Specialized Myka User's Manual
Contents
1. 59 64 100 110 125 130 140 150 64 68 110 120 130 135 150 160 68 73 20 125 135 140 160 170 73 77 25 130 140 150 170 180 77 82 30 135 150 160 180 190 82 86 135 140 160 170 190 200 86 91 40 145 170 180 200 210 91 95 145 155 180 190 210 220 95 100 155 165 190 200 220 230 100 104 165 175 200 210 230 240 104 109 175 185 210 220 240 250 109 113 185 195 220 230 250 265 113 120 195 205 230 240 265 280 120 127 205 215 240 250 280 295 127 134 215 225 250 260 NOTE This air chart is designed as a recommended starting point only Please refer to your shock owner s manual for additonal setup information DERAILLEUR GUARD INSTALLATION The Specialized Derailleur guard is available separately through your local Specialized dealer The guard works with solid or Q R axle types and is compatible with all Mountain bike models using the 2005 2006 Enduro Demo derailleur hanger Guard Part 9896 4030 Hanger Part 9895 4021 Guard Spacer Derailleur Guard Installation Q R option TR GUARD PINS 1 Install rear derailleur on derailleur hanger Lona imm 2 Place rear wheel in frame and install Q R All SRAM derailleurs with springs and without Q R end nut Medium 25mm 3 Insert appropriate derailleur guard pin in derailleur Co ao es Renae 4 Place guard sleeve in derailleur guard E anger bol 5 Slide derailleur guard a2. to the frame which have not been tested for If you must replace any component have this done by your authorized Specialized retailer WARNING Never modify your frame or bicycle in any way Do not sand drill fill or remove parts Do not install incompatible forks or suspension parts An improperly modified frame fork or component can cause you to lose control and fall Caution Any modification of your frame fork or components means that your bike no longer meets our specifications and therefore voids your warranty FORK SETUP INFORMATION A WARNING The FSRxc and Myka frames are compatible ONLY with single crown forks that have travel of 4 0 100mm or less Use of different styled forks or forks with longer travel may result in catastrophic failure of the frame which may result in serious personal injury or death SEAT POST SETUP SEATPOST MINIMUM INSERTION All Specialized full suspension models with interrupted seat tubes have a small hole to identify the minimum extension allowed for your seatpost If you cannot see the seatpost tube through this hole your seatpost is too far extended If a greater saddle height is required replace the seatpost with a longer one Minimum Seat Post Insertion Guide Hole MUDFLAP FENDER CHAINSTAY SLEEVE The Stumpjumper Mudflap is compatible with all 04 Replacement custom neoprene chainstay 06 Stumpjumper FSR 07 Myka and 05 07 FSRxc SlapJacket sl
3. 2 69 73 32lmm 12 64 116mm 43 94 424mm 16 70 Women s Large 595mm 23 43 753mm 29 65 120mm 4 72 69 59 73 321mm 12 64 1094mm 43 07 424mm 16 70 Men s X Large 637m 766mm 148mm 69 73 321mm 144mm 424mm 25 08 30 16 5 83 12 64 45 04 16 70 TT length is the Horizontal Measurement from the center line of the HT at the top of the HT to the center line of the projected seat tube Stand Over height is measured vertically at the centerpoint of the TT measurement Headset 1 1 8 Seatpost diameter 30 9mm Front derailleur clamp 34 9mm Seat Collar 34 9mm 10 Rear hub spacing 135mm BB shell 68mm Shock Stroke 40 6mm 1 6 Eye to Eye 177 8mm 7 0 FSRxc MYKA FRAME GEOMETRY 11 Fox Triad X Fusion RLA RC Sag Setting Set the sag 20 25 of shock stroke See attached pressure chart for starting air pressure Note the chart is only a starting point actual sag needs to the checked and adjusted on the bike while riding and at regular intervals After setting the pressure push the rubber ring up to the seal sit on the bike gently dismount and measure sag Set Standard rebound damping adjuster to rider preference Typically a slower rebound for slow speed bigger hits to eliminate kickback or faster rebound for higher speeds and smaller hits so the suspensio
4. Y ELA VTA AL OWNER S MANUAL lt lt SPELIALIZEO TABLE OF CONTENTS INTO UC Oia een 4 Seat Post Fork Compatibility eee 7 ACOSO Sii iaa 8 Frame Features ia ida 9 Frame Codelco iaa dt 10 Shock SQtU Per scccccsecscssscscsessscectsctecdersectsctssseccsesiessesiesiecseceesssetecs 12 Optional Derailleur Guard Installation 13 Schematic and Specifications ccc sees 14 War Vertice 16 INTRODUCTION Congratulations on your purchase and welcome to the finest line of suspension bikes available About Off Road Stunt Downhill and Freeriding This manual is designed to be used in conjunction with the Bicycle Owner s Manual and owner s manuals supplied by the manufacturer of the front and rear suspension components If you did not receive any of these manuals download them from the Internet contact your dealer or contact us by telephone There may be more current manuals and technical information available For the most current information regularly check the Specialized web site or consult your Specialized dealer These manuals were written for an important reason your safety while riding This manual contains many Warnings and Cautions concerning the consequences of failure to maintain or inspect your bicycle or of failure to follow safe cycling practices The combination of the safety alert symbol and the word Warning indicates a potentially hazardous situation which if not avoided cou
