BRONCO WET / DRY - Cleaning Equipment Parts.com
Contents
1. Br 5796991 BRONCO 8 amp 24 Tom 5796181 BRONCO 4 MEN N 5798591 REPLACEMENT KIT Tom Ee 5796191 BRONCO 4 Ar mm 5796201 BRONCO 4 1 gt Tan SRE ee 5796211 BRONCO 4 1 ROUND BRUSH 5797001 BRONCO 8 amp 24 NOTES NSS Enterprises Inc 3115 Frenchmens Road Toledo Ohio 43607 PHONE 419 531 2121 FAX 419 531 3761 NSS Enterprises Inc European Distribution Centre Unit 1 Pinfold Trading Estate 55 Nottingham Road STAPLEFORD NOTTINGHAM NG9 8AD ENGLAND U K PHONE 44 0115 939 1568 FAX 44 0115 949 0615 9095700 BRONCO WET DRY MANUAL Rev Orig 11 08 Rev G 08 122. a t chapp endommag laiss l ext rieur ou chapp dans l eau retournez le un centre de service NE JAMAIS d brancher ou modifier les interrupteurs ou les dispositifs de s curit NE JAMAIS faire fonctionner cet appareil si le cordon et ou la fiche est endommag e bris e coup e us e ou scell e avec un ruban adh sif TOUJOURS remplacer tout le cordon lorsque ce dernier ou la fiche est endommag e de quelque fa on que ce soit NE JAMAIS manipuler l appareil le cordon ou la fiche avec les mains mouill es NE JAMAIS laisser tomber ou ins rer un objet dans toute ouverture de l appareil NE JAMAIS faire fonctionner cet appareil lorsqu une ouverture d air est bloqu e Garder toutes les ouvertures d air libres de poussi res peluche cheveux etc NE JAMAIS tirer ou porter l appareil par son cordon lectrique utiliser le cordon comme poign e fermer une porte sur le cordon tirer le cordon autour de bords ou coins tranchants exposer des surfaces chauff es faire passer l appareil sur le cordon ou d poser des objets lourds ou tranchants sur le cordon NE JAMAIS d brancher en tirant le cordon Pour d brancher le cordon de la prise agripper la fiche non pas le cordon NE JAMAIS laisser cet appareil servir de jouet Attention tout particuli rement lorsque l appareil est utilis par ou pr s d enfants TOUJOURS garder le visage les doigts les cheveux ou toute autre partie du
3. by or near children ALWAYS keep face fingers hair or any other body part or loose clothing away from any machine opening or moving part ALWAYS use extreme care when cleaning on stairs or when machine is placed on stairs NEVER operate this machine with out the dust bag and or filters in place NEVER use any attachments other than the manufacturers recommended attachments NEVER spray this machine with water or any liquids NEVER operate the machine outdoors NEVER expose the machine to rain snow or extreme temperatures ALWAYS store this machine indoors in a dry cool area ALWAYS use a defoamer when vacuuming soapy liquids ALL REPAIR SERVICE MUST BE PERFORMED BY AN NSS AUTHORIZED DISTRIBUTOR SERVICE STATION USING ONLY NSS ORIGINAL EQUIPMENT PARTS SAVE THESE INSTRUCTIONS MANUEL D UTILISATION BRONCO WET DRY IMPORTANTES INSTRUCTIONS DE SECURITE Lisez toutes les instructions avant d utiliser ou de r parer et faire l entretien de l appareil AVERTISSEMENT Danger d incendie ou d explosion NE JAMAIS utiliser pour ramasser des liquides inflammables ou combustibles ou toute autre chose qui brile ou fume comme des cigarettes des allumettes ou des cendres chaudes NE JAMAIS faire fonctionner cet appareil dans milieu explosif poussi re c r ali re liquides ou fum es inflammables etc AVERTISSEMENT Danger de choc ou d lectrocution TOUJOURS d brancher l appareil avant tout entretie
