Moldex 4030 Use and Care Manual
Contents
1. contact Eye contact Ingestion Most important symptoms effects acute and delayed Not applicable to consumer products This product is regulated by the CCCR Consumer Chemicals and Containers Regulations 2001 amp the CPSC Consumer Product Safety Commission 4 First Aid Measures If breathing is difficult remove to fresh air and keep at rest in a position comfortable for breathing Call a physician if symptoms develop or persist Take off contaminated clothing and wash before reuse Wash with plenty of soap and water Wash off with soap and water If skin irritation occurs Get medical advice attention Immediately flush eyes with plenty of water for at least 15 minutes Remove contact lenses if present and easy to do Continue rinsing Get medical attention if irritation develops and persists Rinse mouth If ingestion of a large amount does occur call a poison control center immediately Symptoms may include stinging tearing redness swelling and blurred vision Skin irritation May cause redness and pain 24455 Page 1 of 7 Issue date 29 May 2015 Indication of immediate medical attention and special treatment needed General information Suitable extinguishing media Unsuitable extinguishing media Specific hazards arising from the chemical Special protective equipment and precautions for firefighters Fire fighting equipment instructions Specific methods General fire hazards Hazardous combu2. Product identifier Other means of identification Recommended use Recommended restrictions Manufacturer Physical hazards Health hazards Environmental hazards OSHA defined hazards Label elements Hazard symbol Signal word Hazard statement Precautionary statement Prevention Response Storage Disposal Hazard s not otherwise classified HNOC Supplemental information SAFETY DATA SHEET 1 Product and Company Identification Moldex Patio Furniture Cleaner Water Based General Cleaner amp Stain Remover None known EnviroCare Corporation 10 Upton Drive Wilmington MA 01887 US Phone 1 978 658 0123 Emergency Phone CHEMTREC US Canada 1 800 424 9300 Intl Maritime 1 703 527 3887 2 Hazards Identification Not classified Not classified Not classified Not classified None Not available Not available Avoid contact with eyes Follow good hygienic and housekeeping practices Follow the directions for use Specific treatment see product label Wash hands after handling Store according to package label instructions Store away from incompatible materials Dispose of waste and residues in accordance with local authority requirements None known Not applicable 3 Composition Information on Ingredients Mixture Chemical name Common name and synonyms CAS number Hydrogen peroxide 7722 84 1 1 5 Lauryldimethylamine oxide 1643 20 5 0 1 1 Composition comments Inhalation Skin
3. apor density Relative density Solubility ies Auto ignition temperature Decomposition temperature Viscosity Not available Not available Not available Not available Not available Not available Not available Not available Not available Not available Not available 24455 Page 3 of 7 Issue date 29 May 2015 Other information VOC Weight 0 10 Stability and Reactivity Reactivity May react with incompatible materials Possibility of hazardous Hazardous polymerization does not occur reactions Chemical stability Material is stable under normal conditions Conditions to avoid Contact with incompatible materials Incompatible materials Strong oxidizing agents Hazardous decomposition May include and are not limited to Oxides of carbon Oxides of nitrogen products 11 Toxicological Information Routes of exposure Inhalation Ingestion Skin contact Eye contact Information on likely routes of exposure Ingestion May cause stomach distress nausea or vomiting Inhalation May cause irritation to the respiratory system Skin contact Prolonged skin contact may cause skin irritation Frequent or prolonged contact may defat and dry the skin leading to discomfort and dermatitis Eye contact Direct contact with eyes may cause temporary irritation Sympioms related to the Symptoms may include stinging tearing redness swelling and blurred vision physical chemical and Symptoms may include redness drying defat
4. ated SDWA Food and Drug Not regulated Administration FDA US state regulations California Safe Drinking Water and Toxic Enforcement Act of 1986 Proposition 65 This material is not known to contain any chemicals currently listed as carcinogens or reproductive toxins US California Hazardous Substances Director s Listed substance Hydrogen peroxide CAS 7722 84 1 Listed US California Proposition 65 Carcinogens amp Reproductive Toxicity CRT Listed substance Not listed US Illinois Chemical Safety Act Listed substance Hydrogen peroxide CAS 7722 84 1 Listed US Minnesota Haz Subs Listed substance Hydrogen peroxide CAS 7722 84 1 Listed US New Jersey RTK Substances Listed substance Hydrogen peroxide CAS 7722 84 1 Listed US New York Release Reporting Hazardous Substances Listed substance Hydrogen peroxide CAS 7722 84 1 Listed US Texas Effects Screening Levels Listed substance Hydrogen peroxide CAS 7722 84 1 Listed Lauryldimethylamine oxide CAS 1643 20 5 Listed 24455 Page 6 of 7 Issue date 29 May 2015 US Massachusetts RTK Substance List Hydrogen peroxide CAS 7722 84 1 Listed US Pennsylvania RTK Hazardous Substances Hydrogen peroxide CAS 7722 84 1 Listed US Rhode Island RTK Hydrogen peroxide CAS 7722 84 1 Listed Inventory status Country s or region Inventory name On inventory yes no Canada Domestic Substances List DSL Yes Canada Non Domestic Substances L
