Zanussi ZK 20/6 R (ZLKF 261) User's Manual
Contents
1.2. 12 Adjustable feet 13 Butter compartment 14 Egg tray 15 Door shelf 16 Door gasket 17 Bottle shelf 18 Ice tray 19 Condenser 20 Defrost water outlet tube 21 Spacer 22 Evaporative tray 23 Compressor 24 Rollers In figures the ZLKF 301 appliance can be seen 23 lt gt Indicating switch To use the yellow indicating switch placed in the cover frame can be necessary in two cases 1 Push the switch it will move outwards and the indicator lamp will give light when the ambient temperature goes beyond 16 C The switch operates a heater which ensures that the necessary 18 C storing temperature can be used This is effective to an ambient temperature limit of 10 C 2 To reach higher freezing capacity from kg 24h 12 kg 24h to 18 kg 24h see chapter Freezing Handling the appliance Putting it into use Place the accessories into the appliance then plug to the mains socket To start cooling turn the thermostatic control knob on the right hand side of the compartment from clockwise In O position the appliance is out of operation The next paragraph will give instructions for setting Controlling the temperature setting The thermostatic controller interrupts the operation of the appliance automa
3. Following operations to be done on the basis of figures and explanations e Break the circuit of the appliance Tilt back the appliance carefully being careful so that the compressor cannot touch the floor It is recommended to ask another person for help who can keep the appliance at this position safely e Remove carefully e g with a knife the covering nails of screws fixing the bottom cover grid then the cover grid can be removed by unscrewing the plate screws 2 pieces e Dismount the bottom door holder of the freezer by removing the screws 2 pieces and the fill plates 2 pieces Take off the door of the freezer by pulling it slightly downwards e Dismount the double door holder by removing the screws 2 pieces and the fill plates 2 pieces Take off the door of the refrigerator by pulling it slightly downwards e Unscrew the top door holding pin of the refrigerator then screw it back on the other side e Remove the covering nails of the double door holder on the left side and put them to the other side e Fit the door of the refrigerator to the top door holding pin e Fix the double door holder onto the left side using the screws 2 pieces and fill plates 2 pieces Be careful that the door edge of the refrigerator is parallel with the edge of the mantle e Fit the door of the freezer to the double door holding pin e Fix the bottom door holder onto the left side using the scr
4. official designation of the appliance is refrigerator freezer combination with one motor compressor and freezer placed in the lower part The appliance has besides the general services a freezer with its own door and is completely separated from the other unit According to this the appliance is suitable for storing frozen and deep frozen food freezing products in quantity given in the user s instructions at home and making ice The appliance can meet the requirements of standards between different temperature limits according to the climate class The letter symbol for climate class can be found on the data label Description of the appliance main parts VA oi Ws a A _ IN 5 a Qc fr a 3 G He OOOO A Refrigerator B Freezer Cover frame with indicating switch Lighting box Wire shelf Defrost water collector Glass shelf Vegetable boxes Data label Freezing compartment Storing compartments Defrost water outlet Bottom cover grid Oyo Ob
5. Weight kg 65 58 Number of compressors 1 Installing the appliance Transportation unpacking 1 is recommended to deliver the appliance in original packaging vertical position considering the protective warning on packaging After each transportation the appliance must not be switched on for approx 2 hours Unpack the appliance and check if there are damages on it Report possible damages immediately to the place you bought it In that case retain packaging Cleaning Remove every adhesive tape which ensure the parts not to move in the appliance Wash the inside of the appliance using lukewarm water and mild detergent Use soft cloth After cleaning wipe out the inside of the appliance 1 Placement The ambient temperature has an effect on the energy consumption and proper operation of the appliance When placing take into consideration that it is practical to operate the appliance between ambient temperature limits according to the climate class that is given in the chart below and can be found in the data label Class of climate SN N ST Ambient temperature 10 32 C 16 32 18 38 If the ambient temperature goes below the lower data the temperature of the cooling compartment can go beyond the prescribed temperature If the ambient temperature goes beyond the upper data this means longer operating time of the compressor breakdown
