Zanussi DCS 14 S Instruction Booklet
Contents
1. Visible lime deposits or white film on Is the salt container empty or is the water softener not the dishes correctly adjusted Is the rinse aid dispenser adjusted to too low dosage The machine is noisy Are the dishes rattling against each other Is the spray arm knocking against the dishes The dishes are not quite dry Is the rinse aid dispenser empty Have the dishes been left too long inside the machine The door is difficult to close Is the dishwasher level Never attempt to repair the dishwasher yourself Repairs carried out by unauthorised or inexperienced persons can cause injury or serious malfunctioning Service Service and Spare Parts In the event of your appliance requiring service or if you wish to purchase spare parts please contact your local Service Force Centre by telephoning 08705 929929 Your telephone call will be automatically routed to the Service Force Centre covering your post code area For the address of your local Service Force Centre and further information about Service Force please visit the website at www serviceforce co uk Before calling out an engineer please ensure you have read the details under the heading In the event of a fault When you contact the Service Force Centre you will need to give the following details 1 Your name address and post code 2 Your telephone number 3 Clear and concise details of the fault 4 The model and serial number of th2. ee ZANUSSI 822 90 11 22 INSTRUCTION BOOKLET Contents For the user For the installer Important safety information 3 Technical specifications 12 Care and cleaning 4 5 Unpacking the machine 13 General cleaning If the machine is damaged Rinse aid dispenser Use Spray arm Protecting the machine against freezing Coarse filter Fine filter Installation 14 15 Detergent dispenser Water inlet Water softener Water drainage Water softener plug Power supply Cleaning the cabinet The control panel and programmes 6 How to load the dishwasher 7 Instruction for test centres Using your appliance 8 In the event of a fault 9 Service 10 Service and Spare Parts Customer Care Department Guarantee Conditions 11 Guide to use the instruction book The following symbols will be found in the text to guide you throughout the instructions AN Safety instructions Step by step instructions i Hints and tips A Environmental information 20s A N Important safety information Before installing and first using the dishwasher read the instruction booklet carefully including its hints and warnings Doing so will ensure that your machine will perform properly and to best advantage Anyone using the machine should be thoroughly familiar with its instructions for use and safety features Save these instructions and make sure they remain with the machine if it is moved or sold so that everyone
3. USD 14 billion in more than 150 countries around the world CE EEE 02 04
4. which is connected to the dish washer can be turned in any direction Loosen the retaining nut turn the hose then retighten the nut Water drainage Place the discharge hose over the sink as illustrated It must not at any point be higher up than 75 cm over the surface which the dishwasher is standing on If it runs higher operation of the dishwasher might be impaired It is also important to ensure that the inside diameter of the hose is not less than 13 mm at any point If the discharge hose is too long it can easily be cut to the right length lt gt 1 Cut the hose to a suitable length using a sharp knife 2 Fit the elbow supplied onto the end of the hose 14 Power supply The dishwasher is supplied with a lead and electrical plug for connection to a 230 V 13 A earthed wall socket Before any work is carried out on the dishwasher it must be isolated from the electric mains supply for example by removing the plug from the wall socket Permanent electrical installation must be carried out by an authorised electrician or competent person WARNING THIS APPLIANCE MUST BE EARTHED The manufacturer declines any liability should this safety measure not be observed If the plug that is fitted to your appliance is not suitable for your socket outlet it must be cut off and the appropriate plug fitted Remove the fuse from the cut off plug The cut off plug should then be disposed
5. of to prevent the hazard of shocks in case it should be plugged into a 13 amp socket in another part of your home Important The wires in the mains lead are coloured in accordance with the following code Green and Yellow Earth Blue Neutral Brown Live If you fit your own plug the colours of the wires in the mains lead of your appliance may not correspond with the markings identifying the terminals in your plug proceed as follows Connect the Green and Yellow earth wire to the terminal in the plug which is marked with the letter E or the earth symbol or coloured green and yellow Connect the blue neutral wire to the terminal in the plug which is marked with the letter N or coloured black Connect the brown live wire to the terminal in the plug which is marked with the letter L or coloured red The plug moulded onto the lead incorporates a fuse For replacement use a 13 amp BSI362 fuse Only ASTA or BSI approved fuses should be used 15 GREEN amp YELLOW 13 AMP FUSE CORD CLAMP ZANUSSI Electrolux Household Appliances Limited 2002 2 From the Electrolux Group The world s No 1 choice The Electrolux Group is the world s largest producer of powered appliances for kitchen cleaning and outdoor use More than 55 million Electrolux Group products such as refrigerators cookers washing machines vacuum cleaners chain saws and lawn mowers are sold each year to a value of approx
