Poulan 545212828 User's Manual
Contents
1. PPB2000T Prineet La ci E PPB5000P A A chee dee ee PPB5500P Brushcutter PPB4000C not designed for use with electric powerheads WARNING Always disconnect pow erhead spark plug or disconnect powerhead from power source before removing or instal ling attachments REMOVING ATTACHMENT CAUTION When removing or installing at tachments place the unit on a flat surface for stability 1 Loosen the coupler by turning the knob counterclockwise Hanger e S TIGHTEN 2 Press and hold the locking release button Locking Release Button IPP RT Attachment Coupler Upper Shaft 3 While securely holding the upper shaft pull the attachment straight out of the coupler INSTALLING ATTACHMENT 1 Remove the shaft cap from the attach ment if present and discard 2 Position locking release button of attach ment into guide recess of upper shaft coupler 3 Push the attachment into the coupler until the locking release button snaps into the primary hole 4 Before using the unit tighten the knob se curely by turning clockwise Primary Hole Coupler Guide Recess Locking Upper Release Attachment Shaft Button WARNING Make sure the locking release button is locked in the primary hole and the knob is securely tightened before op erating the unit Using the wrong hole could lead to serious injury or damage to the unit Locking Release Button in Pri2. THE EXCLUSION OR LIMITATIONS OF INCIDENTAL OR CONSE QUENTIAL DAMAGES SO THE ABOVE LIM ITATIONS OR EXCLUSION MAY NOT APPLY TO YOU This is a limited warranty within the meaning of that term as defined in the Magnuson Moss Act of 1975 The policy of Poulan PRO is to continuously improve its products Therefore Poulan PRO reserves the right to change modify or discontinue models designs specifications and accessories of all products at any time without notice or obligation to any purchaser
3. shown in this manual to pre vent damage to unit and or extension cord and to reduce the possibility of the exten sion cord disconnecting from the unit during operation Do not attempt to repair unit Inspect the insu lation and connectors on the powerhead and extension cord before each use If there is any damage do not use until damage is re paired by your authorized service dealer Do not use the powerhead if the switch does not turn the unit on and off properly Have the unit repaired by your authorized service dealer 23 Avoid unintentional starting of the unit Nev er carry unit with your finger on the switch Be sure the switch is in the OFF position and never touch the switch when connect ing extension cord e Avoid any body contact with any grounded conductor such as metal fences or pipes to avoid the possibility of electric shock Ground Fault Circuit Interrupter GFCI protection should be provided on the circuit or outlet to be used for the powerhead Re ceptacles are available having built in GFCI protection and may be used for this measure of safety e Stop the motor immediately if you are ap proached BLOWER SAFETY A WARNING Never put hands or other objects into blower housing to avoid serious injury from the rotating impeller WARNING Inspect the area before using the unit Remove all debris and hard ob jects such as rocks glass wire etc that can ricochet be thrown or otherwis
4. you are tired ill upset or if you are under the influence of al cohol drugs or medication Keep children bystanders and animals away from work area a minimum of 30 feet 10 meters when starting or operating unit Do not point blower discharge opening in the direction of people or pets FUEL SAFETY for gas powerheads Eliminate all sources of sparks or flame in cluding smoking open flames or work that can cause sparks in the areas where fuel is mixed poured or stored Mix and pour fuel in an outdoor area store fuel in a cool dry well ventilated place use an approved marked container for all fuel purposes Do not smoke while handling fuel or while operating the unit Make sure the attachment is properly as sembled and in good operating condition Do not fill fuel tank while engine is running Avoid spilling fuel or oil Wipe up fuel spills before starting engine Move at least 10 feet 3 meters away from fuel and fueling site before starting engine e Always store gasoline in a container ap proved for flammable liquids ELECTRICAL SAFETY for electric powerheads AWARNING Avoid a dangerous environment To reduce the risk of electrical shock do not use in rain in damp or wet locations or around swimming pools hot tubs etc Do not expose to snow rain or water to avoid the possibility of electrical shock Do not use on wet surfaces Do not han dle extension cord plug or unit with wet hands Avoid dan
