DECOLAV 1220-P Instructions / Assembly
Contents
1. o STEP 6 Slip Joint Nut Washer Wall Cover Horizontal Leg Slip Joint Nut Waste System Washer Bottle Trap Figure 4 STEP 7 o Install faucet and water supply according to manufacturer s installation instructions o NOTE FAUCET AND WATER SUPPLY NOT INCLUDED o Check for leakage Customer Service 561 274 2110 LET YOUR DREAMS COME ALIVE YOUR PASSIONS www decolav com BECOME REALITY BE THE ENVY OF YOUR NEIGHBORS DECOLAV MODELNUMBER 1220 SERIES EA CARE AND CLEANING e DO NOT OVERTIGHTEN DRAIN Overtightening of the drain can damage your DECOLAV product e DO NOT clean the product with Detergents Acid Abrasives Harsh Cleaners or a cloth with a coarse surface S 0 5 Pads Scotch Brite Pads This is good advice for any plumbing fixture regardless of material e DO NOT leave any cleaning agents other than water on your DECOLAV product e DO NOT allow your DECOLAV product to unnecessarily encounter other solid objects e DO clean your DECOLAV product Wipe with a damp cloth and dry with a soft cloth If necessary a general mild soap and water solution can be used Use a mild furniture polish to clean wood frame e DO clean underside of your DECOLAV product with mild soap and water ONLY e DO wipe your DECOLAV product with a clean dry soft cloth after each use as it will limit water spots especially in hard water areas e DO clean your DECOLAV mirror Wipe with a glass c2. USE OF OTHER THAN GENUINE DECOLAV REPLACEMENT PARTS DIRT LIME SCALE AND OTHER MINERALS SCUFFS AND SCRATCHES EXPOSURE TO MARINE AREAS ABNORMAL USAGE AND NORMAL WEAR AND TEAR ANY IMPROPER INSTALLATION IMPROPER MAINTENANCE IMPROPER HANDLING IMPROPER AND CONTRARY USES NOT STATED WITHIN INSTRUCTIONS AND ALL ACTS BEYOND DECOLAV s CONTROL WILL VOID THIS LIFETIME WARRANTY DECOLAV s product s are produced from natural raw materials and there is a slight color variance This is NOT a manufacturing defect s and will not be covered under this Lifetime Warranty This Lifetime Warranty does not apply to local building code compliance Since local building codes vary considerably the original end consumer of the product s should check with a local building or plumbing contractor to ensure local code compliance before installation This Lifetime Warranty does not cover any mechanical pieces of any DECOLAV product s These mechanical pieces will be covered under a One Year Warranty based on the same criteria as this Lifetime Warranty from the date of the initial purchase Upon satisfaction of each of the foregoing conditions and requirements DECOLAV shall at its option either repair or replace such defective product s DECOLAV shall return any product s repaired or replaced under this Lifetime Warranty to the original end consumer transportation prepaid All Closeout Discontinued product s at time of claim will either be repaired or replaced
3. with a comparable item DECOLAV s option to repair or replace the product s under this Lifetime Warranty does not cover any cost of labor to remove or install the DECOLAV product usage and delay time or other costs of removal or installation whatsoever IN NO EVENT WILL DECOLAV BE LIABLE FOR THE COST OF REPAIR OR REPLACEMENT OF ANY INSTALLATION MATERIALS INCLUDING BUT NOT LIMITED TO TILES MARBLE ETC This Lifetime Warranty does not cover any liability for consequential or incidental damages all of which are hereby expressly disclaimed or the extension beyond the duration of this Lifetime Warranty Some states do not allow the exclusion or limitation of incidental or consequential damages so the above limitation or exclusion may not apply to you THE WARRANTIES HEREIN A ARE EXCLUSIVE AND