5. akes the following Limited Warranty concerning Specialized bicycles and framesets LIMITED LIFETIME WARRANTY ON BICYCLE FRAMES AND FRAMESETS Subject to the following limitations terms and conditions Specialized warrants to the original owner for the lifetime of the original owner of each new Specialized bicycle or frameset that the bicycle frame or frameset when new is free of defective materials and workmanship The lifetime limited warranty is conditioned upon the bicycle being operated under normal conditions and use and properly maintained This limited warranty does not apply to paint finish or components attached to the bicycle frameset such as front forks wheels drive train brakes seatpost handlebar and stem or any suspension related parts or components Paint finish components attached to the bicycle frameset such as front forks wheels drive train brakes seatpost handlebar and stem or any suspension related parts or components are covered under the limited one 1 year warranty This warranty is void if the bicycle or frameset was not purchased new from or not properly assembled by an authorized Specialized dealer LIMITED ONE 1 YEAR WARRANTY ON COMPLETE BICYCLE Subject to the following limitations terms and conditions Specialized warrants to the original owner of each new Specialized bicycle that this bicycle when new is free of defective materials and workmanship This warranty shall expire one 1 year from the date of the orig
6. ant the bicycle frame or components for such activities and expressly disclaims all warranties including the warranty of fitness for particular purpose and merchantability Stunt riding severe off road riding jumping or riding downhill at speed is extremely dangerous and the rider voluntarily assumes the risk that the bicycle frame and or its components will bend or break and voluntarily assumes the risk of injury or death INTRODUCTION Technological advances have made bicycles and bicycle components more complex and the pace of innovation is increasing It is impossible for this manual or the accompanying manuals to provide all of the information required to properly repair and or maintain your bicycle In order to help minimize the chances of an injury it is critical for you to have work performed by an authorized Specialized retailer Service and Modifications WARNING Service on Specialized bicycles requires special knowledge and tools Specialized recommends that all service and repairs be performed by an authorized Specialized retailer Your bicycle has been engineered and tested with specific components and parts Because of the great variety in these items it is impossible for Specialized to test and approve of all possible combinations Modifying the frame fork or any of the components may make your bike unsafe For example changing the front suspension on your bicycle may alter the steering characteristics and or add stresses
7. ch use may damage the bicycle can cause serious personal injury or death and in all cases void this warranty 16 USEFUL PRODUCT LIFE CYCLE Every Specialized bicycle and frameset has a useful product life cycle The length of that useful product life cycle will vary with the construction and materials of the bicycle or frameset the maintenance and care the bicycle or frameset receives over its useful product life cycle and the type and amount of use the bicycle or frameset is subject to Uses in competitive events trick riding ramp riding jumping aggressive riding riding on severe terrain riding in severe climates riding with heavy loads commercial activities and other types of non standard use can dramatically shorten the useful product life cycle of a Specialized bicycle or frameset Any one or a combination of these conditions may result in an unpredictable failure of a Specialized bicycle or frameset that would not be covered by this warranty ALL SPECIALIZED BICYCLES AND FRAMESETS SHOULD BE PERIODICALLY CHECKED BY AN AUTHORIZED SPECIALIZED DEALER for indicators of stress and or potential failure including cracks deformation corrosion paint peeling dents and any other indicators of potential problems inappropriate use or abuse These are important safety checks and very important to help prevent accidents bodily injury to the rider and shortened useful product life cycle of a Specialized bicycle or frameset Special Note regarding C
