LS-563 user's manual
Contents
1. Fert HEHH at SH ren r tt EET 32 LS 563 User s Manual BIOS Setup Chapter 3 lt BIOS Setup gt The single board computer uses the Award BIOS for the system configuration The Award BIOS in the single board computer is a customized version of the industrial standard BIOS for IBM PC AT compatible computers It supports Intel x86 and compatible CPU architecture based processors and computers The BIOS provides critical low level support for the system central processing memory and I O sub systems The BIOS setup program of the single board computer let the customers modify the basic configuration setting The settings are stored in a dedicated battery backed memory NVRAM retains the information when the power is turned off If the battery runs out of the power then the settings of BIOS will come back to the default setting The BIOS section of the manual is subject to change without notice and is provided here for reference purpose only The settings and configurations of the BIOS are current at the time of print and therefore they may not be exactly the same as that displayed on your screen To activate CMOS Setup program press DEL key immediately after you turn on the system The following message Press DEL to enter SETUP should appear in the lower left hand corner of your screen When you enter the CMOS Setup Utility the Main Menu will be displayed as Figure 3 1 You can use arrow keys to select2. Solid State Disk Interface Flash Type M systems DiskOnChip2000 Millennium flash disk Package Single chip flash disk in 32 pin DIP JEDEC Capacity 8M to 1GBytes of flash memory for DiskOnChip Data Reliability ECC EDC data protection Memory Window 8 KBytes of memory window Display Interface Chipset VIA S3 Twister T PN133T chipset built in S3 Savage4 SVGA controller with 128 bit 3D 2D engine Video Memory BIOS selectable 8 16 32MBytes of video memory shared with system memory Display Type CRT and LCD monitor LVDS TTL TFT DSTN Color LCD Display Mode VGA SVGA XGA SXGA UXGA Up to 1920 x 1440 of resolution for CRT monitor LCD Interface 36 bit TFT DSTN LCD interface with 256 gray shade Integrated 2 channel 110 MHz LVDS interface Support up to 1280 x 1024 of resolution Connector Onboard 16 pin header connector for CRT Onboard 50 pin header connector for TTL LCD Onboard 2 x 20 pin Hirose DF13 20DP 1 25V for LVDS Ethernet Interface Chipset PCI RTL8100B Fast Ethernet controller Type 10Base T 100Base TX auto switching Fast Ethernet full duplex IEEE802 3U compliant Connector Onboard 10 pin header connector Audio Interface Chipset VIA 686B built in AC97 3D audio controller with codec Interface Line in line out MIC in and CD in Connector Onboard 10 pin header for line in line out and MIC in Onboard 4 pin header for CD in LS 563 User s Manual Introduction Power and
3. Controller S3 Graphics Twister Realtek RTL8139 A B C 8130 PCI Fast Ethernet NIC Realtek RTL8139 A B C 8130 PCI Fast Ethernet NIC System board extension for PnP BIOS System board extension for PnP BIOS 46 LS 563 User s Manual Appendix C 3 lt IRQ and DMA Resource gt C 3 1 IRQ IRQ Number Device System timer Standard 101 102 Key or Microsoft Natural Keyboard Programmable interrupt controller Communications Port COM2 Communications Port COM1 Printer Port LPT2 Standard Floppy Disk Controller Printer Port LPT1 System CMOS real time clock Realtek RTL8139 A B C 8130 PCI Fast Ethernet NIC Realtek RTL8139 A B C 8130 PCI Fast Ethernet NIC Avance AC 97 Audio for VIA R Audio Controller VIA Tech 3038 PCI to USB Universal Host Controller VIA Tech 3038 PCI to USB Universal Host Controller S3 Graphics Twister IRQ Holder for PCI Steering IRQ Holder for PCI Steering 9 IRQ Holder for PCI Steering 10 Communications Port COM3 11 Communications Port COM4 12 PS 2 Compatible Mouse Port 13 Numeric data processor 14 Primary IDE controller dual fifo 14 VIA Bus Master PCI IDE Controller 15 Secondary IDE controller dual fifo 15 VIA Bus Master PCI IDE Controller O O O O O O O O ON O Qn RAN O C 3 2 lt DMA gt Channel Device 0 free free Standard Floppy Disk Controller free Direct Memory Access Controller free free free NO oO fF WD 47 LS 563 User s Manual Appendix This
