AZ Patio Heaters HLDS032-GTTSS Instructions / Assembly
Contents
1. a 36 in 91 cm WALL Place the heater on a strong and stable table Never operate the heater in an explosive atmosphere like in areas where gasoline or other flammable liquids or vapors are stored Make a soap solution of one part liquid detergent and one part water The soap solution can be applied to hoses and connections with a spray bottle brush or rag Make sure that the safety control valve is in the OFF position Turn the cylinder valve ON and check for soap bubbles forming on and around connections and hoses If bubbles appear there is a leak present If a leak is present remove the gas cylinder immediately tighten any leaking fittings replace the gas cylinder and recheck Procedure for Leakage Test D OI WN J Perodically check the whole gas system for leaks Immediately check for leaks if an odor of gas is detected Extinguish all open flames during testing or when an odor of gas is detected Never smoke while performing the leak test If you cannot stop a leak unscrew and remove the cylinder from the heater Check the heater with a full propane cylinder DO NOT use the heater until you have performed a leak test on all the connections and verified that your unit does not leak Use only manufacturer recommended replacement parts Substitution may void the warranty OPERATION INSTRUCTIONS A DANGER CARBON MONOXIDE HAZARD For outdoor us2. Guard E Line up threads on gas cylinder with those on the regulator Insert and rotate cylinder Rotate regulator toward opening in housing clockwise until tight and Fixing Bracket BB Ensure all packaging Tube F must be removed To remove the materials are removed 2 Keep the front panel open ASSEMBLY INSTRUCTIONS 3 Gas Tank Assembly The propane gas and cylinder are sold separately Use a standard 1 02 Ib 0 46 kg propane cylinder only Store the appliance indoors only if the cylinder is disconnected and removed from the appliance A cylinder must be stored outdoors in a well ventilated area out of the reach of children A disconnected cylinder must have dust caps tightly installed and must not be stored in a building garage or any other enclosed area orientation to provide vapor withdrawal Standard 1 02 Ib 0 46 kg tank Use the pressure regulator supplied with the appliance The installation must conform with local codes or in the absence of local codes with National Fuel Gas Code ANS Z223 1 NFPA54 Natural Gas and Propane Installation Code CSA B149 1 or Propane Storage and Handling Code B149 2 Certain materials or items when stored under the heater will be subjected to radiant heat and could be seriously damaged Use only a cylinder marked propane A dented rusted or damaged propane cylinder may be hazardous and should be checked by your cylinder supplier Never use a propane cylinder
3. and fittings for leaks using soapy water Never use a flame Use as a heating appliance only Never alter in any way or use with any device A CAUTION CAUTION indicates an imminently hazardous situation which if not avoided may result in minor or moderate personal injury or property damage PREPARATION A WARNING This product is fueled by propane gas Propane gas is Invisible odorless and flammable An odorant is normally added to help detect leaks and can be described as a rotten egg smell The odorant can fade over time so leaking gas is not always detectable by smell alone Propane gas is heavier than air and leaking propane will sink to the lowest level possible It can ignite by ignition sources including matches lighters sparks or open flames of any kind many feet away from the original leak Use only propane gas set up for vapor withdrawal Store or use propane gas in compliance with local ordinances and codes or with ANS NFPA 58 Turn off propane when not in use A WARNING Alert children and adults to the hazards of high surface temperatures Stay away from these surfaces to avoid burning skin or igniting clothing Carefully supervise young children when in the vicinity of the heater Do not hang clothing or any other flammable materials from the heater or place on or near the heater Replace any guard or protective device removed for servicing the appliance prior to placing back i
