Manuel d`utilisation [594 Ko]
Contents
1. ATOM 1000 et ATOM 3500 CARACTERISTIQUE Les Chargeurs num rique de la gamme ATOM sont contr l s par un microprocesseur 12 Bit int gr fonctionnant suivant 4 modes de charges automatiques Il inclue un mode maintient de charge Ce chargeur est parfaitement adapt la charge des batteries plomb tanches GEL et AGM ainsi que les batteries plomb ouvert Automobile moto motoculture camping car Golf bateau traction l g re batterie d charge lente et de cyclage Le microprocesseur analyse l tat de la batterie et contr le le r gulateur de tension du chargeur afin d optimiser le courant de charge C est une garantie de long vit pour votre batterie Caract ristiques de charge ss il Tension de charge V DD i il S Charge Charge efficace 1 Floating Douce t s Absorption Courant de charge A Current Amperes D part doux Le chargeur d marre avec un test de tat de la batterie Pour une batterie d charg profond ment le chargeur lance une phase de charge a faible intensit jusqu a restaurer un niveau de charge suffisant pour passer en charge normale Phase de charge Douce Le charge teste l tat de la batterie Si la batterie est d charg e profond ment le charge d marre par une phase de charge douce a faible intensit jusqu a atteindre une capacit batteries initial normale Phase de charge efficace La tensi2. et ATOM 3500 e Do not drop a metal tool on the battery The resulting spark or short circuit on the battery of other electrical part may cause an explosion e Remove personal metal items such as rings bracelets necklaces and watches when working with a lead acid battery e A lead acid battery can produces a short circuit current high enough to weld a ring or the like to metal causing severe burns FEATURES Automatic and Intelligent 4 Stage Charging Curve The chargers ATOM are controlled by a 12 bit AD microprocessor with 4 stage charging characteristic for charging batteries automobiles motorcycles snow mobiles tractors personal watercraft boats etc A microprocessor senses the condition of the battery and controls the regulator to provide the right current and voltage to the battery charging characteristic This will give the best effect on charging and give the longest life to battery Charging characteristic Voltage Volts Soft Start Bulk Absorption Float Current Amperes e Soft Start Initial battery test to determine battery condition If the battery is severely discharged charger will begin the Soft Start stage Charging starts with reduced current until battery voltage reaches a normal condition for charge e Bulk Major charging stage where the battery receives the majority of its charge During this stage the battery brought to 75 80 of its charger The ATOM 7500charger delivers m
3. objet de tentatives de r parations non autoris es Acedis Sarl est responsable de la r paration ou de l change du produit d fectueux et non de dommages ou d sagr ments r sultant du d faut et de l utilisation du produit Page 7 sur 14 ATOM 1000 et ATOM 3500 INTRODUCTION The Charger ATOM 3500 and ATOM 1000 is member of the family of advanced battery chargers will increase your battery s performance and prolong its life Please carefully read and follow the following safety and operating instructions IMPORTANT SAFETY INSTRUCTIONS Gases When the battery is being charged you may notice bubbling in the fluid caused by the release of gas As the gas is flammable no naked lights should be used around the battery and the area should be kept well ventilated Because of this risk of explosive gas only connect and disconnect the battery leads when the mains supply is disconnected Type of batteries This charger is only suitable for normal lead acid sealed leisure gel or deep cycle batteries and should not be used to recharge NICAD or any other type of battery Points of note e When not in use store the charger in a dry area to avoid moisture damaging the transformer e Your Battery Charger is suitable for IVDOOR USE ONLY Keep away from liquids rain or snow at all times e This battery charger is not designed as power supply Repair e The Battery Charger should not be opened Any attempt at modification or r
