Tamarack Technologies TC1000 User's Manual
Contents
1. a thermostat must be installed We strongly recommend a non chlorine based chemical for over the water applications TC1000 T TC1000 T std Wall Switchi Single and 3 Way T Stat Multiple TC s 2 Wire Humidistat with Single Control Nic Not Used Black White Hot Neutral 120 60Hz Supply Optional Second Unit a J g Multiple TC s PP with Dual 3 Way Switch Control Black White Hot Neutral 120V 60Hz Supply Troubleshooting i The most common installation error is caused by incorrect wiring Be sure that each of the 3 wires in the TC1000 are connected individually There is a 30 second delay after the control is activated and the damper opens before the fan motors start Care All the motors in the TC are permanently sealed and do not require oiling To keep dirt dust and debris from the fans we recommend that you periodically remove the grille from within the living space and dust the fan blades Please remember to make sure that the electrical circuit is OFF before dusting the fan blades Specifications Power Requirements Airflow Effective R value Rough opening Cover Height above flange Warranty Safety Tested LIMITED WARRANTY If within the period of three years from the date of purchase the TC 1000 the Product is defective or malfunctions in normal home use Tamarack Technologies Inc will repair or replace the Product at its discretion Customer is responsible for shi2. CTRIC SHOCK OR INJURY TO PERSONS OBSERVE THE FOLLOWING WN Use this unit in the manner intended by the manufacturer If you have any questions contact the manufacturer WN Before servicing or cleaning unit switch power off at service panel and lock service panel to prevent power from being switched on accidentally When the service disconnect cannot be locked securely fasten a prominent warning device such as a tag to the service panel N When cutting or drilling into wall or ceiling do not damage electrical wiring or other hidden utilities N Never place a switch where it can be reached from a tub or shower N Do not use this fan over a tub or shower NW Do not use this fan over cooking appliances NM WARNING To Reduce The Risk of Fire or Electric Shock Do Not Use This Fan With Any Solid State Speed Control Device CAUTION For General Ventilation Use Only Do Not Use To Exhaust Hazardous Or Explosive Materials And Vapors Tamarack be Ventilation Solutions 320 Main Street Buzzards Bay Ma 02532 www tamtech com 508 759 4660 800 222 5932 Fax 508 759 6001 Installation Installing the TC1000 in a Wall You will need the following items e Two pieces of 2x stock to match your existing framing e Saw to cut the hole in the wall e Hammer or Screw Gun to attach the blocking to the existing frame e Phillips head Screwdriver to attach the grille e Weather strip material e Low expansion Spray Foam sealant Add framing as s
3. ON OF INCIDENTAL OR CONSEQUENTIAL DAMAGES AND SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS SO THE ABOVE LIMITATIONS OR EXCLUSIONS MAY NOT APPLY TO YOU THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS THAT VARY FROM STATE TO STATE PROOF OF PURCHASE REQUIRED Tamarack ZA Technologig inJ Nc IES Ventilation Solutions 320 Main Street Buzzards Bay Ma 02532 www tamtech com 508 759 4660 800 222 5932 Fax 508 759 6001
