Rust-Oleum Stops Rust 7785830 Use and Care Manual
Contents
1. TECHNICAL DATA SRT 13 TRUSTED QUALITY SINCE 1921 RUST OLEUM HGA DESCRIPTION AND USES Rust Oleum Stops Rust Cold Galvanizing Spray provides maximum corrosion resistance through galvanic protection Use for touch up and repair to damaged galvanized steel galvanized ducts fences gutters trucks trailers and more Do not topcoat with an alkyd finish PRODUCTS SKU 16 ounce spray Description 7785830 Galvanizing Compound PRODUCT APPLICATION PAINTING CONDITIONS Use outdoors or in a well ventilated area such as an open garage Apply when temperature is between 50 90 F 10 32 C and humidity is below 65 to ensure proper drying Do not apply to surfaces when heated exceed 200 F 93 C Avoid spraying in very windy and dusty conditions Cover surrounding area to protect from spray mist SURFACE PREPARATION Remove all dirt grease oil salt and chemical contaminants by washing the surface with a commercial detergent or other suitable cleaning method Rinse with fresh water and allow to thoroughly dry Remove loose paint and rust with a wire brush or sandpaper WARNING If you scrape sand or remove old paint from any surface you may release lead paint dust LEAD IS TOXIC EXPOSURE TO LEAD DUST CAN CAUSE SERIOUS ILLNESS SUCH AS BRAIN DAMAGE ESPECIALLY IN CHILDREN PREGNANT WOMEN SHOULD ALSO AVOID EXPOSURE Wear a NIOSH approved respirator to control lead exposure Clean up carefully with2. LEUM HEDA STOPS RUST COLD GALVANIZING SPRAY PHYSICAL PROPERTIES COLD GALVANIZING SPRAY Resin Type Epoxy Easter Pigment Type Metallic Zinc MIR 1 2 Max Fill Weight 16 ounces Solvents Acetone Toluene Xylene Recommended Dry Film Thickness DFT Per Coat 1 0 2 0 mils 25 50u Practical Coverage at Recommended DFT 8 12 sq ft can 0 74 1 10 m Dry Times at Touch 15 minutes 70 F 21 C and 50 Relative mene 1 2 hours Humidity Recoat Within 1 hour or after 24 hours Fully Dry 24 hours Dry Heat Resistance 200 F 93 C Shelf Life 5 years Flash Point 156 F 104 C Safety Information For additional information see MSDS The technical data and suggestions for use contained herein are correct to the best of our knowledge and offered in good faith The statements of this literature do not constitute a warranty express or implied as to the performance of these products As conditions and use of our materials are beyond our control we can guarantee these products only to conform to our standards of quality and our liability if any will be limited to replacement of defective materials All technical information is subject to change without notice rT Rust Oleum Corporation Form CS2211 mE RU ST O L E U M 11 Hawthorn Parkway Phone 877 385 8155 Rev 030513 Vernon Hills Illinois 60061 www rustoleum com BRANDS
3. a HEPA vacuum and a wet mop Before you start find out how to protect yourself and your family by contacting the National Lead Information Hotline at 1 800 424 LEAD or log on to www epa gov lead STOPS RUST COLD GALVANIZING SPRAY PRODUCT APPLICATION APPLICATION Shake can vigorously for one minute after the mixing ball begins to rattle If mixing ball fails to rattle DO NOT STRIKE CAN Contact Rust Oleum Shake often during use Hold can upright 10 16 from surface and spray ina steady back and forth motion slightly overlapping each stroke Keep the can the same distance from the surface Keep the can in motion while spraying Apply two or more light coats a few minutes apart to avoid drips and runs Do not use near open flame DRY amp RECOAT Dry and recoat times are based on 70 F and 50 relative humidity Allow more time at cooler temperatures Dries to touch in 15 minutes to handle in 1 2 hours and fully dry in 24 hours If a topcoat is desired use a latex coating CLEAN UP Clean valve immediately after use by turning can upside down and depressing spray button for 3 5 seconds Clean up wet paint with xylene or mineral spirits Properly discard empty container Do not burn or place in home trash compactor CLOGGING If the valve clogs twist and pull off spray tip and rinse ina solvent such as mineral spirits Do not insert any object into can valve opening Form CS2211 Rev 030513 TECHNICAL DATA RUSTO
Download Pdf Manuals
Related Search