Vector VEC270MG User's Manual
Contents
1. 6 3 OPERATION RECHARGING 200044444 4 020 60 9 3 1 120 Volt AC Recharging ccccccecceeseeeeeceeeeneeeeceeeeeeseeeeeesaeeeeaeeeeeeeee 9 3 2 12 Volt Recharging cccccccceeceesceeeeeeeeeeeeeeaaeeeeeeeseeeesaeeeeeneeeeaees 10 3 3 Battery Indicator 0 2 0 0 000 10 4 OPERATION AS A PORTABLE COMPRESSOR 10 4 1 Tire Inflation or Products With A Valve Stem 11 4 2 Other Inflatables Without Valve 11 4 3 Typical Inflation Times For Products Without Valve 12 5 OPERATION AS 12 VOLT PORTABLE POWER 5 12 5 1 Estimated 12 Volt DC Usage 12 6 EMERGENCY WORKLIGHT 13 7 REPLACEMENT 2 44040 0 13 7 1 Bulb 13 7 2 Battery 13 7 3 Battery DISPOSAl sissies i aaa a a Ean ARAS 14 8 SPECIFICATIONS 14 9 VECTOR ONE YEAR LIMITED WARRANTY 142. of POWER VEC270MG 260 PSI AIR COMPRESSOR CORDLESS e RECHARGEABLE OWNER S MANUAL amp WARRANTY INFORMATION Features Inflation Uses Power Uses 12 Volt Compact Car Tires Cellular Phones Lightweight Bicycle Tires Lights Portable Minivan Tires Radios Powerful Sports Equipment Small Appliances Rugged Air Mattresses TVs IMPORTANT SAFETY INFORMATION SAVE THESE INSTRUCTIONS THIS MANUAL CONTAINS IMPORTANT INFORMATION REGARDING SAFETY OPERATION MAINTENANCE AND STORAGE OF THIS PRODUCT BEFORE USING READ AND UNDERSTAND ALL CAUTIONS WARNINGS INSTRUCTIONS AND PRODUCT LABELS PLUS YOUR VEHICLE S BATTERY AND INFLATABLE S MANUFACTURER GUIDELINES FAILURE TO DO SO COULD RESULT IN INJURY AND OR PROPERTY DAMAGE 4140 SW 28TH WAY FT LAUDERDALE FL 33312 TEL 954 584 4446 TOLL FREE 866 584 5504 FAX 954 584 5556 WECTOR Page 2 of 16 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE VEC270MG WECTOR R TABLE OF CONTENTS VEC270MG 1 SAFETY INFORMATION AND INSTRUCTIONS 4 1 1 Safety SYMDOIS esitasin 4 1 2 Charging INStruCtiOnS 0 c ccceeccececeeeeeeeceeeeeceaeeeeaaeeeeneeseaeeeesaaeeseeeeeeaees 4 A MAMAS Sia 4 B of 4 Maintenance Recharge Stored 5 D General Safety 5 2
3. 3 Remove the fluorescent tubes 4 Replace with new tubes 5 Snap the lens cover back into place 6 Replace clockwise the screw and carefully tighten Do not over tighten 7 2 Battery Replacement It is recommended that the unit be returned to Vector Customer Service for battery replacement Contact 954 584 4446 or toll free 866 584 5504 Page 13 of 16 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE VEC270MG WECTOR WARNING Do not dispose of the battery in fire as this may result in an explosion Before disposing of the battery protect exposed terminals with heavy duty electrical tape to prevent shorting shorting can result in injury or fire Do not expose battery to fire or intense heat as it may explode 7 3 Battery Disposal The VEC270MG contains a maintenance free non spillable sealed lead acid battery this battery is fully recyclable and should be accepted at any location that accepts common automotive starter batteries Examples of places that accept these batteries are County or municipal recycling drop off centers scrap metal dealers and retailers who sell automotive replacement lead acid starter batteries For more information on recycling this battery call toll free 877 288 7722 8 SPECIFICATIONS Model VEC270MG Voltage 12 VDC Battery Type s 2 Sealed high energy density AGM lead acid rechargeable maintenance free 6 volt DC 4 5 Amp hour Bulb Twin Tubes 2 Fl
4. Page 3 of 16 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE VEC270MG WECTOR 1 SAFETY INFORMATION AND INSTRUCTIONS 1 1 Safety Symbols The following symbols will be used throughout this manual DANGER indicates an imminently hazardous situation which if not avoided WILL result in death or serious injury WARNING indicates a potentially hazardous situation which if not avoided COULD result in death or serious injury 4 CAUTION indicates a hazardous situation which if not avoided MAY result in minor or moderate injury NOTICE indicates important information that if not followed may cause damage to equipment The following safety precautions must be followed at all times along with any additional existing safety rules 1 2 Charging Instructions For best results charge the battery in temperatures ranging from 65 degrees F 18 degrees C to 75 degrees F 24 degrees C Inflator must be charged at least 24 hours using the 120 volt AC method prior to initial use A Initial Use 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE is shipped in a partially charged state not fully charged The battery must be charged using the 120 volt AC before the initial use B End of use Recharge When charge indicator runs down recharge product before storing away using the 120 volt AC Page 4 of 16 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE VEC270MG WECTOR C Maintenance Recharge Stored ltem
5. VECTOR MANUFACTURING Ltd 4140 SW 28th Way Fort Lauderdale FL 33312 PH 954 584 4446 FREE 866 584 5504 Fax 954 584 5556 You may also contact us at our web site www vectormfg com WARRANTY IS NON TRANSFERABLE AND NON REFUNDABLE 2004 VECTOR MANUFACTURING Ltd FT LAUDERDALE FL 33312 MADE IN CHINA
