MB3 Owners Manual - Optima Heating & Air Conditioning
Contents
1. www bonaire com au P N 5432202 A2. operation of the Controller Maintenance requirements Page 7 WARRANTY WARRANTY STATEMENT Please read this warranty information and complete the Dealer Product information on the following page KEEP this with your original purchase documents for any claim under warranty Firstly refer to your owners manual to ensure you have followed the correct operating procedures of your product and refer to the trouble shooting guide to assist solving any problems you may have 1 Read this warranty statement carefully before you request warranty service as items related to installation are not covered by this appliance warranty 2 A proof of product purchase must be provided for warranty service to validate the appliance is within the manufacturer s warranty periods 3 This warranty is only for products and associated original controls for Climate Technologies manufactured product 4 Only an authorised Climate Technologies service provider must carry out warranty service 5 Statutory warranty is 12 months from date of purchase and all additional periods are classified as manufacturer s voluntary warranty Climate Technologies provides the following Manufacturers warranty on new product additional to all implied warranties and other statutory rights which you may have under the Trade Practices Act and similar State amp Territory Laws subject to the following terms and conditions CONDITIONS TO WARRANTY e Subject to the exclusio
3. LOCATION Your appliance model number serial number and model description are located on the appliance data plate on the end of the heater in the vicinity of the electronic controls access These details should also be in the warranty section of this booklet You will need this information should your appliance require servicing spare parts or just if you require additional information about this product ASSEMBLY There is no assembly required of this Mid Efficiency Ducted Gas Central Heater Your Dealer or installer will carry out all assembly and commissioning upon installation ABNORMAL OPERATION Should an error occur the heater will stop operating and 1 For serious errors will remain in lockout until the control is reset 2 Will reset and attempt to restart if the error persists the unit will enter lockout until the control is reset If the unit lockout occurs please contact your local service department RESETTING OF APPLIANCE To reset appliance after lockout 1 Turn off the power to the appliance for 5 seconds 2 Cycle the thermostat on and off 6 times within a 60 second period Allow at least 2 seconds between cycles Page 3 SAFETY SAFETY amp OWNER RESPONSIBILITY The manufacturer and its service providers reserve the right to refuse service unless safety and accessibility to the unit can be guaranteed The cost of any extra equipment required to provide access to the unit for servicing is the responsibility of th
4. OPERATING INSTRUCTIONS 3 Star Ducted Gas Central Heater Owner s Operation and Maintenance Manual Please keep this important manual in a safe place It is the owner s responsibility to ensure that regular maintenance is carried out on this Ducted Gas Central Heater Failure to do so will void all guarantees beyond statutory and legal requirements Page 1 TABLE OF CONTENTS INTRODUCTION cc cates ot at ae at cates ea ae er ate ules ca tas 3 Important N t CE see e e E a E AE 3 Datta LOCATION ese a eie e EEE EE ea E REEE AE REEE aeons 3 ASsSemDy aeea n enan aaa a a a A RA 3 Abnormal OPCTAUOMN esccctsicaaceleidaneisiacvedo nie esceerabeent del tate dadkideniaceitagaeceiemaces 3 Resetting of appliance neces tetieeniadea uation ute nestiele adie NG 3 SAFETY anen a ced She reek a E EE ea ge aA EE edb east 4 Safety amp Owner Responsibility ccccccceeeeeeeesescceeeeeeeeeeesseaeaeeeeeeeeeeenesaaaaes 4 EUPIA Sc ci os a oo ae as Se NS aoe crete a athe Se 4 PU Sd dere i eee eae E te ec dee kM hee de A agate ema ae ec en aa 4 Power or Gas interruption se oo ecas tet ek etc tere er atte cate bet eckee ahead nS 4 Operating INSUCUONS seeria Seen se techno res ep Bleeds cen radeon 4 THERMOSTAT panees ea cee ee atti dh cece ste hasta de aon e AREL crc E aah he ak dati 5 Thermostat FUNCHON ycsieisciseeedd ane aediueer eee REEE e eee 5 Manual Thermostat cae ate tae gol Geet ee eee te ech 5 Programmable ThermOStat cccccccc
