Home

Lenovo U510 User's Manual

1. Only certified trained personnel can service the computer Before replacing any FRU read the entire page on removing and replacing FRUs When you replace FRUs use new nylon coated screws Be extremely careful during such write operations as copying saving or formatting Drives in the computer that you are servicing sequence might have been altered If you select an incorrect drive data or programs might be overwritten Replace an FRU only with another FRU of the correct model When you replace an FRU make sure that the machine model and the FRU part number are correct by referring to the FRU parts list An FRU should not be replaced just because of a single unreproducible failure Single failures can occur for a variety of reasons that have nothing to do with a hardware defect such as cosmic radiation electrostatic discharge or software errors Consider replacing an FRU only when a problem recurs If you suspect that an FRU is defective clear the error logs and run the test again If the error does not recur do not replace the FRU Be careful not to replace a nondefective FRU 19 d Lenovo IdeaPad U510 Hardware Maintenance Manual What to do first to do first When you do return an FRU you must include the following information in the parts exchange form or parts return form that you attach to it 20 1 9e NI Un sw Name and phone number of servicer Date of service Date on which the machine failed
2. Black 2 5 kgfcm M2 0 x 3 0 mm flat head nylok coated Silver 1 8 kgfcm 6 Lift the fan assembly and heat sink assembly in the direction shown by arrow E Be careful not to damage the connector When installing Make sure that the fan connector is attached firmly to the system board 49 M Lenovo IdeaPad U510 Hardware Maintenance Manual 1100 DIMM For access remove these FRUs in order 1010 Keyboard on page 34 1020 Battery pack on page 36 1080 Low frame module on page 47 Figure 10 Removal steps of DIMM Release the two latches on both edges of the socket at the same time in the direction shown by arrows Kl and then unplug the DIMM in the direction shown by arrow BJ When installing Insert the notched end of the DIMM into the socket Push the DIMM firmly and pivot it until it snaps into the place Make sure that it is firmly fixed in the slot and difficult to be moved 50 Lenovo IdeaPad U510 1110 System board Important notices for handling the system board When handling the system board bear the following in mind Becareful not to drop the system board on a bench top that has a hard surface such as metal wood or composite Avoid rough handling of any kind In the whole process make sure not to drop or stack the system board If you put a system board down make sure to put it only
3. DDR3 1600 4GB HMT351S6CFR8C PB DDR3 1600 4GB DDR3 1600 4GB Ram RMT3160MM58E9F 1600 DDR3 1600 4GB DDR3 1600 4GB RMT3160ED58E9W 1600 DDR3 1600 4GB DDR3 1600 4GB SP322NQ08IAF DDR3 1600 4GB DDR3 1600 4GB Sha SP322NQ08IBF DDR3 1600 4GB DDR3 1600 4GB SM322NOO08IAF DDR3 1600 4GB DDR3 1600 4GB Nan NT4GC64B8HGONS DI DDR3 1600 4GB DDR3 1600 8GB M471B1G73BH0 CK0 DDR3 1600 8GB DDR3 1600 8GB HMT41GS6MFR8C PB DDR3 1600 8GB DDR3 1600 8GB MT16KTF1G64HZ 1G6D1 DDR3 1600 8GB VITU5 Lower Case Bracket SSD 24G SSD Samsung MZMPA024HMCD 24G mSATA SSD FRU no 16200306 16200004 16200086 16200195 121500082 121500083 90201893 11201035 11200340 11200343 11200346 11201037 11200392 11200394 11201041 11201036 11200341 11200347 11200344 11201038 11200393 11200395 11201040 11200397 11201042 11200342 11200345 11200507 90201892 16200256 CRU ID E ES ES z z z Z Z Z ZZ ZZ ZZZZ 2 zZ z z ES 71 d Lenovo IdeaPad U510 Hardware Maintenance Manual 72 Table 4 Parts list Overall continued No 17 17 17 17 17 18 19 20 21 21 22 23 24 25 26 FRU SSD 24G SSD Sandisk U100 SDSA5DK 24G mSATA SSD SSD 24G SSD Ramaxel RDM II XM020C 24G mSATA SSD SSD 32G SSD Samsung PM830 32G mSATA SSD SSD 32G SSD Sandisk X100 32G mSATA SSD SSD 32G SSD Micron C400v 32G mSATA SSD VITU5 Fan VITU5 HeatSink DIS VITUS5 HeatSink UMA BT BT4 0 Cbt BCM92070
4. Date of purchase Procedure index and page number in which the failing FRU was detected Failing FRU name and part number Machine type model number and serial number Customer s name and address Note for warranty During the warranty period the customer may be responsible for repair costs if the computer damage was caused by misuse accident modification unsuitable physical or operating environment or improper maintenance by the customer The following is a list of some common items that are not covered under warranty and some symptoms that might indicate that the system was subjected to stress beyond normal use Before checking problems with the computer determine whether the damage is covered under the warranty by referring to the following list The following are not covered under warranty LCD panel cracked from the application of excessive force or from being dropped Scratched cosmetic parts Distortion deformation or discoloration of the cosmetic parts Plastic parts latches pins or connectors that have been cracked or broken by excessive force Damage caused by liquid spilled into the system Damage caused by the improper insertion of a PC Card or the installation of an incompatible card Improper disk insertion or use of an optical drive Diskette drive damage caused by pressure on the diskette drive cover foreign material in the drive or the insertion of a diskette with multiple labels Damaged or bent diskette
5. Description Activate the pause function Activate the break function Enable disable the scroll lock Activate the system request function Turn on off the keyboard backlight CONS The hotkeys are located in the function key row of the keyboard By pressing the appropriate hotkey you can change system settings instantly The following describes the function of each hotkey Table 4 Hotkeys Hotkeys SG an l E El E E Ye ES Description Mutes unmutes the sound Decreases the volume level Increases the volume level Closes the currently active window Refreshes the desktop or the currently active window Enables disables the touchpad Enables disables airplane mode Displays all currently open apps Turn on off the backlight of the LCD screen Opens the interface for the display device switch to select this notebook or an external display Decreases display brightness Increases display brightness 31 M Lenovo IdeaPad U510 Hardware Maintenance Manual FRU replacement notices replacement notices 32 This section presents notices related to removing and replacing parts Read this section carefully before replacing any FRU Screw notices Loose screws can cause a reliability problem In the Lenovo computer this problem is addressed with special nylon coated screws that have the following characteristics They maintain tight connections They do not easily
6. e LINETEK LS15 H05VV F LP E04A 1m Australia 145000589 e LINETEK LS15 H03VV F LP 23A 1m Taiwan 145000588 e LINETEK LS15 VCTF LP 53 1m Japan 145000587 e LINETEK LS15 VCTF LP 54 1m Africa 145000586 e LINETEK LS15 H03VV F PE 364 1m CE 145000585 e LINETEK LP 34 H03VV F LS15 1m CCC 145000568 e Longwell LSG 31 RVV300 300 LS 18 1m Argentina 145000567 e Longwell LP 24 H03VV F LS 18 1m Danmark 145000566 e Longwell LP 40 H03VV F LS 18 1m Switzerland 145000565 e Longwell LP 37 H03VV F LS 18 1m 81 d Lenovo IdeaPad U510 Hardware Maintenance Manual 82 Table 9 Parts list 3 pin power cords continued Region Brazil Longwell LP 46 H03VV F LS 18 1m Israel e Longwell LP 41 H03VV F LS 18 1m UL Longwell LP 30B SPT 2 18AWG LS 18 1m UK Longwell LP 61L H03VV F LS 18 1m Indian Longwell LP 67 BIS LS 18 1m Italy e Longwell LP 22 H03VV F LS 18 1m Korea e Longwell LP 486 KTLHO3VV F LS 5 1m Australia e Longwell LP 23A LFC 3R LS 18 1m Taiwan Longwell LP 71 VCTF LS 33 1m Japan Longwell LP 54 VCTF LS 18 1m Africa Longwell LP 39 H03VV F LS 18 1m CE e Longwell LP 34A H03VV F LS 18 1m CCC e VOLEX GB10S3 RVV 300 500 VAC5S 1m UL e Volex US1553 SPT 2 VAC5S 1m Indian e VOLEX IA6A3 IS694 VAC5S 1m Italy e VOLEX IT1083 HO3VV F VAC5S 1m Danmark VOLEX MP233D H03VV F VAC5S 1m Korea e VOLEX M2511 KETI IEC VAC5S 1m Australia e VOLEX AU10S3 H03VV F VAC5S 1m Taiwan e VOLEX TW15CS3 VCTF VAC5
7. Bottom and Left side view H Louvers El Novo button E Ventilation slots El RJ 45 port H MINI VGA D HDMI port USB 3 0 port D Combo audio jack E Built in microphone E T A D 2 A E CO 66 Lenovo IdeaPad U510 Parts list_ 0 ll This section presents the following service parts Overall on page 68 LCD FRUs on page 73 Keyboard on page 75 Miscellaneous parts on page 79 AC adapters on page 80 Power cords on page 81 Notes Each FRU is available for all types or models unless specific types or models are specified 67 M Lenovo IdeaPad U510 Hardware Maintenance Manual Overall 68 Lenovo IdeaPad U510 Table 4 Parts list Overall No BWIN v 0100000000000 0 FRU LCD unit see LCD FRUs on page 73 Keyboard see Keyboard on page 75 VITU5 Upper Case WLAN WiFi 1x2 BGN WiMAX Intel 6150NX MOW M PCIE NB HMC LI WLAN WiFi 1x2 BGN WiMAX Intel 6150NX BSB M PCIE NB HMC LI WLAN WiFi 2x2 BGN Intel 2200N MOW M PCIE NB HMC WLAN WIDI BT Intel 2230 BGN BT M PCIE HMC WLAN WiFi 1x1 BGN Cbt BCM4313 MOW M PCIE NB HMC WLAN WiFi 1x1 BGN Liteon HB125 1x1BGN HMC wlan WLAN WiFi 1x1 BGN Liteon AR9285 HB95 BGN MOW NB IN WLAN WiFi 1x1 BGN BT4 0 Cbt BCM4313HMGB BGN BT HMC WLAN WiFi 1x1 BGN BT4 0 Liteon WB225 BGN BT HMC Processor Ivy bridge core Dual Core ULV Intel 13 3217U 1 8G L1 3M 2cBGA processor Processor Ivy bridge core D
8. Japanese 25205565 Brazilian 25205564 d Lenovo IdeaPad U510 Hardware Maintenance Manual 78 Table 6 Parts list Keyboard continued Language keyboard continued Sunrex black continued Sunrex backlight Arabic German French Russian Traditional Chinese Korean Canadian English amp French Latin Portuguese Thai Turkish Spanish Italian U K English English Indian Czechoslovakian Bulgarian International English Swiss Slovenian Icelandic Belgian Four Nordic countries Hungarian Hebrew Greek Dutch Japanese Brazilian Arabic German French Russian Traditional Chinese Korean Canadian English amp French Latin Portuguese Thai Turkish Spanish Italian U K English English P N 25205563 25205562 25205561 25205560 25205559 25205558 25205557 25205556 25205555 25205554 25205553 25205552 25205551 25205550 25205549 25205668 25205666 25205667 25205665 25205664 25205663 25205662 25205661 25205660 25205659 25205658 25205657 25205656 25205655 25205654 25205653 25205652 25205651 25205650 25205649 25205648 25205647 25205646 25205645 25205644 25205643 25205642 25205641 25205640 25205639 CRU ID za Lenovo IdeaPad U510 Miscellaneous parts Table 7 Parts list Miscellaneous parts FRU System miscellaneous parts a VITU5 HDD Bracket b VITU5 ODD Bracket e c VITU5 TP Bracket Cable miscellaneous parts d VITU5 TP