6. lt x S x S x DS OK x OK x OK K x x x x x x 2 lt X x X x lt x OK X X X X x x x X DK x x x x x gt lt gt lt x x x x cling film Quickly rotting fruits strawberry raspberry etc cling film Other fruits cling film Tinned fruits opened dish covered Cakes filled with cream Notation X usual storage time x possible storage time concerns to really fresh product only 34 gt lt gt lt lt gt lt gt lt gt lt x gt lt gt lt gt lt x x gt lt dish covered Warranty and service Guarantee conditions Service and spare parts If calling the service is unavoidable announce the trouble at a brand mark service nearest to your place When announcing the appliance has to be identified according to its data label The data label of the appliance is stuck to the wall of the interior beside the vegetable box in the fresh food compartment in the bottom on the left side All necessary data are there which are needed to the service announcement type model serial number etc Note here the data from the data label of your appliance Model Product No Serial No Date of purchase The manufacturer reserves the right to make any changes in the products 90 20 2002 Aq
7. Regular cleaning It is recommended to wash the inside of the refrigerator in 3 4 weeks time using lukewarm water then wipe it it is practical to clean the inside of the freezer and defrost it at a time Household cleaner or soap must not be used After breaking the circuit wash the appliance with lukewarm water then wipe it Clean the door gasket with clean water After cleaning apply voltage to the appliance It is recommended to remove the dust and dirt collected on the back of the refrigerator and the condenser and to clean the evaporative tray on top of the compressor once or twice a year When the refrigerator is not in use In case the appliance will not be used for a long time follow these steps Break the circuit of the appliance Remove foods from the refrigerator Defrost and clean it as written before Leave the door open to avoid a build up of air inside Trouble shooting How to change the bulb Should the light fail to work you can change it as below Break the circuit of the appliance Unscrew the plate screw fixing the lamp cover then lt take the lamp cover off in the direction of arrow and the bulb can be changed Type of the bulb Mignon 322 230 V 15 W 14 thread After changing bulb replace the lamp cover screw the plate screw and apply voltage to the appliance iw The lack of light does not influence operation of the refrigerator If something does not
8. 23 Description of the appliance 23 24 Handling 24 24 Controlling the temperature 24 How to use the 25 Storing the refrigerator cece cece 25 Storage time and temperature Of fOOdS 25 How to 26 A E E 26 26 How to make ice CUBES bs abve nicer va sitareesidastnattagerabzaaetenea AEE EEAS a obs 26 Some useful information 26 27 How to save energy mates 27 The appliance and environment 27 Mantenan GE NN dates 27 2 a eraa 27 Regalar rerien a EE EEE EE EEE A A 28 When the refrigerator
9. ZANUSSI FRIGRORIFICO CONGELADOR COMBINADO REFRIGERATOR FREEZER COMBINATION ZK 20 6 ZLKF 261 ZK 20 10 2 301 MANUAL DE INSTRUCCIONES INSTRUCTION BOOK lt gt 1371854 SP ZA 11 1 02 lt gt Before installing and using the appliance read this user s instruction book carefully It contains safety precautions hints information and ideas If the refrigerator is used in compliance with the instructions written it will operate properly and provide you with greatest satisfaction The symbols below help you to find things more easily Safety precautions Warnings and information at this symbol serve safety for you and your appliance i Hints useful information Environmental information Symbol for ideas At this symbol ideas can be found according to food and its storing 20 Contents Important safety information rete enn ee 22 General safety et ee aA 22 for Child Salet 22 Safety precautions for installation 22 Instructions for the cue es Pak 23
10. companies that are qualified to do so by the manufacturer must carry out service and repairs including repairing and changing the power cord Accessory parts supplied by them should be used only for repairing Otherwise the appliance can be damaged or can cause other damage or injury The appliance is out of circuit only in that case if the plug is removed from the socket Before cleaning and maintenance always unplug it do not get it by the cable If the socket is difficult to reach switch off the appliance by cutting off the current Power cord must not be lengthened Without the lamp cover of interior lighting you must not operate the appliance When cleaning defrosting taking out frozen food or ice tray do not use sharp pointed or hard devices as they can cause damage to the appliance Be careful not to allow liquids to the temperature control and lighting box Ice and ice cream can cause hurt if they are eaten immediately after removal from the frozen food compartment After dissolving frozen food must not be refrozen it must be used up as soon as possible Store pre packed frozen food in accordance with the frozen food manufacturer s instructions You must not make defrosting faster with any electric heating appliance or chemicals Do not put hot pot to the plastic parts Do not store flammable gas and liquid in the appliance because they may explode Do not store carbonated drinks bottled drinks and b