4. removed for charging replace it and reconnect the cables MAINTENANCE AND CARE It is essential to keep your battery regularly charged throughout the year especially during the winter months In the winter the effectiveness of your car battery is reduced by the cold Oil is thick Engines are difficult to start and the heater windscreen wipers and lights are all draining power It is at this time that batteries have to be at peak power If your battery is not regularly maintained and kept fully charged it can cause problems and a possible breakdown Listed are some helpful hints on how to keep your battery healthy in conjunction with your Battery Charger Faulty Cells Batteries are usually made with six cells One of these cells can deteriorate or get damaged If after several hours charging your battery is still flat you should test the battery Take hydrometer readings from each cell in the battery If one reading is lower than the others this could indicate a faulty cell If necessary get an Auto Electrician to check your battery One faulty cell is enough to ruin your battery It is pointless to continue using it and you would be better getting a new one Care Sometimes the battery may appear flat but this could simply be dirty or loose connections on your battery terminals It is important to maintain the leads on a regular basis Do this by removing the leads from the battery clean the inside of each connector and terminal pos
5. the negative charging lead black to the negative terminal post of the battery marked N or It is important to ensure that both DC clamps are making good contact with their respective terminal posts Connect the charger s AC power cable to an AC power outlet Once you have connected the ATOM 7500battery charger to AC power it will sound a tone for 0 5 seconds and the Simple Touch power panel LEDs light for two seconds 4 Reverse Polarity If the DC battery clamps are connected improperly to the battery terminals the reverse polarity LED will indicate the reversed polarity The battery charger s warning buzzer will also sound If this occurs simply disconnect the battery charger from the AC power Connect the DC clamps correctly to the battery terminals Reconnect the charger to the AC power 5 Charging Page 11 sur 14 ATOM 1000 et ATOM 3500 The battery charger is now in the Standby operating mode and the 12 Volts GEL and POWER LED s are illuminated This is the standard charging mode and as soon as the START button is pressed the charger switches immediately into the 12V STANDARD battery charging mode If you require an alternative selection proceed as follows ATOM 3500 ATOM 1000 Step 1 Select the battery s Voltage 12 Volts or 6 Volts Step 2 Select the battery type STD or GEL Only for ATOM 3500 Charge STD indicates a common lead acid battery calcium batter
6. une sonde va automatiquement ajuster la tension de charge La tension de charge est diminu e si la Temp rature monte et inversement augment e basse Temp rature Compensation de charge et pertes en lignes Le chargeur ATOM compare la tension aux bornes de la batterie et celle d livr e p ar le chargeur Il compense les pertes en ligne dues aux c bles Protection contre les courts circuits S1 par accident les pinces se touchent alors que le chargeur est sous tension ou que la charge est d marr e le chargeur s arr te automatiquement et se met en s curit Vous devez red marrer la charge apr s avoir corrig le d faut C bles de branchement Afin de r pondre toutes les applications batteries de d marrage ou industrielles Les chargeurs ATOM sont livr s avec deux type de sorties Les Pinces crocodile pour une utilisation ponctuelle Les cosses illets pour une utilisation en continu ou sur batteries industrielles M moire de Charge Page 4 sur 14 ATOM 1000 et ATOM 3500 En cas de Coupure de Courant les chargeurs ATOM 3500 et ATOM 1000 conservent en m moire le mode de charge s lectionn Quant le courant secteur revient la charge batterie reprend automatiquement sur le m me mode de charge Autres Fonctionnalit s Protection anti tincelles Protection contre la surchauffe du chargeur et de la batterie Boitier en ABS de niveau IP65 UTILISATION 12v GEL START ATOM 3500 AT