5. Once the room temperature has dropped below the set temperature the unit will restart maintaining as close as possible the set temperature For instruction on how to operate your manual or programmable thermostat please refer to the instruction sheet provided with your thermostat Manual Thermostat Programmable Thermostat Page 5 PROBLEM SOLVING Central Heater will not operate Has the unit been run since installation Refer to question 4 No Check the unit is turned on at the power point and the gas cock is turned on Call the installer to commission the unit Is the unit installed in Refer to question 3 a new home a Refer to question 4 Has the installer run the unit Refer to question 4 No Check the unit is turned on at the power point and the gas cock is turned on Call the installer to commission the unit Is the set temperature Press the reset buttons or turn the unit off then on to reset greater that the room unit If the unit still does not start call for service refer to temperature solution 6 for reset instructions Increase the set temperature so the thermostat calls for heat Is the thermostat in The heater may be programmed to be OFF program mode Check the program settings Ra Adjust the room thermostat greater than set temperature Has there been a Reset the unit known power surge Refer to the Abnormal Operating section No Unit should operate normally If not a service call
6. cccccceeeeeeeeeeeeecceaeeeeeeeeeeeeeeennaaees 5 PROBLEM SOLVING c 2 crac ratte eatea aatetta Ea atate Caeiie een vainiedtaereaucnieeeadees 6 COMMISSIONING CHECK LIST 0 eee e ee eeeenee rete eee eeeeenaaaeeeeeeeeeeteneeaaees 7 GONGIAL sis cxs a e a a E RE EAE E 7 Ducted Heating unit ooosnnneeeeooennneneeeeooeeennrnnrrseoerenrrnnrreerrreerrnn 7 DUCIWOIK pannan aa ets hag As aes ts ok a A n aE 7 SC ERRI E EREEREER EE AEEA 7 Customer Hand Over eseessseeeenneneeessoerenrrnrrrsoerrenrrnnrrserrrrerrne resene 7 WARRANTY eera oren a E aE sence AE E E E EEEE 8 Warranty Statement ccc ceivcsct ckceet ceuesvgaddens shiva dds ccued sa abtieeeceesadakdeel seeeeeensdee deen ete 8 Conditions to warranty euiecetsteeehiisle cee teattotiveneraiiuelaniieeckd iecredidah eenberteas 8 DIY Installation Warranty c 5 262ccec ee ccah oes cc aentecis Gets cqusenecasnerperqunentaqenenmeqine 9 Remote Location Warranty coerced coats eratisa Ata tered ele eral Waterkant da 9 Excl sions to warant yon ieann ane r n E na A a Ea a 9 Conditions where warranty may be void ssssesssesssssesrrrnnrsssrrrrrrnnnreserrrnne 9 Aged new product warranty sseeeseessseererrrrttsstrrtrrrrntteserrrtrrrnnnnsserrnnnnn ne 10 Warranty on replacement Parts cccceeceeeeeeeeeceeeeeeeeeeeeeeeeaaeeeeeeeeeeeneas 10 Periods of Warranty YO rs cccccceeeeseeseceeeeeeeeeeeeeenseeeeaeeeeeeseeseeseesaeeeeees 10 NOTES aeaiee eee tient
7. d the name of the installer are recorded on this page The installer is responsible for the correct installation start up and demonstrating the operation of this product The Dealer or retailer is also responsible for issuing the relevant certificates of compliance for the electrical connections These may differ from state to state Page 9 WARRANTY AGED NEW PRODUCT WARRANTY For a new product warranty to apply a product needs to be purchased and installed within 3 years of the manufacturing date by the original purchaser Product that is aged as the result of extended storage or being used for demonstration purposes the following warranty conditions will apply For a product that is greater than 3 years and less than 5 years old from date of manufacture the statutory warranty will apply and any voluntary warranty originally supplied will be reduced by 1 year For a product that is greater than 5 years of age from date of manufacture the statutory warranty will apply to electrically functioning components only All other components being cabinets louvres filters etc will not be covered WARRANTY ON REPLACEMENT PARTS Parts replaced under warranty are warranted for the balance of the original warranty period PERIODS OF WARRANTY YEARS RESIDENTIAL COMMERCIAL Unit Components Parts Labour Parts Labour Heat Exchanger Burner All other components For further technical information or explanation of any of these specificat
8. e owner PRECAUTIONS e DO NOT PLACE ARTICLES ON OR AGAINST THIS APPLIANCE e DONOT USE OR STORE FLAMMABLE MATERIALS NEAR THIS APPLIANCE e DO NOT SPRAY AEROSOLS IN THE VICINITY OF THIS APPLIANCE WHILE IT IS IN OPERATION e DO NOT MODIFY THIS APPLIANCE FEATURES Your Mid Efficiency Ducted Gas Central Heater has all the safety devices to ensure safe operation These devices conform to the standards set out by the Australian Gas Association POWER OR GAS INTERRUPTION Should there be an interruption to the power supply during the heating operation the controls will automatically turn off the gas Should there be an interruption to the gas supply the heater will endeavour to re light 3 times and if