Home

Lenovo 745068U User's Manual

1. Ked je laserov jednotka otvoren Vyhnite sa priamemu poh adu a nehladte priamo 5 optick mi n strojmi do a vyhnite sa priamemu vystaveniu l ov 5 216 9 J623UN SITET 070 J FR Eo je0LZgv lt 7 Radiaci n l ser al abrir No mire fijamente ni examine con instrumental ptico el haz de luz Evite la exposici n directa al haz Safety information 15 16 ThinkPad X200 and X200s Hardware Maintenance Manual Important service information This chapter presents following important service information FRU identification for CTO CMV and products on page 19 Important information about replacing RoHS compliant FRUs on page 21 Important BIOS and device driver fixes are customer installable The BIOS and device drivers are posted on the customer support site http www lenovo com support System Disassembly Reassembly videos that show the FRU removals or replacements for the Lenovo authorized service technicians are available in the following support site http www lenovoservicetraining com ion Advise customers to contact the Customer Support Center at 800 426 7378 if they need assistance in obtaining or installing any software fixes drivers and BIOS downloads Customers
2. Bottom 102 ThinkPad X200 and X200s Hardware Maintenance Manual Table 26 Removal steps of system board DC in connector fan and ExpressCard slot assembly for ThinkPad X200 continued Note The DC in connector and the fan assembly are attached to the underside of the system board Step Screw quantity Color Torque M2 x 3 5 mm wafer head nylon coated 1 Silver 0 181 Nm 1 85 kgfcm Turn the system board over and then disconnect the DC in connector and the fan connector from the system board When installing Make sure that the DC in connector and the fan connector are attached to the system board firmly ThinkPad X200 and X200s 103 Table 26 Removal steps of system board DC in connector fan and ExpressCard slot assembly for ThinkPad X200 continued Step Screw quantity Color Torque EH 2 x 3 5 mm flat head nylon coated 1 Silver 0 181 Nm 1 85 kgfcm When installing Before you attach the fan assembly to the computer apply thermal grease at an amount of 0 2 grams on the part marked BH as in the following figure Either too much or too less application of grease can cause a thermal problem due to imperfect contact with a component You need to peel the thin film off from the rubber Make sure that the fan connector is attached firmly 104 ThinkPad X200 and X200s Ha
3. 198 Common service tools 195 iv ThinkPad X200 and X200s Hardware Maintenance Manual About this manual This manual contains service and reference information for the following ThinkPad products ThinkPad X200 MT 7454 7455 7457 7458 7459 2023 and 2024 ThinkPad X200s MT 7462 7465 7466 7469 7470 2046 and 2047 Use this manual along with the advanced diagnostic tests to troubleshoot problems The manual is divided into sections as follows The common sections provide general information guidelines and safety information required in servicing computers The product specific section includes service reference and product specific parts information Important This manual is intended only for trained servicers who are familiar with ThinkPad products Use this manual along with the advanced diagnostic tests to troubleshoot problems effectively Before servicing a ThinkPad product be sure to read all the information under Safety information on page 1 and Important service information on page 17 Copyright Lenovo 2008 Vi ThinkPad X200 and X200s Hardware Maintenance Manual Safety information Copyright Lenovo 2008 This chapter presents following safety information that you need to be familiar with before you a ThinkPad computer General safety on page 2 on page 2 Electrical safety on page 3 safety on page 3
4. Table 24 Removal steps of base cover assembly for ThinkPad X200 ThinkPad X200 Remove the top shielding assembly at first Step Screw quantity Color Torque M2 x 3 mm wafer head nylon coated 1 0 181 Nm 1 85 kgfcm ThinkPad X200 and X200s 95 Table 24 Removal steps of base cover assembly for ThinkPad X200 continued Step Screw quantity Color Torque M2 x 3 5 mm wafer head nylon coated 1 Black 0 181 Nm 1 85 kgfcm Step Screw quantity Color Torque 2 3 5 mm wafer head nylon coated 3 Silver 0 181 Nm 1 85 kgfcm 96 ThinkPad X200 and X200s Hardware Maintenance Manual Table 24 Removal steps of base cover assembly for ThinkPad X200 continued In step El and remove the system board the DC in connector and the fan assembly together from the base cover assembly When installing Check the position of the wireless switch and firmly fit the system board into the base cover assembly ThinkPad X200 and 2008 97 Table 25 Removal steps of base cover assembly for ThinkPad X200s ThinkPad X200s Remove the top shielding assembly at first Step Screw quantity Color Torque 2 x 3 mm wafer head nylon coated 1 Black 0 181 Nm 1 85 kgfcm Step Screw quantity Color Torque M2 x 3 5 mm wafer head nylon coated 1 Black 0 181 Nm 1 85 kgfcm
5. 124 ThinkPad X200 and X200s Hardware Maintenance Manual 2070 LCD rear cover and wireless antenna cables For access remove these FRUs in order 1010 Battery pack on pag 1040 Keyboard on page 71 1100 Keyboard bezel on page 87 1130 LCD assembly on page 91 2010 LCD front bezel on page 110 2020 Inverter card on page 113 2030 Bluetooth daughter card BDC 2 1 on page 114 2040 Integrated camera on page 115 2050 LCD panel LCD brackets and LCD cable on page 116 2060 Hinges and hinge brackets on page 122 Table 37 Removal steps of LCD rear cover and wireless antenna cables for 12 1 in WXGA LCD model 12 1 in WXGA LCD model Step Screw quantity Color Torque M2 x 3 5 mm wafer head nylon coated 2 Silver 0 181 Nm 1 85 kgfcm ThinkPad 200 X200s 125 Table 37 Removal steps of LCD rear cover and wireless antenna cables for 12 1 in WXGA LCD model continued 126 ThinkPad X200 and X200s Hardware Maintenance Manual Table 37 Removal steps of LCD rear cover and wireless antenna cables for 12 1 in WXGA LCD model continued Note Wireless antennas are secured with double faced adhesive tapes When installing When you attache the antenna cables do as follows ThinkPad X200 and 2008 127 Table 37 Removal steps of LCD rear cover and wireless antenna cables for 12 1 in WXGA L
6. Table 46 Parts list 3 pin power cords Region P N RoHS ID ID Australia New Zealand 42T5050 42T5135 R models xxM Bangladesh Sri Lanka South Africa 42T5056 42T5141 models CTO xxG Canada U S 42T5004 4275089 models xxF xxL 5 xxU China P R C other than Hong Kong S A R 42T5065 4215150 models xxC Denmark 42T5041 4215126 e models xxG European countries 42T5029 42T5114 models CTO xxG India 42T5083 42 5168 models xxG Israel 42T5062 4215147 e models xxG Italy 42 5047 42 5132 models CTO xxG Korea 42 5077 42 5162 models xxK Switzerland 42T5044 4215129 e models xxG Taiwan 42T5071 42 5156 models CTO U K China Hong Kong S A R 42T5035 4215120 e models xxG xxH 186 ThinkPad X200 and X200s Hardware Maintenance Manual Recovery discs Windows XP Professional DVDs Windows XP Professional is preinstalled as the operating system in the following models 7454 CTO 2Gx 2Hx 2Tx 2Ux 2Vx 2Wx 2Xx 2Yx 2Zx 92x 93x 95x 96x 9Bx 9Cx 9Gx 7455 3Kx 3Lx 3Mx 3Nx 3Px 3Qx 3Rx 7457 CTO 4 4Lx 4 4Nx 4Px 4 45 4Tx 7458 CTO 7Rx 7Sx 7Ix 7Ux 7Vx 7Wx 7Xx 7Yx 7Zx 82x 83x 84x 85x 86x 87x 88x 89x 8Kx 8Lx 8Mx 85 7459 CTO 2023 CTO 2024 CTO 7462 CTO
7. Table 18 Removal steps of PCI Express Mini Card for wireless WAN In step unplug the jacks by using the removal tool antenna RF connector P N 08K7159 or pick the connectors with your fingers and gently unplug them in direction of the arrow Step Screw quantity Color Torque M2 x mm wafer head nylon coated 2 Black 0 181 Nm 1 85 kgfcm ThinkPad X200 and X200s 83 Table 18 Removal steps of PCI Express Mini Card for wireless WAN continued When installing Plug the red cable into the jack labeled MAIN on the card and the blue cable into the jack labeled AUX 84 ThinkPad X200 and X200s Hardware Maintenance Manual 1090 Intel Turbo Memory Minicard or wireless USB adapter For access remove these FRUs in order 1010 Battery pack on page 64 1040 Keyboard on page 71 1050 Palm rest or palm rest with fingerprint reader on page 74 Table 19 Removal steps of Intel Turbo Memory Minicard or wireless USB adapter Note Step is only for models with the wireless USB adapter For models with the Intel Turbo Memory Minicard skip step In step unplug the jacks by using the removal tool antenna RF connector P N 08K7159 or pick the connectors with your fingers and gently unplug them in direction of the arrow Step Screw quantity Color Torque BH M2 x 3 mm wafer head nylon coated 2 Black 0 181 Nm 1 85 kgfcm
8. Device address conflict 1 Load Setup Defaults in the BIOS Setup Utility 2 Backup battery 3 System board Allocation error for device 1 Load Setup Defaults in the BIOS Setup Utility Backup battery System board Failing bits nnnn DIMM System board Invalid system configuration data DIMM System board I O device IRQ conflict See pe Load Setup Defaults in the BIOS Setup Utility Backup battery 3 System board N Hibernation error 1 Restore the system configuration to what it was before the computer entered hibernation mode 2 If memory size has been changed re create the hibernation file Fan error 1 Fan 2 Thermal grease 3 System board Thermal sensing error System board Cannot boot from any device Check the status of device which you want to boot from Device not found 1 The device you want to boot from 2 System board Device Error 1 The device you want to boot from 2 System board No valid operating system 1 Check that the operating system has no failure and is installed correctly 2 Reinstall the operation system Excluded from boot order Enter the BIOS Setup Utility and add the device in boot order Related service information 43 symptoms Table 3 symptoms Symptom or error FRU or action in sequence Reseat the LCD connector LCD assembl
9. Table 40 Parts list 12 1 in WXGA TFT continued No FRU LCD rear cover assembly 7454 all 7455 all 7457 all 7458 all 7459 all 2023 CTO 2024 CTO 7462 CTO 42x 43x 44x 45x 46x 47x 48x 49x 4Ax 4Bx 4Cx 4 4Lx 4 4Nx 4 4 4Rx 4Sx 4Tx 4Ux 4Vx 4Wx 7465 CTO 23x 24x 25x 26x 27x 28x 29x 2Dx 2Lx 2Mx 2Nx 2Px 2 2Rx 2Sx 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 35x 3Lx 3Mx 3Nx 3Px 3Rx 3Sx 3Tx 7469 CTO 52x 53x 54x 55x 56x 57x 5Ex 5Fx 5Lx 5Mx 5Nx 5Px 5 5Rx 5Sx 5Tx 5Vx 5Xx 5Yx 5Zx 72x 73x 75x 76x 77x 78x 7Dx 7Ex 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7 7 7Ux 7Vx 7Xx 1 7470 CTO 62x 63x 64x 65x 6Ex 6 x E1x 2046 CTO 2047 CTO FRU no 44C9543 RoHS ID R CRU ID LCD cable assembly with Bluetooth connector with camera connector 7454 all 7455 all 7457 all 7458 all 7459 all 2023 CTO 2024 CTO 7462 CTO 42x 43x 44x 45x 46x 47x 48x 49x 4Ax 4Bx 4Cx 4Kx 4Lx 4Mx 4Nx 4Px 4 4Rx 4Sx 4Tx 7465 CTO 23x 24x 25x 26x 27x 28x 29x 2Dx 2Lx 2Mx 2Nx 2Px 2 2Rx 2Sx 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 35x 3Lx 3Mx 3Nx 3Px 3Rx 3Sx 3Tx 7469 CTO 52x 53x 54x 55x 56x 57x 5Ex 5Fx 5Lx 5Mx 5Nx 5Px 5 5Rx 5Sx 5Tx 5Vx 5Xx 5Yx 5Zx 72x 73x 75x 76x 77x 78x 7Dx 7Ex 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7Mx 7 7Ux 7Vx
10. 5Nx 5Px 5Qx 5Rx 5Sx 5Tx 5Vx 5 5Yx 5Zx 72x 73x 75x 76x 77x 78x 7Dx 7Ex 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7Mx 7Qx 7Ux 7Vx 7Xx 1 7470 CTO 62x 63x 64x 65x 6Ex 6 x E1x 2046 CTO 2047 CTO FRU no 42T0482 RoHS ID R CRU ID 180 ThinkPad X200 and X200s Hardware Maintenance Manual 12 1 in WXGA TFT ThinkPad X200 and X200s 181 Table 41 Parts list 12 1 in WXGA TFT No FRU LCD bezel assembly 7462 CTO 4Dx 4Ex 4Fx 4Gx 4 7465 CTO 2Ex 2Fx 2Hx 2 x 2Kx 7466 CTO 38x 39x 3Ax 3Bx 3Cx 3Dx 3Ex 3Fx 3Gx 3Hx 3 x 3Kx 3Qx 3Ux 7469 CTO 58x 59x 5Ax 5Bx 5Cx 5Dx 5Gx 5Hx 5 x 5 5Ux 5Wx 74x 79x 7 7 7Cx 7Nx 7Rx 75 7 7Yx 7Zx 82x 7470 CTO 5Gx 5Hx 68x 69x 6Ax 6Bx 6Cx 6Dx 6Fx 6Gx 6Hx 6Kx 2046 CTO 2047 CTO FRU no 45N3232 RoHS ID CRU ID LCD panel 12 1 in WXGA e 7462 CTO 4Dx 4Ex 4Fx 4Gx 4 7465 CTO 2Ex 2Fx 2Hx 2Jx 2Kx e 7469 CTO 58x 59x 5Ax 5 5Cx 5Dx 5Gx 5Hx 5 5Kx 5Ux 5Wx 74x 79x 7 Ax 7 7 7Nx 7Rx 7Sx 7Tx 7Yx 7Zx 82x 7470 CTO 5Gx 5Hx 68x 69x 6Ax 6Bx 6Cx 6Dx 6Fx 6Gx 6Hx 6Kx 7470 CTO 5Gx 5Hx 68x 69x 6Ax 6Bx 6Cx 6Dx 6Fx 6Gx 2046 2047 CTO 42T0480 Wireless LAN USB antenna kit e 7462 4Dx 4Ex 4Fx 4Gx 4 7465 CTO 2Ex 2Fx 2Hx 2Jx