4. Description 1 5V Standby 2 Ground 3 Power On Connector CPUFAN SYSFAN Type 3 pin fan power wafer connector Pin Description Pin Description Pin Description 1 Ground 2 12V 3 Fan Control 19 LS 563 Users Manual Hardware Setup 2 7 lt Display Interfaces gt 2 71 Standard Analog VGA Interface The board is integrated with VIA S3 Twister T PN133T chipset built in S3 Savage4 3D SVGA core with BIOS selectable 8 16 32MBytes video memory shared with system memory Connector JVGA Type 16 pin 2 x 8 2 54 pitch pin header Pin Description Pin Description 1 Red 9 Green 2 Blue 10 N C 3 Ground 11 Ground 4 Ground 12 Ground 5 N C 13 Ground 6 N C 14 Data 7 HSYNC 15 VSYNC 8 Clock 16 N C a ana a vs a ba a ji 20 LS 563 User s Manual Hardware Setup 2 7 2 Digital VGA Interface Feet i AAA a Le TER Add i Jumper JVOLT1 Type onboard 3 pin header JVOLT1 LCD Voltage Setting 1 2 5V The board provides an LCD Interface VIA S3 Twister T PN133T 8606T chipset built in dual channel 18 bit LVDS and TTL interface for TFT and DSTN LCD panel 2 3 3 3V Default setting Jumper JVOLT2 Type onboard 3 pin header JVOLT2 LCD Power Sequence Control 1 2 Power Input Directly 2 3 Power Sequence Control by Chipset Default setting 21 ile ela MK 19 20 E 122 JLVDS2 19 120 7 1642 JLVDS1 3 1 EZ JVOLT2 Se JVOLT1 3
5. Environment Power Req 5V 12V DC input LBV O 4 2A typically with Intel Socket 370 FC PGA Pentium Ill 866 MHz CPU and 128 MB PC133 SDRAM ATX Function One 3 pin ATX interface with 5V standby Dimension 146 x 203 mm or 5 75 x 8 L x W standard EBX size Weight 0 30 Kg Board only Temperature Operating within 0 60 C 32 140 F Storage within 20 85 C 4 185 F Ordering Code LS 563VXL 5 25 Drive size Socket 370 Tualatin EBX single board computer with LVDS TTL TFT DSTN LCD CRT SVGA Audio LAN PC 104 plus and 4 COM 2 LPT 16 bit GPIO and DiskOnChip Socket LS 563VTL 5 25 Drive size Socket 370 Tualatin EBX single board computer with CRT SVGA AV amp S Video TV out Audio LAN PC 104 plus and 4 COM 2 LPT 16 bit GPIO and DiskOnChip Socket OEM Version Other Configuration based on LS 563 with Optional Removable Interface LS 563 User s Manual 1 3 lt Component Placement gt 1 X 168 pin DIMM Supports up to 512MB PC133 SDRAM PCI Slot PC 104 amp PC 104 FC PGA FC PGA2 socket 370 for Intel Pentium Ill Celeron or VIA C3 processor Realtek RTL8100B VIA Twister T PN133T LVDS TTL TFT DSTN 10 100Mbps LAN amp 686B chipset LCD interface 11 n r n LS 563 User s Manual Introduction 1 4 lt Block Diagram gt Intel Socket 370 Tualatin Coppermine FC PGA2 FC PGA Pentium Ill Celeron VIA Socket 370 C3 Samuel I II Ezra CPU FSB 66 1
6. Mode Setting JCSEL2 JDOC SWDT JRTC JWDT JLAN JCSEL1 JVOLT2 JVOLT1 14 LS 563 User s Manual Hardware Setup 2 3 lt Connector Reference gt Connector Function Remark CPU CPU Socket PGA370 Standard DIMM1 168 pin DIMM Socket Standard IDE1 40 pin Primary IDE Port Standard IDE2 44 pin Secondary IDE Port Standard FDD 34 pin Floppy Port Standard LPT1 26 pin Primary Parallel Port Standard LPT2 26 pin Secondary Parallel Port Standard JUSB1 10 pin 1st 2nd USB Port Standard JCOM 40 pin COM1 2 3 4 RS232 Serial Port Standard JDIO 20 pin 16 bit GPIO Port Standard DOC 32 pin DiskOnChip Socket Standard JPS2 10 pin PS 2 Keyboard Mouse Connector Standard SIR 5 pin SIR IrDA Port Standard PWR 4 pin AT Power Connector Standard JPS 3 pin ATX Signal Connector Standard JFRNT 14 pin Front Panel Connector Standard CPUFAN 3 pin CPU Fan Connector Standard SYSFAN 3 pin System Fan Connector Standard JVGA 16 pin Internal VGA Port Standard JAUDIO 10 pin Audio Port Standard CDIN 4 pin CD in Interface Standard LAN 10 pin LAN Port Connector Standard JBKL 5 pin Backlight Inverter power connector VXL Only JLCD 50 pin TTL LCD Interface VXL Only JLVDS1 JLVDS2 20 pin LVDS LCD Interface VXL Only CN_TV TV out Interface VTL Only PCI1 32 bit PCI Slot Standard JPCIX 10 pin PCI Expansive Signal Header Standard PC104AB CD 104 pin PC 104 Connector Standard PC104P 120