unsuccessful will lock out This is part of the safety features Should this occur the heater would need to be reset Please refer to the Abnormal Operating section OPERATING INSTRUCTIONS Before operating your mid efficiency central heater ensure the following i The product has been commissioned ready for use If you have not been shown how to operate the unit or the appliance has not been commissioned please contact your installer 2 The gas isolating cock is in the ON position 3 The power is turned on to the unit Page 4 THERMOSTAT THERMOSTAT FUNCTION The function of the room thermostat is to maintain the room temperature at the set temperature selected Once the heater has reached set temperature the unit will stop
9. ions please contact your nearest Bonaire Dealer Page 10 NOTES Page 11 SERVICE amp MAINTENANCE SCHEDULED MAINTENANCE Your Ducted Gas Central Heater should be serviced annually to ensure trouble free operation 1 To ensure that your heater continues to operate at peak efficiency it is recommended that it be periodically serviced by a qualified service technician 2 Fan blades motors ignition systems and burners should be checked every year Heater cabinet and immediate surroundings should be kept clean SERVICE A qualified service technician should conduct any service work carried out on your ducted gas central heating It is important that periodical service is carried out on your product to ensure your will receive the efficiency benefits the product provides An authorised Climate Technologies service provider must carry out warranty service Service Division For Metro Service Only Ring the Number Below South Australia 08 8307 5230 Northern Territory New South Wales 03 8795 2457 Australian Capital Territory Western Australia 08 9454 1000 Victoria Tasmania 03 8795 2456 Queensland 03 8795 2457 Outside Metro areas please contact your nearest Climate Technologies Service Provider New Zealand ABERGAS LTD 0800 161 161 Ia CLIMATE TECHNOLOGIES Excelling today for a better tomorrow Manufactured by Climate Technologies ABN 13 001 418 042 26 Nylex Avenue Salisbury SA 5108 Australia
10. ns noted Climate Technologies warrant the product for the period as prescribed in the table following this statement to be free from inherent defects in materials and workmanship for functional and structural components e This is only valid if the product is operated in accordance with the manufacturers instructions e The appliance must not be modified or changed in any way e Your proof of purchase MUST be produced before free service will be provided e Travelling time and mileage are included within 30km of either your authorised Climate Technologies dealer or service provider s premises Customers in areas other than the above are responsible for any travelling time and mileage required to carry out warranty repairs e The product must be installed by a qualified person in the manner prescribed by local amp statutory regulations and to the manufacturer s specifications e Service within the terms of this warranty will be recognised where we are satisfied that the appliance or part was supplied within the relevant time limits Documents of purchase and Dealer Installer information will assist in this process e Product fitness for purpose and overall system design sizing is solely the responsibility of the dealer installer This includes but is not limited to heat load calculations air flow system balancing humidity water quality etc e The product must be installed in an easily and safe accessible area for service appliances in
11. r workmanship and as such are not considered warranty e No responsibility will be accepted for outside elements such as pests animals pets and vermin that may cause damage to the unit e Harsh environmental situations such as salt air that may cause cabinet damage rusting can not be considered warranty e The manufacturer does not accept liability or any claims for damage to building contents carpet walls ceilings foundations or any other consequential loss either direct or indirect Damage resulting from power spikes incorrect operation incorrect installation and incorrect maintenance is also not covered e All warranties are NOT transferable CONDITIONS WHERE WARRANTY MAY BE VOID e If there is no certificate of compliance for plumbing electrical or refrigeration as required by State amp Territory Laws Climate Technologies reserves the right to refuse service on non compliant installations The defective operation of the appliance that is due to failure of electricity gas water or refrigerant gas supplied Defects are caused by neglect incorrect application abuse or by accidental damage of the appliance An unauthorised person has attempting to repair the appliance A situation arises referenced in the trouble shooting guide A charge will be made for work done or a service call where there is nothing wrong with the appliance It is important that the name of the Dealer or Retailer from whom you purchased your product an