4. hose and the hose should be laid in a loose coil or hung over several pegs on the wall Clean the floor tool and wand of dirt and or liquid residue Empty the tank after each use Wet Pickup e After each use the machine should be emptied and rinsed with clean water Empty liquids and dispose of according to local EPA regulations Allow to air dry e Shake the dirt and or debris from the filter if the machine was used for stripper pickup the filter must be thoroughly cleaned prior to air drying Dry Pickup A polyester filter bag is standard on this unit Shaking lightly before removing from container will clean the filter e Shake the debris from the filter bag The filter bag must be cleaned after each use to prevent loss of vacuum suction and possible machine damage Weekly Maintenance e Inspect the hose for wear e Verify that all daily maintenance has been done e Check all gaskets for damage and to ensure an airtight fit Repair or replace as necessary e Vacuum the filter bag to remove imbedded dirt and maintain airflow e casters and wheels with light oil e Check the float for proper operation Monthly Maintenance e Verify that all weekly maintenance has been done e Oil casters and wheels with a light machine oil e Replace casters and wheels as necessary e Inspect the floor tools for wear Every 4 months Or 500 hours e Check carbon brushes for wear When carbon brushes are 1 2 1 27 cm in
5. 521 CORD BRONCO 4 amp 8 240V 2 5796601 CABLE 488 1 5 5796631 SCREW BRONCO4 amp 8 6 6 5796641 COVER BRONCO488 ___ 1 8 57961 MIDDLE COVER BRONCO 488 1 9 5796671 INSULATION BRONCO 4 amp 8 1 12 Seo VYCena ee 579851 1 MOTOR BRONCO 4 8 8 240V 15 5796731 GASKET MOTOR BRONCO488 1 25 5796831 BASE BRONCO 488 1 26 5796841 FRONT WHEEL BRONCO4 amp 8 2 27 5796851 REAR WHEEL BRONCO 4 amp 8 28 5798621 WIRE PRESSING CLAMP BRONCO 488 1 29 5798631 FILTER CAPACITOR BRONCO488 1 15A OVERLOAD PROTECTION DEVICE N BRONCO 4 amp 8 SHOWN 3394641 THERMOSTAT BRONCO 4 amp 8 BRONCO 16 PART ITEM DESCRIPTION 5 5934 SCREW BRONCO 1624 6 6 5797351 TOP COVER BRONCO 1624 7 1 7 579731 SCREW BRONCO 1624 6 8 5797391 SWITCH BRONCO 16 24 1 9 5931 O RING BRONCO 16 24 Ka 10 579731 MIDDLE COVER BRONCO 16 24 1 2 35 579041 FRONT WHEEL BRONCO 16 2 37 5798671 REAR AXLE END BRONCO 16 BRONCO 24 BRONCO 24 5795831 CABLE BRONCO 24 240V 592 CABLE SLEEVE BRONCO 2 1 7 BINDER BRONCO TT 4 HANDLE BRONCO 28 aT 5 Bronco 24 eT 5 Tor COVER i 7 srarasi SCREW BRONCO24 eT SO Ronco oe 9 5928 RING BRONCO 47 OR G N MO
6. OPERATION MANUAL amp PARTS BOOK BRONCO WET DRY BRONCO 8 BRONCO 16 BRONCO 24 24 5 OPERATION MANUAL amp PARTS BOOK BRONCO WET DRY IMPORTANT SAFETY INSTRUCTIONS Read all instructions before using or servicing machine WARNING Shock or electrocution hazard ALWAYS unplug machine before performing any maintenance or service WARNING Shock or electrocution hazard NEVER connect this machine to an electrical outlet that is not properly grounded See grounding instructions WARNING Fire or explosion hazard NEVER use to pick up flammable or combustible liquids or any thing that is burning or smoking such as cigarettes matches or hot ashes NEVER operate this machine in an explosive atmosphere grain dust flammable liquids or fumes etc WARNING This product contains a chemical known to the state of California to cause cancer and birth defects or other reproductive harm A WARNING To reduce the risk of fire electric shock or injury INTENDED USE The Bronco units are intended for commercial use vacuuming wet spills and or dry debris from floors in an indoor environment This machine is NOT for use in asbestos or hazardous waste removal NSS does not recommend using these machines for any other purpose When Using An Electrical Appliance Basic Precautions Should Always Be Followed Including The Following e ALWAYS read and understand all instruct
