The Forever Cap LYM88 Installation Guide
Contents
1. ON THE ROOF A Carry damper and adhesive to roof No tools are required B Prop flue liner and damper Make certain top of flue liner is dry and clean Install damper on flue so high side of damper i against prevailing most frequent wind see ilustration Be certain 4 inch spring will hang freely from lid when damper is closed Lower end of cable with chain and handle to fireplace opening below C Adhere damper to the flue liner Use the adha sive cap to open the tube Apply adhesive to top of flue liner all the way around the opening important Use only the adhesive furnished Caution Direct contact with adhe sive will irritate eyes or skin Read directions an tube carefull Keep adhesive aut of reach of children Press the damper onto the flue liner Allow 24 hours to set before using fire place AT THE FIREPLACE A Mount bracket in fireplace Using 144 masonry drill bit drill one hole about 1 deep into firabrick towards the front of the fireplace and about 20 off the firebox floor see illustration important If brick is loose first repair amp with refractory mortar or call local mason Caution VYear safety glasses when drilling Use aniy masonry drill bit Failure to da so can cause cracks in the firebox wail Insert nail anchor in top hole of bracket and secure to firebox wall with hammer Drill second hol after bracket is attached to firabox wall Add2. second nail anchor and secure B Install cable handle Pull handle and cable through bracket until slack is out of cable Loosen brass lug with Allen wrench and slide brass lug up cable to brack at Pull cable down z until damper closes and a slight spring tansion can be falt Tighten brass lug with Allen wrench 12 above bracket see illustration Tighten brass lug to cable Close damper by pulling cable down and placing lug under bracket C Check and adjust operation Return to the roof and check that the damper is tightly sealed If it is not adjust lug upward for better seal Da not overdo it if lug is raised too far this may activate the power lever and acwally open the dampar Cut off excess cable
Download Pdf Manuals
Related Search