Leica GKL221 Charger User Manual
Contents
1. _en_GKL221_User book Page 1 Monday April 11 2011 2 30 PM E Leica GKL221 Charger User Manual f Version 1 2 i English when it has to be right Seica Geosystems I Introduction Y AIS _en GK L221_User book Page 2 Monday April 11 2011 2 30 PM AW Product identification Symbols This manual contains important safety directions as well as instructions for setting up the product and operating it Refer to 4 Safety Directions for further information Read carefully through this manual before switching on the product The model and the serial number of the product are indicated on the type plate Enter the model and serial number in this manual and always refer to this information when contacting the agency or Leica Geosystems authorized service workshop Type Serial No The symbols used in this manual have the following meanings Type Description N Danger Indicates an imminently hazardous situation which if not avoided will result in death or serious injury N Warning Indicates a potentially hazardous situation or an unintended use which if not avoided could result in death or serious injury A Caution Indicates a potentially hazardous situation or an unintended use which if not avoided may result in minor or moderate injury and or appreciable material financial and environmental damage S Important paragraphs which must be adhered to in practic2. o 28 ZY Y _en_GKL221_ User book Page 29 Monday April 11 2011 2 30 PM Conservation charging mode for e NiCd and NiMH batteries Charging current depends on the type of battery Charging is done in turns of about fifteen seconds per battery Q S Li lon batteries do not require conservation charging as they do not loose their charge when not used Charging technology Switch off conditions in the quick charging mode E For NiCd and NiMH batteries For Li lon batteries Timer Timer Capacity Capacity Battery temperature Battery temperature Negative voltage difference Charging current Temperature increase per minute Double inflection method Conservation charging of NiCd and NiMH batteries Monitors battery voltage charging current and battery temperature Cell type e NiCd e NiMH e Li lon 29 Technical Data GKL221 o d _en_GKL221_ User book Page 30 Monday April 11 2011 2 30 PM NY is Recharging and Recharging and discharging times depend primarily on the charging and discharging current the discharging times capacity of the battery and the state of charge it is in when connected The following guidelines can be given Quick charging at 20 C PEN NiCd batteries NiMH batteries Li lon batteries max 2200 mAh 1 0 to 1 5 h max 2200 mAh 1 5 to 2 0 h max 4600 mAh 2 5 to 3 5h max 7200 mAh2 5 to 4 0 h max 4900 mAh 2 0 to 2 5h max 10000 mAh2 5to 5 5 h Discharging F
3. GKL221 Operation 16 amp L ZS _en_GKL221 User book Page 17 Monday April 11 2011 2 30 PM 2 6 Explaination of the symbols Operation indicators Status indicators Indicators Symbol Meaning O LED Off sdy LED on permanently 7 sm ee LED flashes oe Symbol LED Meaning O Off The charger is not connected to the power supply wu Green The charger is connected to the power supply x l Symbol LED Meaning O Off The connected battery was not recognized sdy Yellow The connected battery was recognized The charger is in Pas stand by mode as two other batteries are being charged or discharged sy Green The connected battery is now being charged w l Green The connected battery is fully charged and can be removed ANS 17 Operation GKL221 S I Y AIS _en GKL221_User book Page 18 Monday April 11 2011 2 30 PM Symbol LED Meaning sdy Red The charger has detected an error l wiw Red A battery to be refreshed is connected The battery is being 9 discharged a Yellow Indicates the active selected bay Capacity and error indica In normal operation the three capacity and error indicators light up green to indicate the capacity tors of the battery in the selected bay After selecting the bay the indicators light up for about ten to fifteen seconds then they swi
4. Two batteries can be charged at the same time With more than two batteries connected the rest are charged in the order they were connected Beside charging the charger can also discharge and refresh batteries co We recommend starting up the product at this point while continuing to read the Operating Instructions GKL221 System Description 4 g ik WB Alls 4 _en_GKL221_ User book Page 5 Monday April 11 2011 2 30 PM System components A AALI E ith 5288 h GKL221_002 8 Mains cable specific for relevant country b Mains cable socket on the charger c Adapter bays and II for the GDI221 GDI222 i Capacity and error indicators battery adapters j Selection button d External battery cable connection k Status indicator for external battery connection e Cable socket for external 5 pole batteries I GDI221 battery adapter optional f Vehicle adapter GDC221 optional m Battery status indicators g Vehicle cable socket on the charger n GDI222 battery adapter and 5 pole charging h Function indicator cable optional 5 System Description GKL221 aa VA i bs _en_GKL221_User book Page 6 Monday April 11 2011 2 30 PM Rechargeable batteries The following Leica Geosystems batteries can be charged GEB90 E GEB111 Tn ee GEB211 GEB121 0 fi lp GEB212 At O GEB221 Gef GEB87 GEB77 GEB79 GEB70 GEB71 GEB171 GKL221_014 Ee The c