8. d riding jumping and stunt riding increases the stress on every part of your bicycle Frames or parts under high stress may fail causing you to lose control or fall Because of the risk involved Specialized recommends that you conduct a thorough inspection before each ride If you miss a jump ditch your bike in mid crash dump or launch your bike without you on it inspect yourself for injury then carefully inspect your bicycle for damage 4 INTRODUCTION Here is what you should look for when you inspect your bicycle for this type of riding bent or broken components such as the handlebar handlebar stem seatpost pedals dents cracks scratches deformation or discoloration Because damage may be internal and hidden if any of these signs are present stop riding until your bicycle has been thoroughly inspected by your Specialized dealer WARNING Although many catalogs advertisements and articles about bicycling depict riders racing jumping riding hard off road and or stunt riding this activity is extremely dangerous increases the rider s risk of injury or death and potentially increases the severity of any injury The action depicted is being performed by experts with many years of training and experience Even with that training and experience cyclists who engage in such activity often get seriously injured It is also foreseeable that during some jumps or stunts and even some races that the rider will exceed the design capaci
9. eeves are available through your local Models through your local Specialized dealer Specialized dealer SJ MudFlap Part 9894 2300 Enduro SlapJacket Part 9893 2000 FSRxc MYKA FRAME FEATURES 1 Main Frame 2 Seatstay 3 Chainstay 4 Shock Link 5 Main Pivot 6 Dropout Horst Pivot 7 Shock Link at Seatstay Pivot 8 Shock Link at Frame Pivot 9 Lower Shock Eyelet 10 Upper Shock Eyelet Tl Shock 12 Replaceable Derailleur Hanger ONOUKRWDN FSRxc MYKA FRAME GEOMETRY FSRxc Geometry Top Tube Length Standover Hgt Head Tube Length Head Tube Angle Seat Tube Angle BB Height Wheelbase Chainstay Length Myka Geometry GO JOU E WM A Top Tube Length Standover Hgt Head Tube Length Head Tube Angle Seat Tube Angle BB Height Wheelbase Chainstay Length Men s Small 550mm 21 65 723mm 28 46 100mm 3 94 69 73 321mm 12 64 1053mm 41 46 424mm 16 70 Women s Small 535mm 21 06 720mm 28 35 100mm 3 94 69 5 73 321mm 12 64 1040mm 40 94 424mm 16 70 Men s Medium 586mm 745mm 110mm 69 732 321mm 1090mm 424mm 23 07 29 33 4 33 12 64 42 91 16 70 Women s Medium 560mm 725mm 100mm 69 5 13 321mm 1063mm 424mm 22 05 28 54 3 94 12 64 41 85 16 70 Men s Large 61imm 24 06 760mm 29 92 120mm 4 7
10. inal purchase from an authorized Specialized dealer and is conditioned upon the bicycle being operated under normal conditions and use and properly maintained This warranty is void if the bicycle was not purchased new from or not properly assembled by an authorized Specialized dealer LIMITED ONE 1 YEAR WARRANTY ON SUSPENSION ATTACHMENTS amp SUSPENSION RELATED EQUIPMENT Also subject to the following limitations terms and conditions Specialized warrants to the original owner of each new Specialized bicycle or frameset that the suspension attachment points and suspension related equipment including pivot points bushings shock units front suspension forks stays plates fasteners when new are free of defective materials or workmanship This warranty shall expire one 1 year from the date of the original purchase from an authorized Specialized dealer and is conditioned upon the bicycle being operated under normal conditions and use and properly maintained This warranty is void if the bicycle was not purchased new from or not properly assembled by an authorized Specialized dealer Some branded suspension equipment may have additional warranty coverage offered by the specific manufacturer Please check in your owner s manual pack for information regarding these warranties or check with your authorized Specialized dealer for details ADDITIONAL CONDITIONS This Limited Warranty is made only to the original owner of this new Specialized bicycle o
11. ld result in serious injury or death The combination of the safety alert symbol and the word Caution indicates a potentially hazardous situation which if not avoided may result in minor or moderate injury or damage to your bicycle or a component Because the consequences of not following a Warning usually include you may lose control and fall which could result in serious personal injury or death we may not repeat this in conjunction with each Warning Because it is impossible to anticipate every situation or condition which may occur a practice or situation may be unsafe but not anticipated by this manual So don t forget to use your common sense WARNING Make sure you have review and understand the warnings instructions and content of the manuals for your bicycle About Off Road Stunt Downhill and Freeriding Downhill racing severe off road riding jumping and stunt riding is extremely dangerous Some downhill racers and freeriders reach speeds similar to motorcycles thus face similar risks and hazards When engaging in these activities you your bicycle and safety equipment must be in perfect condition We recommend that at all times you wear appropriate safety gear such as an approved full face helmet full finger gloves and body armor Not every bicycle is built for every activity Check with your Specialized dealer to make sure you have the right equipment No bicycle is indestructible Downhill racing severe off roa
