SERVICE MANUAL Level 1&2
Contents
1. ANTI SKID BRAKING SYSTEMS UNDER CERTAIN FAULT CONDITIONS EMITTED RF ENERGY CAN AFFECT THEIR OPERATION IF NECESSARY CONSULT THE VEHICLE DEALER MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF ENERGY 2 THE HANDPORTABLE TELEPHONE MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN POTENTIALLY EXPLOSIVE ATMOSPHERES EG PETROL STATIONS SERVICE STATIONS BLASTING AREAS ETC 3 OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT INCLUDING CELLULAR TELEPHONES MAY INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES CONSULT A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE 3 2 Cautions 1 Servicing and alignment must be undertaken by qualified personnel only 2 Ensure all work is carried out at an anti static workstation and that an anti static wrist Strap is worn 3 Use only approved components as specified in the parts list 4 Ensure all components modules screws and insulators are correctly re fitted after servicing and alignment 5 Ensure all cables and wires are repositioned correctly 5 Confidental ISSUE 1 Copyright 2009 NOKIA All rihts reserved NOKIA Care 4 ESD PROTECTION 6260 Slide RM 368 Service Manual Level 1 amp 2 Nokia requires that service points have sufficient ESD protection against static electricity when servicing the phone Any product of which the co2. All rihts reserved NOKIA 6260 Slide RM 368 a re Service Manual Level 1 amp 2 12 SOLDER COMPONENTS 9 0 Ar6 IWREIK UDO a pe pm eie ed mie A mn men a EK m E m i ie age e men a a SCH LI Ll 23 V2401 62200 X1400 ping Ed HO WA a NSd MH 1000 j poW VIMON A 30OVIN UOI B100105 BIYON WIHON gt o kel 3 y lt D 2 SE O y SZ m 3 S A Y D X60399 X17403 X1700 F2000 20 Confidental ISSUE 1 Copyright 2009 NOKIA All rihts reserved
3. amp 2 AC 4 Travel Charger No KIA Standatd Toolkit V2 NMP standard toolkit v2 For more information refer to the Service Bulletin SB 011 on NOKIA Online Supplier or manufacturer contacts for tool re order can be found in Recommended service equipment document on NOKIA Online ISSUE 1 NOKIA 6260 Slide RM 368 Ca re Service Manual Level 1 amp 2 9 SW UPDATE Flash concept Point of Sales To use the FLS 5 Flash Dongle you have to followw the user guide inside the sales package Please check always for the latest version of flash software wich is available on Nokia Online SERVICE e SOFTWARE EE PRODUCT SPECIFIC SAL BATTERY 11 Confidental ISSUE 1 Copyright O 2009 NOKIA All rihts reserved NOKIA 6260 Slide RM 368 Ca pa Service Manual Level 18 2 10 DISASSEMBLY INSTRUCTION 2 You must use the Nokia Standard Toolkit version 2 You will also need a DC plug 3 To remove the BATTERY COVER push the button on 4 Release the four clips holding the UI BOARD ASSY the bottom side and then lift up the BATTERY COVER with the SS 93 Make sure that the assembly is completely detached Fl Fr er oe e Ge Ze bei A 5 Carefully lift up the UI BOARD ASSY with the SS 93 in 6 Unlock the locking mechanism of the LCD connector the direction shown with the SS 93 and open the connector with the pliers Be careful not to damage the connector The UI BOARD ASSY can now be removed y w h E
4. 6260 Slide RM 368 a re Service Manual Level 1 amp 2 SERVICE MANUAL Level 1 amp 2 NOKIA 6260 SLIDE RM 368 Transceiver characteristics Band GSM EDGE 850 900 1800 1900 WCDMA 2100 band I 1900 band I1 900 Band VIII Display 2 4 HVGA 320x480 16M colours Active area 33 6 mm x 50 4 mm Keypad Multidimensional Navi Key Camera Main camera 5 Mpix double LED Flash Auto focus Carl Zeiss optics Secondary camera VGA Operating System S40 PR8 1 Connections 2 mm charger 2 5 mm AV connector Bluetooth 2 0 EDR USB 2 0 Micro USB GPS WLAN 802 119 Micro SD Transceiver with BL 5F battery pack Talk time Standby e Talk times are Up to 300 hours dependant on l network Up to 300 hours parameters and phone settings 1 Confidental ISSUE 1 Copyright 2009 NOKIA All rihts reserved NOKIA 6260 Slide RM 368 a re Service Manual Level 18 2 Table of contents Deg e E ue L n Ce A EE 3 la ge in du e orion delas 4 3 Wamings and CAUNONS REIS arbada aieneak 5 3 1 lala 5 3 2 CA a E 5 o A 6 Js Ceana MAN IN MIN rss narraciones lianas l 6 Battery Af tel ONE nl 8 Ta Sie tee AT 9 Bu SCC ACV ES aE E 10 D 0619 E 6 ae eee a ne er Pe ee Ce Pe ee ee eRe are nen ee een 11 10 Ban PI II II A 12 11 PASS CNM E 18 12 solder COAST 20 2 Confidental ISSUE 1 Copyright 2009 NOKIA All rihts reserved NOKIA 6260 Slide RM 368 a re Service Manual Level 18 2 1 CHA
