Weed Eater 530088895 Operator's Manual
Contents
1. the proper length The line limiter blade on underside of shield is sharp and can cut you e Remove wing nut from shield e Insert bracket into slot as shown e Pivot shield until bolt passes through hole in bracket e Securely tighten wing nut onto bolt Slot Na Bracket Shield FUEL YOUR UNIT This engine is certified to operate on un leaded gasoline Gasoline must be mixed with a good quality 2 cycle air cooled engine oil designed to be mixed at a ratio of 40 1 Poulan Weed Eater brand oil is recom mended A 40 1 ratio is obtained by mixing 3 2 ounces of oil with 1 gallon of unleaded gasoline When mixing fuel follow the instructions printed on the container Always read and follow the safety rules under FUEL SAFETY STARTING HOW TO STOP YOUR UNIT To stop engine move ON OFF switch to the OFF position Primer Bulb i HOW TO START YOUR UNIT WARNING The trimmer head will turn while starting the engine A hot muffler can cause serious burns STARTING A COLD ENGINE or a warm engine after running out of fuel e Set unit on a flat surface Move ON OFF switch to the ON position Slowly press the primer bulb 6 times Move choke lever to FULL CHOKE posi tion Squeeze the throttle trigger fully and hold through all remaining steps e Pull starter rope handle sharply 6 times e Move choke lever to HALF CHOKE posi tion e Pull starter rope handle no more than 6 pulls until engin2. 6 U S EPA ENVIRONMENT CANADA EMISSION CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OB LIGATIONS The U S Environmental Protection Agency Environment Canada and POULAN WEED EATER DIVISION OF WCI OUTDOOR PRODUCTS are pleased to ex plain the emissions control system warranty on your lawn and garden equipment engine All new utility and lawn and garden equipment engines must be designed built and equipped to meet the stringent anti smog standards POULAN WEED EATER must warrant the emission control system on your lawn and garden equipment engine for the pe riods of time listed below provided there has been no abuse neglect or improper mainte nance of your lawn and garden equipment en gine Your emission control system includes parts such as the carburetor and the ignition system Where a warrantable condition exits POULAN WEED EATER will repair your lawn and garden equipment engine at no cost to you Expenses covered under warranty in clude diagnosis parts and labor MANUFAC TURER S WARRANTY COVERAGE If any emissions related part on your engine as listed under Emissions Control Warranty Parts List is defective or a defect in the mate rials or workmanship of the engine causes the failure of such an emission related part the part will be repaired or replaced by POULAN WEED EATER OWNER S WARRANTY RESPONSIBILITIES As the lawn and gar den equipment engine owner you are re sponsible for the perf
3. WEED EATER Trademark Por favor no devuelva el aparato al lugar de compra Veuillez ne pas retourner l outil au d taillant 1 800 554 6723 www weedeater com Please do not return unit to retailer Operator s Manual Manual del Operador Manuel de L utilisateur TWIST N EDGE TE 400 CXL For Occasional Use Only WARNING Read and follow all Safety Rules and Operating Instructions before using this product Failure to do so can result in serious injury ADVERTENCIA Lea el manual del operador y siga todas las advertencias e instruc ciones de seguridad El no hacerlo puede resultar en lesiones gra ves AVERTISSEMENT Lire le manuel de l utilisateur et bien respecter tous les avertisse ments et toutes les instructions de s curit Tout d faut de le faire pourrait entra ner des blessures graves Electrolux Home Products Electrolux Home Products North America North America Div of WCI Outdoor Products Inc Div of WCI Outdoor Products Inc Augusta GA 30907 Mississauga Ontario 15T 1K6 Copyright 2000 WCI Outdoor Products Inc 530088895 11 13 00 m Z Q un I TONVdS3 SIVONVHA SAFETY RULES WARNING When using gardening appliances basic safety precautions should always be followed to reduce the risk of fire and serious injury Read and follow all instructions This power unit can be dangerous Operator is responsible for following unit and manual instructions and warning
