Owners Manual
Contents
1. SR SUNTOUR OWNERS MANUAL Table Of Contents Quick Start Guide ccccscscsssccceees 2 1 How do I turn the system on 2 2 Support modes esesesssseseseeeeseeees 2 Factors that influence the cruising PN OG ad eee anra 2 3 What information does the system Oer YOU saaa 3 Information MOde sssssssseessseesssessssesss 3 4 How do I remove the display A a eer ene fe ere eer 3 5 How do I charge the battery 4 Upright standing battery type rear Seat TUDO eniai 4 Flat battery type carrier 4 6 How to reset the trip distance 5 7 Error Code 05 E05 wu esessssssesseseees 5 Important Safety Information 6 Before Each Ridel ccsccsssssssccees 7 FOPE WOM sssisssisosisansossnasissuasosisossronasssa 8 Display User Interface ccccceee 10 How to remove the display 10 How to operate the display user INTORTACE sosisini andaan 11 General Information cccseseseeeees 11 How to switch ON OFF cecscseee 12 Headlamp control ceesscssscseseseees 12 Push up support switch c8 13 How to change the Assist Mode 13 Range Influencing Factors 14 How to change the Information ModesS ssesssessseesseesseesseesssessseesseesseesseesss 14 How to reset the trip distance 15 How to reset the trip time total time s sssesseesssesseesseesssesssesssesssess 15 HESC components SEE a E A mumsnet2. flat type battery integrated into rear carrier SR SUNTOUR OWNERS MANUAL Q Always keep in mind gt Recharge the battery before each journey always recharge if it hasn t been used for at least one month Li ion batteries cannot be charged at temperatures over 59 C 138 F or under 2 C 28 F Do not recharge your battery in direct sunlight or within a very hot environment Avoid any contact with water or moisture when recharging your battery If a plug or socket does get wet dry it thoroughly before proceeding Be sure to keep pets and small children away from the area where you are recharging If you notice a strange smell or smoke switch off the Power Socket instantly Take your battery and charger to your authorized dealer for service or replacement Do not recharge the battery continuously for more than 24 hours This could seriously reduce the life of the battery Keep the area where the battery is charged well ventilated Keep it free from litter and anything combustible to avoid fire from sparks or overheating Use only genuine SRSUNTOUR Batteries and Chargers with your bike anything else invali dates your warranty and may cause irreparable harm Do not throw the battery into a fire Do not charge the battery with other chargers then the one which has been delivered with your ebike pedelec Never try to charge other batteries with the delivered charger Do not disassemble or modify the bat
3. How to disassemble the front wheel To remove the front wheel off your bike please follow the steps indicated below WARNING Remove the battery from the bike before opening any cable connec tion and before removing the front wheel 1 Remove the cable guide using a 4mm Allen 3 Unfasten the nuts using a 19mm flat wrench key Le E i 5 T i N 3 W i TAY l i 2 Unplug the cord SR SUNTOUR OWNERS MANUAL HESC components How to re assemble the front wheel Limited Warranty SR SUNTOUR warrants its pedelec drive unit to be free from defects in material and workman ship under normal use for a period of two years from the date of original purchase Excluded from this warranty is the Li lon Battery The battery warranty is 1 year This warranty is made by SR SUNTOUR Inc only with the original purchaser and is not transferable to any third party Lodging a claim under this warranty must be made through the dealer where the bicycle equipped with the drive unit was purchased To prove the original purchase the original retail invoice has to be provided LOCAL LAW This warranty gives you specific legal rights According to the state USA or province Canada or any other country you are living in you may have other rights than explained within these warranty regulations These regulations shall be insofar adapted to the local law to be con sistent with such law LIMITATION OF WARRANTY This limited warran