11. 98 ThinkPad X200 and X200s Hardware Maintenance Manual Table 25 Removal steps of base cover assembly for ThinkPad X200s continued Step Screw quantity Color Torque n M2 x 3 5 mm wafer head nylon coated 4 Silver 0 181 Nm 1 85 kgfcm M2 x 3 mm large head nylon coated 1 Silver 0 181 Nm 1 85 kgfcm In step and remove the system board the DC in connector and the fan assembly together from the base cover assembly LAN m When installing Check the position of the wireless switch El and firmly fit the system board into the base cover assembly ThinkPad X200 and 2008 99 Applying labels to the base cover The new base cover FRU is shipped with a kit containing labels of several kinds When you replace the base cover you need to apply the following labels Product label BH Homologation label Following labels need to be peeled off from the old base cover and need to be put on the new base cover Windows license label COA Serial number label MAC address label IMEI label FCC ID label for Wireless LAN FCC ID label for Wireless WAN China modem label SIRIM label EJEJEJETEJEJEJES For some models you need to apply one or two FCC labels or Check the old base cover if it has one or two FCC labels find duplicates of them in the label kit and apply them to the new base cover For the location of each label refer to the following f
12. Eject ThinkPad PC from UltraBase This button is displayed only if the ThinkPad computer has been attached to a ThinkPad X200 UltraBase The computer can be detached from the ThinkPad X200 UltraBase Run EasyEject Actions This button is used to select stop or remove external devices connected to the ThinkPad computer Configure EasyEject Actions Opens the ThinkPad EasyEject Utility main window Fn F9 Settings Configures the settings for the Fn F9 function Fn F10 Reserved Fn F11 Reserved Fn F12 Put the computer into hibernation mode To return to normal operation press the power button for less than four seconds Note To use Fn F12 for hibernation you must have the ThinkPad PM device driver installed on the computer Fn PgUp Turn the ThinkLight on or off Note This function is supported only on the ThinkPad computers that have the ThinkLight The on or off status of the ThinkLight is shown on the screen for a few seconds when you press Fn PgUp Fn Home The computer display becomes brighter Fn End The computer display becomes dimmer Fn Spacebar Enable the FullScreen Magnifier function 5 Has the same function as the SysRq key Fn ScrLk Enable or disable the numeric keypad Fn Pause Has the same function as the Break key 56 ThinkPad X200 and X200s Hardware Maintenance Manual Table 10 Fn key combinations continue
13. 7458 CTO 7Gx 7459 CTO 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 3Kx 3Ox 7469 CTO 7470 CTO 2046 CTO 2047 CTO 3972799 ThinkPad 200 2008 159 Table 39 Parts list Overall continued 13 13 No FRU FRU no SATA hard disk drive 160 GB 9 5 mm 7 200 rpm D 42T1461 7454 CTO 2 2Px 20x 27 96x 7455 CTO 3Ex 7457 CTO 43x 7458 CTO 5Dx 5Fx 5Hx 5 5Nx 79x 7Bx 7Cx 7Dx 7 x 7Qx 82x 87x 88x 8Dx 8 8Kx 8Mx F2x F4x F7x 7459 CTO 5Fx 65x 66x 6 6Nx 6Vx M4x 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 3Gx 3Hx 3Jx 7469 CTO 5Hx 5Nx 5Ox 5Ux 5Wx 5Zx 75x 76x 7 75 7Ux 7470 CTO 2046 CTO 2047 CTO SATA hard disk drive 160 GB 9 5 mm 7 200 rpm 42T1439 7454 CTO 2 2Px 20x 2Zx 96x 7455 CTO 3Ex 7457 CTO 43x 7458 CTO 5Dx 5Fx 5Hx 5 x 5Nx 79x 7Bx 7Cx 7Dx 7 x 7 82x 87x 88x 8Dx 8 8Kx 8Mx F2x FAx F7x 7459 5 65x 66x 6Mx 6Nx 6Vx 4 2023 CTO 2024 CTO X3x 7462 CTO 7465 CTO 7466 CTO 3Ex 3Gx 3Hx 3 x 7469 CTO 5Hx 5Nx 5 5Ux 5Wx 5Zx 75x 76x 7 7Sx 7Ux 7470 CTO 2046 CTO 2047 CTO 13 SATA hard disk drive 320 GB 9 5 mm 7 200 rpm 42T1559 7454 CTO 7455 CTO 7457 CTO 7458 CTO 7459 2023 C
14. 7Ux 7Vx 7Xx E1x 7470 CTO 62x 63x 64x 65x 6Ex 6 x E1x 2046 CTO 2047 CTO FRU no 42T0510 RoHS ID R CRU ID 10 LCD panel 12 1 in WXGA 7454 all 7455 all 7457 all 7458 all 7459 all 2023 CTO 2024 CTO 7462 CTO 42x 43x 44x 45x 46x 47x 48x 49x 4 4Bx 4Cx 4Lx 4 4 4 45 4Tx 4Ux 4 AWx 7465 CTO 23x 24x 25x 26x 27x 28x 29x 2Dx 21 2Mx 2Nx 2Px 20x 2Rx 25 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 35x 3Lx 3Mx 3Nx 3Px 3Rx 3Sx 3Tx 7469 CTO 52x 53x 54x 55x 56x 57x 5Ex 5Fx 5Lx 5 5Nx 5Px 5 5Rx 5Sx 5Tx 5Vx 5Xx 5Yx 5Zx 72x 73x 75x 76x 77x 78x 7Dx 7Ex 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7Mx 7 7Ux 7Vx 7Xx 1 7470 CTO 62x 63x 64x 65x 6Ex 6 x E1x 2046 CTO 2047 CTO 42T0478 R ThinkPad X200 and 2008 179 Table 40 Parts list 12 1 in WXGA TFT continued No 10 F L RU CD panel 12 1 in WXGA 7454 all 7455 all 7457 all 7458 all 7459 all 2023 CTO 2024 CTO 7462 CTO 42x 43x 44x 45x 46x 47x 48x 49x 4Ax 4Bx 4Cx 4Kx 4Lx 4Mx 4Nx 4Px 4Qx 4Rx 4Sx 4Tx 4Ux 4Vx 4Wx 7465 CTO 23x 24x 25x 26x 27x 28x 29x 2Dx 2Lx 2Mx 2Nx 2Px 2 2Rx 2Sx 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 35x 3Lx 3Mx 3Nx 3Px 3Rx 3Sx 3Tx 7469 CTO 52x 53x 54x 55x 56x 57x 5 5Fx 5Lx 5
15. Table 39 Parts list Overall continued No 17 FRU DVD CD RW combo drive 9 5 mm 7454 CTO 7455 CTO 7457 CTO 7458 CTO 7Bx 7459 CTO M4x 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 5 5Wx 1 7470 CTO E1x 2046 CTO 2047 CTO FRU no 42 2513 RoHS ID CRU ID 17 DVD RAM RW drive 9 5 mm 7454 CTO 2Hx 2 x 2Px 20x 2Zx 96x 98x 9Gx 7455 CTO 3Sx 3Tx 3Xx 7457 CTO 7458 CTO 5Px 5Rx 5Sx 79x 7Px 84x 86x 8 8Hx 8Lx 7459 CTO 66x 6Mx 6Nx 6 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 3Fx 3Gx 3 x 7469 CTO 5Fx 5Lx 5Px 5Vx 73x 7Vx 7470 CTO 6Ex 6 x 2046 CTO 2047 CTO 42 2545 17 DVD RAM RW drive 9 5 mm 7454 CTO 2Hx 2 2Px 20x 2Zx 96x 98x 9Gx 7455 CTO 3Sx 3Tx 3Xx 7457 CTO 7458 CTO 5Px 5Rx 5Sx 79x 7Px 84x 86x 8Ex 8Hx 8Lx 7459 CTO 66x 6Mx 6Nx 60x 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 3Gx 3 x 7469 CTO 5Fx 5Lx 5Px 5Vx 73x 7Vx 7470 CTO 6Ex 6 x 2046 CTO 2047 CTO 42 2515 ThinkPad 200 2008 165 Table 39 Parts list Overall continued No 17 FRU FRU no DVD RAM RW drive 9 5 mm 42T2551 7454 2Hx 2 x 2Px 20x 2Zx 96x 98x 9Gx 7455 35 3Tx 3Xx 7457 CTO 7458 CTO 5P
16. 6Ux 6 6Wx 6Xx 6Yx 6Zx E3x H2x M2x M3x 4 2023 CTO 2024 7462 CTO 42x 43 44 45 46x 47x 48 49x 4 4Bx 4Cx 4 4Lx 4 4Nx 4Px 4 4Rx 45 4Tx 7465 CTO 23x 24x 25x 26x 27x 28x 29x 2Dx 2Lx 2Mx 2Nx 2Px 2 2Rx 2Sx 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 35x 3Lx 3Mx 3Nx 3Px 3Rx 3Sx 3Tx 7469 CTO 52x 53x 54x 55x 56x 57x 5 5Fx 5Lx 5Mx 5Nx 5Px 5 5Rx 5Sx 5Tx 5Vx 5Xx 5Yx 5Zx 72x 73x 75x 76x 77x 78x 7 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7Mx 7Qx 7Ux 7Vx 7 1 7470 CTO 62x 63x 64x 65x 6Ex 6 x 2046 CTO 2047 CTO FRU no 42T0969 RoHS ID R CRU ID 178 ThinkPad X200 and X200s Hardware Maintenance Manual Table 40 Parts list 12 1 in WXGA TFT continued No 10 FRU L CD panel 12 1 in WXGA 7454 all 7455 all 7457 all 7458 all 7459 all 2023 CTO 2024 CTO 7462 CTO 42x 43x 44x 45x 46x 47x 48x 49x 4Ax 4Bx 4Cx 4 4Lx 4 4Nx 4 4 4Rx 4Sx 4Tx 4Ux 4Vx 4Wx 7465 CTO 23x 24x 25x 26x 27x 28x 29x 2Dx 2Lx 2Mx 2Nx 2Px 2 2Rx 2Sx 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 35x 3Lx 3Mx 3Nx 3Px 3Rx 3Sx 3Tx 7469 CTO 52x 53x 54x 55x 56x 57x 5Ex 5Fx 5Lx 5Mx 5Nx 5Px 5 5Rx 5Sx 5Tx 5Vx 5Xx 5Yx 5Zx 72x 73x 75x 76x 77x 78x 7Dx 7Ex 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7Mx 7
17. Alternatively if Hibernate when battery becomes low has been selected in the Power Management Properties window the computer goes into hibernation mode Note for the APM operating system Even if you do not set the low battery alarm the charge indicator notifies you when the battery is low and then the computer enters the power saving mode automatically This default low battery behavior is independent of the operating system so if you have set the low battery alarm the computer may not do what you specified It chooses either your setting or the default setting whichever is appropriate If you are using the ACPI operating system only the low battery alarm is available To cause the computer to return from standby mode and resume operation do one of the following Press the Fn key Open the LCD cover Turn on the power switch Also in either of the following events the computer automatically returns from standby mode and resumes operation Related service information 37 The ring indicator RI is signaled by a serial device or a Card device The time set on the resume timer elapses Note The computer does not accept any input immediately after it enters standby mode Wait a few seconds before taking any action to reenter operation mode Hibernation mode In hibernation mode the following occurs The system status RAM VRAM and setup data are stored on the hard disk The system is powere
18. Ethernet on the system board Gigabit Ethernet Internal modem on the I O card some models 56 6 Kbps ThinkPad X200 and 2008 49 Table 7 Specifications continued Feature Description PCI Express Mini Card ThinkPad 11b g Wireless LAN Mini PCI Express Adapter III Intel WiFi Link 5100 Intel WiFi Link 5300 Intel WiMAX WiFi Link 5350 Qualcomm UNDP1 Wireless WAN card KDDI Wireless WAN Modem Adapter Ericsson F3507g USA Wireless WAN card Ericsson F3507g Other Wireless WAN card Wireless USB adapter Bluetooth wireless some 1 models ThinkPad Bluetooth with Enhanced Data Rate BDC 2 1 ThinkLight Yes Battery Li ion battery 4 cells 2 0 Ah Li ion battery 6 cells 2 6 Ah Li ion battery 9 cells 2 6 Ah AC adapter 65 watt type Preinstalled operating system Windows XP Professional Windows Vista Home Basic 32 bit Windows Vista Home Premium 32 bit Windows Vista Business 32 bit Windows Vista Business 64 bit Windows Vista Ultimate 32 bit 50 ThinkPad X200 and X200s Hardware Maintenance Manual Status indicators The system status indicators show the status of the computer as follows Table 8 Status indicators Indicator Meaning Standby status Green The computer is in standby mode Blinking green The computer is entering standby mode or hibernation mode or is resuming normal oper
19. Logical Disk Drives Information DE Drive Info PCI Information PNPISA Info SMBIOS Info VESA LCD Info Hardware Events Log Utility Run External Tests Surface Scan Hard Disk Benchmark System DOS Shell Tech Support Form Battery Rundown View Test Log Print Log Save Log Full Erase Hard Drive Quick Erase Hard Drive PC Doctor for Windows This product is designed to help you troubleshoot and resolve problems related to your computer Select one of the categories listed below to display symptoms and solutions Check System Health System and Device Tests Lenovo Troubleshooting Center System Reports Updates and Support PC Doctor for Rescue and Recovery In some models of ThinkPad computer the Rescue and Recovery workspace enables you to run the PC Doctor program to test the hardware features of the computer To run the test click Run Diagnostics on the Rescue and Recovery main screen 28 ThinkPad X200 and X200s Hardware Maintenance Manual Power system checkout To verify a symptom do the following Turn off the computer Remove the battery pack Connect the ac adapter Check that power is supplied when you turn on the computer Turn off the computer Disconnect the ac adapter and install the charged battery pack Check that the battery pack supplies power when you turn on the computer doc If you suspect a power problem see the appropri
20. 25x 26x 27x 28x 29x 2Dx 2Fx 2 x 2Kx 2Lx 2Vx 2Wx 7466 CTO 34x 35x 39x 3Ax 3Cx 3Dx 3Ex 3Hx 3Kx 3Qx 3Tx 3Ux 7469 CTO 54x 55x 56x 57x 59x 5Ax 5Cx 5Dx 5Gx 5 5Lx 5Nx 5Px 5 5Sx 5Tx 5Ux 5Xx 5Zx 72x 73x 7 7Nx 7Rx 7Ux 7Yx 82x E1x e 7470 CTO 5Gx 64x 65x 69x 6Ax 6Cx 6Dx 6Fx 1 2046 CTO 2047 CTO FRU no 4274647 RoHS ID R CRU ID ThinkPad X200 and 2008 151 Table 39 Parts list Overall continued 11 11 No FRU FRU no Battery pack 6cell 42 T4648 7454 CTO 22x 23x 24x 25x 27x 28x 2Hx 2 x 2Kx 2Lx 2Mx 2Px 20x 2Rx 2Sx 2Tx 2Ux 2Vx 27 92x 93x 96x 98x 9Gx 7455 CTO 32x 33x 34x 35x 38x 39x 3Bx 3Cx 3Dx 3Fx 3Gx 3Hx 3 x 3Lx 3Mx 3Nx 3Px 3Rx 3Sx 3Tx 3Ux 3Vx 3Wx 37 D2x D3x 7457 CTO 42x 43x 44x 46x 47x 49x 4Cx 4Dx 4Ex 4Fx 4Kx 4Lx 4Mx 7458 CTO 52x 53x 54x 56x 57x 58x 5Ex 5Fx 5Mx 5Nx 5Px 5Rx 5Sx 5Tx 69x 72x 73x 74x 76x 77x 78x 79x 7Dx 7 7Nx 7Px 7Qx 75 7Tx 7Ux 7Zx 82x 84x 85x 86x 87x 8Ax 8Bx 8Dx 8Ex 8Fx 8Gx 8Hx 8 x 8Kx 8Lx 8Mx 8Nx 8Px 8 8Rx 8Sx 8Tx 8Wx 8Xx 8Yx E2x F9x FAx M3x X4x 5 7459 5Ex 5 64x 69x 6Ax 6Bx 6Dx 6Ex 6Fx 6Gx 6 x 6Kx 6Lx 6Mx 6Ux 6Zx H2x E3x M3x 2023 CTO 2024 CTO 7462 CTO 44x 45x 46x 47x 48x 49x 4 4Bx 4
21. 3 Backup battery 92 1210 R N 4 Intel Turbo Memory 2 GB Minicard 43Y6523 R id 7454 CTO 23x 25x 28x 2 x 2Lx 20x 7455 CTO 33x 35x 3Ax 3Hx 3Jx 39 3Tx 3Vx 3Wx 3Xx 3Yx 7457 CTO 43x 44x 47x 49x 4Dx 7458 CTO 53x 54x 56x 57x 58x 5Ax 5Bx 5Cx 5Dx 5Lx 5Mx 5Sx 69x 7Bx 7Dx 7 x 7Kx 7Zx 8Cx 8Fx 8Wx 8Xx 8Yx F3x F4x F7x 7459 CTO 63x 64x 65x 66x 68x 69x 6Bx 6Dx 6Nx 6Px 6 6Ux 6Vx 6Xx H2x 2023 CTO 2024 CTO 7462 CTO 46x 47x 48x 49x 4 4Bx 4Dx 4Ex 4Fx 7465 CTO 25x 26x 27x 28x 29x 2Ex 2Fx 7466 CTO 34x 35x 38x 39x 3Ax 3Fx 3Gx 3Rx 3Sx 3Tx 3Ux 7469 CTO 54x 55x 56x 57x 58x 59x 5Ax 5Lx 5Mx 5Px 5Ox 5Zx 72x 73x 78x 79x 7Bx 7Ux 7470 CTO 64x 65x 68x 69x 6Ax 2046 CTO 2047 CTO 4 Intel Turbo Memory 4 GB Minicard 43Y6525 R 7454 7455 CTO 7457 7458 CTO F8x 9 7459 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 7470 CTO 2046 CTO 2047 CTO 138 ThinkPad X200 and X200s Hardware Maintenance Manual Table 39 Parts list Overall continued No FRU Wireless USB adapter 7454 7455 CTO 7457 7458 7459 2023 CTO 2024 CTO 7462 44 45 4 7465 CTO 2Dx 7466 CTO 7469 CTO 7470 CTO 2046 CTO 2047 FRU no RoHS C
