Pelican WF4 User's Manual
Contents
1. Ag Pelican Water Systems Owner s Manual Pelican WF4 WF8 Premium Whole House lron and Manganese Filtration System Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 2 T Copyright 2013 Enviro Water Solutions Inc All rights reserved All information contained herein is the property of Pelican Water Systems Pelican Water Systems makes no warranty of any kind with regard to this material including but not limited to the implied warranties of merchantability and fitness for a particular purpose Pelican Water Systems shall not be liable for technical or editorial errors or omissions contained herein or for incidental or consequential damages in connection with the furnishing performance or use of this material The information is provided as is without warranty of any kind and is subject to change without notice This document contains proprietary information which is protected by copyright No part of this document may be photocopied reproduced or translated into another language without the prior written consent of Pelican Water Systems Pelican Water Systems is an Enviro Water Solutions Inc company 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 3 Se Table of Contents Table of Contents ou 2522553432. Level the Pelican Whole House Iron amp Manganese Filter Notice If the tank is not level lift the tank straight up 6 inches and tap it on the ground until the tank stands vertical The bottom of the tank is round and the boot allows the tank to stand upright 2 Determine the size and material of your incoming water supply line from the In Line Injection Port and choose the appropriate fittings required to connect it to the Bypass Valve A CAUTION Do not over tighten any of the fittings during installation Table 2 Bypass Valve Fittings Part Description Qty Note The fitting above is designed with a 1 4 give to allow for proper pipe alignment It will not leak and is intended to have some flexibility 1 PVC Tail Adaptor for 2 Electronic Head Bypass 3 Remove the gray cap from the top of the Whole House Iron amp Manganese tank 4 Screw the Electronic Head onto the tank hand tight 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 14 Install the fittings onto the inlet and outlet following the arrows on the Bypass Valve and head Connect the incoming water supply to the fitting on the inlet side of the Bypass Valve Connect the outgoing water supply
3. Turn the ratio adjustment slide 2 full revolutions in the positive direction Replace the black clip b If it is higher than 3ppm remove the black clip from the ratio adjustment slide Turn the ratio adjustment slide 2 full revolutions in the negative direction Replace the black clip 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 18 CAUTION Do not remove the silver clip from the ratio adjustment slide when the system is under pressure 7 Continue with these steps until the system achieves a 3ppm reading on the chlorine test strip Black Clip Chemical Injector Pump Tubing Jm Adjustment Ratio Slide Figure 11 A CAUTION Avoid high flow rates such as bathtub utility sinks hose bibs multi headed showers body sprayers or anything that is considered high flow for the first 72 hours to avoid flow restrictions caused by carbon blockage of the top basket inside the carbon tank Carbon dust may be released into the water lines of the house building during the first few days of water use after carbon tank installation The carbon dust is harmless but may give the water a gray appearance that should diminish within a week or 10 days depending on water use 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand
4. clear the blockage and you can resume using water at low or normal flow rates 2013 Enviro Water Solutions Inc 3060 Performance Circle Suite 2 DeLand FL 32724 www pelicanwater com 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 21 Warranty Pelicans Limited Lifetime Warranty Pelican Water Pelican warrants to the end user customer that its tanks 13 amp smaller valves in out heads bypass s fittings Natursoft media and housings Covered Items will be free from defects in material and workmanship under normal use and service for the life of the system No warranty is made with respect to defects or damaged due to neglect misuse alterations accident misapplication physical damage installation on water quality outside guidelines for system or damaged caused by fire acts of God or freezing Pelican Superdos Professional Chemical Injector Pump Warranty Pelican Water Pelican warrants to the end user customer that its Superdos Professional Chemical Injector Pump Motor upper half of unit will be free from defects in material and workmanship under normal use and service for a period of 1 year The Superdos Professional Chemical Injector Pump Adjustment Ratio Side lower half of unit will be free from defects in material and workmanship under normal use and service for a period of 90 days The Chemical Injector Pump tubing is not covered