4. TC1000 TCPG 3 ALL VVEATHER VENTILATOR PRODUCT MANUAL amp INSTALLATION GUIDE Serial Number Date of Purchase Point of Purchase The serial number is located on the shipping carton and on a label affixed to the upper housing Unpacking your TC When you have unpacked your TC carefully you will find the following TC1000 T TC1000 H One 1 TC1000 T All Weather Ventilator One 1 TC1000 H All Weather Ventilator One 1 Line Voltage Thermostat The TC 1000 can be installed in one of three ways Ina glazing system The TC 1000 must be installed by a qualified installer If it is to be installed in a double glazing system an internal spacer to match the thickness of the glazing must be factory installed or one fabricated on the site If a spacer is site fabricated please note that it must be installed UNDER the fan On a conventional or stress skin panel roof The TC 1000 will have no internal spacer its flanges will be 1 4 thick After a 12 1 2 x 27 rough opening is cut through the roof a sheet metal thimble should be installed to line the opening The fan should be installed using standard skylight flashing techniques and an optional grille is recommended to cover the opening in the ceiling On a vertical wall We strongly suggest installing a piece of flashing above the TC 1000 to sweep the rain away before it hits the edge of the fan READ AND SAVE THESE INSTRUCTIONS MY WARNING TO REDUCE THE RISK OF FIRE ELE
5. hown to create a box of 12 1 2 X 27 3 4 This box will act to hold the unit as well as creating a plenum for air movement Figure 1 1 Create a box to hold the unit Fig 1 2 Remove the sheathing that covers the box 3 Attach TC1000 screwing through the mounting flange 4 Install exterior finish materials over the mounting flange Note additional flashing may be required above the unit to divert rain 5 Remove any interior materials covering the box 6 Install interior finish materials to trim the frame 7 Attach optional grille to finish installation Wiring Important Wiring the TC is different than a normal ON OFF fan The TC damper is motorized and requires a constant source of power power to open and power to close The TC1000 T comes with a wall mounted line voltage thermostat This thermostat is surface mounted and should be positioned at eye level The TC1000 H comes with a SPST wall switch that is mounted in a standard single gang electrical box A 3 wire will need to be run between the control point and the TC regardless of the model Please follow the instructions carefully It is recommended that the wiring of the TC be done by a licensed electrician in accordance with local code requirements Be sure to turn off power before wiring the TC Ventilation Fan Please note that if the TC 1000 is installed in an enclosure with a spa or hot tub or pool a humidistat optional ttem as well as
6. pping charges CONDITIONS EXCLUSIONS AND LIMITATIONS This Warranty is subject to the following conditions exclusions and limitations THIS WARRANTY DOES NOT COVER PROBLEMS RESULTING FROM INSTALLATION OPERATION OR MAINTENANCE THAT HAS BEEN UN DERTAKEN OTHER THAN IN ACCORDANCE WITH THE INSTRUCTIONS THIS WARRANTY DOES NOT COVER PROBLEMS RESULTING FROM DEFECTS IN OR CAUSED BY ASSOCIATED EQUIPMENT FURNACES SOLARIA ETC FROM REPAIRS OR MODIFICATIONS ATTEMPTED BY PERSONS OTHER THAN TAMARACK TECHNOLOGIES INC FROM ABUSE ACCIDENTAL OR SHIPPING DAMAGE OR ACTS OF GOD THIS WARRANTY DOES NOT APPLY TO THE PRODUCT USED OUTSIDE THE UNITED STATES ITS TERRITORIAL POSSESSIONS AND CANADA EXCEPT AS SET FORTH ABOVE NO EXPRESS OR IMPLIED WARRANTY IS GIVEN OR AUTHORIZED BY TAMARACK TECHNOLOGIES INC AND ALL OTHER SUCH WARRANTIES ARE EXPRESSLY DISCLAIMED ANY WARRANTY OR MERCHANTABILITY OF FITNESS FOR ANY PAR TICULAR PURPOSE SHALL BE LIMITED TO THE WARRANTY HEREUNDER MOREOVER ANY LIABILITY OF TAMARACK TECHNOLOGIES INC FOR THE PRODUCT SHALL BE LIMITED TO THE REPLACEMENT VALUE OF THE PRODUCT IN NO EVENT SHALL TAMARACK TECH NOLOGIES INC BE LIABLE FOR ANY INCIDENTAL DAMAGES OR FOR ANY CONSEQUENTIAL PROPERTY OR COMMERCIAL DAMAGES IR RESPECTIVE OF THE CAUSE THEREOF OCCURRING EITHER DURING OR AFTER THE WARRANTY PERIOD INCLUDING WITHOUT LIMITATION ANY DAMAGES TO ANY PART OF A BUILDING OR ITS CONTENTS NOTE SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATI
Download Pdf Manuals
Related Search