User Manual Invacare PreciseR ™ Pediatric Flowmeter
Contents
1. F ANY WARRANTY WHATSOEVER SHALL BE LIMITED TO REPAIR OR REPLACEMENT OF THE DEFECTIVE PRODUCT PURSUANT TO THE TERMS CONTAINED HEREIN THE APPLICATION OF ANY IMPLIED WARRANTY WHATSOEVER SHALL NOT EXTEND BEYOND THE DURATION OF THE EXPRESS WARRANTY PROVIDED HEREIN INVACARE SHALL NOT BE LIABLE FOR ANY CONSEQUENTIAL OR INCIDENTAL DAMAGES WHATSOEVER SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGE OR LIMITATION OF HOW LONG AN IMPLIED WARRANTY LASTS SO THE ABOVE EXCLUSION AND LIMITATION MAY NOT APPLY TO YOU THIS WARRANTY SHALL BE EXTENDED TO COMPLY WITH STATE PROVINCIAL LAWS AND REQUIREMENTS Part No 2001105 7 Invacare PreciseR Pediatric Flowmeter Yes you can Invacare Corporation www invacare com USA One Invacare Way Elyria Ohio USA 44036 2125 440 329 6000 800 333 6900 Technical Services 440 329 6593 800 832 4707 Canada 570 Matheson Blvd E Unit 8 Mississauga Ontario L4Z 4G4 905 890 8300 800 668 5324 Part No 2001105 Invacare Corporation 2101 E Lake Mary Blvd Sanford FL 32773 800 832 4707 2010 Invacare Corporation All rights reserved Republication duplication or modification in whole or in part is prohibited without prior written permission from Invacare Trademarks are identified by and All trademarks are owned by or licensed to Invacare Corporation or its subsidiaries unless otherwise noted Rev G 06 102. User Manual DEALER These instructions MUST be given to the user of the product USER BEFORE using this product read this manual and save for Yes you can future reference Invacare PreciseR Pediatric Flowmeter Model IRCPF16 General 1 1 Symbols Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage See the information below for definitions of the signal words A WARNING Warning indicates a potentially hazardous situation which if not avoided could result in death or serious injury CAUTION Caution indicates a potentially hazardous situation which if not avoided may result in property damage or minor injury or both Gives useful tips recommendations and information for efficient trouble free use Part No 2001105 Invacare PreciseR Pediatric Flowmeter 2 Safety WARNING A DO NOT USE THIS PRODUCT OR ANY AVAILABLE OPTIONAL EQUIPMENT WITHOUT FIRST COMPLETELY READING AND UNDERSTANDING THESE INSTRUCTIONS AND ANY ADDITIONAL INSTRUCTIONAL MATERIAL SUCH AS OWNER S MANUALS SERVICE MANUALS OR INSTRUCTION SHEETS SUPPLIED WITH THIS PRODUCT OR OPTIONAL EQUIPMENT IF YOU ARE UNABLE TO UNDERSTAND THE WARNINGS CAUTIONS OR INSTRUCTIONS CONTACT A HEALTHCARE PROFESSIONAL DEALER OR TECHNICAL PERSONNEL BEFORE ATTEMPTING TO USE THIS EQUIPMENT OTHERWISE INJURY OR DAMAGE MAY OCCUR ACCESSORIES WARNING Invacare products are speci
3. bility of the purchaser to return the entire unit or remove at purchaser s cost the defective component part s identified pack the component part s in a manner to avoid shipping damage and to ship the component part s to either Invacare Corporation s plant or service center as specified by Invacare Corporation in advance Defective component part s MUST be returned for warranty inspection using the serial number as identification within thirty days of return authorization date DO NOT return products to our factory without prior consent C O D shipments will be refused please prepay shipping charges LIMITATIONS AND EXCLUSIONS THE FOREGOING WARRANTY SHALL NOT APPLY TO PRODUCTS SUBJECTED TO NEGLIGENCE ACCIDENT IMPROPER OPERATION MAINTENANCE OR STORAGE SOOT OR SMOKE FILLED ENVIRONMENTS OR OTHER THAN NORMAL APPLICATION USE OR SERVICE OR TO PRODUCTS MODIFIED WITHOUT INVACARE CORPORATION S EXPRESS WRITTEN CONSENT INCLUDING BUT NOT LIMITED TO MODIFICATION THROUGH THE USE OF UNAUTHORIZED PARTS OR ATTACHMENTS OR TO PRODUCTS DAMAGED BY REASON OF REPAIRS MADE TO ANY COMPONENT WITHOUT THE SPECIFIC CONSENT OF INVACARE CORPORATION OR TO PRODUCTS DAMAGED BY CIRCUMSTANCES BEYOND INVACARE CORPORATION S CONTROL THE FOREGOING EXPRESS WARRANTY IS EXCLUSIVE AND IN LIEU OF ANY OTHER WARRANTIES WHATSOEVER WHETHER EXPRESS OR IMPLIED INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE AND THE SOLE REMEDY FOR VIOLATIONS O
