U-Line Wine Captain Cooler User's Manual
Contents
1. User 3 Manual UFLINE CORPORATION Wine Captain Introduction Congratulations on the purchase of your U Line Wine Captain A pioneer in the field for more than 40 years U Line is the world s number one manufacturer of built in under counter ice making and specialty refrigeration products The Right Temperature for the Wine The Wine Captain s unique triple temperature zones permit storage of your finest wines at approximately 60 F 15 C in the top portion of the cabinet for reds 50 55 F 10 12 C in the middle for whites and 45 F 7 C on the bottom for sparkling wines Proper Storage Model 75WC will accommodate 60 bottles 750 ml Model 15WC will accommodate 32 bottles 750 ml Specially designed wine racks allow for proper horizontal storage of the wine The cork remains moist which keeps air from entering the bottle Safety Precautions Do not attempt to install or operate your unit until you have read this manual completely Safety items throughout this manual are labeled with Danger Warning or Caution based on the risk type Definitions A DANGER Danger means that failure to follow this safety statement may result in severe personal injury or death A WARNING Warning means that failure to follow this safety statement may result in extensive product damage serious personal injury or death CAUTION Caution means that failure to follow this safety statement may result in mino2. rear bottom side of the grille on the front lip of the unit base Swing the grille up into position aligning the grille and cabinet screw holes 5 control knob may only be installed correctly If you have to force the installation of the knob you may not have it properly aligned with the two control knobs Preparation Your Wine Captain may be installed as built in or freestanding unit It uses a front vented fan cooled condenser system which provides the ability to be built in tightly without the need for additional clearance on the sides top or rear for ventilation It is recommended that you leave a minimal amount of clearance to install and remove the Wine Captain in the event service is required The Wine Captain must not be installed behind closed doors The front grille must be free from obstruction Obstructing free air flow can cause the Wine Captain to malfunction and may void the warranty For the best performance the location of the Wine Captain should not be in direct sun light or near a heat source Level Installation Position the unit on a flat level surface capable of supporting the entire weight of the unit when full 75WC and 15WC This unit contains four adjustable leveling legs Turn the legs clockwise to raise and counterclockwise to lower Electrical Requirement Provide 115 volt 60 cycle only normal household three prong grounded electrical outlet DO NOT use an extension cord DO NOT use an
3. adapter to bypass the ground DO NOT alter or deform the electrical plug in any manner Reversing The Door Depending upon the location of the unit it may be desirable to change the side on which the door is mounted To reverse the door mounting on the 15WC Wine Captain perform the following 1 Remove top hinge from cabinet 3 screws 2 Lift door off bottom hinge 3 Remove bottom hinge from cabinet 2 screws and install on opposite side of cabinet 4 Remove top hinge plate 2 screws from door and install on bottom opposite side of door 5 Remove bottom hinge plate 2 screws from door and install on top opposite side of door 6 Replace plastic spacer on bottom hinge and set door in place Replace plastic spacer on top hinge and install top hinge on cabinet 8 Adjust as required to assure proper door seal oT To reverse the door mounting on the 75WC Wine Captain perform the following 1 Remove the bottom hinge 2 screws from door 2 Remove top hinge 2 screws from door 3 Remove door 4 Remove top hinge 3 screws from cabinet Invert and install on bottom opposite side of cabinet 5 Remove bottom hinge 3 screws from cabinet Invert and install on top opposite side of cabinet Attach top hinge to door Attach bottom hinge to door 8 Adjust as required to assure proper door seal SS Door Adjustment The Wine Captain door should always be squared to the cabinet to ensure a proper seal To properly
4. adjust the door please follow this procedure 1 Loosen do not remove the three screws in the door hinge plate on the top of the cabinet 2 Align the door so that it is squared to the cabinet 3 Tighten the three screws on the top hinge plate Operation Initial Start Up The Wine Captain is designed to provide different temperature zones within the cabinet See introduction for specific temperatures This is done so that different types of wine may be maintained at varying temperatures The coolest temperature is at the bottom and it is warmer at the top of the cabinet White and sparkling wines should be maintained on the bottom to middle racks and red wine on the top racks Your Wine Captain is preset for a mid point setting 4 1 2 in order to achieve the recommended temperature range when installed in a 72 F ambient room temperature To achieve a warmer setting turn the control counter clockwise lower number and clockwise higher number for a cooler temperature Factors which affect the internal temperatures of the cabinet include Temperature setting Room temperature where installed The number of times the door is opened and closed go The amount of time the internal light is illuminated This affects primarily wines on the top racks 5 Installation in direct sun light or near a heat source Stocking Recommendations The wine racks allow for the proper horizontal storage of wine The bottles are properly po
