Refrigerator service manual
Contents
1. Refrigerator freezer 4 Single door serial Service manual 3 Parts identification Retrigeratar sla 1 Control panel 2 Lamp inside 3 Air outlet 4 Glass shelf 5 Crisper cover 6 Crisper drawer 7 Door rack cover 8 Egg rack inside 9 Door rack 10 Door lower rack Note Due to the updated modifications of our products your refrigerator may differ slightly from this Instruction Manual but the functions and using methods remain the same Refrigerator freezer 5 Single door serial Service manual 4 Refrigeration system diagram when the refrigerator is just powered on The refrigerant flows in the sequence Compressor gt Condenser Dry filter gt Capillary tube Evaporator 5 Circuit diagram The electronic controller directly controls the start and stop of compressor and hence the refrigerator temperature The door switch directly controls the start and stop of the lamp Refrigerator freezer 6 Single door serial 6 Maintenance service and Troubleshooting Service manual DEFECT EFFECT CAUSE REMEDY Group partially or Evaporator dose not frost even though motor compressor runs continually An empty refrigerant system indicates a leakage of R600a this loss is Leakage must be eliminated by completely generally to be looked for at the re soldering the out of soldering points connecting the defective point or re2. 8 When servicing the evaporator wear cotton gloves This is to prevent injuries from the sharp evaporator fins 9 Leave the disassembly of the refrigerating cycle to a specialized service center The gas inside the circuit may pollute the environment Refrigerator freezer 3 Single door serial Service manual 2 Specification Model No RS 45DL BC 345Y HCE Type Single door larder Capacity Net Total L Cu Ft 350 12 4 Freezer L Cu Ft Refrigerator L Cu Ft 350 12 4 Performance Climatic type SN NL ST T N ST Power V Hz L15V 60Hz 220 240V 50Hz Features General Temp Control Electronic Mechanical Electronic Features Defrosting Automatic Manual cycle automatic Reversible Door Yes Handle Recessed Grip Grip Lock No Refrigerant R134a R600a Foam Blowing Agent Cyclopentane Refrigerator Shelf Material No Glass 5 Compartment Door Basket PS 5 Interior Lamp Yes Vegetable Crisper PS 1 Vegetable Crisper Cover Glass 1 Egg Tray Yes Can storage Dispenser No Deodorizer Optional Freezer Star Rating N A Compartment Ice Maker Automatic Twist Normal N A Shelf Material No NA Drawer N A Door Basket N A Dimensions Net Width mm 594 Depth mm 634 Height mm 1752 5 Packing Width mm 648 Height mm 1831 Depth mm 713 Weight Net Packing Kg 59 69 Loading 20Ft 40Ft 40H C 27 54 73 Capacity End of Table
3. dose not freeze and an excessive done after carefully overheating of the condenser and creating vacuum motor compressor Blocked Because of the lack of circulation Freon Eventual impurities contained in the To restore the system capillary in the system there is no frosting of the Freon or in the components of the it must be emptied evaporator while a slight overheating refrigeration system before assembly substitute the of the first spiral of the condenser is and not retained by the filter can capillary or the noted obstruct the capillary evaporator entirely in case the capillary is coaxial with respect to the return tube then refill it Motor The system dose not work and the In case of short circuit the breakdown The compressor clixson intervenes interrupting is due to the electric winding if motor compressor short circuit delivery to the motor compressor blocked there is a mechanical failure must be replaced ed or in the motor compressor and then proceed blocked with refilling Motor com No frost forms on the evaporator even if In this case there is a mechanical The pressor the motor compressor is apparently failure in the diaphram valves which motor compressor dose not running regulary remaining continually open do not must be replaced Refrigerator freezer 7 Single door serial Service manual compress permit the piston to suck and and then proceed compressor the which co
4. Service manual Refrigerator service manual Single door serial MODEL RS 45DL BC 345Y HCE Refrigerator freezer 1 Single door serial Service manual Content ISafety precautions nanne aac cowses oud na peewee awa sa aad Cannes a ND INOUE Os 3 3 DiS DCCUICAM ON sen ss vorrversvordesenndermenere venster enseranui erder ard eeens eenden 4 4 3 Pa rts identification vs rrerri draaie eenen eee ere wert aes 5 5 4 Refrigeration system GiAQramM ccccscccaccccnnccccncccccncceencccscssceeescesesaees 6 6 DCUCHIE diaframmi aanwennen dansende ven RECA Oda and on TARAS EME NECA SONAR RAEN 6 6 6 Maintenance service and Troubleshooting aanv eennv eeens eenen 7 10 7 Quality information report vons vennen vense eeens enen ne vennen 11 11 8 Exploded view and part list ave n ee venne eeens eeens esvennnnens 12 15 Refrigerator freezer 2 Single door serial Service manual 1 Safety precautions Please read the following instructions before servicing your refrigerator 1 Check the refrigerator for current leakage 2 To prevent electronic shock unplug before servicing 3 Always check line voltage and amperage 4 If you use any kind of appliance check regular current voltage and capacity 5 Don t touch metal products in the freezer with wet hands this may cause frostbite 6 Prevent water from following onto electric elements in the mechanical parts 7 When tilting the refrigerator especially the thin plates ex Glass shelf or books
