Universal Tubs HDSI3060RWS Installation Guide
Contents
1. freight costs of the original shipment and return shipment to Universal Walk In Bathtubs All requests for return must first be approved by Universal Walk In Bathtubs and have an assigned Returned Merchandise Authorization number Page 22 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com SNOILLONYLSNI 9NIIVH3d0 Universal kubs your doorway to independent bathing PRODUCT REGISTRATION CARD The completed card should be cut out or copied completed and mailed to UNIVERSAL WALK IN BATHTUBS 5701 NW 35 Avenue Miami FL 33142 have read the Universal Walk In Bathtubs Owner s Manual carefully and understand and agree that any installation operation or maintenance of the walk in bath tub must be done strictly in accordance with instructions and guidelines contained the Universal Walk In Bathtubs owner s manual and installation guide Signature Date Page 23 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com PRODUCT REGISTRATION SNOILONYLSNI 9NI1VH3d0 9 NOLIVTIVISNI Universal kubs our doorway to independent bathing o Universal tubs your doorway to independent bathing Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com2. NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com PRODUCT REGISTRATION TWANVIN SIHL JAWS Universal kubs your doorway to independent bathing SAVE THIS MANUAL READ THESE INSTRUCTIONS COMPLETELY BEFORE INSTALLING THE PRODUCTS FAILURE TO DO SO COULD RESULT IN AN IMPROPER INSTALLATION AND COULD VOID THE WARRANTY THE INSTALLER MUST INSPECT AND WATER TEST THE PRODUCT PRIOR TO INSTALLATION TO ENSURE THE UNIT IS FREE OF DEFECT OR DAMAGE IN THE EVENT OF APROBLEM THE UNIT MUST NOT BE INSTALLED IF THE CRATE OR THE PRODUCT HAS BEEN DAMAGED DURING SHIPPING PLEASE CALL US IMMEDIATELY LICENSED PLUMBERS AND ELECTRICIANS SHOULD BE EMPLOYED TO INSURE PROPER INSTALLATION INSTALLERS ASSUME ALL LIABILITY FOR THE CORRECT INSTALLATION PROCEDURES ONLY ACCESSORIES AUTHORIZED BY THE MANUFACTURER SHOULD BE USED WITH THIS PRODUCT WARNING WHEN USING THIS PRODUCT BASIC PRECAUTIONS SHOULD ALWAYS BE FOLLOWED READ AND FOLLOW ALL INSTRUCTIONS PERTAINING TO RISK OF FIRE ELECTRICAL SHOCK AND OR OTHER INJURIES Page 4 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com SNOILLONYLSNI 9NIIVH3d0 Universal kubs your doorway to independent bathing UNPACKING THE UNIT Inspect the carton If any damages are noted photograph the damaged area s and notify the deliverer carrier Never lift the walk in bathtub by the plumbing Doing so may resu
3. fittings and all plated finishes are covered by a limited one year warranty subject to verification of the defect or malfunction All labor and repair related services are covered within the first 90 days of purchase This warranty is non transferable and applies only to the original owner as stated on the original purchase order Notification must be sent via certified mail to 5701 NW 35 Avenue Miami FL 33142 The manufacturer will not be responsible for any water damage to any structures or any property for any reason including but not limited to manufacturer defects or improper installation Manufacturer will assume no responsibility for the loss of the system inconvenience due to loss damage to real or personal property or any other consequential damage Manufacturer will not be liable for any incidental expenses or material charges in connection with removal or replacement of the purchased part or any part or parts of the system This warranty shall not apply to any type of failure resulting from negligence abuse misuse misapplication improper installation alteration or modification chemical corrosion or improper maintenance Every walk in tub must be installed by a licensed plumber electrician and or contractor Failure to do so will hereby void the warranty There will be a charge for replacement parts or the replacement of the entire electrical unit if the defective unit is returned for any of the reasons listed above NOTE WITHIN THE LI
4. 0 4454 Fax 866 560 1060 info universaltubs com http www universaltubs com Page 2 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com SNOLLONYLSNI Universal kubs your doorway to independent bathing PRODUCT REGISTRATION To ensure that your warranty is registered with Universal Walk In Bathtubs complete sign and return this registration card within 30 days of the purchase NOTE Your warranty will not be recognized by Universal Walk In Bathtubs unless this card is fully completed and returned to Universal Walk In Bathtubs 5701 NW 35th Ave Miami FL 33142 To ensure that your warranty is registered and confirmed with the manufacturer please take a few moments to complete sign and return the Product Registration Card below within 30 days By returning this Product Registration Card we confirm the date of purchase for your new product This confirmation will allow Universal Walk In Bathtubs to process any warranty claims The information provided on Product Registration Card found on page 23 will be kept on file with Universal Walk In Bathtubs as an official Purchase Registration The completed card should be mailed to UNIVERSAL WALK IN BATHTUBS 5701 NW 35 Avenue Miami FL 33142 Phone 877 360 4454 Fax 866 560 1060 info universaltubs com http www universaltubs com Page 3 Universal Walk In Bathtubs 5701