5. following the booster pump f you have questions please call customer service 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 5 Complete Parts List Note Pelican supplies the parts below to accommodate a variety of water supply lines Table 1 Parts List Part Description Description 1 Plastic Male NPT Assembly V3007 04 WS1 Fitting 1 Plastic Male NPT Assembly 2 O Rings 2 Split Rings 2 and Connectors 2 Bypass Valve In Out Bypass Valve with Red Arrow Handles 1 PVC Tail Adaptor for Electronic Head Bypass Hose Bib Assembly Pre Filter System PP5 Big Blue Pre Filter Housing Mounting Bracket Phillips Head Screws 4 Bolt Head Screws 4 and Washers 4 Bypass Valve for Electronic Head Sediment Filter Pre Filter Wrench PC40 1 5 Micron Poly Spun Sediment Filter Electronic Head Solution Tank PVC Tubing Drain Line 50 ft Chemical I njector Pump Tubing Chlorine Test Strips WAX Non Abrasive Auto Wax 4 oz Bottle Chemical I njector Pump 2013 Enviro Water Solutions Inc 3060 Performance Circle Suite 2 DeLand FL 32724 www pelicanwater com 877 842 1635 Pelican WFA WF8 Premium Whole House Iron and Man
6. the tank is round and the boot allows the tank to stand upright Unlevel Tank Sel Boot Se Unlevel Tank us Boot S PNEU a Level Tank Unlevel Boot Water pressure is slowing It is recommended that the Sediment Filter be replaced every 6 9 months depending on the amount of sediment present in the water supply If the system has been working properly and the pressure is slowing it may be time to change the Sediment Filter Check the Sediment Filter and replace if necessary Iron appears in the water Adjust settings on Chemical Injector Pump by removing black clip on the adjustment ratio slide and turning the adjustment ratio slide 2 full revolutions in the positive direction See graphic on page 18 to locate adjustment ratio slide If problem persists increase backwash frequency by one day Water appears grey or cloudy Water may appear grey or cloudy for the first seven to ten days after installation due to extra carbon dust Water pressure is slowing immediately after installation High flow rates such as bathtubs utility sinks hose bibs multi headed showers body sprayers or anything that is considered high flow for the first 72 hours should be avoided If you suspect a carbon blockage of the top basket due to a high flow situation within the first 72 hours of installation turn off any running water for at least 10 minutes This will
7. to the outlet side of the Bypass Valve Firmly press one end of the discharge PVC Tubing Drain Line onto the barbed nose and secure the other end of the line to a drain ongu Whole House Water Filter Tank Installation 1 Level the Pelican Whole House Water Filter i Notice If the tank is not level lift the tank straight up 6 inches and tap it on the ground until the tank stands vertical The bottom of the tank is round and the boot allows the tank to stand upright Chemical Injector Pum Spigot ump optional a i oy Incoming oe Water Supply Chemical Pre Filter Injector Pump Tubing Discharge Line Solution Tank Daf Electronic Head Whole House Water Filter Whole House Iron amp Manganese Filter Figure 9 2 Determine the size and material of your incoming water supply line from the Whole House Iron amp Manganese Filter and choose the appropriate plumbing required to adapt to the 1 Male NPT Assembly CAUTION Do not over tighten any of the fittings during installation Table 3 Bypass Valve Fittings Note The fitting below is designed with a 1 4 give to allow for proper pipe alignment It will not leak and is intended to have some flexibility Part Description Qty 1 Plast
8. where water is microbiologically unsafe or with water of unknown quality without proper disinfection before or after the filter softener system Product Certifications Pelican NaturSoft NS3 NS6 WQA Gold Seal tested and certified under NSF ANSI61 for material safety and tested according to NSF ANSI 42 for structural integrity only Clack V3007 xx Bypass Fittings WWQA Gold Seal Certified to NSF ANSI Standard 44 for material safety and structural integrity only U S Green Building Council 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635
