Hercules 256052 Use and Care Manual
Contents
1. Yes Not Determined Not Determined Yes Hercules Plumber s Caulk White Almond Biscuit Revision date SDS 7354E Version 01 SDS US Issue date 12 May 2015 Page 5 of 6 16 Other information including date of preparation or last revision Issue Date 12 May 2015 Revision Date Version 01 HMIS Rating Health 1 Flammability 1 Physical Hazards 0 Disclaimer HCC Holdings Inc an Oatey Affiliate cannot anticipate all conditions under which this information and its product or the products of other manufacturers in combination with its product may be used It is the user s responsibility to ensure safe conditions for handling storage and disposal of the product and to assume liability for loss injury damage or expense due to improper use The information in the sheet was written based on the best knowledge and experience currently available Hercules Plumber s Caulk White Almond Biscuit SDS US SDS 7354E Version 01 Revision date Issue date 12 May 2015 Page 6 of 62. Conditions for safe storage including any incompatibilities Evacuate surrounding areas Keep unnecessary and unprotected personnel from entering Do not touch or walk through spilled material Put on appropriate personal protective equipment If specialized clothing is required to deal with the spillage take note of any information in Section 8 on suitable and unsuitable materials See also the information in For non emergency personnel Large Spills Move containers from spill area Prevent entry into sewers water courses basements or confined areas Vacuum or sweep up material and place in a designated labeled waste container Dispose of via a licensed waste disposal contractor Note see section 1 of SDS for emergency contact information and section 13 of SDS for waste disposal Small Spills Move containers from spill area Vacuum or sweep up material and place in a designated labeled waste container Dispose of via a licensed waste disposal contractor Note see section 1 of SDS for emergency contact information and section 13 of SDS for waste disposal Avoid dispersal of spilled material and runoff and contact with soil waterways drains and sewers Inform the relevant authorities if the product has caused environmental pollution sewers waterways soil or air Put on appropriate personal protective equipment see section 8 of SDS Eating drinking and smoking should be prohibited in areas where this material is handled stored and
3. processed Workers should wash hands and face before eating drinking and smoking See also Section 8 for additional information on hygiene measures Store in accordance with local regulations Store in original container protected from direct sunlight in a dry cool and well ventilated area away from incompatible materials see section 10 of SDS and food and drink Keep container tightly closed and sealed until ready for use Containers that have been opened must be carefully resealed and kept upright to prevent leakage Do not store in unlabeled containers Use appropriate containment to avoid environmental contamination Hercules Plumber s Caulk White Almond Biscuit Revision date SDS 7354E Version 01 SDS US Issue date 12 May 2015 Page 2 of 6 8 Exposure controls personal protection Occupational exposure limits US ACGIH Threshold Limit Values Components Type Value Distillates petroleum hydrotreated light TWA 200 mg m3 Biological limit values Appropriate engineering controls No Biological limits No special ventilation requirements Good general ventilation should be sufficient to control worker exposure to airborne contaminants If this product contains ingredients with exposure limits use process enclosures local exhaust ventilation or other engineering controls to keep worker exposure below any recommended or statutory limits Individual protection measures such as personal protective e
4. products should not be produced 11 Toxicological information Information on likely routes of exposure Inhalation Skin contact Eye contact Ingestion Symptoms related to the physical chemical and toxicological characteristics No known significant effects or critical hazards No known significant effects or critical hazards No known significant effects or critical hazards No known significant effects or critical hazards No specific data Information on likely routes of exposure Acute Toxicity Components Species Results Skin corrosion irritation Serious eye damage eye irritation Respiratory or skin sensitization Respiratory sensitization Skin sensitization Germ cell mutagenicity Carcinogenicity Reproductive toxicity Specific target organ toxicity Single exposure Repeated exposure Aspiration Hazard Chronic effects Further information 12 Ecological information Ecotoxicity Product ingredient name Results Not determined Not determined Not considered a respiratory irritant This product is not expected to cause skin irritation No specific data No known significant effects or critical hazards No known significant effects or critical hazards Not Classified Not Classified Contains Distillates petroleum hydrotreated Which is a category 1 Aspiration Hazard The likely hood of aspirating the product in this form is very low due to the high viscosity Not Classified Species Expos
