manuel d'utilisation gebrauchsanweisung brugsanvisning
Contents
1. 17 Quarantee YEARS MANUEL D UTILISATION GEBRAUCHSANWEISUNG BRUGSANVISNING INSTRUCCIONES DE USO OPERATING INSTRUCTIONS ISTRUZIONI D USO GEBRUIKSAANWIJZING Dear Sir Madam Congratulations on your purchase of this Zibro heater the number one brand amongst portable heaters You have purchased a first class quality product which will serve you for many years to come This of course provided you use the heater correctly Please read these Directions for Use first to ensure the maximum lifetime for your Zibro heater This appliance comes with a 24 month manufacturer s warranty all defects material or workmanship We wish you much warmth and comfort from your Zibro heater Yours sincerely PVG International b v Customer Service Department 1 READ THE DIRECTIONS FOR USE FIRST 2 IN CASE OF ANY DOUBT CONTACT YOUR DEALER 3 BEFORE YOU START READING FOLD OUT THE LAST PAGE p GENERAL DIRECTIONS FOR USE Below you will find the main steps to be taken for MAIN COMPONENTS using your heater For more details please refer to OFF button the MANUAL pages 53 ff Knurled wick adjustment knob Remove all packaging materials refer to Section A Fig A Ignition button Fill the removable tank and wait 30 minutes before you ignite the heater refer to Section B Fig H Combustion chamber Insert the batteries into the battery holder refer to Section A Fi2. and store them dry place 5 Clean the fuel filter refer to section 6 Store the heater a dust free place if possible in its original packaging Unused fuel cannot be used for the next heating season If there is still some fuel left do not throw it away but dispose of it in accordance with the local regulations for the disposal of domestic chemical waste Always start the new heating season with fresh fuel When you start re using the heater follow the instructions again starting from Section A and as specified J TRANSPORTATION Take the following measures to avoid fuel leakage during the transportation of the heater H Let the heater cool down 2 Remove the removable tank from the heater and remove the fuel filter Fig N Some drops may leak from the filter keep a cloth at hand Store the fuel filter and the removable tank outside the heater 3 Place the transportation cap into the position of the fuel filter Fig O Press it tight 4 Always move the heater in an upright position K SPECIFICATIONS Transportation cap Ignition electrical Dimensions mm width 428 Fuel paraffin including base plate depth 295 Capacity kW 3 00 height 513 Suitable space 85 110 Accessories manual fuel pump Fuel consumption br 0 313 transportation cap Fuel consumption g hr 250 batteries Burning time per tank hr 12 8 Required batteries 2 R20kG MN 1300 Capacity removable tank
3. F p You have run out of fuel from the tank the wick has been replaced After having refilled and replaced the removable tank wait for 30 minutes before igniting the heater p You are pushing the ignition button with too much force Push it in less forcefully Section C p The ignition coil is defective Contact your dealer IRREGULAR FLAME AND OR SOOT AND OR SMELLS p combustion chamber has not been positioned correctly Use the handle to put it level until you can easily slide it slightly to the left and to the right and the chamber is level p You are using fuel which is past its use by date Start every heating season with fresh fuel p You are using the incorrect type of fuel Refer to THE RIGHT FUEL See Section What you need to know in advance p Dust has gathered the lower part of the heater Contact your dealer p The wick height is not correct See section THE HEATER SLOWLY EXTINGUISHES 9 The removable tank is empty See Section B p The fuel filter is contaminated by moist Dry the fuel filter Section H p lower reservoir is contaminated by moist Contact your dealer p The wick has hardened on the upper side Burn the heater until all fuel is used Section H Use the right fuel p You are using fuel which is past its use by date Start every heating season with fresh fuel THE HEATER REMAINS BURNING LOW p Wick position too low Reinstall the wick he