4. gasoline or other flammable liquids or vapors 10 Heater is away from windows air intake openings sprinklers and other water sources 11 Heater is at least 24 in 61 cm on top and at least 36 in 91 cm on sides from combustible materials 12 Heater is on a hard and level surface 13 There are no signs of spider or insect nests 14 All burner passages are clear 15 All air circulation passages are clear 16 Children and adults should be alerted to the hazards of high surface temperatures and should Stay away to avoid burns or clothing ignition 17 Young children should be carefully supervised when they are in the area of the heater 18 Clothing or other protective material should not be hung from the heater or placed on or near the heater 19 Any guard or other protective device removed for servicing the heater must be replaced prior to operating the heater 20 Installation and repair should be done by a qualified service person The heater should be inspected before use and at least annually by a qualified service person 21 More frequent cleaning may be required as necessary It is imperative that control compartment burner and circulating air passageways of the heater be kept clean After Operation 1 Gas control is in OFF position 2 Gas Tank valve is OFF 3 Disconnect Gas line CARE AND MAINTENANCE A WARNING FOR YOUR SAFETY e Do NOT touch or move heater for at least 45 minutes after use e Reflector i
5. must be lit before main burner can be started 1 Turn the control Knob to the OFF position 2 Fully open LP cylinder valve 3 Push control knob in and rotate to pilot position Figure 1 Note For initial start or after any cylinder change hold control knob in for 2 minutes to purge air from gas lines before proceeding Variable Igniter control knob Figure 1 Figure 2 10 OPERATION INSTRUCTIONS 4 Push and release the igniter button until pilot flame is visible through the glass tube 5 Once the pilot is lit continue to depress the control knob for 30 seconds 6 If the pilot does not stay lit repeat steps 4 to 6 7 If after repeating steps 4 to 6 unit does not light then Push in control knob and turn counterclockwise to PILOT Figure 3 As you are depressing the control knob place long stem lighter Variable Igniter through the glass tube to light the pilot Figure 4 SONORO Repeat step 6 Figure 3 Figure 4 Figure 5 8 Push in and turn the control knob to the HIGH then release control knob If you want a lower temperature push in the control knob and turn counterclockwise to the Lo Figure 5 Note If pilot
6. recommended by the instructions CO during the combustion process This product is Provide adequate clearances around air openings designed to produce extremely minute non hazardous into the combustion chamber amounts of CO if used and maintained in accordance Never use the heater in spaces which do or may with all warnings and instructions Do not block air contain volatile or airborne combustibles or products flow into or out of the heater such as gasoline solvents paint thinner dust particles Carbon Monoxide CO poisoning produces flu like or unknown chemicals symptoms watery eyes headaches dizziness fatigue During operation this product can be a source of and possibly death You can t see it and you can t ignition Keep heater area clear and free from smell it It s an invisible killer If these symptoms are combustible materials gasoline paint thinner cleaning present during operation of this product get fresh air solvents and other flammable vapors and liquids Do immediately not use heater in areas with high dust content For outdoor use only Minimum heater clearances from combustible e Never use inside house or other unventilated or materials 3 ft 91 cm from the sides and 2 ft 61 cm enclosed areas from the top This heater consumes air oxygen Do not use in unventilated or enclosed areas to avoid endangering your life A DANGER amp WARNING e EXPLOSION FIRE HAZARD Never store propane
7. with a damaged valve connection The propane cylinder must be constructed and marked in accordance with the specifications for LP gas cylinders of the U S Department of Transportation DOT or the Standard for Cylinders Spheres and Tubes for Transportation of Dangerous Goods and Commission CAN CSA B339 Includes a listed overfilling prevention device Includes a cylinder connection device compatible with the connection for the appliance The cylinder used must include a collar to protect the cylinder valve Never connect an unregulated propane cylinder to the heater ASSEMBLY INSTRUCTIONS Move the burner control knob to the off position Fix the 1 02 Ib 0 46 kg propane cylinder to the regulator rotate the propane cylinder clockwise toward the regulator connecting until tight Unscrew the switch button load small battery tighten the switch button WARNING This product contains small batteries Swallowed small batteries can cause CHOCKING HAZARD Seek immediate medical attention if batteries are swallowed or inhaled Keep children away from the small batteries Close the door plate Disconnect the cylinder when the appliance is not used Store the appliance indoors only if the cylinder is disconnected and removed from the appliance You may place the appliance in a shelter a With walls on all sides but with no overhead cover b Within a partial enclosure which includes an overhead cover and no more tha