7. pin PC 104 plus Connector Standard 15 LS 563 User s Manual Hardware Setup 2 4 lt CPU and DRAM setting gt The board is based on Intel socket 370 Pentium Ill Celeron architecture supports Intel FC PGA and VIA C3 CPUs at 66 100 133 MHz of FSB The FSB ratio and voltage of CPU is default set by CPU without any additional jumper selection The CPU should be installed into the CPU ZIF socket The board supports PC100 133 SDRAM up to 512 Mbytes of memory capacity on one 168 pin DIMM socket DIMM1 2 5 lt CMOS Setting gt The board s data of CMOS can be setting in BIOS If the board refuses to boot due to inappropriate CMOS settings here is how to proceed to clear reset the CMOS to its default values Jumper JRTC Type onboard 3 pin header JRTC Mode 1 2 Clear CMOS 2 3 Normal Operation Default setting See ey ee 0 0 0 u m u u I Bab fay Y JRTC 16 LS 563 User s Manual Hardware Setup 2 6 lt Watchdog Timer Setting gt The watchdog timer makes the systems auto reset while it stops to work for a period The onboard watchdog timer can be set as system reset or active NMI mode by jumper JWDT the timeout value can be set as 1 2 10 20 110 or 220 seconds by jumper SWDT Jumper JWDT Type onboard 3 pin header JWDT Watchdog Timer 1 2 Active NMI 2 3 Reset Default setting Jumper SWDT Type onboard 4 button 2 level DIP switch Timeout Value SWDT 1 2 3 4 1 Sec
8. your function press Enter key to accept the selection and enter the sub menu Figure 3 1 CMOS Setup Utility Main Screen Phoenix AwardBIOS CMOS Setup Utility k Standard CMOS Features K Frequency Voltage Control Advanced BIOS Features Load Fail Safe Defaults Advanced Chipset Features Load Optimized Defaults Integrated Peripherals Set Supervisor Fassword Power Management Setup Set User Passuord FnP PGI Configurations Save amp Exit Setup FG Health Status Exit Without Saving Esc Quit F Menu in z Select Item FiA Save amp Exit Setup Time Date Hard Disk Type 33 LS 563 User s Manual BIOS Setup This Page is Left for Blank This Page is Left for Blank 34 LS 563 User s Manual Driver Installation Chapter 4 lt Driver Installation gt The driver CD offers auto run menu It will detect and select the type of single board computer and helps you install the drivers automatically Install Chipset Driver The selection helps you to install the INF of related chipset interface Install VGA Driver The selection helps you to install the driver of onboard VGA interface Install LAN Driver The selection helps you to install the driver of onboard LAN interface Install Audio Driver The selection helps you to install the driver of onboard audio interface Link to lt Website gt Homepage The selection helps you to link to the website to find the updated technical documents and download d
9. 00 133 MHz CRT LVDS TTL 1 x 168 pin DIMM Socket LCD 512 MB PC133 SDRAM PCI Bus Interface 10 100 Mbps RTL8100B LAN LAN PCI Add on Cards ATA100 IDE ATAPI Device PC 104 plus Add on Modules VIA Povotpius Adon moules ust Devices gt Codes 686B S B a USB Devices PC 104 Add on Modules PS 2 Keyboard ISA Bus Interface PS 2 Mouse Winbond SI O Serial Device DiskOnChip COM3 4 Parallel Device 16 bit GPIO 12 LS 563 User s Manual Hardware Setup Chapter 2 lt Hardware Setup gt This chapter contains the information for the installation of hardware The install procedure includes jumper settings CPU and memory installation fan I O and panel connections 2 1 lt Connector Location gt PCI1 DOC PC104AB PC104CD JPCIX CPUFAN PWR CN_TV FRNT PC104 CPU LAN JLVDS2 CDIN FDD JAUDIO 44414114 AR HRE d THH Hit oo E DIMM1 H IDE1 ers JLVDS1 JLPT1 JVGA H t ES JPS 1 JDIO JCOM SIR JUSBI JPS2 JLCD IDE2 JBKL SYSFAN 13 LS 563 User s Manual Hardware Setup 2 2 lt Jumper Location amp Reference gt Jumper Function JRTC CMOS Setting JWDT Watchdog Timer Mode Setting SWDT Time Out Value of Watchdog Timer Setting JDOC DiskOnChip Address Setting JVOLT1 Flat Panel s Voltage Setting JVOLT2 Flat Panel s Power Setting JLAN LAN Enable Disable Setting JCSEL1 COM2 RS 232 422 485 Mode Setting JCSEL2 COM2 RS 232 422 485