4. Your heater is now ready for use FILLING FUEL Do not fill the removable tank in the living room but in a more suitable place there can always be some spillage Follow the procedure below H Make sure that the heater is switched off 2 Open the lid and lift the removable tank out of the heater Fig Note Some drops may leak from the tank Put down the removable tank GD R OP Y cap pointing upwards and screw off the fuel cap 3 Take the manual fuel pump and insert the smooth most rigid tube into the jerrycan Make sure that it is in a higher position than the removable tank Fig H Insert the ribbed hose into the opening of the removable tank 4 Lock the valve on top of the pump turn clockwise 5 Squeeze the pump a few times until fuel starts flowing into the removable tank As soon as this happens there is no need to press any longer 6 Check the removable tank fuel gauge while filling the tank Fig Stop filling by loosening the valve on top of the pump turn anti clock wise once the gauge indicates that the tank is full Never overfill the tank especially not when the fuel is very cold fuel expands when it heats up Let the remaining fuel in the pump flow back into the jerrycan and carefully remove the pump Carefully screw the fuel cap back on the tank Clean off any spilled fuel empty Check whether the fuel cap is straight and tighte
5. ER H Carefully remove your heater from the box and check the contents In addition to the heater you also need to have gt a manual fuel pump gt transportation cap these directions for use batteries Keep the box and the packaging materials Fig A for storage and or transportation 2 Remove the other packaging materials gt Remove the packaging material from the grill Lift the grill from the slot Fig B and pull it forward Pull both ends of the packaging to the rear and at the same time slightly downwards see Fig C gt Remove the combustion chamber from the heater and remove the packaging underneath see Fig D Put the combustion chamber back into its place The combustion chamber is positioned correctly when it can be smoothly moved a little to the left and to the right by its handle Fig E Close the grill Slightly lift it to reposition it in its slot gt Open the lid of the removable tank and remove the piece of cardboard Fill the removable tank as indicated Section 4 Insert the batteries into their holder at the back of the heater Fig F Ensure that the positive and negative poles match the and marks indicated on the battery housing 5 The floor should be firm and completely level Reposition the heater when it is not level Do not correct the situation by placing books or other goods under the heater 6
6. N fa cl SS d Ip d J gt Q 8 Rev 5 07 DISTRIBUTED IN EUROPE PVG INTERNATIONAL b v PVG Austria VertriebsgmbH Salaberg 49 3350 HAAG tel 43 7434 44867 fax 43 7434 44868 email pvgaustria zibro com PVG Belgium NV SA Industrielaan 55 2900 SCHOTEN tel 32 3 326 39 39 fax 32 3 326 26 39 email pvgbelgium zibro com PVG Schweiz AG Salinenstrasse 63 4133 PRATTELN tel 41 61 337 26 51 fax 41 61 337 26 78 email pvgint zibro com PVG Deutschland GmbH Siemensstrasse 31 47533 KLEVE tel 0800 9427646 fax 31 0 412 648 385 email pvgdeutschland zibro com Appliance A S Blovstroed Teglvaerksvej 3 DK 3450 ALLEROED tel 45 70 205 701 fax 45 70 208 701 email appliance appliance group com PVG Espana S A Pol Ind San Jos de Valderas II Comunidad La Alameda C Aurora Boreal 19 28918 LEGANES Madrid tel 34 91 611 31 13 fax 34 91 612 73 04 email pvgspain zibro com PVG France SARL 4 Rue Jean Sib lius B P 185 76410 SOTTEVILLE SOUS LE VAL tel 33 2 32 96 07 47 fax 33 0 820 34 64 84 email pvgfrance zibro com Appliance Finland Oy Piispantilankuja 6C 02240 ESPOO tel 358 9 4390 030 fax 358 9 4390 0320 email appliance appliance group com Scott Brothers Ltd The Old Barn Holly House Estate Cranage Middlewich CW10 9LT UK tel 44 1606 837787 fax 44 1606 837757 email sal
7. es scottmail co uk PVG Italy SRL Via Niccol Copernico 5 50051 CASTELFIORENTINO FI tel 39 571 628 500 fax 39 571 628 504 email pvgitaly zibro com Appliance Norge AS Vogellunden 31 1394 NESBRU tel 47 667 76 200 fax 47 667 76 201 email appliance appliance group com PVG International B V P O Box 96 5340 AB OSS tel 31 412 694 694 fax 31 412 622 893 email pvgnl zibro com Gardena Lda Recta da Granja do Marqu s ALGUEIR O 2725 596 MEM MARTINS tel 35 21 92 28 530 fax 35 21 92 28 536 email pvgint zibro com PVG Polska Sp z o o ul Ko cielna 110 26 800 Bia obrzegi tel 48 48 613 00 70 fax 48 48 613 00 70 email pvgpoland zibro com Appliance Sweden AB Sj gatan 6 25225 HELSINGBORG tel 46 42 287 830 fax 46 42 145 890 email appliance appliance group com PVG Is tma Klima So utma Ltd ti Atat rk Cad 380 Ishani Kat 6 35220 Alsancak IZMIR TURKEY tel 90 232 463 33 72 fax 90 232 463 69 91 email pvgturkey zibro com Printed in Japan 7076000903 man_R17 avg 070507 PVG Traffic