4. edge and tools are essential to install service and maintain SR SUNTOUR drive units for electric bicycles Common mechanical knowledge may not be sufficient to repair service or maintain the devices Therefore we strongly recommend getting your system serviced and or maintained by a trained and qualified bicycle mechanic Improper installation service or maintenance can result in failure of the product accident injury or even death gt Always be equipped with proper safety gear This includes a properly fitted and fastened helmet Make sure your equipment is in flawless condition gt Make sure to learn about the electric power assistance the changed bicycle behaviour and handling of your bike Learn how to ride and train your skills Know your limits and never ride beyond those gt The torque sensor of your HESC system even detects slight pressure on the pedal If the torque sensor detects and pressure on the pedal it will give the motor the instruction to start running Therefore you should always slightly pull your front brake lever towards the handlebar while standing waiting e g in front of a traffic light with your foot placed on the pedal You brake lever is equipped with a cut of sensor which will avoid the motor to start running unexpectedly gt Never lock your front wheel while the system is active as the motor might get damaged Besides this it could result into a short circuit which might set the system on fire gt
5. Always make sure to fold center stand while moving the bike backwards Before Each Ride Do not ride your bike if one of the following test criteria can t be passed Riding your bike without eliminating any defect or carrying out the neces sary adjustments can result into an accident fatal injury or even death gt Do you notice any cracks dents bent or gt Can you notice any oil leaking out your tarnished parts at your suspension fork fork Also check out hidden areas like or any other part of your bicycle If so the bottom side of your fork crown If please consult a trained and qualified so please consult a trained and qualified bicycle mechanic to check your fork or bicycle mechanic to check your fork or bike bike or SUNTOUR SR SUNTOUR OWNERS MANUAL gt Compress your fork with your body weight If it feels too soft relating to the proper pressure to achieve an accurate SAG inflate it until you have reached the required value Please also refer to chap ter SETTING SAG Make sure your brakes are properly in stalled adjusted and work appropriate This also applies to every other part of your bike like handlebars pedals crank arms seat post saddle etc Also refer to the owner s manuals provided by all HESC components If you are using a quick release system to fasten your wheel set make sure that all levers and nuts are adjusted properly In case you are using a through axle sys tem m
6. SR SUNTOUR OWNERS MANUAL HESC components 26 0000 100 149 A A JOIO 300 349 A JOIOIO 150 199 00000 350 399 OOO 200 249 00000 400 449 X 1 JOIO 250 299 000o 450 499 Ono light light Oblinking Error Codes EMRS Your SR Suntour HESC ebike pedelec system is equipped with an automatic error message report system EMRS This system has been developed to provide you with immediate and effective feedback in case your system detected a major problem This system has to be seen as first aid help tool please always visit Maintenance and cleaning Cleaning If your bike or any component of the electric bike unit is dirty be sure to remove the battery before cleaning the bike Clean it with a soft damp cloth and neutral cleaner or a solution of dishwasing detergent and water Never use a high pressure cleaner Never bring the battery into direct contact with water If the battery needs to get cleaned use a moistly sponge or similar to clean it Never use industrial solvents or aggresive chemicals for cleaning Before inserting the battery make sure to dry the contacts of the lower battery holder and battery WARNING When the battery gets in contact with more water than it gets during common rain or snowfall there is a danger of explosion or SUNTOUR SR SUNTOUR OWNERS MANUAL HESC components
7. a Oo Factors that influence the cruising range The points stated below can influence the cruising range gt Driver characteristics amp driver concentration gt State of maintenance gt Topography ori SUNTOUR SR SUNTOUR OWNERS MANUAL HESC components gt Average speed vs variation of speed gt Traffic conditions gt Type and condition of tires amp tire pressure gt Driver weight gt Direction of wind amp wind speed gt Battery temperature while charging the lower the better gt Battery operating temperature while not in use the higher the better gt Ambient temperature while driving the higher the better gt Battery age the newer the better amp battery charge cycle gt Battery state of charge gt Battery storage cold and dry storage is recommended 3 What information does the system offer you Information mode Information about total kilometers trip distance travel time maximum speed and average speed is displayed in succession when you push the info I button 4 How do I remove the display unit 5 How do I charge the battery Both battery types shown below can be charged in the installed position and don t need to be disassembled For more information about charging the battery please read the chapter on charging the battery Upright standing battery type rear seat tube le battery is not getting charged p