4. ask We recommend that you take your unit to an Authorized Service Dealer Damage will oc cur if you turn the needles beyond the limiter stops IGNITION TIMING The ignition timing is fixed non adjustable SPARK PLUG Replace the spark plug yearly using a Cham pion RCJ 8Y plug Spark plug gap is 0 025 NEED ASSISTANCE Need Assistance Call 1 800 554 6723 Need Service Parts Contact your dealer TROUBLESHOOTING TABLE A WARNING Always stop unit and disconnect spark plug before performing any of the recommended remedies below other than remedies that require operation of the unit Spark plug not firing TROUBLE CAUSE REMEDY Engine will not e Engine flooded e See Starting start Fuel tank empty e Fill tank with correct fuel mixture Fuel not reaching carburetor Carburetor requires adjustment e See Carburetor Adjustments e Install new spark plug e Check for dirty fuel filter replace Check for kinked or split fuel line repair or replace Engine will not idle properly Throttle trigger screw too tight Carburetor requires adjustment e See Carburetor Adjustments e Loosen screw Engine will note Air filter dirty accelerate e Spark plug fouled lacks power or dies under Carburetor requires adjustment e Clean or replace air filter Clean or replace spark plug re gap See Carburetor Adjustments excessively Air filter dirt
5. e runs e Allow engine to run 10 seconds then move choke lever to OFF CHOKE position RESTARTING A WARM ENGINE Move ON OFF switch to the ON position Move choke lever to OFF CHOKE position e Pull starter rope handle until engine runs e If engine does not start in 5 pulls follow instructions in STARTING A COLD EN GINE USING YOUR UNIT OPERATING POSITION Cut from your right to your left TRIMMER LINE ADVANCE The cutting head advances line automatically Do not tap head on the ground to advance line This may break parts and cause cutting head to malfunction Upon unit start up the line will advance auto matically to the correct cutting path length Always keep the shield in place when the tool is being operated TWIST N EDGE e Pull the tab toward the engine e Twist the tube to the edging position release the tab Tab _ REPLACING THE LINE Pre wound spools offer the most convenient method for replacing line and ensuring opti mum performance e Replacement spools are color coded to ensure use of the correct spool with your unit Be sure to use the same color spool as the existing spool NOTE Always clear dirt and debris from cut ting head components when performing any type of maintenance e Hold spool and unscrew cap by turning in the direction shown on top of the cap e Remove line guide ring and spool Line guide ring Cap e Use a pre wound spool or refill spool with line If
6. ial light TRANSPORTING AND STORAGE e Allow the engine to cool secure unit before storing or transporting in vehicle e Empty the fuel tank before storing or trans porting the unit Use up fuel left in the car buretor by starting the engine and letting it run until it stops Store unit and fuel in an area where fuel va pors cannot reach sparks or open flames from water heaters electric motors or switches furnaces etc e Store unit so line limiter cannot accidentally cause injury Unit can be hung by the tube e Store the unit out of the reach of children If situations occur which are not covered in this manual use care and good judgment If you need assistance call 1 800 554 6723 SAFETY NOTICE Exposure to vibrations through prolonged use of gasoline powered hand tools could cause blood vessel or nerve damage in the fingers hands and joints of people prone to circulation disorders or ab normal swellings Prolonged use in cold weather has been linked to blood vessel dam age in otherwise healthy people If symptoms occur such as numbness pain loss of strength change in skin color or texture or loss of feeling in the fingers hands or joints discontinue the use of this tool and seek med ical attention An anti vibration system does not guarantee the avoidance of these prob lems Users who operate power tools on a continual and regular basis must monitor closely their physical condition and the condi tio