8. Owner s Manual Small Glass Tube Patio Heater ITM ART 966697 MODEL HLDS032 GTTSS A DANGER If you smell gas 1 Shut off gas to the appliance 2 Extinguish any open flame y N gt al P A A A A A A A O A PA A SL PS Z 3 If odor continues keep away from the appliance and PSI ZI immediately call you gas supplier or fire department PS ZI SD gt N A WARNING A PSS lt WARNING indicates an imminently hazardous situation PSS STI which if not avoided will result in death or serious injury E S lt DSS o LN Munn i A WARNING Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance A WARN N For Outdoor Use Only A WARNING Improper installation adjustment alteration service or maintenance can cause property damage injury or death Read the installation operation and maintenance A instructions thoroughly before installing or servicing this equipment GP CERTIFIED IMPORTANT RETAIN FOR FUTURE REFERENCE READ CAREFULLY Questions problems missing parts Before returning to your retailer call 1 800 463 3783 6 AM 6 PM PST Monday Friday 8 AM 2 PM PST Saturday email warranty azpatioh
9. age 15 Re lighting Note For your safety control knob cannot be turned OFF without first depressing control knob in PILOT position and then rotating it to OFF 1 Turn control knob to OFF 2 Wait at least 5 minutes to let gas dissipate before attempting to relight Pilot 3 Repeat the Lighting steps on prior page A WARNING FOR YOUR SAFETY Heater will be hot after use Handle with extreme care Shut Down 1 Turn control knob clockwise to PILOT Normally burner will make a slight popping sound when extinguished Burner will extinguish but PILOT will remain ON 2 To extinguish PILOT depress control knob and continue to turn it clockwise to OFF 3 Turn cylinder valve clockwise to OFF and disconnect regulator when heater is not in use Note After use some discoloration of the emitter screen is normal Operation Checklist For a safe and pleasurable heating experience perform this check before each use Before Operating am familiar with entire owner s manual and understand all precautions noted All components are properly assembled intact and operable No alterations have been made All gas connections are secure and do not leak Wind velocity is below 10 mph 16 kmh Unit will operate at reduced efficiency below 40 F 4 4 C Heater is outdoors outside any enclosure There is adequate fresh air ventilation CONDOR WN 12 OPERATION INSTRUCTIONS 9 Heater is away from
10. e in an enclosed space l such as a camper tent or home We cannot foresee every use which may be made of our heaters Check with your local fire safety authority if you have questions about heater use A WARN N Other standards govern the use of fuel gases and heat producing products for specific uses Your local authorities can advise you about these If no local codes exist follow National Fuel Gas Code ANS Z223 1 In Canada installation must conform to local codes If no local codes exist follow the current National standards of CANADA CAN CGA B 149 2 Improper installation adjustment alteration service or maintenance can cause property damage injury or death Read the installation operation and maintenance instructions thoroughly before installing or servicing this equipment A SAFETY INFORMATION WARNING California Proposition 65 Combustion by products produced when using this product contain chemicals known to the State of California to cause cancer birth defects and other reproductive harm A WARNING BURN HAZARD Never leave heater unattended when hot or in use e Keep out of reach of children A WARNING Certain materials or items when stored under the heater will be subjected to radiant heat and could be seriously damaged A CAUTION SERVICE SAFETY Keep all connections and fittings clean Make sure propane cylinder valve outlet is clean During set up check all connections
11. e only Never use inside house or other unventilated or enclosed areas This heater consumes air oxygen Do not use in unventilated or enclosed areas to avoid endangering your life Caution Do not attempt to operate until you have read and understand all General Safety Information in this manual and all assembly is complete and leak checks have been performed Before Turning Gas Supply ON 1 Your heater was designed and approved for outdoor use only Do NOT use it inside a building garage or any other enclosed area 2 Make sure surrounding areas are free of combustible materials gasoline and other flammable vapors or liquids 3 Ensure that there is no obstruction to air ventilation Be sure all gas connections are tight and there are no leaks 4 Be sure the cylinder cover is clear of debris Be sure any component removed during assembly or servicing is replaced and fastened prior to starting Before Lighting 1 Heater should be thoroughly inspected before each use and by a qualified service person at least annually If relighting a hot heater always wait at least 5 minutes 2 Inspect the hose assembly for evidence of excessive abrasion cuts or wear Suspected areas should be leak tested If the hose leaks it must be replaced prior to operation Only use the replacement hose assembly specified by manufacturer Lighting Note This heater is equipped with a pilot light that allows for safer startups and shutdowns Pilot