STATED IN LIEU OF ALL OTHER WARRANTIES WHETHER EXPRESS STATUTORY OR IMPLIED INCLUDING BUT NOT LIMITED TO THE WARRANTIES OF MERCHANTABILITY AND FITNESS FOR AN INTENDED PURPOSE ALL OF WHICH ARE HEREBY EXPRESSLY DISCLAIMED B NEITHER ASSUME NOR AUTHORIZE PURCHASER NOR ANY OTHER PARTY TO ASSUME FOR DECOLAV ANY OTHER LIABILITIES IN CONNECTION WITH THE MANUFACTURE OR SALE OF PRODUCTS AND C ARE SUBJECT TO THE LIMITATIONS ON DAMAGES AS SET FORTH ABOVE Customer Service 561 274 2110 LET YOUR DREAMS COME ALIVE YOUR PASSIONS www decolav com BECOME REALITY BE THE ENVY OF YOUR NEIGHBORS
4. DECOLAV MODEL NUMBER 1220 SERIES PRODUCT DESCRIPTION Stainless Steel Lavatory with Overflow e Simply Stainless Collection e Double Walled with Overflow e 16 Round e High Quality Durable Stainless Steel e For Drop in or Undermount Use e CSA Certified CSA B45 0 2002 CSA B45 4 2002 ASME A112 19 3 2000 PRODUCT MEASUREMENTS e Diameter 16 25 inches 41 275 cm e Height 6 75 inches 17 145 cm RECOMMENDED ACCESSORIES e DECOLAV 9295 Grid Drain or e DECOLAV 9297 Push Button Closing Umbrella Drain e DECOLAV 9100 Decorative Bottle Trap THANK YOU Dear Valued Customer DECOLAV would like to take this opportunity to thank you for your purchase It is our sincere hope that you are completely satisfied with your new product We welcome and look forward to helping you create another unique look for your next bathroom project Prior to installation please take a moment to review all provided materials and hardware For assistance with your new product please contact our dedicated DECOLAV customer service staff a DECOLAV Robert H Mayer Chief Executive Officer and President CHANGING THE WAY YOU VIEW THE BATHROOM Sincerely BEFORE YOU BEGIN 1 Prior to installation unpack your new DECOLAV product and inspect it Keep the product in its original package until you are ready to install it 2 The wall must be square plumb and level 3 Shut the water supply off when rep
5. Template Included a D INSTALLATION INSTRUCTIONS e STEP 1 o Affix Template provided to Countertop at desired location with cellophane tape o Mark guidelines on Countertop in several places o Drill a clearance hole approximately 1 4 to 2 inside the perimeter line of Template o Cut opening following the perimeter line of Template o NOTE FOLLOW PERIMETER LINE OF DESIRED MOUNTING DROP IN OR UNDERMOUNT Clearance Hole Cut Opening e STEP 2 o Check for cutout alignment by placing Lavatory A in desired mounting position Cs If Undermount Customer Service 561 274 2110 LET YOUR DREAMS COME ALIVE YOUR PASSIONS www decolav com BECOME REALITY BE THE ENVY OF YOUR NEIGHBORS S DECOLAV MODELNUMBER 1220 sERIES EN INSTALLATION INSTRUCTIONS e STEP 3 Drop In o Apply Plumber s Putty or Caulking around the underside of rim near the edge as shown o Carefully lower Lavatory in place in a align and press firmly Apply Plumber s o Wipe off excess sealant Putty or Caulking o Refer to Figure 1 a hii o Proceed to Step 5 o NOTE ALLOW SEALANT TO SET BEFORE PROCEEDING Figure 1 e STEP 4 Undermount o Refer to Figure 2 Mounting Clips Detail Installation for solid surface countertops with a minimum thickness of 1 25mm Installer must supply anchors for thinner countertops o For solid surface drill anchors hole 3 8 Dia x 1 2 deep Apply small amount of Epoxy not