7. med at no charge to the owner at an ap proved POULAN WEED EATER servicing center If you have any questions regarding your warranty rights and responsibilities you should contact your nearest authorized ser vice center or call POULAN WEED EATER at 1 800 554 6723 WARRANTY PERIOD Any warranted part which is not scheduled for replacement as required maintenance or which is scheduled only for regular inspection to the effect of repair or replace as neces sary shall be warranted for 2 years Any war ranted part which is scheduled for replace ment as required maintenance shall be warranted for the period of time up to the first scheduled replacement point for that part DIAGNOSIS The owner shall not be charged for diagnostic labor which leads to the determination that a warranted part is de fective if the diagnostic work is performed at an approved POULAN WEED EATER serv icing center CONSEQUENTIAL DAM AGES POULAN WEED EATER may be li able for damages to other engine components caused by the failure of a war ranted part still under warranty WHAT IS NOT COVERED All failures caused by abuse neglect or improper maintenance are not covered ADD ON OR MODIFIED PARTS The use of add on or modified parts can be grounds for disallowing a warranty claim POULAN WEED EATER is not liable to cover failures of warranted parts caused by the use of add on or modified parts HOW TO FILE A CLAIM If you have any questions regarding your wa
8. n of this tool SPECIAL NOTICE This unit is equipped with a temperature limiting muffler and spark arresting screen which meets the require ments of California Codes 4442 and 4443 All U S forest land and the states of California Idaho Maine Minnesota New Jersey Ore gon and Washington require by law that many internal combustion engines be equipped with a spark arresting screen If you operate in a locale where such regulations ex ist you are legally responsible for maintaining the operating condition of these parts Failure to do so is a violation of the law For normal homeowner use the muffler and spark arrest ing screen will not require any service After 50 hours of use we recommend that your muffler be serviced or replaced by your Au thorized Service Dealer ASSEMBLY WARNING Make sure your unit is properly assembled and all fasteners are se cure ATTACHING THE HANDLE Groove e Assemble handle to the unit as shown make sure bottom of handle is seated in the groove in the trigger housing NOTE Wing nut must be assembled on the side of the unit opposite the operator s posi tion e Pivot handle to a comfortable position Tighten handle securely ATTACHING THE SHIELD A WARNING The shield must be prop erly installed The shield provides partial protection from the risk of thrown objects to the operator and others and is equipped with a line limiter blade which cuts excess line to
9. ormance of the required maintenance listed in your Owner s Manual POULAN WEED EATER recommends that you retain all receipts covering maintenance on your lawn and garden equipment engine but POULAN WEED EATER cannot deny warranty solely for the lack of receipts or for your failure to ensure the performance of all scheduled maintenance As the lawn and garden equipment engine owner you should be aware that POULAN WEED EATER may deny you warranty coverage if your lawn and garden equipment engine or a part of it has failed due to abuse neglect improper mainte nance unapproved modifications or the use of parts not made or approved by the original equipment manufacturer You are responsi ble for presenting your lawn and garden equipment engine toa POULAN WEED EAT ER authorized repair center as soon as a problem exists Warranty repairs should be completed in a reasonable amount of time not to exceed 30 days If you have any ques tions regarding your warranty rights and re sponsibilities you should contact your near est authorized service center or call POULAN WEED EATER at 1 800 554 6723 WARRANTY COM MENCEMENT DATE The warranty period begins on the date the lawn and garden equip ment engine is purchased LENGTH OF COVERAGE This warranty shall be for a pe riod of two years from the initial date of pur chase WHAT IS COVERED REPAIR OR REPLACEMENT OF PARTS Repair or re placement of any warranted part will be per for