9. 35 gallons of fresh bottled water Replace the cap 6 Determine the length of Chemical Injector Pump Tubing required to reach the bottom connection point of the Chemical Injector Pump and then cut the Chemical Injector Pump Tubing to the appropriate length 7 Connect the Chemical Injector Pump Tubing to the suction valve on the Chemical Injector Pump II MPORTANT Ensure the Chemical Injector Pump Tubing is free of kinks I MPORTANT Ensure Solution Tank is not sitting directly on a concrete floor 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 13 Iron and Manganese Tank Installation Chemical Injector Pump Spigot optional z Incoming Water Supply Chemical T Outgoing Pre Filter Injector Water to Pump Tubing House T J a T Discharge e Line Solution Tank olution Tan Electronic Head Whole House Water Filter Whole House Iron amp Manganese Filter Figure 8 i Notice Follow the raised black arrows on the head of the Whole House Iron amp Manganese tank 1
10. EI a on ai Oecum arr dogs Rane and dna Teu rid 17 Iron and Manganese Tank Regen ss ser rw exc yx a X Y e es 17 Testing Chlorine Levels in Water ouv sie EE ERR PERLE ek E ex 17 Care and Cleaning uius va REA E eee ieee eles E NET EU 19 Sediment filter ve xccatadeencd e bw REX xxt E eX RP VE X Fey SER EA 19 Replacing the Sediment Filter arcae ate ee rn d ERR ao Samo ob a E RE Wie 19 Chemical Injector PUITID sS eddie we Paca as ttg perci egt oi egt pit ERE earl 19 Solution Tank Refill Chlorine 2 ates eoo aoe Re Eee efr DR e e ded ln es 19 Troubleshooting i 9 924 789a wA tae ee te eee FW GNE Ea eis 20 Warranty exea rede SNR RU WE RE ERR ROSE Bx S tee RU REOR wa ERE E B RUE TRA CER RR 21 Warranty Registration Form os oes der D RU deo to t EV E cba edad t Us PAREM 23 Product Certifications as aces ak ax sri oe ete EGG E GREAT E Sree MEA EE 24 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 4 SS ee Product Operation and Specifications Specification Description WF4 WF8 Max Flow Rate 10 GPM 15 GPM Minimum Working Pressure 25 PSI Maximum Working Pressure 80 PSI Maximum Vacuum 5 inch 127 mm Hg Operating Temperatures 36 F 120 F pH Range 7 11 Minimum Rated Service Flow must be at least 6 GPM Important Information W Read th
11. ERx QS ERE VI we ee sete tek e series euee reeks 3 Product Operation and Specifications 0 00ce eee ee 4 Important I nformation us sx o ered ee eee sete s eae eee ewer setae ada yis 4 Complete Parts List iza iiia iia a aaa a a QUA RR see BUR RARUS CENE Rcg Qe BR RR CR 5 Installation Overview s err hh hh hh hh hh 7 Pre InstallaHon 52 sl ruo ites aie Es ra PA EET WESS Id E a 7 Bypass Valve Installation wies bw v EX vx x RE SS 7 Carbon Tank Soak a 2c 163 4 eod LE bof a sotto dois d cana e aT EN CR en AT M SES rt eius 9 Carbon Tank Washi ee e Gols gerer mida ue pu ER ER tke tte n TA RC EE ES e 10 Installati n i 225 son x annonces a va ee a UR RR C ea daro anc eta as a s RS ile d acide 11 PresPilter Assembly duc ostia d a ace dla 7 RE VE V TAG Lesh ba a NE wet eras 11 Pre Filter Installation s ss s y wr EXER reca X been Eee ee Pee 11 Chemical Injector Pump and Solution Tank Installation 0 00 cee eee eee 12 Chemical Injector Pump Installation 22222 pr RR RR 12 S l ti n Tank Installation 26455 3 ive hte aber atte Sette Coca e EHE ER Ee LEN 12 Iron and Manganese Tank Installation seen 13 Whole House Water Filter Tank Installation leen 14 Complete the Installation iseeerseere hn nnn 16 Programming the Electronic Head eeeee rh 16 Step 1 Setting the Valve aise uu er ERES E dub rhe he dme eee E ers 16 Step 2 Setting the Time ved emend 9 E EU b
12. FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 19 SSS Care and Cleaning Sediment Filter It is recommended that the Sediment Filter be replaced every 6 9 months depending on the amount of sediment present in the water supply If the system has been working properly and the pressure is slowing it may be time to change the Sediment Filter Check the Sediment Filter and replace if necessary Replacing the Sediment Filter Pre Filter Cover Sediment Filter a E 4 Y O Ring Blue Pre Filter Housing Stand Pipe Turn off the main water supply to the Pre Filter System and bypass all tanks Run a faucet cold water inside the house to relieve the pressure Unscrew the Blue Pre Filter Housing clockwise using the supplied Pre Filter Wrench Remove the existing Sediment Filter and discard Un d OS se Remove the O Ring and wipe the groove and O Ring clean Lubricate the O Ring with a coating of Clean silicone grease Replace O Ring and press the O Ring down into the groove with two fingers Note This step is important to ensure the proper filter seal Make sure the O Ring is seated level in the groove If the O Ring appears damaged stretched or crimped it should be replaced at this time 6 Place a new Sediment Filter onto the Stand Pipe in the Blue Pre Filter Housing 7 Screw the Blue Pre Filter Housing onto the Pre Filter Cover 8 Turn on