5. ING SAFETY 14 OPERATING INSTRUCTIONS 16 TUB neces 18 CLEANING AND MAINTENANCE 19 WARRANTY fetas 20 RETURN gi sec 22 PRODUCT REGISTRATION 23 Page 1 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com TABLE OF CONTENTS LOWLNOD Universal kubs your doorway to independent bathing THANK YOU FOR CHOOSING UNIVERSAL WALK IN BATHTUBS 9 Our mission is to help you maintain independence over essential bathing needs and improve the quality of life Universal Walk In Bathtubs has designed the most accessible most comfortable walk in bathtub on the market today Until recently if you have difficulty getting in and out of a bathtub it was almost impossible for you to take a bath Universal Walk In Bathtubs specializes in accessibility and security Safe transfers in and out of the bathtub are the most critical part of bathing safely Universal Walk In Bathtubs is committed to providing a complete bathing experience for the elderly and mobility impaired CONTACT INFORMATION UNIVERSAL WALK IN BATHTUBS 5701 NW 35 Avenue Miami FL 33142 Phone 877 36
6. MITED ONE YEAR WARRANTY THERE WILL BE A PRORATED CHARGE FOR ANY ELECTRICAL AND PLATED REPLACEMENTS PARTS INCLUDING SHIPPING AND HANDLING CHARGES Manufacturer reserves the sole authority to make any type of warranty changes at any time The manufacturer will not be responsible for any warranty information that is being misrepresented by outside sources including dealers Page 20 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com SNOLLONYLSNI 9NIIVH3d0 Universal kubs your doorway to independent bathing retailers distributors or contractors Manufacturer does not warranty the installation plumbing or electrical related connections of any of our products including Walk In Baths shower pans or shower stalls Improper or negligent installation of the product or other components alterations or medications to the system may cause the product or the system to malfunction Such problems are not covered by warranty Manufacturer warranties the door seal for the life of the unit under normal use and conditions This warranty shall not apply to any failure resulting from negligence abuse misuse misapplication alternation or medication or improper maintenance The replacement door seal will be issued to the end user and it will be the responsibility of the end user to determine the means of installation Manufacturer will not be liable for any incidental expenses or material
7. NG DO NOT PUSH THE BUTTON ONCE THE CYCLE BEGINS DOING SO WILL CAUSE Page 16 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com SNOLLONYLSNI 9NIIVH3d0 Universal kubs your doorway to independent bathing THE BLOWER TO RESTART ONCE THE PURGE CYCLE ENDS If your bathtub is equipped with an in line heater it will operate only when the pump is on NOTE THE IN LINE HEATER IS DESIGNED TO KEEP YOUR WATER WARMER LONGER BUT IS NOT DESIGNED TO INCREASE THE WATER TEMPERATURE HEAT SETTINGS ARE NOT ADJUSTABLE Page 17 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com SNOLLONYLSNI 9NIIVH3d0 Universal kubs your doorway to independent bathing EXAMPLE TUB CONTROLS Controls depicted may vary from those found on your unit Variance is based on the options purchased during the order process VAAL 2559999466 x AROMA CANISTER Page 18 1 LI Y Used to turn the water jets ON and OFF AIR CONTROL BLOWER Used to control the air jets on the system 1st Press Blower starts at MAX speed 2nd Press Blower at MED speed 3rd Press Blower at MIN speed 4th Press Blower turns OFF CHROMO CONTROL LIGHT Used to turn the chromotherapy lights ON and OFF Pressing the button repeatedly will cycle through different color modes AIR PRESSURE CO