8. display onto the docking station or SUNTOUR SR SUNTOUR OWNERS MANUAL HESC components To protect the pins of your docking station against moisture and dirt it is is equipped with a cover which can be slid over the pins Always cover the pins after you take off the display e Always close the cover after removing the display Do never expose the pins to any kind of metal like tools coins or hairpins This could result into a short circuit and might cause permanent damage As a result of this massive heat might build up this could result into a burning of the display unit More over you might expose yourself to an electric shock e Make sure to turn off the display before removing it e Removing the display before turning off may result into a failure of the system The display will save all data like trip distance and average speed on a flash memory Removing the display before it has been turned off may result in a loss of stored data Never expose the display to any kind of static electricity or strong radio waves as it might erase all data on your display How to operate the display user interface General Information The user interface display is located on the handlebar When the system is switched on by using the on off switch you can choose among the options below or SUNTOUR 11 SR SUNTOUR OWNERS MANUAL HESC components always displayed Battery capacity Motor status Speed displayed rotational whe
9. please refer to owner s manual of the manufacturer s bike Before each ride especially during dawn and darkness please always check the proper function of your light system ESr SUNTOUR 12 SR SUNTOUR OWNERS MANUAL HESC components Push up support switch Your HESC equiped ebike Pedelec features a so called push up support switch which helps you starting up on gradients while waiting in front of the traffic lights etc The push up knob supports you until 4 5km h beyond this is will be cut off automatically Please note When using the push up support switch always hold your handelbar with both hands How to change the Assist Mode The user can choose the ratio of assistance depending on his personal wish by pressing the Mode button M on the user interface He can use between 4 different modes No assistance ECO Mode Standard Mode and High Power Mode The percentage of assist power varies from 50 ECO Mode 100 Standard Mode and 150 High Power Mode Aw Aw A QO O me Assist Mode ECO STD HI cruising range EBD belt 66km 48km 40km Bom Smm s SR SUNTOUR OWNERS MANUAL HESC components Range Influencing Factors The riding distance might vary as it is influenced by the following factors Operating Temperature of Battery when not in use higher better Ambient Temperature while riding higher better Battery Age newer better amp Battery charg
10. you with 3 dif ferent indications 1 Remaining capacity press button for 1sec Provides you with information about the re maining capacity of your battery Remaining Capacity LED Indicator Remaining capacity 00000 100 80 0000 79 60 00000 59 40 O00 39 20 O0OO00O 19 10 O00000 9 3 O no light light blinking 2 Absolute capacity Gives information about the total absolute ca pacity of your battery It can also be seen as a indicationtor of battery life Please also refer to the section Long term storage and Battery Charging General Information 1 Push button for 1 sec remaining capacity mode shows up 2 Release button for 1 sec 3 Press button for at least 10 sec Absolute Capacity LED Indicator Absolute capacity OLAI 100 80 O00 79 60 O00000 69 60 1 JOJO 59 50 O ood 49 40 O OQOO 39 30 O Ccdoo0O 29 20 OOOO0O 19 0 nolight light blinking 3 Charge count Provides information about how many times your battery has been charged 1 Push button for 1 sec remaining capacity mode shows up 2 Release button for 1 sec 3 Press button for at least 10 sec absolute capacity mode shows up 4 Release button for 1 sec 5 Press button for at least 10 sec Charge Count LED Indicator QOOOO0OO O0O00 Charge count 0 49 50 99