5. frigerant various components or in an eventual substituting the charge hole in the evaporator made by the damaged user evaporator Excessively This defect is indicated by the presence If in the refrigerant system a quantity The system must be full of water outside refrigerator near the of R600a is introduced which is emptied and motor caused by formations of ice on greater than that indicated the excess subsequently refilled the return tube gas dose not terminate its expansion introducing the in the evaporator but proceeds into correct quantity of the return tube R 600a Humidity in This defect is indicated by the partial The refrigerant system is humid when The system must be the system frosting of the evaporator and by there is a small percentage of water emptied and then continual defrosting cycles determined by the interruption of the flow of gas on the evaporator the motor compressor keeps running present which not completely retained by the dehydrator filter enters into circulation with the Freon and freezes at the capillary exit in the evaporator refilled after eliminating the humidity Presence of Poor performance of the refrigerant There is air in a refrigerating system Group must be air in the system which is indicated on the when during the filling phase vacuum drained and system evaporator with a slight frost which is not effected or it is not adequately subsequently refilled
6. is worn out Refrigerator freezer 8 Single door serial Service manual compressor runs Frost doesn t form at the evaporator Refrigerant leaks poor Repair when operating set for more than compressing compressor 30min separate the PTC starter from the Equal to the applied compressor and measure the voltage voltage rating voltage 10 between M and C of the compressor The applied voltage is not in the Advice the customer to use in range of rating voltage 10 the fixed Check the Test the resistance among M C S C resistance of the and M S Replace the compressor EN compressor Check the Test the resistance of the both resistance of the terminals in the PTC STARTER PTC Replace the PTC STARTER Check OLP Check if applying a OLP works within 30sec in forcible regular OLP OLP operation by turning instant power on and off Measure minimum starting voltage after Check the f Starts at the voltage checking stepsl 3 above And measure Normal starting state f of 85 below the pressure balance of the PTC with the interval of more than 5 min Starts at the voltage of more than 90 Check the starting sem state at the regular Replace the PTC Refrigerator freezer 9 Single door serial Service manual PTC Poor starting or First separate the PTC from the compressor and no operating of check the voltage between NO 5 and 6 in the the compressor PTC with a multitester or Wheatsto
7. ne bridge The value is in the range of N Check another ormal 14 28 for the 22 Q PTC electric component The value is 0 Replace the PTC YES Check another electric Separate the OLP from the compressor and check resistance value between two terminals of OLP with tester NO components Replace OLP Refrigerator freezer 10 Single door serial Service manual 7 Quality information report Quality information Thank you very much for purchasing Kelon products In order to provide you with more satisfied products please kindly fill in the questionnaire as the items indicated below We shall strive for best to optimize our products based on your suggestion Client name Sale area Date No Product Quality problem Service result Quantity Factory serial No model describe rate 6L Quality problem of whole sale product detail descriptions client suggest Factory activity Refrigerator freezer 11 Single door serial
8. nsequentely with refilling dose not circulate in the system Noisy In case of mechanical failure in the The cause of the excessive noise is The motor comp motor compressor there in an excessive normally to be sought for in a motor compressor ressor noise when the system is functioning in mechanical break down and only must be substituted case a suspension spring is unhooked rarely in the unhooking of one of the and then proceed banging will be heard and there will be suspension springs especially strong vibrations when the system starts up and stops NO COOLING The compressor Check if the current flows at the Poor contacting point Replace the thermostat doesn t run contacting point of the thermostat Check the current flowing of Shorted broken Replace the device Starting system Check if the current flows at the main Coil shorted Replace the compressor coil of the compressor Check the components on the main Replace circuit components Poor running of Measure the starting voltage Low voltage Increase the voltage the compressor Check if the current flows at the Replace the device Poor contacting contacting point of the starting point and broken system Check if the current flowing of Shorted Replace the compressor the sub coil of the compressor Is the current amount of the The coil of the compressor Replace the compressor electric components normal motor
Download Pdf Manuals
Related Search