Rust-Oleum Automotive 252472 Use and Care Manual
Contents
1. 12813 Vernon Hills Illinois 60061 www rustoleum com BRANDS An RPM Company2. LNESS SUCH AS BRAIN DAMAGE ESPECIALLY IN CHILDREN PREGNANT WOMEN SHOULD ALSO AVOID EXPOSURE Wear a NIOSH approved respirator to control lead exposure Clean up carefully with a HEPA vacuum and a wet mop Before you start find out how to protect yourself and your family by contacting the National Lead Information Hotline at 1 800 424 LEAD or log on to www epa gov lead PRODUCT APPLICATION cont APPLICATION Shake can vigorously for one minute after the mixing ball begins to rattle If mixing ball fails to rattle DO NOT STRIKE CAN Contact Rust Oleum Shake often during use Hold can upright 12 16 from surface and spray in a steady back and forth motion slightly overlapping each stroke Keep the can in motion while spraying Apply 2 light coats a few minutes apart Do not use near open flame DRY and RECOAT TIMES Dry and recoat times are based on 70 F and 50 relative humidity Dries to touch in 10 minutes Allow more time in cooler temperatures When dry surface can be immediately recoated top coated or wet sanded For best results allow to dry 2 4 hours before dry sanding CLEAN UP Wipe off tip when finished Clean up wet paint with Xylol or mineral spirits Properly discard or recycle empty container Do not burn container or place it in home trash compactor CLOGGING If the valve clogs twist and pull off spray tip and rinse ina solvent such as mineral spirits Do not insert any object into can valve opening F
3. SPRAY TECHNICAL DATA ATO 36 AUTOMOTIVE LIGHT GRAY SANDABLE PRIMER DESCRIPTION AND USES Rust Oleum Light Gray Sandable Primer is designed to provide a tough rust inhibitive base for most brands of automotive lacquers and enamels Sands smooth to promote a smooth uniform topcoat finish It features an advanced spray system that allows you to spray at any angle even upside down for those hard to reach areas A comfort spray tip with wider finger pad reduces fatigue caused by continuous spraying PRODUCTS 12 oz Spray Description 252472 Light Gray Sandable Primer PRODUCT APPLICATION PAINTING CONDITIONS Use outdoors or in a well ventilated area such as an open garage Apply when temperature is between 50 90 F 10 32 C and humidity is below 85 to ensure proper drying Do not apply to surfaces that when heated exceed 200 F 93 C or galvanized metal Avoid spraying in very windy dusty conditions Cover surrounding area to protect from spray mist SURFACE PREPARATION Clean the surface of the area to be painted with a commercial detergent or other suitable cleaning method to remove all oil grease wax and dirt Rinse with fresh water and allow to thoroughly dry Remove loose paint and rust with a wire brush or sandpaper Lightly sand glossy surfaces Remove all surface dust WARNING If you scrape sand or remove old paint you may release lead dust LEAD IS TOXIC EXPOSURE TO LEAD DUST CAN CAUSE SERIOUS IL
4. orm RAC 26 Rev 012813 TECHNICAL DATA AUTOMOTIVE LIGHT GRAY SANDABLE PRIMER Physical Properties LIGHT GRAY SANDABLE PRIMER Resin Type Short Oil Alkyd Pigment Type Titanium dioxide Inorganic Red Organic Blue MIR 1 50 Max Fill Weight 12 ounce Solvents Xylene Mineral Spirits Aromatic 150 N Butyl Acetate Naphtha Acetone Recommended Dry Film 1 mil Thickness DFT Per Coat 25 microns Practical Coverage at Recommended i 10 15 sq ft can DFT assumes 15 material loss Dry Times at 77 F Tack free 10 min 25 C and 50 Relative Humidity Handle 2 hours Recoat Immediate when dry Dry Heat Resistance 200 F 93 C Shelf Life 5 years Cautions Flash Point 156 F 104 C Warning For additional Information see MSDS The technical data and suggestions for use contained herein are correct to the best of our knowledge and offered in good faith The statements of this literature do not constitute a warranty express or implied as to the performance of these products As conditions and use of our materials are beyond our control we can guarantee these products only to conform to our standards of quality and our liability if any will be limited to replacement of defective materials All technical information is subject to change without notice Ha Rust Oleum Corporation Form RAC 26 U TTOLEUM 11 Hawthorn Parkway Phone 877 385 8155 Rev 0
Download Pdf Manuals
Related Search