Bionaire BAP1400-U Owner's Manual
Contents
1. S ground service for tracking purposes 4 All shipping charges must be prepaid by you 5 Mark the outside of your package Bionaire J CS THG LLC 303 Nelson Avenue Neosho MO 64850 SHIPPING AND HANDLING CHARGES 7 50 USD This Warranty gives you specific legal rights and you may have other rights which vary from state to state The provisions of this Warranty are in addition to and not a modification of or subtraction from the statutory warranties and other rights and remedies contained in any applicable legislation To the extent that any provision of this Warranty is inconsistent with any applicable law such provision shall be deemed voided or amended as necessary to comply with such law 2006 J CS THG LLC Bionaire the Bionaire logo and PERMAtech are trade marks of J CS THG LLC BAP140006EM1 Printed in China a 2 BIONAIRE PERMAtech air cleaner mone BAP1400 BAP140006EM1 qxd 4 24 06 3 53 PM Page 2 A AIR CLEANER SAFETY PLEASE READ AND SAVE THESE IMPORTANT SAFETY INSTRUCTIONS IMPORTANT SAFEGUARDS When using electrical appliances basic safety precautions should always be followed to reduce the risk of fire electric shock and injury to persons including the following e Read all instructions before using the appliance e To avoid fire or shock hazard plug the appliance directly into a 120V AC electrical outlet e Ifthe filter is covered by a bag when shipped remove plastic2. a soft clean dampened cloth 3 The rear air inlet grill can be removed and washed in warm soapy water not dishwasher safe Dry before replacing in the unit 4 The filtered air outlet can be cleaned of dust with a small soft brush 5 If you wish to clean the inside of the air cleaner please only use a dry soft cloth to wipe it down 6 Filter Indicator a filter reminder dial is manually set to remind the user when it is time to replace the filter 7 Every few weeks check the condition of the pre filter 8 Remove the inlet grill If the foam pre fiter has collected a noticeable amount of dust remove it from the inlet of the grill and wash it in warm soapy water Rinse and dry the pre fit ter thoroughly before replacing it in the inlet of the grill 9 With the inlet grill removed check the condition of your PERMAtech filter If the filter is dirty remove them by gripping on both sides and pulling forward 10 To clean the PERMAtech filter use a brush attachment with your vacuum cleaner Run the attachment along the inlet and outlet side of the filter trying to clean between the pleated filter layers See Fig 2 NOTE Vacuuming will restore performance of the PERMAtech filter however the filter may appear stained This is normal and does not affect performance in any way DO NOT USE WATER OR ANY OTHER HOUSEHOLD CLEANERS OR DETERGENTS TO CLEAN THE PERMAtech FILTER 11 This model utilizes a hang tab
3. parts of this product excluding filters which are cov ered under separate warranty are guaranteed for a peri od of 5 years as follows 1 Within the first 30 days from date of purchase the store from which you purchased your product should replace this product if it is defective in materi al or workmanship provided the store has in stock replacement If you intend to assert any claim in connection with the product please follow the instructions in paragraph F 2 Within the first 60 months from date of purchase J CS THG LLC will repair or replace the product if it is defective in material or workmanship subject to the conditions in paragraph G F If you have any other problem or claim in connection with this product please write to our Consumer Service Department G IMPORTANT RETURN INSTRUCTIONS Your Warranty depends on your following these instructions if you are returning the unit to J CS THG LLC 1 Carefully pack the item in its original carton or other suitable box to avoid damage in shipping 2 Before packing your unit for return be sure to enclose a Your name full address with zip code and telephone number b A dated sales receipt or PROOF OF PURCHASE c Your 7 50 check for return shipping and han dling and d The model number of the unit and the problem you are having Enclose in an envelope and tape directly to the unit before the box is sealed 3 J CS THG LLC recommends you ship the package U P