12. eaters com or visit www azpatioheaters com ANS Z83 26 2007 CSA 2 37 2007 Gas Fired Outdoor Infrared Patio Heaters ANS Z83 26a 2008 CSA 2 37a 2008 Gas Fired Outdoor Infrared Patio Heaters 1 PARTS Y Reflector em Damper s Support O Lu 49 O 0 Z O D sj O Lu O 3 Glass Tube ci Control Box Assembly al Side Panel Front Panel s Bottom Plate GUANTITY c pme DT DESCRIPTION Be fms N x x s OD Support 4 s Protective Guard 4 M Control Box Assembly de Side Panel 57 Glass Tube MIE IN DS Ne Bottom Plate HARDWARE CONTENTS shown actual size Screw Fixing _ Stud Qty 38 Qty 4 M6 Small Flat Washer E Flange st a Nut Qty 1 6 Qty 3 j s AA Battery GG gt oe Nut M6 O of nee A SAFETY INFORMATION Please read and understand this entire manual before attempting to assemble operate or install the product This manual contains important information about the assembly operation and maintenance of this patio heater General safety information is presented in these first few pages and is also located throughout the manual Keep this manual for future reference and to educate new users of this product This manual should be read in conjunction with the labeling on the prod
13. fails to remain lit all valves should be closed and a waiting period of at least 5 minutes should pass before attempting to light If you experience any ignition problem please consult Troubleshooting on page 15 Caution Avoid inhaling fumes emitted from the heaters first use Smoke and odor from the burning of oils used in manufacturing will appear Both smoke and odor will dissipate after approximately 30 minutes The heater should NOT produce thick black smoke Note The burner may be noisy when initially turned to an on position To eliminate excessive noise from the burner turn the control knob to the PILOT position Then turn the knob to the level of heat desired Note Under normal conditions in the Hi position the flame is 2 3 the height of the glass tube and 1 3 the height when in the Lo position An abnormal condition is indicated by the absence of a stable and bright flame and or the presence of noise or black smoke Please turn off the heater and consult Troubleshooting on page 15 44 Normal Abnormal OPERATION INSTRUCTIONS amp WARNING FOR YOUR SAFETY Be careful when attempting to manually ignite this heater Holding in the control knob for more than 10 seconds before igniting the gas will cause a ball of flame upon ignition When heater is ON The flame should be blue with straight yellow tops If excessive yellow flame is detected turn off heater and consult Troubleshooting on p
14. n service Installation and repair should be done by a qualified service person The heater should be inspected before use and annually by a qualified service person More frequent cleaning may be required as necessary It is imperative that the control compartment burners and circulating air passageway of the appliance be kept clean Before beginning assembly of product make sure all parts are present Compare parts with package contents list and hardware contents above If any part is missing or damaged do not attempt to assemble the product Contact customer service for replacement parts Estimated Assembly Time 10 minutes Tools Required for Assembly not included e Phillips screwdriver with medium blade e Leak Detection Solution ASSEMBLY INSTRUCTIONS AZ ETORRI o l IM o MEA ME A i gt A RN Ui LA Le 1 The heater is fully assembled at the factory However the foam protecting the Glass foam unscrew the Fixing Bracket BB and the Protective Guard E Remove the foam pieces Replace the Protective
15. n two side walls These side walls may be parallel as in a breezeway or at right angles to each other c Within a partial enclosure which includes an overhead cover and three side walls as long as 30 percent or more of the horizontal periphery of the enclosure is permanently open e Do not store a spare LP gas cylinder under or near this appliance e Never fill the cylinder beyond 80 percent full Place the dust cap on the cylinder valve outlet whenever the cylinder is not in use Only install the type of dust cap on the cylinder valve that is provided with the cylinder valve Other type of caps or plugs may result in leakage of propane Use a replacement pressure regulator specified by the appliance manufacturer Use the pressure regulator and hose assembly supplied with the appliance 8 OPERATION INSTRUCTIONS Portable Heater Location 1 This portable heater is intended for outdoor use only Always 2 Always maintain proper clearance to combustible materials a minimum of 24 in 61 cm from the top and 36 in 91 cm from the sides 3 4 Testing for Leakage Gas connections on this heater are leak tested at the factory prior to shipment Possible mishandling of this appliance during shipping may impair product integrity Perform a complete leakage test again at the installation site Please follow the procedure below CEILING ensure adequate fresh air ventilation 24 in 61 cm