12. s a a eE a AER edad endet eat E e EEEO 11 BS Ad Go E E terre nnn A nee A A er EA A A 12 Scheduled maintenance wc ccscaiccesdeaelenielacarediavlastietasstedeeddetenesavedeeeiendenenes 12 SOMVICS a E EEE E EEE EEE EE 12 Service DIVISION 2 5 ts dies Balen caer Rae ween Haauueea ee 12 Page 2 INTRODUCTION CONGRATULATIONS ON YOUR CHOICE Congratulations on purchasing this 3 star mid efficiency gas central heating system an exciting new product manufactured by Climate Technologies Wholly designed and manufactured in Australia this Mid Efficiency Ducted Gas Central Heater represents an exciting new development in warm air furnace design It embodies the latest advances in gas heating technology Your heater is supported by Climate Technologies Australia s most advanced manufacturer of a complete range of climate control products To ensure you fully enjoy the benefits of this Mid Efficiency Ducted Gas Central Heater please read these instructions carefully and keep them handy for future reference Operated and maintained in accordance with this manual this unit will provide you with years of quiet warm and environmentally friendly operation Please take the time to read this manual IMPORTANT NOTICE If an appropriately qualified person is not used to install the equipment or if it s not installed according to the guidelines then Climate Technologies will not accept responsibility for any problems which occur as a result DATA
13. stalled in areas not easily and safely assessable costs will be borne by the owner for access equipment should maintenance be required Page 8 WARRANTY DIY INSTALLATION WARRANTY e If the product has been installed as a DIY a supply part only warranty will apply Parts only will be supplied free of charge on the return of the faulty part and the owner will be responsible for all labour charges incurred for the part to be fitted by a qualified person Labour warranty as prescribed in the following table is void in this situation REMOTE LOCATION WARRANTY e Ifthe product has been installed outside the Climate Technologies service network a supply part only warranty will apply Parts only will be supplied free of charge on the return of the faulty part and the owner will be responsible for all labour charges incurred for the part to be fitted by a qualified person Labour warranty as prescribed in the following table is void in this situation EXCLUSIONS TO WARRANTY e Consumable items subject to wear and tear such as filter pads drive belts and bearings are not covered by this warranty e Components used as part of the installation such as grilles filters ducting fittings zone motors and consumer services pipe work are warranted from your place of purchase and not covered by this warranty e Damage caused by elements such as wind rain lighting floods etc along with power spiking and brownouts are not considered defective material o
14. will be required THIS TROUBLE SHOOTING GUIDE IS A REFERENCE ONLY FOR SERVICE OR WARRANTY REQUIREMENTS PLEASE REFER TO THE WARRANTY SECTION OF THIS BOOK Page 6 COMMISSIONING CHECK LIST General OOOOO All equipment ordered by the customer is installed The unit is level and secure The mains and control wiring are complete and the circuit breaker and GPO are turned ON All Controller functions for the appliance operate All electrical or gas connections are to manufacturers specifications and the relevant electrical or gas standards and codes Ducted Heating unit OOOOOOOO Electrical polarity of the power outlet is correct Heater is installed away from sources of dust and fumes i e pool chlorine petrol etc Gas leaks checked for none present Flue outlet pipe complies with limits given code and is sealed waterproof Combustion air meets requirements internal under floor Fan speed set is correct Burner pressure is correct Mounting pad platform complies with requirements codes Ductwork O O O O All ductwork is completed to plan correctly supported and airtight with no bend less than 1 5 x the ductwork diameter Air distribution checked dampers are adjusted and all outlets correctly adjusted and wiped clean All roof penetrations are fully sealed and watertight Manhole cover replaced Site O All rubbish has been removed from inside and on the roof Customer Hand Over O O The
Download Pdf Manuals
Related Search