7. ATOM 1000 et ATOM 3500 CHARGEUR DE BATTERIE INTELLIGENT DIGITAL INTELLIGENT BATTERY CHARGER Chargeur Automatique Intelligent Gestion de la charge par microprocesseur Chargeur charge Puls e pour batterie plomb ouverte et tanche GEL et AGM 6 Volts 12 Volts A MA ATOM 1000 et ATOM 3500 Convient toute batterie plomb acide Batterie tanche gel et AGM Batterie de d marrage batterie industrielle d charge lente et traction l g re Suitable for 12 Volts acid lead batteries VRLA Gel and AGM battery starter and deep cycling use Page 1 sur 14 ATOM 1000 et ATOM 3500 INTRODUCTION Les Chargeurs de la gamme ATOM font partie des chargeurs batterie de derni re g n ration Ils augmentent les performances et la long vit des batteries MERCI DE LIRE ATTENTIVEMENT LE MANUEL ET DE SUIVRE LES INSTRUCTIONS D UTILISATIONS ET DE SECURITES CONSIGNES DE SECURITE Gaz En rechargeant des batteries il peut se former des bulles de gaz Ce gaz est inflammable Il ne faut pas utiliser de source de chaleur proximit Le lieu d utilisation doit tre bien a r Pour viter tous risque d explosion ne jamais brancher ou d brancher les batteries du chargeur sans avoir coup le contact g n ral Types de batteries Ce chargeur convient a la recharge de toutes batteries au plomb 6Volts et 12 Volts Gel et AGM de types ouverte ou tanche batteries industrielles d charge lente et de d marrage Ne
8. OM 1000 Pour des batteries de 7 Ah 80 Ah Pour des batteries de 1 2 Ah 40 Ah 1 votre batterie Pour une batterie de d marrage 1l est conseill de la d connecter de l alternateur et de la sortir du v hicule Respecter les consignes de s curit en la manipulant Portez gants et lunettes 2 Pr parer la batterie Pour les batteries ouverte ouvrez les bouchons de s curit assurez vous des niveaux d lectrolyte si n cessaire refaite les niveaux avec de l eau distill uniquement Pour les mod les sans entretien ou tanche les contr les sont inutiles 3 Branchement Branchez le c ble de raccordement positif Rouge au pole positif de votre batterie puis branchez le c ble de raccordement n gatif au pole n gatif noir Branchez le c ble d alimentation du chargeur qui met un bip sonore Les Leds s allument S1 les c bles ne sont pas branch s correctement le charge d clenche une alarme et la LED INVERSIONS s allume Vous devez inverser les connexions et relancer la charge 4 Choisir le mode de maintient de charge Le mode affich par d faut est le suivant ATOM 3500 12 Volts GEL et POWER ATOM 1000 12 Volts et POWER Si vous voulez en changer vous devez s lectionner e Le mode de charge 6 Volts ou 12 Volts e Le mode de fin de charge Pour le chargeur ATOM 3500 seulement o STD standard charge a tension constante adapt aux batteries type
9. aximum current until the terminal voltage has risen to the full charge level for Normal battery e Absorption Completes the charge up to virtually 100 at a constant voltage The current tapers off until the current reached the minimum level e Float Maintenance charging at constant voltage keeping the batteries at 100 charge Normal charging mode is time limited max 10 days while Float mode chargers indefinitely without damaging the battery LED display The unit is built in with LED display for showing charger status CHARGE FLOATING Page 9 sur 14 ATOM 1000 et ATOM 3500 INVERSION RED LED DC clamps are connected in reverse polarity DEFAUT RED LED Battery Fault POWER YELLOW LED The charger is connected to mains power CHARGE AMBER LED The charger is charging to the battery FIOATING GREEN LED The battery is fully charged and the charger is in maintenance mode Temperature Compensation A sensor will automatically adjust the charging voltage if the temperature deviates from 20 C to 45 C A high temperature environment will lower the voltage and freezing condition is handled by higher voltage A low temperature heightens the output voltage and hot condition is handled by lower voltage Voltage compensation Because of some voltage drop in the cables the actual voltage at the clamps of the battery can be lower than the charger output voltage A special circuitry inside the unit will monitor the t
