gas shut off valves cooling version only These valves provide the facility to inter cept the flow of refrigerant to allow supple mentary maintenance work to be carried out Solenoid valve Cuts in when the compressor shuts down to stop flow of coolant gas to the evapo rator By pass solenoid valve heat pumps only By passes the thermostat
119. nti freeze control The anti freeze control managed by electronic regulation and by the temperature probe at the evaporator outlet has the job of preventing the formation of ice when the water flow rate is too low The control of its correct working can be made by gradually increasing the anti freeze set until it exceeds the outlet water temperature and keeping the water temperature under control with a precise thermometer checking that the unit switches off generating the relative alarm After this operation bring the anti freeze set back to its original value 33 18 DIMENSIONS NRA 275 300 325 350 version A L C HL 34 A B C Mod versioni mm mm mm 275 L A C 1100 2450 1606 300 L A C 1100 2450 1606 325 L A C 1100 2450 1606 350 L C 1100 2450 1606 275 HL 1100 2950 1606 300 HL 1100 2950 1606
120. odelos solo fr o En caso de mantenimiento extraordina rio permiten interceptar el flujo del fluido refrigerante V lvula solenoide Interviene cuando se apaga el compresor interrumpiendo la migraci n de gas refri 3 DESCRIPCI N DE LOS COMPONENTES LEYENDA 1 Bater as de intercambio aire Compresores scroll Evaporador de placas Accumulo Filtro acqua Pompa Vaso di espansione Teclado de mando Paneles cierre caja el ctrica 10 Estructura portante 11 Grupo de ventilaci n 0 ONDUASWWN gerante l quido hacia el evaporador V lvula solenoide de by pass s lo para bomba de calor By pasa la v lvula termost tica durante el ciclo de descongelaci n V lvula en modelo ciclo s lo para bomba de calor Invierte el flujo de refrigerante al variar del funcionamiento de verano invierno y durante los ciclos de descongelaci n V lvula unidireccional Permite el paso del refrigerante en una sola direcci n Desrecalentador s lo a pedido Del tipo con placas AISI 316 se encuen tra aislado externamente mediante mate rial con c maras cerradas para reducir las dispersiones t rmicas Recuperador total solo a pedido Del tipo con placas AISI 316 se encuen tra aislado externamente mediante material con c maras cerradas para reducirlas dispersiones t rmicas Acumulaci n del l quido s lo para bomba de calor o unidad con recuperaci n total Se emplea en
121. oned in this manual is forbidden unless previously agreed with the company The warranty does not include payment for damage due to wrong installation of the unit by the installer The warranty does not include payment for damage due to the improper use of the unit by the user The manufacturer is not to be considered liable for accidents to the user or the installer due to the incorrect installation or improper use of the unit The device must be installed in such a way that maintenance and or repair Operations can be carried out The warranty of the device does not in any case cover costs incurred as a result of motorised ladders scaffolding or any other lifting systems necessary to carry out the operations under warranty The warranty is not valid when the services and repairs have been carried out by non authorised personnel or companies the unit has been repaired or modified in the past with non OEM spare parts the unit has not been adequately maintained the instructions described in this manual have not been followed non authorised modifications have been made N B The Manufacturer reserves the right at all times to make any modification for the improvement of its product and is not obliged to add these modification to machines of previous manufacture that have already been delivered or are being built The warranty conditions are anyway s
