York PC9*DH User's Manual
Contents
1. a 0 OO PC9C20NTO0DH11 100 35 95 33 2000 23a 0o 40 70 20 50 PC9D20N120DH11 120 42 115 39 2000 24 1 2 40 70 20 50 r4 23e aa 258 16 1 4 8 in Air es Size Unit Over current awg 75 ft Operating Voltage PH Hz alae ee Protect One Way Weight PC9B12NO60DH11 a KA xs 9 2 m 136 115 1 60 Sa 11x8 143 115 1 60 AE E EA E E a E S A i 80 PCOCTENTOODHTT 170 o4 96 11x10 T 20 163 115 1 60 Pesos r pre tet 4206 eo PcoD2ont2o0m 170 1 ejman im 2 82 1157 60 Annual Fuel Utilization Efficiency AFUE numbers are determined in accordance with DOE Test procedures Wire size and over current protection must comply with the National Electrical Code NFPA 70 latest edition and all local codes The furnace shall be installed so that the electrical components are protected from water Unitary Products Group 246815 YTG D 0108 AIR FLOW DATA HIGH LOW SPEED COOLING AND HEAT PUMP CFM PC9B12N060DH11 PC9B12N080DH11 ai a JUMPER SETTINGS 5 o re COOL Tap ADITap mo o 1080 670 T e E 720 510 580 ee e30 500 790 530 PC9C16NO80DH11 o l 2 oe PC9C20N100DH11 59 i 7 rr COOL Tap ADI Tap a S E S S 1280 850 1470 K S E E E S S E B50 330 A ee o e eo o e Oa O a eo O a ee a 1500960 ee e 380 ee ee o a i 1360 840 a0 00 ee E E All CFM s are shown at 0 5 w c external static pressure These units have2. DROP INCHES W C AND KPA Minimum APPLYING FILTER PRESSURE DROP TO 3 Select a filter pressure drop from the table based upon DETERMINE SYSTEM AIRFLOW the number of return air openings or return air opening size and add to the ESP from Step 2 to determine the total system static If total system static matches a ESP value in the airflow table i e 0 20 0 60 etc the system airflow corresponds to the intersection of the ESP column and Model Blower Speed row To determine the approximate airflow of the unit with a filter in place follow the steps below 1 Select the filter type 2 Determine the External System Static Pressure ESP without the filter UNIT CLEARANCES TO COMBUSTIBLES i E E m e m m G m So ao a ooa MEE ee Combustible floor base or air conditioning coil required for use on combustible floor t Line contact only permitted between lines formed by the intersection of the rear panel and side panel top in horizontal position of the furnace jacket and build ing joists studs or framing 4 Unitary Products Group 246815 YTG D 0108 For additional connection diagrams for all UPG equipment refer to Line Voltage System Wiring document available on line at www upgnet com in the Product Catalog Section AC 26A Two Stage Air Conditioner Variable Speed Modulating Furnace ID MODELS PC9 FC9C FL9C THERMOSTAT THERMOSTAT VARIABLE SPEED TWO STAGE D
3. O 24VAC Humidifier Optional HUM Dehumidification Open on Humidity Rise Two Stage Heat Pump Variable Speed Modulating Furnace With Hot Heat Pump Operation Reversing Valve Energized in Cool X L Malfunction Light Y2 Second Stage Compressor W Auxiliary Heat Step 1 of the Thermostat Installer Table must be set to Heat Pump Step 2 of the Thermostat Installer Table must be set to 2 Step 5 of Thermostat User Configuration Menu must be set to ON for Dehumidification E2 P Switch must be in the E2 position Thermostat Chart Bonnet Sensor Optional Bonnet Sensor BSG Move HUMIDISTAT jumper to YES if humidistat is to be used Part Numbers SAP Legacy 171334 031 09153 pn n Bonnet Sensor Change FFuel jumper on the heat pump control to ON Change Hot Heat Pump jumper on the heat pump control to ON Part Numbers SAP Legacy 126768 031 09137 18395 031 01996 340512 031 09178 Unitary Products Group 246815 YTG D 0108 HP 28C Two Stage Heat Pump Variable Soeed Modulating Furnace With Hot Heat Pump Operation ID MODELS OD MODELS PC9 YZE FC9C YZH FL9C H 5 THERMOSTAT