8. NSURE POWER IS ON AND THE CABLE CONNECTING THE CONTROLS TO THE PUMP IS ATTACHED WARNING DO NOT RUN ANY PUMPS UNLESS THE TUB IS FILLED WITH WATER TO PROPER LEVEL DAMAGE DUE TO DRY RUNNING PUMPS IS NOT COVERED UNDER WARRANTY FAILURE TO PERFORM THESE TESTS BEFORE INSTALLATION WILL MAKE THE INSTALLER LIABLE FOR FUTURE REPAIR COSTS Page 6 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com SNOLLONYLSNI 9NIIVH3d0 Universal kubs your doorway to independent bathing INSTALLATION PREPARATION 1 Check the floor area where the tub is to be installed Clean area of any debris or trash e b Useabor6 foot level and determine if the floor is level If the floor is not level adjust all 6 leveling feet to perfectly level the tub NOTE IT IS IMPORTANT THAT ALL LEVELING FEET ARE COMPLETELY TOUCHING THE FLOOR AND LEVEL FOR THE DOOR SYSTEM TO WORK PROPERLY 2 Check to ensure that the drain piping has been roughed in at the proper location 3 Ensurethatthe proper electrical service has been installed at the pump location See electrical requirements in the manual on following page Page 7 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com NOLIVuVd3ud 1721819313 Universal kubs your doorway to independent bathing ELECTRICAL PREPARATION All electrical wiring mus
9. NTROL Used to increase or decrease air pressure flowing through the water jets QAROMA CONTAINER Unscrew to place or replace the aroma canister AROMA CANISTER Placed inside the aroma container Check frequently and replace as needed 1UL FUIT Please note that the control panel design will vary as the 3060Si model does not have the combined Dual therapy option Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com SNOILONYLSNI 9NIIVH3d0 Universal kubs our doorway to independent bathing 8 CLEANING AND MAINTENANCE Pump and pipe circulation systems should be flushed before first use and on a monthly basis when product is under normal use Below are the recommended procedures for cleaning Do not run whirlpool dry Fill the tub with hot water 2 3 inches above the jets and add 2 3 teaspoons of low foaming detergent such as dishwashing machine detergent Turn on whirlpool system and run for 10 minutes Drain tub completely Fill tub with cold water above jets Turn on whirlpool system and run for 15 minutes Drain tub completely Cleaning the suction cover Clean and remove any hair or lint from the suction cover see image below On a monthly basis unscrew the suction cover and clean away any hair lint or debris from the cover and housing then remount the cover in place Some suctions are not designed to
10. R RESIDENTIAL PLUMBING IT IS RESPONSIBILITY OF THE INSTALLER TO INSURE THE SANITARY SYSTEM IS ACCEPTABLE FOR THE USE OF THE HIGH SPEED AUTODRAIN WE DO NOT ACCEPT RESPONSIBILITY FOR DAMAGE ARISING FROM THE USE OF THE HIGH SPEED AUTODRAIN Ensure compliance with local plumbing codes Page 11 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com SNOILLONYLSNI 9NIIVH3d0 Universal kubs your doorway to independent bathing OPERATING INSTRUCTIONS ASSEMBLY amp PLACEMENT Verify access to unit s system from one of the side enclosures r Mortar Bathroom Waterproof Sheetrock Wall aS Tile Silicone AN SN NNN SAAS A 6 x1 2 Screw Custom built wall section s for open ends or install against corners of full wall No included with tub Contact your installer Page 12 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com SNOILLONYLSNI 9NIIVH3d0 Universal kubs your doorway to independent bathing FAUCET INSTALLATION The 30x60 Step In models is not equipped with a faucet deck Third party wall or floor mounted faucet sets must be purchased separately Page 13 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com SNOLLONYLSNI 9NIIVH3d0 Universal kubs your doorway to in
11. SNOLLONYLSNI 9NIIVH3d0 Universal kubs your doorway to independent bathing 30605 UNIVERSAL WALK IN BATHTUBS 5701 NW 35 Avenue Miami FL 33142 Phone 877 360 4454 Fax 866 560 1060 info universaltubs com http www universaltubs com Page 25 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com INSTALLATION amp OPERATING INSTRUCTIONS Rev 3 15 SNOILLONYLSNI 9NILIVH3d0 Universal kubs your doorway to independent bathing TABLE OF CONTENTS THANK YOU FOR CHOOSING UNIVERSAL WALK IN BATHTUBS 9 2 CONTACT INFORMATION eeeeeeeeeeee eene 2 PRODUCT REGISTRATION 3 SAVE THIS MANUAL useeeeeeeeeeeeeeee eene nnne nnn nnne nnns nnns 4 UNPACKING gie 5 PRE INSTALLATION 6 INSTALLATION PREPARATION _ nnn 1 ELECTRICAL PREPARATION 8 INSTALLATION PROCEDURES 9 DRAIN 10 CONNECTING THE 11 INSTALLATION AND EXTENSION PANELS 12 FAUCET 13 OPERAT