9. Sonderm ll beachten Beim Ersetzen der Bereitschafts oder Systembatterie nur Batterien des Typs verwenden der in der Ersatzteilliste aufgef hrt ist Der Einsatz falscher Batterien kann zu Entz ndung oder Explosion f hren mop Nyaa Man MIO NINAN MID INN DINO p525 yx OMITA Y SW IN UNI AMIN PIN VIA ANN TOP IDIOT AN PIVI v AMN INP IN 055 V DIAM PAIN INNI mpnn n DN WINI DPIN VIA WINN NINDI PI VANNI DIY DION NI NINDI UVP V ANNA MINOR 5v MININA IN nns DIVI Alcune batterie di riserva contengono una piccola quantita di nichel e cadmio Non smontarle ricaricarle gettarle nel fuoco o nell acqua n cortocircuitarle Smaltirle secondo la normativa in vigore DPR 915 82 successive disposizioni e disposizioni locali Quando si sostituisce la batteria dell RTC real time clock o la batteria di supporto utilizzare soltanto i tipi inseriti nell appropriato Catalogo parti L impiego di una batteria non adatta potrebbe determinare l incendio o l esplosione della batteria stessa FTWANYT ITORLIIVEOZITA LAN FR VARFENTWS DORE V ET LEBST AYTI DRA IH RETIRO SO RSE EY a KSWAT LIALTAT EEN AY TY ABRES S pilye BRROFBNTA ES TI REV BOZA Y e VARIA YT erer LTST SW Bok Ay FY REED Ny TY BH KLEY BRLIVFTELLRDYET Algunas bater as de reserva contienen una peque a cantidad de n quel y cadmio No las desmonte ni recargue ni las eche al fuego o al agua ni las cortocircuite Des chelas tal como dispone la normativa local Utilice s lo ba
10. ces sont bien en place et bien fix es Pour ce faire secouez l unit et assurez vous qu aucun bruit suspect ne se produit Des pi ces m talliques ou des copeaux de m tal pourraient causer un court circuit Bevor nach einem FRU Austausch der Computer wieder angeschlossen wird muf sichergestellt werden daf keine Schrauben Federn oder andere Kleinteile fehlen oder im Geh use vergessen wurden Der Computer muf gesch ttelt und auf Klapperger usche gepr ft werden Metallteile oder splitter k nnen Kurzschl sse erzeugen NTN W FRU NINN INNI awnyan NIYIN ab DNS DANN DP DPIN O vsgn 0n 55V N79 979 AYNA TINI MI DYWAN DYN DNPH PW V MAN 199 PUPAD AWNAN AN 20205 W nt DIN 091899 ON DDI NINN aav IN PAN Prima di accendere l elaboratore dopo che stata effettuata la sostituzione di una FRU accertarsi che tutte le viti le molle e tutte le altri parti di piccole dimensioni siano nella corretta posizione e non siano sparse all interno dell elaboratore Verificare ci scuotendo l elaboratore e prestando attenzione ad eventuali rumori eventuali parti o pezzetti metallici possono provocare cortocircuiti pericolosi FRU DZMH IVE A NRZ ANDANT AL A TOUDE HOST CIEUVMlEIZdS 0 ERIC 2 OAR CRA TOOT L ARL TLES INERAT DIA AV ea REIT WF WF LELRO E KN SUY a ORATI LOV EY Antes de encender el sistema despues de sustituir una FRU compruebe que todos los tornillos muelles y dem s piezas pequefias se encuentran en su
11. 44 1070 SSD Card on page 46 1080 Low frame module on page 47 1090 Fan assembly and Heat Sink assembly on page 49 1100 DIMM on page 50 1110 System board on page 51 1120 LCD unit on page 54 Figure 13 Base cover USB board bluetooth card power board and speakers Remove screw H and then remove the USB board in the direction shown by arrow Ed Step Screw quantity Color Torque M2 5 x 4 mm flat head nylok coated 1 Black 2 5 kgfcm y 8 When installing When attaching the USB board to the base cover adjust the placement of the USB jacks as shown and make sure that both of the USB jacks are attached to the holes on the base cover as shown Improper placement of the jacks might cause a damage Lenovo IdeaPad U510 Figure 13 Base cover USB board bluetooth card power board and speakers continued Remove the bluetooth card in the direction shown by arrow H Step Screw quantity Color Torque H M2 5 x 4 mm flat head nylok coated 1 Black 2 5 kgfcm 57 M Lenovo IdeaPad U510 Hardware Maintenance Manual Figure 13 Base cover USB board bluetooth card power board and speakers continued Remove four screws Hl and then remove the speakers in the direction shown by arrows H Step Screw quantity Color Torque H M2 5 x 2 0 mm flat head nylok coated 4 Black 2 5 kgfcm 58 Lenovo IdeaPad U510 Note Applying labels to the base co
12. DINI IN ANN P4999 09 AIPA PRI DIJON NN PIWI PR PTT MIYA 100 59 un VINI ASDC NN PIDI v D DP NAN 1n nx UNI IDNA g VANWAI v n 1213n D DP DPN Ad UY INNI o pann nma v a NIDI MANIANN IN MD 3295 DIZAY 5125 NINN La batteria di supporto e una batteria al litio e puo incendiarsi esplodere o procurare gravi ustioni Evitare di ricaricarla smontarne il connettore polarizzato smontarla riscaldarla ad una temperatura superiore ai 100 gradi centigradi incendiarla o gettarla in acqua Smaltirla secondo la normativa in vigore DPR 915 82 successive disposizioni e disposizioni locali L impiego di una batteria non adatta potrebbe determinare l incendio o l esplosione della batteria stessa FDA No TY a KR BH ELMBEOCU Carla col WET aha Ry7TI DkE COMETAS F ORVAL RYT VAIO 100 C 212 F LETOMAN HA SERO DA IKE TL LHLIBNT S Wo 77 Y ERES BATA RARO RMN TIE ABD AY DARIA YT ERA UI RE MOR AYT YE BATSL NYT U RBBKLICV BPBLIEVTSILBHSVET La bateria de repuesto es una bateria de litio y puede provocar incendios explosiones o quemaduras graves No la recargue ni quite el conector polarizado ni la desmonte ni caliente por encima de los 100 C 212 F ni la incinere ni exponga el contenido de sus celdas al agua Des chela tal como dispone la normativa local y Safety information 3 N Safety notice 5 If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands immediately wash the
13. Enter the serial number or select a product or use Lenovo smart downloading 3 Select the BIOS Driver Applications and download 4 Follow the directions on the screen and install the necessary software 16 Important service information Use the following strategy to prevent unnecessary expense for replacing and servicing FRUs If you are instructed to replace an FRU but the replacement does not solve the problem reinstall the original FRU before you continue Some computers have both a processor board and a system board If you are instructed to replace either of them and replacing one of them does not solve the problem reinstall that board and then replace the other one e If an adapter or a device consists of more than one FRU any of the FRUs may be the cause of the error Before replacing the adapter or device remove the FRUS one by one to see if the symptoms change Replace only the FRU that changed the symptoms Attention The setup configuration on the computer you are servicing may have been customized Running Automatic Configuration may alter the settings Note the current configuration settings using the View Configuration option then when service has been completed verify that those settings remain in effect Strategy for replacing a hard disk drive Always try to run a low level format before replacing a hard disk drive This will cause all customer data on the hard disk to be lost Make sure that the
14. K English English P N 25205683 25205682 25205681 25205680 25205679 25205678 25205677 25205676 25205675 25205674 25205673 25205672 25205671 25205670 25205669 25205548 25205546 25205547 25205545 25205544 25205543 25205542 25205541 25205540 25205539 25205538 25205537 25205536 25205535 25205534 25205533 25205532 25205531 25205530 25205529 25205528 25205527 25205526 25205525 25205524 25205523 25205522 25205521 25205520 25205519 CRU ID za Lenovo IdeaPad U510 Table 6 Parts list Keyboard continued Language P N CRU ID Indian 25205638 q Czechoslovakian 25205636 Bulgarian 25205637 International English 25205635 Swiss 25205634 Slovenian 25205633 Icelandic 25205632 Belgian 25205631 Four Nordic countries 25205630 Hungarian 25205629 Hebrew 25205628 Greek 25205627 Dutch 25205626 Japanese 25205625 Darfon Brazilian 25205624 backlight Arabic 25205623 German 25205622 French 25205621 Russian 25205620 Traditional Chinese 25205619 Korean 25205618 Canadian English amp French 25205617 EE m Latin 25205616 Portuguese 25205615 Thai 25205614 Turkish 25205613 Spanish 25205612 Italian 25205611 U K English 25205610 English 25205609 Indian 25205578 Czechoslovakian 25205576 Bulgarian 25205577 International English 25205575 Swiss 25205574 Slovenian 25205573 Icelandic 25205572 da Belgian 25205571 Four Nordic countries 25205570 Hungarian 25205569 Hebrew 25205568 Greek 25205567 Dutch 25205566
15. Note RoHS and non RoHS FRU part numbers with the same fit and function are identified with unique FRU part numbers Lenovo plans to transit to RoHS compliance well before the implementation date and expects its suppliers to be ready to support Lenovo s requirements and schedule in the EU Products sold in 2005 and 2006 will contain some RoHS compliant FRUs The following statement pertains to these products and any product Lenovo produces containing RoHS compliant FRUs RoHS compliant FRUs have unique FRU part numbers Before or after the RoHS implementation date failed RoHS compliant parts must always be replaced with RoHS compliant ones so only the FRUs identified as compliant in the system HMM or direct substitutions for those FRUs may be used Products marketed before June 2006 Products marketed after June 2006 Current or Replacement Current or Replacement original part FRU original part FRU Non RoHS Can be Non RoHS Non RoHS Can be RoHS Must be RoHS Must be RoHS Non RoHS Can sub to RoHS RoHS Must be RoHS Note A direct substitution is a part with a different FRU part number that is automatically shipped by the distribution center at the time of the order 18 General checkout General checkout This chapter presents the following information What to do first on page 20 Power system checkout on page 21 Before you go to the checkout make sure to read the following important notes va Important notes
16. bezel Remove the LCD front bezel in the direction shown by arrows Hu Lenovo IdeaPad U510 1150 LCD panel LCD cable and hinges For access remove these FRUs in order 1010 Keyboard on page 34 1020 Battery pack on page 36 1030 Dummy card on page 40 1040 Hard disk drive on page 41 1050 Optical drive on page 43 1060 PCI Express Mini Card for wireless LAN WAN on page 44 1070 SSD Card on page 46 1080 Low frame module on page 47 1090 Fan assembly and Heat Sink assembly on page 49 1100 DIMM on page 50 1110 System board on page 51 1120 LCD unit on page 54 1130 Base cover USB board bluetooth card power board and speakers on page 56 1140 LCD front bezel on page 60 Figure 15 LCD panel LCD cable and hinges Remove screws H Step Screw quantity Color Torque H M2 0 x 3 mm flat head nylok coated 4 Black 1 8 kgfem 61 M Lenovo IdeaPad U510 Hardware Maintenance Manual Figure 15 LCD panel LCD cable and hinges continued Disconnect the connector E lift the LCD panel in the direction shown by arrow When installing Make sure that the connector is attached firmly Remove screws J and the hinges Step Screw quantity Color Torque E M2 0 x 3 0 mm flat head nylok coated Black 1 8 kgfcm 2 62 Lenovo IdeaPad U510 1160 Integrated camera For access remove these FRUs in order 1010 Keyboard on page 34 1020 Battery pack on pa
17. customer has a current backup of the data before performing this action Attention The drive startup sequence in the computer you are servicing may have been changed Be extremely careful during write operations such as copying saving or formatting If you select an incorrect drive data or programs can be overwritten Important notice for replacing a system board Some components mounted on a system board are very sensitive Improper handling can cause damage to those components and may cause a system malfunction Attention When handling a system board Do not drop the system board or apply any excessive force to it Avoid rough handling of any kind Avoid bending the system board and hard pushing to prevent cracking at each BGA Ball Grid Array chipset 17 d Lenovo IdeaPad U510 Hardware Maintenance Manual Important information about replacing RoHS compliant FRUs RoHS The Restriction of Hazardous Substances in Electrical and Electronic Equipment Directive 2002 95 EC is a European Union legal requirement affecting the global electronics industry RoHS requirements must be implemented on Lenovo products placed on the market after June 2006 Products on the market before June 2006 are not required to have RoHS compliant parts If the original FRU parts are non compliant replacement parts can also be non compliant In all cases if the original FRU parts are RoHS compliant the replacement part must also be RoHS compliant