4. THERMOSTAT e EPU e a M tes DP22U70124 FURNACE HEAT PUMP C C C ess D 24 Volt Common 24 Volt Common 24 Volt Common 24 Volt Common M Y1 Y1 Y1 First Stage Compressor First Stage Compressor Single Stage Compressor Single Stage Compressor R R R R 24 Volt Hot ee Heat XFMR 24 Volt Hot 24 Volt Hot 24 Volt Hot G G G Fan Fan Fan E W W1 OUT Emergency Heat Modulating Heat First Stage Heat W2 W2 OUT Second Stage Aux Heat Second Stage Heat RC Y Y2 24 Volt Hot Second or Full E ia wae A Cool XFMR Stage Compressor g P O B s Bavarsing Valve Reversing Valve A Reversing Valve g Energized in Cool Energized in Cool Malfunction Light Malfunction Light Malfunction Light Y2 Y2 Y2 Second Stage CompressorSecond Stage Compresso Second Stage Compressor AUX E W1 W Auxiliary Heat First Stage Aux Heat Auxiliary Heat HUM jumidistat Dehumidification base AD Open on Humidity Rise Bonnet Sensor Optional BS Bonnet Sensor Thermostat Chart Unitary Products Group 9 246815 YTG D 0108 ACCESSORIES PROPANE LP CONVERSION KIT 1NP0680 All units This accessory conversion kit may be used to convert natural gas N units for propane LP operation Conversions must be made by qualified distributor or dealer personnel CON
5. includes Modulating gas valve Modulating inducer operation e Provides increased comfort level amp very quiet unit opera tion e Compact easy to install ideal height 40 cabinet e Blower off delay for cooling SEER improvement e Easy to connect power control wiring e Built in high level self diagnostics with fault code display e Low unit amp requirement for easy replacement applica tion e Integrated control module for reliable economical opera tion e High velocity filter available for easy field installation e May be installed as either two pipe direct vent or single pipe vent using indoor combustion air e Top intake amp vent connection allows installation in narrow locations e Electronic Hot Surface Ignition saves fuel cost with increased dependability and reliability e Induced combustion system with inshot main burners for quiet efficient operation e No special vent termination kit required e 100 shut off main gas valve for extra safety e ECM High efficiency direct drive motor with large quiet blower e 24V 40 VA control transformer and blower relay supplied for add on cooling e Hi tech tubular aluminized steel primary heat exchanger e Secondary condensing heat exchanger of 29 4C high grade stainless steel e Timed on adjustable off blower capability for maximum comfort e Independent door removal for greater durabilty and ease of access e Easy access from front of unit for cle
6. 6815 YTG C 0606 Unitary 5005 Norman Products York OK Group Drive 73069
7. CENTRIC VENT TERMINATION 1C T0302 2 1CT0303 3 CONDENSATE NEUTRALIZER KIT 1HT0901 Neutralizer cartidge has a 1 2 plastic tube fittings for installa tion in the drain line Calcium carbonate refill media is also avaiable from the Source 1 Parts p n 026 30228 000 SIDEWALL VENT TERMINATION 1HT0901 3 1HT0902 2 For use on sidewall two pipe installations only Provide a more attractive termination for locations where the terminal is visable on the side of the home COMBUSTIBLE FLOOR BASE 1CB0317 17 1 2 Cabinet 1CB0321 21 Cabinet 1CB0324 24 1 2 Cabinet COIL TRANSITION 1TK0917 17 1 2 Cabinet 1TK0921 21 Cabinet 1TK0924 24 1 2 Cabinet Required in downflow applications when using G FD series coils ROOM THERMOSTATS A wide selection of compatible thermosets are available to provide optimum performance and features for any installation 1H 1C manual change over electronic non programmable thermostat 1H 1C auto manual changeover electronic programmable deluxe 7 day thermostat 1H 1C auto manual changeover electronic programmable For the most current accessory information refer to the price book or consult factory Unitary Products Group 246815 YTG D 0108 NOTES Unitary Products Group 14 NOTES Subject to change without notice Printed in U S A 246815 YTG D 0108 Copyright by Unitary Products Group 2008 All rights reserved Supersedes 24