5. waterways drains and sewers Not Applicable Not Applicable 14 Transportation information DOT UN number UN Proper Shipping Name Transportation Hazard classes Packing group IATA UN number UN Proper Shipping Name Transportation Hazard classes Packing group IMDG UN number UN Proper Shipping Name Transportation Hazard classes Packing group Environmental hazards Marine polluntant 15 Regulatory information U S Federal regulations SARA 311 312 Classification US state regulations California Prop 65 Canada WHMIS Canada International regulations Couniry s or region Canada Australia China United States amp Puerto Rico Not Regulated Not Regulated Not Regulated TSCA 12 b Chemical export notification None required TSCA 5 a 2 Final significant new use rules Not listed TSCA 5 a 2 Proposed significant new use rules Not listed TSCA 5 e Substances consent order Not listed Not applicable This product contains a chemical known to the State of California to cause cancer birth defects or other reproductive harm Class D 2A Material causing other toxic effects Very toxic Inventory Name At least one component not listed in DSL but all such components are listed in NDSLDomestic Substance List Australian Inventory of Chemical Substances AICS Inventory of Existing Chemical Substances in China IECSC Toxic Substances Control Act TSCA 8b On inventory list yes no
6. 10 Distillates petroleum hydrotreated light 64742 47 8 1 5 There are no additional ingredients present which within the current knowledge of the supplier and in the concentrations applicable are classified as hazardous to health or the environment and hence require reporting in this section Designates that a specific chemical identity and or percentage of composition has been withheld as a trade secret 4 First aid measures Inhalation Skin contact Remove victim to fresh air and keep at rest in a position comfortable for breathing Get medical attention if symptoms occur Flush contaminated skin with plenty of water Remove contaminated clothing and shoes Get Hercules Plumber s Caulk White Almond Biscuit SDS 7354E Version 01 Revision date Issue date 12 May 2015 SDS US Page 1 of 6 Eye contact Ingestion Most important symptoms effects acute and delayed Indication of immediate medical attention and special treatment needed General information 5 Fire fighting measures Suitable extinguishing media Unsuitable extinguishing media Specific hazards arising from the chemical Special protective equipment and precautions for firefighters Fire fighting equipment instructions Specific methods General fire hazards medical attention if symptoms occur Immediately flush eyes with plenty of water occasionally lifting the upper and lower eyelids Check for and remove any contact l
7. HERCULES 1 Identification Product identifier Other means of identification Product code Synonyms Recommended use Recommended restrictions SAFETY DATA SHEET Hercules Plumber s Caulk White Almond Bone Biscuit Linen 7354E Part Numbers 25605 25615 25631 25636 25641 25641R 35646 Caulk and sealant for use around tubs sinks and other plumbing applications Do not us on applications where product will be submerged under water Manufacturer Importer Supplier Distributor information Company Name Address Telephone E mail Transport Emergency Emergency First Aid Contact person 2 Hazard s identification Physical hazards Health hazards OSHA defined hazards Label elements Hazard symbol Signal word Hazard statement Precautionary statement Prevention Response Storage Disposal Hazard s not otherwise classified HNOC HCC Holdings Inc an Oatey Affiliate 4700 West 160th Street Cleveland OH 44135 216 267 7100 info oatey com Chemtrec 1 800 424 9300 Outside the US 1 703 527 3887 1 877 740 5015 MSDS Coordinator Not Classified Not Classfiied Not Classified None None This material does not meet the criteria for classification Not applicable Not applicable Not applicable Not applicable Uncured product is irritating to eyes skin and respiratory system 3 Composition information on ingredients Mixtures Chemical name CAS number Plasticizer Polymer Additive Trade Secret 5