10. rds is recommended e Always wear foot protection Do not go barefoot or wear sandals Stay clear of spinning line Secure hair above shoulder length Se cure or remove loose clothing or clothing with loosely hanging ties straps tassels etc They can be caught in moving parts Being fully covered also helps protect you from debris and pieces of toxic plants thrown by spinning line Stay Alert Do not operate this unit when you are tired ill upset or under the influ ence of alcohol drugs or medication e Wear hearing protection Never start or run inside a closed room or building Breathing exhaust fumes can kill e Keep handles free of oil and fuel UNIT MAINTENANCE SAFETY e Disconnect the spark plug before perform ing maintenance except carburetor adjust ments Look for and replace damaged or loose parts before each use Look for and repair fuel leaks before use Keep in good work ing condition Replace trimmer head parts that are chipped cracked broken or damaged in any other way before using the unit Maintain unit according to recommended procedures Keep cutting line at proper length Use only 0 080 2 mm diameter Poulan Weed Eater brand line Never use wire rope string etc Install required shield properly before using the unit Use only specified trimmer head make sure it is properly installed and se curely fastened Make sure unit is assembled correctly as shown in this man
11. rranty rights and responsibilities you should contact your nearest authorized ser vice center or call POULAN WEED EATER at 1 800 554 6723 WHERE TO GET WAR RANTY SERVICE Warranty services or re pairs shall be provided at all POULAN WEED EATER service centers call 1 800 554 6723 MAINTENANCE REPLACEMENT AND RE PAIR OF EMISSION RELATED PARTS Any POULAN WEED EATER approved replace ment part used in the performance of any war ranty maintenance or repair on emission re lated parts will be provided without charge to the owner if the part is under warranty EMIS SION CONTROL WARRANTY PARTS LIST Carburetor Ignition System Spark Plug covered up to maintenance schedule Ignition Module MAINTENANCE STATE MENT The owner is responsible for the per formance of all required maintenance as de fined in the owner s manual The information on the product label indicates which standard your engine is certified Example Year EPA Phase 1 or Phase 2 and or CALIFORNIA IMPORTANT ENGINE INFORMATION THIS ENGINE CONFORMS TO EMISSIONS REGULATIONS FOR SMALL OFF ROAD ENGINES FAMILY DISP SERIAL REFER TO OWNER S MANUAL FOR MAINTENANCE SPECIFICATIONS AND ADJUSTMENTS
12. s Read entire Oper ator s Manual before using unit Be thorough ly familiar with the controls and the proper use of the unit Restrict the use of this unit to per sons who read understand and follow unit and manual instructions and warnings Never allow children to operate this unit amp S gt LL OPERATORS MANUAL SAFETY INFORMATION ON THE UNIT A DANGER Never use blades wire or flailing devices This unit is designed for line trimmer use only Use of any other accesso ries or attachments will increase the risk of injury SOO A WARNING Trimmer line throws ob jects violently You and others can be blinded injured Wear safety glasses and leg protec tion Keep body parts clear of rotating line Safety Glasses or similar eye protection Keep children bystanders and animals 50 feet 15 meters away If approached stop unit immediately If situations occur which are not covered in this manual use care and good judgement If you need assistance contact your Authorized Service Dealer or call 1 800 554 6723 OPERATOR SAFETY e Dress properly Always wear safety glasses or similar eye protection when op erating or performing maintenance on your unit safety glasses are available Eye protection should meet the require ments of ANSI Z87 1 e Always wear face or dust mask if operation is dusty e Always wear heavy long pants long sleeves boots and gloves Wearing safety leg gua
13. ses 30 DAYS Parts and Labor if used for rental purposes This warranty is not transferable and does not cover damage or liability caused by improper handling improper maintenance or the use of accessories and or attachments not specifically recommended by ELECTROLUX HOME PRODUCTS NORTH AMERICA for this tool Additionally this warranty does not cover tune ups spark plugs filters starter ropes starter springs cutting line or rotating head parts that will wear and require replacement with reason able use during the warranty period This war ranty does not cover predelivery setup or nor mal adjustments explained in the operator s manual THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE NO CLAIMS FOR CONSEQUENTIAL OR OTHER DAMAGES WILL BE ALLOWED AND THERE ARE NO OTHER EXPRESS WARRANTIES EXCEPT THOSE EX PRESSLY STIPULATED HEREIN SOME STATES DO NOT ALLOW LIMITA TIONS ON HOW LONG AN IMPLIED WAR RANTY LASTS OR THE EXCLUSION OR LIMITATIONS OF INCIDENTAL OR CONSE QUENTIAL DAMAGES SO THE ABOVE LIMITATIONS OR EXCLUSION MAY NOT APPLY TO YOU ELECTROLUX HOME PRODUCTS NORTH AMERICA S policy is to continuously improve its products Therefore ELECTROLUX HOME PRODUCTS NORTH AMERICA reserves the right to change modify or discontinue models designs specifications and accessories of all products at any time without notice or obligation to any purchaser