8. g F Combustion chamber handle Check whether the combustion chamber is fully upright Fuel indicator refer to Section Fig Ignite the heater by turning the knurled wick adjustment knob as far to the right as possible and then gently push the ignition button refer to Section Fig 7 K ror removable tank After igniting the h it will take 10 to 15 mi 1 ter igniting the heater it will take 10 to 15 minutes before Removable tank you can check if the heater burns well refer to Section D Fuel gauge Switch off the heater refer to Section E removable tank The first time you ignite your heater it will smell Ignition coil like new for a short time Store your fuel in a cool and dark place Battery holder Fuel has a limited shelf life Start every heating season with new fuel The right quality of fuel will be assured when you Wick height lock use Zibro Extra or Zibro Kristal for your heater If you change to another brand and or type of paraffin oil you must first finish up all the remaining fuel in the heater WHAT YOU NEED KNOW ADVANCE ALWAYS MAKE SURE THAT THERE IS SUFFICIENT VENTILATION For each model the minimum size of space is specified in which you can use the heater safely without additional ventilation refer to Section K If a particular room is smaller than the specified space always leave a window or door slightly ajar 2 5 cm We also rec
9. ight lock Section F p Before you refilled the tank the heater had burnt up almost all the fuel After having refilled and replaced the removable tank wait for 30 minutes before igniting the heater p You are using the incorrect type of fuel Refer to THE RIGHT FUEL See Section What you need to know in advance GD gt The room is insufficiently ventilated Leave a window or a door wide open for a while K Rttrrt r stereS S S R THE IS TOO HIGH p You are using an incorrect too volatile type of fuel Refer to THE RIGHT FUEL See Section What you need to know in advance gt Wick position too high Reinstall the wick height lock Section F MAINTENANCE Your heater needs hardly any maintenance It is however important that you remove dust and stains in time with a damp cloth because otherwise these may cause stains that are hard to remove Under normal conditions only three components are subject to wear 1 THE BATTERIES You may replace the batteries yourself Do not dispose of old batteries along with the other domestic waste Follow the locally applicable regulations regarding the disposal of domestic chemical waste 2 THE IGNITION COIL The ignition coil will have a longer life if you ignite the heater in the correct manner Replace the batteries in time and take care not to push in the ignition button with too much force If the filament is broken the ignition coi
10. ing to the allo wed direction engraved on the wick sleeve 13 Install the wick sleeve with wick to the primary air tube And then install the top of the stem into the groove of the wick sleeve with wick from right side and left the stem to the end Install the wick height lock the wick position should be adjusted at No 1 spring and bracket Then tighten the screw which is holding the stem 15 Put the wick holder chassis back into position Screw the four wing nuts hand tight Place the knurled wick adjustment knob on the wick mechanism Turn the knob as far to the right as possi ble Press the tip over switch Check that the wick can be lowered completely Repeat this check a number of times If the wick cannot be lowered completely it has not been placed correctly If this is the case repeat the procedure from No 12 Pull the knurled wick adjust ment knob off the heater Put the cabinet back into position and tighten the three screws Put the knurled wick adjustment knob back into position Now put the combustion chamber back into position Check that it is level by sliding it slightly to the left and the right by its handle Close the grill Put the filled removable tank into position Put the bat teries into the battery holder ensure that the positive and negative poles match the and marks indicated on the battery housing Wait 30 minutes after repla cing the tank and batteries before using the heater U
11. l must be replaced 3 THE WICK To extend the glass fibre wick life you must occasionally let the heater burn until the tank is completely emptied and the heater extinguishes by itself Do this when fuel filter you notice that the flame is weakening The burn out will cause some smells so it is recommended that you take the heater outside of the living room w III f THE FUEL FILTER 07 GE Check the fuel filter regularly as well Remove the removable tank from the heater and take out the fuel filter Fig Some drops of fuel may spill from the filter keep a cloth at hand Turn the fuel filter upside down and clean it from all dirt deposits by tapping it on a hard surface Never clean it with water Reposition the fuel filter in the heater Do not remove any heater components yourself Always contact your dealer for repairs Let the heater cool down first before you start any maintenance or service work STORAGE END OF THE HEATING SEASON We recommend that you burn up all the fuel in the fuel tank at the end of the heating season and store the heater properly Follow the procedure on the next page 1 Ignite the heater outside the living room it burn until all fuel is used GD RR 2 Let the heater cool down 3 Clean the heater with a damp cloth and then dry it with a dry cloth 4 Remove the batteries from the holder
