Zanussi ZERC 2425 Instruction Booklet
Contents
1. handling of this product For more detailed information about recycling of this product please contact your local city office your household waste disposal service or the shop where you purchased the product CONTENTS Instructions for the User Instructions for the Installer N Important Safety Information Operation Technical Specification Before use Installation Setting the temperature Positioning Fresh food refrigeration Rear Spacers Normal operating sounds 3 P 9 Electrical Connection Movable shelves Positioning the door shelves Door Reversal O 00h A HR bh FA Hints and Tips Maintenance and Cleaning Internal cleaning External cleaning When the appliance is not in use Changing the light bulb Defrosting D NN DODD OD Something Not Working Service and Spare Parts 9 Customer Care 9 Guarantee Conditions 10 11 12 12 12 13 14 OPERATION Before using Remove all securing tapes Wash inside the appliance with lukewarm water and bicarbonate of soda 5 ml to 0 5 litre of water Do not use soap or detergent as the smell may linger Dry thoroughly Setting the temperature The temperature inside the refrigerator is regulated by a thermostat with 6 temperature positions and an OFF O position Position 1 minimum coldness Position 6 maximum coldness Turn the thermostat dial to the required position The intermediate position is usually the most suitable 3 4 T2. installed taking into account regulations in your new country Before you move please contact your nearest Customer Care centre listed below to give them details of your new home They will then ensure that the local Service Organisation is aware of your move and able to look after you and your appliances France Senlis 33 0 3 44 62 29 29 Germany Nurnberg 49 0 800 234 7378 Italy Pordenone 39 0 0434 39 4700 Sweden Stockholm 46 0 8 672 53 90 UK Luton 44 0 8705 727727 Ireland Dublin 353 0 1 4090751 10 TECHNICAL SPECIFICATIONS DIMENSIONS Height Width Depth POWER SUPPLY VOLTAGE AND FREQUENCY TOTAL POWER ABSORBED AVERAGE DAILY UNITS ELECTRICITY GROSS CAPACITY NET CAPACITY 124 cm 55 cm 60 cm 220 240 V 50 Hz 110W 0 44 KWh 235 230 This figure is based on standard test results in accordance with European Standard EN 153 Actual consumption will depend on how the appliance is used and where it is located INSTALLATION A Important IF YOU ARE DISCARDING AN OLD APPLIANCE THAT HAS A LOCK OR CATCH ON THE DOOR YOU MUST ENSURE THAT IT IS MADE UNUSABLE TO PREVENT YOUNG CHILDREN BEING TRAPPED INSIDE Positioning This appliance should only be installed at a location where the ambient temperature corresponds to the climate classification indicated on the rating plate which is located at the left on the inside of the appliance The following table shows which ambient temperature is correct for
3. refrigerant to settle Child Safety e e Do not allow children to tamper with the controls or play with the product Keep all packaging well away from children General Safety This appliance contains hydrocarbons in its cooling unit maintenance and recharging must therefore only be carried out by authorized technicians Take utmost care when handling your appliance so as not to cause any damages to the cooling unit with consequent possible fluid leakages The appliance must not be located close to cookers radiators or boilers Avoid prolonged exposure of the appliance to direct sunlight Do not use other electrical appliances such as ice cream makers inside of refrigerating appliances During Use e This appliance is designed for domestic use only specifically for the storage of edible foodstuffs e Frozen food must NOT be re frozen once it has thawed out Do not place carbonated or fizzy drinks in the freezer Do not remove items from the freezer if your hands are damp wet as this could cause skin abrasions or frost freezer burns e Ice lollies can cause frost freezer burns if consumed straight from the freezer e Manufacturers storage recommendations should be strictly adhered to Refer to relevant instructions e The cooling plate or refrigerated freezer shelves in this appliance contain channels through which the refrigerant passes If these are punctured this will cause substan
4. ZANUSSI Electrolux REFRIGERATOR ZERC 2425 INSTRUCTION BOOKLET IMPORTANT SAFETY INFORMATION It is most important that this instruction book should be retained with the appliance for future reference Should the appliance be sold or transferred to another owner or should you move house and leave the appliance always ensure that the book is left with the appliance in order that the new owner can get to know the functioning of the appliance and the relevant safety information This information has been provided in the interest of safety You MUST read it carefully before installing or using the appliance Installation e This appliance is heavy Care should be taken when moving it It is dangerous to alter the specifications or attempt to modify this product in any way Care must be taken to ensure that the appliance does not stand on the electrical supply cable Important if the supply cable is damaged it must be replaced by a special cable available from your local Service Force Centre Any electrical work required to install this appliance should be carried out by a qualified electrician or competent person Parts which heat up should not be exposed Whenever possible the back of the appliance should be close to a wall but leaving the required distance for ventilation as stated in the installation instructions The appliance should be left for 2 hours after installation before it is turned on in order to allow the