7. S oROUNDING m BLA ROLINDED BOX a A PATTE DE MISE D A LA TERRE FERRE R A LA TER REMARQUE Au Canada l utilisation d un rallonge temporaire peut tre interdite par le code canadien de l lectricit TOUTES LES REPARATIONS DOIVENT ETRE EFFECTUEES PAR UN DISTRIBUTEUR STATION SERVICE AUTORISE E NSS UTILISANT SEULEMENT DES PIECES ORIGINALES NSS CONSERVER CES INSTRUCTIONS 7 NOISE AND VIBRATION NOISE BRONCO 4 Sound pressure level at Operator position NOISE BRONCO 8 Sound pressure level at Operator position NOISE BRONCO 16 Sound pressure level at Operator position NOISE BRONCO 24 Sound pressure level at Operator position GENERAL INFORMATION e Now that the machine is unpacked remember to recycle all packing materials e Inspect the machine for damage or missing components If damage is found contact the local freight company to file a freight claim ASSEMBLY Installing the Hose e Push in on the intake button on the side of the intake then insert the end of the hose into the intake opening until it stops e To remove push in on the intake button grasp the coupling and pull 69 dB A 69 dB A 69 dB A 69 dB A INTAKE PUSH BUT TUN HUSE COUPE ING x UN Attaching Wands and or Tools e Choose the proper tool for the operation being performed Squeegee tool for
8. TOR BRONCO 24 120V CARBON BRUSH BRONCO 24 120V MOTOR BRONCO 24 240V CARBON BRUSH BRONCO 24 240V 5951 2 5798621 WIRE PRESSING CLAMP BRONCO 24 5798631 FILTER CAPACITOR BRONCO 24 WN 3394631 15 OVERLOAD DEVICE BRONCO 3394641 THERMOSTAT BRONCO 24 5798681 REAR AXLE BRONCO 24 5798791 REAR AXLE BRACKET BRONCO 24 9120370 10 FLAT WASHER 8 9120770 10 32 X 5 8 L MACHINE SCREW BRONCO 24 FRONT MOUNT SQUEEGEE 5795179 Complete FMS Kit 5798559 Squeegee Assembly Fits Bronco 24 Only PART ITEM NUMBER DESCRIPTION ar 1 5795141 SQUEEGEE HOUSING 1 6 5795111 2 8 5795131 BLADE SUPPORT____ 9 6394641 M5 X 16mm LONG PAN HEAD MACHINE SCREW 22 M5 SELF LOCKING HEX NUT 44 tt 5795331 C LITARM 2 BRONCO ACCESSORIES INCLUDED WITH MACHINES BRONCO 4 TOOL KIT BRONCO 8 AND 24 5796121 5796861 aH PART ITEM NUMBER DESCRIPTION QTY gt Ten eee 2 5796141 BRONCO 4 1 gt Tem NS 3 5796151 BRONCO 4 1 Tone sms 5796161 BRONCO 4 2 Tome eases 5 5796171 BRONCO 4 1 m ITEM NUMBER DESCRIPTION QTY S EET Es 1 5796931 24 1 MP 2 5796941 8 amp 24 1 MP OR 3 5796951 8 amp 24 1 MP OR 4 5796961 BRONCO 8 amp 24 2 BP Van 5796971 BRONCO 8 amp 24 ON 5796981 8 amp 24 SQUEEGEE L 5798601
9. corps ou v tements amples loin de toute ouverture de l appareil ou pi ce mobile TOUJOURS utiliser l appareil prudemment en nettoyant les escaliers ou lorsque l appareil lui m me est sur l escalier NE JAMAIS faire fonctionner cet appareil sans sac poussi res et ou filtres en place NE JAMAIS utiliser d accessoires autres que ceux recommand s par le fabricant NE JAMAIS pulv riser cet appareil d eau ou d autres liquides NE JAMAIS faire fonctionner l appareil l ext rieur e NE JAMAIS exposer l appareil la pluie la neige ou des temp ratures extr mes e TOUJOURS ranger cet appareil l int rieur dans un endroit sec et frais e TOUJOURS utiliser un agent antimousse pour aspirer les liquides savonneux TOUTES LES R PARATIONS DOIVENT TRE EFFECTU ES PAR UN DISTRIBUTEUR STATION SERVICE AUTORIS E NSS UTILISANT SEULEMENT DES PI CES ORIGINALES NSS CONSERVER CES INSTRUCTIONS G IMPORTANT SAFETY INSTRUCTIONS GROUNDING OF ELECTRICAL EQUIPMENT WARNING Improper connection of the equipment grounding conductor can result in a risk of electric shock Check with a qualified electrician or service person if you are doubt as to whether the outlet is properly grounded Do not modify the plug provided with the machine If outlet is not suitable for safe use have a proper outlet installed by a qualified electrician Always use a properly grounded 3 wire extension cord which has male and femal