6. open door During Use E This dishwasher is designed solely for washing house hold utensils suitable for machine washing Using it for other purposes could lead to physical injury or damage to property and invalidate the guarantee E Avoid opening the door while the dishwasher is running as hot steam may escape m Only use detergent specifically designed for use in dishwashers E f you take any dishes out of the machine before the end of the dishwashing cycle it is extremely important to rinse them thoroughly under running water to remove any remaining detergent E Do not place sharp knives with their points upwards It is much safer to lay them horizontally in the basket E When finishing loading or unloading close the door as an open door can be a hazard m Make sure that the machine is disconnected from the power supply during cleaning and maintenance work m After using the machine turn off its water supply and disconnect it from the power supply When removing the electrical plug grip the plug not the lead Identification of materials A A All materials used in packaging this machine are environmentally friendly The various plastics used are identified and can be recycled PE stands for polyethylene which is used for the bag around the machine and the bag in which these instructions were supplied e PS stands for polystyrene moulded which is used for the sections of packaging needed to cushion the m
7. whitish spots If this happens decrease the quantity of rinse aid by turning the red dial below the filler trough anti clockwise The dispenser holds about 140 ml This is enough for 40 70 wash cycles depending on the dosage setting When the rinse aid level is approaching the bottom of the scale it is time to refill the dispenser Swivel out the filler trough and carefully fill up with rinse aid until the level reaches up to the red mark on the level indicator tube Do not overfill and carefully wipe off any spillage with a damp cloth immediately Don t forget to close the filler trough afterwards Do not fill the rinse aid dispenser with liquid detergent Spray arm 2 The holes in the spray arm nozzle must be kept free of scraps for the efficiency of the washing action Inspect the spray arm regularly When thorough cleaning is necessary remove the spray arm by unscrewing the nut clockwise it has a left handed thread and lift off the spray arm Wash the spray arm with hot soapy water using a stiff saucepan brush if necessary to remove scraps Re assemble carefully making sure the nut is secure Coarse filter 3 The purpose of the coarse filter is to catch large objects such as toothpicks and pieces of eggshell Make sure that the filter is always clean Lift it out and rinse it under running water whenever necessary Fine filter 4 It is just as important to keep this filter clean A dirty or clogged filter wi
8. achine The cardboard components of the packaging are made from recyclable paper and should be taken to a collection point for recycling The machine contains plastic and rubber components These have identifying marks to show what they are made from so they can be recycled or disposed of properly at the end of the machine s life The materials are identified according to international standards 822 90 11 22 Care and cleaning Important Make sure that the machine is unplugged and the water turned off before undertaking any kind of maintenance General cleaning Inspect the filters and spray arm nozzle before re loading the machine and remove any food scraps Wipe round the rubber gasket at the bottom of the door to remove grease which tends to collect there Rinse aid dispenser 1 Use of rinse aid will result in faster drying of the load and gives the dishes a shiny finish It may be necessary to adjust the quantity of rinse aid dispensed if you live in either a very hard water or a very soft water area More is needed for hard water and less for soft water Leave the dispenser in its preset position when you first use the dishwasher and only adjust if after a few cycles you notice the following e Crockery remaining dull looking and or showing occasional round spots If this happens increase the quantity of rinse aid by turning the red dial below the filter trough clockwise e Crockery feeling sticky or showing
9. aged If the dishwasher has been damaged during transport you should immediately notify the company responsible for delivering it Check that the dishwasher is undamaged If you discover any damage faults or that anything is missing you should notify the dealer immediately Never leave packaging material in a place where children may play with it Check that the following accessories are supplied with the dishwasher when you unpack it e A funnel for filling with salt 1 e Elbow for discharge hose 2 e Washer filter for inlet hose 3 Use This dishwasher is designed solely for washing household utensils suitable for washing in a dishwasher Using it for other purposes may damage it and invalidate the guarantee Protecting the machine against freezing If the dishwasher is placed in an environment where the temperature sometimes fall below 0 C there is a risk that the small amount of water which remains inside the parts of the dishwasher will freeze and damage it To prevent this you should lt gt 1 Turn off the water supply to the machine and disconnect the water intake hose from the supply pipe 2 Select a wash programme start the machine and let the programme run for a short time 2 Make sure that there is dishwasher salt in the salt container for the water softener The appliance is only to be used and stored indoors at normal room temperature The manu facture is not responsible for any frost da