12. litres 4 0 1 5V size D Weight kg 9 0 Wick type F At maximum setting Specified values are indicative c L WARRANTY PROVISIONS Your heater comes with a 24 month warranty starting on the date of purchase Within this period all defects in material or workmanship will be repaired without any charge The following provisions shall apply regarding this warranty H We expressly dismiss all other claims for damages including consequential damages 2 Any repairs or replacements of components within the term of warranty will not result in an extension of the term of warranty 3 The warranty will no longer apply when the heater has been modified non original parts have been used or when it is repaired by third parties 4 The warranty will not apply to parts that subject to normal wear such the batteries the ignition coil the wick and the manual fuel pump 5 The warranty will only apply when you present the original dated proof of purchase provided no changes have been made to it 6 The warranty will not apply to damages caused by actions not compliance with the Directions for Use neglect and the use of an incorrect type of fuel or fuel past its use by date The use of incorrect fuel can even be dangerous Transportation costs and the risks involved during the transportation of the heater or heater components will always be the responsibility of the purchaser In order to avoid unnecessa
13. may no longer be high enough Section D In that case you can adjust the wick height to improve the flame To do this the heater must have been switched off Follow the procedure below 1 Push the OFF button Fig 2 Pull the knurled wick adjustment knob off the heater so the wick height lock will be visible 3 Take the plastic collar between your thumb and index finger and pull it out Turn the collar up one step to either position 2 or 3 Fig Q Carefully push the collar back so the pin engages in the recess 4 Carefully reinstall the knurled wick adjustment knob This be done way only check the rear of the cap for the correct position If adjustment of the wick height does not have the required effect let the heater burn until all fuel has been used up Section H GD H the flame height is still too low the wick is set position 3 then contact your dealer or replace the wick refer to section M If the flame gets too high after adjus ting Fig Q the wick height lock should be placed one position lower again Otherwise smoke or soot may be caused G MALFUNCTION CAUSES AND SOLUTIONS If any malfunctioning cannot be solved from the directions below please contact your dealer THE HEATER DOES NOT IGNITE p batteries are not positioned correctly in the holder Check Fig F p There is not enough power left the batteries for the ignition Replace Fig
14. ned properly Reinstall the removable tank in the heater cap down Close the lid C IGNITING THE HEATER A new heater may give off some smells for a short while when it is used for the first time You should therefore provide extra ventilation or ignite the heater outside the living room When you use the heater for the first time first put the filled removable tank into place and then wait approximately 30 minutes before you ignite the heater This allows the glass fibre wick to soak up the fuel Follow the same procedure when you have completely burnt up all fuel from the tank and after the glass fibre wick has been replaced Before igniting the heater always check the fuel indicator to see whether the removable tank needs filling up Always ignite the heater with the ignition coil Never use matches or a cigarette lighter Follow the procedure below H Turn the knurled wick adjustment knob clockwise to its stop Fig J If you apply more pressure you may turn it slightly further however it will automatically return to the startposition 2 Push the ignition button Fig but do not apply too much force Release the ignition button as soon as a flame is visible in the combustion chamber If the heater has been used only a few times and the wick adjustment knob is not locked first turn the wick adjustment knob Fig L completely left before putting the wick in the highest position for igniti