18. disassemble it heat it above 100 C 212 F incinerate it or expose its cell contents to water Dispose of the battery as required by local ordinances or regulations Use only the battery in the appropriate parts listing Use of an incorrect battery can result in ignition or explosion of the battery La pile de sauvegarde contient du lithium Elle pr sente des risques d incendie d explosion ou de br lures graves Ne la rechargez pas ne retirez pas son connecteur polaris et ne la d montez pas Ne l exposez pas une temperature sup rieure 100 C ne la faites pas br ler et n en exposez pas le contenu l eau Mettez la pile au rebut conform ment la r glementation en vigueur Une pile inappropri e risque de prendre feu ou d exploser Die Systembatterie ist eine Lithiumbatterie Sie kann sich entz nden explodieren oder schwere Verbrennungen hervorrufen Batterien dieses Typs d rfen nicht aufgeladen zerlegt ber 100 C erhitzt oder verbrannt werden Auch darf ihr Inhalt nicht mit Wasser in Verbindung gebracht oder der zur richtigen Polung angebrachte Verbindungsstecker entfernt werden Bei der Entsorgung die rtlichen Bestimmungen f r Sonderm ll beachten Beim Ersetzen der Batterie nur Batterien des Typs verwenden der in der Ersatzteilliste aufgef hrt ist Der Einsatz falscher Batterien kann zu Entz ndung oder Explosion f hren IN mssonnb 099799 01535 n515y AVMIIN noo JANDA DN PID WAN AMIN PYOY PN nup aan n310521305 AMIN
19. end Do not wear jewelry chains metal frame eyeglasses or metal fasteners for your clothing Attention Metal objects are good electrical conductors Wear safety glasses when you are hammering drilling soldering cutting wire attaching springs using solvents or working in any other conditions that may be hazardous to your eyes After service reinstall all safety shields guards labels and ground wires Replace any safety device that is worn or defective Reinstall all covers correctly before returning the machine to the customer Fan louvers on the machine help to prevent the overheating of internal components Do not obstruct fan louvers or cover them with labels or stickers Safety information Electrical safety safety Observe the following rules when working on electrical equipments Important Use only approved tools and test equipments Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents Many customers have rubber floor mats near their machines that contain small conductive fibers to decrease electrostatic discharges Do not use such kind of mat to protect yourself from electrical shock Find the room emergency power off EPO switch disconnecting switch or electrical outlet If an electrical accident occurs you can then operate the switch or unplug the power cord quickly Do not work alone under hazardous conditions or
20. near the equipment that has hazardous voltages Disconnect all power before Performing a mechanical inspection Working near power supplies Removing or installing main units Before you start to work on the machine unplug the power cord If you cannot unplug it ask the customer to power off the wall box that supplies power to the machine and to lock the wall box in the off position If you need to work on a machine that has exposed electrical circuits observe the following precautions Ensure that another person familiar with the power off controls is near you Attention Another person must be there to switch off the power if necessary Use only one hand when working with powered on electrical equipment keep the other hand in your pocket or behind your back Attention An electrical shock can occur only when there is a complete circuit By observing the above rule you may prevent a current from passing through your body When using testers set the controls correctly and use the approved probe leads and accessories for that tester Stand on suitable rubber mats obtained locally if necessary to insulate you from grounds such as metal floor strips and machine frames Observe the special safety precautions when you work with very high voltages instructions for these precautions are in the safety sections of maintenance information Be extremely careful when you measure the high voltages Regularly ins
21. on a padded surface such as an ESD mat or conductive corrugated material M J For access remove these FRUS in order 1010 Keyboard on page 34 1020 Battery pack on page 36 1030 Dummy card on page 40 1040 Hard disk drive on page 41 1050 Optical drive on page 43 1060 PCI Express Mini Card for wireless LAN WAN on page 44 1070 SSD Card on page 46 1080 Low frame module on page 47 1090 Fan assembly and Heat Sink assembly on page 49 1100 DIMM on page 50 51 M Lenovo IdeaPad U510 Hardware Maintenance Manual Figure 11 Removal steps of system board continued Disconnect the LCD connector in the direction shown by arrow H unplug Bluetooth connector in the direction shown by arrow EJ When installing Make sure that all the connectors are attached firmly 52 Lenovo IdeaPad U510 Figure 11 Removal steps of system board continued Remove the system board in the direction shown by arrow E When installing When attaching the system board to the base cover adjust the placement of the combo audio jack USB HDMI RJ 45 ports as shown in EI I IA El and make sure that they are attached to the holes on the base cover as shown Improper placement of those jacks might cause a damage 53 M Lenovo IdeaPad U510 Hardware Maintenance Manual 1120 LCD unit For access remove these FRUs in order 1010 Keyboard on page 34 1020 Battery pack on page 36 1030 Dum
22. patent applications covering subject matter described in this document The furnishing of this document does not give you any license to these patents LENOVO GROUP LTD PROVIDES THIS PUBLICATION AS IS WITHOUT WARRANTY OF ANY KIND EITHER EXPRESS OR IMPLIED INCLUDING BUT NOT LIMITED TO THE IMPLIED WARRANTIES OF NON INFRINGEMENT MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE Some jurisdictions do not allow disclaimer of express or implied warranties in certain transactions therefore this statement may not apply to you This information could include technical inaccuracies or typographical errors Changes are periodically made to the information herein these changes will be incorporated in new editions of the publication Lenovo may make improvements and or changes in the product s and or the program s described in this publication at any time without notice The products described in this document are not intended for use in implantation or other life support applications where malfunction may result in injury or death to persons The information contained in this document does not affect or change Lenovo product specifications or warranties Nothing in this document shall operate as an express or implied license or indemnity under the intellectual property rights of Lenovo or third parties All information contained in this document was obtained in specific environments and is presented as an illustration The result obtained in ot
23. sitio y no se encuentran sueltas dentro del sistema Compru belo agitando el sistema y escuchando los posibles ruidos que provocar an Las piezas met licas pueden causar cortocircuitos el ctricos d Lenovo IdeaPad U510 Hardware Maintenance Manual Safety notice 2 N DANGER Some standby batteries contain a small amount of nickel and cadmium Do not disassemble a standby battery recharge it throw it into fire or water or short circuit it Dispose of the battery as required by local ordinances or regulations Use only the battery in the appropriate parts listing Use of an incorrect battery can result in ignition or explosion of the battery Certaines batteries de secours contiennent du nickel et du cadmium Ne les d montez pas ne les rechargez pas ne les exposez ni au feu ni l eau Ne les mettez pas en court circuit Pour les mettre au rebut conformez vous la r glementation en vigueur Lorsque vous remplacez la pile de sauvegarde ou celle de l horloge temps r el veillez n utiliser que les mod les cit s dans la liste de pi ces d tach es ad quate Une batterie ou une pile inappropri e risque de prendre feu ou d exploser Die Bereitschaftsbatterie die sich unter dem Diskettenlaufwerk befindet kann geringe Mengen Nickel und Cadmium enthalten Sie darf nicht zerlegt wiederaufgeladen kurzgeschlossen oder Feuer oder Wasser ausgesetzt werden Bei der Entsorgung die rtlichen Bestimmungen f r
24. under this condition the battery pack can charge to 100 of its capacity This protects the battery pack from being overcharged or from having a shortened life To check your battery move your cursor to the Power Meter icon in the icon tray of the Windows taskbar and wait for a moment but do not click it and the percentage of battery power remaining is displayed To get detailed information about the battery double click the Power Meter icon Note If the battery pack becomes hot it may not be able to be charged Remove it from the computer and leave it at room temperature for a while After it cools down reinstall and recharge it 22 Related service information Related service information This chapter presents the following information Restoring the factory contents by using Recovery Disc Set on page 23 Passwords on page 24 Power management on page 25 Restoring the factory contents by using Recovery Disc Set When the hard disk drive or solid state drive is replaced because of a failure no product recovery program is on the new drive In this case you must use the Recovery Disc Set for the computer Order the Recovery Disc Set and the drive at the same time so that you can recover the new drive with the pre installed software when they arrive The Recovery Disc Set consists of the following set of DVDs to restore the computer to the original factory configuration Start Recovery Disc one disc This disc is use
25. 06 25204155 16200210 16200264 16200089 16200211 16200297 16200067 16004643 16004189 16200273 16200209 16004848 16200192 16200220 16200088 16005334 16200008 16200208 16200071 16200193 16200219 CRU ID za za ES ES E za E za za ES ES za E ES Lenovo IdeaPad U510 Table 4 Parts list Overall continued No 12 12 12 12 13 13 14 15 15 15 15 15 15 15 15 15 15 15 15 15 15 15 15 15 15 15 15 15 16 17 FRU HDD 500G 7200rpm HTS725050A7E630 RV 7mm 7 2K 500G HDD HDD 500G 7200rpm WD WD5000BPKT 7200RPM 500G HDD HDD 500G 7200rpm TSB MK5061GSY 7200PRM 9 5mm 500G HDD HDD 500G 7200rpm HTS725050A7E630 7 7 2K 500G HDD Battery 45Wh polymer battery U510 SMP ATL L11M3P02 11 1V45Wh 3cellbty Battery 45Wh polymer battery U510 LG L11L6P01 11 1V45Wh 6cellbty VITUS ODD Bezel DDR3 1600 2GB SS M471B5773EB0 CK0 DDR3 1600 2GB DDR3 1600 2GB M471B5773DH0 CK0 DDR3 1600 2GB DDR3 1600 2GB HMT325S6CFR8C PB DDR3 1600 2GB DDR3 1600 2GB MT8KTF25664HZ 1G6M1 DDR3 1600 2GB DDR3 1600 2GB Ram RMT3150MM58E8F 1600 DDR3 1600 2GB DDR3 1600 2GB RMT3150ED58E8W 1600 DDR3 1600 2GB DDR3 1600 2GB SP321NH08IAF DDR3 1600 2GB DDR3 1600 2GB Nan NT2GC64B88GONS DI DDR3 1600 2GB DDR3 1600 4GB SS M471B5273EB0 CK0 DDR3 1600 4GB DDR3 1600 4GB M471B5273DH0 CK0 DDR3 1600 4GB DDR3 1600 4GB MT16KTF51264HZ 1G6M1 DDR3 1600 4GB