10. e appliance found on the rating plate 5 The purchase date Please note that a valid purchase receipt or guarantee documentation is required for in guarantee service calls Customer Care Department For general enquiries concerning your Zanussi appliance or for further information on Zanussi products please contact our Customer Care Department by letter or telephone at the address below or visit our website at www zanussi co uk Customer Care Department Zanussi 55 77 High Street Slough Berkshire SL1 1DZ Tel 08705 727727 call to this number may be recorded for training purposes 10 Guarantee Conditions Standard guarantee conditions We Zanussi undertake that if within 12 months of the date of the purchase this Zanussi appliance or any part thereof is proved to be defective by reason only of faulty workmanship or materials we will at our option repair or replace the same FREE OF CHARGE for labour materials or carriage on condition that The appliance has been correctly installed and used only on the electricity supply stated on the rating plate The appliance has been used for normal domestic purposes only and in accordance with the manufacturer s instructions The appliance has not been serviced maintained repaired taken apart or tampered with by any person not authorised by us e All service work under this guarantee must be undertaken by a Zanussi Service Force Centre e Any appliance or defect
11. e down Incline deep dishes soup plates etc so that the water can run off when drying Make sure that the dishes do not rest against each other This is particularly important in regard to the cutlery basket nested spoons etc simply cannot be properly washed The water must get at all the soiled surfaces Make sure that cutlery with slender handles and other items do not protrude through the openings in the basket and prevent the spray arm from rotating Never put silver and stainless steel objects together When these metals come into contact with each other a chemical reaction occurs which stains the silver China with a pattern applied on top of the glaze may not be suitable for machine washing as the colours may fade and lose their lustre The same applies to cutlery with wooden or plastic handles Make sure you always buy articles that are dishwasher proof e Not all plastic articles are machine washable If you are in doubt as to whether your plasticware can be machine washed we suggest you check by washing a single item or else wash them by hand 2 e Aluminium becomes dull and tarnished when machine washed The machine gets it clean but at the expense of its appearance e When washing delicate items select the lower wash temperature e Substances such as ketchup containing strong colouring agents can cause temporary discolouration in the machine Instruction for te
12. e the outside of the cabinet and control panel regularly with a soft damp cloth When necessary use liquid kitchen or household cleaner to remove stubborn marks rinse with a damp cloth and rub up with a soft duster Never use abrasive cleaners which could damage the surface ie scouring pads or solvents acetone trichlori ethylene etc If the machine is not going to be used for some time take the folllowing precautions lt gt 1 Unplug the machine and turn off the water supply 2 Fill up the rinse aid container 3 Make sure the tub is clean by carrying out a wash programme without any crockery using Finish Dishwasher cleaner then dry the inside thoroughly 4 Leave the door ajar 5 The control panel and programmes SETTING Cycle Symbol Temp selection E Rinse amp Hold Ay Prewash Prerinse Ce Intensive Economy g ZANUSSI lt j HA 1 On Off button Press the button in order to start the required programme 2 Temperature selector 55 Button in 65 Button out 3 Extra drying effect If the button is pressed in the temperature of the final rinse water will be higher and the drying effect will be improved 4 Programme selector Turn the programme selector clockwise to the programme required and press in the On Off button During the water heating process the timer is standing still To isolate the dishwasher from the mains compl
13. etely unplug it from the wall socket 5 Indicator lamp While the programme is in progress the operating lamp is lit and it goes out when the programme is ready 6 Salt indicator lamp The operating lamp indicates when the salt needs to be replenished The lamp may remain lit for one or more programmes after replenishment which is fully normal 6 COMPACT DISHWASHER 6 5 4 Door lock Press the handle down and open the door Avoid opening the door while the machine is running If the door is opened and is put standing ajar after a completed programme the dishes will dry faster Programmes Rinse amp Hold is used if you want to wait until you have a full load This cycle rinses the load and keeps it moist making the main wash easier later on No detergent should be used It does not matter which temperature you select Intensive for loads which have heavily dried on food remnants and for those which are heavily soiled Normal for normal soiled loads Replaces the pre wash with one rinse without heating Economy is used for lightly soiled loads which do not need any rinse off such as cups saucers and glasses How to load the dishwasher The illustration shows the machine loaded with five stan dard place settings Your own dishes are not likely to be identical to this load but if you follow the advice below 1 we are sure you will be pleased with the results Always place glasses cups and bowls upsid