5. de CAS 7722 84 1 Biological limit values Exposure guidelines Appropriate engineering controls Individual protection measures such as personal protective equipment Wear gear as deemed necessary Follow label directions Eye face protection Skin protection Hand protection Other Respiratory protection Thermal hazards General hygiene considerations Appearance Physical state Form Color Odor Odor threshold pH Melting point freezing point Initial boiling point and boiling range Pour point Specific gravity Partition coefficient n octanol water Flash point Evaporation rate Flammability Solid gas Type TWA No biological exposure limits noted for the ingredient s Chemicals listed in section 3 that are not listed here do not have established limit values for ACGIH or OSHA PEL Ensure adequate ventilation Follow label instructions Follow label instructions Follow label instructions Not available Follow good hygienic and housekeeping practices 9 Physical and Chemical Properties Liquid Liquid Liquid Colorless Minimal to none Not available 4 5 Not available 212 F 100 C Not available 1 1 1 8 38lb ga Not available None will not ignite Not available Not applicable Upper lower flammability or explosive limits Flammability limit lower Flammability limit upper Explosive limit lower Explosive limit upper Vapor pressure V
6. es should be advised if significant spillages cannot be contained For personal protection see section 8 of the SDS Stop the flow of material if this is without risk Large Spills Dike the spilled material where this is possible Cover with plastic sheet to prevent spreading Absorb in vermiculite dry sand or earth and place into containers Prevent entry into waterways sewer basements or confined areas Following product recovery flush area with water Small Spills Wipe up with absorbent material e g cloth fleece Clean surface thoroughly to remove residual contamination Never return spills to original containers for re use For waste disposal see section 13 of the SDS Do not discharge into lakes streams ponds or public waters 7 Handling and Storage Avoid contact with eyes skin and clothing Practice good housekeeping Use with adequate ventilation Use care in handling storage Wear appropriate personal protective equipment Store away from incompatible materials see Section 10 of the SDS 8 Exposure Controls Personal Protection US OSHA Table Z 1 Limits for Air Contaminants 29 CFR 1910 1000 Components Hydrogen peroxide CAS 7722 84 1 Type Value PEL 1 4 mg m3 1 ppm 24455 Page 2 of 7 Issue date 29 May 2015 US ACGIH Threshold Limit Values Components Type Hydrogen peroxide CAS 7722 84 1 TWA US NIOSH Pocket Guide to Chemical Hazards Components Hydrogen peroxi
7. fects e g ozone depletion photochemical ozone creation potential endocrine disruption global warming potential are expected from this component 13 Disposal Considerations Collect and reclaim or dispose in sealed containers at licensed waste disposal site Dispose of contents container in accordance with local regional national international regulations Dispose in accordance with all applicable regulations The waste code should be assigned in discussion between the user the producer and the waste disposal company Dispose of in accordance with local regulations Empty containers or liners may retain some product residues This material and its container must be disposed of in a safe manner see Disposal instructions Empty containers should be taken to an approved waste handling site for recycling or disposal Since emptied containers may retain product residue follow label warnings even after container is emptied 14 Transport Information U S Department of Transportation DOT Not regulated as dangerous goods Transportation of Dangerous Goods TDG Canada Not regulated as dangerous goods 24455 Page 5 of 7 Issue date 29 May 2015 15 Regulatory Information Canadian federal regulations This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the SDS contains all the information required by the Controlled Products Regulations Per the HPA Part Il Secti
8. ist NDSL No United States amp Puerto Rico Toxic Substances Control Act TSCA Inventory Yes A Yes indicates that all components of this product comply with the inventory requirements administered by the governing country s 16 Other Information Da Severe FLAMMABILITY Serious Moderate Slight Minimal PROTECTION PERSONAL Disclaimer The information in the sheet was written based on the best knowledge and experience currently available Information contained herein was obtained from sources considered technically accurate and reliable While every effort has been made to ensure full disclosure of product hazards in some cases data is not available and is so stated Since conditions of actual product use are beyond control of the supplier it is assumed that users of this material have been fully trained according to the requirements of all applicable legislation and regulatory instruments No warranty expressed or implied is made and supplier will not be liable for any losses injuries or consequential damages which may result from the use of or reliance on any information contained in this document Issue date 29 May 2015 Effective date 31 May 2015 Expiry date 31 May 2018 Further information For an updated SDS please contact the supplier manufacturer listed on the first page of the document Prepared by Dell Tech Laboratories Ltd Phone 519 858 5021 Other information This Safety Data Sheet was prepared to comply