5. ap rivets The upright rear brace should not be touching the evaporator on the rear wall of the Wine Captain Avoid the use of solvent cleaning agents abrasives and cleaners Exterior The exterior may be cleaned with mild cleaners or mild soap and water Glass Door The glass door may be cleaned using a glass cleaner or mild soap and water Avoid use of abrasive cleaners Condenser The condenser coil located behind the front grille should be cleaned three to four times per year Using brush or vacuum cleaner remove dirt lint and other accumulations from the condenser coil Z WARNING The condenser fins are sharp DO NOT run hands or fingers over condenser fins To remove and replace the grille to obtain access to the condenser fins please follow this procedure 1 Using standard blade screwdriver remove the screw located toward the middle of the grille 2 Remove the cabinet knob 3 Grasp the grille in both hands and pull up and forward 4 Clean the condenser coil using brush or vacuum cleaner 5 install the grille place the two hook hinges located the back bottom side of the grille on the front lip of the unit s base Swing the grille up into position aligning the grille and cabinet s screws 6 Insert the grille screw and tighten being careful not to overtighten 7 Install the control knob 10 Troubleshooting Before Calling For Service If the unit appears to be malfunctioning
6. ase During the initial one year warranty period for all U Line products U Line shall 1 at U Line s option repair any product or replace any part of a product that breaches this warranty and 2 for all Marine RV and Domestic U Line products sold and serviced in the United States including Alaska and Hawaii and Canada U Line shall cover the labor costs incurred in connection with the replacement of any defective part During years two through five of the warranty period for the sealed system U Line shall 1 repair or replace any part of the sealed system that breaches this warranty and 2 for all Marine RV and Domestic U Line products sold and serviced in the United States including Alaska and Hawaii and Canada U Line shall cover the labor costs incurred in connection with the replacement of any defective part of the sealed system All other charges including transportation charges for replacements under this warranty and labor costs not specifically covered by this warranty shall be borne by you This warranty is extended only to the original purchaser of the U Line product The Registration Card includ ed with the product should be promptly completed by you and mailed back to U Line or you can register online at www U LineService com The following are excluded from this limited warranty installation charges damages caused by disasters or acts of God such as fire floods wind and lightening damages incurred or resulting from sh
7. e high in alcohol and extract generally speaking fills the mouth powerful Generally wines that are slim lacking of generosity or thin A desirable flavor imparted to wine if done in moderation Most wines are aged in oak barrels 1 to 3 years thereby receiving this toasty oak characteristic However if a weak wine is left in contact too long with an oak barrel it will tend to be overpowered with an oaky taste Tannins are extracted from the grape skins and stems and are necessary for a well balanced red wine Tannins are easily identified in wine tasting as the drying sensation over the gums Tannins generally fade as a wine ages Safety Precautions Do not attempt to install or operate your Wine Captain until you have read the safety precautions The precautions are labeled with DANGER WARNING OR CAUTION DANGERS Indicate hazards or unsafe practices which could result in severe personal injury or death WARNINGS Indicate hazards or unsafe practices which could result in personal injury or death CAUTIONS Indicate hazards or unsafe practices which could result in damage to the Wine Captain Z DANGER RISK OF CHILD ENTRAPMENT Before you discard your Wine Captain remove the door and leave the shelves in place so that children may not easily climb inside A WARNING Never attempt to repair or perform maintenance on the Wine Captain until the electricity has been disconnected Do not alter or deform electrical plug
8. edium Bodied Semi Sweet Light Bodied Off Dry Red Wines Calif Zinfandel Cabernet French Rhone Chateauneuf du Pape Italian Barbaresco Barolo Calif Pinot Noir French Bordeaux Burgundy French Beaujolais Italian Chianti Bardolino White Wines Calif Chardonnay French Montrachet Meursault Puligny Montrachet Calif Sauvignon Blanc French Pouilly Fuisse Sancerre Vouvray Graves French Chablis Muscadet Pouilly Fume Germany Beerenauslese French Sauternes Hungary Tokay Calif Gewurtztraminer Germany Liebfraumilch Germany Rhine Mosel Riesling Acidity Balance Body Bouquet Complex Flabby Full Bodied Lean Oaky Tannin Common Tasting Terms critical element of wine preserves the wine s freshness In excess results in an overly tart and sour wine desired trait where tannin fruit and acidity are in total harmony Wines with good balance tend to age gracefully The weight and presence of wine in the mouth provided by the alcohol and tannin level Full bodied wines tend to have this strong concentration The blending of a wine s aroma within the bottle over period of time Caused by volatile acidity A subjective term often used in tasting wine is said to be complex if it offers a variety of flavors and scents that continue to evolve as it develops A wine that lacks structure or is heavy to the taste lacks acidity Win