8. N22U00124 PP32U70124 MODULATING AIR FURNACE CONDITIONER C C C b 24 Volt Common 24 Volt Common 24 Volt Common 24 Volt Common Y1 Y1 Y1 Y1 First Stage Compressor First Stage Compressor Single Stage Compressor First Stage Compressor R R R R 24 Volt Hot 24 Volt Hot Heat XFMR Heat XFMR j 24 Volt Hot 24 Volt Hot G G G Fan Fan j Fan E W1 E W1 W First Stage Heat Emergency Heat Modulating Heat W2 AUX Second Stage Heat Auxiliary Heat R R Y Y2 24 Volt Hot 24 Volt Hot Second or Full Cool XFMR Cool XFMR Stage Compressor Y2 Y2 Y2 Second Stage Second Stage Second Stage Compressor Compressor Compressor HUM Dehumidification y Rise Open on Humidity Rise 24VAC Humidifier Optional Thermostat Chart Unitary Products Group 5 246815 YTG D 0108 AC 26B Two Stage Air Conditioner Variable Speed Modulating Furnace ID MODELS PC9 FC9C FL9C THERMOSTAT THERMOSTAT VARIABLE SPEED TWO STAGE DN22C00124 DP22U70124 MODULATING AIR FURNACE CONDITIONER C C C 24 Volt Common 24 Volt Common 24 Volt Common 24 Volt Common Y Y1 Y1 Y1 First Stage C
9. aning maintenance or service e Protection from intake exhaust or condensate blockage e Insulated blower compartment for quiet operation e 3 way transition facilitates fresh air piping FOR DISTRIBUTION USE ONLY NOT TO BE USED AT POINT OF RETAIL SALE 246815 YTG D 0108 T STAT WIRING 7 8 K O HORIZONTAL CONDENSATE DRAIN OPENING 1 3 4 F gt o HORIZONTAL CONDENSATE DRAIN OPENING 2 JUNCTION BOX HOLE 7 8 GAS PIPE ENTRY 1 1 2 CONDENSATE DRAINN HOLE 7 8 SIDE PIPING HOLE 3 3 8 lt 22 1 4 25 3 8 26 1 2 27 1 8 30 1 8 LEFT SIDE To ae 19 1 4 gt BOTTOM IMAGE SUPPLY END DIMENSIONS Cabinet Size 17 1 2 1 TOP IMAGE RETURN END Cabinet Dimension 6 1 4 E T STAT WIRING 7 8 K O HORIZONTAL CONDENSATE DRAIN OPENING 1 3 4 D HORIZONTAL CONDENSATE DRAIN OPENING 1 3 4 JUNCTION BOX HOLE 7 8 GAS PIPE ENTRY 1 1 2 CONDENSATE DRAIN HOLE 7 8 RIGHT SIDE a E _PCaBTeNOGODHTT 120 PcacienosoDHTt oo a PoscientooonT feof CSC PcacentooonT 200 CSCC Pospenvzopni 2000 S a a eT ELECTRICAL AND PERFORMANCE DATA Input Output Nominal Air Temp Rise Air Temp Rise exitin mexan Amou cabinet wae AFUE taimm put Minimum Input 57 20 1200 17 1 2 95 0 40 70 20 50 7 172 40 70 20 50 PPoscTeNosoDHit 80 28 76 26 160 a 0 om 25 POSCTENTOODHTT 100735 95733 160
10. atie Dehumidification panumidcaion Open on Humidity Rise HM 24VAC Humidifer Humidistat Optional Step 1 of Thermostat User Move HUMIDISTAT Configuration Menu must jumper to YES be set to MLTISTG if humidistat is to be used Step 16 of Thermostat Installer Table Menu must be set to ON to use Comfort Alert Features Only applies to PP32U72124 E2 P Switch must be in the E2 position Part Numbers SAP Legacy 171334 031 09153 Optional Harness Thermostat Chart Unitary Products Group 7 246815 YTG D 0108 HP 28A THERMOSTAT PP32U71124 PP32U72124 24 Volt Common Y1 First Stage Compressor R 24 Volt Hot G Fan W2 Second Stage Aux Heat O Reversing Valve Energized in Cool L Malfunction Light Y2 Second Stage Compresso E W1 First Stage Aux Heat DHM Dehumidistat HM Humidistat ID MODELS OD MODELS PC9 YZE FC9C YZH FL9C H 5 H 8 VARIABLE SPEED TWO STAGE MODULATING HEAT PUMP FURNACE VARIABLE SPEED YORKGUARD VI MODULATING CONTROL FURNACE CONTROL C C 24 Volt Common 24 Volt Common Y1 Y1 Single Stage Compressor Single Stage Compressor R R 24 Volt Hot 24 Volt Hot G Fan W W1 OUT Modulating Heat First Stage Heat W2 OUT Second Stage Heat Y Y2 Serre Cia Second ae ae ressor Stage Compressor g p