13. arbon Tank Soak process is complete Notice Water will flow out of the downflow inlet side of the Bypass Valve during this process Be sure you perform this series of steps in a location suitable for water flow Bypass Valve Garden Hose Hose Bib Assembly N Whole House Water Filter Figure 4 1 Reattach the garden hose to the Hose Bib Assembly 2 Slowly turn on the water 1 4 turn for this entire process 3 Run water through the upflow inlet side of the Bypass Valve for 15 30 minutes or until the water discharging from the downflow inlet side of the Bypass Valve runs clear 4 Turn off the water 5 Remove the Hose Bib Assembly from the upflow inlet side and attach it to the downflow inlet side of the Bypass Valve 6 Run the water through the downflow inlet side for 1 minute or until water runs clear 7 Turn off the water 8 Remove the Hose Bib Assembly from the Bypass Valve and disconnect the garden hose Note Please save the Hose Bib Assembly as this will be used in the future for the carbon exchange 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 11 Installation Pre Filter Assembly EN Pre Filter Cover N h Sediment Filter j E v O Ring Blue Pre Filter Housi
14. as part of this warranty Limitations and Responsibilities Pelican s obligation to the customer under these warranties shall be limited at its option to replacement or repair of Covered Items by these warranties labor is not covered Prior to return or repair of Covered Items the customer must obtain a return goods authorization number from Pelican and at Pelicans option return the Covered Items freight prepaid Any Covered Item repaired or replaced under these warranties will be returned prepaid standard freight to the original point of shipment Expedited freight options are available at customer expense No warranty is made with respect to defects or damaged due to neglect misuse alterations accident misapplication physical damage or damaged caused by fire acts of God or freezing These warranties apply only to the original registered owner so long as the owner owns the home in which the unit was originally installed Customer must register their system with Pelican within 90 days of purchase in order to obtain a warranty Warranty will discontinue after the unit is removed from the location where it was originally installed Warranty begins on the date of delivery of product to the customer Improper maintenance of system i e not replacing filters or media on time will be considered neglect Installation of any system on water conditions outside of or beyond the recommended specs of any system voids any warranty Pelican gives
15. ce For safety reasons the outlet must be protected by a Ground Fault Circuit Interrupter GFCI Note These settings are specific to this system Do not make changes to the settings unless instructed by customer service All settings have to be set by first setting the clock to 12 01 PM To restart programming you must start over at step 1 Do not go to a previous step you must start over at step 1 Extra Cycle Up Down Button Button Button Figure 10 Step 1 Setting the Valve l Press and hold the UP or DOWN button to change the clock to 12 01 PM 2 Press the EXTRA CYCLE button once 3 Press and hold the UP and DOWN buttons together until DF is displayed in the left corner Scroll using the UP and DOWN arrows until GAL is selected Press EXTRA CYCLE 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 17 4 Follow the steps in the table below to finish setting the valve When each setting is displayed use the UP and DOWN buttons to scroll to the appropriate data setting displayed in the table Press EXTRA CYCLE to select the data setting and go to the next setting Table 4 Setting the Valve Parameter Display Left Corner Data Display Set To VT Valve Type Fitr CT Co