5. GEB111 or GEB121 and one NiCd or NiMH 5 pole battery GKL221 Operation g P e VA bs _en_GKL221_User book Page 9 Monday April 11 2011 2 30 PM Inserting and removing GKL221_005 GKL221_006 Inserting Removing 1 Insert the battery adapter along the rear 1 Press on the front edge of the battery adapter guiding edge to open it 2 Press on the front of the battery adapter until 2 Carefully lift it up to the stop point it clicks and locks into place 3 Remove the adapter by pulling it out forwards 2 2 Connecting the Charger N Warning Only use the charger in dry rooms Never use the charger when it is wet or damp Start up Always set the charger on a firm surface before starting it up Connect the charger either e With the supplied mains cable to the mains power socket or e With the optional GDC211 vehicle adapter to the battery circuit of a vehicle Operation GKL221 v _en_GKL221_ User book Page 10 Monday April 11 2011 2 30 PM NY iss S Pull the plug from the mains socket and from the vehicle s power socket if the charger will not be used for a long period S Only use the vehicle adapter for power supply from a vehicle If the power supply comes from other sources such as transformers malfunctions could occur Refer to section 5 Technical Data for infor EN mation on voltage and rated power S Check older vehicles and makes sure that the pole is on the middle
6. can lead to injury malfunction and damage It is the task of the person responsible for the equipment to inform the user about hazards and how to counteract them The product is not to be oper ated until the user has been instructed on how to work with it GKL221 Safety Directions 22 g ik Z y _en_GKL221_ User book Page 23 Monday April 11 2011 2 30 PM 4 3 Environment 4 4 Manufacturer of the product Manufacturers of non Leica Geosystems accessories Person in charge of the product AN Warning Limits of Use Suitable for use in dry environment only and not under adverse conditions Areas of Responsibilities Leica Geosystems AG CH 9435 Heerbrugg hereinafter referred to as Leica Geosystems is respon sible for supplying the product including the user manual and original accessories in a completely safe condition The manufacturers of non Leica Geosystems accessories are responsible for developing imple menting and communicating safety concepts for their products and are also responsible for the effec tiveness of those safety concepts in combination with the Leica Geosystems product The person in charge of the product has the following duties e To understand the safety instructions on the product and the instructions in the user manual e To be familiar with local regulations relating to safety and accident prevention To inform Leica Geosystems immediately if the pro
7. contact surface of the cigarette lighter socket Should the polarity be wrong then the fuse in the charger or the fuse in the vehicle adapter has to be changed The fuse in the charger has to be changed by an authorised Leica Geosys tems service workshop The fuse in the vehicle adapter has to be changed as described in the manual of the adapter Function check After the adapter is connected to the mains or to the vehicle s battery circuit the red yellow and green function indicators light up once the capacity and error indicators light up red and green This is a func tion check If no battery was inserted then only the green function indicator will light up If the status indicator and the three capacity and error indicators light up and remain red then a defect was detected Refer to section 2 6 Indicators for additional information GKL221 Operation 10 a 9 6 Fic _en_GKL221 User book Page 11 Monday April 11 2011 2 30 PM 2 3 Inserting and Removing the Batteries Li lon batteries Inserting 1 Insert the battery flush to the front edge of the GDI221 battery bay 2 Push the battery downwards with only slight EN pressure to the stop position Removing e Push the battery backwards to the stop and then remove it GKL221_007 N Warning Only charge or discharge batteries recommended by Leica Geosystems Only use Leica Geosystems Li lon batteries 11 Operation GKL221 v VA