12. assage amp Air Massage Dual w Light amp Auto Drain Whirlpool Inline Heater Dedicated 15 Amp Circuit All electrical connections must be carried out b y a certified electrician in accordance with local electrical requirements and codes Page 8 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com 15 Amp GFCI 15 Amp GFCI 15 Amp GFCI 15 Amp GFCI 15 Amp GFCI 15 Amp GFCI 15 Amp GFCI 20 Amp GFCI 20 Amp GFCI 20 Amp GFCI 20 Amp GFCI 15 Amp GFCI SNOILLONYLSNI 9NIIVH3d0 Universal kubs your doorway to independent bathing INSTALLATION PROCEDURES WARNING WHEN INSTALLING JET MASSAGE BATH THE FOLLOWING BASIC PRECAUTIONS SHOULD BE FOLLOWED DANGER RISK OF ELECTRIC SHOCK CONNECT ONLY TO SEPARATE CIRCUIT PROTECTED BY A GROUND FAULT CIRCUIT INTERRUPTER GFCI ON PLUG IN UNITS NOTE INSTALLATION MUST PROVIDE ACCESS FOR SERVICING PUMP MOTOR ALL TUBS COME WITH AN ACCESS PANEL FOR THE PUMP MOTOR e Install tub waste overflow according to instructions see page 10 e Standard installation After framing is a complete see attached diagrams set product in place to make certain that the tub can be properly leveled Caution If a walk in bathtub is not resting on all leveling feet water will not drain properly and may cause the door to leak see page 7 e Verify the product s level by checking tub s deck surface and ensure all leveling feet are touch
13. be removed only suctions that have screws on the cover visible from the inside of the tub can be removed WARNING NEVER OPERATE THE UNIT WITH THE SAFETY SUCTION COVER OFF 00020000 00000000000 T OPERE ee rr a ecc ee oe ecc 960002000909 90009 299 0000000050000 00 000000200060 OE CORE Oe T vro up 8 TC ly y 000000000009 eee eee OPT Set OO ks OFRET cee Ov T eeseecesot Peu p M EN Perte SUCTION COVER Page 19 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com ALNVHHVM Universal kubs your doorway to independent bathing WARRANTY This 10 year bath tub warranty is extended to the first user to be free from defects in workmanship and material under normal use and conditions for a period of 10 years from the date of the original purchase This warranty relates to the bathtub shell frame and finish The finish s warranty does not apply to fading cracking delaminating or blistering due to excessive wear sun fading or scouring due to cleaning Different warranty periods apply The tub and all its components including motors electronic controls waste and overflow
14. charges in connection with removal or replacement of the door seal NOTE TO THE EXTEND PERMITTED BY LAW ALL IMPLIED WARRANTIES INCLUDING THOSE OF MERCHANT ABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE HEREBY DISCLAIMED Universal Walk In Bathtubs AND SELLER HEREBY DISCLAIM ANY LIABILITY FOR SPECIAL INCIDENTAL OR CONSEQUENTIAL DAMAGES Some states provinces do not allow limitations on how long an implied warranty lasts or the exclusion or limitation special incidental or consequential damages so these limitations and exclusions may not apply to you This warranty gives you specific legal rights You may have other rights which vary by state province All lawsuits must be filed in Florida Tub units are for residential use only Page 21 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com WARRANTY Universal kubs your doorway to independent bathing RETURN POLICY Universal Walk In Bathtubs is committed to providing premium customer service In the event that a product must be returned due to reasons other than defects as mentioned in the warranty the following procedures apply Requests for returns and or exchanges must be made within 30 days of receipt of product The product must be in its original packaging and received at Universal Walk In Bathtubs in saleable condition All returns will receive 20 restocking fee plus all
15. dependent bathing OPERATING SAFETY INSTRUCTIONS WARNING RISK OF PERSONAL INJURY Use this unit for its intended use as described in this manual DO NOT use attachments not recommended by the manufacturer To avoid injury exercise caution when entering or exiting your walk in tub To reduce the risk of injury do not permit children or persons with infirmities to use this product unless they are closely supervised at all times The maximum recommended temperature is 102 F 38 8 C Fifteen minutes per soak is the recommended maximum time at 102 F which may induce Hyperthermia which is an increase in body temperature This can be a serious medical condition and all bath users are cautioned against lengthy immersion at high water temperatures Should you become light headed dizzy or nauseous immediately get out of the bath and cool off Risk of electric shock do not permit electric appliances such as a hair dryer lamp telephone radio or television within four feet of this bathtub Never drop or insert any objects into any openings Do not operate this unit without the guard over the suction fittings WARNING RISK OF HYPERTHERMIA AND POSSIBLE DROWNING People using medications herbal remedies sleep aids and or having adverse medical history should consult a physician before using this product WARNING NO FOOD OR ALCOHOLIC BEVERAGES Use of your bathtub immediately after meals is not recommended Avoid alcohol consumptio