122. or y bomba alta prevalencia 04 Acumulador bomba alta prevalencia y bomba de reserva 05 Acumulador con orificios para resistencia complementaria y bomba baja prevalencia 06 Acumulador con orificios para resistencia complementaria bomba baja prevalencia y bomba de reserva 07 Acumulador con orificios para resistencia complementaria bomba alta prevalencia 08 Acumulador con orificios para resistencia complementaria bomba alta prevalencia y bomba de reserva campo 14 Alimentaci n 2 37 400V 50Hz con magnetot rmicos 4 37 230V 50Hz con magnetot rmicos 9 37 500V 50Hz con magnetot rmicos campo 13 Evaporador Conforme PED C Motocondensadora sin evap campo 12 Baterias De aluminio R de cobre EI Cobre esta ado V cobre aluminio lacado campo 11 Version E est ndar A Alta temperatura L Est ndar en ejecuci n Silenciada campo 10 Recuperadores de calor Sin recuperadores D Desrecalentador T Recuperaci n total campo H Modelo S S lo fr o H Bomba de calor Refrigerante 2 Est ndar Y Versi n para baja temperatura del agua producida hasta los 6 C 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 31 CIRCUITO DE REFRIGERACI N Circuito frigorifero Compresors Compresores herm ticos de tipo scroll provistos de serie de la resistencia el ctrica anticongelante La resistencia se alimenta autom ticamente con el paro de la unidad siempre que la unidad se man tenga bajo ten
123. ow pressure side of the cooling circuit the switch shuts down compressor operation in the event of abnormal operating pressure levels High pressure switch Variable setting located on the high pres sure side of the cooling circuit the switch shuts down compressor operation in the event of abnormal operating pressu re levels Anti freeze electric heater Supplied as a standard accessory This is turned on by the antifreeze sensor located in the plate evaporator It turns on when the water temperature drops to 3 C and turns off again when the temperature reaches 5 C The resistor is managed by dedicated software resident in the regula tion card Refrigerator cirucit safety valves Calibrated at 30 Bar it cuts in by letting off the overpressure in the case of abnormal pressures TP1 low pressure transducer as a standard option for heat pumps as an ac cessory for cooling only versions TP2 high pressure transducer Standard options for size to 500 ap 750 and in all heat pump version AER485 Modbus system board Accessory for connecting the unit to BMS supervisor systems with electric standard RS485 and MODBUS pro tocol AVX VT Vibration damper support Group of vibration dampers to be fitted under the plate base of the unit at the points provided and which serves to reduce the vibration produced by the fan unit and compressors during operation 3 5 ELECTRICAL COMPONENT Electric panel Features po
124. ple with the relative means in compliance with safety standards for the position of the points of implan tation of the AVX to make reference the installation handbook 41 INSTRUCCIONES PARA LA SELECCI N Declaracion d comformidad EE p g 41 1 Normas generales 42 2 Descripci n y Elecci n dela unidad 20 ag 43 21 IG elsa es Tesis lt T g 43 2 2 Versiones disponible Siima inaina aiai in lai ela ai g 43 2 21 Equipamiento de serie ANDA GA O IAS MI ail g 43 2 3 A O NITAL ag 44 3 Descripci n e Ee lu e ue g 45 3 1 ECU AN db i ag 45 3 2 B stidor y ventiladoress A AA g 45 3 3 Componentes Old UCSI ii a Aid g 45 3 4 Componentes de seguridad y control 46 3 5 Gomponent s el CtrICOS 1 4 2 10284 000 elia ai ERA R EA A i g 46 4 Accesorios y tabla COMPINADIIAAT ENEE g 47 5 Datos t cnicos 5 2 VEIS EN AA A oa ARA p g 49 5 3 Versiones alta MC rin ado e bib p g 50 DA KINN Ee pag 51 5 5 Versiones bomba de Calor croata li p g 52 5 6 Versiones bomba de calor olecladag ENEE p g 53 5 7 KEEN RRE p g 54 5 8 Versiones LA dd TEIN p g 55 6 Criterios de elecci n 6 1 Limites CTC AN G A A A A e p g 56 6 2 Datos de proyecto 56 7 Coeficientes correctivos 71 Potencia de refrigeraci n absorbida versiones est ndar Bomba de calor funcionamiento en fr o Alta a E AA EROI N ata p g 57 H Soltici nide atilenglicol ail a ee i ia a Int p g 61 9 P rdidas de carga
125. pumps kg 940 955 1030 1110 1285 1500 ol COOL MODE 8 TECHNICAL DATA VERSION CL Cooling capacity kW 117 134 153 165 Total input power kW 40 5 49 55 ENERGY INDICES EER W W 29 ESEER W W ELECTRICAL DATA Fuel feed A 3N 400 V 50Hz Total input current only COOLING A 39 42 7 46 5 55 5 66 71 5 878 99 2 111 8 124 Maximum current A 65 68 71 il 98 104 133 145 145 160 Peak current A 155 161 166 209 215 222 239 250 257 314 Type Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Number n 2 2 2 2 3 3 4 4 4 4 Number per circuit foot ee 2 2 2 2 2 2 3 2 3 2 4 2 4 2 4 2 4 2 Compressor carter heater n W 2x75 2x75 2x75 2x75 3x75 3x75 4x75 4x75 4x75 2x75 2 x 130 Type Axial Axial Axial Axial Axial Axial Axial Axial Axial Axial Number n 4 6 6 8 2 2 2 3 3 3 Input current ventilation unit A 3 2 4 80 4 80 6 40 1 20 1 20 1 80 2 20 2 40 Input power ventilation unit kW 0 58 0 87 0 87 116 0 6 0 6 1 21 1 2 Air flow rate m3 h 13720 20450 20450 27300 19000 21100 25000 27100 37600 40000 SOUND DATA Sound Power dB A 76 0 76 0 770 770 74 0 74 5 75 5 76 0 77 0 79 0 Sound pressure 1 dB A 44 0 44 0 45 0 45 0 42 0 42 5 43 5 44 0 45 0 470 DIMENSIONS for all versions