10. d marrage plomb calcium ou batteries profond ment d charg es Page 5 sur 14 ATOM 1000 et ATOM 3500 o GEL Ce mode est adapt tout type de batteries tanche VRLA Gel AGM mais aussi batteries de d marrage batteries d charge lentes plaques planes ou tubulaires e 5 Appuyez sur START La charge d marre ERREUR BATTERIE Si quelque seconde apr s la charge la LED DEFAULT s allume les causes peuvent tres les suivantes La tension vide de la batterie est trop basse lt 3 Volts La tension de la batterie est trop haute gt 15 Volts La batterie a un ou plusieurs l ments en court circuit Le chargeur s arr te automatiquement La batterie doit tre d fectueuse consultez votre revendeur Quand la LED Floating s allume la batterie est compl tement charg e Le chargeur passe automatiquement en mode Floating ou maintient de charge La batterie peut y rester en permanence jusqu a sa prochaine utilisation FIN DE CHARGE D branchez le chargeur du secteur V rifiez si n cessaire les niveaux d lectrolyte revissez si n cessaires les bouchons une fois nettoy e la batterie est pr te l emploi Si la batterie est de type tanche VRLA aucun contr le n est possible une fois la fin de charge constat e la batterie nettoy e est pr te l emplot CARACTERISTIQUE TECHNIQUES Chargeur pour batteries 6 Volts et 12 Volts plomb acide VRLA gel et AGM plomb o
11. epair by the user will entail the loss of your guarantee e The mains supply cord of this appliance can not be replaced if the cord is damaged the appliance should be discarded Danger e Avoid getting electrolyte on your skin or clothes It is acidic and can cause burns If this occurs you should rinse the affected area with water immediately e If it gets into your eyes wash thoroughly and seek medical attention immediately e Never charge a frozen battery If battery fluid electrolyte becomes frozen bring battery into a warm area to allow battery to thaw before you begin charging Never let a battery on top of charger or vice versa e Do not touch the battery clamps together when the charger is on e Never operate charger if it has received a hard blow been dropped or otherwise damaged Take it to a qualified professional for inspection and repair e Be sure to position the charger power cord to prevent it from being stepped on tripped over or damaged e Never pull out the plug by the cord when unplugging the charger Pulling on the cord may cause damage to the cord or the plug Precautions When Working with Batteries e If battery acid contacts skin or clothing wash immediately with soap and water If acid enters eye immediately flood eye with running cold water for at least 20 minutes and get medical attention immediately e Never smoke or allow a spark or flame in vicinity of battery or Engine Page 8 sur 14 ATOM 1000
12. exist Check with your local authority or retailer for recycling advice o 1P65 GUARANIEE Charger ATOM 3500 and ATOM 1000 are guaranteed 2 years from the date of purchase The guarantee 1s not transferable The guarantee covers defect against workmanship and material only To obtain the guarantee service returns the unit to your retailer accompanied by your purchase invoice The guarantee does not apply if the unit was damaged or not used as initial use as described in the instruction manual The guarantee is void if non authorized repair has been performed Acedis is responsible for the repair or the replacement of the defective product and is not responsible for any consequential damage or inconvenience caused by the defect Page 14 sur 14
13. her features Anti Spark Protection Battery and Charger Overheating Protection ABS Housing Ingress Protection Rating IP65 OPERATION PLEASE READ CAREFULLY BEFORE USING Suitable for 6 amp 12V Lead Acid Batteries VRLA Gel and AGM batteries Sealed and stationary batteries Leisure starter or Gel Batteries ATOM 3500 batteries between 7 Ah to 80 Ah ATOM 1000 batteries between 1 2 Ah to 40 Ah 1 Charging your battery It is essential to disconnect the battery from the car This will avoid possible damage to the alternator To avoid damage to the bodywork from possible spillage remove the battery completely from the vehicle It is advisable to use gloves when handling the battery as there is a high possibility of corrosive acid being on the outside of the battery 2 Preparing the battery Firstly remove the caps from each cell and check that the level of the liquid is sufficient in each cell If it is below the recommended level top up with de ionized or distilled water Note Under no circumstances should tap water be used The cell caps should not be replaced until charging is complete This allows any gases formed during charging to escape It is inevitable that some minor escape of acid will occur during charging For permanently sealed battery it is not necessary to carry out the above checks 3 Connection Connect the positive charging lead red to the positive terminal post of the battery marked P or Connect