11. 15 Display INdicatiONS ccccccecees 15 OOS O 15 Total DiStanCe ccssecsssssesesssssseeeeees 15 Trip DISTANCE sscssssscssonsecsesesisnensssusszoreoneocs 15 Trip Time Total Time 16 Max SPCC cessssssssesscssssseeessssseeseseers 16 Average SPC cesesesessesesesessseeeeseees 16 MOTON ASSIST ocasecsevcesatececsdstectscvedtsseesesteves 16 Remaining capacity fuel gauge 16 Battery General information 17 Always keep in mind uu cesses 19 Battery Charging sssesssssssssccesssssso 20 General Information cseseeeee 20 Upright type battery ssssscssssssssee 21 Charging status csscsesecssseeeeesees 22 Battery indication s ssessseesseesseesseees 22 Flat type batterry ccccccccceoees 23 Charging Status uu esesseseseseeeseseeees 24 Battery indication 25 Error COGES soninn 26 Maintenance and cleaning 26 EEEa a AE E 26 How to disassemble the front WAGEN irena e N 27 How to re assemble the front AWE Gl E E E 28 Limited Warranty cccccccccccees 28 SR SUNTOUR OWNERS MANUAL HESC components Quick Start Guide 1 How do I turn the system on Press the modus M key for about 2 seconds The system turns on and shows you all of the important information about the current status 2 Support modes Assist Mode ECO STD HI cruising range EBD belt 66km 48km 40km Dom Brom Bso QE OE Oe G9 gt
12. YY YYYY YY YYYY h ori SUNTOUR SR SUNTOUR OWNERS MANUAL Upright type battery Your bike is delivered together with a charger Please only use this charger don t try to com bine with other devices Please note The battery needs an initial full charge before the first use of the bike and after To charge the battery please follow these steps 1 Switch off the system by pressing the MODE button LY C gt 3 COM sto m NO AS Eco OE Total km UU Total time sel MAX SPD km h 2B eS im eS i S gt 8 2 Unplug the battery from its docking station Please note You can also charge the battery if it is plugged onto the docking station while mounted onto the bike HESC components every use regardless of the remaining capacity of the battery The battery doesn t need to be empty before charging it One full charge takes up to 4 0 4 5hours de pending on the condition of battery 3 Open the cover which protects the socket 4 Plug the charger cable in SR SUNTOUR OWNERS MANUAL 5 Plug charger into power outlet 6 The status indication should now shine red ready for use 7 During the charging process the status indication will turn to orange 22 HESC components Charging status battery is not getting charged pleas
13. ake sure that all fixing bolts are tightened with the appropriate torque values Check the cable length and routing of your components Make sure they do not interfere your steering actions If you are using reflectors for on road cycling make sure they are clean and other component manufacturers properly installed gt Make sure your wheels are centered per fectly in order to avoid any contact with your suspension fork or brake system gt Bounce your bike slightly on the ground while looking and listening for anything which might be loose Foreword Dear customer congratulations on your new electric bicycle purchase The bike is equipped with the SR SUNTOUR HESC drive unit with a rechargeable Lithium lon battery a display and user interface a torque sensor a controller and a brushless front hub motor To make your ride smooth safe and fun please take some time to read this manual carefully It contains information on the proper care of the drive unit of your electric bicycle and advice on how to achieve the bikes and batteries full lifespan In case of any enquiries not covered by this manual please contact your local dealer Enjoy the ride What is a Pedelec It is legally considered a conventional bicycle where the rider is enjoying some electrical power assistance based on the human power brought up by the rider Just ride like ona conventional bike the system will add some extra power It feels
14. and protects the system from over loading Your system is equipped with a torque sensor After pressing the pedal the sensor measures the force used and sends the measurement to the controller In order to offer you a balanced and natural ride the sensor is very finely adjusted There are several points to keep in mind so that problem free operation may be ensured Turn on the system before placing your foot on the pedal If you depress the pedal before turning on the system the controller may interpret this as a system overload and report this as error 05 Solution Turn off the system and release the pedal Afterwards turn the system back on remove your foot from the pedal If error 05 still appears contact your retailer During driving operation The front brake lever is equipped with a disruption sensor When you pull the brake lever a signal is sent to the controller The controller subsequently disrupts the current supply to the motor and tells the torque sensor that no measurements are necessary In order to avoid an error 05 you should always make sure to pull the front brake lever i e while waiting at a red light This way the system always knows that no assistance is necessary at that moment or SINTOLR SR SUNTOUR OWNERS MANUAL HESC components Important Safety Information WARNING Failure to comply with the given warnings and instructions may cause damage to the product injur