126. r sticas de los desrecalen tadores y las curvas de las p rdidas de carga est n indicadas a continuaci n Para los valores de temperatura del agua producida a una graduaci n distinta de 50 C hay que multiplicar el resultado obtenido por el factor de correcci n el cual se puede encontrar en la tabla al final de la p gina 12 2 4 12 DESRECALENTADORES 121 VERSION EST NDAR VERSION ALTA TEMPERATURA 1 5 2 Pm ms da val mi o 5 45 v 40 g 1 397 a 30 v 25 5 20 24 2 n D 05 S 40 41 42 43 44 45 46 47 48 49 50 12 1 2 CON SILENCIADOR 1 5 S a 5 dai i Tel LL alk ll 3 oO EA El 3 40 1 35 30 v 25 5 20 ES 2 E 2 05 40 41 42 43 44 45 46 47 48 49 50 agua producida At 5 C 12 2 3 Temperatura del agua C 5 7 9 11 13 15 Factor de correcci n 0 94 1 1 07 113 1 2 1 27 Temperatura de evaporaci n C 1 3 5 7 9 11 Factor de correcci n 0 88 10 94 1
127. rection coefficient N B FOR THE VERSIONS Y with temperatures below 4 C contact company headquarters 45 40 3 3 2 20 s E 5 2 bd g N o E 4 6 7 8 9 10 1 12 13 14 15 1 40 t 1 35 I 1 30 l 20 I 1 25 1 20 30 1 15 35 I 1 1 40 1 05 1 de LAA EUA ae ea d O E E T 0 95 0 9 l 45 I 0 85 t 0 8 0 75 0 7 4 6 7 8 9 10 11 12 13 14 15 Processed water temperature At 5 C Ca 1 20 1 15 1 1 1 05 0 95 0 9 0 85 0 8 Cf potenza frigorifera 73 HEATING AND INPUT CAPACITIES HEAT PUMP VERSIONS The heating capacity yielded and the electrical input power in conditions other than rated conditions are obtained by multiplying the rated values Pf Pa by the respective correction coefficients Cft Cpa The following diagram makes it possible to obtain the correction coefficients next to each curve you can see the temperature of the hot processed water to which it refers assuming a difference of water temperature between the inlet and outlet of the condenser equal to 5 C The yields are intended as net of the
128. ro n 3 3 4 4 4 4 N mero por circuito n n 3 2 3 2 4 2 4 2 4 2 4 2 RESISTENCIA COMPRESORES Resistencia c rter compresores 3x75 3x75 4 x 75 4 x 75 4 x 75 2x75 Tipo Axial Axial Axial Axial Axial Axial N mero n E 2 2 2 2 2 3 Corriente absorbida gr ventilaci n A 47 47 47 5 5 2 Potencia absorbida gr ventilaci n kW z S 2 7 2 7 2 7 2 8 2 7 Caudal aire m3 h 37500 37500 37500 35500 34600 56000 EVAPORADORES Tipo E Placas Placas Placas Placas Placas Placas N mero n 1 1 1 1 1 1 CIRCUITO HIDR ULICO Acumulador de agua ai a 500 500 500 500 500 500 Resistencia antihielo acumulador n xkW 300 300 300 300 300 300 CONEXIONES HIDRAULICAS paralelo no incluido Conexiones versioni estandard V R 2 1 2 EW 2 GW 2 GRUPO BOMBEO BAJA PREVALENCIA Potencia absorbida KW 11 11 RIS 1 5 1 85 3 Corriente absorbida A 214 214 214 2 92 3 60 6 4 Presi n til kPa 121 112 69 85 103 90 GRUPO BOMBEO ALTA PREVALE NCIA Potencia absorbida S 1 8 1 8 3 7 3 7 3 7 5 5 Corriente absorbida ES ES 3 60 3 60 721 721 721 11 3 Presi n til 5 a 186 184 177 163 146 205 DATOS SONOROS Potencia sonora dB A 82 5 82 5 83 0 84 0 86 0 86 0 Presi n sonora 1 dB A 50
129. rrespondiente cuando la presi n de env o supera el valor del set El control de su correcto funcionamiento puede realizarse cerrando la aspiraci n de aire del intercambiador en funcionamiento en fr o y manteniendo bajo control el man metro de alta presi n compruebe la intervenci n en correspondencia del valor de calibrado ATENCI N 17 CALIBRADO PAR METROS DE CONTROL Y DE SEGURIDAD min standard max Set point enfriamiento C 4 6 7 61 14 Set point calentamiento C 35 48 50 Intervenci n antihielo C 9 3 4 Diferencial total 4G 8 10 Autostart auto 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 N BA BA BA BA BA 9A A 4A 6A 6A 8A 6A 6A BA 6A SA SA L 4A 6A 6A 6A 6A 6A 6A 9A 9A 9A H 6A 6A 8A 8A 6A 6A 6A 9A SA 9A HL GA 8A 8A 8A 6A 6A 6A 9A 9A 9A 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 25 25 30 35 25 26 25 30 35 35 25 30 30 35 25 30 30 30 35 35 MTC A 35 35 25 30 35 35 30 30 35 35 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 PA a freddo 28 28 28 28 28 28 28 28 28 28 PA a caldo 28 28 28 28 28 28 28 28 28 28 PB 2 2 2 2 2 2 2 2 2 TRB 1 1 1 1 1 1 1 1 1 en el caso de una falta de intervenci n en el valor de ajuste detener en el valor de ajuste detener inmediatamente el compresor y comprobar las causas E