10. e de choc lectrique V rifier aupr s d un lectricien ou d un r parateur qualifi si vous avez des doutes quanta la mise a la terre appropri e de la prise Ne pas modifier la fiche fournie avec la machine Si la sortie n est pas adapt pour une utilisation s curitaire avoir une bonne sortie install e par un lectricien qualifi Toujours utiliser une rallonge 3 fils mise a la terre et a prises male et femelle Si vous utilisez une rallonge de 25 pieds la capacit lectrique de transport doit tre d au moins 14 3 ST les rallonges de 50 pieds d au moins 12 3 ST INSTRUCTIONS DE MISE A LA TERRE Cet appareil doit tre mis a la terre lorsqu il est en marche pour prot ger l op rateur de tout choc lectrique L appareil est fourni avec un cordon 3 conducteurs et une fiche de branchement masse trois contacts La fiche doit tre branch e dans une prise appropri e install e et mise a la terre correctement selon tous les codes et ordonnances locaux Le conducteur vert du cordon est le fil de masse jamais brancher ce fila autre chose que la broche de masse de la fiche de branchement V rifier la plaque signal tique de l appareil pour tre certain que la tension et le cycle indiqu s sont les m mes que la prise lectrique Ne pas essayer de brancher un appareil de 120 volts a une prise de 240 volts ou un appareil de 240 volts a une prise de 120 volts Si l appareil est fourni avec une fiche de branchement tel qu
11. e plugs If 25 foot extension cords are used the electrical carrying capacity should be no less than 14 3 ST 50 foot extension cords no less than 12 3 ST GROUNDING INSTRUCTIONS This machine shall be grounded while in use to protect the operator from electric shock The machine is provided with a three conductor cord and a three contact grounding type attachment plug The plug must be plugged into an appropriate outlet that is properly installed and grounded in accordance with all local codes and ordinances The green conductor in the cord is the ground wire Never connect this wire to other than the grounding pin of the attachment plug Check nameplate on the machine to be sure voltage and cycle stated is the same as the electrical outlet Do not attempt to plug a 120 volt machine into a 240 volt outlet or a 240 volt machine into a 120 volt outlet If the machine is provided with an attachment plug as shown in Figure A below it is intended for use on a nominal 120 volt circuit If a properly grounded receptacle as shown in Figure A is not available an adapter may be installed as shown in Figure B if the outlet box that houses the receptacle is grounded Be sure to fasten the grounding tab the green colored rigid ear lug or the like extending from the adapter with a metal faceplate screw lf the machine is provided with an attachment plug as shown in Figure C it is intended for use on a nominal 240 volt circuit Changes to the attachment
12. he vac motor If the vacuum motor is flooded with liquids or foam immediately turn the motor OFF Consult your local distributor for complete chemical advice When using the wand with the squeegee tool on floors the operator should drop his her arm Slightly to allow air to enter the front edge of the tool on the forward stroke On the backward stroke the operator should raise their arm slightly to allow the back edge of the tool to clear the floor This method gives the air a chance to do the work in the most effective manner The operator should make strokes at a leisurely pace and at a length that feels the most natural Always work away from the machine pulling the machine behind you Dry Pick Up e Dry soil can be vacuumed directly into the tank e Clean or replace the filter bag when suction 1 reduced e Choose the proper wand and tool MAINTENANCE Routine maintenance is critical to ensure proper machine operation and cleaning performance Perform all maintenance procedures as follows WARNING Always unplug machine before performing any maintenance Daily Maintenance e Inspect the cord and plug for any damage NOTE To prevent damage to the AC power cord ALWAYS store the machine with the AC power cord coiled loosely over the machine Remove the hose from the machine at the end of each workday check for obstructions or damage Repair or replace as necessary The wand and tools should be removed from the