4. BAP140006EM1 qxd 4 24 06 3 53 PM Page 1 NOTE The pleated material and rubber gasket should be facing towards the unit when applied Filter Life The filter has been designed to never need replacement however it does need servicing We recom mend that under normal conditions of continuous use the filters should be cleaned at least every 3 months to help maintain optimal performance Should the filter become damaged during cleaning replacements are available by calling 1 800 253 2764 14 The filter reminder dial should be set ahead 3 6 months depending on usage TROUBLESHOOTING Problem Solution Unit will not operate Check to make sure the unit is plugged in e Check to make sure the unit is on by turning the speed control knob to the desired speed setting Decreased airflow e If the filter has not been cleaned in six months or more clean the PERMAtech filter e Check the filters to make sure they are in good condition e Check to ensure nothing is blocking rear air inlet grill abd filtered outlet grill AIR CLEANER SERVICE INSTRUCTIONS 1 DO NOT attempt to repair or adjust any electrical or mechanical functions on this unit Doing so will void the warranty The inside of the unit contains no user serv iceable parts All servicing should be performed by qualified personnel only 2 If you need to exchange the unit please return it in its original carton with a sales receipt to the store where you purch
5. and filter clips to insure that the filter is properly in place Before replacing the PERMAtech filter make sure that the hang tab is securely in place 12 Align the clips on the side of your PERMAtech filter with the rails on the inside of the unit Gently slide the filter onto the rails 13 The filter clip should easily slide onto the filter hang tabs Do not use force while attaching the filter clip to the filter Align the clip on the side of your PERMAtech filter with the rails on the inside of the unit See Fig 3 and 4
6. ased it If you are returning the unit more than 30 days after the date of purchase please see the enclosed warranty 3 Should your air cleaner require service please call 1 800 253 2764 in North America for further assistance A return authorization will be given when you call 4 If you have any other questions or comments feel free to write to us Bionaire J CS THG LLC 303 Nelson Avenue Neosho MO 64850 Visit our website at www bionaire com FIVE 5 YEAR LIMITED WARRANTY SAVE THIS WARRANTY INFORMATION A This Warranty applies only to the original purchaser of this product B This Warranty applies ONLY to repair or replacement of any supplied or manufactured parts of this product that upon inspection by J CS THG LLC authorized person nel is shown to have failed in normal use due to defects in material or workmanship J CS THG LLC will deter mine whether to repair or replace the unit This Warranty does not apply to installation expenses C Operating this unit under conditions other than those recommended or at voltages other than the voltage indi cated on the unit or attempting to service or modify the unit will render this WARRANTY VOID D Unless otherwise proscribed by law J CS THG LLC shall not be liable for any personal injury property or any incidental or consequential damage of any kind resulting from malfunctions defects misuse improper installation or alteration of this product E All
7. bag before use e Keep the cord out of heavy traffic areas To avoid fire hazard NEVER put the cord under rugs near heat registers radiators stoves or heaters e To protect against electrical hazards DO NOT immerse in water or other liquids Do not use near water e Close supervision is necessary when any appliance is used by or near children or disabled persons e Always unplug the air cleaner before moving it opening the grill changing the filters cleaning or whenever the air cleaner is not in use Be sure to pull by the plug and not the cord e NEVER drop or insert any object into any openings DO NOT operate any appliance with a damaged cord or plug if motor fan fails to rotate after the appliance malfunctions or if it has been dropped or damaged in any manner Return appliance to manufacturer for examination electrical or mechanical adjustment or repair e Use appliance only for intended household use as described in this manual Any other use not recommended by the manufacturer may cause fire electric shock or injury to persons The use of attachments not recommended or sold by J CS THG LLC may cause hazards DO NOT use outdoors e NEVER block the air openings grills outlets or place on a soft surface such as a bed or sofa as this could cause the unit to tip over blocking the air intake opening grill e Keep unit away from heated surfaces and open flames e DO NOT attempt to repair or adjust a
8. ensure the best performance from your air cleaner please read and save the following instructions IONIZER Your air cleaner has an independently controlled ionizer which when turned on releases negative ions into outgoing filtered air Ions are tiny particles that carry a positive or negative charge These ions exist naturally around us in the air water and ground Both positive and negative ions are colorless odorless and completely harmless Negative ions help the air purification process by attaching themselves to very small airborne particles in the room These particles take on a negative charge and may join with positively charged particles such as dust pollen smoke and pet dander to form larger particles that are then more readily captured by the filter system or may be attracted to positively charged surfaces throughout the home like walls or floors This may occur more frequently when the filter is nearing the end of its functional life expectancy and is able to capture less of the charged particles You may also note after extended use that dust has collected around the grills or front panel This is from the ionization affect caused by the negative ions exiting from the air outlet This is additional evidence of the air cleaning effectiveness of negative ions The dust can be easily removed with a clean damp cloth or soft brush Finally using your ionizer may result in an occasional popping or cracki