14. jamais tenter de recharger une batterie de type Ni CD Ni Mh ou lithium ou tout autre batterie Consignes Stock le chargeur dans un endroit sec Ce chargeur n est pas pr vu pour une utilisation en tant qu alimentation permanente Il doit tre utilis en int rieur ou prot g des intemp ries Ne jamais ouvrir le chargeur Toutes interventions sur le chargeur entrainent la perte de la garantie Le c ble d alimentation ne peut tre chang Le chargeur doit tre mis au rebut Danger de manipulation des batteries Ne pas mettre en contact la peau ou des v tements avec lectrolyte acide de la batterie L lectrolyte peut provoquer des br lures En cas de projection rincez abondamment avec de l eau Portez des lunettes lors des manipulations en cas de projection dans les yeux rincez grande eau durant au moins 20 minutes appelez les urgences ou consultez un m decin Ne jamais recharger une batterie gel e Laisser la d geler avant de d marrer la recharge Ne pas poser la batterie sur le chargeur ou inversement Si le chargeur est branch ne laisser pas les pinces se toucher Ne pas tenter de recharger une batterie fendues ou qui aurait re u un choc important Ne jamais tirer sur les cables pour les d brancher Ne pas fumer Ne jamais poser un objet m tallique entre les deux bornes d une batterie Retirez tous vos objets personnels m talliques Une bague est une source de court circuit Page 2 sur 14
15. on monte jusqu a sa valeur max et le chargeur d livre un d intensit constante maximum afin de recharger jusqu 80 de la batterie Phase d absorption Durant cette phase a tension constante on atteint 100 th orique de l tat de charge Le courant d croit rapidement jusqu presque s annuler Phase de fin charge et de maintient de charge e En mode GEL La batterie peut rester en permanence connect e au chargeur qui sera r gl pour compenser l autod charge et ainsi maintenir la batterie a 100 de sa charge Ce mode est adapt tout type de batteries tanche VRLA Gel AGM mais aussi batteries de d marrage batteries d charge lentes plaques planes ou tubulaires e En mode STD la dur e de maintient de charge ne doit pas exc der 10 jours Page 3 sur 14 ATOM 1000 et ATOM 3500 Affichage LED INVERSION DEFAUT POWER CHARGE FLOATING L affichage LED vous informe sur la batterie INVERSION Led Rouge Vous avez invers les pinces de raccordement DEFAUT Led Rouge Erreur de batterie panne chargeur ou batterie hors d tat POWER Led Jaune Le chargeur est raccord au secteur CHARGE Led Ambre la batterie est en charge FLOATING led Verte la batterie et completement charg e et le chargeur est en position maintient de charge Compensation de la tension de charge en fonction de la temp rature En cas de d passement des temp ratures extr me de 20 C a 45 C
16. rue input voltage to the battery and adjust the output voltage of the unit accordingly This will maximize the charging efficiency Reverse polarity protection This unit offers reverse polarity protection the RED INVERSION LED will illuminate and the charging process will not start If this happens unplug immediately from mains connect the red crocodile clip to positive battery post and black crocodile clip to negative post then plug into the mains power and the charging process will start Short circuit protection Should you accidentally touch the crocodile clips together whilst the mains power is on the unit will not perform charging Unplug from mains disconnect and start the process again being careful not to touch the clips together Cable connector The ATOM 3500 ATOM 1000 has two options for connecting the unit to the battery Via the intelligent cable connector you can select witch connection you want to use e Crocodile clamps for easy and flexible use e O ring connectors for permanent fixation on your battery Charger memory Page 10 sur 14 ATOM 1000 et ATOM 3500 In the event of a black out or loss of AC power the charger will automatically memorize the selected charging mode When AC power is restored the charging will continue in the selected mode ATTENTION Once the clamp of charger is disconnected from the battery this memory is erased and the charging mode will need to be reselected Ot