10. 1 A Mal 2 KM Ths Audio Cable X 1 RJ45 LAN port Cable sss X 1 L E L m da AV and S Video TV out cable LS 563VTL only X 1 Printed Matter and Software Users Mandl iia X 1 BLE A X 1 Chapter Introduction ur 7 tet Produc NNN 7 1 2 lt Product Specification gt aiaee ae aaa 8 123 G nmporent Placement aan Eee 11 14 Block Diagram Far en 12 Chapter 2 lt Hardware Setup Sitesidir i A Taa aiaiai 13 21 C0nneClor Loca ON Sa sere 13 2 2 lt Jumper Location amp Reference gt eee eee 14 2 3 lt Connector Reference gt 15 2 42 GPU and DRAM SENGS a nee ee 16 252 MOS SENG eee 16 25 4 Watchdog Timer Setting gt 17 2 7 Embedded Flash Disk 2 a ae 18 2 6 lt Power amp Fan Connector sure ie 19 2 lt Display Interfaces en eek 20 2 71 Standard Analog VGA Interface esse eee 20 2 7 2 Digital VGA Interface aa ia 21 PTE al BEG n AGO eV a EN REN 25 2 8 lt Ethernet INlerface an een ras 26 2 9 AUNE an ei ne 27 ee 28 211 SAP NE Nese 28 2 102 GPIO INEA CE S sion or 29 211 Expansive BUS Menace ea nee men 30 2111x POLDUS iHteface Suicida 30 221 2 PO 1042 Inlerace Sa ed 31 2 12 SWIICH and Indicator sea head 32 Chapter 3 lt BIOS Setup siii ibas 33 Chapter 4 lt Driver Installation gt id dit ab ds 35 Appendix A lt I O Ports Pin Assignment gt eee eee eee 36 LAS A A A 36 A NA 38 PJ PP NN SG 39 Ads Sellal PA See 40 a e o A eee eee ers oes 41 PO ME AT EIA ON ee ee ee
11. 1 LS 563 User s Manual Hardware Setup Connector JLCD TTL TFT DSTN LCD Interface Type onboard 50 pin 2 x 25 2 0 pitch pin header Pin Signal Pin Signal 1 Ground 2 Ground 3 Ground 4 Ground 5 LCDVCC 6 LCDVCC 7 Ground 8 Ground gt PO 10 PI 11 P2 12 P3 13 P4 14 P5 15 P6 16 P7 17 P8 18 P9 19 P10 20 P11 21 P12 22 P13 23 P14 24 P15 25 P16 26 P17 27 P18 28 P19 29 P20 30 P21 31 P22 32 P23 33 P24 34 P25 35 SHFCLK 36 FLM 37 M 38 LP 39 Ground 40 Ground 41 P26 42 P27 43 P28 44 P29 45 P30 46 P31 47 P32 48 P33 49 P34 50 P35 22 LS 563 User s Manual Hardware Setup Connector JLVDS1 JLVDS2 LVDS TFT DSTN LCD Interface Type onboard 20 pin Hirose DF13 20DP 1 25V Pin Signal Pin Signal 1 LCDVCC 2 LCDVCC 3 GND 4 GND 5 TA 6 TA 7 GND 8 TB 9 TB 10 GND 11 TC 12 TC 13 GND 14 TCLK 15 TCLK 16 GND 17 N C 18 N C 19 GND 20 GND Connector JBKL LCD Backlight Inverter Power Connector Type 5 pin wafer connector Pin Description 12V Ground Ground Ground ENABKL OIA OR After connecting devices properly please select panel type number in the BIOS Phoenix AwardBIOS CMOS Setup Utility Advanced Chipset Features DRAM Timing By SPD Disabled DRAM Clock Host CLK SDRAM Cycle Length 3 Menu Level Bank Interleave D ed Memory Hole P2C C2P Concurrency System BIO
12. 41 A 7 lt PS 2 Keyboard and Mouse Port gt sse eee 41 Appendix B lt BIOS Flash Information gt eee eee eee 43 Bl BIOS Fash TOO ac ee e 43 Bes FEST Med 43 Appendix G lt System Resource ad 45 Gal O Po Address MAN Ne 45 C 2 lt Memory Address Map gt sss 46 C 3 lt IRQ and DMA Resource gt eee eee eee 47 Comac Nomad 49 LS 563 User s Manual Introduction Chapter 1 lt Introduction gt 1 1 Product Overview The LS 563 SBC Single Board Computer is an all in one industrial 5 25 drive size EBX compliant motherboard computer based on Intel socket 370 architecture supports Intel Tualatin Coppermine FC PGA2 FC PGA Pentium Ill Celeron and VIA C3 Samuel III Ezra CPU up to 1 4 GHz at 66 100 133 MHz of FSB with PC100 133 SDRAM Based on value VIA S3 Twister T PN133T chipset with VIA 8606T north bridge and 686B south bridge the LS 563 supports the Intel and VIA latest socket 370 based CPU 512 MB PC133 SDRAM and VIA S3 Savage4 3D SVGA core with BIOS selectable 8 16 32 MB video memory shard with system memory To be the requirement of multi media computing platform the LS 563 also offers the LVDS TTL TFT DSTN LCD interface and optional AV and S video TV out at NTSC PAL mode The onboard Fast Ethernet PC 104 and PC 104 plus 4 COM 2 LPT ports 2 USB ports and 16 bit GPIO port also provides the interfaces for embedded peripherals for the POS POI Kiosk ATM and Panel PC industrial workstation node terminal transaction stati