12. mplied warranty of merchantability any claimed implied warranty arising from course of performance course of dealing or usage of trade and any claimed implied warranty of fitness are disclaimed by Specialized and waived by the original owner Some states jurisdictions countries provinces do not allow some or all of the limitations set forth herein or the exclusion or limitation of incidental or consequential damages If any provision is found unenforceable only that provision shall be stricken and all others shall apply This limited warranty does provide the original owner with certain legal rights and recourse and the original owner may possess other rights or recourse depending on the state jurisdiction country or province 2Bliss 415 Al AA Main Aerotec Air Force Airliner Air Lock Air Tool Air Wave Air Wave Mega Allez Armadillo Assfault Beadlock BigHit BigHit Grom Body Geometry BrainTrust Big Mouth Cap Ply Chamonix Comfort Plush Crossroads Demo 9 Deuce Dirt Bag Dirtboy Dirt Control Dirt Master Dirt Rodz Dolce E5 E Cage Epic Evil Twin Expedition Extreme Control Extreme Master F A C T Fatboy FlakJacket Flexflo ForeArm FSR FSRxc FS Xpert Fuse Globe Ground Control Ground Force Hardlock Hardlock Rapper Hardrock Hardrock r Hemi Hotrock Hucker In Vent ITch Switch KidTrust Kid Cobra King Cobra Langster Little Big Mouth LSD M1 M2 M4 M5 Mini Wedgie Mt Baldy Mondo Mountain Cage Mouthpor
13. n does not dive and has time to rebound between bumps Fox Triad ride tips fig 1 Three compression settings dial in the shock efficiency and ride characteristics 1 Lockout compression is closed locking out the shock for the most efficient pedaling setting 2 ProPedal adds in slow speed compression to improve shock efficiency while still allowing the shock to absorb medium and large size hits This setting is great for all round riding providing an efficient pedaling platform while still absorbing trail features 3 Open very little compression damping for the most supple and sensitive ride possible X Fusion RLA ride tips fig 2 the RLA shock has a unique rebound adjust feature that affects compression and lockouts at the side X Fusion RC ride tips the blue compression lever will close the shock s compression locking it out for the most efficient ride 12 REAR AIR SHOCK SETUP Fig LOCKED AS FAST SLOW 3 OPEN L ur o PROPEDAL D Ssou TRIAD Fig 2 3 Place washer and tighten bolt 2 Position splined lever nO stop against shock body to lock preset rebound setting y 1 Position rebound adjust lever to achieve desired rebound X FUSION RLA Rider Triad X Fusion lbs kg air psi air psi 90 100 41 45 80 85 95 100 100 110 45 50 85 90 100 110 110 120 50 54 90 95 110 120 120 130 54 59 95 100 120 125 130 140
14. nd sleeve over guard pin and Q R F E f gt Short 10 J 6 Install supplied Q R nut and tighten Q R Ce CAN Ehe cit o 7 Torque guard pinch bolt to 80 in lbf 9 N m gt countersunk hanger bolt 13 14 Schematic 12 2004 2005 Hanger 9894 4205 2006 Hanger 9895 4020 1 f 1 b Dropouts 2 e Shock Link Chainstay 1 e Shock Link Mount Shock Link A NOTE Bearing and Bolt Kits are available only through your local Specialized dealer To retain your warranty and for your safety all maintenance should be performed by your local Specialized dealer Bearing Kit Parts ta 1 td te tg th Shock Link Seatstay Pivot Spacer Bolt Kit Parts B Blue Loctite required Part Qty PartDescription________ ______________________PartSpecification_____________________ Torque in ib Pp 2a i BBPivotNut AlloyNut 23 5mm0O Dxt5mml D t9mmsocket_______________ 200 230 2d 2 Shock Link Frame Pivot Bolt Alloy Bolt 10mm O D x 20mm Length 5mm AllenHexHead 120 140B 2e 2 _ShockLink Seatstay Pivot Bolt Alloy Bolt 10mm O D x 20mm Length 5mm AllenHexHead 120 140B 2k 2 Upper Shock Eye Spacer Spacer 16 5mm O D x 8 6mm I D x1mmWidth _ _ _ _ _ _ 15 SBC LIMITED WARRANTY Specialized Bicycle Components Inc Specialized a California corporation located at 15130 Concord Circle Morgan Hill California 95037 m