5. ance in a cool well ventilated room and make sure that the air openings of the appliance are not obstructed Always leave warm food to cool down to room temperature before placing in the fridge e Try to avoid keeping the door open for long periods or opening the door too frequently as warm air will enter the cabinet and cause the compressor to switch on unnecessarily often Ensure there are no obstructions preventing the door from closing properly e Itis advisable to peridocally clean the refrigeration system at the back of the appliance with a duster or vacuum cleaner MAINTENANCE AND CLEANING Before any maintenance or cleaning work is carried out DISCONNECT the appliance from the ELECTRICITY supply Internal cleaning Clean the inside and accessories with warm water and bicarbonate of soda 5ml to 0 5 litre of water Rinse and dry thoroughly A NEVER USE DETERGENTS ABRASIVE POWDERS HIGHLY PERFUMED CLEANING PRODUCTS OR WAX POLISHES TO CLEAN THE INTERIOR AS THESE WILL DAMAGE THE SURFACE AND LEAVE A STRONG ODOUR External cleaning Many proprietary kitchen surface cleaners contain chemicals that can attack damage the plastics used in this appliance For this reason it is recommended that the outer casing of this appliance is only cleaned with warm water with a little washing up liquid added An accumulation of dust will affect the performance of the appliance and cause excessive electricity consumption Yo
6. each climate classification SN 10 C to 32 C N 16 C to 32 C ST 18 C to 38 C T 18 C to 43 C It should be located in a dry atmosphere out of direct sunlight and away from extreme temperature e g not next to a boiler or radiator or in a very cold room e g an outhouse where the temperatures may fall below 10 C 50 F If these temperatures are exceeded i e colder or warmer then the appliance may not operate correctly You should also ensure that air can circulate freely around the back and the top of the cabinet There must also be at least 100 mm 4 distance between the top of the cabinet and any overhanging kitchen furniture A Ideally the appliance should not be positioned beneath overhanging furniture B There should also be a gap of 25 mm either side of the appliance Do not obstruct the space underneath The back of the cabinet may be placed close to the wall but must not touch it DO NOT install in places with restricted ventilation Adjust the level of the appliance by screwing out the adjustable foot or feet at the bottom of the cabinet using your fingers or a tool see figure Rear spacers The plastic bag containing all relevant documentation also contains two spacers to be fitted into special holes in the back of the appliance Fit the spacers into the holes taking care to ensure that the arrow A is positioned as shown in the Figure Then turn them through 45 arrow A vert
7. ease note that it will be necessary to provide proof of purchase for any in guarantee service calls In guarantee customers should ensure that the above checks have been made as the engineer will make a charge if the fault is not a mechanical or electrical breakdown SERVICE AND SPARE PARTS sseuicesronce In the event of your appliance requiring service or if you wish to purchase spare parts please contact your local Service Force Centre by telephoning 0870 5 929929 Your telephone call will be automatically routed to the Service Force Centre covering your post code area For the address of your local Service Force Centre and further information about Service Force please visit the website at www serviceforce co uk For Customer Service in Ireland please contact us at the address below Zanussi Electrolux Electrolux Group Irl Ltd Long Mile Road Dublin 12 Republic of Ireland Telephone 353 0 1 4090751 Email service eid O electrolux ie Before calling out an engineer please ensure you have read the details under the heading Something Not Working When you contact the Service Force Centre you will need to give the following details Your name address and post code Your telephone number Clear and concise details of the fault The model and serial number of the appliance found on the rating plate ar D The purchase date Please note that a valid purchase receipt or guarantee documentation is required
8. en and Yellow earth wire to the terminal in the plug which is marked with the letter E or the earth symbol or coloured green and yellow Connect the blue neutral wire to the terminal in the plug which is marked with the letter N or coloured black Connect the brown live wire to the terminal in the plug which is marked with the letter L or coloured red The plug moulded onto the lead incorporates a fuse For replacement use a 13amp BSI362 fuse Only ASTA or BSI approved fuses should be used The plug must not be used if the fuse cover carrier is lost The cover carrier is indicated by the coloured insert at the base of the plug A replacement cover carrier must be obtained from your local Service Force Centre This appliance complies with the E E C Directive No 87 308 of 2 6 87 relative to radio interference suppression E E C Directives 73 23 EEC of 19 2 73 Low Voltage Directive and subsequent modifications 89 336 EEC of 3 5 89 Electromagnetic Compatibility Directive and subsequent modifications This appliance complies with the following Door reversal directions Disconnect from the electricity supply Gently lay the fridge on its back with the top held away from the floor by 5 8 cm 2 3 inches of packing Remove the bottom hinge 1 retaining screws and remove the foot 2 Slide out the fridge door from pin G unscrew the latter and then refit it on the oppo