4. fer servicing to qualified service personnel Check ALL parts for shipping damage If shipping damage is noted DO NOT use Contact carrier dealer for further instructions Invacare PreciseR Pediatric Flowmeter 2 Part No 2001105 3 Overview 3 1 Package Contents This model number includes DESCRIPTION QUANTITY Flowmeter Stand Crush Proof Tubing CP 25 ft Max 7 5 m Crush Proof Tubing 7 ft 2 1 m total Humidifier Bottle Adapter Humidifier Bottle Connector Packaging Carton Instructions 3 2 Typical Product Parameters INPUT PRESSURE RATING 345 3 45 KPa 5 0 5 psi OXYGEN INPUT 2 Limin OXYGEN OUTPUT 0 750 cc min 0 4 L min FLOW ADJUSTABLE IN 50 cc min 1 16 L min INCREMENTS FLOW ACCURACY 10 of full scale WIDTH 11 94 cm 47 in HEIGHT 14 48 cm 5 7 in DEPTH 14 48 cm 5 7 in WEIGHT 0 8 kg 1 86 Ibs SHIPPING WEIGHT LT kg 2 40 Ibs OPERATING TEMPERATURE 10 35 C 50 95 F STORAGE TEMPERATURE 29 to 70 C 20 to 158 C 3 3 Unpacking Inspection Handling 1 Check for any obvious damage to the carton or its contents If damage is evident notify your carrier dealer for further instruction 2 Remove all the loose packing from the carton 3 Carefully remove all the components from the carton Packing materials and carton should be
5. fically designed and manufactured for use in conjunction with Invacare accessories Accessories designed by other manufacturers have not been tested by Invacare and are not recommended for use with Invacare products gt WARNING A DO NOT SMOKE while using this device Keep all matches lit cigarettes or other sources of ignition out of the room in which this product is located and away from where oxygen is being delivered NO SMOKING signs should be prominently displayed Textiles and other materials that normally would not burn are easily ignited and burn with great intensity in oxygen enriched air Failure to observe this warning can result in severe fire property damage and cause physical injury or death A spontaneous and violent ignition may occur if oil grease or greasy substances come in contact with oxygen under pressure Example of items to avoid are hand creams or lotions cooking oils suntan oils or sunblocks and similar oily products If you use these types of products wash your hands prior to using this product These substances MUST be kept away from the oxygen concentrator tubing and connections and all other oxygen equipment DO NOT use any lubricants unless recommended by Invacare The PreciseR Pediatric Flowmeter is designed for an input pressure of 34 5 kPa 5 psi only The flowmeter is applicable only with Invacare concentrators with 34 4 kPa 5 psi output pressure Keep out of reach of children DO NOT disassemble Re
6. he On position The power light located on the control panel will illuminate GREEN The alarm will beep indicating that the system is functioning properly 4 Set the oxygen concentrator to 2 0 L min Allow concentrator to run a minimum of 10 min to ensure proper concentration level Set Up If A Humidifier Bottle Is Not Prescribed For this procedure refer to FIGURE I I Connect a 2 1 m 7 ft oxygen tubing from the output fitting of the concentrator to the input fitting on the Pediatric Flowmeter 2 Connect a 7 6 m 25 ft max length oxygen tubing not shown to the output fitting on the Pediatric Flowmeter 3 Attach the opposite end of the oxygen tubing to a nasal cannula using an appropriate oxygen tubing connector as applicable not shown Invacare PreciseR Pediatric Flowmeter 4 Pediatric Flowmeter Output Fitting eee eee Fitting ooo E 2 1 m 7 ft if Oxygen Tubing FIGURE Typical Setup Set Up If A Humidifier Bottle Is Not Prescribed Part No 2001105 Set Up With A Humidifier Bottle If Prescribed For this procedure refer to FIGURE 2 l Connect a 2 1 m 7 ft max oxygen tubing from the output fitting of the concentrator to the input fitting on the pediatric flowmeter 2 Follow the directions supplied by the humidifier bottle manufacturer for instructions on filling and connecting to oxygen tubing 3 After filling the humidifier bottle with water place it in the
7. humidifier compartment on the Invacare concentrator see concentrator owner s manual for mounting the bottle 4 Connect 2 1 m 7 ft max oxygen tubing from the pediatric flowmeter output fitting to the inlet of the humidifier bottle using an appropriate adapter if applicable 5 Connect 7 6 m 25 ft max oxygen tubing to the outlet of the humidifier bottle not shown 6 Attach the opposite end of the oxygen tubing to a nasal cannula using an appropriate oxygen tubing connector not shown A CAUTION DO NOT coil crush resistant oxygen tubing on COLD floor or condensation will form inside the tubing 2 1 m 7 ft Oxygen Output Fitting Tubing gt Inlet of Pediatric Flowmeter Input Fitting Ou FIGURE 2 Typical Setup Set Up With A Humidifier Bottle If Prescribed Part No 2001105 5 Invacare PreciseR Pediatric Flowmeter Setting The Flowrate On The Pediatric Flowmeter For this procedure refer to FIGURE 3 WARNING A DO NOT select a different setting unless your physician has prescribed a change in the flowrate of the PreciseRy Pediatric Flowmeter A CAUTION DO NOT allow water or other substances to enter flowmeter openings DO NOT submerge flow stand flowmeter or tubing Set the pediatric flowmeter to the setting prescribed by your physician Flowrate on the standard concentrator flowmeter will drop below the 2 0 L min setting after the Invacare PreciseRy Pediatric Flowmeter is installed and o