6. Recharge the unit every 3 to 6 months even if the unit has not been used D General Safety Precautions 1 Completely read this product manual as well as all interactive applicable manufacturers and or vehicles manuals and safety guidelines 2 Be familiar with the proper use of the unit and all interactive applicable manufacturers products 3 Never exceed recommended pressures or over inflate tires inflatable items Bursting articles can cause serious injury Always check pressure with the pressure gauge It is recommended to wear protective eyewear when inflating tires inflatable items 4 Always wear protective clothing i e no vinyl and eyewear when using this product contact with battery acid may cause blindness and or severe burns Be aware of first aid 5 Never recharge more than 18 hours maximum using 12 volt DC method more than 24 hours maximum using 120 volt AC method 6 reduce risk of damage to plug cord pull by plug and not the cord when disconnecting 7 Never operate charger if it has received a sharp blow been dropped or otherwise damaged in any way take it to a qualified service technician or call Vector Customer Service 8 Never disassemble take unit to a qualified service technician or call Vector Customer Service when service or repair is required Incorrect reassembly may result in a risk of electric shock or fire and will void the warranty 9 To reduce risk of electric shock unplug c
7. 0 volt UL listed AC DC Charging Adapter Cord 12 DC Charging Adapter Cord 13 Analogue Dial Pressure Gage 12 11 Page 8 of 16 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE VEC270MG Freedom of POWER 10 R pe 3 OPERATION RECHARGING gt NOTICE BATTERY MUST BE CHARGED BEFORE INITIAL USE IS RECOMMENDED TO USE 120 VOLT AC ADAPTER If the power is totally drained from the battery and not recharged the battery may not be rechargeable 3 1 CAUTION This unit is NOT intended for recharging a vehicle s battery Never start the vehicle when the 12 volt DC recharging adapter is plugged into the vehicle accessory outlet Never insert anything other than the supplied power recharging cords or recommended appliance power recharging cords into the charging or power outlet on this unit NOTICE Charging the battery while the vehicle s engine is not running is not recommended as it could drain the vehicle s battery If the unit is used too long after the red light comes on recharging could take up to 7 hours 120 Volt AC Recharging IMPORTANT The unit s power ON OFF switch MUST be OFF when the unit is charging or not in use To recharge the battery using the 120 volt AC adapter follow these procedures 1 Push the power switch to the Off position and insert the 120 volt AC recharging adapter into the AC recharge adapter barrel connector outlet located next to the bat
8. ar water do not allow electrical cords and outlets to become moist damp or wet electrical shock could result Always protect the unit from rain snow or other sources of moisture When charging unit from a 120 volt AC electrical outlet make sure area is dry It is recommended to use an outlet complete with a Ground Fault Interrupt Switch Keep unit out of reach of children whether stored or in use All On Off switches should be in the OFF position when the unit is charging or not in use Make sure all switches are in the OFF position before connection to a power source or load There is a risk of explosive gases being released when lead acid batteries are being charged or discharged Failure to follow instructions may cause property damage explosive hazard and or personal injury DO NOT over inflate tires inflatable items Although this unit contains a sealed non spillable lead acid battery it is recommended to be kept upright during storage use and recharging When using this unit in proximity to vehicle s battery and engine stand the unit on a flat stable surface and be sure to keep all clamps cords clothing and body parts away from moving vehicle components Do not smoke or use flammable items matches cigarette lighters etc while working on or near a vehicle s battery or engine system CA Prop WARNING This product contains chemicals known to the state of CA to cause cancer or reproductive toxicity Check un
