Rust-Oleum Specialty 210372 Use and Care Manual
Contents
1. TECHNICAL DATA SPC 01 SPECIALTY APPLIANCE EPOXY SPRAYS e TRUSTED QUALITY SINCE 1921 RUSTOLEUM SPECIALTY DESCRIPTION AND USES Appliance epoxy is a hard moisture resistant enamel that is specifically formulated for indoor metal surfaces It provides a smooth washable surface for refinishing the exterior of appliances such as refrigerators dishwashers laundry machines dryers and other indoor metal applications such as tables or cabinets Interior use only PRODUCTS SKU Description 210372 Biscuit 7881830 White 7882830 Almond 7886830 Black 7887830 Stainless Steel PAINTING CONDITIONS Use in a well ventilated area such as an open garage Not intended for continuous water immersion or for surfaces that when heated exceed 200 F 93 C Priming is not recommended Do not use on objects exposed to heat ie stovetops oven interiors etc PRODUCT APPLICATION SURFACE PREPARATION Remove all dirt grease oil salt and chemical contaminants by washing the surface with a commercial detergent or other suitable cleaning method Rinse with fresh water and allow to thoroughly dry Remove loose paint and rust with wire brush or sandpaper Lightly sand glossy surfaces Removal of old paint by sanding scraping or other means may generate dust or fumes that contain lead LEAD IS TOXIC Contact the U S EPA Lead Information Hotline at 1 800 424 LEAD pr log on to www epa gov lead PRODUCT APPLICATION co2. Form GDH 324 Rev 042114 RUSFOLEUM TNs aie act Wee PHYSICAL PROPERTIES Physical Properties APPLIANCE EPOXY SPRAYS Resin Type Epoxy Ester Modified Alkyd Pigment Type Varies with color Solvents Acetone Toluene VM amp P Naphtha Xylene MIR 1 40 Max Fill Weight 12 ounces Practical Coverage at Recommended DFT assumes 15 material loss Approximately 7 sq ft can 0 63 m can Tack Free 2 4h Dry Times at 70 80 F ours 21 27 C and 50 Handle 5 9 hours Relative Humidity Recoat Within 30 minutes or after 1 week Dry Heat Resistance 200 F 93 C Shelf Life 5 years Flash Point 156 F 104 C Safety Information For additional information see MSDS The technical data and suggestions for use contained herein are correct to the best of our knowledge and offered in good faith The statements of this literature do not constitute a warranty express or implied as to the performance of these products As conditions and use of our materials are beyond our control we can guarantee these products only to conform to our standards of quality and our liability if any will be limited to replacement of defective materials All technical information is subject to change without notice HE Rust Oleum Corporation Form GDH 324 11 Hawthorn Parkway Phone 877 385 8155 Rev 042114 Vernon Hills Illinois 60061 www rustoleum com BRANDS An RPM Company
3. nt APPLICATION Apply only when air and surface temperatures are between 50 90 F 10 32 C and the relative humidity is below 85 to ensure proper drying Avoid spraying in very windy or dusty conditions Cover surrounding area to protect from overspray Overspray can carry a significant distance Shake can vigorously for one minute after the mixing ball begins to rattle If mixing ball fails to rattle DO NOT STRIKE CAN Contact Rust Oleum Hold can upright 12 16 from surface and spray in a steady back and forth motion slightly overlapping each stroke Keep the can the same distance from the surface Keep the can in motion while spraying Apply several light coats a few minutes apart to avoid drips and runs Do not use near open flame DRY amp RECOAT Dry and recoat times are based on 70 F 21 C and 50 relative humidity Dries tack free in 2 4 hours and can be handled in 5 9 hours Recoat within 30 minutes or after 1 week CLEAN UP Clean valve immediately after use by turning can upside down and depressing spray button for 3 5 seconds some paint will be sprayed out so be careful to not inadvertently spray yourself or other objects Clean up wet paint with xylene or mineral spirits Throw away empty can in trash pick up Do not burn or place in home trash compactor CLOGGING If the valve clogs twist and pull off spray tip and rinse ina solvent such as mineral spirits Do not insert any object into can valve opening
Download Pdf Manuals
Related Search