130. s 2 2 VERSION AVAILABLE STANDARD BASE RAH heat pump appliances are not avai 2 UNIT DESCRIPTION lable in the following configurations NOTE NRA with water produced at 6 C YA version only high temperature with water produced at 6 C is available For all other configurations including Y please contact the company HIGH TEMPERATURE available only for cold working versions via the expansion of the pack finned heat exchanger it allows you to widen the operating limits arriving at a maximum outside air temperature of 46 C SILENZIATE L this indicates models con figured for particularly low noise operation In cold only and heat pump appliances sizes 275 300 325 and 350 the units are low noise Sizes 500 550 600 650 and 700 are fitted with a fan speed adjustment device All the sizes are fitted with a device for regulating the fan speed When the temperature is lower than 35 C the low noise version further reduces the number of fan rotations thereby obtaining an even quieter operation than that in nominal conditions SILENCED HEAT PUMPS HL represents the models designed for particularly quiet operation 500 and 750 are fitted with a device for regulating the fan speed DCPX HEAT RECOVERY A unit with air condensation complete with section for partial heat recovery The heat exchanger is specially scaled to guarantee heat recovery for the production of hot w
131. s ha sido confeccionado con el objetivo de facilitar la correcta instalaci n de la unidad y proveer las indicaciones necesarias para un uso y mantenimiento correcto del aparato Antes de proceder con la instalaci n le sugerimos que lea con ATENCI N toda la informaci n contenida en el manual en el que se ilustran los procedimientos necesarios para la instalaci n y uso correcto de la unidad At ngase meticulosamente a las instrucciones contenidas en el presente manual y observe las normas vigentes de seguridad La instalaci n del aparato deber realizarse de acuerdo con la legislaci n nacional vigente en el pa s de destino e Manipulaciones no autorizadas del aparato tanto el ctricas como mec nicas ANULAN POR COMPLETO LA GARANT A y eximen a la empresa de posibles responsabilidades Compruebe las caracter sticas el ctricas indicadas en la etiqueta de matr cula Doll antes de realizar las conexiones el ctricas Lea las instrucciones de la secci n relativa a las conexiones el ctricas 11 Placa t cnica 1 NORMAS GENERALES En caso de necesitar la reparaci n de la unidad dir jase exclusivamente a un centro de asistencia especializado AERMEC y Utilice siempre piezas de recambio originales El fabricante declina adem s cualquier responsabilidad derivada de los da os personales o materiales causados por el no seguimiento del contenido de este manual Usos permitidos la ser
132. s Standard 0275 0300 10325 10350 0500 0550 0600 0650 0700 0750 Heating capacity available kW 23 25 29 34 38 45 Water flow rate m3 h 4 4 3 5 6 6 5 8 Water pressure drops kPa 10 9 5 9 7 8 5 9 Versiones A 0275 0300 0325 10350 0500 0550 0600 0650 0700 0750 Heating capacity available kW 13 16 18 20 23 25 30 34 39 46 Water flow rate m9 h 2 2 2 6 3 3 5 4 4 4 5 6 6 5 8 Water pressure drops kPa 9 5 75 9 5 12 10 9 5 9 7 9 9 Versiones L 0275 0300 10325 10350 0500 0550 0600 0650 0700 0750 Heating capacity available kW 11 7 14 16 18 22 5 24 29 34 38 40 Water flow rate m3 h 2 2 5 2 7 3 4 4 5 6 6 5 7 Water pressure drops kPa 7 6 7 10 9 5 9 8 5 7 9 7 13 TOTAL RECOVERY When operating with the total heat recove ry function machine performance depends on the temperature of the hot water produ ced not on that of external air to calculate the absorbed electrical and heat recovery power values multiply the values Pa Pr specified at the bottom of the page by the relevant correction factors Ca Cr derived from the diagrams below The temperature of the relative hot water is given for each curve a difference of 5 C between total heat recovery unit input and output is pre sumed Calculate the cooling power Pf by measuring the difference between heat recovery power Pr and power absorbed Pa D op Oo The heating capacity available to the total hea
