Real Flame 2609-B Installation Guide
Contents
1. Instruction Manual o Instructions and warnings for use P REAL F G E L FIRE PFLER EEES If parts are missing or damaged call 1 800 654 1704 for assistance Welcome to the Real Flame family of gel fuel products If you have any questions please call customer service at 1 800 654 1704 or log on to www REALFLAME com A WARNINGS A 1 Log set is designed to be used with Real Flame gel fuel only Do not use with any other gel fuel or any other flammable liquid or gel 2 Read entire label and instructions before using Real Flame gel fuel 3 Never leave a burning fire unattended especially around children or pets 4 When burning in an existing fireplace be sure that the material surrounding the logs is non combustible and itis clear and free of all flammable materials 5 Firebox must be brick cement steel or other non flammable material because there will be a real fire inside 6 Never touch logs or grate during or after burning gel fuel Logs and grate will be extremely HOT Allow logs grate and gel fuel cans to cool for 60 minutes before touching 7 Do not burn more than three cans of fuel at once 8 Keep away from children and pets Log set is not to be operated by children 9 Make sure log set and gel fuel are burned on a flat and level surface 10 Do not alter log set in any matter 11 Do not store or use gasoline or other flammable vapors or liquids in the vicinity of this product 12 Do not wear flamma2. ble or loose clothing when operating the outdoor gel log set 13 Do not attempt to move or store the log set until 60 min after gel fuel cans have been extinguished 14 Do not lean over log set when lighting or when in use 15 Do not burn gel fuel outside designated burn areas on the metal plate 16 In case of an emergency use a CO2 extinguisher to extinguish the fire 17 Death serious injury or damage to property may occur if the above is not followed exactly 18 If for any reason you cannot follow these warnings please call us at 1 800 654 1704 NOTICE Buyer assumes all responsibility for safety and use that is not in accordance with instructions and warnings Using your Log Set Log Setis designed for use in your existing indoor fireplace Follow all instructions included with gel fuel before use Before using Gel Conversion Log Set make sure you have read and understand the step by step instructions During the inital burn you may experince a slight odor This odor is temporary and will be absent on following burns Get FIREPLAC ES Rev 04 30 07 2609 Instructions and warnings for use Or REAL FLAME Parts List Number Description PartNumber Quantity Before starting assembly review Left Log 2609 R A 1 parts list making sure you have all the Middle Left Log 2609 R B pieces in good condition If there are MiddleRightLog 2609 R C an damaged or missing parts please Right Log 2609 R D call cust
3. ning three logs Use figure 4 as reference for placing the logs After all logs have been fastened to Lift Assembly slowly lower lift arm If the top four logs don t rest on Front L og 5 you may need to adjust the position of the Rear Log 6 left or right Place assembled unit in your existing fireplace A dd decorative lava rock around the base of your fireplace Figure 5 Rev 4 30 07
4. omer service at Front Log 2609 R E 1 800 654 1704 Rear Log Grate Lift Assembly Lava Rock 1 Phillips Head Bolt 9742 Before using fireplace read and understand all instructions and safety 1 1 1 1 1 1 7 precautions included with this 1 2 3 4 5 6 7 8 9 1 Step One Figure 1 With Grate 7 set on flat surface locate LiftAssembly 8 Using the four holes on the back of the Grate and 1 bolts attach the Lift Assembly with handle as shown in figure 1 Figure 1 Rev 4 26 07 Figure 3 Step Two Figure 2 Raise handle on lift assembly to the open position Place Front Log 5 and Rear Log 6 E as shown in figure 2 Step Three Figure 3 Locate the L eft Log 1 with the curve of the log facing inward towards the center Attach log to metal brace with two 1 bolts NOTE Use caution not to over tighten bolts Rev 4 26 07 2609 Instructions and warnings for use Figure 4 Step Five Figure5 Using your Convert to Gd Log Set With assembled unit in fireplace raise lift assembly Place three cans of REAL FLAME gel fuel in fuel tray located in the middle of the grate With an extended lighter or long match light gel fuel Carefully lower lift handle During the initial burn you may experience a slight odor This odor is temporary and will be absent on following burns G EL El R EP LACES Step Four Figure4 Repeat step three with the remai
Download Pdf Manuals
Related Search