22. 3Bx 3Cx 3Ex 3Fx 3Gx 3Hx 3Lx 3Mx 3Nx 3Qx 3Rx 3Xx 3Yx 3Zx D5x 7457 CTO 42x 43x 44x 46x 47x 49x 4Ex 4Fx 4Kx 4Lx 4Mx 7458 CTO 52x 53x 54x 56x 58x 59x 5Cx 5Dx 5Ex 5Fx 5Hx 5 5 5Rx 5Sx 5 69x 74x 76x 77x 79x 7Bx 7 7Dx 7 x 7Kx 7 78x 7Ux 7Yx 83x 84x 85x 87x 88x 89x 8Ax 8Px 8Ox 8Rx 85 8Zx E2x F2x F6x F7x F8x M2x M3x X4x 7459 5Ex 5Fx 64x 65x 66x 67x 69x 6Ax 6Bx 6Dx 6Gx 6 x 6Kx 6Mx 6Nx 6Px 60x 65 6Ux 6Vx 6Wx 6Xx E3x M2x M3x M4x 2023 CTO 2024 FRU no 42W8151 System board with Intel Core 2 Duo processor P8600 42W8154 2 4 GHz AMT non TPM 7454 7455 CTO 3Ux 3Vx 7457 CTO 7458 8Bx 8Ex 8Fx 8 8 x 8Mx 7459 CTO 6Yx 6Zx H2x 2023 CTO 2024 CTO 5 System board with Intel Core 2 Duo processor P8600 42W8007 R N 2 4 GHz non AMT TPM 7454 CTO 7455 CTO 5 System board with Intel Core 2 Duo processor P8600 2 4 GHz non AMT non TPM 7454 CTO 7455 CTO 42W8097 R N 5 System board with Intel Core 2 Duo processor P8700 42W8224 R N 2 53 GHz AMT TPM 7454 CTO 9Bx 9Cx 7455 CTO D2x D3x 7457 CTO 4Rx 4Sx 4 7458 CTO 8Tx 8Wx 8Xx F3x F4x F9x FAx 7459 2023 CTO 2024 CTO 140 ThinkPad X200 and X200s Hardware Maintenance Manual Table 39 Parts list Overall
23. 3Rx 3Sx 3Tx 7469 CTO 54x 55x 56x 57x 5Fx 5Lx 5Mx 5Nx 5Px 5Qx 5Rx 5Sx 5 Tx 5 5 5Yx 5Zx 72x 73x 75x 76x 77x 7 7Lx 7Mx 7Ux 7Vx 7Xx e 7470 CTO 64x 65x 6Ex 6 x 2046 CTO 2047 44C5395 R ThinkPad X200 and 2008 173 Table 40 Parts list 12 1 in WXGA TFT continued No FRU Wireless LAN WAN USB antenna kit 7454 7455 CTO 7457 CTO 7458 CTO 7459 2023 CTO 2024 CTO 7462 CTO 44x 45x 7465 CTO 2Dx 7466 CTO 7469 7470 CTO 2046 CTO 2047 CTO FRU no 44C5394 RoHS ID R CRU ID Hinge L R e 7454 all 7455 all 7457 all 7458 all 7459 all 2023 CTO 2024 CTO 7462 CTO 42x 43x 44x 45 46x 47x 48x 49x 4 4Bx 4Cx 4 4Lx 4 4Nx 4 4 4Rx 4Sx 4Tx 4Ux 4 AWx 7465 CTO 23x 24x 25x 26x 27x 28x 29x 2Dx 2Lx 2Mx 2Nx 2Px 20x 2Rx 2Sx 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 35x 3Lx 3Mx 3Nx 3Px 3Rx 3Sx 3Tx 7469 CTO 52x 53x 54x 55x 56x 57x 5Ex 5Fx 5Lx 5Mx 5Nx 5Px 5 5Rx 5Sx 5Tx 5Vx 5Xx 5Yx 5Zx 72x 73x 75x 76x 77x 78x 7Dx 7Ex 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7 7Qx 7Ux 7Vx 7Xx E1x e 7470 CTO 62x 63x 64x 65x 6Ex 6 x 1 2046 CTO 2047 CTO 44C9544 174 ThinkPad X200 and X200s Hardware Maintenance Manual
24. 4 4Rx 4Sx 4Tx 7465 CTO 2Rx 2Sx 2Tx 2Ux 2Wx 7466 CTO 3Hx 3 x 3Qx 3Nx 3Px 7469 CTO 5 x 74x 7 x 7Kx 82x 7470 CTO 6Hx 6Kx 2046 CTO 2047 CTO ThinkPad X200 and 2008 187 Table 47 Parts list Windows XP Professional recovery DVDs Language P N RoHS CRU ID ID Arabic 46V3670 R N Brazilian Portuguese 46V3671 Czech 46 3673 Danish 46V3674 Dutch 46V3685 English 46V3696 English modem disabled 46V3695 Finnish 46V3675 French 46V3676 German 46V3678 Greek 46V3677 Hebrew 46 3679 Hungarian 46V3681 Italian 46V3682 Japanese 46V3683 Korean 46V3684 Norwegian 46V3686 Polish 46V3687 Russian 46V3689 Russian English enabled 46V3688 Simplified Chinese 46V3672 Slovenian 46V3690 Spanish 46V3691 Swedish 46V3692 Traditional Chinese 46V3694 Traditional Chinese Hong Kong S A R 46V3680 Turkish 46V3693 188 ThinkPad X200 and X200s Hardware Maintenance Manual Windows Vista Home Basic 32 bit DVDs Windows Vista Home Basic 32 bit is preinstalled as the operating system in the following models e 7454 CTO 7455 CTO e 7457 4 4Gx 4Ux 4 7458 7 7Fx 8Zx 7459 CTO 65 2023 e 2024 CTO e 7462 CTO 42x 4 4Ux 4 4Wx 7465 CTO 23x 2Xx 7466 CTO 32x e 7469 CTO 52x 7Dx 7470 CTO 62x 2046 CTO
25. 47x 48x 49x 4Ax 4Bx 4Cx 4Fx 4Lx 4Mx 4Ox 4Rx 4Vx AWx 7465 CTO 28x 29x 2Dx 2Mx 2Nx 2Rx 25 7466 CTO 35x 3Ax 3Rx 3Sx 3Tx 3Ux 7469 CTO 55x 57x 5 Ax 5Ex 5Kx 5Px 72x 78x 7Ax 7Ex 7Qx 7Tx 7470 CTO 65x 6Ax 2046 CTO 2047 CTO 156 ThinkPad X200 and X200s Hardware Maintenance Manual Table 39 Parts list Overall continued No 13 FRU SATA hard disk drive 250 GB 9 5 mm 5 400 rpm 7454 CTO 23x 28x 2Lx 2Tx 2Wx 9Bx 9Cx 7455 CTO 33x 3Cx 3Lx 3 3Sx 3Tx 3Zx D5x 7457 CTO 44x 47x 4Dx 4 4Kx 4Nx 4Rx 45 4Tx 4Ux 4Wx 7458 CTO 54x 58x 5Bx 5Cx 5Mx 5Rx 55 77x 7Fx 7 7 78x 7 7Xx 7Yx 7Zx 84x 8Ex 8Zx F5x 7459 CTO 63x 64x 6Kx 6Rx 6Tx 6Ux 2023 CTO 2024 CTO 7462 CTO 47x 48x 49x 4Ax 4Bx 4 4Fx 4Lx 4Mx 4 4Rx 4Vx AWx 7465 CTO 28x 29x 2Dx 2Mx 2Nx 2Rx 2Sx 7466 CTO 35x 3Ax 3Rx 3Sx 3Tx 3Ux 7469 CTO 55x 57x 5Ax 5Ex 5Kx 5Px 72x 78x 7Ax 7 7Ox 7Tx 7470 CTO 65x 6Ax 2046 CTO 2047 CTO FRU no 42T1471 RoHS ID R CRU ID 13 SATA hard disk drive 250 GB 9 5 mm 5 400 rpm 7454 CTO 23x 28x 2Lx 2Tx 2Wx 9Bx 9Cx 7455 CTO 33x 3Cx 3Lx 3Mx 3Sx 3Tx 3Zx D5x 7457 CTO 44x 47x 4Dx 4Jx 4Kx 4Nx 4Rx 45 4Tx 4Ux 4Wx 7458 CTO 54x 58x 5 5Cx 5Mx 5Rx 5Sx 77x 7Fx 7Hx 7Nx 7Sx 7Ix
26. 5Bx 5Cx 5Dx 5Gx 5Hx 5 5Kx 5Ux 5Wx 74x 79x 7 Ax 7Bx 7Cx 7Nx 7Rx 7Sx 7Tx 7Yx 7Zx 82x 7470 CTO 5Gx 5Hx 68x 69x 6Ax 6Bx 6Cx 6Dx 6Fx 6Gx 6Hx 6Kx 7470 CTO 5Gx 5Hx 68x 69x 6Ax 6Bx 6Cx 6Dx 6Fx 6Gx 2046 2047 45N3201 LCD cable assembly with Bluetooth connector e 7462 CTO 4Dx 4Ex 4Fx 4Gx 4 7465 CTO 2Ex 2Fx 2Hx 2 x 2Kx 7469 CTO 58x 59x 5 5Bx 5Cx 5Dx 5Gx 5Hx 5 x 5 5Ux 5Wx 74x 79x 7 7Bx 7Cx 7Nx 7Rx 75 7 7Yx 7Zx 82x 7470 CTO 5Gx 5Hx 68x 69x 6Ax 6Bx 6Cx 6Dx 6Fx 6Gx 6Hx 6Kx 7470 5Gx 5Hx 68x 69x 6Ax 6 6Cx 6Dx 6Fx 6Gx 2046 CTO e 2047 CTO 4409919 Bluetooth daughter card BDC 2 1 e 7462 CTO 4Dx 4Ex 4Fx 4Gx 4Hx 4 7465 CTO 2Ex 2Fx 2Hx 2Jx 2Kx 7469 CTO 58x 59x 5 5Bx 5Cx 5Dx 5Gx 5Hx 5 5Kx 5Ux 5Wx 74x 79x 7 7Bx 7Cx 7Nx 7Rx 75 7 7Yx 7Zx 82x 7470 CTO 5Gx 5Hx 68x 69x 6Ax 6Bx 6Cx 6Dx 6Fx 6Gx 6Hx 6Kx 7470 CTO 5Gx 5Hx 68x 69x 6Ax 6Bx 6Cx 6Dx 6Fx 6Gx 2046 CTO 2047 CTO 42T0969 ThinkPad X200 and X200s 183 Keyboard Table 42 Parts list Keyboard Language P N RoHS CRU ID ID Arabic 42T3752 42 3686 R Belgian 42T3749 4213683 Brazilian Portuguese 427
27. 5Nx 5Px 5 5Rx 5Sx 5Tx 5Ux 5Vx 5Wx 5Xx 5Yx 5Zx 72x 73x 74x 75x 76x 77x 78x 7Ax 7Bx 7Cx 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7Mx 7Nx 7Px 7Qx 7Rx 7Rx 7Sx 7Tx 7Ux 7Vx 7Wx E1x 7470 CTO 5Gx 5Hx 62x 63x 64x 65x 68x 69x 6Ax 6Bx 6 6Dx 6Ex 6Fx 6Gx 6Hx 6 x 6Kx 1 2046 CTO 2047 CTO FRU no 42W8011 RoHS ID R CRU ID ThinkPad X200 and X200s 149 Table 39 Parts list Overall continued No FRU FRU no I O card assembly without modem connector with 42W8012 3 in 1 Media Card Reader slot 7454 CTO 2Rx 92x 7455 CTO 3Dx 3Px 7457 CTO 4 4Bx 4Gx 4Hx 4Ux 4Vx AWx 7458 CTO 78x 7 7Vx 7Wx 7Xx 8Nx F5x F6x 5 7459 CTO 62x 63x 66x 68x 6Lx 6Nx 6Tx 2023 CTO 2024 7462 4Ux 4Vx AWx 7465 2Vx 2Wx 7466 CTO 3Kx 3Qx 7469 CTO 79x 7Dx 7Ex 7470 CTO 2046 CTO 2047 CTO 10 DC in cable assembly 44C5396 11 Battery pack 4 cell 42 4646 7454 26x 29x 2Gx 2 2Wx 2 2Yx 95x 97x 9Bx 9Cx 9Fx 7455 CTO 36x 3Kx 7457 CTO 45x 48x 4Ax 4Bx 4Gx 4 4Nx 4Px 4 4Rx 4Sx 4Tx 4Ux 4Vx 4Wx 7458 CTO 55x 5Ax 5Bx 5Cx 5Dx 5Lx 7Ex 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7Rx 7Vx 7Wx 7Xx 7Yx 8Cx 8Zx F2x F3x F4x F5x Fox F7x F8x 2 7459 CTO 62x 63x 68x 6Cx 6Rx 6Tx 6Yx M2x 2023 CTO 2024 CTO 7462 CTO 42x 43x 4Dx
28. 6Yx 6Zx M2x M3x 2023 CTO 2024 CTO 7462 CTO 42x 43x 4Kx 4Lx 4Mx 4Nx 4Px 4 4Rx 4Sx 4Tx 4Ux 4Vx 4Wx 7465 CTO 23x 24x 2Mx 2Nx 2Px 20x 2Rx 2Sx 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 3Lx 3Mx 3Nx 3Px 7469 CTO 52x 53x 5Ex 78x 7Dx 7Ex 7Gx 7Hx 7 x 7Kx 7 E1x e 7470 CTO 62x 63x 1 2046 CTO 2047 CTO FRU no 44C5393 RoHS ID R CRU ID Wireless LAN WAN antenna kit 7454 CTO 22x 23x 24x 25x 27x 28x 2 x 2 2Nx 2Px 20x 25 2Tx 2Ux 2Vx 27 93x 96x 9Bx 9Cx 9Fx 9Gx 7455 CTO 32x 33x 34x 35x 3Bx 3Dx 3Ex 3Lx 3 3Nx 3Px 3Qx 35 3Tx 3Xx 3Zx D2x D3x 7457 CTO 42x 43x 44x 46x 47x 49x 4Bx 4Ex 4Fx 4 4Kx 4Lx 4Mx 4Rx 4Sx 4Tx 7458 CTO 52x 53x 54x 56x 59x 5 5Bx 5Cx 5Dx 5Hx 5Jx 5Lx 5Mx 5 5Px 5 5Rx 55 5Tx 69x 74x 76x 78x 79x 7Bx 7Cx 7Dx 7Ex 7Fx 7Gx 7Hx 7 x 7Kx 7Nx 7Px 7 75 7Tx 7Ux 7Wx 7Xx 7Yx 7Zx 82x 83x 84x 85x 86x 88x 89x 8Cx 8Dx 8 8Fx 8Hx 8 8Kx 8Lx 8Px 8 8Rx 8Sx 8Tx 8Wx 8Xx 8Yx E2x X4x 7459 CTO 62x 63x 64x 65x 66x 67x 68x 69x 6Ax 6Bx 6Dx 6Gx 6 x 6Lx 6Mx 6Nx 6Px 60x 6Rx 6Sx 6Tx 6Ux 6 6Wx 6Xx E3x H2x M4x 2023 CTO 2024 CTO 7462 CTO 46x 47x 48x 49x 4 4Bx 7465 CTO 25x 26x 27x 28x 29x 2Lx 7466 CTO 34x 35x
29. 72x 73x 74x 75x 76x 77x 78x 7Ax 7Bx 7 7Ex 7 7Gx 7Hx 7 x 7Kx 7Lx 7Mx 7Nx 7Px 7Qx 7Rx 79 7Tx 7Ux 7 7Xx 7Yx 82x 7470 CTO 5Gx 5Hx 62x 63x 64x 65x 68x 69x 6Ax 6Bx 6Cx 6Dx 6Ex 6Fx 6Gx 6Hx 6 x 6Kx 2046 CTO 2047 CTO FRU no 44C9671 RoHS CRU 25 Keyboard see Keyboard on page 184 26 TrackPoint stick caps 91P9642 AC adapter see AC adapters on page 185 170 ThinkPad X200 and X200s Hardware Maintenance Manual LCD FRUs In ThinkPad X200 and X200s there are following types of LCDs e 12 1 in WXGA TFT e 12 1 in WXGA TFT on page 181 12 1 in WXGA TFT ThinkPad 200 2008 171 Table 40 Parts list 12 1 in WXGA TFT No FRU LCD bezel assembly 7454 all 7455 all 7457 all 7458 all 7459 all 2023 CTO 2024 CTO 7462 CTO 42x 43x 44x 45x 46x 47x 48x 49x 4Ax 4Bx 4Cx 4 4Lx 4 4Nx 4Px 4 4Rx 4Sx 4Tx 4Ux 4Vx 4Wx 7465 CTO 23x 24x 25x 26x 27x 28x 29x 2Dx 2Lx 2Mx 2Nx 2Px 2 2Rx 2Sx 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 35x 3Lx 3Mx 3Nx 3Px 3Rx 3Sx 3Tx 7469 CTO 52x 53x 54x 55x 56x 57x 5Ex 5Fx 5Lx 5Mx 5Nx 5Px 5Ox 5Rx 5Sx 5Tx 5Vx 5Xx 5Yx 5Zx 72x 73x 75x 76x 77x 78x 7Dx 7 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7 7 7Ux 7Vx 7Xx 1 7470 CTO 62x 63x 64x
30. 7466 CTO 38x 3Bx 7469 CTO 58x 5Bx 7470 CTO 68x 6Bx 2046 CTO 2047 CTO System board with Intel Core 2 Duo processor 5179300 42W8099 1 2 GHz AMT non TPM 7462 CTO 7465 CTO 7466 CTO 7469 CTO 7470 CTO 2046 CTO 2047 CTO System board with Intel Core 2 Duo processor SL9300 44 9668 1 6 GHz AMT TPM 7462 CTO 42x 43x 44x 45x 46x 4 4Hx 4Kx 4Lx 4Nx 4Qx 4Sx 7465 CTO 23x 24x 25x 26x 27x 2Fx 2Jx 2Mx 2Px 2Rx 2Tx 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 39x 3Cx 3Kx 3Ox 3Lx 3Mx 3Nx 3Px 7469 CTO 52x 53x 54x 56x 59x 5 5Ex 5Lx 5Mx 5Nx 5 5Xx 5Yx 5Zx 72x 75x 78x 7Ax 7Dx 7 7Gx 7Hx 7 x 7Kx 7Yx 7Zx 82x 1 e 7470 CTO 62x 63x 64x 69x 6 1 2046 CTO 2047 CTO System board with Intel Core 2 Duo processor SL9300 42 8100 1 6 GHz AMT non TPM 7462 CTO 7465 CTO 7466 CTO 7469 CTO 7Ox 7470 CTO 2046 CTO 2047 CTO 142 ThinkPad X200 and X200s Hardware Maintenance Manual Table 39 Parts list Overall continued No FRU FRU no RoHS CRU ID ID 5 System board with Intel Core 2 Duo processor SL9400 44 9669 R N 1 86 GHz AMT TPM 7462 CTO 47x 48x 49x 4Ax 4Bx 4Cx 4Fx 4Jx 4 4Px 4Rx 4Tx 7465 CTO 28x 29x 2Dx 2Kx 2Lx 2Nx 20x 25 2Ux 7466 CTO 35x 3Ax 3Dx 3Ex 3Fx 3Gx 3Hx 3 3Rx 3Sx 7469 CTO
31. 7Xx 7Yx 7Zx 84x 8Ex 8Zx F5x F6x 7459 CTO 63x 64x 6Kx 6Rx 6Tx 6Ux 2023 CTO 2024 CTO 7462 CTO 47x 48x 49x 4Ax 4Bx 4 4Fx 4Lx 4Mx 4 4Rx 4Vx AWx 7465 CTO 28x 29x 2Dx 2Mx 2Nx 2Rx 2Sx 7466 CTO 35x 3Ax 3Rx 3Sx 3Tx 3Ux 7469 CTO 55x 57x 5Ax 5Ex 5Kx 5Px 72x 78x 7Ax 7 7Ox 7Tx 7470 CTO 65x 6Ax 2046 CTO 2047 CTO 42T1517 R ThinkPad X200 and X200s 157 Table 39 Parts list Overall continued 13 No FRU FRU no SATA hard disk drive 250 GB 9 5 mm 5 400 rpm 42T1581 7454 CTO 23x 28x 2Lx 2Tx 2Wx 9Bx 9Cx 7455 CTO 33x 3Cx 3Lx 3Mx 3Sx 3Tx 37 D5x 7457 CTO 44x 47x 4Dx 4 4Kx 4Nx 4Rx 4Sx 4Tx 4Ux 4Wx 7458 CTO 54x 58x 5Bx 5Cx 5Mx 5Rx 5Sx 77x 7Fx 7Hx 7 78x 7Ix 7Xx 7Yx 7Zx 84x 8Ex 8Zx F5x F6x 7459 CTO 63x 64x 6Kx 6Rx 6Tx 6Ux 2023 CTO 2024 7462 CTO 47x 48x 49x 4Ax 4Bx 4 4Fx 4Lx 4Mx 4Ox 4Rx 4Vx AWx 7465 CTO 28x 29x 2Dx 2Mx 2Nx 2Rx 25 7466 CTO 35x 3Ax 3Rx 3Sx 3Tx 3Ux 7469 CTO 55x 57x 5 Ax 5Ex 5 5Px 72x 78x 7Ax 7 7Ox 7Tx 7470 CTO 65x 6Ax 2046 CTO 2047 CTO 13 SATA hard disk drive 320 GB 9 5 mm 5 400 rpm 42 1507 7454 CTO 7455 CTO 3Hx 3Nx 3Vx 3Xx 3Yx D2x D3x 7457 CTO 7458 CTO 7Kx 7Ux 8Tx 8Wx 8Xx 8Yx F3x F8x 9 7459 6Px 6 6 2023 2
32. Core 2 Duo Other company product or service names may be the trademarks or service marks of others 198 ThinkPad X200 and X200s Hardware Maintenance Manual ThinkPad Part Number 43Y6632 03 1P P N 43Y6632 03
33. Cross section Torque driver If you have a torque driver refer to the Torque column for each step Make sure that you use the correct screw If you have a torque screwdriver tighten all screws firmly to the torque shown in the table Never use a screw that you removed Use a new one Make sure that all of the screws are tightened firmly Ensure torque screw drivers are calibrated correctly following country specifications 58 ThinkPad X200 and X200s Hardware Maintenance Manual Retaining serial numbers This section includes the following descriptions Restoring the serial number of the system unit Retaining the UUID Reading or writing the ECA information on page 61 Restoring the serial number of the system unit When the computer was manufactured the EEPROM on the system board was loaded with the serial numbers of the system and all major components These numbers need to remain the same throughout the life of the computer If you replace the system board you must restore the serial number of the system unit to its original value Before replacing the system board save the original serial number by doing the following 1 Install the ThinkPad Hardware Maintenance Diskette Version 1 73 or later and restart the computer 2 From the main menu select 1 Set System Identification 3 Select 2 Read S N data from EEPROM The serial number of each device in your computer is displayed the seria