13. 5 D I 4 16 D I 5 17 D I 6 18 D I 7 19 5V 20 12V 2011103150350 Ahjaa dd dad pe brp dred 7 BE 7 PETTEE TESE ERE JDIO 29 LS 563 User s Manual Hardware Setup 2 11 lt Expansive Bus Interface gt The board offers PCI ISA expansive bus interfaces including one PCI slot and one PC 104 plus connector 2 11 1 lt PCI bus interface gt The onboard expansive PCI bus interface offers 3 sets of bus master PCI signal to support up to 3 pieces of PCI based add on cards via an additional riser card Connector JPCIX 3 x Bus Master PCI Interfaces Supported Type 8 pin 2 x 4 2 54 pitch pin header Pin Description Pin Description 1 N C 2 Ground 3 PCI Clock 1 4 PCI Clock 2 5 Request 1 6 Request 2 7 Grant 1 8 Grant 2 pen l 2 4 HENNE AAA 30 LS 563 User s Manual Hardware Setup 2 11 2 lt PC 104 Interface gt The onboard PC 104 plus interface includes 32 bit PCI based 120 pin PC 104 plus interface and 16 bit ISA based PC 104 interface There is one set of bus master PCI signal is supported on the onboard PC 104 plus interface PC 104 31 Connector JFRNT Type onboard 14 pin 2 x 7 2 54 pitch pin header LS 563 User s Manual Hardware Setup 2 12 lt Switch and Indicator gt Function PIN Signal Function 13 Ground Power 11 PW BN Button SPEAKER 9 N C 7 Ground Reset Ground 5 RST_SW PWRLED 3 HD_LED HDD LED 1 VCC
14. AM One 168 pin DIMM socket supports up to 512MB PC100 133 SDRAM BIOS Phoenix Award 2Mb PnP flash BIOS Enhanced IDE PCI enhanced IDE interface supports dual ports up to 4 ATAPI devices with UltraATA 100 supported One 40 pin IDE1 and one 44 pin IDE2 box header Green Function Power saving mode supported in BIOS with DOZE STANDBY and SUSPEND modes ACPI version 1 0 and APM version 1 2 compliant Watchdog Timer 6 level generates NMI or system reset programmable watchdog timer Real Time Clock VIA 686B built in RTC with onboard lithium battery Multi O Port Chipset VIA 686B built in super I O controller Winbond W83977EF AW for COM3 4 and LPT2 Ports Serial Port Three RS 232 serial port COM1 3 4 and one jumper selectable RS 232 422 485 serial port COM2 Both with 160550 compatible UART and 16 bytes FIFO Parallel Port Two bi direction parallel port with SPP ECP EPP mode USB Port Two USB ports with USB version 1 1 compliant GPIO Port One 16 bit programmable general purpose l O port Floppy Port One floppy port supports up to two FDD IrDA Port One IrDA compliant Infrared interface supports SIR K B amp Mouse PS 2 keyboard and mouse port Expansive Interface PCI Bus One 32 bit 33 MHz PCI slot with 3 x bus master PCI via an additional riser card PC 104 plus One 120 pin 32 bit PCI based PC 104 plus interface One 104 pin 8 16 bit ISA based PC 104 interface LS 563 User s Manual Introduction
15. LS 563 Single Board Computer User s Manual Edition 1 1 2004 3 26 Copyright Copyright 2003 2004 All rights reserved This document is copyrighted and all rights are reserved The information in this document is subject to change without prior notice to make improvements to the products This document contains proprietary information and protected by copyright No part of this document may be reproduced copied or translated in any form or any means without prior written permission of the manufacturer All trademarks and or registered trademarks contains in this document are property of their respective owners Disclaimer The company shall not be liable for any incidental or consequential damages resulting from the performance or use of this product The company does not issue a warranty of any kind express or implied including without limitation implied warranties of merchantability or fitness for a particular purpose The company has the right to revise the manual or include changes in the specifications of the product described within it at any time without notice and without obligation to notify any person of such revision or changes Trademark All trademarks are the property of their respective holders Any questions please visit our website at http www commell com tw Packing List Hardware LS 563 Motherboard e X 1 Cable Kit UltraATA 100 IDE cable X 1 X 1 X 1 X 2 Dual USB ports Cable eee X
16. Page is Left for Blank This Page is Left for Blank 48 LV 671 User s Manual Contact Information Contact Information Any advice or comment about our products and service or anything we can help you please don t hesitate to contact with us We will do our best to support you for your products projects and business COMMELL IPC Division Taiwan Commate Computer Inc COMMELL Your Embedded Applied Computer Partner www commell com tw Address 8F No 94 Sec 1 Shin Tai Wu Rd Shi Chih Taipei Hsien Taiwan TEL 886 2 26963909 FAX 886 2 26963911 Website http www commell com tw E Mail info commell com tw General Information tech commell com tw Technical Support 49