15. omposite Frames and Components Composite materials develop their strength and maintain strength only if the integrity of the part is fully maintained Pay special attention to and periodically and carefully inspect composite frames and components for signs of dents fraying gouging scratches fracture lines chipping In the event of a crash or serious impact or if any of the foregoing signs are observed the component and frame should not be ridden until inspected by an Authorized Specialized Dealer For your safety Specialized recommends replacing composite handlebars after three years of use THIS IS AN INTEGRATED AND FINAL STATEMENT OF SPECIALIZED S LIMITED WARRANTY SPECIALIZED DOES NOT AUTHORIZE OR ALLOW ANYONE INCLUDING ITS AUTHORIZED DEALERS TO EXTEND ANY OTHER WARRANTIES EXPRESS OR IMPLIED FOR SPECIALIZED NO OTHER REPRESENTATION AND NO STATEMENT OF ANYONE BUT SPECIALIZED INCLUDING A DEMONSTRATION OF ANY KIND BY ANYONE SHALL CREATE ANY WARRANTY REGARDING THIS BICYCLE OR FRAMESET ALL OF THE REMEDIES AVAILABLE TO THE ORIGINAL OWNER ARE STATED HEREIN IT IS AGREED THAT SPECIALIZED S LIABILITY UNDER THIS LIMITED WARRANTY SHALL BE NO GREATER THAN THE AMOUNT OF THE ORIGINAL PURCHASE PRICE AND IN NO EVENT SHALL SPECIALIZED BE LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES DISCLAIMER All other remedies obligations liabilities rights warranties express or implied arising from law or otherwise including but not limited to any claimed i
16. r frameset purchased from an authorized Specialized dealer and it shall remain in force only as long as the original owner retains ownership of the Specialized bicycle This Limited Warranty is not transferable In order to exercise your rights under this limited warranty the bicycle or frameset must be presented to an authorized Specialized dealer together with a receipt bill of sale or other appropriate written proof of purchase which identifies the bicycle or frameset by serial number Should this bicycle frameset or any part be determined by Specialized to be covered by this warranty it will be repaired or replaced at Specialized s sole option which will be conclusive and binding The original owner shall pay all labor charges connected with the repair or replacement of all parts Under no circumstances does this limited warranty include the cost of travel or shipment to and from an authorized Specialized dealer Such costs if any shall be borne by the original owner This limited warranty does not apply to normal wear and tear nor to claimed defects malfunctions or failures that result from abuse neglect improper assembly improper maintenance alteration collision crash or misuse This warranty is null and void if the bicycle is used for racing trick riding ramp riding jumping riding hard off road aggressive riding riding on severe terrain riding in severe climates riding with heavy loads commercial activities or similar activities Su
17. t Nimbus P 1 P 2 P 3 P Brain P Street Pave Prybaby Rib Cage Rockhopper Roll Model Roll X Roubaix the Stylized S logo S Works S1 Sawpit Sequoia Shocksox Sirrus Spanky Speed Zone Streetboy Strongarm Stumpjumper SubZero Survival Kit Tarmac Team Control Team Master Team Turbo TrailTraction TransForm Tri Sport TRX TR Xpert Turbo Pro Twistlock Vegas Web Wedgie Wedlock X Brace X Wire and Zertz are trademarks of Specialized Bicycle Components Inc which may be registered in some jurisdictions All other marks are the property of their respective owners 17 SPELIALIZEL 15130 Concord Circle Morgan Hill CA 95037 www specialized com 2008 Specialized Bicycles PN W2080308 SPECIALIZED BICYCLE COMPONENTS Please note all instructions are subject to change for improvement without notice 15130 Concord Circle Morgan Hill CA 95037 408 779 6229 Rev April 2007 18
18. ty of the frame or components which may result in something on the bicycle bending or breaking If a frame or component bends or breaks such may lead to loss of control serious personal injury or death As activities such as racing jumping severe off road riding and stunt riding are extremely dangerous SAFETY should always be the first consideration Don t ride in the race ride hard off road try the jump or do the stunt UNLESS YOU CAN DO SO SAFELY Here are some additional recommendations s Take lessons from a competent instructor first s Do jumps or stunts only in areas designated for this type of riding e Start with easy jumps and easy stunts first and slowly develop skills before trying more dangerous jumps or stunts e Wear appropriate safety gear such as a full face helmet body armor full finger gloves e Make sure by checking with your dealer that your bike is suitable for the kind of activity you intend to engage in s Constantly inspect your bicycle for signs of stress cracks in the paint dents crushing or bending of the frame bent components Do not ride your bicycle if it shows such signs of stress s Do not seek to bend or break the frame or components Remember SAFETY FIRST e Understand and recognize that the stresses imposed on your bike by riding at speed jumping or stunt riding may break or damage parts of the bicycle which may result in loss of control serious injury or death Specialized does not warr
Download Pdf Manuals
Related Search