15. arrier of your bike Li ION batteries are very user friendly however to assure a long battery life there are some points to adhered to Maximum Range e Charge the battery at room temperature 0 C to 40 C 32 F to 104 F e Discharge the battery as much as possible before recharging it e Chose a lower gear while uphill riding e Always make sure your tires are inflated with the prober value Battery Life e Min 300 500 charging cycles e If battery indication gives information that the battery is fully charged but the distance you are able to ride does vary from the information given in this manual your batteries life may have come to an end In this case please contact your local SR Suntour HESC dealer for further investigations Long term storage If you are not going to use your battery for a long term period there are some points to follow Otherwise your battery might get damaged which will affect the batteries life e Remove the battery from the bike to avoid natural discharging Do not store the battery fully charged approx 40 is recommended or SINTOLR 17 SR SUNTOUR OWNERS MANUAL HESC components e Recommended storage temperature 20 C to 35 C 4 F to 95 F e As a battery discharges during a certain periode of time we recommend to recharge the battery every 3 month up to 40 of full capacity e Only store battery in a dark room upright type battery located behind seat tube
16. co stp HI Total km BEEBE Total time Wheel MAX SPD km h HESC components 3 Charge count press button for 10 sec Provides information about how many times your battery has been charged LED Indicator Charge count 0000 0 99 00o 100 189 A JOIO 190 269 OO00O 270 349 OOOO 350 nolight light blinking every use regardless of the remaining capacity of the battery The battery doesn t need to be empty before charging it One full charge takes up to 4 0 4 5hours de pending on the condition of battery 2 Take the battery out of the rear carrier For more detailed information please refer to your rear carrier manufacturers manual 3 Open the cover which protects the 4 Plug the charger cable in socket it is located at the left end of the battery Please note You can also charge the battery if it is plugged onto the docking station while mounted onto the bike 5 Plug charger into power outlet 6 Status LED should now shine red Charging status battery is getting charged battery is fully charged battery is not getting charged please check all connections failure battery unplug and try again OJ failure chager unplug and try again out of operating temperature range Battery indication CAPACITY CHECK en E oe ee UT Your flat type battery provides
17. cycling com SR SUNTOUR NORTH AMERICA SR SUNTOUR NORTH AMERICA INC 14511 NE 10th Avenue Unit E Vancouver Washington 98685 USA Tel 1 360 737 6450 email service srsuntourna com
18. e check all connections battery is getting charged battery is fully charged Battery indication Li ion INTELLIGENT BATTERY SYSTEM Your upright type battery provides you with 3 different indications 1 Remaining capacity press button for 1sec Provides you with information about the re maining capacity of your battery LED Indicator Remaining capacity 0000 100 75 000 75 50 A JOIO 50 25 OO0O 25 10 OOOO 10 0 OOOO Over Temperature nolight light blinking SR SUNTOUR OWNERS MANUAL 2 Absolute capacity press button for 6 sec Gives information about the total absolute ca pacity of your battery It can also be seen as a indicator of battery life Please also refer to the section Long term storage and Battery Charging General Information LED Indicator Absolute capacity 000o 100 80 A JOIO 79 70 000 69 60 OOOO 59 0 nolight light blinking Flat type battery Your bike is delivered together with a charger Please only use this charger don t try to com bine with other devices Please note The battery needs an initial full charge before the first use of the bike and after To charge the battery please follow these steps 1 Switch off the system by pressing the MODE button TTT No as
19. e cycles number of time charged Battery Condition state of charge Battery Storage Cool dry place recommended Driver ability amp Driver concentration Condition repair state Topography Speed Average Speed Variability Traffic conditions Tire style Tire condition amp Tire Pressure Weight of rider Wind direction amp Wind speed VvvVvvvvvvvvvVvVv VW Y How to change the Information Modes The ride information total distance trip distance trip time maximum speed and average speed are shown one after another when pressing the Information Button I Av oe 2 Aus SS l CON l rae total trip frip SWS distance distance time average max speed speed 14 SR SUNTOUR OWNERS MANUAL HESC components How to reset the trip distance 1 Switch to trip distance 2 Press the Mode button that followed press the Info button Afterwards release both buttons the buttons should not remain pressed How to reset the trip time total time 1 Switch to trip time 2 Press the Mode button that followed press the Info button Afterwards release both buttons the buttons should not remain pressed How to reset the maximum speed 1 Switch to maximum speed 2 Press the Mode button that followed press the Info button Afterwards release both buttons the buttons should not remain pressed Display Indications Speed The sp