17. S Cacheable Video RAM Cacheable Frame Buffer 5ize AGP Aperture Size AGP 4k Mode AGP Driving Control Panel Type Boot Device Select OnChip USE USB Keyboard Support USB Mouse Support OnChip Sound tl Move Enter 5elect PU PD Value F1 i Save ESC Exit Fi General Help F FS Previous Values F6 Fail Safe Defaults Optimized Defaults 23 LS 563 User s Manual Hardwar BIOS Configuration for Flat Panel The selection of display type for flat panel depends on the LCD display you use Please entry the Advanced Chipset Features screen on the main screen and find the item of Panel Type and set it with the specification of the flat panel Panel Type Support Display 640x480 TFT 800x600 TFT 1024x768TFT 2 pixel clk at 32Mhz 1280x1024 TFT 640x480 DSTN 800x600 DSTN 1024x768 DSTN 1024x768 TFT 1 pixel clk at 65Mhz 800x600 TFT 1024x768 TFT 1280x1024 TFT pixel 1400x1050 TFT 800x600 DSTN 1024x768 DSTN 1280x1024 DSTN 640x480 TFT Default setting 24 LS 563 User s Manual Hardware Setup 2 73 lt TV out Interface gt The board provides the optional AV and S video TV out Interface at both of PAL and NTSC mode with VIA S3 Twister T PN133T 8606 chipset built in VGA interface and VIA 1621 TV out encoder Connector CN TV Type onboard 8 pin 2 x 4 2 54 pitch pin header Pin Description Pin Description 1 Ground 2 TVY 3 TVC 4 Ground 5 Ground 6 N C 7 TVCVBS 8 Groun
18. d SHELELESTEZLELFELLSITELEIERTE HAS y ar 4 Letter r ee EGG Optional TV out Cable 25 LS 563 User s Manual Hardware Setup 2 8 lt Ethernet Interface gt The board integrated with 10 100BASE TX Fast Ethernet interface at the type of 10Base T 100Base TX auto switching Fast Ethernet with full duplex and IEEE 802 3U compliant The LAN controller RTL8100B provides the powerful Fast Ethernet interface with embedded operating system OS supported green function power saving mode wake on LAN and advanced network management functions Jumper JLAN Type onboard 3 pin header JLAN LAN Interface 1 2 Enable 2 3 Disable Default setting Connector LAN Type 10 pin 2 x 5 2 54 pitch header connector Pin Description Pin Description 1 TX 2 TX 3 RX 4 N C 5 N C 6 RX 7 N C 8 N C 9 Ground 10 Ground LAN Indicator LED LAN_LED Type 3 pin LED Pin 1 Green 2 Green 3 Yellow Description 10 Mbps Mode 100 Mbps Mode Active Transfer 26 LS 563 User s Manual Hardware Setup 2 9 lt Audio Interface gt The board integrates with AC97 3D audio interface REALTEK ALC201A code that provides line in line out MIC in and CD in interfaces for industrial applications with audio function Connector JAUDIO Type 10 pin 2 x 5 2 54 pitch pin header Pin Description Pin Description 1 Line Right 2 Ground 3 Line Left 4 MIC 5 MIC 6 Ground 7 N C 8 Line Out Left 9 Line O
19. irectly Browse this CD The selection helps you to find the drivers in this CD directly 35 LS 563 User s Manual Appendix Appendix A lt I O Ports Pin Assignment gt A 1 lt IDE port gt Connector IDE1 Type 40 pin box header 40 2 Pin Description Pin Description 1 Reset 2 Ground 3 D7 4 D8 5 D6 6 D9 7 D5 8 D10 9 D4 10 D11 11 D3 12 D12 13 D2 14 D13 15 D1 16 D14 17 DO 18 D15 19 Ground 20 N C 21 REQ 22 Ground 23 IOW STOP 24 Ground 25 IOR HDMARDY 26 Ground 27 IORDY DDMARDY 28 IDESEL 29 DACK 30 Ground 31 IRQ 32 N C 33 A1 34 CBLID 35 AO 36 A2 37 CSO MASTER CS 38 CS1 SLAVE CS 39 LED ACT 40 Ground 36 LS 563 User s Manual Appendix Connector IDE2 Type 44 pin 2 x 22 2 0 pitch box header Description Reset D7 D6 D5 D4 D3 D2 D1 DO Ground REQ IOW STOP IOR HDMARDY IORDY DDMARDY DAGK IRQ A1 AO CS1 ASP1 Vcc Ground 37 43 44 Description Ground D8 D9 D10 D11 D12 D13 D14 D15 N C Ground Ground Ground Ground Ground N C SD A2 CS3 Ground Vcc Ground 1 LS 563 User s Manual Appendix A 2 lt Floppy Port gt Connector FDD Type 34 pin 2x 17 2 54 pitch pin header Pin Description Pin Description 1 Ground 2 DRIVE DENSITY SELECT 0 3 Ground 4 DRIVE DENSITY SELECT 1 5 Ground 6 N C 7 Ground 8 INDEX 9 Ground 10 MOTOR ENABLE A 11 Ground 12 DRIVER SELECT B 13 Ground 14 DRIVER SELECT A 15 Ground 16 MOTOR ENABLE B 17 Gro