8. is power coming from the mains or vehicle battery power circuit e If the cables are all correctly connected and no obvious faults can be detected e If the function indicator is lit on the optionally connected vehicle adapter 19 Operation GKL221 aa Bik I AIS _en GKL221_User book Page 20 Monday April 11 2011 2 30 PM 2 7 Tips Tips To charge batteries to their full capacity new NiCd and NiMH batteries should be fully discharged and charged three to five times e Letthe batteries in the instrument discharge as much as possible It prevents the so called memory EN effect with NiCd batteries When using the vehicle adapter always keep the motor running while charging the batteries co Avoid sudden ambient temperature changes while charging the batteries e g do not let the sun shine directly on the batteries or on the charger Sudden ambient temperature changes may cause the charging process to end prematurely without having fully charged the batteries GKL221 Operation 20 g ik VA z S _en_GKL221_ User book Page 21 Monday April 11 2011 2 30 PM Shipment 3 2 Product 3 3 Product Cables and plugs Care and Transport Transport When transporting the product by rail air or sea always use the complete original Leica Geosystems FEN packaging transport container and cardboard box or its equivalent to protect against shock and vibra tion Storage Respect the tem
9. as been tested and found to comply with the limits for a Class B digital device pursuant to part 15 of the FCC Rules These limits are designed to provide reasonable protection against harmful interference in a residential installation This equipment generates uses and can radiate frequency energy and if not installed and used in accordance with the instructions may cause harmful interference to radio communications However there is no guarantee that interference will not occur in a particular installation If this equipment does cause harmful interference to radio or television reception which can be deter mined by turning the equipment off and on the user is encouraged to try to eliminate the interference by one or more of the following measures e Reorient or relocate the receiving antenna e Increase the separation between the equipment and the receiver GKL221 Safety Directions 26 g ik Zi _en_GKL221_ User book Page 27 Monday April 11 2011 2 30 PM AN Warning Labels Connect the equipment to an outlet on a circuit different from that to which the receiver is connected e Consult the dealer or an experienced radio TV technician for help Changes or modifications not expressly approved by Leica Geosystems for compliance could void the user s authority to operate the equipment GKL221_013 ey cause undesired operation This device complies with part 15 of the FCC Rules Operat
10. d and ready for use Refer to section Charging modes for more information 15 Operation GKL221 aa 9 4 S z7 ZY Y ZIN _en_GKL221 User book Page 16 Monday April 11 2011 2 30 PM Refreshing the battery o The refresh function totally discharges the battery and then puts it on quick charge Step Description 1 Connect the charger to the power supply 2 Insert the battery The yellow status indicator flashes to indicate that the battery has been recognized 3 Press the selection button for more than three seconds to start the process of discharging the battery Discharging is indicated by the red status indicator flashing cE Discharging may take a long time for large capacity batteries To keep discharge times short only use this function with batteries that are empty or low on charge 4 When the battery has been discharged it is put on quick charge The status indicator lights up green 5 The battery has been completely charged when the green status indicator starts to flash We recommend refreshing NiCd and NiMH batteries two to three times when their capacity starts to sink noticeably For Li lon batteries a single discharging and charging cycle is sufficient We recommend carrying out the process when the battery capacity indicated on the charger or on a Leica Geosystems product deviates significantly from the actual battery capacity available
11. duct becomes unsafe The person responsible for the product must ensure that it is used in accordance with the instructions This person is also accountable for the training and the deployment of personnel who use the product and for the safety of the equipment in use 23 Safety Directions GKL221 Lp AIS _en GKL221_User book Page 24 Monday April 11 2011 2 30 PM 4 5 Hazards of Use AN Warning The absence of instruction or the inadequate imparting of instruction can lead to incorrect or adverse use and can give rise to accidents with far reaching human material financial and environmental EN consequences Precautions All users must follow the safety directions given by the manufacturer and the directions of the person responsible for the product N Warning The product is not designed for use under wet and severe conditions If unit becomes wet it may cause you to receive an electric shock Precautions Use the product only in dry environments for example in buildings or vehicles Protect the product against humidity If the product becomes humid it must not be used AN Warning If you open the product either of the following actions may cause you to receive an electric shock Touching live components e Using the product after incorrect attempts were made to carry out repairs Precautions Do not open the product Only Leica Geosystems authorized service workshops are entitled to repair thes