9. ation and charges if applicable You may also contact us through our website www vectormfg com STATE LAW RIGHTS This warranty gives you specific legal rights Some states do not allow limitations on how long an implied warranty lasts or the exclusion or limitation of incidental or consequential damages so the exclusions or limitations stated herein may not apply This warranty gives the purchaser specific legal rights other rights which vary from state to state may apply TO REQUEST WARRANTY SERVICE FOR THIS PRODUCT Contact Vector Manufacturing Technical Support by telephone fax or mail We suggest that you Page 15 of 16 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE VEC270MG WECTOR keep the original packaging in case you need to ship the unit When returning a product include your name address phone number dated sales receipt or copy and a description of the reason for return and product serial number After repairing or replacing the unit we will make every effort to return it to you within four weeks WARRANTY ACTIVATION Please complete Warranty Activation Card and mail to Vector Manufacturing Enter VEC270MG as Model and 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE as Product All Vector Manufacturing Ltd products must be registered within 10 days of purchase to activate this warranty Mail the completed registration card along with a copy of the original sales receipt to ATIN CUSTOMER SERVICE
10. d LEDs will light when recharging the battery 4 OPERATION AS A PORTABLE COMPRESSOR INFLATOR WARNING Do not leave the inflator unattended while the unit is running The universal adapter must be locked to secure the inflation accessories Any misuse could cause property damage or personal injury Use extreme caution when using inflation accessories CAUTION Turn unit off to allow inflator to cool for 10 minutes after 15 minutes of continuous operation If not cooled properly the inflator will overheat NOTICE Make sure the universal adapter touches the core of tire valve stem The compressor is capable of inflating up to 260 pounds per square inch PSI pressure To avoid over inflation carefully follow instructions on articles to be inflated DANGER Read all manufacturers safety guidelines Never exceed recommended pressures Bursting articles can cause serious injury Always check pressure with the pressure gauge Never leave compressor unattended while in use Page 10 of 16 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE VEC270MG WECTOR R After the battery is charged the inflator is ready for use If the battery has not been charged please see section 3 1 120 Volt AC Charging before continuing 1 2 3 4 5 4 1 Remove valve stem cap and attach the universal adapter from the air inflator to the valve stem with the lever in the up position Be sure to press universal adapter down o
11. ge in the battery Charge level can be viewed when the charge PUSH FOR STATUS button switch is pressed When pressed the CHARGE STATUS button will show the battery s power level status from Low to Full The green LED full indicator illuminates when the unit is fully recharged and charging can be discontinued 12 volt DC accessory outlet is provided for use with appliances that can operate from a vehicle 12 volt DC accessory outlet This allows maximum portability and utility when the VEC270MG is used in remote locations i 08 07 z The VEC270MG can be recharged from any standard 120 volt AC power source using the supplied AC recharge adapter The adapter s barrel connector attaches to the recharge port on the side panel A built in 12 volt appliance outlet and the appropriate DC DC charging adapter cord is used to recharge the battery from another 12 volt DC source A LAMP ON OFF switch operates the built in fluorescent work emergency light Page 7 of 16 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE VEC270MG WECTOR 1 Built in Twin Fluorescent Tube Emergency Worklight 2 ON OFF Compressor s Power Switch 3 LAMP ON OFF Switch for worklight 4 AC Recharge Adapter Barrel Connector Outlet 5 LED Charging Battery Status Indicators 6 Charge Status Push Button 7 12 Volt DC Accessory Outlet with 15 Amp Overload Protection 8 Air Vent 9 Rubberized Handle and Base 10 20 Air Hose and Coupler 11 12
12. harger from outlet before attempting to clean 10 Always recharge unit after each use recommended 120 volt AC method 11 Avoid charging the battery at temperatures below 40 degrees 5 degrees above 105 degrees 40 degrees 12 Never operate the unit near fire flammable gas or liquid Never expose battery to fire or intense heat as it may explode Before disposing of the battery protect exposed terminals with heavy duty electrical tape to prevent shorting shorting can result in injury or fire 13 Never operate the inflator after the battery indicator light comes on 14 Never operate the inflator with the 120 volt AC recharging adapter connected to the unit as the charger could become damaged 15 Never leave unit unattended while in use Page 5 of 16 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE VEC270MG WECTOR 16 17 18 19 20 21 22 23 24 R Never put metal objects into the 12 volt DC power outlet Never insert anything other than the supplied power recharging cords or recommended appliance power recharging cords into the 12 volt DC charging power outlet on this unit Do not use any accessory that is not recommended or provided by the manufacturer Use only the supplied cords adapters for recharging this unit Always replace the fuse with the same type and amp rating Never use a higher amperage fuse rating Never submerge this unit in water When charging the unit ne