16. drain which allowsthe drain to be opened or closed Once the components of the overflow are secured into place turn the overflow knob tothe open and closed position to ensure proper function The cap and stem will move up and down opening and closing the drain Figure 1 lt gt Foor Drain Your walk in tub also has a door drain to remove excess water from the door after Poor Drain each use From the underside of the unit a hose is connected to the door drain with a check valve This hose and valve is to provide a one way flow from the door drain to the main drain pipe The check valve will constrict the water flow away from the door Insert the opposite end of the hose into the port on the main drain Be sure the port is open before attaching the hose Secure the hose with clamps or ties Once the hose is in place close the door on the unit place the handle in the locked posi IO Tm Correct FIGURE 2 tion and fill tub with at least 12 of water to test the connection Once the completion of the drain components are installed and have been tested for proper function the unit can be leveled and give a final water test before installation of unit Figure 2 Page 10 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com SNOILLONYLSNI 9NIIVH3d0 Universal kubs your doorway to independent bathing CONNECTING THE AUTODRAIN e System requi
17. ing the ground see page 7 e Electrical connection is made pre instruction on specified models e After plumbing and electrical connections have been made the tub should be cleaned of dirt and debris e Installation is not complete until the tub has been tested in place Page 9 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com INSTALLATION PROCEDURES SNOLLONYLSNI 9NIIVH3d0 Universal kubs your doorway to independent bathing DRAIN CONNECTION To ensure safe transit for your walk in tub the overflow drain components are not connected to the unit during the process of production The following in structions are provided for installation purposes Your walk in tub is supplied with a 1 72 drain pipe overflow The open and close valve with the turn knob should be attached to the unit at the 1 7 pre drilled opening in the wall of the unit from the outside The opposite end of the overflow should be attached to 1 1 2 Door Drain Pipe supplied the 1 72 pre drilled opening in the foot well of the unit from the underside The FIGURE 1 chrome turn knob and the drain cover should be attached to the appropriate ends of the overflow drain from the inside of the unit Place the chrome cap with stem into thefloordrainto close offthe opening The cable attached totheturn knob ofthe overflow is also connected toa lever insidethe floor
18. lt in damaging the plumbing and causing a leak Immediately inspect the unit for damage even if there is no carton damage Once the unit is installed surface damages will be assumed to be installation related if not reported at this point Please note that an installer s assumes full liability for damages to the walk in bathtub after the unit is installed in the cradle niche Page 5 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com UNPACKING Universal kubs your doorway to independent bathing PRE INSTALLATION All Walk In Bath Tubs are 100 water tested at the factory certified to be free of leaks Transportation and mishandling may cause leaks It is necessary to test the bathtub while there is access to all sides of the bathtub e Place the tub on a completely flat surface in an area where it may be drained after testing e Close the drain and fill the tub until it is above the highest jet If it s a soaker fill up to normal water height level e Allow the water to stand in tub for 30 minutes and then inspect all plumbing and seals for leaks e ftubis jetted supply electric to unit and run for 10 minutes and inspect for leaks Inspect the unions around the pump if leaks persist from the unions after tightening loosen the unions and insure the O ring is seated properly NOTE IF THE PUMPS DO NOT OPERATE CHECK THE BREAKER TO E
19. n before or during the bathing Alcoholic beverages can cause drowsiness or hyperthermia resulting in loss of consciousness or even drowning Page 14 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com SNOILLONYLSNI 9NILIVH3d0 Universal kubs your doorway to independent bathing The unit must be connected only to a supply circuit that is protected by a ground fault circuit interrupter GFCI Such a GFCI should be provided by the installer and should be tested on a routine basis To test the GFCI push the test button The GFCI should interrupt power Push the reset button Power should be restored If the GFCI fails to operate in this manner there may be a ground current flowing indicating the possibility of an electric shock Do not use this massage bathtub Disconnect the jet massage bathtub and have the problem corrected by a qualified service representative before using To reduce the risk of electrical shock the dedicated electrical supply circuit s must be grounded To do this connect the third leg of the 3 conductor wiring cable to the grounding terminal of the electrical service panel and run continuously to the green grounding screw on the or electrical receptacle in the wiring compartment Page 15 Universal Walk In Bathtubs 5701 NW 35 Avenue Miami FL 33142 PHONE 877 360 4454 FAX 866 560 1060 www universaltubs com SNOLLONYLSNI 9NIIVH3d0 U