9. in any way The use of an extension cord is not recommended Altering cutting of power cord removal of power plug or direct wiring can cause serious injury fire and or loss of prop erty and or life and will void the warranty CAUTION Do not lift unit by door handle Failure to clean the condenser on a regular basis can cause the Wine Captain to malfunction This could void the warranty The unit must not be installed behind closed doors Be sure the front grille is free of obstruction Obstructing free air flow can cause the Wine Captain to malfunction and may void the war ranty Use only genuine factory replacement parts Installation The Wine Captain is manufactured in two different sizes The 15WC will accommodate thirty two 32 750 ml wine bottles and the 75WC will accommodate sixty 60 750 ml wine bottles Unless other wise noted all documentation pertains to both units Grille Installation The lower grille should be affixed prior to installing the Wine Captain To affix the grille complete the following 1 With a standard blade screwdriver remove the screw located toward the middle of the unit below the door needed to attach the grille 2 Ifthe control knob is located in the grille area remove it by pulling it toward you 3 Carefully remove the grille from inside the unit A small screw hole is located toward the top of the middle recessed section of the grille 4 Place the two hook hinges located on the
10. in the mid dle of the upper portion of your door The lock is a deterrent to keep children out and is not intended to keep your valuable wine collection safe The reversing of the door will not effect the locking mechanism Additional keys may be ordered as a separate part Light Switch and Bulb Your Wine Captain has an interior light that is illuminated when the door is opened If you wish to display your wines for those special occasions while the door is closed just depress the switch located below the control knob in the grille to the ON position Please note that when the light is on for an extended perior of time it will slightly increase the cabinet temperature Bulb Replacement To replace the light bulb 1 Remove the light housing cover by sliding the cover towards the tab swinging the end opposite of the tab down and pulling down and away Replace bulb with genuine U Line replacement 3 Replace the light housing cover I by inserting the tab FIRST and pushing up the other end You should hear snap click TAB Cleaning And Maintenance Periodic cleaning and proper maintenance will ensure efficiency and top performance Interior The Wine racks may be removed by removing the security tabs at the rear of each rack if desired Clean the interior of the cabinet with mild soap and water and rinse with clear water The lock tabs at the rear of the wine racks must be properly secured with the sn
11. ipping improper installation unauthorized modification or misuse abuse of the product customer education calls food loss spoilage door and water level adjustments except during the first 90 days from the date of purchase defrosting the product adjusting the controls door reversal or cleaning the condenser If a product defect is discovered during the applicable warranty period you must promptly notify either the dealer from whom you purchased the product or U Line at PO Box 23220 Milwaukee Wisconsin 53223 or at 414 354 0300 In no event shall such notification be received later than 30 days after the expiration of the applicable warranty period U Line may require that defective parts be returned at your expense to U Line s factory in Milwaukee Wisconsin for inspection Any action by you for breach of warranty must be commenced with in one year after the expiration of the applicable warranty period This limited warranty is in lieu of any other warranty express or implied including but not limited to any implied warranty of merchantability or fitness for a particular purpose provid ed however that to the extent required by law implied warranties are included but do not extend beyond the duration of the express warranty first set forth above U Line s sole liability and your exclusive remedy under this warranty is set forth in the initial paragraph above U Line shall have no liability whatsoever for any incidental consequen
12. ked obstructed to front grille See INSTALLATION Dirty condenser Clean condenser coils See CLEANING AND MAINTENANCE Door gasket not Adjust door See sealing properly DOOR ADJUSTMENT Unit is too cold Control set too cold Turn control knob COUNTER CLOCKWISE Check temperatures to set temperature see introduction for warmer Allow 24 hours specific temperatures for temperature to stabilize No interior light Loose or burned Tighten or replace out bulb bulb See BULB REPLACEMENT Light won t go out Light on off switch Turn switch to off when door is closed is turned to ON See LIGHT SWITCH AND BULB 12 U PO Box 245040 Milwaukee Wisconsin 53224 9540 U LINE 414 354 0300 FAX 414 354 7905 TT P N 41739 Rev 5 03
13. ore near Eg term drinking enjoyment The primary guideline to the subject of wine you need to follow is your own palate Do not be afraid to make mistakes Experiment discover but most of all enjoy yourself and your new Wine Captain GRAND VIN CHATEAU LATOUR Suggestions For Matching Wine And Food Although there are no hard fast rules for matching wine to food some guidelines should be observed Delicate dishes should be accompanied by lighter more delicate wines Full flavored foods should be matched with fuller bodied wines general rule one should aim to ascend in flavor and quality of wines served A DRY WINE Before A SWEET WINE A WHITE WINE Before RED WINE A YOUNG WINE Before An OLD WINE A LIGHT BODIED WINE Before A FULL BODIED WINE Any step back in quality will be noticed If a fine wine were to be tasted prior to a lesser wine many of the fine wine s subtle qualities may be missed Common Food And Wine Matches Fish Shell Fish Crab Oysters Dry White Wines Light Sparkling or Extra Dry Champagne Beef Venison Full Bodied Red Wines Pork Veal Lamb amp Poultry Light Bodied Red Wines MUS AYN Fruit Sweet White and Sparkling Wines Guide To Common Styles Of Wines Full Bodied Dry Medium Bodied Dry Light Bodied Dry Full Bodied Dry Medium Bodied Dry Light Bodied Dry Full Bodied Very Sweet M