9. for in guarantee service calls CUSTOMER CARE DEPARTMENT For general enquiries concerning your Zanussi Electrolux appliance or for further information on Zanussi Electrolux products please contact our Customer Care Department by letter or telephone at the address below or visit our website at www zanussi co uk Customer Care Department Zanussi Electrolux Major Appliances Addington Way Luton Bedfordshire LU4 9QQ Tel 08705 727 727 calls to this number may be recorded for training purposes GUARANTEE CONDITIONS Standard guarantee conditions We Zanussi Electrolux undertake that if within 12 months of the date of the purchase this ZANUSSI ELECTROLUX appliance or any part thereof is proved to be defective by reason only of faulty workmanship or materials we will at our option repair or replace the same FREE OF CHARGE for labour materials or carriage on condition that e The appliance has been correctly installed and used only on the electricity supply stated on the rating plate e The appliance has been used for normal domestic purposes only and in accordance with the manufacturer s instructions e The appliance has not been serviced maintained repaired taken apart or tampered with by any person not authorised by us e All service work under this guarantee must be undertaken by a Service Force Centre Any appliance or defective part replaced shall become the Company s property e This guarantee is in additio
10. he thermostat setting can vary as the temperature inside the refrigeration compartment depends on the following factors room temperature how often the door is opened how much food is stored position of the appliance A Important During prolonged periods of abnormally hot weather if the thermostat is set on too high a number the cooling system may operate continuously and the fridge cooling plate may not defrost Turning the knob to a lower number will cause the automatic defrosting to resume Fresh food refrigeration To obtain the best performance do not store warm food or evaporating liquids in the refrigerator do cover or wrap the food particularly if it has a strong flavour Do not cover the shelves with any protective material such as paper cardboard or plastic which may obstruct the air circulation through them To help you use your refrigerator correctly here are some more useful hints Raw meat beef pork lamb amp poultry or chicken wrap in polythene bags and place on the glass shelf above the salad crispers Meat can only be stored safely in this way for one or two days at the most Fruit amp vegetables these should be thoroughly cleaned and placed in the bottom salad crispers Butter amp cheese these should be placed in special airtight containers or wrapped in aluminium foil or polythene bags to exclude as much air as possible Milk bottles these should have a cap and s
11. hould be stored in the bottle rack on the door Normal Operating Sounds e You may hear faint gurgling or bubbling sounds when the refrigerant is pumped through the coils or tubing at the rear to the cooling plate evaporator When the compressor is on the refrigerant is being pumped round and you will hear a whirring sound or pulsating noise from the compressor e A thermostat controls the compressor and you will hear a faint click when the thermostat cuts in and out Movable shelves The walls of the refrigerator have runners so that shelves can be positioned as desired Positioning the door shelves To permit storage of food packages of various sizes the door shelves can be adjusted in height To do this proceed as shown in the diagram G HINTS AND TIPS Food Storage e To obtain the best results from the appliance neither hot foods nor liquids which may evaporate should be placed in the larder compartment e Keep the time between buying chilled food and placing it in your refrigerator as short as possible e Do not push food together too much try to allow air to circulate around each item e Do not store food uncovered e Remove suspect food from your refrigerator and clean refer to Maintenance and Cleaning vo Energy Saving Advice Do not install the appliance close to sources of heat such as a boiler or radiator e Locate the appli
12. ical until they lock into place 12 Depending upon the position which you choose for your appliance you may wish to reverse the way in which the door opens To do this refer to instructions on Door reversal Please ensure that when the appliance is installed it is easily accessible for the engineer in the event of a breakdown D200 A Electrical connections Any electrical work required to install this appliance should be carried out by a qualified electrician or competent person WARNING THIS APPLIANCE MUST BE EARTHED The manufacturer declines any liability should this safety measure not be observed If the plug that is fitted to your appliance is not suitable for your socket outlet it must be cut off and the appropriate plug fitted Remove the fuse from the cut off plug The cut off plug should then be disposed of to prevent the hazard of shocks in case it should be plugged into a 13amp socket in another part of your home A Important The wires in the mains lead are coloured in accordance with the following code Green and Yellow Earth Blue Neutral Brown Live If you fit your own plug the colours of the wires in the mains lead of your appliance may not correspond with the markings identifying the terminals in your plug proceed as follows GREEN amp YELLOW 13 AMP FUSE CORD CLAMP Connect the Gre
13. n to your statutory and other legal rights Home visits are made between 8 30am and 5 30pm Monday to Friday Visits may be available outside these hours in which case a premium will be charged Exclusions This guarantee does not cover Damage or calls resulting from transportation improper use or neglect the replacement of any light bulbs or removable parts of glass or plastic e Costs incurred for calls to put right an appliance which is improperly installed or calls to appliances outside the European Community EC or European Free Trade Area e Appliances found to be in use within a commercial environment plus those which are subject to rental agreements e Products of Zanussi Electrolux manufacture which are not marketed by Zanussi Electrolux European Guarantee If you should move to another country within Europe then your guarantee moves with you to your new home subject to the following qualifications e The guarantee starts from the date you first purchased your product e The guarantee is for the same period and to the same extent for labour and parts as exists in the new country of use for this brand or range of products e This guarantee relates to you and cannot be transferred to another user Your new home is within the European Community EC or European Free Trade Area e The product is installed and used in accordance with our instructions and is only used domestically i e a normal household e The product is