11. the automatic defrosting increasing temperature in the cooling compartment or increasing energy consumption 31 lt gt When placing the appliance ensure that it stands level This can be achieved by two adjustable feet 1 at the bottom in front 1 1 piece of distance washer 2 are accessories of the adjustable feet If levelling the appliance requires these washers can be removed Do not stand the appliance on a sunny place or close to a radiator or cooker If it is unavoidable because of furnishing and the appliance has to be stood near a cooker take these minimum distances into consideration e Incase of gas or electric cooker 3 cm must be left when it is less put a 0 5 1 cm non flam insulation between the two appliances e case of oil or coal fired stove the distance must be 30 cms since they give off more heat The refrigerator is designed to operate when it is totally pushed to the wall When the refrigerator keep minimal distances recommended in figure placing it under wall cupboard placing it freely Change of door opening direction Should the setting up place or handling demand it door opening direction can be refitted from right handed to left handed Appliances on the market are right handed In figure the ZLKF 301 appliance can be seen but the refitting is completely the same at the other ZLKF 261 appliance 32
12. the quantity to be frozen into the freezing compartment max 3 kg 1 3 Operate the appliance in this position for 24 hours 1 4 After 24 hours reset the thermostatic knob to a position adequate for you or leave it in position 3 which generally meets the requirements of everyday cooling Replace the frozen products into the wire basket ZLKF 261 or baskets ZLKF 301 in the storing compartment 2 If the quantity to be frozen is between 3 12 and 18 kg using maximum freezing capacity 2 1 Push the indicating switch it moves outwards and the indicator lamp gives light and put the quantity to be frozen into the freezing compartment max 12 or 18 kg 2 2 Operate the appliance in this position for 24 hours 2 3 After 24 hours turn off the indicating switch push it and the lamp will go out and replace the frozen products into the wire basket ZLKF 261 or baskets ZLKF 301 in the storing compartment 1 Never freeze food in bigger quantity than given in the Technical at the same time otherwise freezing will not be thorough and after dissolving various deterioration may take place losing taste and aroma lysing etc i Do not make ice during freezing preferably because making ice reduces freezing capacity Storing in the freezer It is practical to replace frozen products into the wire basket s after freezing has finished Doing this you could make room in the freezing compartment for another
13. Cooked meat dish covered Roasted meat gt lt gt lt gt lt dish covered Raw minced meat dish covered Roasted minced meat dish covered Cold cuts Vienna sausage cling film cellophane grease proof pape Fresh fish cling film airtight Cooked fish dish covered Fried fish dish covered Tinned fish open dish covered Fresh chicken cling film airtight Fried chicken dish covered Fresh hen cling film airtight Boiled hen dish covered Fresh duck goose cling film airtight Roasted duck goose dish covered Butter unopened original packaging Butter opened original packaging Milk in a plastic bag x x OK xX gt x gt x xX x x original packaging Cream plastic box Sour cream plastic box Cheese hard aluminium foil Cheese soft cling film Curds cling film Egg x x lt x Spinach sorrel cling film Green peas green beans cling film Mushroom cling film Carrot roots cling film Bell pepper cling film Tomato cling film Cabbage gt lt gt lt X lt lt X S X X X X X X X gt lt X X X X X X X X X X X lt gt lt lt X lt X lt X DK S gt lt X X X DK lt OK lt gt lt X X X S x S x lt gt lt
14. cessories to the appliance When ice coating is so thick that it can not be removed with the plastic scraper the cooling plates have to be defrosted Frequency of defrosting depends on usage generally 2 3 times a year Take the frozen foods out of the appliance and put them into a basket lined with paper or cloth Store them in a possibly cool place or replace them into another refrigerator Pull out the mains plug from the mains socket so both parts of the appliance are out of operation Open the doors of both parts of the appliance and clean the refrigerator according to Regular cleaning Maintain and clean the freezer as following Sweep off the melting water with a cloth or sponge in direction of sides of the cooling plates The melting water swept down gathers in the outlet channel practically formed in the bottom of the appliance and can be removed according to figure Put an adequately high bowl or dish under the outlet The bowl in figure is not a piece of accessories to the appliance Wipe the surfaces after defrosting and leading the water out Put the mains plug into the mains socket and put foods taken out back to their places It is recommended to operate the appliance at the highest position of the thermostatic control for some hours so that it can reach the sufficient storing temperature as soon as possible 28 ARE TAP N lt ES Lath