34. RYT ZDELE E RYTY Ky HUE T CREW 11770 NYT BIRN Y VANTHS RyFV RIRBAULCK REY Bok Ay TU RBATSL RYT 97 03 1320 BELEVTAZLEBSVETF Las bater as contienen pequefias cantidades de n quel No las desmonte ni recargue ni las eche al fuego o al agua ni las cortocircuite Des chelas tal como dispone la normativa local Utilice s lo bater as que se encuentren en 1 lista de piezas al sustituir la bater a La utilizaci n de una bater a no apropiada puede provocar la ignici n o explosi n de la misma Safety information 9 Safety notice 4 N DANGER The lithium battery can cause a fire an explosion or a severe burn Do not recharge it remove its polarized connector disassemble it heat it above 100 C 212 F incinerate it or expose its cell contents to water Dispose of the battery as required by local ordinances or regulations Use only the battery in the appropriate parts listing Use of an incorrect battery can result in ignition or explosion of the battery La pile de sauvegarde contient du lithium Elle pr sente des risques d incendie d explosion ou de br lures graves Ne la rechargez pas ne retirez pas son connecteur polaris et ne la d montez pas Ne l exposez pas une temperature sup rieure 100 C ne la faites pas br ler et n en exposez pas le contenu l eau Mettez la pile au rebut co
35. SATA interface 250 GB 5400 rpm 9 5 mm high SATA interface 320 GB 5400 rpm 9 5 mm high SATA interface 100 GB 7200 rpm 9 5 mm high SATA interface 160 GB 7200 rpm 9 5 mm high SATA interface 320 GB 7200 rpm 9 5 mm high SATA interface 200 GB 7200 rpm FDE Full Disk Encryption 9 5 mm high SATA interface 250 GB 7200 rpm FDE Full Disk Encryption 9 5 mm high SATA interface Supported hard disk drives depend on the model Solid state drive 64 GB 8 mm high SATA interface 80 GB 8 mm high SATA interface 128 GB 8 mm high SATA interface Serial Ultrabay Slim device Supported in ThinkPad X200 UltraBase DVD drive 9 5 mm high DVD CD RW combo drive 9 5 mm high DVD RAM RW drive 9 5 mm high Blu ray disc drive 9 5 mm high Fingerprint reader Some models I O port ThinkPad X200 or X200s External monitor connector Stereo headphone jack Monaural microphone jack Docking connector RJ 11 Modem connector some models RJ 45 Ethernet connector Universal serial bus USB connector x 3 5 in 1 Media Card Reader slot some models 3 in 1 Media Card Reader slot some models ExpressCard slot I O port ThinkPad X200 UltraBase External monitor connector Stereo headphone jack Monaural microphone jack DisplayPort connector Docking connector RJ 45 Ethernet connector Universal serial bus USB connector x 4 Audio Built in monaural speakers Software control volume
36. V dc 1 0 to 12 6 7 Ground 3 If the voltage is less than 11 0 V dc the battery pack has been discharged Note Recharging will take at least 3 hours even if the indicator does not turn on If the voltage is still less than 11 0 V dc after recharging replace the battery 4 If the voltage is more than 11 0 V dc measure the resistance between battery terminals 5 and 7 The resistance must be 4 to 30 K 0 If the resistance is not correct replace the battery pack If the resistance is correct replace the system board 30 ThinkPad X200 and X200s Hardware Maintenance Manual Checking the backup battery Do the following 1 Power off the computer and unplug the ac adapter from it 2 Turn the computer upside down 3 Remove the battery pack see 1010 Battery pack on page 64 4 Remove the backup battery see 1060 Backup battery on page 77 5 Measure the voltage of the backup battery See the following figure Red Wire Voltage V dc Red 42 5 to 432 Black Black Ground If the voltage is correct replace the system board If the voltage is not correct replace the backup battery If the backup battery discharges quickly after replacement replace the system board Generalcheckout 31 32 ThinkPad X200 and X200s Hardware Maintenance Manual Related service information This chapter presents following information Restoring the factory contents by usin
37. continued No FRU FRU no RoHS CRU 13 hard disk drive 160 GB 9 5 mm 5 400 rpm 42T1579 R 7454 CTO 25x 26x 29x 2Gx 2Hx 2Nx 2Rx 2Ux 2Vx 2Xx 2Yx 92x 95x 97x 98x 9Fx 7455 CTO 35x 36x 39x 3Dx 3 x 3Kx 3Px 3Wx 7457 CTO 45x 48x 49x 4 4Bx 4Hx 4Lx 4Mx 4Px 4 4Vx e 7458 CTO 53x 55x 56x 57x 5Ax 5Ex 5Lx 5Qx 69x 73x 78x 7Ex 7Lx 7Mx 7Px 7Rx 7Vx 7Wx 83x 86x 89x 8Ax 8Bx 8Cx 8Fx 8Gx 8Hx 8Lx 8Nx E2x M2x M3x X4x X5x 7459 CTO 5Ex 62x 68x 69x 6Bx 6Cx 6Dx 6Fx 6Lx 6Sx 6Yx 6Zx H2x E3x M2x M3x 2023 CTO 2024 CTO 7462 CTO 42x 43x 44x 45x 46x 4Dx 4Ex 4Kx 4Nx 4Px 4Sx 4Tx 4Ux 7465 CTO 23x 24x 25x 26x 27x 2Ex 2Fx 2Lx 2Px 2Qx 21 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 38x 39x 3Fx 3Lx 3Mx 3Nx 7469 CTO 52x 53x 54x 56x 58x 59x 5Gx 5Lx 5Mx 5Xx 5Yx 7Dx 7Gx 7Hx 7 x 7Kx 7Rx 7470 5Gx 62x 63x 64x 68x 69x 6Fx 2046 CTO 2047 CTO 13 SATA hard disk drive 250 GB 9 5 mm 5 400 rpm 4271481 R 7454 23x 28x 2Lx 2Tx 2Wx 9Bx 9 7455 CTO 33x 3Cx 3Lx 3Mx 3Sx 3Tx 3Zx D5x 7457 CTO 44x 47x 4Dx 4 4Kx 4Nx 4Rx 45 4Tx 4Ux 4Wx 7458 CTO 54x 58x 5Bx 5Cx 5Mx 5Rx 5Sx 77x 7Fx 7Hx 7Nx 7Sx 7Tx 7Xx 7Yx 7Zx 84x 8Ex 8Zx F5x Fox 7459 CTO 63x 64x 6Kx 6Rx 6Tx 6Ux 2023 CTO 2024 CTO 7462 CTO
38. quantity Color Torque M2 5 x 4 mm wafer head nylon coated 2 Black 0 392 Nm 4 kgfcm BH M2 x 3 5 mm wafer head nylon coated 4 Silver 0 181 Nm 1 85 kgfcm 116 ThinkPad X200 and X200s Hardware Maintenance Manual Table 33 Removal steps of LCD panel LCD brackets and LCD cable for 12 1 in WXGA LCD model continued Note Step is only for models without the integrated camera For models with the integrated camera skip step El Step Screw quantity Color Torque M2 x 3 5 mm wafer head nylon coated 2 Silver 0 181 Nm 1 85 kgfcm In step release the antenna cables from the cable guides and then remove the LCD panel ThinkPad X200 and X200s 117 Table 33 Removal steps of LCD panel LCD brackets and LCD cable for 12 1 in WXGA LCD model continued Remove the LCD bracket W Step Screw quantity Color Torque M2 x 2 mm wafer head nylon coated 4 Black 0 181 Nm 1 85 kgfcm 118 ThinkPad X200 and X200s Hardware Maintenance Manual Table 33 Removal steps of LCD panel LCD brackets and LCD cable for 12 1 in WXGA LCD model continued Turn the LCD panel over and then remove the LCD cable from the LCD panel When installing Make sure that the LCD cable connector is attached firmly ThinkPad X200 and 2008 119 Table 34 Removal steps of LCD panel LCD brackets and LCD cable for 12 1 in WXGA
39. 2Kx 7469 CTO 58x 59x 5 5Bx 5Cx 5Dx 5Gx 5Hx 5 5 5Ux 5Wx 74x 79x 7 Ax 7Bx 7Cx 7 7Rx 75 7Tx 7Yx 7Zx 82x 7470 CTO 5Gx 5Hx 68x 69x 6Ax 6Bx 6Cx 6Dx 6Fx 6Gx 6Hx 6Kx 7470 CTO 5Gx 5Hx 68x 69x 6Ax 6Bx 6Cx 6Dx 6Fx 6Gx 2046 CTO 2047 CTO 43Y9841 Hinge bracket L R 7462 4Dx 4Ex 4Fx 4Gx 4 7465 CTO 2Ex 2Fx 2Hx 2Jx 2Kx 7469 CTO 58x 59x 5Ax 5Bx 5Cx 5Dx 5Gx 5Hx 5 5Kx 5Ux 5Wx 74x 79x 7 7Bx 7Cx 7Nx 7Rx 7Sx 7Tx 7Yx 7Zx 82x 7470 CTO 5Gx 5Hx 68x 69x 6Ax 6Bx 6Cx 6Dx 6Fx 6Gx 6Hx 6Kx e 7470 CTO 5Gx 5Hx 68x 69x 6Ax 6 6Cx 6Dx 6Fx 6Gx 2046 CTO 2047 CTO 45N3234 182 ThinkPad X200 and X200s Hardware Maintenance Manual Table 41 Parts list 12 1 in WXGA TFT continued No FRU Hinge L R 7462 CTO 4Dx 4Ex 4Fx 4Gx 4 7465 CTO 2Ex 2Fx 2Hx 2 x 2Kx 7469 CTO 58x 59x 5 5Bx 5Cx 5Dx 5Gx 5Hx 5 x 5Kx 5Ux 5Wx 74x 79x 7 Ax 7 7Cx 7Nx 7Rx 7Sx 7Tx 7Yx 7Zx 82x 7470 CTO 5Gx 5Hx 68x 69x 6Ax 6Bx 6Cx 6Dx 6Fx 6Gx 6Hx 6Kx 7470 CTO 5Gx 5Hx 68x 69x 6Ax 6Bx 6Cx 6Dx 6Fx 6Gx 2046 2047 CTO FRU no 45N3233 RoHS ID R CRU ID LCD rear cover assembly e 7462 CTO 4Dx 4Ex 4Fx 4Gx 4Jx 7465 CTO 2Ex 2Fx 2Hx 2Jx 2Kx 7469 CTO 58x 59x 5Ax
40. 34x 35x 36x 38x 39x 3Ax 3Bx 3Cx 3Ex 3Fx 3Gx 3Hx 3 x 3Kx 3Lx 3Mx 3Nx 3Qx 3Rx 3Sx 3Tx 3Ux 3Wx 3Xx 3Yx 3Zx D2x D3x D5x 7457 CTO 42x 43x 44x 45x 46x 47x 48 49x 4 4Dx 4 4Fx 4 4Kx 4Lx 4Nx 4Px 40x 4Rx 45 4 7458 CTO 52x 53x 54x 55x 56x 57x 58x 59x 5Ax 5Bx 5Cx 5Dx 5Ex 5Fx 5Hx 5 x 5Lx 5Mx 5Nx 5Px 5Ox 5Rx 5Sx 5Tx 69x 72x 73x 74x 76x 77x 79x 7Bx 7Cx 7Dx 7Ex 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7 7Px 7 7Rx 78x 7Tx 7Ux 7Yx 7Zx 82x 83x 84x 85x 86x 87x 88x 89x 8Ax 8Bx 8Cx 8Dx 8Ex 8Fx 8Gx 8Hx 8 x 8Kx 8Lx 8Mx 8Px 8 8Rx 8Sx 8Tx 8Wx 8Xx 8Yx 8Zx E2x F2x F3x F4x F7x F8x F9x FAx M2x M3x X4x 7459 CTO 5Ex 5Fx 64x 65x 67x 69x 6Ax 6Bx 6Cx 6Dx 6Ex 6Fx 6Gx 6 6Kx 6 6 60x 6Rx 6Sx 6Ux 6Vx 6Wx 6Xx 6Yx 6Zx H2x E3x M2x M3x 4 2023 CTO 2024 CTO 7462 CTO 42x 43x 44x 45x 46x 47x 48x 49x 4Ax 4Bx 4Cx 4Dx 4Ex 4Fx 4Gx 4Hx 4 4Lx 4Mx 4Nx 4Px 4 4Rx 4Sx 4Tx 7465 CTO 23x 24x 25x 26x 27x 28x 29x 2Dx 2Ex 2Fx 2Hx 2Jx 2Kx 2Lx 2Mx 2Nx 2Px 20x 2Rx 2Sx 2Tx 2Ux 2Xx 7466 CTO 32x 33x 34x 35x 38x 39x 3Ax 3Bx 3Cx 3Dx 3Ex 3Fx 3Gx 3Jx 3Lx 3Mx 3Nx 3Px 3Rx 3Sx 3Tx 3Ux 7469 CTO 52x 53x 54x 55x 56x 57x 58x 59x 5Ax 5Bx 5Cx 5Dx 5Ex 5Gx 5Hx 5 x 5Kx 5Lx 5Mx
41. 55x 57x 5Ax 5Dx 5Gx 5Hx 5 5Kx 5Qx 5Rx 5Sx 5 Tx 5Ux 5Vx 5Wx 73x 74x 76x 77x 79x 7Bx 7Cx 7Fx 7470 CTO 5Gx 5Hx 65x 6Ax 6Dx 6Ex 6Fx 6Gx 6Hx 2046 CTO 2047 CTO 5 System board with Intel Core 2 Duo processor SL9400 42W8101 R N 1 86 GHz AMT non TPM 7462 CTO 7465 CTO 7466 CTO 3Tx 3Ux 7469 CTO 5Fx 7Lx 7Mx 7Nx 7Px 7Rx 7Sx 7 7Ux 7Vx 7Xx 7470 CTO 6 x 6Kx 2046 CTO 2047 CTO 5 System board with Intel Celeron M processor 723 1 2 42W8223 R N GHZ non AMT TPM 7462 CTO 4Ux 4 4Wx 7465 CTO 7466 CTO 7469 CTO 7470 CTO 2046 CTO 2047 CTO 5 System board with Intel Celeron M processor 723 1 2 42W8226 R N GHz 7462 7465 7466 7469 7470 2046 CTO 2047 CTO ThinkPad X200 and X200s 143 Table 39 Parts list Overall continued No FRU FRU no 512 DDR3 1066 SDRAM SO DIMM PC3 8500 43R1775 7454 CTO 7455 CTO 7457 CTO 4Bx 4 7458 CTO 7459 CTO 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 7470 CTO 2046 CTO 2047 CTO 1 GB DDR3 1066 SDRAM SO DIMM PC3 8500 card 43R1989 7454 CTO 23x 24x 25x 26x 28x 29x 2Gx 2Hx 2 x 2Nx 2Px 2Rx 2Sx 2Tx 2Ux 2 2Wx 2 2Yx 92x 93x 97x 98x 9Gx 7455 CTO 33x 36x 39x 3Ax 3Dx 3Ex 3Fx
42. 7454 CTO 7455 CTO 7457 CTO 7458 CTO 7459 CTO 67x 6Wx 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 5 74x 77x 7 7Px 7470 CTO 6Hx 6Kx 2046 CTO 2047 CTO 41W0516 R 16 SATA solid state drive 128 GB 8 mm 7454 CTO 2 9Gx 7455 CTO 3Bx 3Gx 3Ux 7457 CTO 4Fx 7458 CTO 59x 76x 8Px 8 8Rx 8Sx FAx 7459 CTO 6 x 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 5Fx 5Tx 7Yx 7Zx 82x 7470 CTO 2046 CTO 2047 CTO 41W0519 R ThinkPad X200 and X200s 163 Table 39 Parts list Overall continued No 17 FRU FRU no DVD drive 9 5 mm 42 2541 7454 CTO 7455 7457 CTO 7458 7459 2023 2024 7462 7465 CTO 7466 CTO 7469 CTO 7470 CTO 2046 CTO 2047 CTO 17 DVD drive 9 5 mm 42T2511 7454 CTO 7455 CTO 7457 CTO 7458 CTO 7459 CTO 2023 CTO 2024 CTO 7462 7465 CTO 7466 CTO 7469 CTO 7470 CTO 2046 CTO 2047 CTO 17 DVD CD RW combo drive 9 5 mm 42 T2543 7454 7455 CTO 7457 7458 CTO 7Bx 7459 CTO 4 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 5 5Wx 1 7470 CTO E1x 2046 CTO 2047 164 ThinkPad X200 and X200s Hardware Maintenance Manual
43. 8Hx 8 x 8Kx 8Lx 8 85 8 8 8Yx E2x F4x F5x F7x F8x F9x FAx 7459 CTO 62x 63x 64x 65x 66x 67x 68x 69x 6Ax 6Bx 6Dx 6Gx 6 x 6Lx 6Mx 6Nx 6Px 60x 6Rx 6Sx 6Tx 6Ux 6Vx 6Wx 6Xx E3x 2 M4x 2023 CTO 2024 CTO 7462 CTO 46x 4 7465 CTO 27x 2Lx 7466 CTO 34x 35x 3Lx 3Mx 3Nx 3Px 3Rx 3Sx 3Tx 7469 CTO 54x 55x 56x 57x 5Fx 5Lx 5Mx 5Nx 5Px 5Qx 5Rx 5Sx 5 Tx 5 5 5Yx 5Zx 72x 73x 75x 76x 77x 7Ex 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7Mx 7Ux 7Vx 7Xx e 7470 CTO 64x 65x 6Ex 6 x 2046 CTO 2047 CTO 8 Inverter card 42W8009 N 7454 all 7455 all 7457 all 7458 all 7459 2023 CTO 2024 CTO ThinkPad X200 and X200s Hardware Maintenance Manual Table 40 Parts list 12 1 in WXGA TFT continued No FRU Inverter card e 7454 all 7455 7457 e 7458 all 7459 2023 CTO 2024 CTO e 7462 CTO 42x 43x 44x 45x 46x 47x 48x 49x 4Ax 4Bx 4Cx 4 4Lx 4 4Nx 4 4 4Rx 4Sx 4Tx 4Ux 4Vx 4Wx 7465 CTO 23x 24x 25x 26x 27x 28x 29x 2Dx 2Lx 2Mx 2Nx 2Px 2 2Rx 2Sx 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 35x 3Lx 3Mx 3Nx 3Px 3Rx 3Sx 3Tx 7469 CTO 52x 53x 54x 55x 56x 57x 5Ex 5Fx 5Lx 5Mx 5Nx 5Px 5 5Rx 5Sx 5Tx 5Vx 5Xx 5Yx 5Zx 72x 73x 75x 76x 77x 78x 7Dx 7Ex 7Fx 7Gx