16. near high heat open flames WARNING indicates an imminently hazardous situation pilot lights direct sunlight other ignition sources or which if not avoided will result in death or serious injury where temperatures exceed 120 F 49 C e Propane vapors are heavier than air and can accumulate in low places If you smell gas leave the area immediately e Never install or remove propane cylinder while heater 71 WARN N is lighted near flame pilot lights other ignition sources or while heater is hot to touch Do not store or use gasoline or other flammable vapors This heater is red hot during use and can ignite and liquids in the vicinity of this or any other appliance flammables too close to the burner Keep flammables An LP cylinder not connected for use shall not be at least 3 ft 91 cm from the sides and 2 ft 61 cm stored in the vicinity of this or any other appliance from the top Keep gasoline and other flammable liquids and vapors well away from heater Store the propane cylinder outdoors in a well ventilated A WARN N For Outdoor Use Only space out of reach of children Never store the propane cylinder in an enclosed area house garage etc If heater is to be stored indoors disconnect the propane CARBON MONOXIDE HAZARD cylinder for outdoor storage This appliance can produce carbon monoxide which has no odor Using it in an enclosed A WARN N SO space can kill you Never use this i applianc
17. or it any obligation or liability associated with its products Light bulbs and fuses are not covered under this warranty Questions problems missing parts Before returning to your retailer call 1 800 463 3783 6 AM 6 PM PST Monday Friday 8 AM 2 PM PST Saturday email warranty azpatioheaters com or visit www azpatioheaters com 16
18. reduced efficiency below 40 F 5 C Carbon build up Thick black smoke __ Blockage in burner Remove blockage and clean burner inside and outside 15 ONE YEAR LIMITED WARRANTY CUSTOMERS IN USA AND CANADA Do not return this product to the store where you purchased it Please call 1 800 463 3783 6 AM 6 PM PST Monday Friday 8 AM 2 PM PST Saturday email warranty azpatioheaters com or visit www azpatioheaters com for assistance DATED PROOF OF PURCHASE REQUIRED FOR WARRANTY SERVICE This product is inspected tested and carefully packaged to minimize the chance of damage during shipment If a part excluding light bulbs and fuses within one year from the date of purchase proves to be defective in material or fabrication under normal use the part will be repaired or replaced The Company s obligation under the warranty is to replace or repair defective parts at our discretion Any expenses or damage resulting from the installation removal or transportation of the product will the responsibility of the owner and are not covered by this warranty The owner assumes all other risks arising out from the use or misuse of the product The warranty will be void if the product damage or failure is deemed by the Company to be caused by accident alteration misuse abuse incorrect installation or removal or connection to an incorrect power source by the owner The Company neither assumes nor authorizes any person or entity to assume f
19. rew the reflector spacer take off the screen take down one side of protective guards Then take the glass tube from the heater and wash and clear After that assemble the glass tube and the rest of parts Note n a salt air environment such as near an ocean corrosion occurs more quickly than normal Frequently check for corroded areas and repair them promptly TIP Use high quality automobile wax to help maintain the appearance of your heater Apply to exterior surfaces from the pole down Do not apply to emitter screen or domes Storage Between uses e Turn Control Knob OFF e Disconnect LP cylinder e Store heater upright in an area sheltered from direct contact with inclement weather such as rain sleet hail snow dust and debris elf desired cover heater to protect exterior surfaces and to help prevent build up in air passages Note Wait until heater is cool before covering During periods of extended inactivity or when transporting e Turn Control Knob OFF e Disconnect LP cylinder and move to a secure well ventilated location outdoors e Store heater upright in an area sheltered from direct contact with inclement weather such as rain sleet hail snow dust and debris e If desired cover heater to protect exterior surfaces and to help prevent build up in air passages Never leave LP cylinder exposed to direct sunlight or excessive heat Note Wait until heater is cool before covering Service Only a q