26. 2 BT4 0 EDR Flash U NB BT BT4 0 Ltn BCM920702 BT4 0 EDR Flash U NB VITU5 TP Board VITUS Battery On MB VITUS Speaker L R VITU5 Lower Case VITU5 Rubber Foot FRU no 16200252 16200253 16200108 16200162 16200163 90201877 90201875 90201876 20200056 20200057 90001026 90201888 90201891 90201874 90201889 CRU ID ES ES ES ES ES ES E Lenovo IdeaPad U510 LCD FRUs In Lenovo IdeaPad U510 there are following types of LCDs 15 6 in HD TFT 1 SA 73 d Lenovo IdeaPad U510 Hardware Maintenance Manual 74 15 6 in HD TFT Table 5 Parts list 15 6 in HD TFT No o do DA FRU VITUS5 LCD Bezel Panel 15 6 Glare AUO B156XTN03 2 HD G W LED1 NB LCD Panel 15 6 Glare CMI N156BGE LB1 HD G W LED1 NB LCD VITU5 LCD Hinge L VITU5 LCD Hinge R VITU5 LCD Cable W Camera Cable VITU5 Camera Board 1 0M VITU5 Camera Board 0 3M VITU5 LCD Cover VITU5 Antenna 2 FRU no 90201886 18200449 18200450 90201884 90201885 90201878 90001022 90001454 90201883 90201887 CRU ID Z Z Z Z Z Z Z Z Keyboard Table 6 Parts list Keyboard Language keyboard OKI black OKI backlight Indian Czechoslovakian Bulgarian International English Swiss Slovenian Icelandic Belgian Four Nordic countries Hungarian Hebrew Greek Dutch Japanese Brazilian Arabic German French Russian Traditional Chinese Korean Canadian English
27. 99 IN UNI INN mann zm DN WINI ASADA AION INA A55Y03 p VANUNI W DAD OPINNI NINA pata AANA DIPINN nav 3 NDA 2129 MINIMA NI NINDI VIV INON INI AINON 5v MIVINA IN ANSNI DIVI La batteria contiene piccole quantit di nichel Non smontarla gettarla nel fuoco o nell acqua n cortocircuitarla Smaltirla secondo la normativa in vigore DPR 915 82 successive disposizioni e disposizioni locali Quando si sostituisce la batteria utilizzare soltanto i tipi inseriti nell appropriato Catalogo parti L impiego di una batteria non adatta potrebbe determinare l incendio o l esplosione della batteria stessa Ry7TY_ AyFRPED ITABEENTWET NYT Y RVD VAMUIEU KETNIROPICRIFIAAITO va bh SURV ESV RYT VY NYT OBERIC biro CH HUS AREORA E ke IU C HES C CREW NYT U9 NYT RRRT SLE tee gt DA RI SITIO SEAL TSC RES Rolky I EATE ST Y BREKUEO RELIEVTSIERSVET Las bater as contienen peque as cantidades de n quel No las desmonte ni recargue ni las eche al fuego o al agua ni las cortocircuite Des chelas tal como dispone la normativa local Utilice s lo bater as que se encuentren en la lista de piezas al sustituir la bater a La utilizaci n de una bater a no apropiada puede provocar la ignici n o explosi n de la misma d Lenovo IdeaPad U510 Hardware Maintenance Manual 10 Safety notice 4 N DANGER The lithium battery can cause a fire an explosion or a severe burn Do not recharge it remove its polarized connector
28. Cable e VITU5 HDD Cable f VITU5 DC IN Cable g VITU5 MINI VGA CABLE e h VITUS BT Cable Note Italicized letters in parentheses are references to the exploded view in Overall on page 71 P N 90201896 90201894 90201890 90201879 90201881 90201882 90202049 90201880 CRU ID 79 d Lenovo IdeaPad U510 Hardware Maintenance Manual AC adapters Table 8 Parts list 3 pin AC adapters FRU 65W Delta ADP 65KH BD 20V 3 25A adapter 65W Liteon PA 1650 56LC adapter 65W Brazil PA 1650 52LB adapter 65W Delta ADP 65KH B 20V 3 25A adapter 65W Chicony CPA A065 20V3 25A adapter 330PF 80 P N 36001929 36001651 36001714 36002066 36001943 CRU ID ZZZZZ Lenovo IdeaPad U510 Power cords A Lenovo power cord for a specific country or region is usually available only in that country or region Table 9 Parts list 3 pin power cords Region P N CRU ID CCC 145000600 e LINETEK PC323 RVV300 300 LS15 1m Argentina 145000599 e LINETEK LS15 H03VV F LP39 1m Danmark 145000598 e LINETEK LS15 H03VV F LP 38 1m Switzerland 145000597 e LINETEK LS15 H03VV F LP 37 1m Brazil 145000596 e LINETEK LS15 H03VV F LP26A 1m Israel 145000595 e LINETEK LS15 H03VV F LP 41 1m UL 145000594 e LINETEK LP 30B SPT 2 LS15 1m UK 145000593 e LINETEK LP 61L HO3VV F LS15 1m Indian 145000592 e LINETEK PE 361 HO5VV F LS15 1m Italy 145000591 e LINETEK LS15 H03VV F PE 336 1m Korea 145000590
29. I port x 1 Intel Wifi 2 x 2 GN Intel WiMAX Wifi 1 x 2 BGN Option New Key Board One piece TouchPad 0 3 or 1 0 mega pixels Li Polymer 65W Win8 Win7 driver mini support Lenovo IdeaPad U510 Status indicators indicators The system status indicators below show the computer status 29 M Lenovo IdeaPad U510 Hardware Maintenance Manual 30 Table 2 Status indicators Symbol H Battery status indicator Power indicator O Indicator status On solid white Solid amber Fast blinking amber Slow blinking amber Slow blinking white Off On solid white Blinking Off Meaning The battery has more than 20 charge The battery has between 5 and 20 charge The battery has less than 5 charge The battery is being charged When battery charge reaches 20 the blinking color changes to white The battery has between 20 and 80 charge and is still charging When the battery reaches 80 charge the light will stop blinking but charg ing will continue until the bat tery is fully charged The battery is detached The computer is powered on The computer is in sleep mode The computer is powered off Lenovo IdeaPad U510 Fn key combinations key combinations The following table shows the function of each combination of Fn with a function key Table 3 Fn key combinations Key combination Fn Home Fn End Fn PgUp Fn PgDn Fn Space on select models
30. NTUYECKUX VHCTPYMEHTOB a TAKKE u3berante npamoro Bo3AelicrBus nasepHoro nysa Ked je laserov jednotka otvoren Vyhnite sa priamemu poh adu a nehladte priamo s optick mi n strojmi do l ta a vyhnite sa priamemu vystaveniu l ov HJELP HERB SIET RARO AIR TE JEU UZz vv Sun Radiaci n l ser al abrir No mire fijamente ni examine con instrumental ptico el haz de luz Evite la exposici n directa al haz 15 M Lenovo IdeaPad U510 Hardware Maintenance Manual Important service information This chapter presents the following important service information Strategy for replacing FRUs on page 16 Strategy for replacing a hard disk drive on page 17 Important notice for replacing a system board on page 17 Important information about replacing RoHS compliant FRUs on page 18 Important BIOS and device driver fixes are customer installable The BIOS and device drivers are posted on the customer support site http consumersupport lenovo com Strategy for replacing FRUS for replacing FRUs Before replacing parts Make sure that all software fixes drivers and BIOS downloads are installed before replacing any FRUs listed in this manual After a system board is replaced ensure that the latest BIOS is loaded to the system board before completing the service action To download software fixes drivers and BIOS follow the steps below 1 Goto http consumersupport lenovo com 2
31. OM drive the DVD ROM drive or any other optical storage device could result in exposure to hazardous laser radiation There are no serviceable parts inside those drives Do not open 14 Safety information A CD ROM drive a DVD ROM drive or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode Note the following a N DANGER Emits visible and invisible laser radiation when open Do not stare into the beam do not view directly with optical instruments and avoid direct exposure to the beam Radiac o por raio laser ao abrir Nao olhe fixo no feixe de luz nao olhe diretamente por meio de instrumentos ticos e evite exposic o direta com o feixe de luz FAANSABAZAN SHEET NBA USE ERRE BEE BOWER ZF Rayonnement laser si carter ouvert vitez de fixer le faisceau de le regarder directement avec des instruments optiques ou de vous exposer au rayon Laserstrahlung bei ge ffnetem Ger t Nicht direkt oder ber optische Instrumente in den Laserstrahl sehen und den Strahlungsbereich meiden Kinyit skor l zersug r Ne n zzen bele se szabad szemmel se optikai eszk z kkel Ker lje a sug rnyal bbal val rintkez st Aprendo l unit vengono emesse radiazioni laser Non fissare il fascio non guardarlo direttamente con strumenti ottici e evitare l esposizione diretta al fascio OrkpbiBas Geperwrecb nasepHoro usnyyeHna He cmoTpuTe Ha nyy He pasrnaabiBante ero C NOMOLLIbIO O
32. S Sila LCD se rompe y el fluido de su interior entra en contacto con sus ojos o sus manos lave inmediatamente las reas afectadas con agua durante 15 minutos como m nimo Obtenga atenci n medica si se presenta alg n s ntoma del fluido despues de lavarse 11 d Lenovo IdeaPad U510 Hardware Maintenance Manual 12 Safety notice 6 A DANGER To avoid shock do not remove the plastic cover that protects the lower part of the inverter card Afin d viter tout risque de choc lectrique ne retirez pas le cache en plastique prot geant la partie inf rieure de la carte d alimentation Aus Sicherheitsgr nden die Kunststoffabdeckung die den unteren Teil der Spannungswandlerplatine umgibt nicht entfernen prooLban NUI AN PONI N monunnn YI 913 pann 990997 90 ANNA IPIN by yan Per evitare scosse elettriche non rimuovere la copertura in plastica che avvolge la parte inferiore della scheda invertitore MBE cito AVI AL FOTWERSUCOSZZATyZ STES ROT EEN Para evitar descargas no quite la cubierta de pl stico que rodea la parte baja de la tarjeta invertida Safety notice 7 A DANGER Though the main batteries have low voltage a shorted or grounded battery can produce enough current to burn personnel or combustible materials Bien que le voltage des batteries principales soit peu lev le court circuit ou la mise la masse d une batterie peut produire suffisamment de courant pour br le
33. S 1m Japan e VOLEX VAC5S VCTF M755 1m Argentina VOLEX VA2073 H03VV F VAC5S 1m P N 145000564 145000563 145000562 145000561 145000560 145000559 145000558 145000557 145000556 145000555 145000554 145000553 145000538 145000537 145000536 145000535 145000534 145000533 145000532 145000531 145000530 145000528 CRU ID Lenovo IdeaPad U510 Table 9 Parts list 3 pin power cords continued Region P N CRU ID Brazil 145000527 e VOLEX CH10S3 H03VV F VAC5S 1m i Israel 145000526 e VOLEX SI16S3 H03VV F VAC5S 1m CE 145000525 e VOLEX M2511 HO3VV F VAC5S 1m Switzerland 145000524 e VOLEX MP232 H03VV F VAC5S 1m UK 145000605 VOLEX MP5004 H03VV F VAC5S 1m 83 M Lenovo IdeaPad U510 Hardware Maintenance Manual Lenovo may not offer the products services or features discussed in this document in all countries Consult your local Lenovo representative for information on the products and services currently available in your area Any reference to a Lenovo product program or service is not intended to state or imply that only that Lenovo product program or service may be used Any functionally equivalent product program or service that does not infringe any Lenovo intellectual property right may be used instead However it is the user s responsibility to evaluate and verify the operation of any other product program or service Lenovo may have patents or pending
34. SD sensitive devices Select a grounding system such as those listed below to provide protection that meets the specific service requirement Notes The use of a grounding system to guard against ESD damage is desirable but not necessary Attach the ESD ground clip to any frame ground ground braid or green wire ground When working on a double insulated or battery operated system use an ESD common ground or reference point You can use coax or connector outside shells on these systems Use the round ground prong of the ac plug on ac operated computers Grounding requirements requirements Electrical grounding of the computer is required for operator safety and correct system function Proper grounding of the electrical outlet can be verified by a certified electrician Safety information Safety notices multilingual translations The safety notices in this section are provided in English French German Hebrew Italian Japanese and Spanish A Safety notice 1 Before the computer is powered on after FRU replacement make sure all screws springs and other small parts are in place and are not left loose inside the computer Verify this by shaking the computer and listening for rattling sounds Metallic parts or metal flakes can cause electrical shorts Avant de remettre l ordinateur sous tension apr s remplacement d une unit P P en client le v rifiez que tous les ressorts vis et autres pi