13. it periodically for wear and tear Replace worn or defective parts immediately contact Vector Customer Service at 954 584 4446 or toll free 866 584 5504 2 INTRODUCTION Congratulations on selecting the VEC270MG 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE This system is an advanced high pressure up to 260 PSI multi use air compressor system and 12 volt power source that will provide years of reliable service if maintained properly Page 6 of 16 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE VEC270MG WECTOR The Freedom of POWER The 270 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE is a compact durable and portable system that features e Standard tire valve chuck e Twin fluorescent worklight and e 12 volt DC power source and outlet It is ideal for use with Vector 12 volt DC cordless portable rechargeable products SST DC AC Power Inverters Use the VEC270MG 260 PSI AIR COMPRESSOR CORDLESS e RECHARGEABLE to Operate 12 volt DC fans inflators fluorescent worklights cell phones spotlights TVs portable radios cassette or CD players and more Can quick charge a cellular phone by using the phone s 12 volt DC adapter cord Operate Certain 120 volt AC accessories requires a Vector 12 volt power inverter sold separately The VEC270MG system has an easy to read series of LED Light Emitting Diode charge indicators that show when the unit is fully charged or the level of char
14. lve Stem Inflation of other items requires use of one of the adapters nozzles Page 11 of 16 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE VEC270MG WECTOR 1 Select the appropriate nozzle located on the inside back cover Insert appropriate adapter i e needle into connector chuck and close thumb latch 3 Refer to Typical Inflation Times for approximate pressure and time Small items such as volleyballs footballs etc inflate very rapidly 4 Insert adapter needle into item to inflate to appropriate pressure 5 ON compressor switch inflate to desired pressure or fullness 6 Remove adaptor 4 3 Typical Inflation Times For Products Without Valve Stems The following are approximate pressure and inflation times for various items WARNING Always follow tire manufacturers recommendations for pressure to be inflated Inflatable Pressure Time From 0 Articles Pressure Football 13 PSI 24 seconds Basketball 9 PSI 20 seconds Volleyball 5 PSI 6 seconds 5 OPERATION AS A 12 VOLT PORTABLE POWER SOURCE NOTICE Make sure that the unit s power ON OFF switch is ALWAYS the OFF position when using the 12 volt DC accessory outlet The unit s 12 volt power supply can power 12 volt DC items rated under 15 amps by simply inserting the item s plug into the 12 volt DC outlet WARNING Do not attempt to connect items exceeding the 15 amp 12 volt rating Using the compressor and a 12 v
15. olt DC item may exceed 15 amps and cause damage to the unit item and or accessories 5 1 Estimated 12 Volt DC Usage Times Estimated usage 217272 Appliance Type consumption in PP yp Wake Hours CELL PHONE 1 20 120 FLUORESCENT LIGHT 4 10 30 RADIO FAN DEPTH FINDER 9 1 14 CAMCORDER VCR SPOTLIGHT 15 1 8 Page 12 of 16 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE VEC270MG WECTOR Estimated usage AT Time in Appliance Type consumption in pp yp Wate Hours POWER TOOLS BILGE PUMP 24 1 5 ELECTRIC COOLER 48 1 3 CAR VACUUM 80 1 NOTICE ALL TIMES ARE APPROXIMATE AND ARE TYPICAL BUT MAY VARY DEPENDING UPON VEHICLE S BATTERY CAPACITY 6 EMERGENCY WORKLIGHT The twin fluorescent tube worklight is controlled by an On Off switch on the side of the unit The 8 watt twin tubes 4 watts each provide the necessary light when working in low or no light situations NOTICE Make sure the lamp is turned OFF when the unit is being recharged or stored 7 REPLACEMENT PARTS For replacement parts bulbs batteries fuses etc contact Vector Customer Service 954 584 4446 or toll free 866 584 5504 7 1 Bulb Replacement WARNING Make sure all power is off and unit is disconnected before attempting to remove cover and replace fluorescent tubes Tools needed small Phillips screwdriver 1 Unscrew counterclockwise and remove one Phillips screw 2 Remove the lens cover
16. tery status LED indicators 2 Plug the charger into a 120 volt electrical outlet 3 red charging light will come on indicating the battery is recharging and will remain on until charger is removed No other indicator lights will come on 4 Charge the unit for 14 to 16 continuous hours before initial use After multiple uses recharge the battery for 5 to 6 hours If the unit is used too long after the red light comes on recharging time could take up to 20 hours and the battery life may be shortened Page 9 of 16 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE VEC270MG WECTOR NOTICE Do not operate the unit while recharging with the 120 volt AC adapter Damage will occur to the unit accessory 3 2 12 Volt DC Recharging CAUTION This unit is NOT intended for recharging a vehicle s battery Never start the vehicle when the 12 volt DC recharging adapter is plugged into the accessory outlet 1 Insert the 12 volt DC recharging adapter into the 12 volt DC accessory outlet Insert the other end into the vehicle accessory outlet 3 inflator should be charged for 5 to 6 hours while driving before initial use After multiple uses recharge the inflator for 3 hours 3 3 Battery Indicator Lights The battery is at full charge if the green LED is lit If 2 red LEDs are lit up the unit can be used but will need a charge soon If 1 red LED is lit this indicates the battery must be recharged The re