44. ANY KIND EITHER EXPRESS OR IMPLIED INCLUDING BUT NOT LIMITED TO THE IMPLIED WARRANTIES OF NON INFRINGEMENT MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE Some jurisdictions do not allow disclaimer of express or implied warranties in certain transactions therefore this statement may not apply to you This information could include technical inaccuracies or typographical errors Changes are periodically made to the information herein these changes will be incorporated in new editions of the publication Lenovo may make improvements and or changes in the product s and or the program s described in this publication at any time without notice The products described in this document are not intended for use in implantation or other life support applications where malfunction may result in injury or death to persons The information contained in this document does not affect or change Lenovo product specifications or warranties Nothing in this document shall operate as an express or implied license or indemnity under the intellectual property rights of Lenovo or third parties All information contained in this document was obtained in specific environments and is presented as an illustration The result obtained in other operating environments may vary Lenovo may use or distribute any of the information you supply in any way it believes appropriate without incurring any obligation to you Any references in this publication to non Lenov
45. FRU you must include the following information in the parts exchange form or parts return form that you attach to it 1 Name and phone number of servicer 2 Date of service 3 Date on which the machine failed 4 Date of purchase 5 Failure symptoms error codes appearing on the display and beep symptoms 6 Procedure index and page number in which the failing FRU was detected 7 Failing FRU name and part number 8 Machine type model number and serial number 9 Customer s name and address Note for warranty During the warranty period the customer may be responsible for repair costs if the computer damage was caused by misuse accident modification unsuitable physical or operating environment or improper maintenance by the customer Following is a list of some common items that are not covered under warranty and some symptoms that might indicate that the system was subjected to stress beyond normal use Before checking problems with the computer determine whether the damage is covered under the warranty by referring to the following list The following are not covered under warranty LCD panel cracked from the application of excessive force or from being dropped Scratched cosmetic parts Distortion deformation or discoloration of the cosmetic parts Plastic parts latches pins or connectors that have been cracked or broken by excessive force Damage caused by liquid spilled into the system Damage caus
46. T9550 2 66 GHz 1066 MHz FSB 6 L2 cache Intel Core 2 Duo processor SU9300 1 2 GHz 800 MHz FSB 3 MB L2 cache Intel Core 2 Duo processor SL9300 1 6 GHz 1066 MHz FSB 6 L2 cache Intel Core 2 Duo processor SL9400 1 86 GHz 1066 MHz FSB 6 L2 cache Intel Celeron M processor 723 1 2 GHz 800 MHz FSB 1 MB L2 cache Bus architecture s 800 MHz or 1066 MHz FSB 1066 MHz DDR3 SDRAM PC3 8500 PCI bus PCI Express bus DMI Graphic memory chip e Display Intel Integrated Graphics 4500MHD 12 1 inch 16M colors WXGA 1280 x 800 resolution TFT color LCD 12 1 inch 16M colors WXGA 1440 x 900 resolution TFT color LCD LED backlight ThinkPad X200s only Standard memory 512 MB DDR3 1066 SDRAM SO DIMM PC3 8500 card T 1 GB DDR3 1066 SDRAM SO DIMM PC3 8500 card x 1 2 GB DDR3 1066 SDRAM SO DIMM PC3 8500 card x 1 Optional memory G 512 MB DDR3 1066 SDRAM SO DIMM PC3 8500 card x il 1 GB DDR3 1066 SDRAM SO DIMM PC3 8500 card x 1 2 GB DDR3 1066 SDRAM SO DIMM PC3 8500 card x 1 maximum of 4 0 GB Extended memory device some models Intel Turbo Memory 2 GB Minicard Intel Turbo Memory 4 GB Minicard CMOS RAM 242 bytes 48 ThinkPad X200 and X200s Hardware Maintenance Manual Table 7 Specifications continued Feature Description Hard disk drive 80 GB 5400 rpm 9 5 mm high SATA interface 160 GB 5400 rpm 9 5 mm high
47. TFT LCD for the notebook computer contains many thin film transistors TFTs The presence of a small number of dots that are missing discolored or always lighted is characteristic of TFT LCD technology but excessive pixel problems can cause viewing concerns The LCD should be replaced if the number of missing discolored or lighted dots in any background is as follows Table 5 Minimum quantity of defective pixels required for LCD replacement on June 2006 or later manufactured ThinkPad LCD resolution Bright dots Dark dots Bright and dark dots XGA WXGA 5 6 6 WXGA 5 5 8 10 WSXGA UXGA WUXGA 5 13 13 QXGA Notes Lenovo will not provide replacement if the LCD is within specification as we cannot guarantee that any replacement LCD will have zero pixel defects A bright dot means a pixel is always on white or color A dark dot means a pixel is always off black color One pixel consists of R G B sub pixels Table 6 LCD related symptoms Symptom or error FRU or action in sequence No beep power on indicator on and a System board blank LCD during POST LCD backlight not working Reseat the LCD connectors LCD too dark 2 LCD assembly LCD brightness cannot be adjusted 3 System board LCD contrast cannot be adjusted LCD screen unreadable 1 See important note for LCD related Characters missing pixels symptoms Scree
48. ThinkPad X200 and X200s 85 Table 19 Removal steps of Intel Turbo Memory Minicard or wireless USB adapter continued oe P LOTR When installing In models with the wireless USB adapter plug the yellow cable into the jack on the card 86 ThinkPad X200 and X200s Hardware Maintenance Manual 1100 Keyboard bezel For access remove these FRUs in order 1010 Battery pack on page 64 1040 Keyboard on page 71 1050 Palm rest or palm rest with fingerprint reader on page 74 Step Screw quantity Color Torque M2 x 5 mm wafer head nylon coated 1 Black 0 181 Nm 1 85 kgfcm In step BH detach the claws Then remove the keyboard bezel in the direction shown by arrow El Attention handling When you service the keyboard bezel avoid any kind of rough When installing Make sure that all the claws are attached firmly ThinkPad X200 and X200s 87 1110 Speaker assembly For access remove these FRUs in order 1010 Battery pack on page 64 1040 Keyboard on page 71 1050 Palm rest or palm rest with fingerprint reader on page 74 When installing Make sure that the speaker connector is attached firmly 88 ThinkPad X200 and X200s Hardware Maintenance Manual 1120 1 card assembly For access remove these FRUs in order 1050 Palm rest or palm rest with fingerprint reader on page 1110 Speaker assembly on pag
49. continued No FRU System board with Intel Core 2 Duo processor P8700 2 53 GHz AMT non TPM 7454 CTO 7455 CTO 7457 CTO 7458 CTO 8Yx 7459 CTO 2023 CTO 2024 CTO FRU no 42W8227 RoHS ID CRU ID System board with Intel Core 2 Duo processor 19400 2 53 GHz AMT TPM 7454 CTO 7455 CTO 7457 CTO 7458 CTO 7459 CTO 2023 CTO 2024 CTO 42W8152 System board with Intel Core 2 Duo processor 19400 2 53 GHz AMT non TPM 7454 CTO 7455 CTO 7457 CTO 7458 CTO 7459 CTO 2023 CTO 2024 CTO 42W8155 System board with Intel Core 2 Duo processor 19400 2 53 GHz non AMT TPM 7454 CTO 7455 CTO 42W8008 System board with Intel Core 2 Duo processor 19400 2 53 GHz 7454 CTO 7455 CTO 42W8098 System board with Intel Core 2 Duo processor T9550 2 66 GHz AMT TPM 7454 CTO 7455 CTO 7457 CTO 7458 CTO 7459 CTO 2023 CTO 2024 CTO 42W8225 System board with Intel Core 2 Duo processor T9550 2 66 GHz AMT non TPM e 7454 CTO 7455 CTO 7457 CTO 7458 CTO 7459 CTO 2023 CTO 2024 CTO 42W8228 ThinkPad X200 and X200s 141 Table 39 Parts list Overall continued No FRU FRU no System board with Intel Core 2 Duo processor SU9300 44 9667 1 2 GHz AMT TPM 7462 CTO 4Dx 4Gx 7465 CTO 2Ex 2Hx
50. cortocircuiti pericolosi FRU ThinkPad Oz ALC AK SOMOS ZEB HOT TCE LIM 280 E ThinkPad ONES CHA CGw72w z b lt lt KAW 21213 ThinkPad RoT DF VDF HY LGR LAV AMER DE BRA IET S bOBEICZRSICSA 0xX T Antes de encender el sistema despues de sustituir una FRU compruebe que todos los tornillos muelles y dem s piezas pequefias se encuentran en su sitio y no se encuentran sueltas dentro del sistema Compru belo agitando el sistema y escuchando los posibles ruidos que provocar an Las piezas met licas pueden causar cortocircuitos el ctricos Safety information 7 8 Safety notice 2 N DANGER Some standby batteries contain a small amount of nickel and cadmium Do not disassemble a standby battery recharge it throw it into fire or water or short circuit it Dispose of the battery as required by local ordinances or regulations Use only the battery in the appropriate parts listing Use of an incorrect battery can result in ignition or explosion of the battery Certaines batteries de secours contiennent du nickel et du cadmium Ne les d montez pas ne les rechargez pas ne les exposez ni au feu ni l eau Ne les mettez pas en court circuit Pour les mettre au rebut conformez vous la r glementation en vigueur Lorsque vous remplacez la pile de sauvegarde ou celle de l horloge temps r el vei
51. date 0251 System CMOS checksum bad Default configuration used Charge the backup battery for more than 8 hours by connecting the ac adapter Replace the backup battery and run BIOS Setup Utility to reset the time and date 0252 Password checksum bad The password is cleared Reset the password by running BIOS Setup Utility 0260 System timer error Charge the backup battery for more than 8 hours by connecting the ac adapter Replace the backup battery and run BIOS Setup Utility to reset the time and date System board 0270 Real time clock error 2 3 Charge the backup battery for more than 8 hours by connecting the ac adapter Replace the backup battery and run BIOS Setup Utility to reset the time and date System board 0271 Date and time error Neither the date nor the time is set in the computer Run BIOS Setup Utility to reset the time and date 0280 Load Setup Default in BIOS Setup Previous boot incomplete Default Utility configuration used 2 DIMM 3 System board 02 0 1 CPU ID xx Failed 2 System board 02 4 1 Load Setup Defaults in BIOS Setup EISA CMOS not writable Utility 2 Replace the backup battery 3 System board 02 5 1 DIMM DMA test failed 2 System board 02 6 1 DIMM Software NMI failed 2 System board 02F7 1 DIMM Fail safe timer NMI failed 2 System board 1802 1 Remove Mini P
52. for DOS The ThinkPad computer has a test program called PC Doctor for DOS hereafter called PC Doctor You can detect errors by running the diagnostics test included in PC Doctor This section is an overview of the procedure For details that depend on model unique functions refer to ThinkPad X200 and X200s on page 47 Note PC Doctor for DOS is available at following Web site http www lenovo com support To create the PC Doctor diagnostic diskette follow the instruction on the Web site For some possible configurations of the computer PC Doctor might not run correctly To avoid this problem you need to initialize the computer setup by use of the BIOS Setup Utility before you run PC Doctor To enter BIOS Setup Utility do as follows 1 Turn on the computer 2 When the ThinkPad logo comes up immediately press F1 to enter the BIOS Setup Utility Note If a supervisor password has been set by the customer BIOS Setup Utility menu appears after the password is entered You can start the utility by pressing Enter instead of entering the supervisor password however you cannot change the parameters that are protected by the supervisor password On the BIOS Setup Utility screen press F9 Enter F10 and then Enter Note When you initialize the computer configuration some devices are disabled such as the serial port If you test one of these devices you will need to enable it by using Configuration uti
53. gt Communication a Conexant Smart Modem Interrupt b Conexant Smart Modem Dialtone N Audio Enter the BIOS Setup Utility and change Serial ATA SATA setting to Compatibility and run Diagnostics gt Other Device gt Conexant Audio Speaker Interactive Tests gt Internal Speaker Note Once Modem Audio test is done the no sound is heard this test In this case turn off and turn on the computer Then run this test again PC Card slot Diagnostics gt Systemboard gt PCMCIA ExpressCard slot Insert a PCI Express USB Wrap card into the ExpressCard slot Turn on the computer Run Diagnostics gt ThinkPad Devices gt ExpressCard slot Keyboard Diagnostics gt Systemboard gt Keyboard Interactive Tests gt Keyboard MEZ N Hard disk drive Enter the BIOS Setup Utility and change Serial ATA SATA setting to Compatibility and run Diagnostics gt Fixed Disks You can also diagnose the hard disk drive without starting up the operating system To diagnose the hard disk drive from the BIOS Setup Utility do as follows 1 Remove any diskette from the diskette drive and then turn off the computer 2 Turn on the computer 3 While the message To interrupt normal startup press the blue ThinkVangate button is displayed at the lower left of the screen press F1 to enter the BIOS Setup Utility 4 Using cursor keys select HDD diagnostic program Press en