5. AT 12 Confidental ISSUE 1 Copyright 2009 NOKIA All rihts reserved 6260 Slide RM 368 Service Manual Level 1 amp 2 We ma 7 Unscrew the two Torx 4 screws in the order 8 Turn the phone over and slide it open Then shown unscrew these two Torx 4 screws in the order shown 9 Use the SRT 6 to open the two clips of the A COVER 10 The A COVER ASSY can now be removed ASSY Slide the SRT 6 along the cover edge Do the Remember to protect the LCD with protective film Same on the opposite side 11 Lift up the LCD with the SS 93 12 To dee gue LCD flex first open hl q mechanism of the connector with the SS 93 Then pull on the flex with the pliers Be careful not to damage the connector 13 Confidental ISSUE 1 Copyright O 2009 NOKIA All rihts reserved 6260 Slide RM 368 Service Manual Level 1 amp 2 13 Slide the phone open to detach the MAIN KEYMAT 14 Release the six dins on the MAIN KEYMAT with the SRT 6 15 To release the two remaining clips remove the 16 To detach the ANTENNA COVER ASSEMBLY detach KEYMAT in the direction shown the two clips by sliding the SRT 6 along the bottom edge of the cover 17 Remove the ANTENNA COVER ASSEMBLY in the 18 Use the SS 93 to detach the camera button direction shown Pay attention to not to damage the appendix of the assembly 14 Confidental ISSUE 1 Copyright 2009 NOKIA All rihts reserved 6260 Slide RM 368 Service Manual Level 1 a
6. NGE HISTORY Status VersionNo ate Comments Approved version flO 412009 The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to carry out service to NOKIA products This Service Manual is to be used only by authorized NOKIA service suppliers and the content of it is confidential Please note that NOKIA provides also other guidance documents e g Service Bulletins for service suppliers follow these regularly and comply with the given instructions While every endeavor has been made to ensure the accuracy of this document some errors may exist If you find any errors or if you have further suggestions please notify NOKIA using the address below CMO Operation amp Logistics Training and Vendor Development Multimedia Creation amp Support mailto Service Manuals nokia com Please keep in mind also that this documentation is continuously being updated and modified SO watch always out for the newest version 3 Confidental ISSUE 1 Copyright 2009 NOKIA All rihts reserved NOKIA 6260 Slide RM 368 a re Service Manual Level 18 2 2 COPYRIGHT Copyright 2009 Nokia All rights reserved Reproduction transfer distribution or storage of part or all of the contents in this document in any form without the prior written permission of Nokia is prohibited Nokia Nokia Connecting People and Nokia X and Y are trademarks or registered trademarks of Nokia Corporation Other pro
7. duct and company names mentioned herein may be trademarks or tradenames of their respective owners Nokia operates a policy of continuous development Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice Under no circumstances shall Nokia be responsible for any loss of data or income or any special incidental consequential or indirect damages howsoever caused The contents of this document are provided as is Except as required by applicable law no warranties of any kind either express or implied including but not limited to the implied warranties of merchantability and fitness for a particular purpose are made in relation to the accuracy reliability or contents of this document Nokia reserves the right to revise this document or withdraw it at any time without prior notice The availability of particular products may vary by region IMPORTANT This document is intended for use by qualified service personnel only 4 Confidental ISSUE 1 Copyright 2009 NOKIA All rihts reserved NOKIA 6260 Slide RM 368 a re Service Manual Level 1 amp 2 3 WARNINGS AND CAUTIONS Please refer to the phone s user guide for instructions relating to operation care and maintenance including important safety information Note also the following 3 1 Warnings 1 CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND
