AUTOMATIC POOL FILLER INSTALLATION MANUAL
Contents
1. AUTOMATIC POOL FILLER INSTALLATION MANUAL Model T40 F Installation Instructions Prior to installation check local building codes for exceptions to these instructions Install leveler bucket so top of bucket is flush with bond beam of pool See Fig A Ring and Lid then should be installed flush with deck Use rebar mounting flanges provided on bucket to insure and aid in keeping bucket level during concrete pour Install 172 equalizer pipe IMPORTANT Equalizer pipe must be straight as shown Figure A The use of any 45 or 90 pipe could cause air lock and void warranty Use only PVC to ABS joint cement for this application Connect 3 4 fresh water supply pipe to side leveler bucket See Fig A Special Note Please allow adequate cure time as per cement manufacturer before applying pressure You can pressure test auto fill with supplied fitting P N 210067 See Fig D CAUTION Do not over tighten Remove test plug and flush supply line for approximately 60 seconds or until all debris has cleared Connect 3 4 overflow pipe in port See Fig A using a PVC to ABS joint cement Install valve assembly Fluidmaster valve IMPORTANT Do not use liquid or paste sealers Pentair Water Pool and Spa Inc does not cover warranty if damaged because of over tightening or cross threading To adjust float height of Fluidmaster valve lightly press down the top of fill valve with one hand while turning clockw2. T UP OR DOWN ON STAINLESS STEEL ROD TEST PLUG P N 210067 WITH O RING PLUG HAS NO THROUGH HOLE SUPPLIED BY PENTAIR WATER POOL AND SPA CAUTION DO NOT OVER TIGHTEN FIGURE D SCREW VALVE UP OR DOWN TO ADJUST VALVE HEIGHT 5 DEBRIS SCREEN amp 47 GASKET SHOWN IN BUCKET TO CLEAR SAND AND DEBRIS FROM SUPPLY LINE REMOVE DEBRIS SCREEN AND CLEAN SCREEN THEN REINSTALL SCREEN AND VALVE FIGURE E Pentair Water Pool and Spa Inc Pentair 1620 Hawkins Avenue Sanford NC 27330 919 566 8000 Pool Products 10951 W Los Angeles Avenue Moorpark CA 93021 805 553 5000 2 Because reliability matters most 2006 Pentair Water Pool and Spa Inc All rights reserved This document is subject to change without notice Trademarks and Disclaimers The Pentair Pool Products logo is a registered trademark of Pentair Water Pool and Spa Inc Other trademarks and trade names may be used in this document to refer to either the entities claiming the marks and names of their products Pentair Water Pool and Spa Inc disclaims any proprietary interest in trademarks and trade names other than its own P N YYLEVF Rev B 6 26 06
3. ise or counter clockwise to adjust valve Continue turning until water level is achieved See Figure By Pentair Products Because reliability matters most www pentairpool com Rev 6 26 06 P N YYLEVF ONILNNOW Yves v 18514 ce 5 dOl HOd ONIY SZL aavisnrav a a 34NDIH4 ei ra el a Jdid 3211 AL s TA 4030 OL kit f g NO 1 GAIVHOHHAd N S QIAOHd DNIH HJAOO LI dl Z N pota z 831 100d SLE L i ja 100d 5 T s gt AlddNS HS344 b i A xe tall a e II RE E 4 ae ea Pul SAIdVA LHDI3H 4930 MOTHHAJAO 7 ONIH LNOHLIM NMOHS NAMIXVW LAMONE 437114 JILVINOLAV 3A04V I OL HSNI Hd GINOHS 437114 OILLVWOLNV AO dOL 4 001 SAGIND NOILVTIVLSNI 931115 100d DJILVINOLAV 7 3 DIA 1 FROM CENTER TO OVERFLOW 34 SLIP FIT t OVERFLOW 1 5 13 5 0 16 7 MINIMUM REBAR FLANGES EQUALIZER LINE TO POOL 1 SLIP FIT 34 SLIP FIT FOR WATER SUPPLY FIGURE C REFER TO FIGURE A OF INSTALLATION INSTRUCTIONS FOR HEIGHT OF DECK CONSIDERATIONS SQUEEZE CLIP TO ADJUST FLOA
Download Pdf Manuals
Related Search