17. to Vector Manufacturing Any defective product other than accessories that is returned to Vector Manufacturing within 30 days of the date of purchase will be replaced free of charge If such a product is returned more than 30 days but less than one year from the purchase date Vector Manufacturing will repair the unit or at its option replace it free of charge If the unit is repaired new or reconditioned replacement parts may be used at Vector Manufacturing s option A unit may be replaced with a new or reconditioned unit of the same or comparable design The repaired or replaced unit will then be warranted under the terms of the remainder of the warranty period The customer is responsible for the shipping charges on all returned items after 30 days During the warranty period Vector Manufacturing Ltd will be responsible for the return shipping charges LIMITATIONS This warranty does not cover accessories bulbs fuses and batteries defects resulting from normal wear and tear including chips scratches abrasions discoloration or fading due to usage or exposure to sunlight accidents damage during shipping to our service facility alterations unauthorized use or repair neglect misuse abuse failure to follow instructions for care and maintenance fire flood and Acts of God If your problem is not covered by this warranty call our Technical Support Department 954 584 4446 or toll free 866 584 5504 for general repair inform
18. uorescent Tubes 4 Watts each Accessory Socket Protected by a 15 Amp Fuse Charging Cord 12 volt DC Adapter Charger 120 volt 500mA 12 volt DC Output HEIGHT 8 5 in 21 6 cm LENGTH 11 in 27 94 cm WIDTH DEPTH 3 75 9 5 cm WEIGHT 7 Lbs 3 17 Kg 9 VECTOR ONE YEAR LIMITED WARRANTY This limited warranty program is the only one that applies to this product and it sets forth all the responsibilities of Vector Manufacturing Ltd regarding this product There is no other warranty other than described herein This Vector Manufacturing Ltd product is warranted to the original purchaser only to be free of defects in materials and workmanship for one year from the date of purchase without additional charge The warranty does not extend to subsequent purchasers or users Vector Manufacturing Ltd will not be responsible for any amount of damage in excess of Page 14 of 16 260 PSI AIR COMPRESSOR CORDLESS RECHARGEABLE VEC270MG WECTOR the retail purchase price of the product under any circumstances Incidental and consequential damages are specifically excluded from coverage under this warranty This product is not intended for commercial use This warranty does not apply to accessories or damage to units from misuse or incorrect installation Misuse includes wiring or connecting to improper polarity power sources RETURN REPAIR POLICY Defective products other than accessories may be returned postage prepaid
19. ver valve stem threads completely Press down on the universal adapter s lever to lock onto valve stem when the adapter is firmly place See FIGURE need artwork To use the inflation accessories insert piece into the universal adapter and push the lever to lock into place The inflation accessory will fit securely Insert the appropriate inflation accessory into the inflatable object Turn on the power and the compressor switch When the object is firm turn the inflator off Tire Inflation or Products With A Valve Stem The built in 12 volt DC 260 PSI Air Compressor is the ultimate compressor for most vehicles trailer tires and recreational inflatables q 2 3 4 5 OND 4 2 Place connector chuck on valve stem Ensure connector is pushed on to valve stem as far as possible before closing thumb latch Make sure latch is secure Check pressure with the pressure gauge When desired pressure is reached open thumb latch and remove connector from valve stem Turn OFF Compressor Power Switch Allow unit to cool after use before storing away Store compressor hose and tire fitting in storage compartment TYPICAL INFLATION TIMES FOR PRODUCTS W VALVE STEMS TIRE SIZE PRESSURE TIME FROM 0 155 80R 13 26 psi 2 50 min 185 70R 14 30 psi 4 50 min 235 75R 15 30 psi 6 50 min 235 85R 16 50 psi 16 00 min BICYCLE TIRES 27 x 1 racing 70 psi 2 30 min Other Inflatables Without Va
Download Pdf Manuals
Related Search