9. hed to the tabs on the filter one way only The filter clip should easily slide onto the filter hang tab with only a small amount of pressure DO NOT use force while attaching the clip to the filter See Fig 3 Align the clip on the top of the PERMAtech filter with the rails on the inside of the air cleaner unit Gently slide the filter onto the rail See Fig 4 NOTE The side with the soft gasket should face inward 6 Replace air inlet grill back onto unit securely DO NOT POINT AIR OUTLET TOWARDS A WALL OPERATING INSTRUCTIONS 1 Plug into a 120V AC electrical outlet 2 Select the desired operating speed HI MEDIUM LOW by turning the knob to the appropriate setting 3 To release negative ions into the filtered air turn the ion izer knob to ON amp and the lonizer light will illuminate 4 The ionizer will not work unless the unit is running 5 For optimum air filtration it is recommended to operate the air purifier continuously Its rugged motor has been designed to give many years of use A Filtered Air Outlet B Speed Knob C lonizer Knob D lonizer Light E Filter Reminder Dial F Washable Foam Filter G Inlet Grill H PERMAtech Filter Fig 2 Fig 3 uw tt CLEANING MAINTENANCE INSTRUCTIONS 1 Turn the air cleaner off and unplug it before cleaning 2 The outside of the air cleaner can be cleaned with
10. ng sound This is a normal sound generally caused by a small build up of ions that when discharged cause the popping or cracking sound NOTE It is important to clean the PERMAtech filter at the recommended intervals Using the ionizer in conjunction with dirty filters may result in dirty particles exiting the air purifier and being attracted to walls carpets furniture or other household objects These dirty particles may prove very difficult to remove Homes with excessive amounts of pet dander dust or smoke may decrease the life expectancy of the PERMAtech filtration system and may interfere with the ionization process You may want to run the lonizer less often or and check the condition of the PERMAtech filter s more frequently in order to reduce particles from being attracted to surfaces throughout your home as mentioned above PRE OPERATING INSTRUCTIONS 1 Carefully unpack your air cleaner Select a firm level place where there are no obstructions to the air inlet or filtered air outlet A good location in a room is approximately 1 foot away from the wall in a central location of your home 2 Pull rear air inlet grill towards you by grasping the finger tabs and pulling forward 3 Remove PERMAtech filter by gripping on both sides and pulling forward 4 Remove protective plastic bag from the filter cartridge if packed in a bag 5 This model utilizes a hang tab and filter clip The clip can only be attac
11. ny electrical or mechanical functions on this unit Doing so will void your warranty The inside of the unit contains no user serviceable parts All servicing should be performed by qualified personnel only e WARNING To reduce the risk of fire or electric shock DO NOT use this air cleaner with any solid state speed control device e DO NOT place anything on top of unit PLEASE READ AND SAVE THESE IMPORTANT SAFETY INSTRUCTIONS CONSUMER SAFETY INFORMATION THIS PRODUCT IS EQUIPPED WITH A POLARIZED AC Alternating Current PLUG a plug having one blade wider than the other This plug will fit into the _ power outlet only one way If the plug does not fit fully into the outlet reverse the plug If it still does not fit contact qualified personnel to install the proper outlet DO NOT DEFEAT THE SAFETY PURPOSE OF THIS POLARIZED PLUG IN ANY WAY CORD AND PLUG INSTALLATION SAFETY INSTRUCTIONS The length of cord used on this appliance was selected to reduce the hazards of becoming tangled in or tripping over a longer cord If a longer cord is necessary an approved extension cord may be used The electrical rating of the extension cord must be equal to or greater than the rating of the air cleaner Care must be taken to arrange the extension cord so that it will not drape over the countertop or tabletop where it can be pulled on by children or accidentally tripped over Thank you for choosing a Bionaire air cleaner To
Download Pdf Manuals
Related Search