35. U510 1040 Hard disk drive For access remove this FRU 1010 Keyboard on page 34 1020 Battery pack on page 36 va Attention Do not drop the hard disk drive or apply any physical shock to it The hard disk drive is sensitive to physical shock Improper handling can cause damages and permanent loss of data Before removing the drive suggest the customer to backup all the information on it if possible e Never remove the drive while the system is operating or is in suspend mode V M Figure 4 Removal steps of hard disk drive Remove the frame fixing screws Jj Pull the tab in the direction shown by arrow Step Screw quantity Color Torque H M2 5 x 6 mm flat head nylok coated 4 Silver 2 5 kgfcm 41 M Lenovo IdeaPad U510 Hardware Maintenance Manual Figure 4 Removal steps of hard disk drive continued Hold the SATA receptacle connector with one hand and pull the hard disk drive secured in the metal frame in the direction shown below to detach the connector Step Screw quantity Color Torque E M3 0 x 3 0 mm flat head nylok coated Black 4 0 kgfcm 4 When installing Make sure that the HDD connector is attached firmly 42 Lenovo IdeaPad U510 1050 Optical drive For access remove these FRUs in order 1010 Keyboard on page 34 1020 Battery pack on page 36 1030 Dummy card on page 40 Figure 5 Removal steps of optical drive Pull the optical drive out in the di
36. VITU5 LED Board W Cable ODD 9 5mm Tray in Rambo HLDS GU70N Slim Tray DVD Rambo ODD ODD 9 5mm HLDS GU60N Slim Tray DVD Rambo ODD ODD 9 5mm PSN UJ8B2 Slim Tray DVD Rambo ODD ODD 9 5mm Optiarc AD 7940H Slim Tray DVD Rambo ODD ODD 9 5mm PLDS DU 8A5SH Slim Tray DVD Rambo ODD ODD 9 5mm PLDS DU 8A4SH Slim Tray DVD Rambo ODD HDD 500G 5400rpm ST500LM012 5 4K 9 5 500G HDD HDD 500G 5400rpm WD5000LPVT 08G33T1 7mm 5 4K rpm 500G HDD HDD 500G 5400rpm WD WD5000BPVT 24A1YTO 5400PRM 9 5mm 500 HDD HDD 500G 5400rpm ST500LT012 5 4K 7mm 500G HDD HDD 500G 5400rpm HTS545050A7E380 RV 7mm 5 4K 500G HDD HDD 500G 5400rpm HGST HTS545050A7E380 5400PRM7mm 500G HDD HDD 500G 5400rpm Toshiba MK5065GSX 5400RPM 500G HDD HDD 500G 5400rpm Seagate ST9500325AS 500G 9NB HDD HDD 500G 5400rpm MQ01ABF050 7mm 5 4K rpm 500G HDD HDD 750G 5400rpm ST750LM022 5 4K 9 5 750G HDD HDD 750G 5400rpm WD7500BPVT 24HXZT1 WD7500BPVT 24HXZ HDD 750G 5400rpm HTS541075A9E680 9 5 5 4K 750G HDD HDD 750G 5400rpmTSB MQ01ABD075 9 5mm 5 4K 750G HDD HDD 750G 5400rpm WD WD7500BPVT 24A1YTO 5400PRM 9 5mm 750 HDD HDD 750G 5400rpm Toshiba MK7575GSX 5400RPM 750G HDD HDD 750G 5400rpm HT HTS547575A9E384 5400RPM 750G HDD HDD 1TB 5400rpm ST1000LM024 5 4K 9 5 1T HDD HDD 1TB 5400rpm WD WD10JPVT 24A1YTO 5400PRM 9 5mm 1T HDD HDD 1TB 5400rpm HTS541010A9E680 9 5 5 4K 1T HDD HDD 1TB 5400rpm TSB MQ01ABD100 9 5mm 5 4K 1T HDD FRU no 90001025 25205807 25204158 25204157 25204156 252058
37. affected areas with water at least for 15 minutes Seek medical care if any symptoms caused by the fluid are present after washing Si le panneau d affichage cristaux liquides se brise et que vous recevez dans les yeux ou sur les mains une partie du fluide rincez les abondamment pendant au moins quinze minutes Consultez un m decin si des sympt mes persistent apr s le lavage Die Leuchtstoffr hre im LCD Bildschirm enth lt Quecksilber Bei der Entsorgung die rtlichen Bestimmungen f r Sonderm ll beachten Der LCD Bildschirm besteht aus Glas und kann zerbrechen wenn er unsachgema amp behandelt wird oder der Computer auf den Boden f llt Wenn der Bildschirm besch digt ist und die darin befindliche Fl ssigkeit in Kontakt mit Haut und Augen ger t sollten die betroffenen Stellen mindestens 15 Minuten mit Wasser abgesp lt und bei Beschwerden anschlie end ein Arzt aufgesucht werden 3992 N2 TON Tinn Drum nav LCD nmn Wan TOM ON TUAL DINI PN DIVINA DMN NN OW DPT IN D y DY DINA DPMON ON MNI mi 2395 M9 mno mp 15 DOWN INNI DIVINI Drun OY MINNA Nel caso che caso l LCD si dovesse rompere ed il liquido in esso contenuto entrasse in contatto con gli occhi o le mani lavare immediatamente le parti interessate con acqua corrente per almeno 15 minuti poi consultare un medico se i sintomi dovessero permanere LCD MAL LCD OH OWA BI AAI 0 FRicf nmi o vLex W TBE E615 EUG UCI BEE LIC TRIK Iz d o Cfi o DIOR AAA EOTAREZ EI CA TES V
38. amp French Latin Portuguese Thai Turkish Spanish Italian U K English English Indian Czechoslovakian Bulgarian International English Swiss Slovenian Icelandic Belgian Four Nordic countries Hungarian Hebrew Greek Dutch Japanese Brazilian Lenovo IdeaPad U510 P N 25205608 25205606 25205607 25205605 25205604 25205603 25205602 25205601 25205600 25205599 25205598 25205597 25205596 25205595 25205594 25205593 25205592 25205591 25205590 25205589 25205588 25205587 25205586 25205585 25205584 25205583 25205582 25205581 25205580 25205579 25205698 25205696 25205697 25205695 25205694 25205693 25205692 25205691 25205690 25205689 25205688 25205687 25205686 25205685 25205684 CRU ID za 75 d Lenovo IdeaPad U510 Hardware Maintenance Manual 76 Table 6 Parts list Keyboard continued Language keyboard continued OKI backlight continued Darfon black Arabic German French Russian Traditional Chinese Korean Canadian English amp French Latin Portuguese Thai Turkish Spanish Italian U K English English Indian Czechoslovakian Bulgarian International English Swiss Slovenian Icelandic Belgian Four Nordic countries Hungarian Hebrew Greek Dutch Japanese Brazilian Arabic German French Russian Traditional Chinese Korean Canadian English amp French Latin Portuguese Thai Turkish Spanish Italian U
39. are trademarks of Intel Corporation or its subsidiaries in the United States other countries or both Intel Intel Core 2 Duo The following is a trademark of Advanced Micro Devices Inc AMD Other company product or service names may be the trademarks or service marks of others 85
40. by state When the computer enters sleep standby state the following events occur in addition to what occurs in screen blank state The LCD is powered off The hard disk drive is powered off The CPU stops Putting your computer into sleep state If you will be away from your computer for only a short time put the computer to sleep When the computer is in sleep mode you can quickly wake it to resume use bypassing the startup process To put the computer to sleep do one of the following Close the display panel Press the power button Open the charms and then select Settings E gt Power gt Sleep To wake the computer do one of the following Press the power button Press any key on the keyboard Also in the following event the computer automatically returns from sleep standby state and resumes the operation The time set on the resume timer elapses Note Wait until the power indicator light starts blinking indicating that the computer is in sleep mode before you move your computer Moving your computer while the hard disk is spinning can damage the hard disk causing loss of data 25 SM Lenovo IdeaPad U510 Hardware Maintenance Manual Shutting down the computer If you are not going to use your computer for a long time shut it down To shut down your computer 1 Open the charms select Settings E Start 26 Lenovo IdeaPad U510 Lenovo IdeaPad U510 This chapter presents
41. cing a system boat cane tutt erem ate iatale 17 Important information about replacing RoHS compliant FRUS en 18 General checkout What to do first Power system checkout Checking the AC adapter Checking operational charging Checking the battery pack Related service information 23 Restoring the factory contents by using Recovery Disc Set Start Recovery Disc one disc Operating System Recovery Disc one o or more discs e ON 23 Applications and Drivers Recovery Disc one or more discs Supplemental Recovery Disc PasswordS Power on password Hard disk password Supervisor password Power management Screen blank state Sleep standby state Shutting down the computer Lenovo IdeaPad U510 Specifications i27 Status indicators Fn key combinations Hotkeys FRU replacement notices Screw notices Removing and replacing an FRU 1010 Keyboard 1020 Battery pack 1030 Dummy card 1040 Hard disk drive 1050 Optical drive 1060 PCI Express Mini Card for wireless LAN WAN 1070 SSD Card 1080 Low frame module 1090 Fan assembly and Heat Sink 1100 DIMM 1110 System board 1120 LCD unit 1130 Base cover USB board bluetooth card power board and speakers 56 1140 LCD front bezel 60 1150 LCD panel LCD cable and
42. come loose even with shock or vibration They are harder to tighten Each one should be used only once Do the following when you service this machine Keep the screw kit in your tool bag Always use new screws Usea torque screwdriver if you have one Tighten screws as follows Plastic to plastic Turn an additional 90 after the screw head touches the surface of the plastic part more than 90 Z Cross section Logic card to plastic Turn an additional 180 after the screw head touches the surface of the logic card more than 180 4 A E ZZ 2 Cross section e Torque driver If you have a torque screwdriver refer to the Torque column for each step Make sure that you use the correct screws If you have a torque screwdriver tighten all screws firmly to the torque shown in the table Never use a screw that you removed Use a new one Make sure that all screws are tightened firmly Ensure torque screwdrivers are calibrated correctly following country specifications Lenovo IdeaPad U510 Removing and replacing an FRU This section presents exploded figures with the instructions to indicate how to remove and replace the FRU Make sure to observe the following general rules 1 Do not attempt to service any computer unless you have been trained and certified An untrained person runs the risk of damaging parts 2 Before replacing any FRU review FRU re
43. d to format the hard disk drive and initiate the recovery process Operating System Recovery Disc one or more discs This disc restores the Microsoft Windows operating system Applications and Drivers Recovery Disc one or more discs This disc restores the pre installed applications and drivers on the computer Supplemental Recovery Disc This disc contains additional content such as software for specific models and updates to the software that was preloaded on the computer Not all recovery disc sets come with a Supplemental Recovery Disc To restore the computer to the original factory configuration using the recovery disc set do the following 1 Insert the bootable Start Recovery Disc into the optical drive 2 Startthe computer When the Lenovo logo comes up immediately press F12 on the boot sequence menu select the optical drive as the first boot up device The computer will boot from the Start Recovery Disc Follow the on screen instructions to begin the recovery process 3 Read the license If you agree with the terms select I accept these terms and conditions and then click Next 4 Insertthe Operating System Recovery Disc when prompted and click Yes to begin the operating system recovery process 5 Insert the Applications and Drivers Recovery Disc when prompted and then click OK to begin the applications and drivers recovery process 6 If you have a Supplemental Recovery Disc insert it when prompted and click Yes If