16. ese instructions carefully and determine the location of all system components before beginning installation W Check all applicable plumbing building and electrical codes for installation compliance W install the system on the main water supply W Systems that contain electronic components cannot be installed outside in uncovered areas A WARNING If this or any other system is installed in a metal conductive plumbing system i e copper or galvanized metal the plastic components of the system will interrupt the continuity of the plumbing system As a result any errant electricity from improperly grounded appliances downstream or potential galvanic activity in the plumbing system can no longer ground through contiguous metal plumbing Some homes may have been built in accordance with building codes which actually encouraged the grounding of electrical appliances through the plumbing system Consequently the installation of a bypass consisting of the same material as the existing plumbing or a grounded jumper wire bridging the equipment and re establishing the contiguous conductive nature of the plumbing system must be installed prior to your systems use A CAUTION When adding a filtration softening system to homes buildings supplied by well water the system should be installed following the pressure tank DO NOT USE this system for pneumatic or hydro pneumatic applications If you are using a booster pump then install this system
17. ganese Rev R Filtration System Page 6 Part Description Part Description Qty Pelican Whole House Pelican Whole House I ron 1 Ww Water Filter c o amp Manganese Filter M SS Note Drawings are not to scale Additional fittings will be needed to adapt to your plumbing 2013 Enviro Water Solutions Inc 3060 Performance Circle Suite 2 DeLand FL 32724 www pelicanwater com 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 7 Installation Overview Chemical Injector Spigot Pump optional x Incoming gt N Water Outgoing Supply Water to Pre Filter Injector House Pump Tubing Discharge Line Solution Tank Electronic Head Whole House Water Filter Whole House Iron amp Manganese Filter Figure 1 Pre Installation Bypass Valve Installation Red Arrow Bypass a Valve Quick R Connect Nut LAIN MO ddn Water Filter Electronic Head Whole House Water Filter Whole House Iron amp Manganese Filter Figure 2 Whole House Water Filter The Bypass Valve comes pre assembled and ready to install with the O Rings S
18. ic Male NPT Assembly 1 V3007 04 WS1 Fitting 1 Plastic Male NPT bag Assembly 2 O Rings 2 Split Rings 2 and Connectors 2 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 15 UH 3 Install the fitting onto the upflow and downflow inlet sides of the Bypass Valve Follow the diagram supplied with the fitting 4 Connectthe incoming water supply from the Pelican Whole House Iron amp Manganese Filter to the fitting on the upflow inlet side of the Bypass Valve 5 Connect the outgoing water supply to the downflow inlet side of the Bypass Valve 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 16 Complete the Installation Turn on the main water supply Check for leaks Peel off the protective plastic wrap from the stainless steel tank jackets Add the Pelican logo sticker in the desired location on the tank T Da 5 Wax stainless steel tank jacket s with wax provided or any other non abrasive auto wax a minimum of 1 2 times per year or as needed based on the installed environment Programming the Electronic Head Note Power Sour
19. main water supply slowly to allow the Pre Filter System to fill with water and put tanks back in service out of bypass 9 Check for leaks Chemical Injector Pump 1 Change every six months Kit A part number P SDP A 2 o rings and dosage piston One extra Kit A is included with your original purchase 2 Change every year Kit C part number P SDP C 2 o rings dosage piston and shaft Note Spare kits for replacement purposes can be obtained by calling your customer service representative at Pelican Water Solution Tank Refill Chlorine l Check the level of the Solution Tank once per month Do not let the liquid in the tank fall below V4 full 2 Fill the tank with 9 cups of household bleach and 35 gallons of treated water water that has gone through your filtration system Replace the cap 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Filtration System Rev R Page 20 Troubleshooting Problem Solution Water leaking at the top of the tank around the head You may need to turn the head to tighten it The tank head is pre installed hand tight do not overtighten the head just turn it snug The tank leans to one side or is not level If the tank is not level lift the tank straight up 6 inches and tap it on the ground until the tank stands vertical The bottom of