20. n Description Pin Description 1 VCC 6 VCC 2 Data0 7 Datal 3 Data0 8 Datai 4 Ground 9 Ground 5 Ground 10 N C A 6 lt IrDA Port gt Connector SIR 00000 Type 5 pin 1 x 5 2 54 pitch pin header 5 1 Pin Description 1 Vcc 2 N C 3 IRRX 4 Ground 5 IRTX A 7 lt PS 2 Keyboard and Mouse Port gt 9 1 Connector JPS2 ARENA Type 10 pin 2 x 5 2 54 pitch pin header 10 9 Pin Description Pin Description 1 Keyboard Data 2 Mouse Data 3 N C 4 N C 5 Ground 6 Ground 7 Ground 8 Ground 9 Keyboard Clock 10 Mouse Clock 41 LS 563 User s Manual Appendix This Page is Left for Blank This Page is Left for Blank 42 LS 563 User s Manual Appendix Appendix B lt BIOS Flash Information gt B 1 lt BIOS Flash Tool gt The board is based on Award BIOS and can be updated easily by the BIOS auto flash tool You can download the tool online at the address below http www award com http www commell com tw Support Support SBC htm File name of the tool is awdflash exe it s the utility that can write the data into the BIOS flash ship and update the BIOS B 2 lt Flash Method gt 1 Get the bin file including the image of new BIOS you want to update 2 Power on the system and flash the BIOS 3 Re star the system Any question about the BIOS re flash please contact your distributors or visit our website at below http www commell com tw Support Support SBC htm 43 LS 563 U
21. on and industrial embedded application With these features LS 563 should be the value powerful and all in one integration solution including but not limited to the following Value Advanced Computing Platform Intel latest Tualatin Pentium Ill Celeron and VIA C3 CPU up to 1 4 GHz with 133 MHz FSB 512 MB PC133 SDRAM of system memory for high end industrial computing platform with high CPU and memory loading LVDS TTL TFT DSTN LCD Interface VIA S3 Twister T integrated S3 Savage4 3D SVGA core BIOS selectable 8 16 32 MB of video memory shared with system memory and 2 x 18 bit LVDS TTL TFT DSTN LCD interface offers the value and performance solution for the LCD based multi media applications Multiple I O Port and Solid State Disk Interface Onboard 4 COM 2 parallel 2 USB and 16 bit GPIO ports offer the interface for industrial embedded peripherals and application The DiskOnChip socket and IDE based DiskOnModule DOM interface provides the SSD Solid State Disk with flash disk for disk free and embedded OS based application LS 563 User s Manual Introduction 1 2 lt Product Specification gt General Specification Form Factor 5 25 drive size EBX compliant single board computer CPU Socket 370 Intel Pentium lll Celeron VIA C3 CPU Up to 1 4 GHz at 66 100 133 MHz of FSB Intel Tualatin Coppermine FC PGA2 FC PGA CPU and VIA C3 Samuel I II Ezra CPU Chipset VIA Twister T PN133T with 8606T and 686B DR
22. ond OFF OFF ON OFF 2 Seconds OFF OFF ON ON 10 Seconds OFF ON OFF OFF 20 Seconds OFF ON OFF ON 110 Seconds ON OFF OFF OFF 220 Seconds ON OFF OFF ON Default setting k 1 U BPE L U aan id aia ened HEP Peet eee eee ee HiH iio il a a elle il 17 LS 563 User s Manual Hardware Setup 2 7 lt Embedded Flash Disk gt The board supports both of 32 pin DiskOnChip 2000 and DiskOnChip IDE Pro or DOM DiskOnModule embedded flash disk The onboard 32 pin socket DOC supports DiskOnChip2000 single chip flash disk in 32 pin DIP JEDEC with jumper selectable address on jumper JDOC onboard 40 pin IDE1 box header and 44 pin IDE2 header support DOM DiskOnModule or M systems DiskOnChip IDE Pro flash disk Jumper JDOC Type onboard 4 pin header JDOC DiskOnChip Address 1 2 DOOOh 2 3 D800h Default setting DOC socket HE HHR HH Optional DiskOnChip Optional DiskOnModule 18 LS 563 User s Manual Hardware Setup 2 6 lt Power amp Fan Connector gt This board needs a standard 4 pin 5V 12V power connector from a standard AT ATX power supply The connector JPS can let the board work as ATX system The Board also provides one CPU fan connector and one system fan connector Connector PWR Type 4 pin AT power connector Pin Description Cable Color Reference 1 12V Yellow 2 Ground Black 3 Ground Black 4 5V Red Connector JPS Type 3 pin ATX function connector Pin Description Pin Description Pin