133. si n Scambiador lado aire Est realizado con tubos de cobre y aletas en aluminio bloqueadas mediante expan si n mec nica de los tubos Es del tipo de elevada eficiencia tubo rayado y aletas arrugadas para bomba de calor tubo liso y aletas turbo para solo fr o Scambiador lado agua Del tipo con placas AISI 316 de doble cir cuito frigor fico y circuitos agua freon alter nados Externamente se encuentra aislado mediante material con c maras cerradas de manera de reducir las dispersiones t r micas Provisto de serie de la resistencia el ctrica anticongelante Separador de l quido sdlopara la bomba de calor Colocado en aspiraci n al compresor para la protecci n de eventuales retornos de refrigerante l quido comienzos inundados y funcionamiento con existencia de l quido Filtro deshidratador De tipo mec nico realizado en cer mica y material higrosc pico en grado de retener las impuridades y las eventuales huellas de humedad existentes en el circui to frigor fico Indicador de liquido Sirve para verificar la carga de gas refrige rante y la eventual existencia de humedad en el circuito frigor fico V lvula termost tica La v lvula con ecualizador externo ubicado a la salida del evaporador modula la entra da de gas al evaporador de acuerdo con la carga t rmica de manera de asegurar un suficiente grado de sobrecalentamiento al gas de aspiraci n Grifos de l quido e impelente m
134. stintas de las nominales se obtienen multiplicando los valores nominales Pf Pa por los respectivos coeficientes correctivos Cf Ca Los siguientes diagramas permiten obtener los coeficientes correctivos a utilizar para los aparatos en los varios modelos durante el funcionamiento en fr o con cada curva se encuentra correspondientemente indicada la temperatura del aire externo a la cual se refiere LEYENDA Cf Coeficiente correctivo de la potencia de refrigeraci n Ca Coeficiente correctivo de la potencia absorbida NOTA PARA LAS VERSIONES Y Con temperaturas inferiores a los 4 C contacte la sede PARA AT DIFERENTES DE 5 C Use en el evaporador la Tab 7 4 para obtener los factores correctivos de la potencia de refrigeraci n y absorbida Para controlar el ensuciamiento de los intercambiadores se utilizan los correspondientes factores de ensuciamiento 7 COEFICIENTES CORRECTIVOS potenza assorbita 0 9 0 8 0 7 0 6 05 Temperatura del agua producida At 5 C Pe h 40 35 30 25 AO OS O O O O O O A 6 4 2 0 2 4 6 8 10 12 14 16 h 45 46 6 4 2 0 2 4 6 8 10 12 14 16
135. t A 4 2 5 6 5 6 5 6 2 4 2 4 2 4 3 5 3 5 Input power ventilation unit kW 0 87 116 116 116 1 2 1 2 1 2 1 5 1 5 Air flow rate m3 h 21000 28000 _ 28000 28000 _ 25000 26000 28000 34000 38000 42000 Type Plate Plate Plate Plate Plate Plate Plate Plate Plate Plate Number n 1 il 1 1 1 1 1 1 1 d Water tank l 500 500 500 500 500 500 500 500 500 500 Accumulation anti freeze heater n x KW 300 300 300 300 300 300 300 300 300 300 PLUMBING CONNECTIONS STANDARD VERSIONS hydraulic parallel not supplied Hydraulic connections Victaulic 2 1 2 2 21 2 2 21 2 21 2 ENZ 21 2 21 2 ENZ LOW PRESSURE PUMPING UNIT Input power kw 0 75 075 0 75 0 75 11 11 11 1 5 1 85 3 Input current A 1 85 1 85 1 85 214 214 214 214 2 92 3 60 6 4 Useful pressure pumping sF 134 131 122 105 134 119 60 100 117 120 HIGH PRESSURE PUMPING UNIT Input power kW 14 14 1 5 do 1 8 18 3 7 3 7 3 7 59 Input current A 214 214 292 2 92 3 60 3 60 721 zel 721 11 3 Useful pressure pumping SF 176 172 168 155 194 189 185 172 154 230 SOUND DATA Sound Power dB A 76 0 76 0 770 770 76 0 76 5 77 5 78 5 80 0 81 0 Sound pressure 1 dB A 44 0 45 0 45 0 45 0 44 0 44 5 45 5 46 5 48 0 49 0 DIMENSIONS for all versions Height mm 1606 1606 1606 1606 1875 1875 1875 1875 1875 1875 Width mm 1100 1100 1100 1100 1100 1100 1100 1100 1100 1100 Length mm 2950 2950 2950 2950 2950 2950 2950 3950 3950 4275 EMPTY W