14. ual Make carburetor adjustments with lower end supported to prevent line from contact ing any object Keep others away when making carburetor adjustments Use only recommended Poulan Weed Eat er accessories and replacement parts Have all maintenance and service not ex plained in this manual performed by an au thorized service dealer FUEL SAFETY e Mix and pour fuel outdoors Keep away from sparks or flames Use a container approved for fuel Do not smoke or allow smoking near fuel or the unit Avoid spilling fuel or oil Wipe up all fuel spills Move atleast 10 feet 3 meters away from fueling site before starting engine Stop engine and allow to cool before re moving fuel cap e Always store gasoline in a container ap proved for flammable liquids CUTTING SAFETY WARNING Inspect the area before each use Remove objects rocks broken glass nails wire etc which can be thrown by or become entangled in line Hard objects can damage trimmer head and be thrown causing serious injury e Use only for trimming mowing edging and sweeping Donotuse for pruning or hedge trimming Keep firm footing and balance Do not over reach Keep all parts of your body away from spin ning line and muffler Keep engine below waist level A hot muffler can cause serious burns e Cutting with the line on left side of the shield will throw debris away from the operator e Use only in daylight or good artific
15. using a pre wound spool remove tape strip from line and spool REFILLING THE SPOOL WITH LINE WARNING Use only 0 080 2 mm diameter round line Other sizes and shapes of line will not advance properly and will result in improper cutting head function or can cause serious injury Do not use other materi als such as wire string rope etc Wire can break off during cutting and become a dan gerous missile that can cause serious injury e Cut a length of 30 feet of 0 080 2 mm di ameter round Poulan Weed Eater brand line Feed line in direction shown on spool Spool e Insert one end of line into center cavity of empty spool Ensure line will feed into spool in the direction shown on the spool counterclockwise e Continue feeding line into spool leaving 4 6 inches 10 15 cm unwound from center of spool INSTALLING SPOOL WITH LINE e Install replacement spool e Thread line through line guide ring Line through guide ring Replacement Spool e Rest guide ring on spool and place line in slot Allow line to extend 4 6 inches 10 15 cm from center of spool e Ensure line remains in slot while screwing ranted to the shaft Only tighten cap hand tight SERVICE We recommend all service and adjustments not listed in this manual be performed by an Authorized Service Dealer CARBURETOR ADJUSTMENTS Your carburetor is equipped with limiter caps Carburetor adjustment is a complicated t
16. y a load Engine e Fuel mixture incorrect e Empty fuel tank and refill with smokes correct fuel mixture e Carburetor requires adjustment e Clean or replace air filter e See Carburetor Adjustments Line does not e Line improperly routed in head e Check line routing advance or e Line improperly routed through See Replacing the line breaks while line guide ae cutting e Line size incorrect e Use only 0 080 2 mm dia line Line welds e Line size incorrect e Use only 0 080 2 mm dia line onto spool e Incorrect spool e Replace with correct spool e Line is being crowded against e Cut with tip of line fully extended material being cut Line pulls e Too little line outside of head Remove spool and pull 4 6 inches back into 10 15 cm of line outside of head head e Line size incorrect e Use only 0 080 2 mm dia line LIMITED WARRANTY ELECTROLUX HOME PRODUCTS NORTH AMERICA Division of WCI Outdoor Prod ucts Inc warrants to the original purchaser that each new Weed Eater brand gasoline tool or at tachment is free from defects in material and workmanship and agrees to repair or replace under this warranty any defective gasoline prod uct or attachment as follows from the original date of purchase 2 YEARS Parts and Labor when used for household purposes 90 DAYS Parts and Labor when used for commercial professional or income producing purpo
Download Pdf Manuals
Related Search