8. e battery only with the chargers approved by the manufacturer Unplug the charger when not in use Do not leave the battery connected to a charger for longer than a week since overcharging may shorten its lifetime If left unused a fully charged battery will discharge itself over time Temperature extremes can affect the ability of your battery to charge For good operation times with Ni Cd NiMh batteries discharge the battery from time to time by leaving the product switched on until it turns itself off or by using the battery discharge facility of any approved accessory available for the product Do not attempt to discharge the battery by any other means Use the battery only for its intended purpose Never use any charger or battery which is damaged Do not short circuit the battery Accidental short circuiting can occur when a metallic object coin clip or pen causes direct connection of the and terminals of the battery metal strips on the battery for example when you carry a spare battery in your pocket or purse Shortcircuiting the terminals may damage the battery or the connecting object Leaving the battery in hot or cold places such as in a closed car in summer or winter conditions will reduce the capacity and lifetime of the battery Always try to keep the battery between 15 C and 25 C 59 F and 77 F A phone with a hot or cold battery may temporarily not work even when the battery is fully charged Batteries p
9. erformance is particularly limited in temperatures well below freezing Do not dispose batteries in a fire Dispose of batteries according to local regulations e g recycling Do not dispose as household waste 8 Confidental ISSUE 1 Copyright 2009 NOKIA All rihts reserved NOKIA Care T EXPLODED VIEW A1 A COVER ASSEMBLY 10003 10005 m A COVER ASSY 10003 A LCD AM 320x480 COG 10006 A2 SLIDE MODULE 10101 10102 SLIDE MODULE 10101 m SCREW M1 4X2 5 10007 A3 LIGHT SWAP PACKAGE 10203 10206 LIGHT SWAP PWB kk 10205 USD PWB MECH ASSEMBLY 10204 A4 B COVER ASSEMBLY apr 10208 10211 _Avjak 10208 DC JACK 10209 USB PLUG 10211 T SCREW M1 4X3 4 77T 10212 BATTERY COVER 10214 6260 Slide RM 368 Service Manual Level 1 amp 2 3DFS UI BOARD ASSY 10001 SCREW M1 4X2 5 MAIN KEYMAT 10201 gt e MAIN FLEX MECHANICAL ASSEMBLY 10102 2NTC CAMERA FLEX MECH ASSEMBLY 10202 l DOMESHEET ASSEMBLY 10203 TYPE LABEL m MAIN ANTENNA ASSEMBLY 10207 B COVER 10210 ANTENNA COVER ASSEMBLY 10213 ste Only available as These parts can not be assembly reused after removal ISSUE 1 Copyright O 2009 NOKIA All rihts reserved NOKIA Care 8 10 SERVICE DEVICES FLS 5 Flash Device BL 5F Battery CA 101 Service Cable Confidental Copyright 2009 NOKIA All rihts reserved 6260 Slide RM 368 Service Manual Level 1
10. ex connectors carefully through 32 Continue loosening the adhesive until the main the gaps flex can be completely removed END OF DISASSEMBLING 33 The Nokia 6260 SLIDE disassembly is now complete 17 Confidental ISSUE 1 Copyright O 2009 NOKIA All rihts reserved NOKIA 6260 Slide RM 368 Ca re Service Manual Level 1 amp 2 11 ASSEMBLY HINTS ITESO pe aA DAD VA Sen beten 1 After IE the MAIN FLEX slide the connectors 2 After connecting the MICRO SD PWB ASSEMBLY carefully through the gaps connector first attach the two clips 3 Rotate the MICRO SD PWB ASSEMBLY into position 4 When placing the engine board make sure that the and attach the two remaining clips with the SS 93 camera key is not damaged GH E 5 Tighten the screws to the torque of 11Ncm in the 6 When gece the ANTENNA COVER ASSEMBLY first order shown attach the appendix Then press the assembly down to attach the remaining clips 18 Confidental ISSUE 1 Copyright O 2009 NOKIA All rihts reserved 6260 Slide RM 368 Service Manual Level 1 amp 2 e 7 Slide the MAIN KEYMAT into place by first attaching 8 Tighten the two screws to the torque of 14Ncm in the two clips in the corners of the MAIN KEYMAT the order shown Then press the MAIN KEYMAT edges to attach the rest of the clips li MOKIA 9 Tighten the remaining screws to the torque of 14Ncm in the order shown 19 Confidental ISSUE 1 Copyright 2009 NOKIA