13. indiqu dans la figure A plus bas il doit donc tre utilis avec un circuit nominal de 120 volts S il n y a pas de prise mise a la terre telle qu indiqu dans la figure A disponible on peut installer un adaptateur tel qu indiqu dans la figure B si la boite a prises est mise a la terre S assurer d attacher la patte de mise a la terre boucle cosse rigide de couleur verte ou quelque chose de semblable sortant de l adaptateur avec une vis de plaque signal tique de m tal Si l appareil est fourni avec une fiche de branchement tel qu indiqu dans la figure C il doit donc tre utilis avec un circuit nominal de 240 volts Modifications du prise ou le rallonge a d autres types de prises doit se faire en conformit avec les r glements du pays map FIGURE FIGURE C 101 230V NOMINAL 50 60HZ 115V 60HZ eee CORD SHUKO CORD TYPE F INTERNATIONAL POUNDING CLIP MODELS ONLY 2 PATI SE GROUNDING A A ID CLIP PATTE DE mise ALA TERRE D 0 5 gt ak METAL SCREW 4 ROUNDED OUTLET BOX ROUNDING SITE DE SIRTIE
14. ions before operating or servicing machine ALWAYS use this machine ONLY as described in this manual NEVER attempt to operate this machine unless you have been trained in its operation NEVER allow an untrained person to operate this machine NEVER leave the machine plugged in to the electrical outlet when not in use NEVER unplug the machine from an electrical outlet until after the machine is turned off If appliance is not working as it should has been dropped damaged left outdoors or dropped into water return it to a service center NEVER disconnect or modify any switches or safety devices NEVER operate this machine if the cord and or plug has been damaged broken cut abraded or taped ALWAYS replace the entire cord when the cord or plug is damaged in any way NEVER handle the machine cord or plug with wet hands NEVER drop or insert any object into any machine opening NEVER operate this machine with any air opening blocked Keep all air openings free of dust lint hair etc NEVER pull or carry the machine by it s electrical supply cord use the cord as a handle close a door on the cord pull the cord around sharp edges or corners expose to heated surfaces run machine over cord or set heavy or sharp objects on the cord NEVER unplug by pulling on the cord To unplug the cord from the outlet grasp the plug not the cord NEVER allow this machine to be used as a toy Close attention is necessary when used
15. length return the machine to an authorized NSS Service center for service e Failure to inspect vacuum motor for carbon brush wear Can cause severe motor damage and failure e Check filters and gasket seals for wear or damage replace if necessary TROUBLESHOOTING Solution Cause Machine Does Not Damaged Switch Replace Switch Run Damaged Cord Carbon Brushes Worn Out Vacuum Motor Worn Out Replace Cord Replace Brushes Repair Replace Vac Motor Machine Has Poor Obstruction in Hose Tool Wand or intake Remove Obstruction Tank 1 Full Empty Tank Dirty Filters Clean or Replace Filters Adjust Coupling Connection _____________ Machine is Difficult Replace Wheels Repair service for this machine must be performed by an NSS authorized service center Repairs performed by an unauthorized company will void the machine warranty If you require assistance finding an authorized service center contact NSS Enterprises BRONCO 4 BRONCO 4 5798521 CORD BRONCO 4 4 8 240V __5__ 5796631 SCREW BRONCO488 6 6 5796641 TOP COVER BRONCO 488 1 8 5796661 MIDDLE COVER BRONCO 488 1 __9 5796671 INSULATION BRONCO 4 amp 8 1 7 5798511 MOTOR BRONCO 4 amp 8 240V 5798631 FILTER CAPACITOR BRONCO 4 amp 8 30 3394631 15A OVERLOAD PROTECTION DEVICE BRONCO 4 amp 8 SHOWN 3394641 THERMOSTAT BRONCO 4 amp 8 BRONCO 8 BRONCO 8 oo on 5798