44. e the following A ZAN CAUTION Use of controls or adjustments or performance of procedures other than those specified herein might result in hazardous radiation exposure O uso de controles ajustes ou desempenho de procedimentos diferentes daqueles aqui especificados pode resultar em perigosa exposi o radia o NARRAN WE Ch HERA GR Pour viter tout risque d exposition au rayon laser respectez les consignes de r glage et d utilisation des commandes ainsi que les proc dures d crites Werden Steuer und Einstellelemente anders als hier festgesetzt verwendet kann gef hrliche Laserstrahlung auftreten Az itt el rt elj r sokt l be ll t sokt l s vez rl sekt l elt rni a l zersug rz s vesz lye miatt kock zatos L utilizzo di controlli regolazioni o l esecuzione di procedure diverse da quelle specificate possono provocare l esposizione a Ucnonb30BaHue aneMeHTOB Hacrpoliku n BbINONHeHue Npoueayp HS HEM yKa3aHO 3DECb MOXET MPUBECTU K ONACHOMY pannaunoHHOMy O NyyeHnto Pouzitie kontr l prav alebo inych vykonani od inych vyrobcov ako je v tomto Specifikovan mohlo by mat za n sledok nebezpe enstvo vystavenia sa vyZiarovaniu AGE CHAE SNE NAUISD ERIC LS ER E EI FIRE TO TAR UF 360 BUR OPE DO XE El uso de controles o ajustes o la ejecuci n de procedimientos distintos de los aqu especificados puede provocar la exposici n a radiaciones peligrosas Opening the CD R
45. eject button Fuses blown by attachment of a nonsupported device Forgotten computer password making the computer unusable Sticky keys caused by spilling a liquid onto the keyboard Use of an incorrect AC adapter on laptop products The following symptoms might indicate damage caused by nonwarranted activities Missing parts might be a symptom of unauthorized service or modification If the spindle of a hard disk drive becomes noisy it may have been subjected to excessive force or dropped General checkout Power system checkout system checkout To verify a symptom follow the steps below Turn off the computer Remove the battery pack Connect the AC adapter Make sure that power is supplied when you turn on the computer Turn off the computer Disconnect the AC adapter and install the charged battery pack Make sure that the battery pack supplies power when you turn on the computer SE E If you suspect a power problem see the appropriate one of the following power supply checkouts Checking the AC adapter on page 21 Checking operational charging on page 21 Checking the battery pack on page 22 Checking the AC adapter You are here because the computer fails only when the AC adapter is used If the power on indicator does not turn on check the power cord of the AC adapter for correct continuity and installation If the computer does not charge during operation go to Checking operational charg
46. ge 36 1030 Dummy card on page 40 1040 Hard disk drive on page 41 1050 Optical drive on page 43 1060 PCI Express Mini Card for wireless LAN WAN on page 44 1070 SSD Card on page 46 1080 Low frame module on page 47 1090 Fan assembly and Heat Sink assembly on page 49 1100 DIMM on page 50 1110 System board on page 51 1120 LCD unit on page 54 1130 Base cover USB board bluetooth card power board and speakers on page 56 1140 LCD front bezel on page 60 1150 LCD panel LCD cable and hinges on page 61 Figure 16 Removal steps of integrated camera Note The integrated camera is stuck on the top center of the LCD cover Detach the connector in the direction H Remove the integrated camera from the LCD cover in the direction El When installing Stick the integrated camera to the top center of the LCD cover and ajust the placement of it to make sure the connector is attached firmly 63 M Lenovo IdeaPad U510 Hardware Maintenance Manual Front view H Integrated camera EA Computer display E Wireless LAN antennas El Power button H Caps lock indicator D Touchpad Speakers D Number lock indicator E Touchpad buttons H Battery status indicator ll Power indicator Lenovo IdeaPad U510 Right side view El USB 2 0 port B1 Memory card slot EJ Optical drive on select models D AC power adapter jack 65 M Lenovo IdeaPad U510 Hardware Maintenance Manual
47. her operating environments may vary Lenovo may use or distribute any of the information you supply in any way it believes appropriate without incurring any obligation to you Any references in this publication to non Lenovo Web sites are provided for convenience only and do not in any manner serve as an endorsement of those Web sites The materials at those Web sites are not part of the materials for this Lenovo product and use of those Web sites is at your own risk 84 Notices Any performance data contained herein was determined in a controlled environment Therefore the result obtained in other operating environments may vary significantly Some measurements may have been made on development level systems and there is no guarantee that these measurements will be the same on generally available systems Furthermore some measurements may have been estimated through extrapolation Actual results may vary Users of this document should verify the applicable data for their specific environment Trademarks The following terms are either registered trademarks or trademarks of Lenovo in the United States and or other countries Lenovo Lenovo logo IdeaPad VeriFace OneKey Rescue OneKey Recovery OneKey Antivirus APS Power Express Energy Management and ReadyComm The following terms are trademarks of Microsoft Corporation in the United States other countries or both Windows Windows 7 The following
48. hinges 61 1160 Integrated camera Locations Front view Right side view Bottom and Left side view Parts list Keyboard AC adapters Power cords Notices Trademarks iti This manual contains service and reference information for the following Lenovo product Lenovo IdeaPad U510 Use this manual to troubleshoot problems The manual is divided into the following sections The common sections provide general information guidelines and safety information required for servicing computers The product specific section includes service reference and product specific parts information Important This manual is intended only for trained servicers who are familiar with Lenovo products Use this manual to troubleshoot problems effectively Before servicing a Lenovo product make sure to read all the information under Safety information on page 1 and Important service information on page 16 Safety information This chapter presents the following safety information that you need to get familiar with before you service a Lenovo computer General safety on page 2 Electrical safety on page 3 Safety inspection guide on page 5 Handling devices that are sensitive to electrostatic discharge on page 6 Grounding requirements on page 6 Safety notices multilingual translations on page 7 Laser compliance statement on page 14 d Le
49. ing To check the AC adapter follow the steps below 1 Unplug the AC adapter cable from the computer 2 Measure the output voltage at the plug of the AC adapter cable See the following figure Pin Voltage V DC 1 20 2 0 Note Output voltage for the AC adapter pin No 2 may differ from the one you are servicing 3 If the voltage is not correct replace the AC adapter 4 If the voltage is acceptable do the following Replace the system board If the problem persists go to Lenovo IdeaPad U510 on page 27 Note Noise from the AC adapter does not always indicate a defect Checking operational charging To check whether the battery charges properly during operation use a discharged battery pack or a battery pack that has less than 50 of the total power remaining when installed in the computer 21 d Lenovo IdeaPad U510 Hardware Maintenance Manual Perform operational charging If the battery status indicator or icon does not light on remove the battery pack and let it return to room temperature Reinstall the battery pack If the charge indicator or icon is still off replace the battery pack If the charge indicator still does not light on replace the system board Then reinstall the battery pack If it is still not charged go to the next section Checking the battery pack Battery charging does not start until the Power Meter shows that less than 95 of the total power remains
50. lenovo Lenovo IdeaPad U510 Hardware Maintenance Manual Note Before using this information and the product it supports be sure to read the general information under Notices on page 84 First Edition September 2012 O Copyright Lenovo 2012 All rights reserved LENOVO products data computer software and services have been developed exclusively at private expense and are sold to governmental entities as commercial items as defined by 48 C F R 2 101 with limited and restricted rights to use reproduction and disclosure LIMITED AND RESTRICTED RIGHTS NOTICE If products data computer software or services are delivered pursuant a General Services Administration GSA contract use reproduction or disclo sure is subject to restrictions set forth in Contract No GS 35F 05925 O 2012 Lenovo Contents About this manual sees iv Safety information 1 General safety Electrical safety Safety inspection guide 5 Handling devices that are sensitive to electrostatic discharge Grounding requirements Safety notices multilingual translations 7 Laser compliance statement 14 Important service information 16 Strategy for replacing FRUS 16 Strategy for replacing a hard disk CIEL Vene dicano a 17 Important notice for repla
51. my card on page 40 1040 Hard disk drive on page 41 1050 Optical drive on page 43 1060 PCI Express Mini Card for wireless LAN WAN on page 44 1070 SSD Card on page 46 1080 Low frame module on page 47 1090 Fan assembly and Heat Sink assembly on page 49 1100 DIMM on page 50 1110 System board on page 51 Figure 12 Removal steps of LCD unit Remove four screws Efl Step Screw quantity Color Torque H M2 5 x 4 mm flat head nylok coated Black 2 5 kgfem When installing 54 Route the antenna cables along the cable guides As you route the cables make sure that they are not subjected to any tension Tension could cause the cables to be damaged by the cable guides or a wire to be broken Make sure that the LCD connector is attached firmly and make sure that you do not pinch the antenna cables when you attach the LCD assembly Route the LCD cable along the cable guides Lenovo IdeaPad U510 Figure 12 Removal steps of LCD unit continued Remove the LCD unit in the direction shown by arrow EJ 55 M Lenovo IdeaPad U510 Hardware Maintenance Manual 56 1130 Base cover USB board bluetooth card power board and speakers For access remove these FRUs in order 1010 Keyboard on page 34 1020 Battery pack on page 36 1030 Dummy card on page 40 1040 Hard disk drive on page 41 1050 Optical drive on page 43 1060 PCI Express Mini Card for wireless LAN WAN on page