20. niversal kubs your doorway to independent bathing OPERATING INSTRUCTIONS When entering an Universal walk in tub be sure to close the door placing the handle in the down position Before activating any of the jetting controls you must first fill the bath to a water level at least 2 inches above the highest jet placement Do not put weight on the door when entering and exiting the tub It is recommended to leave the door in the open position when the tub is not in use The pump is operated by the hydro control button which starts the water flow The blower is operated by the air control button which starts the air flow see EXAMPLE TUB DOOR HANDLE page 18 Adjust the direction and rate of flow of the jets by moving the nozzle for direction Turn either the outside ring or the nozzle clockwise or counterclockwise for flow Some jets adjust the flow with the outside ring and some with the nozzle Adjust the air pressure flow of all water jets by using the air volume control see page 18 which controls air water mixture Universal walk in tubs equipped with the chromotherapy lights ordered separately feature a dedicated on off switch Pressing the switch off and back on will change the color of light see page 18 All air blowers are equipped with a purge cycle to remove residual water from the lines The cycle will begin approximately 30 minutes after the unit is turned off and will continue for 1 2 minutes WARNI
21. res the connection to a minimum 1 1 sanitary drain line e Use UPC Approved PVC Glue primer and Schedule 40 1 pipe Do not change or modify the location and or piping of the Back Flow Preventer e The sanitary tee is installed directly above the drain tee with clearance not greater than 1 Dry fit the drain overflow assembly to the sanitary drainage pipe and check for proper fit e Glue the High Speed Autodrain Fittings pipe and drain overflow assembly to the sanitary drainage pipe NOTE WATER TIGHT INSTALLATION OF THE WASTE OVERFLOW IS THE INSTALLER S RESPONSIBILITY DRAIN LEAKAGE IS EXCLUDED FROM THE UNIVERSAL TUBS WARRANTY OF THIS PRODUCT overflow p 4 drain cable sanitary tee drain tee L VE LL drain cable back flow preventer reducer 1 1 2 1 90 Elbow s drain A air button on off 110Vt 60hz pump 15 Amp Circuit drain shoe SOAKER amp AIR AUTODRAIN CONNECTION overflow s drain cable sanitary tee drain tee D diverter valve Q air button on off back flow preventer reducer 1 1 2 1 90 Elbow T A drain cable drain A jets 110Vt 60hz pump 15 Amp Circuit Es drain shoe 4 HYDRO amp DUAL AUTODRAIN CONNECTION NOTE WE HAVE TAKEN RESPONSIBLE PRECAUTIONS TO ENSURE THE HIGH SPEED AUTODRAIN IS SUITABLE FO
22. t be installed in accordance with the National Electrical Code and with all local codes All wiring shall be done by a qualified electrician Run one two or three branch circuits as required from the main electrical service panel to the pump area of the framing structure to provide power to the unit Electrical components have specific wiring requirements Refer to the matrix below for the electrical supply requirements for the jet massage bathtub and factory installed components Branch circuits must be rated for 110 120 volts Use 12 Gauge 3 conductor cable for the circuits If the length run exceeds 100 feet check with local codes for requirements Install moisture proof junction box s 6 above the floor at the pump end of the framing for each circuit NOTE DO NOT INSTALL THE JUNCTION BOX S WHERE IT CAN BE REACHED WHILE SITTING OR STANDING IN THE TUB OR TOUCHING THE FAUCETS This section lists the factory installed components of the Jet Massage and or Air Massage Systems Electrical Rating Dedicated Circuit 1 Circuit Systems Soaker w Auto Drain Soaker w Light Soaker w Auto Drain w Light Jet Massage Or Air Massage Jet Massage Or Air Massage w Light Jet Massage Or Air Massage w Auto Drain Jet Massage Or Air Massage w Light amp Auto Drain Jet Massage amp Air Massage Dual Jet Massage amp Air Massage Dual w Light Jet Massage amp Air Massage Dual w Auto Drain Jet M
Download Pdf Manuals
Related Search