Self Contained (Wet) and Stationary Compactor (Dry)
Contents
1. Rotobale Compaction Solutions Inc Kenilworth Ontario NOG 2E0 Tele 519 323 3673 Fax 519 323 3816 Self Contained Wet and Stationary Compactor Dry Operating Instructions Models RC 4260 C Series Compactors TO TURN ON COMPACTOR Insert the key into the switch and turn right to the on position If the power on light does not illuminate disengage the emergency stop button see below and push start If the power on light still does not illuminate and the full light is on the container needs to be emptied Remove key when the compactor is not in use EMERGENCY STOP BUTTON Press to stop the compactor The compactor will remain in the off mode until the emergency stop button is disengaged To disengage rotate the knurled outer edge of the stop button in direction of arrow The emergency stop button plunger will pop out and the power on light will illuminate allowing the compactor to be started FULL LIGHT When pressure inside the charging chamber reaches a preset limit approx 1500 psi the full light will illuminate and the compactor will shut off The container needs to be emptied RESET Press the reset button to deactivate the full and 75 full lights This will reset the system and enable it to start REVERSE BUTTON Press the reverse button to engage the ram in reverse mode 75 FULL LIGHT Optional The light will illuminate when pressure inside the charging chamber r2. Some units may be purchased with extended warranties Voiding of Warranty If the contents of this manual are explicitly followed the operation of the Rotobale compactor is under warranty If however operations are performed in a manner not in accordance with these instructions and a defect results the Rotobale warranty shall be rendered void In addition defects resulting from service work not authorized by RCS shall render the warranty void Revision 04_08
3. eaches a preset limit approx 1000 psi PRESSURE GAUGE Optional Indicates compaction system pressure MULTI CYCLE TIMER Optional Will allow the ram to continuously run through a preset number of complete cycles before the compactor shuts off Dumper Handle Optional Used to overturn and dump containers into hopper Winch Handle Optional Used to pull container into place Revision 04_08 Rotobale Compaction Solutions Inc Kenilworth Ontario NOG 2E0 Tele 519 323 3673 Fax 519 323 3816 Self Contained Wet and Stationary Compactor Dry Maintenance Manual Models RC 4260 C Series Compactors Hydraulic System The manufacturer recommends regular inspection of all hoses and visual inspection of hydraulic components All inspections must be done with compactor disabled By doing so the user becomes more familiar with the compactor which in turn guarantees early detection of possible problems E g leaks When inspecting hoses look for cuts abrasions and fluid Look for leaks around the power pack at all hose connections and inside the rear of the compaction chamber If any hydraulic fluid is visible the user should contact the manufacturer The hydraulic fluid level in the power pack reservoir should be maintained at 2 from the top of the tank with the ram in the rear position Only a qualified technician should service any components in the hydraulic system Lockout Procedure NOTE Only a qualified
4. technician Should perform work on electrical system The person working on these machines should turn the machine off with the stop button To turn off and lockout the power supply follow the electrical supply cord from the machine to the disconnect box on the wall This box should be located within 30 feet of the machine Pull the handle down or turn the switch to the off position to shut off the electricity Put a padlock through the holes of the handle or switch and lock it so that it cannot be turned on without removing the lock Only the person locking out the machine should have a key for the padlock If more than one person is involved the person who disconnected and locked out the power supply should communicate the purpose and status of the disconnecting and locking out A non conducting tag secured in a conspicuous location may serve this purpose For more guidelines concerning this procedure refer to the Occupational Health and Safety Act and Regulations for Industrial Establishments section Warranty All equipment designed and manufactured by Rotobale Compaction Solutions Inc RCS carries a 1 year parts and labour guarantee A Rotobale waste system is constructed of high grade materials and is guaranteed to perform on a continued basis at its rated capacity Any parts that prove defective within 1 year from the date of installation will be replaced without charge provided the purchaser notifies any such defects to RCS
Download Pdf Manuals
Related Search