14. household e The product is installed taking into account regulations in your new country Before you move please contact your nearest Customer Care centre listed below to give them details of your new home They will then ensure that the local Service Organisation is aware of your move and able to look after you and your appliances France Senlis 33 0 3 44 62 29 99 Germany Nurnberg 49 0 800 234 7378 Italy Pordenone 39 0 0434 39 4700 Sweden Stockholm 46 0 8 672 53 90 UK Slough 44 0 1753 219897 Pas be Any electrical work required to install this appliance should be carried out by a qualified electrician or competent person Any plumbing work required to install this appliance should be carried out by a qualified plumber or competent person Technical specifications Installation instructions Dimensions Height 460 mm Width 450 mm Depth 480 mm Weight Net 17 kg Gross 20 kg Capacity 5 settings Water pressures Minimum 50 kPa 0 5 bar Maximum 1000 kPa 10 bar Water Temperature Maximum 25 C Electrical data Power supply Fuse Heating element Power rating This appliance complies with the following E E C directives 73 23 EEC dated 19 02 1973 low voltage directive 89 336 EEC dated 03 05 1989 incl amendment 92 31 EEC directive on electromagnetic compatibility 12 230 V 50 Hz 13A 1200 W 1280 W Unpacking the machine If the machine is dam
15. ive part replaced shall become the Company s property e This guarantee is in addition to your statutory and other legal rights Home visits are made between 8 30am and 5 30pm Monday to Friday Visits may be available outside these hours in which case a premium will be charged Exclusions This guarantee does not cover Damage or calls resulting from transportation improper use or neglect the replacement of any light bulbs or removable parts of glass or plastic e Costs incurred for calls to put right an appliance which is improperly installed or calls to appliances outside the United Kingdom e Appliances found to be in use within a commercial environment plus those which are the subject to rental agreements Products of Zanussi manufacture which are not marketed by Zanussi European Guarantee If you should move to another country within Europe then your guarantee moves with you to your new home subject to the following qualifications e The guarantee starts from the date you first purchased your product The guarantee is for the same period and to the same extent for labour and parts as exists in the new country of use for this brand or range of products e This guarantee relates to you and cannot be transferred to another user e Your new home is within the European Community EC or European Free Trade Area The product is installed and used in accordance with our instructions and is only used domestically i e a normal
16. ll impair washing efficiency The fine filter can easily be lifted out for cleaning when you have removed the coarse filter The dishwasher must not be used without the filters Incorrect repositioning of the filters will produce poor washing results Cleaning of the filters is vital to ensure correct operation of the machine Detergent dispenser 5 Only use detergents specially designed for dishwashers Open the detergent compartment on the inside of the door by pushing the lid catch sideways Pour the detergent into the compartment for a normal load pour about 15g Close the lid firmly The detergent will be automatically dispensed at the right time Pre wash detergent is not generally needed but if the dishes are heavily soiled add an extra 5g anywhere on the inside of the door Since not all detergents are the same you should also consult the instructions on the packet Using the correct amount of detergent also contributes to reducing pollution Lil Water softener 6 This dishwasher is equipped with a water softener for hard chalky water therefore the rinse aid dispenser should be set for a low dosage The lime chalk in hard water causes white deposits to occur on dishes and the interior of the dishwasher To prevent this the water has to pass through a special container where its hardness is removed Since the water softener consumes coarse dishwasher salt you will have to replenish the salt container after a ce
17. mage 13 Installation The dishwasher is intended for installation ona kitchen sink or worktop It is important to ensure the dishwasher is level to avoid any difficulty opening and closing the door Its height can be adjusted with the adjustable feet 8 mm each in each corner of the dishwasher Water inlet The dishwasher should be permanently plumbed into a separate cold water supply The water pressure must be within the limits given in the technical specifications as it will not function correctly if pressure is outside these specifications Your local Water Authority will advise you on the average mains pressure in your area Where the water is supplied from a cold water cistern you can work out the pressure yourself by measuring the vertical distance or Head between the machine s inlet hose and the outlet from the cold water storage cistern allowing 86 psi for every 2 feet under normal conditions We would advise you to have a shut off valve or stopcock in the water supply pipe close to the dish washer and accessible for easy use This should be turned off when the appliance is not in use Insert the combination rubber washer filter and connect the inlet hose to a tap with a 3 4 pipe thread The inlet hose must not be joined onto any form of extension hose If it is too short the entire hose must be replaced with a longer high pressure hose specially designed for the purpose The end of the hose