8. kept for future use 4 Examine exterior of the flowmeter for nicks dents scratches or other damages Inspect all components Storage l Store the repackaged flowmeter in a dry area 2 DO NOT place other objects on top of the repackaged device Part No 2001105 3 Invacare PreciseR Pediatric Flowmeter 4 Usage 4 1 Typical Setup A WARNING Place cannula on patient only after all tubing connections have been made Possible water feedback through the tubing could occur if this sequence is not followed When adjusting the Pediatric Flowmeter the flowmeter on the oxygen concentrator MUST be set 2 0 L min Failure to comply with this procedure will cause incorrect flow rates to the patient Invacare recommends that crush resistant oxygen tubing be used with this product Ifa humidifier bottle is not prescribed the oxygen tubing is not to exceed 7 6 m 25 ft in total length from the Pediatric Flowmeter to the patient and the total length of ALL tubing CANNOT exceed 15 2 m 50 ft If a humidifier bottle is prescribed the oxygen tubing is not to exceed 7 6 m 25 ft in total length from the humidifier bottle to the patient and the total length of ALL tubing for the Pediatric Flowmeter CANNOT exceed 1 8 m 39 ft For this procedure refer to FIGURE or FIGURE 2 Place the pediatric flowmeter stand on table top Turn the pediatric flowmeter knob to the fully open position Press concentrator power switch to t
9. nder this warranty will end upon any such subsequent sale or other transfer of title to any other person This warranty gives you specific legal rights and you may also have other legal rights which may vary from state to state Invacare Corporation warrants its Pediatric Flowmeter when purchased new and unused to be free from defects in materials and workmanship for a period of one year from date of purchase from Invacare or a dealer with a copy of the seller s invoice required for coverage under this warranty If within such warranty periods any such product shall be proven to Invacare Corporation s satisfaction to be defective such product shall be repaired or replaced at Invacare Corporation s option This warranty only applies to the labor for repairs performed by the Invacare Service Department or Invacare Authorized Service Centers It does not apply to the labor performed by the purchaser or user This warranty does not include normal wear and tear or shipping charges Invacare Corporation s sole obligation and your exclusive remedy under this warranty shall be limited to such repair or replacement Routine maintenance items such as filters are excluded from this warranty For warranty service please contact Invacare Corporation s Service Department at the toll free number on the back cover Upon receiving notice of an alleged defect in a product Invacare Corporation will issue a serialized return authorization It shall then be the responsi
10. perating 2 Center the ball of the Pediatric Flowmeter with the line of the prescribed flowrate This will ensure an accurate flowrate 3 Place cannula on the patient Ball Flowmeter FIGURE 3 Setting The Flowrate On The Pediatric Flowmeter 5 Care and Maintenance 5 1 Cleaning The unit can be cleaned with warm soapy water Rinse with a soft damp cloth and dry thoroughly The humidifier bottle MUST be cleaned after each use Humidifier bottle and tubing MUST be changed after each patient 5 2 Service and Preventative Maintenance CAUTION DO NOT allow water or other substances to enter flowmeter openings DO NOT submerge flow stand flowmeter or tubing The PreciseR Pediatric Flowmeter is specifically designed to minimize routine preventive maintenance If damage to the unit is suspected or if for any reason flow accuracy is in question Invacare recommends returning the unit to Invacare for calibration by qualified personnel Invacare PreciseR Pediatric Flowmeter 6 Part No 2001105 6 Limited Warranty NOTE THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4 1975 This warranty is extended only to the original purchaser who purchases this product when new and unused from Invacare Corporation or a dealer This warranty is not extended to any other person or entity and it is not transferable or assignable to any subsequent purchaser or owner Coverage u
Download Pdf Manuals
Related Search