17. ts on the battery smear the terminal posts and connectors with Vaseline refit in there correct positions and tighten firmly It is essential to keep the electrolyte level above the plates Note however that you should not overfill it as the electrolyte is strongly acidic When topping up do not use tap water Always use distilled or de ionized water It is important to keep the acid level up If necessary have it checked by your garage Checking the condition of your battery Using a hydrometer which can be purchased from most motor accessory stores you can check the specific gravity of the electrolyte in each cell The hydrometer is use to suck up a quantity of fluid from the cell The weighted float inside the hydrometer will register the condition of that cell Put the fluid back into the cell after testing taking care not to splash the fluid about TECHNICAL SPECIFICATIONS For 6 Volts and 12V Normal Lead Acid Sealed VRLA Gel and AGM batteries Leisure and starter batteries Floating or Deep cycle Batteries ATOM 1000 Imput 220 Volts 240 volts 50 Hz 21 W Output 6 volts 1 A DC 1 5A RMS 12 volts 1 A DC 1 5 A RMS ATOM 3500 Imput 220 Volts 240 volts 50 Hz 65 W Output 6 volts 3 5 A DC 5 3A RMS 12 volts 3 5 A DC 5 3 A RMS Page 13 sur 14 ATOM 1000 et ATOM 3500 ENVIRONMENTAL PROTECTION Waste electrical products should not be disposed of with household waste Please recycle where facilities
18. uvert batteries d charge lente et de cyclage batteries d charge profonde ATOM 1000 Alimentation 220 Volts 240 volts 50 Hz 21 W Sortie 6 volts 1 A DC 1 5A RMS 12 volts 1 A DC 1 5 A RMS ATOM 3500 Alimentation 220 Volts 240 volts 50 Hz 65 W Sortie 6 volts 3 5 A DC 5 3A RMS 12 volts 3 5 A DC 5 3 A RMS ENVIRONNEMENT sd Les appareils lectriques ne doivent pas tre mis au rebus avec les ordures m nag res Veuillez les porter a la d ch terie pr vue a cet effet Consultez votre revendeur ou votre mairie pour connaitre la proc dure de recyclage De m me il est express ment interdit de jeter les batteries a la d charge Ramener votre batterie usag e a votre distributeur qui assurera son recyclage et sa valorisation au sein d un circuit agr Ce o P65 Page 6 sur 14 ATOM 1000 et ATOM 3500 CE LVD CE EMC GARANTIE Les chargeurs ATOM 3500 et ATOM 1000 sont garantie 2 ans partir de la data d achat originelle La facture faisant foi La garantie n est pas transf rable La garantie en cas de panne couvre uniquement la main d ceuvre et le mat riel Pour faire valoir la garantie veuillez retourner l appareil votre revendeur accompagn de votre facture d achat La garantie ne s applique pas si l appareil a t endommag ou d tourn de son utilisation initiale tel que d crite dans le manuel d utilisation La garantie ne s applique pas si le chargeur a fait l
19. y and for Deep Cycle batteries Charge GEL indicates a common lead acid battery calcium battery Deep Cycle batteries but overall Maintenance Free battery e g Gel Cell VRLA AGM amp GEL etc Step 3 Press the START button to begin charging the battery Battery Fault A few seconds after switching on to the operating mode the LED indicator DEFAUT will illuminate if the following occurs A Low battery voltage lt 3 V B High battery voltage gt 15 V 12 V battery C Battery short circuit or battery cell short circuit Under these conditions the battery charger will stop charging In the event of A B or C the battery may be defective and we advise you to consult your nearest battery service centre When the LED FLOATING illuminates the battery is completely charged The battery charger now switches to the Float mode and doesn t require your attention until the next time it is used The ATOM 7500battery charger will automatically maintain your battery 6 When charging is complete Switch off the mains supply unplug the charger and disconnect the leads from the battery posts Inspect the liquid levels in each cell and top up If necessary using the Page 12 sur 14 ATOM 1000 et ATOM 3500 correct fluid Replace the caps Any surplus fluid around the cell tops should be wiped off this should be done with extreme care as it may be acidic corrosive Where appropriate if the battery has been
Download Pdf Manuals
Related Search