20. eed is shown in kilometres per hour Display speed range 0 0 60 0km h 28inch Display accuracy 0 1km h The system needs approx 2 5seconds to recognize the speed of the wheel Total Distance The total distance is counted when the system is activated and is displayed in kilometres km h Numerical values will get stored on the non volatile memory Value can not be reset manually Trip Distance The trip distance is counting when the system is activated and the front wheel is turning Display range 0 0 999 9km Display accuracy 0 1km The trip distance can be reset please refer to How to reset the trip distance or SINTOLR m 16 SR SUNTOUR OWNERS MANUAL HESC components Trip Time Total Time The trip time total time is recorded when the system is turned on and the wheel is running Display range 00 00 99 59 hh mm 1 unit 1 minute The trip distance can be reset please refer to How to reset the trip time Max Speed The max speed indicates the maximal ever ridden speed Display range 0 0 60 0km h Display accuracy 0 1km h The trip distance can be reset please refer to How to reset the maximum speed Average Speed The average speed indicates the average ridden speed and is calculted through the following formular trip distance trip time Please note If the tr
21. ies or even death to the rider and user gt Be sure to read this manual carefully before using your electric bicycle Inappropriate usage of your electric bicycle may cause damage to the product serious injuries or even death to the rider gt Do not use damaged components consult your authorised SR SUNTOUR dealer imme diately gt The battery of the electric bicycle contains chemicals which can be dangerous when used improperly warnings included in this manual must be followed in order to reduce the possibility of dangerous situations resulting in injuries or possible death Never try to open any SR SUNTOUR device of the electric bicycle especially not the battery Opening any SR SUNTOUR battery implies the risk of getting seriously injured gt Do not let the battery come into contact with water or any other liquid other than rain or snowfall The guarantee will be void if the battery gets in contact with water Whenever the battery gets in contact with liquid immediately disconnect it to prevent dangerous situations gt Do not store the battery above room temperature The battery life expectancy will be significantly reduced if the battery is stored under higher temperatures gt Do not place the battery immediately close to a flame or any other heat source Extreme heat can cause the battery to explode Keep the area where the battery is charged well ventilated Keep it free from litter and anything combustible to avoid fi
22. ip time is 0 the average speed cannot be displayed Display accuracy 0 1km h Motor assist The motor status indicates the current assist power according to the chosen mode The motor status will not be indicated beyond a speed of 26km h Remaining capacity fuel gauge Please note that the indication of the remaining capacity of the battery is getting update while the motor is inactive The indication of the remaining capacity of the battery will provide you with precise informa tion regarding the remaining power However this indication might get influenced by various different outside factors To avoid any problems please immediately recharge your battery after the indication starts blinking When the main switch is turned on the battery fuel gauge shows up The remaining battery capacity is is represented by illustration as follows Remaining capacity Remaining capacity CL C 100 75 75 50 Remaining capacity Remaining capacity gt m _ 50 25 25 10 ori SUNTOUR SR SUNTOUR OWNERS MANUAL HESC components Blinking 2 times per second Blinking 8 times per second Remaining capacity Remaining capacity C A 10 0 0 Battery General information Our HESC system is equipped with a Li ION type battery There are two possible types of batteries your bike is being delivered with 1 Upright type battery which is located behind the seat tube of your bike 2 flat type battery which is located within the rear c