52. novo IdeaPad U510 Hardware Maintenance Manual General safety safety Follow these rules below to ensure general safety Observe a good housekeeping in the area where the machines are put during and after the maintenance When lifting any heavy object 1 Make sure that you can stand safely without slipping 2 Distribute the weight of the object equally between your feet 3 Use a slow lifting force Never move suddenly or twist when you attempt to lift it 4 Liftit by standing or pushing up with your leg muscles this action could avoid the strain from the muscles in your back Do not attempt to lift any object that weighs more than 16 kg 35 Ib or that you think is too heavy for you Do not perform any action that causes hazards to the customer or that makes the machine unsafe Before you start the machine make sure that other service representatives and the customer are not in a hazardous position Please remove covers and other parts in a safe place away from all personnel while you are servicing the machine Keep your toolcase away from walk areas so that other people will not trip it over Do not wear loose clothing that can be trapped in the moving parts of the machine Make sure that your sleeves are fastened or rolled up above your elbows If your hair is long fasten it Insert the ends of your necktie or scarf inside clothing or fasten it with the nonconductive clip about 8 centimeters 3 inches from the
53. pect and maintain your electrical hand tools for safe operational condition Do not use worn or broken tools and testers Never assume that power has been disconnected from a circuit First check it to make sure that it has been powered off d Lenovo IdeaPad U510 Hardware Maintenance Manual Always look carefully for possible hazards in your work area Examples of these hazards are moist floors nongrounded power extension cables power surges and missing safety grounds Do not touch live electrical circuits with the reflective surface of a plastic dental mirror The surface is conductive such touching can cause personal injury and machine damage Do not service the following parts with the power on when they are removed from their normal operating places in a machine Power supply units Pumps Blowers and fans Motor generators and similar units This practice ensures correct grounding of the units If an electrical accident occurs Use caution do not become a victim yourself Switch off the power Send the victim to get medical aid Safety information Safety inspection guide inspection guide The purpose of this inspection guide is to assist you in identifying potential unsafe conditions As each machine was designed and built required safety items were installed to protect users and service personnel from injury This guide addresses only those items You should use good judgment to identif
54. placement notices on page 32 3 Begin by removing any FRUs that have to be removed before the failing FRU Any of such FRUs are listed at the top of the page Remove them in the order in which they are listed 4 Follow the correct sequence in the steps to remove the FRU as given in the figures by the numbers in square callouts 5 When turning a screw to replace an FRU turn it in the direction as given by the arrow in the figure 6 When removing the FRU move it in the direction as given by the arrow in the figure 7 To put the new FRU in place reverse the removal procedures and follow any of the notes that pertain to replacement For information about connecting and arranging internal cables see Locations on page 64 8 When replacing an FRU use the correct screw as shown in the procedures N DANGER Before removing any FRU turn off the computer unplug all power cords from electrical outlets remove the battery pack and then disconnect any of the interconnecting cables Attention After replacing an FRU do not turn on the computer until you have made sure that all screws springs and other small parts are in place and none are loose inside the computer Verify this by shaking the computer gently and listening for rattling sounds Metallic parts or metal flakes can cause electrical short circuits Attention The system board is sensitive to and can be damaged by electrostatic discharge Before touching it e
55. r des mat riaux combustibles ou causer des br lures corporelles graves Obwohl Hauptbatterien eine niedrige Spannung haben k nnen sie doch bei Kurzschluf oder Erdung genug Strom abgeben um brennbare Materialien zu entz nden oder Verletzungen bei Personen hervorzurufen AINO MAI nia MIYA YN NPUNIN MINONY AN DINI PAVN DIT PINI NIDI NINA IN NINPA PIT BAIN nnsn5 IN DNI Sebbene le batterie di alimentazione siano a basso voltaggio una batteria in corto circuito o a massa pu fornire corrente sufficiente da bruciare materiali combustibili o provocare ustioni ai tecnici di manutenzione ju rier HOER Th Va PLE enka yA IDEM DuRDWIU UN WASH EI O TEE E EARD EN ET Aunque las bater as principales tienen un voltaje bajo una bater a cortocircuitada o con contacto a tierra puede producir la corriente suficiente como para quemar material combustible o provocar quemaduras en el personal Safety information Safety notice 8 A DANGER Before removing any FRU turn off the computer unplug all power cords from electrical outlets remove the battery pack and then disconnect any interconnecting cables Avant de retirer une unit remplacable en client le mettez le syst me hors tension d branchez tous les cordons d alimentation des socles de prise de courant retirez la batterie et d connectez tous les cordons d interface Die Stromzufuhr muf abgeschaltet alle Stromkabel aus der Steckdose gezogen der Akku entfernt
56. rd connector in the direction shown by arrows Ell E USB board connector in the direction shown by arrows EJ EA touchpad connector in the direction shown by arrows EJ E When installing Make sure that all the connectors are attached firmly Open four rubber foot pads with a screw driver in the direction shown by arrows El then remove four screws EJ s E T a m 2 WAZ Ls B Step Screw quantity Color Torque H M2 5 x 10 mm flat head nylok coated Black 2 5 kgfem 4 37 M Lenovo IdeaPad U510 Hardware Maintenance Manual Figure 2 Removal steps of battery pack continued Open the back cover along the device frame with a flat blade in the direction shown by arrows and then lift the back cover in the direction shown by arrow Unplug the battery connector in the direction shown by arrow J first then remove three screws E Step Screw quantity Color Torque M2 5 x 6 mm flat head nylokcoated Silver 2 5 kgfcm 3 38 Lenovo IdeaPad U510 Figure 2 Removal steps of battery pack continued Remove the battery in the direction shown by arrow fj When installing Separate the antenna from other cables Put them in different tracks to improve signal reception Connect the battery last 39 I Lenovo IdeaPad U510 Hardware Maintenance Manual 1030 Dummy card Figure 3 Removal steps of dummy card Remove the dummy card in the direction shown by arrows El 40 Lenovo IdeaPad
57. rdware Maintenance Manual 1070 SSD Card For access remove these FRUs in order 1020 Battery pack on page 36 Figure 7 Removal steps of SSD Card Remove the screw Efl Step Screw quantity Color Torque H M2 0 x 3 0 mm flat head nylok coated Black 1 8 kgfcm 1 46 Lenovo IdeaPad U510 1080 Low frame module For access remove these FRUs in order 1010 Keyboard on page 34 1020 Battery pack on page 36 1040 Hard disk drive on page 41 1050 Optical drive on page 43 Figure 8 Removal steps of low frame module Remove six screws D on H Step Screw quantity Color Torque M2 5 x 6 0 mm flat head nylok coated Silver 2 5 kgfcm 1 Lift the power assembly in the direction shown by arrow EJ 47 M Lenovo IdeaPad U510 Hardware Maintenance Manual Figure 8 Removal steps of low frame module continued Lift the Low frame module in the direction as shown by arrow E 48 Lenovo IdeaPad U510 1090 Fan assembly and Heat Sink assembly For access remove this FRU 1010 Keyboard on page 34 1020 Battery pack on page 36 1040 Hard disk drive on page 41 1050 Optical drive on page 43 1080 Low frame module on page 47 Figure 9 Removal steps of fan assembly and heat sink assembly Unplug the fan connector in the direction as shown by arrow Kl Remove screw EA and six screws Ef Step Screw quantity Color Torque H M2 5 x 4 mm flat head nylok coated 1
58. rection shown by arrow Ef 43 M Lenovo IdeaPad U510 Hardware Maintenance Manual 1060 PCI Express Mini Card for wireless LAN WAN For access remove this FRU 1010 Keyboard on page 34 1020 Battery pack on page 36 Figure 6 Removal steps of PCI Express Mini Card for wireless LAN WAN Disconnect the two wireless LAN cables black white H and then remove the screw EH gt m a lta In step Efl unplug the jacks by using the removal tool antenna RF connector P N 08K7159 or pick up the connectors with your fingers and gently unplug them in the direction shown by arrows Notes wireless LAN card has 2 cables in step Jj wireless LAN card in some models may have 3 cables in step E Step Screw quantity Color Torque M2 5 x 4 mm flat head nylok coated Black 2 5 kgfcm 1 Lenovo IdeaPad U510 Figure 6 Removal steps of PCI Express Mini Card for wireless LAN WAN continued Remove the card in the direction shown by arrow Efl When installing In models with a wireless LAN card that has two antenna connectors plug the black cable 1st MAIN into the jack labeled 1 and the white cable 2nd AUX into jack labeled 2 on the card In models with a wireless LAN card that has three antenna connectors plug the black cable 1st MAIN into the jack labeled 1 the grey cable 3rd into jack labeled 3 and the white cable 2nd AUX into jack labeled 2 on the card 45 M Lenovo IdeaPad U510 Ha
59. stablish personal grounding by touching a ground point with one hand or using an electrostatic discharge ESD strap P N 6405959 to remove potential shock reasons Note The illustrations used in this section are of the Lenovo U410 unless otherwise stated 33 M Lenovo IdeaPad U510 Hardware Maintenance Manual 1010 Keyboard Figure 1 Removal steps of keyboard Loosen the keyboard with a flat blade in the direction shown by arrow FJ Lift the keyboard a little in the direction shown by arrow EJ 34 Lenovo IdeaPad U510 Figure 1 Removal steps of keyboard continued Lift the keyboard a little E and then detach the connectors in the direction shown by arrows Ell EJ and D When installing Make sure that the FPC connectors are attached firmly 35 M Lenovo IdeaPad U510 Hardware Maintenance Manual 1020 Battery pack For access remove this FRU 1010 Keyboard on page 34 A DANGER Only use the battery specified in the parts list for your computer Any other battery could ignite or explode Make sure the battery has been disconnected already before replacing any devices Figure 2 Removal steps of battery pack Remove five screws H 36 Lenovo IdeaPad U510 Figure 2 Removal steps of battery pack continued Unplug the speakers cable connector in the direction shown by arrow j disconnect power board connector in the direction shown by arrows FJ E system indicator boa
60. stem administrator who can use it to get access to the hard disk drive even if the user has changed the user HDP Attention If the user HDP has been forgotten check whether a master HDP has been set If it has it can be used for access to the hard disk drive If no master HDP is available neither Lenovo nor Lenov authorized service technicians provide any services to reset either the user or the master HDP or to recover data from the hard disk drive The hard disk drive can be replaced for a scheduled fee Supervisor password A supervisor password SVP protects the system information stored in the BIOS Setup Utility The user must enter the SVP in order to get access to the BIOS Setup Utility and change the system configuration Attention If the SVP has been forgotten and cannot be made available to the servicer there is no service procedure to reset the password The system board must be replaced for a scheduled fee Related service information Power management management Note Power management modes are not supported for APM operating system To reduce power consumption the computer has three power management modes screen blank sleep standby and hibernation Screen blank state If the time set on the Turn off monitor timer in the operating system expires the LCD backlight turns off You can also turn off the LCD backlight by pressing To end screen blank state and resume normal operation press FL Sleep stand