8. enses Get medical attention if irritation occurs Wash out mouth with water Remove victim to fresh air and keep at rest in a position comfortable for breathing If material has been swallowed and the exposed person is conscious give small quantities of water to drink Do not induce vomiting unless directed to do so by medical personnel Get medical attention if symptoms occur Skin or eye irritation Contact poison treatment specialist immediately if large quantities have been ingested or inhaled Note to physician treat symptomatically Use dry chemical CO2 alcohol resistant foam or water spray fog water jet No specific fire or explosion hazard Fire fighters should wear appropriate protective equipment and self contained breathing apparatus SCBA with a full face piece operated in positive pressure mode Promptly isolate the scene by removing all persons from the vicinity of the incident if there is a fire No action shall be taken involving any personal risk or without suitable training Use water spray to keep fire exposed containers cool Fire water contaminated with this material must be contained and prevented from being discharged to any waterway sewer or drain None None 6 Accidental release measures Personal precautions protective equipment and emergency procedures Methods and materials for containment and cleaning up Environmental precautions 7 Handling and storage Precautions for safe handling
9. ical and chemical properties Appearance Physical state Form Color Odor Odor threshold pH Melting point freezing point Initial boiling point and boiling range Flash point Solid Paste White or Off White Ammonia Not available 7 7 Not applicable Not determined gt 199 F gt 93 3 C Upper lower flammability or explosive limits Flammability limit lower Flammability limit upper Explosive limit lower Explosive limit upper Vapor pressure Vapor density Relative density Solubility ies Solubility water Partition coefficient n octanol water Auto ignition temperature Decomposition temperature Viscosity Other information VOC Weight Not available Not available Not available Not available Not applicable Not applicable 1 50 Not available Not available Not applicable Not available Not available 1 4 or 37 g L Hercules Plumber s Caulk White Almond Biscuit SDS US SDS 7354E Version 01 Revision date Issue date 12 May 2015 Page 3 of 6 10 Stability and reactivity Reactivity Chemical stability Possibility of hazardous reaction Conditions to avoid Incompatible materials Hazardous decomposition products Stable under normal conditions The product is stable Under normal conditions of storage and use hazardous reactions will not occur No specific data No specific data Under normal conditions of storage and use hazardous decomposition
10. quipment Eye face protection Skin protection Hand Other Respiratory protection Thermal hazards General hygiene considerations Safety eyewear complying with an approved standard should be used when a risk assessment indicates this is necessary to avoid exposure to liquid splashes mists gases or dusts Chemical resistant impervious gloves complying with an approved standard should be worn at all times when handling chemical products if a risk assessment indicates this is necessary Appropriate footwear and any additional skin protection measures should be selected based on the task being performed and the risks involved and should be approved by a specialist before handling this product Use a properly fitted particulate filter respirator complying with an approved standard if a risk assessment indicates this is necessary Respirator selection must be based on known or anticipated exposure levels the hazards of the product and the safe working limits of the selected respirator None Wash hands forearms and face thoroughly after handling chemical products before eating smoking and using the lavatory and at the end of the working period Appropriate techniques should be used to remove potentially contaminated clothing Contaminated work clothing should not be allowed out of the workplace Wash contaminated clothing before reusing Ensure that eyewash stations and safety showers are close to the workstation location 9 Phys
11. ure Distillates petroleum hydrotreated light Acute LC50 2 900 ug l Fresh water Fish Rainbow trout Donaldson trout 96h Acute LC50 2 200 ug l Fresh water Fish Bluegill 96 h Persistence and degradability Not Available Bio accumulative potential Not Available Mobility in soil Not available Other adverse effects No known significant effects of critical hazards Hercules Plumber s Caulk White Almond Biscuit Revision date SDS 7354E Version 01 SDS US Issue date 12 May 2015 Page 4 of 6 13 Disposal considerations Disposal instructions Local disposal regulations Hazardous waste code The generation of waste should be avoided or minimized wherever possible Disposal of this product solutions and any by products should at all times comply with the requirements of environmental protection and waste disposal legislation and any regional local authority requirements Dispose of surplus and non recyclable products via a licensed waste disposal contractor Waste should not be disposed of untreated to the sewer unless fully compliant with the requirements of all authorities with jurisdiction Waste packaging should be recycled Incineration or landfill should only be considered when recycling is not feasible This material and its container must be disposed of in a safe way Empty containers or liners may retain some product residues Avoid dispersal of spilled material and runoff and contact with soil
Download Pdf Manuals
Related Search