12. e as they enable the product to be used in a technically correct and efficient manner GKL221 Introduction aa S Z Z Zi I _en_GKL221_User book Page 3 Monday April 11 2011 2 30 PM Table of Contents In this manual Chapter Page 1 System Description 2 Operation 2 1 Battery Adapter 8 2 2 Connecting the Charger 9 2 3 Inserting and Removing the Batteries 11 2 4 Selection Button 14 2 5 Charging the Battery 15 2 6 Indicators 17 2 7 Tips 20 3 Care and Transport 21 3 1 Transport 21 3 2 Storage 21 3 3 Cleaning and Drying 21 4 Safety Directions 22 4 1 General 22 4 2 Purpose 22 4 3 Limits of Use 23 4 4 Areas of Responsibilities 23 4 5 Hazards of Use 24 4 6 Electromagnetic Compatibility EMC 25 4 7 FCC Statement Applicable in U S 26 5 Technical Data 28 Table of Contents GKL221 E Lp AIS _en_GKL221_ User book Page 4 Monday April 11 2011 2 30 PM 1 System Description Description The Leica Geosystems GKL221 is an intelligent charger with advanced charging technology It is designed to charge all Leica batteries As power supply the mains as well as GDC221 vehicle dapter connected to the cigarette lighter socket of a vehicle can be used The GKL221 is a very useful comple EN ment to all of your battery operated Leica Geosystems products General information Up to five batteries can be connected to the charger
13. e products AN Warning Batteries not recommended by Leica Geosystems may be damaged if charged or discharged They may burn and explode Precautions Only charge and discharge batteries recommended by Leica Geosystems GKL221 Safety Directions 24 g ik I AIS _en GKL221_User book Page 25 Monday April 11 2011 2 30 PM N Warning If the product is improperly disposed of the following can happen e If polymer parts are burnt poisonous gases are produced which may impair health e If batteries are damaged or are heated strongly they can explode and cause poisoning burning corrosion or environmental contamination e By disposing of the equipment irresponsibly you may enable unauthorized persons to use it in contravention of the regulations exposing themselves and third parties to the risk of severe injury TEN and rendering the environment liable to contamination Precautions The product must not be disposed with household waste Dispose of the product appropriately in accordance with the national regulations in force in your country Always prevent access to the product by unauthorized personnel Product specific treatment and waste management information can be downloaded from the Leica Geosystems home page at http www leica geosystems com treatment or received from your Leica Geosystems dealer 4 6 Electromagnetic Compatibility EMC Description The term Electromagnetic Compatability is taken to
14. harger is designed to recharge and discharge original Leica batteries as well as some NiMH NiCd camcorder batteries Refer to section 2 3 Inserting and Removing the Batteries for more information a GKL221 System Description 6 P e ZY Y Q _en_GKL221_ User book Page 7 Monday April 11 2011 2 30 PM Using the charger in combination with the battery adapters enables the following batteries to be Charger and battery o adapters connected to the charger Charger battery adapter Rechargeable batteries GKL221 with two GDI221 Up to four Li lon batteries and one battery with a 5 pole socket GKL221 with one GDI221 and one GDI222 Up to two Li lon batteries one camcorder type battery and two batteries with 5 pole sockets GKL221 with two GDI222 Up to two camcorder type batteries and three batteries with 5 pole sockets 7 System Description GKL221 amp a al iis o _en_GKL221_User book Page 8 Monday April 11 2011 2 30 PM 2 1 Purpose Type Operation Battery Adapter o The battery adapter connects the charger to the corresponding batteries and has one LED per charging bay that indicates the status of the battery The following battery adapters are available GKL221_003 GDI221 e For two Leica Geosystems Li lon batteries GEB90 GEB211 GEB212 GEB221 or GEB241 GKL221_004 GDI222 e For one Leica Geosystems NiMH battery