5. Poulan PRO Por favor no devuelva el producto al lugar de compra Veuillez ne pas retourner le produit au d taillant 1 800 554 6723 9 Please do not return product to retailer Register your product online at Registre su producto en linea en Enregistrez votre produit en ligne a l adresse www poulanpro com Instruction Manual Manual de Instrucciones Manuel d Instructions PPB3000B LONE RE WARNING A Read and follow all Safety Rules and Operating Instructions before using this product Failure to do so can result in serious injury Refer to your original manual for additional Warnings and Operating Instructions ADVERTENCIA Lea el manual de instrucciones y siga todas las advertencias e instrucciones de seguridad El no hacerlo puede resultar en le siones graves Refiera a su manual original para las Instrucciones de Funcioniamiento y las Advertencias adicionales AVERTISSEMENT Lire le manuel d instructions et bien respecter tous les avertisse ments et toutes les instructions de s curit Tout d faut de le faire pourrait entrainer des blessures graves R f rez vous a votre manuel original pour des Avertissements et des Instructions d Uti lisation additionnels Poulan PRO 7349 Statesville Road Charlotte NC 28269 SIVONVHS 545212828 Rev 3 6 15 10 BRW IDENTIFICATION OF SAFETY SYMBOLS AWARNING This unit can be dangerous Careless or improper Use can cause serious injury
6. Read the operator s manual before use Failure to follow instructions could result in serious injury Save operator s manual Hazard zone for thrown objects Keep children bystand ers and animals away from work area a minimum of 50 feet 15 meters when starting or operating unit Do not point blower nozzle in the direction of people or pets The blower can throw objects violently You can be blinded or injured Always wear hearing protection and safety glasses marked Z87 Always wear heavy long pants long sleeves boots and gloves IMPORTANT WARNINGS AND SAFETY INSTRUCTIONS AWARNING When using electric gardening appliances basic safety precautions should always be followed to reduce the risk of fire electric shock and serious injury The warnings and safety instructions in this manual must be followed to reduce the risk of fire electric shock or injury and to provide reasonable safety and efficiency in using this unit The operator is responsible for following the warnings and instructions in this manual and on the unit Read the entire instruction manual be fore assembling and using the unit Restrict the use of this unit to persons who read understand and follow the warnings and instructions in this manual and on the unit Never allow children to use this unit Do not allow the unit to be used as a toy Close attention is necessary when used near children Always disconnect unit from power source when making repairs adj
7. e damage to the unit Never use for spreading chemicals fertiliz ers or other substances which may contain toxic materials To avoid spreading fire do not use near leaf or brush fires fireplaces barbecue pits ashtrays etc Wear hearing protection Use only in daylight or good artificial light MAINTAIN YOUR UNIT PROPERLY WARNING Disconnect powerhead spark plug or disconnect powerhead from power source before performing mainte nance Have all maintenance other than the rec ommended procedures described in the in struction manual performed by your autho rized service dealer Always see your authorized service dealerto replace a damaged impeller Parts that are chipped cracked broken or damaged in any other way can fly apart and cause seri ous injury Have damaged parts replaced before using attachment Use only recommended Poulan PRO re placement parts use of any other parts may void your warranty and cause damage to your unit Never douse or squirt the attachment with water or any other liquid TRANSPORTING AND STORAGE e Hand carry the unit with the engine stopped Allow the powerhead and attachment to cool and secure the unit before storing or transporting in a vehicle Store unit and fuel in area where fuel vapors cannot reach sparks or open flames from water heaters electric motors or switches furnaces etc Store in a high cool dry indoor area out of reach of children If situation
8. e cause injury or damage during operation Inspect attachment before each use for worn loose missing or damaged parts Do not use until unit is in proper working order Keep outside surfaces free from oil and fuel Never start or run engine inside a closed room building or other unventilated area Breathing exhaust fumes can kill Avoid dangerous environments Do notuse in unventilated areas or where explosive vapors or carbon monoxide build up could be present Do not set unit on any surface except a clean hard area while engine is running Debris such as gravel sand dust grass etc could be picked up by the air intake and thrown out through discharge opening damaging unit property or causing serious injury to bystanders or operator Do not overreach or use from unstable sur faces such as ladders trees steep slopes rooftops etc Keep firm footing and balance at all times Never place objects inside the discharge opening always direct the blowing debris away from people animals glass and solid objects such as trees automobiles walls etc The force of air can cause rocks dirt or sticks to be thrown or to ricochet which can hurt people or animals break glass or cause other damage Check air intake opening frequently Keep vents and discharge opening free of debris which can accumulate and restrict proper air flow Never place any object in air intake opening as this could restrict proper air flow and caus