20. s hot to the touch Allow reflector to cool before touching To enjoy years of outstanding performance from your heater make sure you perform the following maintenance activities on a regular basis Keep exterior surfaces clean 1 Use warm soapy water for cleaning Never use flammable or corrosive cleaning agents 2 While cleaning your unit be sure to keep the area around the burner and pilot assembly dry at all times Do not submerge the control valve assembly If the gas control is submerged in water do NOT use it It must be replaced e Keep the appliance area clear and free from combustible materials gasoline and other flammable vapors and liquids Do not obstruct the flow of combustion and ventilation air e Keep the ventilation opening s of the cylinder enclosure free and clear from debris 3 Air flow must be unobstructed Keep controls burner and circulating air passageways clean Signs of possible blockage include 13 CARE AND MAINTENANCE e Gas odor with extreme yellow tipping of flame e Heater does NOT reach the desired temperature e Heater glow is excessively uneven e Heater makes popping noises e Spiders and insects can nest in burner or orifices This dangerous condition can damage heater and render it unsafe for use Clean burner holes by using a heavy duty pipe cleaner Compressed air may help clear away smaller particles eCarbon deposits may create a fire hazard Disassemble the reflector unsc
21. ualified service person should repair gas passages and associated components Caution Always allow heater to cool before attempting service 14 TROUBLESHOOTING PROBLEM POSSIBLE CAUSE CORRECTIVE ACTION Cylinder valve is closed Open valve k in orifi 7 Clean or replace orifice or Blockage in orifice or pilot tube pilot tube Open gas line and bleed it pressing control knob in for not Pilot won t light Air in gas line more than 1 2 minutes or until you smell gas Low gas pressure with cylinder valve Turn cylinder valve OFF and replace fully open cylinder Igniter fails Use match to light pilot obtain new igniter and replace Dirt built up around pilot Clean dirt from around pilot Pilot won t stay lit Connection between gas valve and pilot Tighten connection and perform assembly is loose leak check Thermocouple is not operating correctly Replace thermocouple Propane cylinder is frosted over Wait until the propane cylinder warms up and becomes unfrosted Burner wont light Blockage in orifice Clear blockage Control knob is not in ON position Turn control knob to ON Turn cylinder valve OFF and replace Gas pressure is low cylinder Burner flame is low Outdoor temperature is less than 40 F 4 4 C and tank is less than 1 4 full Use a full cylinder Control knob fully ON Check burner and orifices for blockage Dirt or film on reflector and burner screen Clean reflector and burner screen Note Heater operates at
22. uct Safety precautions are essential when any mechanical or propane fueled equipment is involved These precautions are necessary when using storing and servicing Using this equipment with the respect and caution demanded will reduce the possibilities of personal injury or property damage The following symbols shown below are used extensively throughout this manual Always heed these precautions as they are essential when using any mechanical or fueled equipment A DANGER A DANGER DANGER indicates an imminently hazardous situation FOR YOUR SAFETY which if not avoided will result in death or serious injury If you smell gas 1 Shut off gas to the appliance 2 Extinguish any open flame A 3 If odor continues keep away from the appliance and DAN G R immediately call you gas supplier or fire department Failure to comply with the precautions and instructions provided with this heater can result in death serious bodily injury and property loss or damage from hazards of fire explosion burn asphyxiation and or carbon monoxide poisoning Only persons who can understand and follow the instructions should use or service this heater SAFETY INFORMATION A DANGER A DANGER EXPLOSION FIRE HAZARD CARBON MONOXIDE HAZARD Keep solid combustibles such as building materials This heater is a combustion appliance All paper or cardboard a safe distance away from the combustion appliances produce carbon monoxide heater as
Download Pdf Manuals
Related Search