15. ion is subject to the following two conditions 1 This device may not cause harmful interference and 2 this device must accept any interference received including interference that d 27 Safety Directions GKL221 S Z y _en_GKL221_ User book Page 28 Monday April 11 2011 2 30 PM 5 Power supply EN Input voltage Charging power Discharging Power rating Operating environment Temperature range Charging modes Technical Data e Mains connection e D C voltage connection e 100 240 VAC 50 60 Hz e 24VDC Maximum 18 VDC maximum 4 0 A depends on the type of battery 4w 75W 155 W Only operate in dry environments e g in buildings and vehicles IP40 according to IEC60529 Storage 40 C to 70 C 40 F to 158 F Operating sis 0 C to 40 C 32 F to 104 F i 0 C to 50 C 32 F to 122 F Quick charging mode for e All Leica Geosystems batteries It features temperature monitoring and battery recognition Charging current is maximum 4 0 A depending on the battery All standard camcorder batteries with three contact surfaces and temperature monitoring Charging current maximum 1 6 A Normal charging mode for e NiCd and NiMH batteries with temperature below 10 C e Li lon batteries with temperature below 6 C Almost or totally empty Li lon NiCd and NiMH batteries GKL221 Technical Data
16. mean the capability of the product to function smoothly in an environment where electromagnetic radiation and electrostatic discharges are present and without causing electromagnetic disturbances to other equipment AN Warning Electromagnetic radiation can cause disturbances in other equipment Although the product meets the strict regulations and standards which are in force in this respect Leica Geosystems cannot completely exclude the possibility that other equipment may be disturbed 25 Safety Directions GKL221 40 I AIS _en GKL221_User book Page 26 Monday April 11 2011 2 30 PM N Caution May cause failure in other equipment if the product is used with third party components e g third party cables or external batteries Precautions Only use equipment or accessories recommended by Leica Geosystems When combined with the product they meet the strict requirements stipulated by the guidelines and standards AN Warning If the product is operated with connecting cables attached at only one of their two ends for example external supply cables interface cables the permitted level of electromagnetic radiation may be exceeded and the correct functioning of other products may be impaired Precautions While the product is in use connecting cables for example product to external battery product to computer must be connected at both ends 4 7 FCC Statement Applicable in U S AN Warning This product h
17. or NiCd and NiMH batteries Li lon batteries 6V batteries with 600 mAh per hour 7 4V batteries with 500 mAh per hour 12V batteries with 300 mAh per hour Indication Refer to section 2 6 Indicators Weight Charger including two battery adapters 1 12 kg Dimensions W X D X H maximum 237 mm x 227 mm x 43 mm including the battery adapter GKL221 Technical Data 30 a 9 6
18. perature limits when storing the product particularly in summer if the product is inside a vehicle Refer to section 5 Technical Data for information about temperature limits Cleaning and Drying Use only a clean soft lint free cloth for cleaning Keep plugs clean and dry Blow away any dirt lodged in the plugs of the connecting cables Care and Transport GKL221 Y I AIS _en GKL221_User book Page 22 Monday April 11 2011 2 30 PM 4 Safety Directions 4 1 General Description The following instructions should enable the person responsible for the product and the person who EN actually uses the equipment to anticipate and avoid operational hazards The person responsible for the product must ensure that all users understand these instructions and adhere to them 4 2 Purpose Permitted use e Charging and discharging batteries of differing cell technologies Adverse use e Use of the product without instruction e Use outside of the intended limits e Disabling safety systems e Removal of hazard notices Opening the product using tools for example screwdriver unless this is specifically permitted for certain functions e Modification or conversion of the product e Use after misappropriation e Use of products with obviously recognizable damages or defects e Use with accessories from other manufacturers without the prior explicit approval of Leica Geosystems N Warning Adverse use