54. in Canada should call the Customer Support Center at 800 565 3344 for assistance or download information Strategy for replacing FRUs Before replacing parts Make sure that all software fixes drivers and BIOS downloads are installed before replacing any FRUs listed in this manual After a system board is replaced ensure that the latest BIOS is loaded to the system board before completing the service action To download software fixes drivers and BIOS do as follows 1 Go to http www lenovo com support 2 Enter the product number of the computer or press Auto detect button on the screen 3 Select Downloads and drivers 4 Follow the directions on the screen and install the necessary software Use the following strategy to prevent unnecessary expense for replacing and servicing FRUs O Copyright Lenovo 2008 17 If you are instructed to replace a FRU but the replacement does not correct the problem reinstall the original FRU before you continue Some computers have both a processor board and a system board If you are instructed to replace either the processor board or the system board and replacing one of them does not correct the problem reinstall that board and then replace the other one adapter or a device consists of more than one FRU any of the FRUs may be the cause of the error Before replacing the adapter or device remove the FRUS one by one to see if the symptoms chang
55. locally if necessary to insulate you from grounds such as metal floor strips and machine frames Observe the special safety precautions when you work with very high voltages Instructions for these precautions are in the safety sections of maintenance information Use extreme care when measuring high voltages Regularly inspect and maintain your electrical hand tools for safe operational condition Do not use worn or broken tools and testers Never assume that power has been disconnected from a circuit First check that it has been powered off Always look carefully for possible hazards in your work area Examples of these hazards are moist floors nongrounded power extension cables power surges and missing safety grounds Safety information 3 Do not touch live electrical circuits with the reflective surface of a plastic dental mirror The surface is conductive such touching can cause personal injury and machine damage Do not service the following parts with the power on when they are removed from their normal operating places in a machine Power supply units Pumps Blowers and fans Motor generators and similar units This practice ensures correct grounding of the units f an electrical accident occurs Use caution do not become a victim yourself Switch off power Send another person to get medical aid 4 ThinkPad X200 and X200s Hardware Maintenance Manual Safety inspection guide
56. mm wafer head nylon coated 1 Silver 0 181 Nm ThinkPad X200 and X200s 1 85 kgfcm 107 Table 27 Removal steps of system board DC in connector fan and ExpressCard slot assembly for ThinkPad X200s continued When installing Before you attach the fan assembly to the computer apply thermal grease at an amount of 0 2 grams on the part marked BH as in the following figure Either too much or too less application of grease can cause a thermal problem due to imperfect contact with a component You need to peel the thin film off from the rubber Make sure that the fan connector is attached firmly Note The ExpressCard slot assembly is attached to the system board Step Screw quantity Color Torque M2 x 3 5 mm wafer head nylon coated 1 Silver 0 181 Nm 1 85 kgfcm 108 ThinkPad X200 and X200s Hardware Maintenance Manual Table 27 Removal steps of system board DC in connector fan ExpressCard slot assembly for ThinkPad X200s continued Turn the system board over and then remove the ExpressCard slot assembly from the system board ThinkPad X200 and X200s 109 2010 LCD front bezel For access remove this FRU e 171010 Battery pack on page 64 Table 28 Removal steps of LCD front bezel for 12 1 in WXGA LCD model 12 1 in WXGA LCD model Step Screw cap Screw quantity Color Torque Q M2 5 x 4 mm wafer head Blac
57. two antenna connectors plug the gray cable into the jack labeled MAIN on the card and the black cable into the jack labeled AUX If the computer you are servicing has three cables put the white cable in the cable protection tube In models with wireless LAN card that has three antenna connector plug the gray cable MAIN into the jack labeled TR1 the white cable 3rd into jack labeled R0 or and the black cable AUX into jack labeled TR2 on the card 80 ThinkPad X200 and X200s Hardware Maintenance Manual Table 17 Removal steps of PCI Express Mini Card for wireless LAN continued Harf size PCI Express Mini Card In step unplug the jacks by using the removal tool antenna RF connector P N 08K7159 or pick the connectors with your fingers and gently unplug them in direction of the arrow Step Screw quantity Torque M2 x 3 mm wafer head nylon coated 2 0 181 Nm 1 85 kgfcm ThinkPad X200 and X200s 81 Table 17 Removal steps of PCI Express Mini Card for wireless LAN continued When installing Plug the gray cable into the jack labeled MAIN on the card and the black cable into the jack labeled AUX 82 ThinkPad X200 and X200s Hardware Maintenance Manual 1080 PCI Express Mini Card for wireless WAN For access remove these FRUs in order 1010 Battery pack on page 64 1040 Keyboard on page 71 1050 Palm rest or palm rest with fingerprint reader on page 74
58. 024 7462 7465 7466 7469 CTO 73x 79x 7Bx 7 7Xx 7470 CTO 6Ex 6 x 2046 2047 13 SATA hard disk drive 320 GB 9 5 mm 5 400 rpm 42 1535 7454 CTO 7455 3Hx 3Nx 3Vx 3Xx D2x D3x 7457 CTO 7458 CTO 7Kx 7Ux 8Tx 8Wx 8Xx 8Yx F3x F8x F9x 7459 6Px 6 6Xx 2023 CTO 2024 7462 7465 7466 7469 73x 79x 7Bx 7Fx 7Xx 7470 CTO 6Ex 6 x 2046 2047 158 ThinkPad X200 and X200s Hardware Maintenance Manual Table 39 Parts list Overall continued No 13 FRU SATA hard disk drive 320 GB 9 5 mm 5 400 rpm 7454 CTO 7455 CTO 3Hx 3Nx 3Vx 3Xx 3Yx D2x D3x 7457 CTO 7458 CTO 7Kx 7Ux 8Tx 8Wx 8Xx 8Yx F3x F8x F9x 7459 CTO 6Px 60x 6Xx 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 73x 79x 7Bx 7Fx 7Xx 7470 CTO 6Ex 6 x 2046 CTO 2047 CTO 42T1583 FRU no RoHS ID CRU ID 13 SATA hard disk drive 100 GB 9 5 mm 7 200 rpm OP 7454 CTO 2Sx 93x 7455 CTO 3Fx 3Rx 7457 CTO 7458 CTO 7Gx 7459 CTO 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 3Kx 3Ox 7469 CTO 7470 CTO 2046 CTO 2047 CTO 42T1485 13 SATA hard disk drive 100 GB 9 5 mm 7 200 rpm 7454 CTO 2Sx 93x 7455 CTO 3Fx 3Rx 7457 CTO
59. 046 CTO 2047 CTO ThinkPad X200 and 2008 191 Table 50 Parts list Windows Vista Business 32 bit DVDs Language P N RoHS CRU ID ID Brazilian Portuguese 46V3560 N Czech 46V3563 Danish 46V3564 English 46V3586 English modem disabled 46V3585 French 46V3565 German 46V3567 Greek 46V3566 Hebrew 46V3568 Hungarian 46V3570 Italian 46V3571 Japanese 46V3572 Korean 46V3573 Norwegian 46V3574 Polish 46V3575 Portuguese 46V3576 Romanian 46V3578 Russian 46V3579 Russian English enabled 46V3577 Serbian Latin 46V3583 Simplified Chinese 46V3561 Slovak 46V3580 Slovenian 46V3581 Spanish 46V3582 Traditional Chinese 46 3562 Traditional Chinese Hong Kong S A R 46V3569 Turkish 46V3584 192 ThinkPad X200 and X200s Hardware Maintenance Manual Windows Vista Business 64 bit DVDs Windows Vista Business 64 bit is preinstalled as the operating system in the following models e 7454 CTO e 7455 CTO e 7457 e 7458 CTO 7459 6 6Ux 6Vx 6 6Wx 7Px e 2023 CTO e 2024 CTO e 7462 CTO e 7465 CTO 7466 CTO e 7469 CTO e 7470 CTO e 2046 e 2047 CTO Table 51 Parts list Windows Vista Business 32 bit DVDs Language P N RoHS ID CRU ID English 46V3642 English modem disabled 46V3641 German Japanese 46V3639 46V3640 Simp
60. 2047 CTO Table 48 Parts list Windows Vista Home Basic 32 bit DVDs Language P N RoHS CRU ID ID English 46V3595 N Japanese 46V3593 Korean 46V3594 Simplified Chinese 46V3590 Traditional Chinese 46V3591 Traditional Chinese Hong Kong S A R 46V3592 ThinkPad X200 and X200s 189 Windows Vista Home Premium 32 bit DVDs Windows Vista Home Premium 32 bit is preinstalled as the operating system in the following models 7454 CTO 29x 7455 CTO e 7457 CTO 48x 4Wx 7458 CTO e 7459 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 3Fx 7469 CTO 7470 CTO 2046 CTO 2047 CTO Table 49 Parts list Windows Vista Home Premium 32 bit DVDs Language P N RoHS CRU ID ID Danish 46 3598 N English 46V3611 English modem disabled 46V3610 French 46V3599 German 46V3600 Hebrew 46V3601 Italian 46V3603 Japanese 46V3604 Korean 46V3605 Norwegian 46V3606 Russian 46V3608 Russian English enabled 46V3607 Simplified Chinese 46V3596 Spanish 46V3609 Traditional Chinese 46V3597 Traditional Chinese Hong Kong S A R 46V3602 190 ThinkPad X200 and X200s Hardware Maintenance Manual Windows Vista Business 32 bit DVDs Windows Vista Business 32 bit is preinstalled as the operating system in the following models 7454 CTO 22x 23x 24x 25x 26x 27x 28x 2 x 2Kx 2Lx 2
61. 3768 4213702 Bulgarian 42T4143 42T4139 Canadian French 058 4213739 4213673 Canadian French 4213738 4213672 Czech 42T3757 42T3691 Danish 42T3746 4213680 Dutch 42T3743 4213677 Finnish Swedish 42T3744 42T3678 French 4213742 4213676 42713740 4213674 Greek 0 5 English and Greek layout 42 3759 4213693 Hebrew 4213754 4213688 Hungarian 42T3758 4213692 Icelandic 42T3769 4213703 Italian 42T3747 42T3681 Japanese 42 3762 42 3696 Kazakhstan 4274136 4274133 4213764 4213698 Latin American Spanish 4213765 42T3699 Norwegian 42713745 4213679 Polish 4213755 4213689 Portuguese 4213751 4213685 Russian 42T3753 4213687 Slovak 42T3761 4213695 Slovenian 42T3760 42T3694 Spanish 42T3748 42T3682 Swiss 4213750 4213684 Thai 42T3766 4213700 Traditional Chinese 4213763 4213697 Turkish 4213756 4213690 U K English 42T3741 4213675 0 5 English 4213737 4213671 0 5 English International with Euro 4213767 4213701 symbol 184 ThinkPad X200 and X200s Hardware Maintenance Manual Miscellaneous parts Table 43 Parts list Miscellaneous parts FRU P N RoHS CRU ID ID Screw kit 44C9558 R N Base cover miscellaneous parts kit 44C9556 R N Dummy cover RJ 11 connector Knob Wireless WAN Knob screw Wireless WAN Latch battery Latch spring battery System miscellaneous parts kit 44C9557 R N a Top shielding assembly Holder Heat sink O bracket VGA n
62. 3Kx 3Lx 3Px 3Qx 3Rx 7457 CTO 44x 45x 47x 48x 49x 4Ax 4Ex 4Gx 4 4Kx 4Lx 4Mx 4Nx 4Px 4 4Vx 4Wx 7458 CTO 54x 55x 56x 5Ax 5Ex 5Px 5Ox 5Rx 5Sx 69x 73x 78x 79x 7Ex 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7 7 7Rx 78x 7Vx 7Wx 7 7Yx 83x 84x 8Bx 8Ex 8Fx 8Gx 8 F5x M2x M3x 7459 CTO 5Ex 62x 63x 64x 68x 69x 6Cx 6Dx 6Fx 6Lx 6Mx 6Rx 6Sx 6Tx 6Ux 6Yx 6Zx H2x M2x M3x 2023 CTO 2024 CTO 7462 CTO 42x 4 4Lx 4Nx 4Px 4 4Sx 4Tx 4Ux 4Vx 7465 CTO 23x 2Lx 2Mx 2Px 20x 2Rx 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 3Kx 3Qx 3Mx 3Px 7469 CTO 52x 75x 76x 77x 7Ax 7Bx 7Dx 7Ex 7Fx 7Hx 7Kx 7Xx 1 7470 CTO 62x 1 2046 CTO 2047 CTO 144 ThinkPad X200 and X200s Hardware Maintenance Manual Table 39 Parts list Overall continued No FRU 2 GB DDR3 1066 SDRAM SO DIMM PC3 8500 card 7454 CTO 22x 27x 2Kx 2Lx 2Mx 20x 2Zx 95x 96x 9Bx 9Cx 9Fx 9Gx 7455 CTO 32x 34x 35x 38x 3Bx 3Cx 3Gx 3Hx 3 3Mx 3Nx 3Sx 3Tx 3Ux 3Vx 3Wx 3Xx 3Yx 3Zx D2x D3x D5x 7457 CTO 42x 43x 46x 4Cx 4Dx 4Fx 4Rx 4Sx 4Tx 4Ux 7458 CTO 52x 53x 57x 58x 59x 5Bx 5Cx 5Dx 5Fx 5Hx 5Jx 5Lx 5Mx 5 5Tx 72x 74x 76x 77x 7Bx 7Cx 7Dx 7Nx 7Px 7Tx 7Ux 7Zx 82x 85x 86x 87x 88x 89x 8Ax 8Cx 8Dx 8Hx 8Kx 8Lx 8Mx 8Nx 8Px 8 8Rx 89 8Tx 8W
63. 3Wx 7457 CTO 45x 48x 49x 4 4 4Hx 4Lx 4Mx 4Px 4 4Vx 7458 53x 55x 56x 57x 5 5 5Lx 5Ox 69x 73x 78x 7Ex 7Lx 7Mx 7 7Rx 7Vx 7Wx 83x 86x 89x 8Ax 8Bx 8Cx 8Fx 8Gx 8Hx 8Lx 8Nx E2x M2x M3x X4x X5x 7459 CTO 5Ex 62x 68x 69x 6Bx 6Cx 6Dx 6Fx 6Lx 6Sx 6Yx 6Zx H2x E3x M2x M3x 2023 CTO 2024 CTO 7462 CTO 42x 43x 44x 45x 46x 4Dx 4Ex 4Kx 4Nx 4Px 4Sx 4Tx 4Ux 7465 CTO 23x 24x 25x 26x 27x 2Ex 2Fx 2Lx 2Px 2Qx 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 38x 39x 3Fx 3Lx 3Mx 3Nx 3Px 7469 CTO 52x 53x 54x 56x 58x 59x 5Gx 5Lx 5Mx 5Xx 5Yx 7Dx 7Gx 7Hx 7 x 7Kx 7Rx 7470 5Gx 62x 63x 64x 68x 69x 6Fx 2046 CTO 2047 CTO 154 ThinkPad X200 and X200s Hardware Maintenance Manual Table 39 Parts list Overall continued No FRU FRU no RoHS ID ID 13 SATA hard disk drive 160 GB 9 5 mm 5 400 rpm 42 1501 R 7454 CTO 25x 26x 29x 2Gx 2Hx 2Nx 2Rx 2Ux 2Vx 2Xx 2Yx 92x 95x 97x 98x 9Fx 7455 CTO 35x 36x 39x 3Ax 3Dx 3Jx 3Kx 3Px 3Wx 7457 CTO 45x 48x 49x 4Ax 4Bx 4Hx 4Lx 4Mx 4Px 4 4Vx 7458 CTO 53x 55x 56x 57x 5Ax 5Ex 5Lx 5Ox 69x 73x 78x 7 7Lx 7Mx 7Px 7Rx 7Vx 7Wx 83x 86x 89x 8Ax 8Bx 8Cx 8Fx 8Gx 8Hx 8Lx 8Nx E2x M2x M3x X4x X5x 7459 CTO 5Ex 62x 68x 69x 6Bx 6Cx 6Dx 6Fx 6Lx 6Sx 6Yx 6Zx H2x