9. e plug still does not fit obtain a correct polarized extension cord A polarized extension cord will require the use of a polarized wall outlet This plug will fit into the polarized wall outlet only one way If plug does not fit fully into the wall outlet reverse the plug Ifit still does not fit contact a qualified electrician to install the proper wall outlet Do not change the equip ment plug extension cord receptacle or extension cord plug in any way To reduce risk of electrical shock use ex tension cords specifically marked as suit able for outdoor appliances having electri cal rating not less than the rating of unit Cord must be marked with suffix W A in Canada W Make sure your extension cord is in good condition Inspect extension cord before use and replace if damaged Do not use a damaged cord Cord insulation must be intact with no cracks or deteriora tion Plug connectors must be undamaged The extension cord used to reach the pow er source must be heavy enough to carry current from the power source the full length of the extension cord to the unit An under sized extension cord will cause a drop in line voltage resulting in loss of power and overheating If in doubt use the next heavi er gauge The lower the gauge number the heavier the cord Do not use multiple cords Keep the extension cord clear of operator and obstacles at all times Tie cord to cord retainer and connect to re cessed plug as
10. gerous situations Do not use in the presence of flammable liquids or gases to avoid creating a fire or explosion and or causing dam age to unit Do not abuse cord Never carry the unit by the extension cord or yank extension cord to disconnect unit To unplug grasp the plug not the cord Do not use cord as a handle close a door on cord or pull cord around sharp edges or corners Turn off all controls before un plugging Do not expose cords to heat oil or water Do not use with damaged cord or plug If unit is not working as it should has been dropped damaged left outdoors or dropped into water return it to your authorized service dealer for repair Unplug the unit from the power source when not in use before servicing and when changing accessories and or attach ments Do not put any object into openings Do not use with any opening blocked keep free of dust lint hair and anything that may reduce air flow e Use only a voltage supply as shown on the nameplate of the powerhead e Avoid dangerous environments Do not use in unventilated areas or where dust or explo sive vapors can build up e To reduce the risk of electric shock the powerhead may have a polarized plug one blade is wider than the other if so it will re quire the use of a polarized extension cord The appliance plug will fit into a polarized extension cord only one way If the plug does not fit fully into the extension cord re verse the plug If th
11. mary Hole INSTALLING ATTACHMENT HANGER An attachment hanger is provided for storage when attachmentis notin use To install hang er on attachment 1 Remove the shaft cap from the attach ment if present and discard 2 Press and hold the locking release but ton 3 Push hanger onto the attachment until the locking release button snaps into the hole OPERATING POSITION Eye Protection WARNING Inspect the area before using the unit Remove all debris and hard objects such as rocks glass wire etc that can ricochet be thrown or otherwise cause injury or damage during operation Use your blower attachment for e Sweeping debris or grass clippings from driveways sidewalks patios etc e Blowing grass clippings straw or leaves into piles or removing debris from corners around joints or between bricks Control air flow by directing the blower dis charge opening down or to one side Always work away from solid objects such as walks large stones vehicles and fences Clean corners by starting in corners and moving outward This will help prevent an accumulation of debris which could fly into your face Be careful when working near plants The force of the air could damage tender plants MAINTENANCE A WARNING Always stop unit and dis connect spark plug wire or disconnect pow erhead from power source before performing maintenance CHECK FOR LOOSE FASTENERS AND PARTS e Hou