15. eck the temperature again Place the products in a way so that cold air could circulate among them Water flows at the back plate of the refrigerator Water flows into the chamber Water flows onto the floor It is normal During automatic defrosting frost melts on the back plate The outlet of the chamber can be clogged up Products placed in can prevent water from flowing into the collector The melting water outlet flows not into the evaporative tray above the compressor Clean the outlet Replace the products so that they can not touch the back plate directly Put the melting water outlet to the evaporative tray There are too much frost and ice Products are not wrapped properly Doors are not shut properly or do not close tightly The thermostatic control can be set wrongly Wrap the products better Check if the doors close well and the gaskets are unhurt and clean Set the thermostat knob to a position that gives higher temperature The compressor operates continually The thermostatic control is set wrongly Doors are not shut properly or do not close tightly Products in big quantity to be frozen were put in Too warm food was put in The appliance is in too warm place Set the thermostat knob to a position that gives higher temperature Check if the doors close well and the gaskets are unhurt and clean Wait some hours and then check the temperature agai
16. ews 2 pieces and fill plates 2 pieces Be careful that the door edge of the freezer is parallel with the edge of the mantle e Pull out the cover element of the cover grid in the direction of arrow 1 and place it and contrary side 2 e Put the cover grid back and fix it with the plate screws 2 pieces then put the covering nails back e Put the appliance to its place set it level and apply voltage to it In case you do not want to perform the procedures above call the nearest brand mark service Technicians will accomplish the refitting expertly for charge Electrical connection This refrigerator is designed to operate ona 230 V AC 50 Hz supply The plug must be put into a socket with protective contact If there is no such it is recommended to get an electrician to fit an earthed socket in compliance with standards near the refrigerator This appliance complies with the following E E C Directives 73 23 EEC of 19 02 73 Low Voltage Directive and subsequent modifications 89 336 EEC of 03 05 89 Electromagnetic Compatibility Directive and subsequent modifications 33 lt gt Storage time chart Time and method of storage of fresh foods in the refrigerator Storage time in days 3 4 5 Method of packaging Raw meat cling film airtight
17. freezing Intermediate freezing does not deteriorate foods already stored 2 Do not forget to keep to the storage time given on the packaging of frozen products if you buy them frozen To store home frozen products see the storing instructions placed in the door of the freezer Symbols signify the various foods numbers mean maximum storing time given in months 26 Gi is safe to store quick frozen frozen foods only if they have not dissolved even for a short time until placing them into the freezer If the deep frozen food has already dissolved refreezing is not recommended it has to be used up as soon as possible How to make ice cubes To make ice cubes fill the enclosed ice cube tray with water and put it to the frozen food compartment Wetting the bottom of the tray and setting thermostatic control knob to maximum position can shorten preparing time After finishing do not forget to reset the thermostatic control to the suitable position Ready ice cubes can be taken out of the tray under running water then twist or hit it If the ice tray freezes to the compartment avoid using metal tools or knife to take it out as the cooling system can be damaged 1 Some useful information and advice e The variable shelves are worth paying attention to which increases the usability of the fresh food compartment considerably Rearranging the shelves is also possible when the door is open at an angle of 90 e After o
18. grease proof paper or cling film before placing them into the refrigerator This way foods will keep their moisture e g vegetables will not dry out after some days Storing in the refrigerator When placing the different kinds of food take into consideration the sketch below in figure 1 Confectionery ready cooked foods foods in dishes fresh meat cold cuts drinks Milk dairy products foods in dishes Fruits vegetables salads Cheese butter Eggs Yoghurt sour cream Small bottles soft drinks Big bottles drinks 7 Storage time and temperature of foods The storage time chart at the end of the instruction book gives information about storage time The storage time can not be determined exactly in advance as it depends on the freshness and handling of the cooled food That is why the storage time made known is only informative If you do not want to use up deep frozen foods bought immediately they can be stored for about 1 day until dissolving in the refrigerator 25 lt gt How to use the freezer Freezing Freezing different products should always be done in the freezing compartment or rather on its cooling plate after proper preparing Depending on quantity to be frozen the freezing procedure can be the following 1 If the quantity to be frozen is not more than 3 kg 1 1 Set the thermostat knob to position 3 1 2