19. re Step Description 1 Insert the battery adapter 2 Connect the charger to the power supply the green function indicator lights up EN 3 Insert the battery The yellow status indicator flashes to indicate that the battery has been recognized 4 Make sure the green status indicator remains on The battery is now being charged Refer to section 2 6 Indicators Lamps if after connecting the battery a different status indicator lights up K Check the status indicator after about one minute 5 The battery has been completely charged when the green status indicator starts to flash Refer to section 5 Technical Data for information on the charging times 6 The battery may be removed or remain connected to ensure it is fully charged when needed Refer to section Charging modes for more information Set the charging sequence The GKL221 charger can charge two batteries simultaneously When more than one battery is connected to the charger the one connected first is charged first Always connect the more urgently needed battery first Priorities Batteries are charged at the external battery connection without interrupting a charging process already begun Retaining the full charge When the battery is fully charged it may remain connected NiCd and NiMH batteries are charged in turns to retain their full charge In this way the intrinsic self discharging is compensated and the battery is always fully charge
20. ries on external battery connection sockets can be charged without termi nating a charging process that has already begun External batteries with 5 pole charging sockets GKL221 010 Operation GKL221 V e 13 Z y _en_GKL221 User book Page 14 Monday April 11 2011 2 30 PM 2 4 Functions Selection Button The selection button is used to select a charging bay and to toggle between the charging and discharging modes GKL221_011 Functions Press the Description selection button Selectthe charging Less than two The next bay containing a battery is selected The selected bay seconds bay is indicated by the yellow status indicator flashing quickly for about three seconds the battery capacity is also displayed o Switching between More than three Switching to the discharging mode causes the status indicator charging and seconds to flash yellow red for about five seconds switching into discharging modes charging mode causes it to flash yellow green for about five seconds Discharging is indicated by the red status indicator flashing When the process of discharging is completed the green indicator starts to flash indicating that the battery is now being charged GKL221 Operation 14 QB Y AIS _en GKL221_User book Page 15 Monday April 11 2011 2 30 PM 2 5 Charging the Battery Procedu
21. tch off e Incase of an error the capacity and error indicators turn red to show that there is an error in the selected bay Capacity indicators s 7 LEDs Meaning H a A O The battery charge is less than 20 i 0 O O O J O O The battery charge is at least 20 l Vee The battery charge is at least 50 eH O lt li sL 1 The battery charge is at least 80 Fa eS cE Presently the level of charge can only be displayed for the Leica Geosystems GEB211 GEB212 GEB221 GEB241 and GEB90 batteries GKL221 Operation 18 aa S AN Lp AIS _en GKL221_User book Page 19 Monday April 11 2011 2 30 PM a aa O LEDs Meaning Measures to take z a b gt O oO The battery is too cold or overheated Refer to section Temperature range for l wen Y TS additional information o Vly The battery is defective Use a different battery en O Oo gt Faulty contact on the battery or the Check the contacts 77 battery adapter Ss Nb Ss Hardware error in the charger Contact an authorised Leica Geosys 2 gt 7TN ZTS tems service workshop S If the charger indicates an error when the battery is connected Connect a different battery to check if the fault lies with the battery or the charger e Ifthe problem persists contact an authorised Leica Geosystems service workshop S In case of error please also check e If there
22. z S _en_GKL221 User book Page 12 Monday April 11 2011 2 30 PM NiCd and NiMH batteries Inserting 1 Insert the battery into the front edge of the GDI222 battery bay 2 Press it downwards until it clicks into place Removing e Pull up the back of the battery and remove it GKL221_008 Ee The Leica Geosystems GEB111 and GEB121 batteries have four contact surfaces whereas camcorder batteries made by third parties only have three The charger can distinguish between these two types of batteries and adjust the charging process accordingly S Camcorder batteries with three contact surfaces must meet the following specifications to prevent damage e Voltage 6 V e Type of battery NiCd or NiMH e Minimum capacity NiCd 1500 mAh NiMH 1800 mAh Compatible contacts in the correct sequence i e T in one line Camcorder batteries that meet these specifications are monitored for temperature and charged with a current of 1 6 A GKL221 Operation 12 g ik VA Zi _en_GKL221_ User book Page 13 Monday April 11 2011 2 30 PM Leica Geosystems batteries with 5 pole charging sockets e g the GEB87 or GEB70 must be connected to the 5 pole charging socket of the charging cable Batteries with 5 pole charging sockets GKL221_009 Leica Geosystems batteries with 5 pole charging sockets e g the GEB87 or GEB70 must be connected to the external battery connection socket of the charging cable K Batte
Download Pdf Manuals
Related Search