20. nc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 9 Carbon Tank Soak II MPORTANT Your system will not be ready for use for a minimum of 48 hours while the Carbon Soak process takes place Please plan your installation accordingly DN Notice Water will flow out of the downflow inlet side of the Bypass Valve during this process Be sure you perform this series of steps in a location suitable for water flow Bypass Valve Garden Hose LAS Top View Hose Bib Assembly gt UPFLOW INLET Whole House Water Filter Figure 3 1 Attach a garden hose to the Hose Bib Assembly 2 Connect the Hose Bib Assembly to the upflow inlet side of the Bypass Valve and hand tighten 3 Fill the Pelican Whole House WaterFilter Tank full until water comes out of downflow inlet side of the Bypass Valve 4 Turn the water off 5 Remove the garden hose from the Hose Bib Assembly Do not remove the fitting 6 Allow the carbon tank to soak for at least 48 hours prior to tank installation 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 10 Carbon Tank Wash I MPORTANT Do not perform the Carbon Tank Wash until the C
21. ng Cr di ul i Stand Pipe 1 Unscrew the cover from the Blue Pre Filter Housing Figure 5 2 Remove the plastic covering from the Sediment Filter 3 Place the Sediment Filter onto the Stand Pipe in the Blue Pre Filter Housing 4 Screw the cover onto the Blue Pre Filter Housing until hand tight Pre Filter Installation o o Mounting Top View Pre Filter Bracket Inlet Water 5 Supply i E Blue Pre Filter Housing Figure 6 l Shut off the water Attach the Mounting Bracket to the wall using the supplied Phillips Head Screws and Washers Attach the Pre Filter System to the Mounting Bracket using the supplied Bolt Head Screws Lube the o ring with clean silicone grease before attaching the cover onto the housing Tighten the Blue Pre Filter Housing using the supplied Pre Filter Wrench counter clockwise Determine the size of your inlet water supply line PVC Reducers may be needed to fit the 1 Pre Filter System Notice The Pre Filter Housing comes with a 1 threaded female inlet outlet and will require additional fittings to adapt to your plumbing A shut off valve is recommended prior to the Pre Filter System QUOI ds p 9 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 12 Chemical I
22. nganese Rev R Filtration System Page 22 responsible for the repair or replacement of defective media only labor to replace the media is the responsibility of the purchaser 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 23 m A A et Warranty Registration Form Send in this Warranty Registration Form to validate your warranty or visit www PelicanWater com to complete warranty registration form online Pelican Warranty Registration Form Date Item s were Received Order ID Dealer Purchased From Model Serial Number Send To Pelican Water Systems 3060 Performance Circle Suite 2 DeLand FL 32724 Phone 1 877 842 1635 Plumber s I nformation optional We like to recommend good plumbers throughout the USA and if you were happy with your installer please give us their information so we can pass it on as a courtesy Thank you for your time Phone Z a ee ee of the Plumbing installer 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 24 I MPORTANT Do not use
23. njector Pump and Solution Tank Installation Chemical Injector Spigot Pump her optional Outgoing Water Chemical Injector to House Pump Tubing Incoming Water Supply Nut Pre Filter Front View Esai ook Solution Tank mene Pump Foot Valve Figure 7 Chemical Injector Pump Installation II MPORTANT Install the Chemical Injector Pump into the water supply after the Pre Filter and before any other filtration or softening system l Determine the size and material of your incoming water supply line from the Pre Filter System 2 Mount the Chemical Injector Pump to the wall using the provided brackets Line up the inflow and outflow connections with the current water line 3 Plumb the Chemical Injector Pump into your water line The arrow on the body of the Chemical Injector Pump shows the correct water flow direction The water should enter and exit the pump following the direction of the arrow Solution Tank Installation 1 Remove the black cap from the opening on the Solution Tank 2 Drill one 3 8 hole into the top of the Solution Tank 3 Insert the end of the Chemical Injector Pump Tubing with the pump foot valve connected into the hole which was covered by the black cap on the top of the Solution Tank 4 Feed and pull the other end of the tubing through the drilled opening on the top of the Solution Tank 5 Fill the Solution Tank with 9 cups household bleach and