23. lease check all connections battery is getting charged battery is fully charged 1 Open the cover of the charging socket 2 Connect the battery with the battery charger 3 Connect the battery to the power supply Next turn on the battery charger The status indicator should light up red if not check the connection Flat battery type carrier Battery is charging Battery is fully charged Battery isn t charg ing please check all connections Q Error re connect 1 Open the cover of the charging socket Error with battery charger re connect Q Above charging Next turn on the battery charger temperature 2 Connect the battery with the battery charger 3 Connect the battery to the power supply The status indicator should light up red if not check the connection SR SUNTOUR OWNERS MANUAL HESC components 6 How to reset the trip distance 1 Change the display to trip distance 2 First press the mode button and then the info button Afterwards release the buttons but tons are not allowed to remain pressed down Please note When resetting the trip distance the travel time will also automatically be reset In order to reset the maximum speed change the display to max speed and do as stated in the instructions above 7 Error Code 05 E05 Error report 05 should be interpreted as a security measure
24. like having tailwind or a continuous descending ride In European Countries the assistance is legally limited to 250W nominal power and a max speed of 25km h Riding faster than that is possible but there will be no assistance when or SUNTOUR SR SUNTOUR OWNERS MANUAL HESC components riding faster than 25km h A Pedelec is sometimes called EPAC Light Electric Vehicle LEV Hybrid Bicycle or eBike or electric bicycle with Pedal Assisted System PAS The below stated graphic gives you a better understanding how all HESC com ponents interact with each other Display the cockpit N ab ab QO ab L WY OO ab N sends receives request instructions the fuel tank Motor Controller the brain feedback the engine energy O Ez T O q Sensor Crankset the tansmitter ori SINTOLR SR SUNTOUR OWNERS MANUAL HESC components Display User Interface Speed Battery Capacity Motor Assist Assist Mode Ae sw CG Total km mea Total time Wheel MAX SPD km h Data correspond ing to the informa tion mode ON OFF Button Info Button Mode Button How to remove the display To remove the display off the docking station carry out the steps like indicated above To install the display onto the docking station slide the
25. n pressing MODE button Assist Mode displayed rotational when pressing INFO button Total distance Trip distance Trip time Max speed Average speed The system will switch off automatically after 10 minutes of inactivity During the first setup of the bike the wheel size have to be set on this user interface please refer to the chapter how to set wheel size The display is connected to the conntroller brain the cut off sensor and the push up support switch The power cut off sensor will automatically cut of the power supplied to the motor when pull ing the brake lever The cut off sensor is connected to the front brake Always use booth brakes when braking How to switch ON OFF To turn ON OFF the display user interface press the MODE button for at least 3 seconds The display will automatically switch off after 10 minutes if non of the below stated operations are carried out Pushing the Mode Button Pushing push up support switch Applying pressure on the pedal o AS Eco HBB BE toma Wheel MAX SPD k Headlamp control The controller of the SR Suntour HESC pedelec ebike system is equipped with a power supply mechanism which will automatically supply power to the the light system of our bike if the system is turn on As this is not a standard feature it might not being used on every pedelec or ebike which is equipped with SR Suntour HESC components
26. our authorized dealer for service or replacement gt Do not recharge the battery continuously for more than 24 hours This could seriously reduce the life of the battery gt Keep the area where the battery is charged well ventilated Keep it free from litter and anything combustible to avoid fire from sparks or overheating gt Use only genuine SRSUNTOUR Batteries and Chargers with your bike anything else invali dates your warranty and may cause irreparable harm Battery Charging General Information To charge your battery please follow the steps stated below Before you start charging your battery we would like to make you aware of some factors which might influence charging process and range of your battery M Temperature of Battery while charging lower better Operating Temperature of Battery when not in use higher better Ambient Temperature while riding higher better Battery Age newer better amp Battery charge cycles number of time charged Battery Condition state of charge Battery Storage Cool dry place recommended Driver ability amp Driver concentration inadvertently braking with the throttle open Condition repair state a well serviced SR SUNTOUR improves range Topography Speed Average Speed Variability Traffic conditions including vehicles pedestrians and cyclists traffic lights etc Tire condition amp Tire Pressure Weight of rider Wind direction amp Wind speed Y