64. 462 CTO 49x 4Ax 7465 CTO 7466 CTO 7469 CTO 7470 CTO 2046 CTO 2047 CTO RoHS CRU Ericsson F3507g USA Wireless WAN card 43Y6477 7454 CTO 2Nx 2Px 20x 2Zx 7455 CTO 7457 CTO 7458 CTO 5 7Cx 88x 7459 CTO 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 7470 CTO 2046 CTO 2047 CTO Ericsson F3507g Other Wireless WAN card 43Y6513 7454 CTO 7455 CTO 3Sx 3Xx 7457 CTO 7458 CTO 5 5Px 5Sx 5 Tx 7Zx 85x 7459 CTO 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 3Rx 7469 CTO 5Lx 5Mx 5Nx 5Px 5Rx 5Sx 5Tx 5Xx 5Yx 5Zx 72x 73x 7Lx 7Mx 7470 CTO 2046 CTO 2047 CTO 146 ThinkPad X200 and X200s Hardware Maintenance Manual Table 39 Parts list Overall continued No FRU ThinkPad 11b g Wireless LAN Mini PCI Express Adapter III 7454 CTO 2Rx 92x 7455 CTO 3Dx 3Px 7457 CTO 7458 CTO 57x 5 78x 7459 CTO 6Lx 65 2023 CTO 2024 7462 4Ux 7465 21 2 2Wx 7466 3 7469 7470 2046 2047 FRU no 43Y6511 RoHS ID R CRU ID Intel WiFi Link 5100 7454 CTO 26x 29x 2Gx 2Hx 2Nx 2Px 20x 2Sx 2Wx 2Xx 2Yx 2Zx 93x 95x 97x 98x 9Gx 7455 CTO 36x 39x 3Ex 3Fx 3Kx 3Rx 3Ux 3Vx 3Wx D5x 7457 CTO 45x 48x 4A
65. 470 CTO 2046 CTO 2047 CTO 13 SATA hard disk drive 250 FDE 9 5 mm 7 200 rpm 42T1573 7454 7455 7457 CTO 7458 CTO 7459 CTO 2023 CTO 2024 CTO 7462 7465 CTO 7466 CTO 7469 CTO 7470 CTO 2046 CTO 2047 CTO 14 Hard disk drive cover assembly 44 9553 15 1 8 inch 2 5 inch storage converter 42W8019 R m 7454 CTO 24x 2Kx 2 9Gx 7455 CTO 34x 38x 3Bx 3Gx 3Ux 7457 CTO 4Cx 4Ex 4Fx 7458 CTO 59x 72x 74x 76x 8Px 80x 8Rx 8Sx FAx 7459 CTO 67x 6Ex 6Gx 6 x 6Wx 2023 CTO 2024 CTO 7462 CTO 4Gx 4Hx 4Jx 7465 CTO 2Hx 2Jx 2Kx 7466 CTO 3Bx 3Cx 3Dx 7469 CTO 5Bx 5Cx 5Dx 5Fx 5 x 5Sx 5Tx 5Vx 74x 77x 7Cx 7Mx 7Px 7Vx 7Yx 7Zx 82x 7470 CTO 6Bx 6Cx 6Dx 6Hx 6Kx 2046 CTO 2047 CTO 162 ThinkPad X200 and X200s Hardware Maintenance Manual Table 39 Parts list Overall continued No FRU 16 SATA solid state drive 64 GB 8 mm 7454 CTO 24x 2Kx 7455 CTO 34x 38x 7457 4Cx 4Ex 7458 CTO 72x 74x 7459 CTO 6Ex 6Gx 2023 CTO 2024 CTO e 7462 CTO 4Gx 4Hx 4Jx 7465 CTO 2Hx 2Jx 2Kx 7466 CTO 3Bx 3Cx 3Dx 7469 CTO 5Bx 5Cx 5Dx 59 5Vx 7 7Vx 7470 CTO 6Bx 6Cx 6Dx 2046 CTO 2047 FRU no 42W0520 RoHS ID R CRU ID 16 SATA solid state drive 80 GB 8 mm
66. 4Gx 4 4Lx 4Mx 4Nx 4Px 4 4Rx 45 4Tx 4Ux 4 4Wx 7465 CTO 23x 24x 2Ex 2Hx 2Mx 2Nx 2Px 2 2Rx 2Sx 2Tx 2Ux 2Xx 7466 CTO 32x 33x 38x 3Bx 3Rx 3Sx 7469 CTO 52x 53x 58x 5Bx 5Hx 74x 75x 76x 77x 78x 79x 7 Ax 7Bx 7Dx 7 7Fx 75 7Xx 7Zx 7470 CTO 5Hx 62x 63x 68x 6Bx 6Gx 6Hx 6Kx 2046 CTO 2047 CTO 150 ThinkPad X200 and X200s Hardware Maintenance Manual Table 39 Parts list Overall continued No 11 FRU Battery pack 6cell 7454 CTO 22x 23x 24x 25x 27x 28x 2Hx 2 x 2Kx 2Lx 2Mx 2Px 20x 2Rx 25 2Tx 2Ux 2Vx 27 92x 93x 96x 98x 9Gx 7455 CTO 32x 33x 34x 35x 38x 39x 3Ax 3Bx 3Cx 3Dx 3Fx 3Gx 3Hx 3 x 3Lx 3Mx 3Nx 3Px 3Rx 35 3Tx 3Ux 3Vx 3Wx 3Zx D2x D3x 7457 CTO 42x 43x 44x 46x 47x 49x ACx 4 4 4Fx 4 4Lx 4Mx 7458 CTO 52x 53x 54x 56x 57x 58x 5Ex 5Fx 5Mx 5Nx 5Px 5Rx 5Sx 5Tx 69x 72x 73x 74x 76x 77x 78x 79x 7Dx 7 7Nx 7 7Qx 79 7Tx 7Ux 7Zx 82x 84x 85x 86x 87x 8Ax 8Bx 8Dx 8Ex 8Fx 8Gx 8Hx 8 x 8Kx 8Lx 8Mx 8Nx 8Px 80x 8Rx 8Sx 8Tx 8Wx 8Xx 8Yx E2x F9x FAx M3x X4x 5 7459 CTO 5 5 64x 69x 6Ax 6Bx 6Dx 6Ex 6Fx 6Gx 6 x 6Kx 6Lx 6Mx 6Ux 6Zx H2x E3x M3x 2023 CTO 2024 CTO 7462 CTO 44x 45x 46x 47x 48x 49x 4Ax 4Bx 4Cx 4Ex 4Fx 4 7465 CTO
67. 5Sx 5Tx 69x 72x 74x 76x 78x 79x 7Bx 7Cx 7Dx 7 x 7Kx 7Nx 7Px 7Qx 7Rx 7Sx 7Tx 7Ux 7Wx 7Xx 7Yx 7Zx 82x 83x 84x 85x 86x 87x 88x 89x 8Cx 8Dx 8Ex 8Fx 8Gx 8Hx 8 x 8Kx 8Lx 8 8Px 80x 8Rx 8 8Wx 8Xx 8Yx 2 F3x F4x F5x Fox F7x F8x F9x FAx M3x 7459 CTO 5Fx 62x 63x 64x 65x 66x 67x 68x 69x 6Ax 6Bx 6Cx 6Ex 6Gx 6 x 6Lx 6Mx 6Nx 6Px 6Qx 6Sx 6Tx 6Ux 6Vx 6Wx 6Xx 6Zx H2x M3x 4 2023 CTO 2024 CTO 24 Palm rest assembly without fingerprint reader 25W for 44C9670 R X200s 7462 CTO 4Ux 4 4Wx 7465 CTO 2Vx 2Wx 7466 CTO 3Kx 7469 CTO 79x 7Dx 7Zx E1x 7470 CTO E1x 2046 CTO 2047 CTO ThinkPad X200 and X200s 169 Table 39 Parts list Overall continued No 24 FRU Palm rest assembly with fingerprint reader 25W for X200s 7462 CTO 42x 43x 44x 45x 46x 47x 48x 49x 4Ax 4Bx 4Cx 4Dx 4Ex 4Fx 4Gx 4Jx 4 4Lx 4Mx 4Nx 4Px 4 4Rx 4Sx 4Tx 7465 CTO 23x 24x 25x 26x 27x 28x 29x 2Dx 2Ex 2Fx 2Hx 2Jx 2Kx 2Lx 2Mx 2Nx 2Px 20x 2Rx 25 2Tx 2Ux 2Xx 7466 CTO 32x 33x 34x 35x 38x 39x 3Ax 3Bx 3Cx 3Dx 3Ex 3Fx 3Gx 3Hx 3 x 3Lx 3Mx 3Nx 3Px 3Rx 3Sx 3Tx 3Ux 7469 CTO 52x 53x 54x 55x 56x 57x 58x 59x 5Ax 5Bx 5Cx 5Dx 5Ex 5Gx 5Hx 5 5Kx 5Lx 5Mx 5Nx 5Px 5Ox 5Rx 5Sx 5Tx 5Ux 5Vx 5Wx 5Xx 5Yx 5Zx
68. 65x 6Ex 6 x E1x 2046 CTO 2047 CTO FRU no 44C9541 RoHS ID R CRU ID LCD bracket L R 7454 all 7455 all 7457 all 7458 all 7459 all 2023 CTO 2024 CTO 7462 CTO 42x 43x 44x 45x 46x 47x 48x 49x 4Ax 4Bx 4Cx 4 4Lx 4 4Nx 4 4 4Rx 4Sx 4Tx 4Ux 4Vx AWx 7465 CTO 23x 24x 25x 26x 27x 28x 29x 2Dx 2Lx 2Mx 2Nx 2Px 2 2Rx 2Sx 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 35x 3Lx 3Mx 3Nx 3Px 3Rx 3Sx 3Tx 7469 CTO 52x 53x 54x 55x 56x 57x 5 5Fx 5Lx 5 5Nx 5Px 5 5Rx 5Sx 5Tx 5Vx 5 5Yx 5Zx 72x 73x 75x 76x 77x 78x 7Dx 7Ex 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7Mx 7Qx 7Ux 7Vx 7Xx 1 e 7470 CTO 62x 63x 64x 65x 6Ex 6 x 1 2046 CTO 2047 CTO 44C9545 172 ThinkPad X200 and X200s Hardware Maintenance Manual Table 40 Parts list 12 1 in WXGA TFT continued No FRU Wireless LAN antenna kit 7454 CTO 26x 29x 2Gx 2Hx 2Kx 2Lx 2Rx 2Wx 2Xx 2Yx 92x 95x 97x 98x e 7455 CTO 36x 38x 39x 3Cx 3Fx 3Gx 3Hx 3 x 3Kx 3Rx 3Ux 3Vx 3Wx D5x 7457 CTO 45x 48x 4Ax 4Cx 4Dx 4Gx 4Hx 4Nx 4Px 4 4Ux 4Vx AWx 7458 CTO 55x 57x 58x 5Ex 5Fx 72x 73x 77x 7Lx 7 7Rx 7Vx 87x 8Ax 8Bx 8Gx 8Mx 8Nx 8Zx F2x F3x F4x F5x F6x F7x F8x F9x FAx M2x M3x X5x 7459 CTO 5Ex 5Fx 6Cx 6Ex 6Fx 6Kx
69. 7Hx 7 x 7Kx 7Lx 7Mx 7 7Ux 7Vx 7Xx E1x e 7470 CTO 62x 63x 64x 65x 6Ex 6 x 1 2046 CTO 2047 CTO FRU no 42W8010 RoHS ID R CRU ID ThinkPad X200 and 2008 177 Table 40 Parts list 12 1 in WXGA TFT continued No FRU Bluetooth daughter card BDC 2 1 7454 CTO 22x 23x 24x 25x 26x 27x 28x 29x 2Gx 2Hx 2 2 2Lx 2Mx 2Nx 2Px 20x 2Rx 28x 21 2Ux 2Vx 2Wx 2Xx 2Yx 2Zx 92x 93x 95x 96x 97x 98x 9Bx 9Cx 9Fx 9Gx 7455 CTO 32x 33x 34x 35x 36x 38x 39x 3Ax 3 3Cx 3Dx 3Ex 3Fx 3Gx 3Hx 3Kx 3Lx 3Mx 3Nx 3Px 3Ox 3Rx 3Sx 3Tx 3Ux 3Vx 3Wx 3Xx 3Yx 3Zx D2x D3x D5x 7457 CTO 42x 43x 44x 45x 46x 47x 48x 49x 4Bx 4Cx 4Dx 4Ex 4Fx 4Jx 4Kx 4Lx 4Mx 4Nx 4Px 4Qx 4Rx 4Sx 4Tx 4Wx 7458 CTO 52x 53x 54x 55x 56x 57x 58x 59x 5Ax 5Bx 5Cx 5Dx 5Ex 5Fx 5Hx 5 5Lx 5Mx 5Nx 5Px 5Qx 5Rx 5Sx 5Tx 69x 72x 73x 74x 76x 77x 78x 79x 7Bx 7Cx 7Dx 7 7Fx 7Gx 7Hx 7 x 7Kx 7Nx 7 7 7Rx 79 7 7Ux 7Wx 7Xx 7Yx 7Zx 82x 83x 84x 85x 86x 87x 88x 89x 8Ax 8Bx 8Cx 8Dx 8Ex 8Fx 8Gx 8Hx 8 x 8Kx 8Lx 8Mx 8Px 80x 8Rx 8Tx 8Wx 8Xx 8Yx 8Zx E2x F2x F3x 4 F5x F6x F7x F8x F9x FAx M2x M3x 7459 CTO 5Ex 5Fx 62x 63x 64x 65x 66x 67x 68x 69x 6Ax 6Bx 6Cx 6Dx 6Ex 6Fx 6Gx 6 x 6Kx 6Lx 6 6Nx 6Px 60x 6Rx 6Sx
70. 7Xx 1 7470 CTO 62x 63x 64x 65x 6Ex 6 x E1x 2046 CTO 2047 CTO 44C9909 R ThinkPad X200 and 2008 175 176 Table 40 Parts list 12 1 in WXGA TFT continued 7462 CTO 42x 43x 44x 45x 46x 47x 48x 49x 4Ax 4Bx 4Cx 4 4Lx 4 4Nx 4 4 4Rx 4Sx 4Tx 4Ux 4Vx 4Wx 7465 CTO 23x 24x 25x 26x 27x 28x 29x 2Dx 2Lx 2Mx 2Nx 2Px 2 2Rx 2Sx 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 35x 3Lx 3Mx 3Nx 3Px 3Rx 3Sx 3Tx 7469 CTO 52x 53x 54x 55x 56x 57x 5Ex 5Fx 5Lx 5Mx 5Nx 5Px 5 5Rx 5Sx 5Tx 5Vx 5Xx 5Yx 5Zx 72x 73x 75x 76x 77x 78x 7Dx 7Ex 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7Mx 7Qx 7Ux 7Vx 7Xx 1 e 7470 CTO 62x 63x 64x 65x 6Ex 6 x 1 2046 CTO 2047 CTO No FRU FRU RoHS ID ID 7 Integrated camera 42W8015 R N 7454 CTO 23x 24x 25x 28x 2Jx 2Mx 20x 25 2Tx 2Ux 2Vx 2Zx 93x 96x 9Bx 9Cx 9Gx 7455 CTO 33x 34x 35x 3Ax 3Bx 3Dx 3Ex 3Lx 3 3Nx 3Px 3Sx 3Tx 3Xx 3Zx D2x D3x e 7457 CTO 43x 44x 47x 49x 4Ex 4Fx 4Jx 4Kx 4Lx 4Mx 4Rx 4Sx 4Tx 4Wx 7458 CTO 52x 53x 54x 56x 59x 5Ax 5Bx 5Cx 5Dx 5Mx 5Nx 5Px 5 5Rx 5Sx 5Tx 69x 74x 76x 78x 79x 7Bx 7Dx 7Ex 7Fx 7Gx 7Hx 7 x 7Kx 7Nx 7Px 7Qx 79 7Tx 7 7Wx 7Xx 7 7Zx 82x 83x 84x 85x 86x 89x 8Dx 8Ex 8Fx
71. 7x F8x F9x FAx M2x M3x X4x X5x 7459 CTO 5Ex 5Fx 62x 63x 64x 65x 66x 67x 68x 69x 6Ax 6Bx 6Cx 6Dx 6Ex 6Fx 6Gx 6 x 6Kx 6Lx 6Mx 6Nx 6Px 60x 6Rx 6Sx 6Tx 6Ux 6Vx 6Wx 6Xx 6Yx 6Zx E3x H2x M2x M3x 4 2023 CTO 2024 CTO 21 assembly NV 35 for X200 44C9550 IR N 7454 CTO 7455 CTO 7457 CTO 7458 CTO 7459 CTO 2023 CTO 2024 CTO ThinkPad X200 and 2008 167 Table 39 Parts list Overall continued No FRU FRU no RoHS CRU 21 assembly LV for X200s 45N3235 N 7462 CTO 42x 43x 44x 45x 46x 47x 48x 49x 4 4Bx 4Cx 4Ex 4Fx 4Hx 4Jx 4Kx 4Lx 4Mx 4Nx 4Px 4 4Rx 4Sx 4Tx 7465 CTO 23x 24x 25x 26x 27x 28x 29x 2Dx 2Fx 2 x 2Kx 2Lx 2Mx 2Nx 2Px 20x 2Rx 2Sx 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 35x 39x 3Ax 3Cx 3Dx 3Ex 3Gx 3Hx 3Kx 3Lx 3Mx 3Nx 3Px 3Rx 3Sx 3Tx 3Ux 7469 CTO 52x 53x 54x 55x 56x 57x 59x 5 5Cx 5Dx 5Ex 5Gx 5Hx 5 x 5Kx 5Lx 5Mx 5Nx 5Px 5Qx 5Rx 5Sx 5Tx 5Ux 5Vx 5Wx 5Xx 5Yx 5Zx 72x 73x 74x 75x 76x 77x 78x 79x 7Ax 7Bx 7 7Dx 7Ex 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7Mx 7Nx 7Px 7Qx 7Rx 79 7Tx 7Ux 7Vx 7Xx 7Yx 7Zx 82x 1 7470 CTO 5Gx 5Hx 62x 63x 64x 65x 69x 6Ax 6Cx 6Dx 6Ex 6Fx 6Gx 6Hx 6 x 6Kx E1x 2046 CTO 2047 CTO 21 assembly ULV
72. CD model continued Cable routing Place the antenna assembly as shown in this figure Wireless WAN antenna AUX blue Wireless LAN antenna AUX black Wireless USB antenna yellow MIMO antenna white Wireless LAN antenna MAIN gray Wireless WAN antenna MAIN red SUP 69 e 5 Attention As you route the antenna cables make sure that they are not subjected to any tension Tension could cause the cables to be damaged by the cable guides or a wire to be broken 128 ThinkPad X200 and X200s Hardware Maintenance Manual Table 38 Removal steps of LCD rear cover and wireless antenna cables for 12 1 in WXGA LCD model 12 1 in WXGA LCD model In step f release the antenna cables from the cable guides of the rear cover Note Wireless antennas are secured with double faced adhesive tapes ThinkPad X200 and X200s 129 Table 38 Removal steps of LCD rear cover and wireless antenna cables for 12 1 in WXGA LCD model continued Cable routing Place the antenna assembly as shown in this figure EB Wireless LAN antenna AUX black Wireless USB antenna yellow MIMO antenna white Wireless LAN antenna MAIN gray E a ae 1 9 Attention As you route the antenna cables make sure that they are not subjected to any tension Tension cou
73. CI network card Unauthorized network card is plugged in Turn off and remove the miniPCI network card N System board 1803 Unauthorized daughter card is plugged in Turn off and remove the daughter card Remove the daughter card that you installed System board Related service information 41 Table 1 Numeric error codes continued Symptom or error FRU or action in sequence 1804 Unauthorized WAN card is plugged in Power off and remove the WAN card 1 Remove the WAN card that you installed 2 System board 1805 Unauthorized Wireless USB card is plugged in Power off and remove the Wireless USB card 1820 More than one external fingerprint reader is attached Power off and remove all but the reader that you set up within your main operating system 1 Remove the Wireless USB card that you installed 2 System board Remove all but the reader that you set up for the authentication 1830 Invalid memory configuration Power off and install memory module to Slot 0 or the lower slot Install DIMM in Slot 0 but not in Slot 1 Note For the construction of the DIMM slot see 1030 DIMM on page 69 2000 Hard Drive Active Protection sensor diagnostics failed Press Esc to continue Press F1 to enter SETUP 1 Place the ThinkPad computer on a horizontal surface Do not apply any physical shock to the computer 2 Run Diagnostics Thi
74. Cx 4Ex 4Fx 4Hx 4 7465 CTO 25x 26x 27x 28x 29x 2Dx 2Fx 2Jx 2Kx 2Lx 2Vx 2Wx 7466 CTO 34x 35x 39x 3Ax 3Cx 3Dx 3Ex 3Hx 3Kx 3Qx 3Tx 3Ux 7469 CTO 54x 55x 56x 57x 59x 5Ax 5Cx 5Dx 5Gx 5 5Lx 5Nx 5Px 5 5Sx 5Tx 5Ux 5Xx 5Zx 72x 73x 7Mx 7Nx 7Rx 7Ux 7Yx 82x E1x 7470 CTO 5Gx 64x 65x 69x 6Ax 6Cx 6Dx 6Fx E1x 2046 CTO 2047 CTO Battery pack 9 cell 42 4649 7454 7455 3 5 7457 7458 59 5Hx 5 x 5Ox 7 7 83x 88x 89x 7459 CTO 65x 66x 67x 6Nx 6Px 6Qx 68x 6Vx 6Wx 6Xx 4 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 3Fx 3Gx 3 x 3Lx 3Mx 3Nx 3Px 7469 CTO 5Ex 5Fx 5 5Mx 5Rx 5Vx 5Wx 5Yx 7Cx 7Gx 7Hx 7 x 7Kx 7Lx 7Px 7Ox 7Tx 7Vx 7470 CTO 6Ex 6 x 2046 2047 152 ThinkPad X200 and 2008 Hardware Maintenance Manual Table 39 Parts list Overall continued No 11 FRU Battery pack 9 cell 7454 CTO 7455 CTO 3Ex 3Qx D5x 7457 7458 CTO 59x 5Hx 5 x 5Ox 7Bx 7Cx 83x 88x 89x 7459 CTO 65x 66x 67x 6Nx 6Px 60x 69x 6Vx 6Wx 6Xx 4 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 3Gx 3 3Lx 3 3Nx 3Px 7469 CTO 5Ex 5Fx 5Kx 5Mx 5Rx 5Vx 5Wx 5Yx 7Cx 7Gx 7Hx 7 x 7Kx 7Lx 7Px 7Ox 7Tx 7Vx 7470 CTO 6Ex 6 x 2046 CTO 2047 CTO 42T4650 FR