12. s occur which are not covered in this manual use care and good judgment If you need assistance call 1 800 554 6723 SPECIAL NOTICE Exposure to vibrations through prolonged use of gasoline powered hand tools could cause blood vessel or nerve damage in the fingers hands and joints of peo ple prone to circulation disorders or abnormal swelling Prolonged use in cold weather has been linked to blood vessel damage in other wise healthy people If symptoms occur such as numbness pain loss of strength change in skin color or texture or loss of feeling in the fingers hands or joints discontinue the use of this tool and seek medical attention An anti vibration system does not guarantee the avoidance of these problems Users who operate power tools on a continual and regular basis must monitor closely their physical condition and the condition of this tool SAVE THESE INSTRUCTIONS 4 OPERATION KNOW YOUR BLOWER ATTACHMENT READ THIS INSTRUCTION MANUAL AND SAFETY RULES BEFORE OPERATING YOUR BLOWER ATTACHMENT Compare the illustrations with your unitto familiarize yourself with the location of the various controls and adjustments Save this manual for future reference Shaft pa Air Intake Opening Blower Discharge Opening OPERATING THE COUPLER Your powerhead is equipped with a coupler which enables optional attachments to be installed The optional attachments are MODEL E ari ars PPB1000E Cultivator
13. sing Screws INSPECT AND CLEAN UNIT AND LABELS After each use inspect complete unit for loose or damaged parts Clean the unit and labels using a damp cloth with a mild deter gent Wipe off unit with a clean dry cloth STORAGE WARNING Perform the following steps after each use e Allow attachment to cool before storing or transporting Store in a high cool dry indoor area out of reach of children SEASONAL STORAGE Prepare attachment for storage at end of sea son or if it will not be used for 30 days or more If your blower attachment is to be stored for a period of time e Clean the entire unit Inspect attachment for any loose or dam aged parts Tighten any loose screws Replace any damaged worn or broken parts At the beginning of the next season use only fresh fuel having the proper gasolineto oil ratio LIMITED WARRANTY Poulan PRO a division of Husqvarna Consum er Outdoor Products N A Inc warrants to the original consumer purchaser that each new Poulan PRO brand gasoline tool or attachment is free from defects in material and workman ship and agrees to repair or replace under this warranty any defective gasoline product or at tachment as follows from the original date of purchase 2 YEARS Parts and Labor when used for household purposes 90 DAYS Parts and Labor when used for commercial professional or income producing purposes 30 DAYS Parts and Labor if used for rental p
14. urposes This warranty is not transferable and does not cover damage or liability caused by improper handling improper maintenance or alteration or the use of accessories and or attachments not specifically recommended by Poulan PRO for this tool This warranty does not cover parts that will wear and require replacement with reason able use during the warranty period This war ranty does not cover pre delivery setup or nor mal adjustments explained in the instruction manual This warranty does not cover trans portation costs In the event you have a claim under this warran ty you must return the product to an authorized service dealer Should you have any unanswered questions concerning this warranty please contact Poulan PRO a division of Husqvarna Consumer Outdoor Products N A Inc 7349 Statesville Road Charlotte NC 28269 1 800 554 6723 In Canada contact Poulan PRO 850 Matheson Blvd West Mississauga Ontario L5V 0B4 Giving the model number serial number and date of purchase of your product and the name and address of the authorized dealer from whom it was purchased THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY HAVE OTH ER RIGHTS WHICH VARY FROM STATE TO STATE NO CLAIMS FOR CONSEQUENTIAL OR OTHER DAMAGES WILL BE ALLOWED AND THERE ARE NO OTHER EXPRESS WARRANTIES EXCEPT THOSE EX PRESSLY STIPULATED HEREIN SOME STATES DO NOT ALLOW LIMITA TIONS ON HOW LONG AN IMPLIED WAR RANTY LASTS OR
15. ustments and when changing accessories and attachments Nonconforming replacement components or the removal of safety devices may cause damage to the unit and possible injury to the operator or bystanders Use only accessories and replacement parts as recommended Use only for jobs explained in this manual KNOW YOUR UNIT PLAN AHEAD Read your instruction manual carefully until you completely understand and can follow WARNING Inspect area before use all warnings and safety rules before operat Remove all debris and hard objects such as ing this attachment rocks glass wire etc that can ricochet be e Restrict use of this attachmentto users who thrown or otherwise cause injury or damage understand and will follow all warnings and during operation safety rules in this manual 2 e Always wear eye protection when operat ing servicing or performing maintenance on this attachment Wearing eye protection will help to prevent rocks or debris from be ing blown or ricocheting into eyes and face which can result in blindness and or seri ous injury Eye protection should be marked Z87 Always wear foot protection Do not go barefoot or wear sandals Always wear respirator or face mask when working with unit in dusty environments Secure hair above shoulder length Secure or remove jewelry loose clothing or cloth ing with loosely hanging straps ties tas sels etc They can be caught in moving parts Do not operate unit when
Download Pdf Manuals
Related Search