61. ter as que se encuentren en la lista de piezas La utilizaci n de una bater a no apropiada puede provocar la ignici n o explosi n de la misma Safety information Safety notice 3 A DANGER The battery pack contains small amounts of nickel Do not disassemble it throw it into fire or water or short circuit it Dispose of the battery pack as required by local ordinances or regulations Use only the battery in the appropriate parts listing when replacing the battery pack Use of an incorrect battery can result in ignition or explosion of the battery La batterie contient du nickel Ne la d montez pas ne l exposez ni au feu ni l eau Ne la mettez pas en court circuit Pour la mettre au rebut conformez vous la r glementation en vigueur Lorsque vous remplacez la batterie veillez n utiliser que les mod les cit s dans la liste de pi ces d tach es ad quate En effet une batterie inappropri e risque de prendre feu ou d exploser Akkus enthalten geringe Mengen von Nickel Sie d rfen nicht zerlegt wiederaufgeladen kurzgeschlossen oder Feuer oder Wasser ausgesetzt werden Bei der Entsorgung die rtlichen Bestimmungen f r Sondermiill beachten Beim Ersetzen der Batterie nur Batterien des Typs verwenden der in der Ersatzteilliste aufgef hrt ist Der Einsatz falscher Batterien kann zu Entz ndung oder Explosion f hren 5p Sw nog NM In NIINON INI pownd Addon TINA DN p5235 PN DIT PA DN DO V INN ISPI IN 09
62. the following product specific service references and product specific parts information Specifications on page 27 Status indicators on page 29 FRU tests on page 31 Fn key combinations on page 31 FRU replacement notices on page 32 Removing and replacing an FRU on page 33 Locations on page 64 Parts list on page 67 Specifications The following table lists the specifications of the Lenovo IdeaPad U510 Table 1 Specifications Feature Processor Core Chipset Bus architecture Graphic Chipset Display Standard memory CMOS RAM Hard disk drive Optical drive SSD Description See the system properties of your computer you can do this as follows Click Control Panel then click Hardware and Sound click Device Manager under Devices and Printers and double click Processors Intel Panther point HM77 FDI DMI 1333MHz 1600 MHZ DDR3 bus PCIE bus N13GS R 17W 16 9 1 366 x 768 pixels DDR3 1333 or DDR3 1600 8 GB SODIMM x 2 256 bytes 2 5 inch 9 5 mm or 2 5 inch 7 0 mm NA 24G 32G mSATA 27 d Lenovo IdeaPad U510 Hardware Maintenance Manual 28 Table 1 Specifications continued Feature I O ports Audio Video WLAN WWAN Bluetooth Keyboard Touch pad Integrated camera Battery AC adapter Pre installed operating system HDMI port x 1 USB 3 0 x 1 USB 2 0 x 2 2 in 1 slot x 1 MMC SD Combo audio jack x 1 Speaker x 2 Built in microphone HDM
63. ual Core ULV Intel 15 3317U 1 7G L1 3M 2cBGA processor Processor Ivy bridge core Dual Core ULV Intel 15 3427U 1 8G L1 3M 2cBGA processor Processor Ivy bridge core Dual Core ULV Intel I7 3517U 1 9G L1 4M 2cBGA processor Processor Sandy bridge core Dual Core 17W Intel 13 2365M 1 4G J1 3M 2cBGA CPU Processor Sandy bridge core Dual Core 17W Intel 13 2377M 1 5G J1 3M 2cBGA CPU VITU5 MB UMA 13 2377 VITU5 MB DIS 13 2377 W BL VITU5 MB DIS 15 3317 VITU5 MB DIS 13 3217 VITU5 W8P MB UMA 13 2377 VITU5 W8P MB DIS 13 2377 W BL VITU5 W8P MB DIS 15 3317 VITU5 W8P MB DIS 13 3217 VITU5 W8 MB UMA 13 2377 VITU5 W8 MB DIS 13 2377 W BL VITU5 W8 MB DIS 15 3317 VITU5 W8 MB DIS 13 3217 VITU5 SD Dummy Card VITU5 USB Board W Cable VITU5 Power Board W Cable FRU no 90201873 20002484 20002543 20200048 20200078 20002505 20200223 20002357 20002501 20200197 102500313 102500314 102500315 102500330 102500409 102500410 900010 900010 900010 900010 900010 900010 900010 900010 90001018 90001019 90001020 90001021 90201895 90001023 90001024 ND OTB WN ra CH CRU ID za za za E za ak kon IZIZIZ 69 d Lenovo IdeaPad U510 Hardware Maintenance Manual 70 Table 4 Parts list Overall continued No 10 1 11 12 12 12 12 12 12 12 12 12 12 12 12 12 12 12 12 12 12 12 12 FRU
64. und alle Verbindungskabel abgenommen sein bevor eine FRU entfernt wird AUNAN NN 335 v mud FRU p90 van NOMA WN un IWNI 929 99 NN PMII DIAN MAN 5532 PMI TN ADDON 152 NN MINI V ON Prima di rimuovere qualsiasi FRU spegnere il sistema scollegare dalle prese elettriche tutti i cavi di alimentazione rimuovere la batteria e poi scollegare i cavi di interconnessione FRU DIF ThinkPad ORE WoC 3 COS FEL VYRBOALTC HEV RIT AYI IT eKYIZAL HEBE 7 v BALTC HEV Antes de quitar una FRU apague el sistema desenchufe todos los cables de las tomas de corriente el ctrica quite la bater a y a continuaci n desconecte cualquier cable de conexi n entre dispositivos 13 M Lenovo IdeaPad U510 Hardware Maintenance Manual Laser compliance statement compliance statement Some models of Lenovo computer are equipped from the factory with an optical storage device such as a CD ROM drive or a DVD ROM drive Such devices are also sold separately as options If one of these drives is installed it is certified in the U S to conform to the requirements of the Department of Health and Human Services 21 Code of Federal Regulations DHHS 21 CFR Subchapter J for Class 1 laser products Elsewhere the drive is certified to conform to the requirements ofthe International Electrotechnical Commission IEC 825 and CENELEC EN 60 825 for Class 1 laser products If a CD ROM drive a DVD ROM drive or another laser device is installed not
65. ver The new base cover FRU is shipped with a kit containing labels of several kinds When you replace the base cover you need to apply the following label The following labels need to be peeled off from the old base cover and need to be put on the new base cover EI SIRIM BT Label m SIRIM WLAN Label INDONESIA Label for B T El BT Label for US CA TW B B T BRAZIL B T ISRAEL El WLAN Label for ISRAEL WLAN Label for INDONESIA or WLAN Label for US CA TW or WLAN Label for US TW n WLAN Label for BRAZIL or WLAN Label for ISRAEL n INDONESIA LABEL For some models you also need to apply one or two FCC labels Check the old base cover if it has one or two FCC labels find duplicates of them in the label kit and apply them to the new base cover For the location of each label refer to the following figure CNN DI D WD HU er Dose y 59 M Lenovo IdeaPad U510 Hardware Maintenance Manual 60 1140 LCD front bezel For access remove these FRUs in order 1010 Keyboard on page 34 1020 Battery pack on page 36 1030 Dummy card on page 40 1040 Hard disk drive on page 41 1050 Optical drive on page 43 1060 PCI Express Mini Card for wireless LAN WAN on page 44 1070 SSD Card on page 46 1080 Low frame module on page 47 1090 Fan assembly and Heat Sink assembly on page 49 1100 DIMM on page 50 1110 System board on page 51 1120 LCD unit on page 54 Figure 14 Removal steps of LCD front
66. vious unsafe conditions such as metal filings contamination water or other liquids or signs of fire or smoke damage 8 Check for worn frayed or pinched cables 9 Check that the power supply cover fasteners screws or rivets have not been removed or tampered with a d Lenovo IdeaPad U510 Hardware Maintenance Manual Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits ICs should be considered sensitive to electrostatic discharge ESD ESD damage can occur when there is a difference in charge between objects Protect against ESD damage by equalizing the charge so that the machine the part the work mat and the person handling the part are all at the same charge Notes 1 Use product specific ESD procedures when they exceed the requirements noted here 2 Make sure that the ESD protective devices you use have been certified ISO 9000 as fully effective When handling ESD sensitive parts Keep the parts in protective packages until they are inserted into the product Avoid contact with other people Wear a grounded wrist strap against your skin to eliminate static on your body Prevent the part from touching your clothing Most clothing is insulative and retains a charge even when you are wearing a wrist strap Use the black side of a grounded work mat to provide a static free work surface The mat is especially useful when handling E
67. y potential safety hazards due to attachment of non Lenovo features or options not covered by this inspection guide If any unsafe conditions are present you must determine how serious the apparent hazard could be and whether you can continue without first correcting the problem Consider these conditions and the safety hazards they present Electrical hazards especially primary power primary voltage on the frame can cause serious or fatal electrical shock Explosive hazards such as a damaged CRT face or a bulging capacitor Mechanical hazards such as loose or missing hardware To determine whether there are any potential unsafe conditions use the following checklist at the beginning of every service task Begin the checks with the power off and the power cord disconnected Checklist 1 Check exterior covers for damage loose broken or sharp edges 2 Turn off the computer Disconnect the power cord 3 Check the power cord for a Athird wire ground connector in good condition Use a meter to measure third wire ground continuity for 0 1 ohm or less between the external ground pin and the frame ground b The power cord should be the type specified in the parts list c Insulation must not be frayed or worn 4 Check for cracked or bulging batteries Remove the cover 6 Check for any obvious non Lenovo alterations Use good judgment as to the safety of any non Lenovo alterations 7 Checkinside the unit for any ob
68. you do not have a Supplemental Recovery Disc click No 23 d Lenovo IdeaPad U510 Hardware Maintenance Manual 7 When all of the data has been copied from the last disc in the set remove the disc and restart the computer Note The remainder of the recovery process is fully automated and no action is required by you The computer will restart into the Windows desktop several times and you might experience periods when no activity is apparent on the screen for several minutes at a time This is normal 8 When the recovery process is complete the Welcome to the Microsoft Windows screen is displayed Follow the instructions on the screen to complete the Windows setup Passwords 24 As many as three passwords may be needed for any Lenovo computer the power on password POP the hard disk password HDP and the supervisor password SVP If any of these passwords has been set a prompt for it appears on the screen whenever the computer is turned on The computer does not start until the password is entered Exception If only an SVP is installed the password prompt does not appear when the operating system is booted Power on password A power on password POP protects the system from being powered on by an unauthorized person The password must be entered before an operating system can be booted Hard disk password There are two hard disk passwords HDPs User HDP for the user Master HDP for the sy

Lenovo U510 User's Manual

Contents

Download Pdf Manuals

Related Search

Related Contents