14. site side Unscrew the foot on the left side and refit it on the opposite side Remove the two screws which mask the holes for fixing the hinge from the left hand side Refit the door and the lower hinge 1 and the foot 2 Unscrew the handle Refit it on the opposite side after having pierced the plugs with a punch Cover the holes left open with the plugs supplied in the documentation pack A Important After completion of the door reversing operation check that the door gasket adheres to the cabinet If the ambient temperature is cold i e in Winter the gasket may not fit perfectly to the cabinet In that case wait for the natural fitting of the gasket or accelerate this process by heating up the part involved with a normal hairdryer on a low setting 14 Electrolux ple 2005 E From the Electrolux Group The world s No 1 choice The Electrolux Group is the world s largest producer of powered appliances for kitchen cleaning and outdoor use More than 55 million Electrolux Group products such as refrigerators Cookers washing machines vacuum cleaners chain saws and lawn mowers are sold each year to a value of approx USD 14 billion in more than 150 countries around the world
15. tervals Dry throughly before replacing SOMETHING NOT WORKING If the appliance is not working correctly please carry out the following checks before contacting your local Service Force Centre Symptom Solution No power to the appliance Check there is power at the socket Check there is not a power cut by checking the household lights Check the fuse has not blown The light does not come on Ensure that the bulb is correctly fitted Replace the bulb if it has blown Check the door light switch is not jammed The temperature in the fridge Check the thermostat control knob in the fridge is turned to the correct setting relative to ambient conditions Check the ambient temperature is within the appliance s operating limits please refer to the installation section in this instruction book Relocate the appliance if necessary The compressor runs continously Adjust the thermostat control knob to give correct temperature control See Setting the temperature Check that the door is closed Large quantities of food have recently been placed in the cabinet and or door is frequently opened Check that air ventilation is not obstructed Noise Refer to normal operating sounds Water under the salad crispers Check the drain hole is not blocked see Maintenance and Cleaning If after the above checks your appliance still does not operate correctly contact your local Service Force Centre Pl
16. tial damage to the appliance and result in food loss DO NOT USE SHARP INSTRUMENTS to scrape off frost or ice Under NO circumstances should solid ice be forced off the lining or shelves Solid ice should be allowed to thaw when defrosting the appliance See Defrost Instructions Maintenance and Cleaning e Switch off and unplug the appliance before carrying out any cleaning or maintenance work Servicing e This product should be serviced by an authorised engineer and only genuine spare parts should be used e Under no circumstances should you attempt to repair the machine yourself Repairs carried out by inexperienced persons may cause injury or serious malfunctioning Refer to your local Service Force Centre and always insist on genuine spare parts At the end of the Appliance Life e When disposing of your appliance use an authorised disposal site Remove the plug and ensure that any locks or catches are removed to prevent young children being trapped inside Disposal of old Appliances The symbol X on the product or on its packaging indicates that this product may not be treated as household waste Instead it shall be handed over to the applicable collection point for the recycling of electrical and electronic equipment By ensuring this product is disposed of correctly you will help prevent potential negative consequences for the environment and human health which could otherwise be caused by inappropriate waste
17. u MUST ensure that the appliance is switched OFF Once or twice a year dust the condenser black grill and the compressor at the back of the appliance with a brush or vacuum cleaner see figure When the appliance is not in use When the appliance is not in use for long periods disconnect from the electricity supply empty all foods and clean the appliance leaving the doors ajar to prevent unpleasant smells Changing the light bulb Unscrew the light cover and then pull it outward toward the middle of the cabinet Unscrew the bulb and replace it with one of the same power the maximum power is shown on the light diffuser available from your nearest Service Force Centre Replace the light cover by sliding it into its original position and replacing the screw Defrosting The refrigerator automatically defrosts every time the compressor stops The water is discharged via the pipe into a tray located at the back of the appliance above the compressor where it evaporates A Important To avoid defrost water overflowing into the fridge periodically clean the water discharge hole in the centre of the V shaped drip collector at the back of the refrigerator compartment behind the salad crispers Use the defrost cleaner provided which you will find already inserted into the discharge hole Remember to wash the defrost cleaner in hot soapy water at regular in
Download Pdf Manuals
Related Search