11. ompressor First Stage Compressor Single Stage Compressor First Stage Compressor R R R R 24 Volt Hot 24 Volt Hot 7 24 Volt Hot D Ch 24 Volt Hot G G G Fan Fan p Fan W E W1 W First Stage Heat First Stage Heat Modulating Heat W2 W2 Second Stage Heat Second Stage Heat Y Y2 Second or Full Stage Compressor Y2 Y2 Y2 Second Stage Second Stage Second Stage Compressor Compressor Compressor HUM Dehumidification Open on Humidity Rise 24VAC Humidifier Optional Thermostat Chart 6 Unitary Products Group 246815 YTG D 0108 AC 26C Two Stage Air Conditioner Variable Speed Modulating Furnace ID MODELS PC9 FC9C FL9C THERMOSTAT VARIABLE SPEED PP32U71124 z TWO STAGE A MODULATING AIR PP32U72124 FURNACE CONDITIONER VARIABLE SPEED MODULATING FURNACE CONTROL C C C 24 Volt Common 24 Volt Common 24 Volt Common Y1 Y1 Y1 First Stage Compressor Single Stage Compressor First Stage Compressor R R R 24 Volt Hot 24 Volt Hot 24 Volt Hot G G Comfort Alert Interface Fan Fan two pin connector E W1 W First Stage Heat Modulating Heat W2 Second Stage Heat Y Y2 Second or Full Stage Compressor L Malfunction Light Y2 Y2 Second Stage Second Stage Compressor Compressor HUM DHM S
12. ual YORK Heating and Air Conditioning TECHNICAL GUIDE AFFINITY MODELS PC9 DH GAS FIRED CONDENSING HIGH EFFICIENCY DOWNFLOW HORIZONTAL MODULATING FURNACES WITH ECM MOTOR NATURAL GAS 60 120 MBH INPUT G an To COnStmap a Good Housekeeping RATING a j a me uenn IIS ES aS ERTIF ES Ar z TE S ET REGIS L AT l ISO 9001 ENERGY STAR Certified Quality Management System Due to continuous product improvement specifications are subject to change without notice Visit us on the web at www york com for the most up to date technical information Additional rating information can be found at www gamanet org 246815 YTG D 0108 DESCRIPTION These Category IV highly efficient compact condensing type furnaces are designed for residential and commercial installations in a basement closet alcove recreation room or garage where the ambient temperature is above 32 F or higher They may be either side wall or thru roof vented using approved plastic type combustion air and vent piping All units are factory assembled wired and tested to assure dependable and economical installation and operation WARRANTY Lifetime limited warranty on both heat exchangers to the orig inal purchaser a 20 year limited warranty from original instal lation date to subsequent purchaser 10 year warranty on the heat exchanger in commercial appli cations 5 year limited parts warranty FEATURES e Modulating heating operation
13. variable speed motors that automatically adjust to provide constant CFM from 0 0 to 0 6 w c static pressure From 0 6 to 1 0 static pressure CFM is reduced by 2 per 0 1 increase in static Operation on duct systems with greater than 1 0 w c external static pressure is not recommended NOTE At some settings LOW COOL airflow may be lower that what is required to operate an airflow switch on certain models of electronic air cleaners Consult the instructions for the electronic air cleaner for further details NOTES 1 Airflow expressed in standard cubic feet per minute CFM Unitary Products Group 3 246815 YTG D 0108 FILTER PERFORMANCE FILTER SIZES The airflow capacity data published in the Blower Perfor mance table listed above represents blower performance CFM Cabinet Top Return WITHOUT filters To determine the approximate blower per size Filter in formance of the system apply the filter drop value for the fil P1200 B 14x20 ter being used or select an appropriate value from the Filter 60 ce 8 14 20 E ees 2000 14x20 NOTE The filter pressure drop values in the Filter Perfor 200 f D 2 14 x 20 mance table shown are typical values for the type of filter NOTE All filters must be high velocity cleanable type listed and should only be used as a guideline Actual pres sure drop ratings for each filter type vary between filter manu facturer FILTER PERFORMANCE PRESSURE
Download Pdf Manuals
Related Search