19. iS 28 Trouble SHOOLING a 28 How Change the 28 If Something WOFK 28 Instructions for the 1 1 29 TECHNICAL 29 Installing the appliance 29 Transportation UNPAaCkiNG 29 29 A abe eect esa 29 Change of door Opening direction sss 30 Electrical CONMECHON 31 Storage time thair 32 Warranty and sevite 33 Guarantee COOS a 33 Service and Spare seu iala iaaea Tea oi 33 21 lt gt Important safety information N General safety precautions Keep these instructions and they should remain at the appliance when moving away or changing owner This appliance is designed for storing food domestic use according to these instructions only Specialised
20. n Put food at max room temperature Try to reduce the temperature in the room where the appliance stands The appliance does not work at all Neither cooling lighting works Indicator lamps do not give light The appliance is noisy Plug is not connected to the mains socket properly The fuse burnt out The thermostatic control is not on There is no voltage in the mains socket Try to connect another appliance into it The appliance is not supported properly Connect the mains plug properly Change the fuse Start the appliance according to instructions in chapter Putting it into use Call an electrician Check if the appliance stands stable all the four feet should be on the floor Inasmuch as the advice does not lead to result call the nearest brand mark service 30 lt gt Instructions for the Installer Technical data Model Type ZK 20 10 R ZLKF 301 ZK 20 6 ZLKF 261 Freezer Gross capacity I Refrigerator 105 195 Freezer 65 Refrigerator 195 Net capacity I Freezer Refrigerator 80 192 Freezer 51 Refrigerator 192 Width mm 600 600 Height mm 1790 1580 Depth mm 600 600 1 42 518 Energy consumption kWh 24h kWh year 1 20 438 Energy class according to EU standards Freezing capacity kg 24h 18 12 Rising time h 19 17 Rated power W
21. ne layer in either its refrigerant circuit or insulation materials The appliance shall not be discarded together with the urban refuse and rubbish Avoid damaging the cooling unit especially at the rear near the heat exchanger Information on your local disposal sites may be obtained from your municipal authorities The materials used on this appliance marked with the 4 recyclable lt gt Maintenance Defrosting Bleeding part of the moisture of cooling chambers in form of frost and ice goes with the operation of the appliance Thick frost and ice has an insulating effect so it reduces cooling efficiency as the temperature increases in the cooling chambers they need more energy at a certain thickness it does not allow the door of the freezing compartment to open At this type of appliance defrosting the cooling plate of the refrigerator is automatic without any external intervention The thermostatic control interrupts the operation of compressor at regular intervals for more or less time during this cooling is interrupted the temperature of the cooling plate goes above O C due to interior heating load of the compartment so defrosting occurs When the surface temperature of the cooling plate has reached 3 4 C the thermostatic control restarts operation of the system Melting water flows through defrost water outlet leaded through the back into the evaporative tray maintained on the top of c
22. ompressor and evaporates due to its warmth Check and clean the outlet of melting water coming during defrosting regularly a label inside the appliance warns you for this If it is clogged the melting water gathered can cause earlier failure as it can go to the insulating of the appliance Clean the melting water outlet with the supplied pipe scraper that can be seen in the figure The pipe scraper has to be stored in the outlet The most typical case of clogging up in the melting water outlet when you put food wrapped in some paper into the appliance and this paper contacts back plate of the refrigerator and freezes to it If you remove the food right at this moment the paper will tear and it can cause clogging up in the outlet by getting into it So you are asked to be careful because of the above when placing foods wrapped in paper into the appliance 27 lt gt In case of increased demand e g during heatwaves the refrigerator temporarily happens to operate constantly during this the automatic defrosting is ineffective Remaining small ice and frost stains on back plate of the refrigerator after defrosting period is not abnormal The freezer can not be equipped with automatic defrosting set since the deep frozen and frozen foods do not endure melting temperature When small frost and ice occurs scrape off and remove frost and ice coating with the supplied plastic scraper The tray in figure is not a piece of ac