23. ser s Manual Appendix This Page is Left for Blank This Page is Left for Blank 44 LS 563 User s Manual Appendix Appendix C lt System Resource gt C 1 1 0 Port Address Map Address Range Device 0060 0060 i8042prt 0064 0064 i8042prt 0170 0170 viadsk 01CE 01CF VgaSave 01F0 01F7 viadsk 0278 027A Parport 02E8 02EE Serial 02F8 02FE Serial 0376 0376 viadsk 0378 037A Parport 03B0 03BB VgaSave 03C0 03CF S3Inc 03C0 03DF VgaSave 03D4 03DB S3Inc 03E8 03EE Serial 03F0 03F5 Floppy 03F6 03F6 viadsk 03F7 03F7 Floppy 03F8 03FE Serial D000 D007 viadsk D008 DO00F viadsk DC00 DCFF alcxnt E000 E003 alcxnt 45 LS 563 User s Manual Appendix C 2 lt Memory Address Map gt Range x00000000 x0009FFFF x000A0000 x000AFFFF x000B0000 x000BFFFF x000F0000 x000F3FFF x000F4000 x000F7FFF x000F8000 x000FBFFF x000FC000 x000FFFFF x00100000 x00FFFFFF xE0000000 xE7FFFFFF xE0000000 xE7FFFFFF xE8000000 xEBFFFFFF xEC000000 xECO7FFFF xEC000000 xECOFFFFF xEC080000 xECO8FFFF xEC100000 xEC1001FF xEC101000 xEC1011FF xFEE00000 xFEEOFFFF xFFFE0000 xFFFFFFFF Device System board extension for PnP BIOS S3 Graphics Twister S3 Graphics Twister Motherboard resources Motherboard resources Motherboard resources Motherboard resources System board extension for PnP BIOS VIA CPU to AGP Controller S3 Graphics Twister VIA Standard CPU to PCI Bridge S3 Graphics Twister VIA CPU to AGP
24. und 18 DIRECTION 19 Ground 20 STEP 21 Ground 22 WRITE DATA 23 Ground 24 WRITE GATE 25 Ground 26 TRACK 0 27 Ground 28 WRITE PROTECT 29 Ground 30 READ DATA 31 Ground 32 HEAD SELECT 33 Ground 34 DISK CHANGE 38 LS 563 User s Manual Appendix A 3 lt Parallel Port gt Connector JLPT1 JLPT2 Type 26 pin 2 x 13 2 54 pitch pin header Pin Description Pin Description 1 STROBE 14 AUTO FEED 2 DO 15 ERROR 3 D1 16 INITIALIZE 4 D2 17 SELECT INPUT 5 D3 18 Ground 6 D4 19 Ground 7 D5 20 Ground 8 D6 21 Ground 9 D7 22 Ground 10 ACKNOWLEDGE 23 Ground 11 BUSY 24 Ground 12 PAPER EMPTY 25 Ground 13 SELECT 26 N C aa LEN Sr RE EL dd e kd ee tert EEE EE EEE EEE IAEA FrPs 39 LS 563 User s Manual Appendix A 4 lt Serial Port gt Connector JCOM Type 40 pin 2 x 20 2 54 pitch pin header Pin Description Pin Description 1 DCD1 2 RXD1 3 TXD1 4 DTR1 5 Ground 6 DSR1 7 RTS1 8 CTS1 9 HI 10 N C 11 DCDBTXC1 12 SINBTXC 13 SOUTBRXC 14 DTRBRC 15 Ground 16 DSR2 17 RTS2 18 CTS2 19 RI2 20 N C 21 DCD3 22 RXD3 23 TXD3 24 DTR3 25 Ground 26 DSR3 27 RTS3 28 CTS3 29 RI3 30 N C 31 DCD4 32 RXD4 33 TXD4 34 DTR4 35 Ground 36 DSR4 37 RTS4 38 CTS4 39 RI4 40 N C LS 563 User s Manual Appendix A 5 lt USB Port gt Connector JUSB1 Type 10 pin 2 x 5 2 54 pitch pin header for dual USB Ports 10 2 Pi
25. ut Right 10 Ground Connector CDIN CD Audio Input Interface Type 4 pin 1 x 4 2 54 pitch pin header Pin Description 1 CD LEFT 2 Ground 3 Ground 4 CD RIGHT u bl HET EE ser ram ET Te TSTST JAUDIO 27 LS 563 User s Manual Hardware Setup 2 10 lt Multi I O Port gt 2 10 1 lt Serial Ports gt The onboard provides 4 COM ports with RS232 mode and the COM2 also provides RS 422 485 mode which setting is done by the jumper JCSEL1 and JCSEL2 and actives at connector JCOM Jumper JCSEL2 JCSEL1 COM2 RS 422 485 Mode Selection Type onboard 6 12 pin header COM2 Mode JCSEL2 JCSEL1 RS 232 1 2 1 2 4 5 7 8 10 11 RS 422 9 6 2 3 5 6 8 9 11 12 RS 485 3 4 2 3 5 6 8 9 11 12 Default setting Connector Pin11 20 on JCOM COM2 Type 10 pin header Pin RS232 RS422 RS485 Pin RS232 RS422 RS485 11 DCD TX 485 12 RXD TX 485 13 TXD RX N C 14 DTR RX N C 15 Ground N C N C 16 DSR N C N C 17 RTS N C N C 18 CTS N C N C 19 RI N C N C 20 N C N C N C HHH HHHHH HHHH HHE ERE m HE str kne 107 4 1 JCSEL1 LS 563 User s Manual Hardware Setup 2 10 2 lt GPIO Interface gt The board provides 20 pin programmable 16 bit general purpose l O interface Connector JDIO Type 20 pin 2 x 10 2 54 pitch pin header Pin Description Pin Description 1 D O 0 2 D O 1 3 D O 2 4 D O 3 5 D O 4 6 D O 5 7 D O 6 8 D O 7 9 Ground 10 Ground 11 D I 0 12 D I 1 13 D I 2 14 D I 3 1
Download Pdf Manuals
Related Search