9. nknown relevance to humans IARC Monographs Overall Evaluation of Carcinogenicity Hydrogen peroxide CAS 7722 84 1 Reproductive toxicity Teratogenicity Specific target organ toxicity single exposure Specific target organ toxicity repeated exposure Aspiration hazard Chronic effects Further information Name of Toxicologically Synergistic Products Volume 36 Supplement 7 Volume 71 3 Not classifiable as to carcinogenicity to humans This product is not expected to cause reproductive or developmental effects Not classified Not classified Not classified Not classified Not classified Not available Not available 12 Ecological Information Ecotoxicity The product is not classified as environmentally hazardous However this does not exclude the possibility that large or frequent spills can have a harmful or damaging effect on the environment See below Components Species Test Results Hydrogen peroxide CAS 7722 84 1 Algae IC50 Algae 2 5 mg L 72 Hours Crustacea EC50 Daphnia 7 7 mg L 48 Hours Persistence and degradability Bioaccumulative potential Mobility in soil Mobility in general Other adverse effects Disposal instructions Local disposal regulations Hazardous waste code Waste from residues unused products Contaminated packaging No data is available on the degradability of this product No data available No data available Not available No other adverse environmental ef
10. on 12 f an SDS is not required for this consumer product Canada WHMIS Ingredient Disclosure Threshold limits Hydrogen peroxide CAS 7722 84 1 1 Lauryldimethylamine oxide CAS 1643 20 5 1 WHMIS status Exempt WHMIS classification Exempt Consumer product US federal regulations This product is a Hazardous Chemical as defined by the OSHA Hazard Communication Standard 29 CFR 1910 1200 US EPCRA SARA Title III Section 302 Extremely Hazardous Spill Reportable quantity Hydrogen peroxide CAS 7722 84 1 1000 LBS US EPCRA SARA Title III Section 302 Extremely Hazardous Substance Threshold Planning Quantity Hydrogen peroxide CAS 7722 84 1 1000 LBS TSCA Section 12 b Export Notification 40 CFR 707 Subpt D Not regulated CERCLA Hazardous Substance List 40 CFR 302 4 Not listed Clean Air Act CAA Section 112 r Accidental Release Prevention 40 CFR 68 130 Not regulated Clean Air Act CAA Section 112 Hazardous Air Pollutants HAPs List Not regulated US CAA Section 612 SNAP Program Listed substance Hydrogen peroxide CAS 7722 84 1 Listed Superfund Amendments and Reauthorization Act of 1986 SARA Hazard categories Immediate Hazard Yes Delayed Hazard No Fire Hazard No Pressure Hazard No Reactivity Hazard No SARA 302 Extremely No hazardous substance SARA 311 312 Hazardous No chemical SARA 313 TRI reporting Not regulated Other federal regulations Safe Drinking Water Act Not regul
11. stion products Explosion data Sensitivity to mechanical impact Sensitivity to static discharge Personal precautions protective equipment and emergency procedures Methods and materials for containment and cleaning up Environmental precautions Precautions for safe handling Conditions for safe storage including any incompatibilities Occupational exposure limits Provide general supportive measures and treat symptomatically Keep victim under observation Symptoms may be delayed Ensure that medical personnel are aware of the material s involved and take precautions to protect themselves 5 Fire Fighting Measures Water fog Foam Dry chemical powder Carbon dioxide CO2 Not available During fire gases hazardous to health may be formed Self contained breathing apparatus and full protective clothing must be worn in case of fire Move containers from fire area if you can do so without risk Use standard firefighting procedures and consider the hazards of other involved materials No unusual fire or explosion hazards noted Not available Not available Not available 6 Accidental Release Measures Keep unnecessary personnel away Keep out of low areas Keep people away from and upwind of spill leak Wear appropriate protective equipment and clothing during clean up Do not touch damaged containers or spilled material unless wearing appropriate protective clothing Ensure adequate ventilation Local authoriti
12. ting and cracking of the skin toxicological characteristics Information on toxicological effects Acute toxicity Components Species Test Results Hydrogen peroxide CAS 7722 84 1 Acute Dermal LD50 Rabbit 2000 mg kg Rat 2000 mg kg Inhalation LC50 Not available Oral LD50 Mouse 2000 mg kg Rat 75 mg kg Lauryldimethylamine oxide CAS 1643 20 5 Acute Inhalation LC50 Rat 5300 mg l 4h Oral LD50 Rat gt 20000 mg kg Skin corrosion irritation May cause irritation Exposure minutes Not available Erythema value Not available Oedema value Not available Serious eye damage eye Direct contact with eyes may cause temporary irritation irritation Corneal opacity value Not available Iris lesion value Not available Conjunctival reddening Not available value Conjunctival oedema value Not available Recover days Not available 24455 Page 4 of 7 Issue date 29 May 2015 Respiratory or skin sensitization Respiratory sensitization Skin sensitization Germ cell mutagenicity Mutagenicity Carcinogenicity ACGIH Carcinogens Hydrogen peroxide CAS 7722 84 1 Not available Not classified No data available to indicate product or any components present at greater than 0 1 are mutagenic or genotoxic No data available to indicate product or any components present at greater than 0 1 are mutagenic or genotoxic This product is not considered to be a carcinogen by IARC ACGIH NTP or OSHA A3 Confirmed animal carcinogen with u
13. with the current OSHA Hazard Communication Standard HCS adoption of the Globally Harmonized System of Classification and Labeling of Chemicals GHS This SDS conforms to the ANSI Z400 1 Z129 1 2010 Standard 24455 Page 7 of 7 Issue date 29 May 2015
Download Pdf Manuals
Related Search