16. n ou r paration AVERTISSEMENT Danger de choc ou d lectrocution NE JAMAIS brancher cet appareil a une prise lectrique qui n est pas mise a la terre correctement Voir les instructions de mise a la terre ADVERTENCIA Este producto contiene un quimico conocido al estado de California para causar defectos de cancer y nacimiento u otro dano reproductor A AVERTISSEMENT Pour reduire le risque d incendies de choc lectrique ou de blessures UTILISATION PREVUE Les appareils Bronco sont des appareils a utilisation commerciale pour aspirer les deversement humides et ou les debris secs des planchers dans un milieu int rieur Cet appareil N est PAS pour retirer l amiante ou les d chets dangereux NSS ne recommande pas d utiliser ces appareils a d autres fins En utilisant un appareil lectrique on doit suivre les pr cautions de bas y compris ce qui suit TOUJOURS lire et comprendre toutes les instructions avant d utiliser ou de r parer l appareil TOUJOURS utiliser l appareil SEULEMENT selon la description dans ce manuel NE JAMAIS essayer de faire fonctionner cet appareil a moins d tre form pour son utilisation NE JAMAIS permettre a une personne non form e de faire fonctionner cet appareil NE JAMAIS laisser l appareil branch dans la prise de courant lorsqu il n est pas utilis NE JAMAIS d brancher l appareil de la prise de courant avant qu il ne soit teint SI l appareil ne fonctionne pas correctement
17. plug or use of adaptors to other plug types must be done in accordance with local regulations IRE FIGURE 1 ISYZBOUZ 230V NOMINAL 50 60HZ ee SV A 1 PHASE 19V 60HZ SHUKO CORD TYPE F Ce INTERNATIONAL D MODELS ONLY KY IROLNDING 4 PATTE DE SE GROUNDING DE MISE 5 A LA TERRE z VIS META A ROUNDED ROUND ING LET GROUNDING LA IROUNDED LET BOX TEE A LA TERRE DE MISE n SORTIE ALA TERRE D _ ERRE NOTE In Canada the use of a temporary adaptor may not be permitted by Canadian electrical code ALL REPAIR SERVICE MUST BE PERFORMED BY AN NSS AUTHORIZED DISTRIBUTOR SERVICE STATION USING ONLY NSS ORIGINAL EQUIPMENT PARTS SAVE THESE INSTRUCTIONS IMPORTANTES INSTRUCTIONS DE SECURITE MISE A LA TERRE DE L EQUIPEMENT ELECTRIQUE AVERTISSEMENT Toute mauvaise connexion de l appareil conducteur de mise a la terre peut risqu
18. wet pick up Brush tools for bare floors or dusting Chrome Steel Wand When assembling the 2 pieces be sure to line up the indicators prior to connecting the parts together The top end of the upper half of the wand connects to the hose The bottom end the upper half fits over the upper end of the lower half of the wand e Connect the proper tool to the bottom of the bottom half of the wand with a friction fit Optional Front Mount Squeegee The squeegee mounts to the base of the machine and is used for vacuuming large areas of water spills or to pick up excess liquids after stripping floors Dusting For overhead areas use the two piece tube kit For routine dusting attach the dusting brushes or crevice tool directly to the end of the hose MACHINE OPERATION With the switch in the off position plug the electrical cord into an approved outlet To turn the machine on use the switch located on the lid of the machine Wet Pick Up e Remove the polyester filter for wet pickup e Empty the tank e As the liquid level rises the built in float will be activated The built in float will not be activated by foam The motor will soeed up and sound different when the airflow is closed off Turn the vacuum off and drain liquids according to your local EPA regulations NSS recommends that you always use a defoamer agent along with low foaming chemicals diluted according to manufacturers specifications in order to protect t
Download Pdf Manuals
Related Search