136. t recovery is in rated conditions Air temperature 35 C Water produced 50 C At 5 C 0 7 5 6 7 8 9 10 11 12 13 14 15 C Temperatura dell acqua refrigerata prodotta At 5 C LEGENDA Cr Coefficiente correttivo potenza recuperata Ca Coefficiente correttivo potenza assorbita Versi ei A EH SEH 0275 0300 0325 0350 0500 0550 0600 0650 0700 0750 Total rec capacity KW 662 758 868 998 1255 1374 164 18856 2145 2212 Tesla saus kw 182 18 8 218 258 375 404 49 546 645 672 Water flow rate m3 h 11 39 13 04 14 93 1717 21 59 23 63 28 21 32 44 36 89 38 05 Pressure drop kPa 17 15 19 19 45 19 18 15 20 18 28 1314 PRESSURE DROPS All NRA models with total recovery are equipped with ONE recoveries Heat reco very unit specifications and load loss cur ves are given below The pressure drops you see in the table do not include the filter drop whose curve is indicated NOTE The parallel water connections is to be made by the installer The pressure drops in the charts above refer to an average water temperature of 50 C The following table shows the corrections to apply to the pressure drops with a variation in average water tempe rature 13 2 Pressure drop water filter total recovery kPa 50 0300 ke40 0325 0350 30 20 30 35 40 45 50 55 6
137. tave band Hz i Pow Press 125 250 500 1000 2000 4000 8000 DI op dB A op GE coustic power by central band frequency dB 10m 1m 0275 0300 0325 0350 0500 83 0 51 0 700 835 8413 778 777 765 735 6539 0550 835 515 710 834 819 793 781 769 732 63 5 0600 845 525 720 848 845 808 795 772 72 7 64 5 0650 85 0 530 710 855 852 808 803 776 729 652 0700 865 545 730 871 85 9 823 818 794 _ 74 6 66 3 0750 87 0 55 0 73 0 871 85 9 82 9 821 793 756 672 Total sound levels Octave band Hz Pow Press 125 250 500 1000 2000 4000 8000 HL dB A dB A dB A ti b tral band frequency dB wane At coustic power by cen q y dB 0275 760 440 680 766 765 735 715 663 615 51 0300 76 0 45 0 680 776 749 745 715 66 59 7 49 7 0325 770 45 0 690 775 778 761 71 4 66 8 59 7 50 3 0350 77 0 45 0 69 0 791 USS la 172 66 9 595 49 3 0500 760 440 630 812 776 723 693 683 639 563 0550 76 5 445 640 810 781 73 7 696 686 635 53 8 0600 77 5 455 650 822 180 5 750 708 68 7 628 546 0650 785 465 650 834 817 755 72 1 696 638 5 55 8 0700 80 0 48 0 67 0 852 826 772 738 _ 71 6 654 571 0750 81 0 49 0 670 852 823 789 753 709 705 619 31 16 CAPACITY CONTROL
138. tes correctivos correspondientes 81 C MO LEER LAS CURVAS DEL GLICOL Las curvas presentadas en la figura resumen una notable cantidad de datos cada un de los cuales est representado por una espec fica curva para poder utilizar de forma correcta estas curvas es necesario hacer algunas consideraciones iniciales Si se desea calcular el porcentaje de glicol en base a la temperatura exterior se deber entrar desde el eje izquierdo y una vez intersecada la curva debe trazarse una l nea vertical que interceptar a su vez las otras curvas Los puntos obtenidos de las LEYENDA FCGPf Factor de correcci n de la potencia de refrigeraci n Factor de correcci n de la potencia absorbida Factor de correcci n de las p rdidas de carga evaporador temp media 3 5 C Factor de correcci n de as p rdidas de carga temperatura media 0 5 C Factor de correcci n de as p rdidas de carga temperatura media 5 5 C Factor de correcci n de as p rdidas de carga temperatura media 9 5 C Factor de correcci n de as p rdidas de carga temperatura media 47 5 C Factor de correcci n de los caudales evap temperatura media 9 5 C Factor de correcci n de los caudales condensador temperatura media 47 5 C FcGPa FcGDpF a NOTAS EI grafico a pesar de que alcance temperaturas externas de aire de 40 C obligatoriamente hay que tener como referencia los limites op
139. tings per day i e two on off cycles different programs may be set for each day of the week ROMEO Remote Overwatching Modem Enablig Operation Remote Overwatching Mo dem Enabling Operation is a device that enables a remote control of a chiller from an ordinary mobile phone with WAP browser Furthermore it allows to send alarm or pre alarm SMS up to 3 GSM mobile phones which may not be equipped with WAP browser TP1 Low pressure transducer Standard equipment on heat pump models Serves to show the compressor suc tion pressure value on the micropro cessor board display one per circuit Located on the low pressure side of the refrige rant circuit disconnects the compres sor if anomalous working pressures are detected TP2 High pressure transducer Standard equipment on sizes 500 550 600 650 700 750 and on all heat pump models Serves to show the compressor di scharge pressure value on the mt croprocessor board display one per circuit This adjustable sensor located on the high pressure side of the refrige rant circuit disconnects the compres sor if anomalous working pressures are detected DRE Dispositivo riduzione corrente di spunto Electronic peak current reducer It must be factory mounted RIF Current rephaser Parallel connection with the motor makes the reduction of input current possible This can onlybe installed when the machine is being made and must therefore be specifie