6. lacing an existing fixture Preparation of the floors and walls including all additional wall supports may be required A Observe all local plumbing and building codes 5 It is recommended that this installation be done with a minimum of two people Do not install this fixture alone Customer Service 561 274 2110 LET YOUR DREAMS COME ALIVE YOUR PASSIONS www decolav com BECOME REALITY BE THE ENVY OF YOUR NEIGHBORS DECOLAV MODELNUMBER 1220 SERIES 2 RECOMMENDED TOOLS Tape Measure Adjustable Wrench Pipe Clamp Channel Locks Drill Hacksaw Level Toe R i 4 Phillips Plumber s Putty or Flathead Screwdriver Pipe Wrench Caulking Putty Knife neti Scroll Saw Pipe Cutter Pencil Square Ruler ROUGHING IN DIMENSIONS Finished Wall line Re 1 3 8 3 4925 cm _2 5 08 cm Sugg Faucet Hole 2 1 2 6 35 cm Sugg 4 445 cm Drain Finished Wall ips Countertop 16 1 4 41 275 cm 12 30 48 cm 14 35 56 cm 14 35 56 cm 1 1 4 3 175 cm Waste 34 86 365 cm 34 86 365 cm Finished Floor Finished Floor Side View Front View LET YOUR DREAMS COME ALIVE YOUR PASSIONS BECOME REALITY BE THE ENVY OF YOUR NEIGHBORS Customer Service 561 274 2110 www decolav com Sa DECOLAV MODELNUMBER 1220 SERIES 3 PARTS ltem Description Stainless Steel Lavatory Undermount Clips e NOTE Cutout
7. leaner and a clean soft cloth Use a mild furniture polish to clean wood frame e DECOLAV recommends proper sealing of ALL natural stone products PRIOR TO INSTALLATION FULL LIFETIME WARRANTY Any Deco Lay Inc DECOLAV product s sold after January 1 2006 will be warranted to the original end consumer to be free of true defect s in material and workmanship for life of the product s subject to the following restrictions e DECOLAV is notified promptly in writing via fax or mail by the Retail Wholesale Purchaser upon discovery of any alleged defect s in the product s including a detailed description of the alleged defect s e Proof of purchase original sales receipt from the original end consumer must be made available to DECOLAV for all warranty claims e Authorized DECOLAV personnel has inspected the product s and determined the product s to have true manufacturing defect s e Such product s are returned to DECOLAV unless other arrangements satisfactory to DECOLAV have been agreed upon This Lifetime Warranty is non transferable and applies only to the original end consumer and to the original installation of the product s This Lifetime Warranty is void if the product s has been moved from its initial installation site or if ownership of the product s has changed THIS LIFETIME WARRANTY DOES NOT COVER ANY DAMAGES CAUSED BY SHIPPING MISUSE ABUSE ACCIDENTS NEGLECT UNAUTHORIZED REPAIRS OR ALTERATIONS MODIFICATIONS
8. provided to closed end of Threaded Knurl C Insert threaded knurl threaded open end exposed o Apply Plumber s Putty or Caulking around the topside of rim near the edge as shown o Carefully raise Lavatory in place align and press firmly o Wipe off excess sealant o Attach Undermount Clips B to hold Lavatory in place o NOTE FOR WOOD COUNTERTOPS USE WOOD SCREWS AND ANCHORS WOOD SCREWS NOT PROVIDED o NOTE ALLOW SEALANT TO SET BEFORE PROCEEDING Countertop Threaded Knurl Apply plumber s putty or caulking here Mounting Clip Washer Machine Screw Mounting Clip Detail Figure 2 Customer Service 561 274 2110 LET YOUR DREAMS COME ALIVE YOUR PASSIONS www decolav com BECOME REALITY BE THE ENVY OF YOUR NEIGHBORS Sa DECOLAV MODELNUMBER 1220 SERIES 5 INSTALLATION INSTRUCTIONS e STEP 5 o NOTE DRAIN SHOWN DECOLAV 9297 PUSH BUTTON CLOSING UMBRELLA DRAIN IS A RECOMMENDED ACCESSORY AND NOT INCLUDED o Install Drain according to manufacturer s installation instructions o NOTE DO NOT OVERTIGHTEN DRAIN o Refer to Figure 3 Countertop Drain Thick Washer Hard Washer ee Drain Nut biad Aaen Thick Washer Drain Nut Drain t Tailpiece Figure 3 o NOTE WASTE SYSTEM SHOWN DECOLAV 9100 DECORATIVE BOTTLE TRAP IS A RECOMMENDED ACCESSORY AND NOT INCLUDED o Install Waste System according to manufacturer s installation instructions o Refer to Figure 4
Download Pdf Manuals
Related Search