14. r or moderate personal injury property or equipment damage Table Of Contents Wine Selection Suggestions 1 Suggestions For Matching Wine And Food 2 Common Food And Wine Matches Guide To Common Styles Of Wine Common Tasting Terms Salety Precautions 6 5 PRP 5 Level Installation Electrical Requirement Reversing The Door Door Adjustment 8 Initial Startup 8 Stocking Recommendations 8 Door LOCK 9 Light Switch And 9 Bulb Replacement seres 9 Cleaning And Maintenance 10 Troubleshooting 11 Service Is REQUIRGE senga nearest keti 11 Replacement Pants 11 Troubleshooting Guid 12 U Line Corporation Limited Warranty U Line Corporation warrants each U Line product to be free from defects in materials and workmanship for period of one year from the date of purchase and warrants the sealed sys tem consisting of the compressor the condenser the evaporator the hot gas bypass valve the dryer and the connecting tubing in each U Line product to be free from defects in materials and workmanship for a period of five years from the date of purch
15. read through NORMAL OPERATION first If the problem persists check the TROUBLE SHOOTING GUIDE Locate the problem in the guide and refer to the cause and its remedy before calling for service The problem could be something very simple which can be solved without a service call If Service Is Required If the need for service arises contact the dealer from whom the unit was purchased State the Model and Serial number and explain the problem The Model and Serial number plate is located inside unit at upper right hand corner If you do not know the name of the selling dealer or local service com pany you can check on line at www U LineService com Replacement Parts Use only genuine U Line replacement parts Genuine U Line parts are designed to work correctly with U Line products and offer superior service life The use of non U Line parts can damage the unit and may void the warranty 11 Troubleshooting Guide Z WARNING Never attempt to repair or perform maintenance on the unit until the main electrical power has been disconnected PROBLEM POSSIBLE CAUSE REMEDY Unit not cold enough Control set too Turn control knob warm CLOCKWISE to set Check temperatures temperature colder see introduction for Allow 24 hours for specific temperatures temperature to stabilize Light staying on Adjust door so light switch bracket contacts switch plunger See DOOR ADJUSTMENT Airflow to front Airflow must not be grille bloc
16. sitioned so that the wine remains in contact with the cork to assure that the cork does not become dry The racking system is designed with three parallel braces rear middle and front per shelf The procedure listed below may be used to load your Wine Captain 75WC Start at the left hand side of the FIA shelf and place the first bottle on lo oC oC NaC Jal the rear and middle parallel braces eQal with the neck facing towards the tinted glass door The next bottle 9 should be placed on the front and middle parallel braces with the neck lp facing towards the rear Alternate this stocking sequence moving left loa oC aa to right on the shelf The same stocking procedure may be used on all remaining full shelves The bottom half shelf wine bottles should be stocked crosswise 15WC IoC aC I Start at the left hand side of the shelf and OOQ place the first bottle on the front and middle parallel braces with the neck facing towards the OOQ rear The next bottle should be placed on the OOO rear and middle parallel braces with the neck facing the tinted glass door Alternate this IOO stocking procedure left to right The same stocking procedure may be used on all full shelves The bottom half shelf wine bottles should be stocked crosswise Door Lock All Origins Wine Captains contain door lock located
17. tial or special damages arising from the sale use or installation of the product or from any other cause whatsoever whether based on warranty express or implied or otherwise based on contract tort or any other theory of liability Some states do not allow limitations on how long an implied warranty lasts or the exclusion or limitation of incidental or consequential damages so the above limitations may not apply to you This warranty gives you specific legal rights and you may also have other rights which vary from state to state Wine Selection Suggestions Selecting the right wine for the right occasion can sometimes be seemingly awkward or difficult task for the beginning wine enthusiast We would therefore like to present you with a few suggestions which may provide a little more confidence and enjoyment when choosing and serving your wines When selecting wines keep an open mind and do not be afraid to be adventurous Do not view the subject of wine so seriously it discourages you from learning and discovering for fear of embarrassment if something is incorrect Wine is best viewed as a hobby and enjoyed When assembling your collection try not to become obsessed with Vintages Although a chart Cay MUS can provide itself as useful tool generalizations VINEVARDS about a specific year have led more than one collector to disappointment In many instances le Off Year will provide a better value and m
Download Pdf Manuals
Related Search