27. re from sparks or overheating gt The battery must only be charged with the supplied charger Using a different charger can result in malfunction and reduced lifecycle of the battery gt Charge the Li ion battery indoors at a temperature between 0 C to 40 C 32 F 104 F The Li ion battery charger cannot charge a battery with a temperature above 60 C or less than 3 C gt If you notice a strange smell or smoke un plug the charger immediately from the power socket and disconnect the battery from the charger Take your battery and charger to your authorized dealer for service or replacement gt Disconnect the charger when the battery is fully charged gt Use only genuine SR SUNTOUR parts The use of non designated aftermarket accessories replacement and spare parts voids the warranty of the electric bike drive unit and might cause failure to the system 5 or SUNTOUR SR SUNTOUR OWNERS MANUAL HESC components gt Do not disassemble or modify any of the parts of the drive unit The warranty will be void in case of any modification gt SR Suntour electric bike units are designed for the usage on single seated bicycles for regular and common use on regular city and trekking bikes The intended use of the drive unit is accordingly gt This instruction sheet contains important information about the correct installation service and maintenance of your drive unit Nevertheless please be informed that special knowl
28. tery or charger Do not connect positive and negative terminals by using metallic objects be especially careful when inserting any key to ensure that it is not accidentally inserted into the charger socket on any battery Do not submerge the battery or charger Soaking either in water may cause irreparable damage Always make sure that all electronic contacts are free of moisture grease oil or any other kind of fulid Do not subject the battery or charger to shocks e g by dropping Do not touch the charger with your skin for long periods during charging Burning of the skin may result Do not cover the charger or place objects on it Place the charger firmly on a flat surface Using the charger upside down or stretching the Recharge the battery before each journey always recharge if it hasn t been used for at least one month Li ion batteries cannot be charged at temperatures over 59 C 138 F or under 2 C 28 F Do not recharge your battery in direct sunlight or within a very hot environment or SUNTOUR HESC components 19 SR SUNTOUR OWNERS MANUAL HESC components gt Avoid any contact with water or moisture when recharging your battery If a plug or socket does get wet dry it thoroughly before proceeding Pm Be sure to keep pets and small children away from the area where you are recharging gt If you notice a strange smell or smoke switch off the Power Socket instantly Take your battery and charger to y
29. ty does not apply to any defect of the component caused by improper installation disassembling and re assembling intentional breakage alterations or modification to the component any unreasonable use or abuse of the product or any use for which this product was not intended for accidents crashes improper maintenance repairs improperly performed The obligation of this Limited Warranty is restricted to repairs and replacements of the com ponents or any parts of it in which there is a defect in materials or workman ship within a period of two years SR SUNTOUR makes no express or implied warranties of fitness or merchantability of any kind except as set forth above Under no circumstances will SR SUNTOUR be liable for incidental or consequential damages Damages which are caused by the use of other manufacturer s replacements parts or dam ages which are caused by the use of parts that are not compatible or suitable to SR SUNTOUR drive units are not covered by this warranty This warranty does not apply to normal wear and tear or SUNTOUR 28 www srsuntour cycling com SR SUNTOUR HEADQUARTER SR SUNTOUR INC 7 Hsing Yeh Rd Fu Hsing Industrial Zone Chang Hua Taiwan R O C Tel 886 4 769115 Fax 886 4 7694028 email orders srsuntour com tw SR SUNTOUR EUROPE SR SUNTOUR EUROPE GMBH Am Marschallfeld 6a 83626 Valley Germany Tel 49 8024 473 990 Fax 49 8024 4730984 email hesc srsuntour
Download Pdf Manuals
Related Search