23. ottled fruits in the frozen food compartment Check and clean the outlet of melting water coming during defrosting regularly a label inside the appliance warns you for this If it is clogged the melting water gathered can cause earlier failure 22 Precautions for child safety Do not allow children to play with the packaging of the appliance Plastic foil can cause suffocation e Adults must handle the appliance Do not allow children to play with it or its controlling parts e f you are discarding the appliance pull the plug out of the socket cut the connection cable as close to the appliance as you can and remove the door to prevent playing children to suffer electric shock or to close themselves into it Safety precautions for installation e Put the appliance to the wall to avoid touching or catching warm parts compressor condenser to prevent possible burn e When moving the appliance take care of the plug not to be in the socket e When placing the appliance take care not to stand it on the power cord e Adequate air circulation should be around the appliance lacking this leads to overheating To achieve sufficient ventilation follow the instructions relevant to installation For the safety of life and property keep the precautions of these user s instructions as the manufacturer 1 responsible for damages caused by omission lt gt Instructions for the User General information
24. pening and closing the door of freezer vacuum will rise inside the appliance because of the low temperature So wait 2 3 minutes after closing the door if you want to open it again while inner pressure equalises e Take care of operating the freezer at a position of thermostatic control so that the inside temperature can never go above 18 C since temperature higher than this can deteriorate frozen foods e 1 15 practical to make sure of faultless operation of the appliance daily so as to notice possible failure in time and prevent deterioration of frozen foods Hints and ideas In this chapter practical hints and ideas are given about how to use the appliance to reach maximum energy saving and there is environmental information about the appliance as well How to save energy e Avoid putting the appliance in a sunny place and near anything that gives off heat e Be sure that the condenser and the compressor are well ventilated Do not cover the sections where ventilation is e Wrap products in tightly closing dishes or cling film to avoid building up unnecessary frost e Do not leave the door open longer than necessary and avoid unnecessary openings e Put foods into the appliance only in a closed dish e Put warm foods into the appliance only when they are at room temperature e Keep the condenser clean The appliance and environment This appliance does not contain gasses which could damage the ozo
25. tically for more or less time depending on the setting then restarts it assuring the required temperature Turning the control button towards the bigger numbers cooling becomes more and more intensive In the frozen food compartment 18 C or lower temperature can be reached if the knob of the thermostatic control is set to 3 In this case the temperature starting automatically in the fresh food compartment is about 5 C or below The 3 position generally meets the requirements of everyday cooling The temperature coming about in the refrigerator is effected by not only the position of the thermostatic control but the ambient temperature frequency of door openings and the quantity of food put into it newly etc Gi In the maximum i e 5 position in case of increased demand e g during heatwaves without disconnecting continuous operation can occur This does not cause damages to the appliance 24 How to use the refrigerator For adequate cooling developing interior air circulation is necessary For this reason you are asked not to cover the whole surface of the wire shelves with paper trays etc 1 Do not put hot food into the refrigerator Allow it to reach room temperature naturally In this way the unnecessary frost building up can be avoided Foods can take over odours from each other So it is essential to put foods in closed dishes or wrap them in cellophane aluminium foil
26. work During operation of the appliance some smaller but annoying trouble can often occur which does not require calling a technician out In the following chart information is given about them to avoid unnecessary charges on service We draw your attention that operation of appliance goes with certain sounds compressor circulating sound This is not trouble but means normal operation We draw it to your attention again that the appliance operates discontinuously so the stopping of compressor does not mean being no current That is why you must not touch the electrical parts of the appliance before breaking the circuit 29 Problem Possible cause Solution It is too warm in the refrigerator Thermostatic control can be set wrongly If products not cold enough placed wrongly The door does not close tightly or it is not shut properly Set the thermostat knob to higher position Place the products to the appropriate place Check if the door closes well and the gasket is unhurt and clean It is too warm in the freezer Thermostatic control can be set wrongly The door does not close tightly or it is not shut properly Products in big quantity to be frozen were put in Products to be frozen are placed too closely to each other Set the thermostat knob to higher position Check if the door closes well and the gasket is unhurt and clean Wait some hours and then ch
Download Pdf Manuals
Related Search