FOLDING SOLAR PANEL KIT USER MANUAL
Contents
1. Q Will the solar panels over charge my battery A The charge regulator ensures that a steady charge is supplied to the battery and will not be over f i E i charged It has three stages of charging Bulk Absorb and Float Folding Solar Charging System Specification Specifications Q Can extend lengthen the battery lead p A If the lead is extended this could result in a loss of voltage and insufficient power transferred from the Max Max Open solar panels to charge the battery Quality wire should always be used to extend the lead length Type Module Size N W si Power Power Circuit gop m m pu Q Is the Controller water resistant mmm A Yes but it is recommended during rain hail or storms the kit be moved indoors to protect it axew zem ios 9 ie 4 ao A Dust amp dirt should firstly be sw pt off the panel surface using a soft brush and then use a wet cloth to A inane uae 2x BOW 1005x505x70 21 60 removed as soon as possible as if left can cause damage to the surface 2x100W 1005x670x70 11 12 21 60 Q How do clean the solar panel wipe the panel surface to remove remaining dirt amp grime It is recommended that any bird droppings be Solar Cell Monocrystalline WARNING DO NOT CHARGE A BATTERY DIRECT FROM THE SOLAR PANELS THERE MUST BE A REGULATOR USED2. Accessories 1 2 3 4 o 6 Handle Latches Aluminium Frame Aluminium Support Legs Solar Charge Controller Junction Box e o 10 Protective Corners 12 Label Cable Battery Clips Anderson Plugs Storage Carry Bag FOLDING SOLAR PANEL KIT USER MANUAL Installation Trouble shooting if system does not function 1 Remove the solar panel kit from the handy carry bag Check all connections to ensure they are secure and free from moisture amp debris 2 Unclip the two latches on the side of the unit and fold two panels outward Extend the two legs to Check the solar panels are in good sunlight the desired angle and lock in position to gain maximum support Test the battery the solar kit is hooked to to ensure it is not faulty 3 Place solar panel kit in the position facing the sun free from over hanging branches or Disconnect the solar kit from the battery wait 30 seconds and reconnect This will restart the solar obstructions controller 4 Fully extend battery lead and connect to solar charger controller Connect the battery clips to the To test if your kit is working check the battery voltage before you connect the solar kit to it Then positive red amp negative black battery terminals Ensure that the connection is secure connect the solar kit and leave it on for 10 minutes then check the voltage in your battery The battery voltage would now be higher than your first reading if the kit is working cor
3. rectly Note To obtain maximum output it is suggested that the solar panel kit direction be frequently If problems continue please consult your place of purchase adjusted to track the suns movement throughout the day PV Array Short Circuit Operation LEDs If PV array short circuit occurs clear it to resume normal operation Charging Status indicator Load Short Circuit GREEN ON whenever sunlight is available for battery charging Fully protected against load wiring short circuit After one automatic load reconnect attempt the fault must be cleared by reapply power Battery Status indicator GREEN ON when battery voltage is in normal range Charged Battery Reverse Polarity ORANGE ON when battery under voltage under full charge Full protection against battery reverse polarity no damage to the controller will result Disconnect the RED ON when battery over discharged flat wires from the battery and reconnect making sure the positive lead is connected to the positive terminal on the battery and the negative lead is connected to the negative on the battery FREQUENTLY ASKED QUESTIONS Q What type of batteries can be used with the kit A Factory set for AGM Batteries but will charge Gel amp Flood Batteries too Overheating Protection If the temperature of the controller heat sink exceeds 85 C the controller will automatically start the overheating protection l It is recommended to move the solar kit indoors during rain hail or storms
Download Pdf Manuals
Related Search