18. n engineer please check through the details below because some faults can be rectified easily without the need to call out an engineer If an engineer is called to resolve a problem listed below or to repair a fault caused by incorrect installation or mis use a charge will be made even if the appliance is under guarantee Fault Check Is the door closed properly Have you pressed the ON OFF button Is there power to the machine Has the fuse blown Start with fuse in electrical plug Have you set the programme control knob properly Is the water tap turned on The machine will not start The machine is not filling with water Is the water tap turned on Has your domestic water supply been cut off temporarily Is the water intake hose kinked or blocked Is the filter inside the intake hose blocked Is the water pressure too low The machine will not drain Did you open the door before the light went out and the cycle ended Is the drain hose kinked Is the sink drain blocked Are the baskets too full Have the dishes not been arranged properly Has anything prevented the spray arm from rotating Are the spray arm holes clogged Are the filters clogged Are the filters in position Did you use enough detergent Is the detergent old or has gone hard Is the salt container cap properly closed Is the washing programme selected too gentle Is the rinse aid dispenser empty Dishes not washed satisfactorily
19. rtain number of dishwashing cycles When the indicator lamp on the control panel lights up it is time to fill up with salt Zanussi recommends the use of Finish dish washer detergent and Rinse Aid Proceed as follows L amp 1 Unscrew the salt container filler cap 2 Fill up salt container with water only the first time 3 Fill the container with coarse salt Use the funnel supplied with the machine Ordinary domestic salt will affect the efficiency of the water softener and damage it 4 Remove the funnel and wipe off any spillage 5 Screw the filler cap back in place The salt container holds about 1 litre which is enough for about 20 30 dishwashing cycles Always ensure that there is water in the salt container before filling salt Water softener plug 7 As supplied from the factory the water softener is set for a water hardness of up to 20H If your water is harder than this you can increase the capacity of the water softener by pulling out the rubber plug at the rear of the dishwasher on the left hand side viewed from the back See illustration Contact your local Water Authority to find the exact water hardness level for your area Never run the dishwasher without salt in the container as this may damage the water softener If the damage is slight the water softener function can be partially restored by filling the container with salt and then running the Normal cycle 4 5 times Cleaning the cabinet Wip
20. st centres Test standard EN 50242 Rated capacity 5 place settings Loading of rack According to figure 1 Test program Normal 65 C Extra Drying Detergent IEC type B 15 gram in the dispenser Rinse aid typ III Setting medium Feed water pressure Minimum 0 8 bar maximum 10 bar Waste water outlet Install according to figure 2 The salt container and rinse aid dispenser shall be filled in accordance with the instruction manual Before conducting the measurements the dishwasher shall be operated for one or two complete cycles using detergent and a clean load sTo Using your appliance Proceed as follows I 1 Scrape off solid food remnants 2 Load the dishwasher See How to load the dishwasher Pour approx 15 g detergent into the detergent dispenser and close the dispenser lid If the dishes are heavily soiled add an extra 5 g anywhere on the inside of the door 3 Close the door 4 Select a suitable programme 5 Select the required temperature and if required the option for extra drying The programme is started when the On Off button is pressed in 6 Check the filters to see whether they need cleaning when the dishwasher has finished the wash Detergent recommendations i For best results we recommend the use of Finish detergents rinse aid and salt finish i A complimentary sample pack is included in your new dishwasher 8 In the event of a fault Before calling out a
21. using it through its life can be properly informed on appliance use and safety Installation and servicing E All installation and service work done on the product must be carried out by a qualified technician Work performed by persons with inadequate knowledge may adversely affect the satisfactory functioning of the product and may cause personal injury or damage Before any work is carried out on the dishwasher it must be isolated from the electrical supply To do this the power plug must be removed from the wall socket m Water connection shall be made via an easily accessible stopcock m The power cable must be plugged into an earthed socket which must to be easily accessible Permanent installation must only be carried out by an authorized electrician E Make sure that the power cord is not nipped or other wise damaged and that its hoses do not get crushed or kinked when moving the dishwasher in connection with installation or cleaning etc E Servicing and possible repairs must be carried out by a service company authorized by the supplier Use only spare parts supplied by these Never try to repair the dishwasher yourself Child Safety m The dishwasher should be used by adults only Do not let children play with the controls or other parts of it E Keep all packaging well away for children m Keep all detergents in safe place out of children s reach E Prevent children from sitting swinging or standing on the
Download Pdf Manuals
Related Search