11. mp 2 E 3 kb o A aa DI h inie Ja 19 vea the four Torx 4 screws in the order Ze ON release the slide module with the SS 93 shown ANNANS ree eee ath 21 Carefully disconnect the MAIN FLEX from the E 22 petad Ge gees clips of the B COVER ASSEMBLY engine board with the SS 93 The SLIDE MODULE can with the SS 93 and then remove the engine board now be removed I 23 Carefully pull out the USB PLUG 24 Release the AV JACK and the DC JACK with the DC plug and remove them with the tweezers 15 Confidental ISSUE 1 Copyright O 2009 NOKIA All rihts reserved 6260 Slide RM 368 Service Manual Level 1 amp 2 25 Detach the MAIN ANTENNA ASSEMBLY by pressing 26 When opening the CAMERA ASSEMBLY connector it lightly be careful not to damage the nearby components Disconnect the CAMERA ASSEMBLY connector with the SS 93 and then remove the CAMERA ASSEMBLY with the tweezers 3dALOLOYA 21 Detach the DOMESHEET ASSEMBLY with the dental 28 Release the two clips holding the MICRO SD PWB tool ASSEMBLY Lift up the assembly to get access to the connector KI e e kart ue em E Y a Y 29 Open MICRO SD PWB ASSEMBLY connector and 30 Carefully loosen up the adhesive on the MAIN FLEX remove the assembly with the SS 93 as shown 16 Confidental ISSUE 1 Copyright 2009 NOKIA All rihts reserved 6260 Slide RM 368 Service Manual Level 1 amp 2 31 Then pull the fl
12. reas Its moving parts can be damaged o Do not store the phone in hot areas High temperatures can shorten the life of electronic devices damage batteries and warp or melt certain plastics e Do not store the phone in cold areas When it warms up to its normal temperature moisture can form inside which may damage electronic circuit boards e Do not drop knock or shake the phone Rough handling can break internal circuit boards e Do not use harsh chemicals cleaning solvents or strong detergents to clean the phone Do not paint the phone Paint can clog the moving parts and prevent proper Operation a Use only the supplied or an approved replacement antenna Unauthorised antennas modifications or attachments could damage the phone and may violate regulations governing radio devices All of the above suggestions apply equally to the product battery charger or any accessory 1 Confidental ISSUE 1 Copyright O 2009 NOKIA All rihts reserved NOKIA 6260 Slide RM 368 a re Service Manual Level 1 amp 2 6 BATTERY INFORMATION Note A new battery s full performance is achieved only after two or three complete charge and discharge cycles The battery can be charged and discharged hundreds of times but it will eventually wear out When the operating time talk time and standby time is noticeably shorter than normal it is time to buy a new battery Use only batteries approved by the phone manufacturer and recharge th
13. vers are removed must be handled with ESD protection The SIM card can be replaced without ESD protection if the product is otherwise ready for use To replace the covers ESD protection must be applied All electronic parts of the product are susceptible to ESD Resistors too can be damaged by static electricity discharge All ESD sensitive parts must be packed in metallized protective bags during shipping and handling outside any ESD Protected Area EPA Every repair action involving opening the product or handling the product components must be done under ESD protection ESD protected spare part packages MUST NOT be opened closed out of an ESD Protected Area For more information and local requirements about ESD protection and ESD Protected Area contact your local Nokia After Market Services representative Confidental ISSUE 1 Copyright 2009 NOKIA All rihts reserved NOKIA 6260 Slide RM 368 a re Service Manual Level 18 2 5 CARE AND MAINTENANCE This product is of superior design and craftsmanship and should be treated with care The suggestions below will help you to fulfil any warranty obligations and to enjoy this product for many years o Keep the phone and all its parts and accessories out of the reach of small children e Keep the phone dry Precipitation humidity and all types of liquids or moisture can contain minerals that will corrode electronic circuits o Do not use or store the phone in dusty dirty a
Download Pdf Manuals
Related Search