15. ommend doing this in highly insulated or draught free rooms and or at altitudes above 1 500 metres Do not use your heater in cellars or other underground areas SAFE TOP The heater is supplied with a safe top This application decreases the temperature of the top plate In this way the risk of harmful accidents at accidentally touching the top plate is considerably decreased However be aware that the top plate still becomes hot Avoid any contact with the top plate and grille THE RIGHT FUEL Only use Class C1 paraffin fuel in accordance with BS2869 Part two or equivalent Your heater has been designed for use with high quality water free pure paraffin oil such as Zibro Extra or Zibro Kristal Only fuels of this kind will ensure clean and proper burning Lower quality fuel may result in excessive tar deposits on the glass fibre wick incomplete burning reduced heater lifetime smoke and or smells deposits the grid or mantle Using the right fuel is therefore essential for safe efficient and comfortable use of your heater Only the use of the correct fuel will ensure Always refer to your local dealer for the right fuel for your heater safe efficient and comfortable use of your heater This transportation cap is packed separately in the box Only this cap ensures trouble free transportation of the heater after use Store it well GD MANUAL gt P P P P A INSTALLING THE HEAT
16. on Section O 1 ee el l le l llll L vlqa al r n K r After having ignited the heater always check whether the combustion chamber is level by sliding it slightly to the left and the right by its handle Fig E This should be a smooth movement If the combustion chamber is not level this will cause smoke and soot to develop BURNING OF THE HEATER After you have ignited the heater it will take 10 to 15 minutes before you can check whether the heater is burning well Too high a flame may cause smoke and soot whereas too low a flame causes smells The page opposite the folding page shows the minimum and maximum permissible burning heights of the flame Fig P The flame can be slightly adjusted with the knurled wick adjustment knob Fig L Burning that is too low may be caused by 9 insufficient fuel fill the tank 9 poor fuel quality contact your dealer 9 insufficient ventilation put window or door ajar p wastage of the wick contact your dealer or replace the wick refer to section M SWITCHING OFF THE HEATER Let the heater burn at its lowest setting Fig L for approximately one minute Then slowly turn the knurled wick adjustment knob anti clockwise to its stop The flame will extinguish after a little while In case of an emergency switch off the heater by pushing in the OFF button Fig M ADJUSTING THE WICK HEIGHT After a period of time the combustion
17. ry costs we recommend that you always read the Directions for Use carefully first case they offer no solution please take the heater to your dealer for repair Highly inflammable substances may induce uncontrollable burning causing flames to break out Should this happen never try to move the heater but always switch off the heater immediately refer to Section cases of emergency you may use a fire extinguisher but only a type B extinguisher a carbon dioxide or powder extinguisher 10 TIPS FOR SAFE USE 1 Make sure that children are always aware of the presence of a burning heater 2 Do not move the heater when it is burning or still hot Do not refill nor service the heater when it is burning or still hot 3 Position the front of the heater at a minimum distance of 1 5 metres from walls curtains and furniture 4 Do not use the heater in dusty rooms or in very draughty places In both cases you will not have optimum burning 5 Switch off the heater before you go to sleep Store and move fuel only in suitable tanks and jerrycans 7 Make sure that the fuel is not exposed to heat or extreme temperature changes Always store the fuel in a cool dry and dark place sunlight will affect the quality 8 Never use the heater in places where harmful gasses or fumes may be present e g exhaust gasses or paint fumes 9 Be aware
18. that the grid of the heater becomes hot If the appliance is covered there is a risk of fire 10 Always make sure that there is sufficient ventilation REPLACEMENT OF THE WICK ENSURE THAT THE HEATER IS OFF AND COMPLETELY COOL BEFORE STARTING TO REPLACE THE WICK H Open the lid and remove the removable tank 2 Remove the batteries from the battery holder lt KED 3 Open the front grill Remove the combustion chamber from the heater Close the grill t E 4 Pull the knurled wick adjustment knob off the heater 7 WW 5 Unscrew the three cabinet screws the back sides of the heater Pull the cabinet forward slightly and then remove it from the base plate 6 Unscrew the four wing nuts from the wick holder Lift up the wick holder and the wick mechanism Remove the screw on the stem holding the bracket and remove the bracket spring and wick height lock 9 Turn right the stem to the end and remove the wick sleeve with wick Lift the wick sleeve up and remove it from the primary air tube 11 Squeeze the wick to loosen the three wick pins and remove the wick from the wick sleeve Ensure that you are wearing gloves and that you have a container in which to put the old wick ES 2225 lt 12 Install the wick to the wick sleeve accord
Download Pdf Manuals
Related Search