140. uado de la unidad e si no se han seguido las instrucciones incluidas en el presente manual si se han realizado modificaciones no autorizadas NOTA El fabricante se reserva el derecho en todo momento de efectuar cualquier modificaci n con el fin de mejorar el producto y no est obligado a a adir dichas modificaciones a m quinas fabricadas con antelaci n y ya entregadas o en fase de construcci n En cualquier modo las condiciones de garant a est n sujetas a las condiciones generales de venta previstas en el momento de la estipulaci n del contrato Fig 1 Los aparatos de la serie NRA son unidades empleadas para la producci n de agua fr a para instalaciones tecnol gicas los modelos con bomba de calor permiten producir agua caliente para calefacci n Est n compuestos por dos circuitos frigor ficos de R407C y por un nico circuito hidr ulico el cual puede o no estar provisto de grupo de acumulaci n La presencia de varios compresores de tipo scroll permite a los enfriadores NRA diversas parcializaciones de la potencia frigor fica La regulaci n electr nica con microprocesador controla y gestiona todos los componentes y los par metros de funcionamiento de la uni dad en el momento de surgir una condici n de alarma una memoria interna registra las condiciones de funcionamiento para luego visualizarlas en el display Las unidades cuen tan con grado de protecci n IP 24 21 MODELOS E
141. ubject to the general sales conditions at the moment the contract is finalised Fig 1 The devices of the NRA range are units Used to produce cold water for technolo gical systems the heat pump models also allow you to produce hotwater for heating They consist of two R407C refrigerating circuits and a single hydraulic circuit which may or may not be fitted with an accumulation unit The presence of more than one scroll type compressor allows the NRA chillers various capacity controls of the cooling capacity By means of a microprocessor the electro nic regulation controls and manages all the components and working parameters of the unit an internal memory registers the working conditions in the moment when an alarm condition arises in order to visualise it on the display The units have a protection rating of IP 24 21 MODELS AVAILABLE STANDARD COOLING ONLY TT maximum outside temperature allowed 41 42 C Acoustic protection cover for the compres sor for quiet operation HEAT PUMPS H in cooling mode the operating limits arrive to a maximum out side air temperature of 46 C Le grandez ze 275 300 325 e 350 sono disponibili nella sola versione silenziata NRAH do not envisage the following configu rations YH with processed water lower than 4 C HC condensing heat pump HA heat pump in high temperature because the heat pump is by its very nature a ma chine for high temperature
142. ura m xima del aire externo de 46 C En igualdad de condiciones de fun cionamiento ofrece rendimientos superio res al modelo base SILENCIADA L representa los modelos configurados para un funcionamiento par ticularmente silencioso En las dimensiones 275 300 325 y 350 con solo fr o y con bomba de calor todas las unidades son silenciosas Las dimensiones 500 550 600 650 700 750 est n dotadas de dispositivo de regulaci n de la velocidad de los ventiladores DCPX BOMBA DEL CALOR CON SILENCIA DOR HL Representa los modelos configurados para un funcionamiento particularmente silencioso Las dimensiones 500 550 600 650 y 700 est n dotadas de dispo sitivo de regulaci n de la velocidad de los ventiladores DCPX RECUPERACI N DE CALOR D Recuperaci n parcial con desrecalenta dor insertado de serie ATTENZIONE En los modelos con bomba de calor el desre calentador debe ser interceptado en el fun cionamiento en bomba de calor bajo pena de anulaci n de la garant a T Recuperaci n de calor con cambiador de placas introducido en pa ralelo con las bater as est previsto Unica mente en el modelo s lo fr o no se encuentra a disposici n para las bombas de calor y las unidades motocondensadoras Los NRA con desrecalentador y los con recu peraci n total montan de serie en el circuito hidr ulico destinado a la recuperaci n fluj stato filtro del agua C