24. ntrol Type tc DO Day Override 3 RT Regeneration Time 2 00 BW Backwash 10 RR Rapid Rinse 10 Step 2 Setting the Time 1 Press and hold down the UP button to change the clock 2 Press the EXTRA CYCLE button when the time is set The water valve displayed will stop flashing when the time is set Iron and Manganese Tank Regen I MPORTANT You will not be able to use water in the house for approximately 25 minutes during the Regen process l Press and hold the EXTRA CYCLE button for 3 seconds Note Gears will make noise and water will start to flow 2 Allow the system to EXTRA CYCLE for 25 minutes Your manual regen cycle is complete and the tank is ready for use Note The days between regen may vary based on flow and Iron content If you are unsure about the days between regen please contact your Pelican dealer for further help Testing Chlorine Levels in Water 1 Put the carbon tank in bypass 2 Turn on the nearest cold water faucet to the system 3 Listen and watch the pump to make sure it is pumping The pump should pulse and not run continuously If the water is off the pump will stop 4 Letthe water run for 10 minutes 5 After 10 minutes use the chlorine test strip at the running cold water faucet to check the chlorine level 6 The optimum chlorine level reading is 3ppm on the test strip a If the level is lower than 3ppm chlorine remove the black clip from the ratio adjustment slide
25. plit Rings and Quick Connect Nuts Push the Bypass Valve into the head of the Pelican Whole House Water Filter with the unthreaded ends orientated towards the tank and hand tighten the Quick Connect Nuts 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WF4 WF8 Premium Whole House Iron and Manganese Rev R Filtration System Page 8 Whole House I ron amp Manganese Filter f the Red Clips are in the slots female opening of Electronic Head remove them Push the male O Ring side of the Bypass Valve into the female opening of the Electronic Head Push the Red Clips back into the slots to tighten TS Notice The Bypass Valve on the Electronic Head can be set to Bypass or Service by turning the knobs on the side of the valve If the holes are up and down then the tank is in the Bypass Mode If the holes are side to side then the tank is in the Service Mode Do not remove the red clips from the Bypass Valve after connecting to main water supply Note The Whole House Water Filter flows in a different direction than the Iron Manganese Filter The Red Arrows on the Whole House FilterBypass may be pointing in a different direction then shown in Figure 2 If this is the case remove the Red Arrows by pulling them straight up Turn them around and reposition correctly onto the Bypass Valve so they are positioned as shown in Figure 2 2013 Enviro Water Solutions I
26. this warranty to the customer in lieu of all other warranties express or implied including without limitation any implied warranties of merchantability or fitness for a particular purpose or treatment of certain water and hereby expressly disclaims all other such warranties Pelican s liability hereunder shall not exceed the cost of the product Under no circumstances will Pelican be liable for any incidental or consequential damages or for any other loss damage or expense of any kind including loss of use arising in connection with the installation or use or inability to use the Covered Items or any water treatment system the Covered Items are incorporated into These warranties are governed by the laws of the state of Florida and may change at any time without notice Failure by California and Quebec residents to complete the product registration form does not diminish their warranty rights For all orders placed on or after June 3rd 2011 Manufacturer s Performance Guarantee The Pelican PC600 Premium Whole House Water Filter is guaranteed to perform for 600 000 gallons or 5 years whichever comes first The Pelican PC1000 Premium Whole House Water Filter is guaranteed to perform for 1 000 000 gallons or 5 years whichever comes first The authorized dealers shall be 2013 Enviro Water Solutions Inc www pelicanwater com 3060 Performance Circle Suite 2 DeLand FL 32724 877 842 1635 Pelican WFA WF8 Premium Whole House Iron and Ma
Download Pdf Manuals
Related Search