143. valve during the defrosting cycle 3 DESCRIPTION OF COMPONENTS KEY Air side exchanger Compressor Water side exchanger Storage tank Water filter Circulation pump Expansion Vessel Control keypad Electric panel Frame Fan assembly 2 2 00 00 M A k ef Reverse cycle valve heat pump version only Reverses the flow of coolant on changing from Summer to Winter operating mode and during defrosting cycles Unidirectional valve Allows refrigerant to flow in only one direc tion Desuerheater only if requested Plate type exchanger AISI 316 with outer closed cell heat insulation Total recovery device only if requested Not available for heat pump versions Plate type exchanger AISI 316 with outer clo sed cell heat insulation 3 2 FRAME AND FANS Fan assembly Statically and dynamically balanced axial flow type The fan units are electrically protected with thermal magnetic circuit breakers and mechanically protected with metal anti intrusion grilles CEl EN 60335 2 40 Frame Made from hot galvanised thick sheet metal painted with stoved polyurethane powder for resistance to atmospheric agents 3 3 HYDRAULIC COMPONENTS Circulation pump Fitted to the tank provides the head requi red to compensate for pressure drops in the system The option of a reserve pump is also foreseen and in this case the sof tware resident in the regulation card will provide for alternation o
144. wer section regulation of con trols and safety devices Compliant with CEl 60204 1 standards and Directives EMC 89 336 EEC and 92 31 EEC Door lock disconnector For safety s sake it is only possible to ac cess the electric panel after cutting off the power supply using the lever that opens the panel itself This lever can be fastened with one or more locks during maintenance ope rations to prevent power from being resto red to the machine accidentally Control Keypad Gives complete control over unit functions For more information refer to the user manual Remote control panel For remote control of chiller operation compressor thermomagnetic cut out fan thermomagnetic cut out auxiliary thermomagnetic cut out exhaust gas temperature control ther mostat 3 6 ELECTRONIC REGULATION Microprocessor Comprises control board and display panel Functions include e evaporator inlet water temperature control with thermostatting up to 6 steps and proportional integral con trol on the fan speed e compressor start up delay chiller operating mode with possibi 4 ACCESSORIES lity of additional cooling capacity using free cooling compressor sequence rotation e low temperature control device acces sory e compressor operation timer e start stop control reset e permanent alarm log automatic restart after power failure e multi language messages e local or remote control operatio
145. xial Axial Axial Axial Axial N mero n 4 6 6 8 2 2 2 3 3 3 Corriente absorbida gr ventilaci n A 3 2 4 8 4 8 6 4 5 5 5 5 Za Potencia absorbida gr ventilaci n kW 2 32 5 22 5 22 9 28 2 8 2 8 2 8 2 8 4 2 Caudal aire m3 h 13720 20450 20450 27300 35500 35500 35500 35000 54900 56000 EVAPORADORES Tipo Placas Placas Placas Placas Placas Placas Placas Placas Placas Placas Numero n 1 d 1 1 1 1 1 1 1 1 CIRCUITO HIDR ULICO Acumulador de agua 500 500 500 500 500 500 500 500 500 500 Resistencia antihielo acumulador n xkw 300 300 300 300 300 300 300 300 300 300 CONEXIONES HIDRAULICAS paralelo no incluido Conexiones versioni estandard V 2 EW EW 2 GW EW 2 GW EW EW GRUPO BOMBEO BAJA PREVALENCIA Potencia absorbida kW 0 75 0 75 0 75 0 75 11 11 al 15 1 85 3 Corriente absorbida A 1 85 1 85 1 85 214 214 214 214 2 92 3 60 6 4 Presi n til kPa 122 126 113 91 112 103 59 76 83 80 GRUPO BOMBEO ALTA PREVALE NCIA Potencia absorbida kW 11 11 1 5 1 5 1 8 1 8 3 7 3 7 3 7 5 5 Corriente absorbida A 214 214 2 92 2 92 3 60 3 60 7 21 7 21 7 21 11 3 Presi n til kPa 172 162 161 145 180 179 171 158 133 195 DATOS SONOROS Potencia sonora dB A 76 0 76 0 770 770 82 5 82 5 83 0 84 0 84 0 84 5 Presi n sonora 1 dB A 44 0 44 0 45 0 45 0 50 5 50 5 51

Download Pdf Manuals

image

Related Search

Related Contents

Philips Halogen spot 8727900252453  取扱説明書 - M    Instruction Manual - Cole  Montar o ponto de acesso  G.B.S. Elettronica 42308 flashlight  AS-i 3.0 EtherNET/IP+Modbus TCP Gateway  OK - Rolladen  TC electronic SDN BHD X3 User's Manual  9 - heidenhain  

Copyright © All rights reserved.
Failed to retrieve file