75. E3x M2x M3x 2023 CTO 2024 CTO 7462 CTO 42x 43x 44x 45x 46x 4Dx 4Ex 4Kx 4Nx 4Px 4Sx 4Tx 4Ux 7465 CTO 23x 24x 25x 26x 27x 2Ex 2Fx 2Lx 2Px 2Qx 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 38x 39x 3Fx 3Lx 3Mx 3Nx 3Px 7469 CTO 52x 53x 54x 56x 58x 59x 5Gx 5Lx 5Mx 5Xx 5Yx 7Dx 7Gx 7Hx 7 x 7Kx 7Rx e 7470 CTO 5Gx 62x 63x 64x 68x 69x 6 2046 CTO 2047 CTO 13 SATA hard disk drive 160 GB 9 5 mm 5 400 rpm 42T1309 R 7454 CTO 25x 26x 29x 2Gx 2Hx 2Nx 2Rx 2Ux 2Vx 2Xx 2Yx 92x 95x 97x 98x 9Fx 7455 CTO 35x 36x 39x 3Ax 3Dx 3 x 3Kx 3Px 3Wx 7457 CTO 45x 48x 49x 4 4 4Hx 4Lx 4Mx 4Px 4 4Vx 7458 CTO 53x 55x 56x 57x 5Ax 5Ex 5Lx 5 69x 73x 78x 7Ex 7Lx 7Mx 7Px 7Rx 7Vx 7Wx 83x 86x 89x 8Ax 8Bx 8Cx 8Fx 8Gx 8Hx 8Lx 8Nx E2x M2x M3x X4x X5x 7459 CTO 5Ex 62x 68x 69x 6Bx 6Cx 6Dx 6Fx 6Lx 6Sx 6Yx 6Zx H2x E3x M2x M3x 2023 CTO 2024 CTO 7462 CTO 42x 43x 44x 45x 46x 4Dx 4Ex 4Kx 4Nx 4Px 4Sx 4Tx 4Ux 7465 CTO 23x 24x 25x 26x 27x 2Ex 2Fx 2Lx 2Px 2Qx 2Tx 2Ux 2Vx 2Wx 2Xx 7466 CTO 32x 33x 34x 38x 39x 3Fx 3Lx 3Mx 3Nx 3Px 7469 CTO 52x 53x 54x 56x 58x 59x 5Gx 5Lx 5Mx 5Xx 5Yx 7Dx 7Gx 7Hx 7 x 7Kx 7Rx 7470 5Gx 62x 63x 64x 68x 69x 6Fx 2046 CTO 2047 CTO ThinkPad X200 and X200s 155 Table 39 Parts list Overall
76. LCD model 12 1 in WXGA LCD model Step Screw quantity Color Torque M2 x 2 mm wafer head nylon coated 1 Silver 0 181 Nm 1 85 kgfcm 120 ThinkPad X200 and X200s Hardware Maintenance Manual Table 34 Removal steps of LCD panel LCD brackets and LCD cable for 12 1 in WXGA LCD model continued Turn the LCD panel over and then remove the LCD cable from the LCD panel When installing Make sure that the LCD cable connector is attached firmly ThinkPad 200 2008 121 2060 Hinges and hinge brackets For access remove these FRUs in order 1010 Battery pack on page 6 2010 LCD front bezel on page 110 2020 Inverter card on page 113 2030 Bluetooth daughter card BDC 2 1 on page 114 2040 Integrated camera on page 115 Table 35 Removal steps of hinges for 12 1 in WXGA LCD model 12 1 in WXGA LCD model Remove the hinges 122 ThinkPad X200 and X200s Hardware Maintenance Manual Table 36 Removal steps of hinges and hinge brackets for 12 1 in WXGA LCD model 12 1 in WXGA LCD model In step release the antenna cables from the cable guides ThinkPad X200 and X200s 123 Table 36 Removal steps of hinges and hinge brackets for 12 1 in WXGA LCD model continued Remove the hinges and the hinge brackets Step Screw quantity Color Torque B M2 5 x 4 mm wafer head nylon coated 2 Black 0 392 Nm 4 kgfcm
77. Mx 2Nx 2Px 20x 2Rx 25 97x 98x 9Fx 7455 CTO 32x 33x 34x 35x 36x 38x 3Bx 3Dx 3Ex 3Fx 3Gx 3Hx 3 x 35 3Tx 3Ux 3Vx 3Wx 3Xx 3Yx 3Zx D2x D5x 7457 CTO 42x 43x 44x 45x 46x 47x 49x 4Cx 4Dx 4Ex 4Fx 4 4Rx 7458 CTO 52x 53x 54x 55x 56x 57x 58x 59x 5Ax 5Bx 5Cx 5Dx 5Ex 5Fx 5Hx 5Lx 5Mx 5Nx 5Ox 5Rx 5Sx 69x 72x 74x 76x 78x 79x 7Cx 7Dx 7Gx 7Hx 7 x 7Kx 7Lx 7Mx 7Nx 7Px 7Qx 8Ax 8Bx 8Cx 8Dx 8Ex 8Fx 8Gx 8Hx 8 x 8Nx 8Px 8 8Rx 8Tx 8Wx 8Xx 8Yx E2x F2x F3x F4x F5x F7x F8x FAx M2x M3x X4x X5x 7459 CTO 5Ex 5Fx 62x 63x 64x 65x 67x 68x 69x 6Ax 6Bx 6Cx 6Dx 6Ex 6Gx 6 x 6Lx 6Mx 6Nx 6Px 6Qx 6Rx 6Yx 6Zx H2x E3x M2x M3x 2023 CTO 2024 CTO 7462 CTO 43x 44x 45x 46x 47x 48x 49x 4Ax 4Bx 4Cx 4Dx 4Ex 4Fx 4Gx 4Hx 4 4Lx 4Mx 4Nx 4Px 7465 CTO 24x 25x 26x 27x 28x 29x 2Dx 2Ex 2Fx 2Hx 2Jx 2Kx 2Lx 2Mx 2Nx 2Px 2 2Vx 7466 CTO 33x 34x 35x 38x 39x 3Ax 3Bx 3Cx 3Dx 3Ex 3Gx 3Kx 3Lx 3Mx 3Rx 3Sx 3Tx 3Ux 7469 CTO 53x 54x 55x 56x 57x 58x 59x 5Ax 5Bx 5Cx 5Dx 5Ex 5Fx 5Gx 5Hx 5Kx 5Lx 5Mx 5Nx 5Px 5Ox 5Rx 5Sx 5Tx 5Ux 5Vx 5Xx 5Yx 5Zx 72x 73x 75x 76x 77x 78x 79x 7Ax 7Bx 7Cx 7Ex 7Fx 7Gx 7Hx 7Lx 7Mx 7Nx 7Ox 7Rx 7Sx 7Ix 7Ux 7Vx 7Xx 7Yx 7Zx E1x 7470 CTO 5Gx 5Hx 63x 64x 65x 68x 69x 6Ax 6Bx 6Cx 6Dx 6Ex 6Fx 6Gx 6 x 1 2
78. RU ID ID US 43Y6501 43Y6503 System board with Intel Core 2 Duo processor P8400 2 26 GHz AMT TPM 7454 CTO 26x 29x 2Kx 2Lx 2Nx 2Px 2Rx 2Wx 2Xx 2Yx 92x 7455 CTO 36x 38x 39x 3Dx 3Jx 3Kx 3Px 3Sx 3Tx 7457 CTO 45x 48x 4 4Bx 4Cx 4Dx 4Gx 4 4 4 4Px 4 4Ux 4 4Wx 7458 CTO 55x 57x 5Ax 5Bx 5Lx 5Mx 5Nx 5Px 72x 73x 78x TEx 7Fx 7Gx 7Hx 7Lx 7Mx 7Nx 7Px 7Rx 7Tx 7Xx 7Zx 82x 86x F5x X5x 7459 CTO 62x 63x 68x 6Cx 6Ex 6Fx 6Lx 6Rx 6Tx 2023 CTO 2024 CTO 42W8150 System board with Intel Core 2 Duo processor P8400 2 26 GHz AMT non TPM 7454 CTO 7455 CTO 7457 CTO 7458 CTO 3Wx 7Vx 7Wx 8Cx 8Dx 8Hx 8Kx 8Lx 8Nx 7459 CTO 2023 CTO 2024 CTO 42W8153 R System board with Intel Core 2 Duo processor P8400 2 26 GHz non AMT TPM 7454 CTO 7455 CTO 42W8006 R System board with Intel Core 2 Duo processor P8400 2 26 GHz 7454 CTO 7455 CTO 42W8096 R ThinkPad X200 and X200s 139 Table 39 Parts list Overall continued No FRU System board with Intel Core 2 Duo processor P8600 Q 4 GHz 7454 CTO 22x 23x 24x 25x 27x 28x 2Gx 2Hx 2 x 2Mx 20x 28x 2 Tx 2Ux 2Vx 2Zx 93x 95x 96x 97x 98x 9Fx 9Gx 7455 CTO 32x 33x 34x 35x
79. RU identification for CMV products Important information about replacing RoHS compliant FRUs General checkout What to do first Checkout guide Diagnostics using Doctor for DOS PC Doctor for Windows PC Doctor for Rescue and Recovery Power system checkout Checking the ac adapter Checking operational charging Checking the battery pack Checking the backup battery Related service information Restoring the factory contents by using Product Recovery discs Passwords Power on password Hard disk password Supervisor password How to remove the power on password How to remove the hard disk password Power management Screen blank mode Standby mode Hibernation mode Symptom to FRU index Numeric error codes Error messages Beep symptoms Copyright Lenovo 2008 awn BND 17 17 18 18 18 19 19 19 21 23 24 25 26 28 28 229 429 30 30 81 33 33 34 34 34 34 35 35 37 37 37 38 39 39 43 44 No beep symptoms LCD related symptoms Intermittent problems Undetermined problems ThinkPad X200 and X200s Specifications Status indicators FRU tests Fn key coinbinations FRU replacement notices Screw notices Retaining serial numbers Removing and replacing a FRU Before servicing ThinkPad X200 and X200s 1010 Battery pack 1020 Hard dis
80. Safety inspection guide on page 5 inspection guide on page 5 Handling devices that are sensitive t devices that are sensitive to electrostatic discharge on page 6 Grounding requirements on page 6 requirements on page 6 Safety notices multilingual translations notices multilingual translations on page 7 Laser compliance statement on page 14 General safety Follow these rules to ensure general safety Observe good housekeeping in the area of the machines during and after maintenance When lifting any heavy object 1 Make sure that you can stand safely without slipping 2 Distribute the weight of the object equally between your feet 3 Use a slow lifting force Never move suddenly or twist when you attempt to lift 4 Lift by standing or by pushing up with your leg muscles this action removes the strain from the muscles in your back Do not attempt to lift any object that weighs more than 16 kg 35 or that you think is too heavy for you Do not perform any action that causes hazards to the customer or that makes the equipment unsafe Before you start the machine make sure that other service representatives and the customer s personnel are not in a hazardous position Place removed covers and other parts in a safe place away from all personnel while you are servicing the machine Keep your toolcase away from walk areas so that other people will not trip over it Do not wear l
81. Support will show both the CTO and CMV machine type models Example 1829 CTO and 1829 W15 will be found on the eSupport site The HMM will have the 4 digit MT and 3 digit CTO model only Example 1829 CTO Again CMVs are custom models and are not found in the HMM General Announce Variant GAV This is a standard model fixed configuration GAVs are announced and offered to all customers The MTM portion of the machine label is a 4 digit MT and 3 digit model where model a fixed part number not Example 1829 F1U Also PEW eSupport and the HMM will list these products under the same fixed model number FRU identification for CTO CMV and GAV products There are three information resources to identify which FRUs are used to support CTO CMV and GAV products These sources are PEW eSupport and the HMM Using PEW PEW is the primary source for identifying FRU part numbers and FRU descriptions for the key commodities for CTO CMV and GAV products at a MT serial number level An example of key commodities are hard disk drives system boards microprocessors Liquid Crystal Displays LCDs and memory Remember all CTO and CMV products are loaded in PEW under the 4 digit MT and 3 digit model where model Example 1829 CTO GAVs are loaded in PEW under the 4 digit MT and 3 digit model where model a fixed part number not CTO Example 1829 F1U e PEW can be accessed at the following
82. TO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 7470 CTO 2046 CTO 2047 CTO 160 ThinkPad X200 and X200s Hardware Maintenance Manual Table 39 Parts list Overall continued No 13 FRU SATA hard disk drive 320 GB 9 5 mm 7 200 rpm 7454 CTO 7455 CTO 7457 CTO 7458 CTO 7459 CTO 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 7470 CTO 2046 CTO 2047 CTO FRU no 4271571 RoHS ID CRU ID 13 SATA hard disk drive 200 GB FDE 9 5 mm 7 200 rpm OP 7454 CTO 22x 27x 7455 CTO 32x 7457 CTO 42x 46x 7458 CTO 52x 5Px 5Tx 85x 7459 CTO 6Ax 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 5Rx 7Lx 7470 CTO 2046 CTO 2047 CTO 42T1463 13 SATA hard disk drive 200 GB FDE 9 5 mm 7 200 rpm 7454 CTO 22x 27x 7455 CTO 32x 7457 CTO 42x 46x 7458 CTO 52x 5Px 5Tx 85x 7459 CTO 6Ax 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 5Rx 7Lx 7470 CTO 2046 CTO 2047 CTO 42T1561 ThinkPad X200 and 2008 161 Table 39 Parts list Overall continued No FRU FRU no RoHS CRU 13 hard disk drive 250 FDE 9 5 mm 7 200 rpm 42T1563 7454 CTO 7455 CTO 7457 CTO 7458 CTO 7459 CTO 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 7
83. The purpose of this inspection guide is to assist you in identifying potentially unsafe conditions As each machine was designed and built required safety items were installed to protect users and service personnel from injury This guide addresses only those items You should use good judgment to identify potential safety hazards due to attachment of non ThinkPad features or options not covered by this inspection guide If any unsafe conditions are present you must determine how serious the apparent hazard could be and whether you can continue without first correcting the problem Consider these conditions and the safety hazards they present Electrical hazards especially primary power primary voltage on the frame can cause serious or fatal electrical shock Explosive hazards such as a damaged CRT face or a bulging capacitor Mechanical hazards such as loose or missing hardware To determine whether there are any potentially unsafe conditions use the following checklist at the beginning of every service task Begin the checks with the power off and the power cord disconnected Checklist 1 Check exterior covers for damage loose broken or sharp edges 2 Power off the computer Disconnect the power cord 3 Check the power cord for a Athird wire ground connector in good condition Use a meter to measure third wire ground continuity for 0 1 ohm or less between the external ground pin and the frame ground b The po
84. ThinkPad ThinkPad X200 and X200s Hardware Maintenance Manual ThinkPad ThinkPad X200 and X200s Hardware Maintenance Manual Before using this information and the product it supports be sure to read the general information under Notices on page Fourth Edition December 2008 Copyright Lenovo 2008 rights reserved LENOVO products data computer software and services have been developed exclusively at private expense and are sold to governmental entities as commercial items as defined by 48 2 101 with limited and restricted rights to use reproduction and disclosure LIMITED AND RESTRICTED RIGHTS NOTICE If products data computer software or services are delivered pursuant a General Services Administration GSA contract use reproduction or disclosure is subject to restrictions set forth in Contract No GS 35F 05925 2008 Lenovo Contents About this manual Safety information General safety Electrical safety Safety inspection guide Handling devices that are to elecdirostatic discharge 20 Grounding requirements Safety notices multilingual translations Laser compliance statement Important service information Strategy for replacing FRUs Strategy for replacing a hard disk Important notice for replacing system board How to use error message Strategy for d au d FRUs for CTO au GAV 20484 Product definition 1 F
85. U no RoHS ID CRU ID 12 Hard disk drive rubber rails 41V9756 13 SATA hard disk drive 80 GB 9 5 mm 5 400 rpm J 7454 CTO 4Gx 7455 CTO 7457 7458 CTO 7459 CTO 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO E1x e 7470 6Gx Elx 2046 CTO 2047 CTO 3972885 13 SATA hard disk drive 80 GB 9 5 mm 5 400 rpm 7454 CTO 4Gx 7455 CTO 7457 CTO 7458 CTO 7459 CTO 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO E1x 7470 6Gx E1x 2046 CTO 2047 CTO 4271491 ThinkPad X200 and 2008 153 Table 39 Parts list Overall continued 13 No FRU FRU no SATA hard disk drive 80 GB 9 5 mm 5 400 rpm 4271305 7454 CTO 4Gx 7455 7457 7458 7459 2023 2024 7462 7465 7466 7469 1 7470 6 1 2046 2047 13 SATA hard disk drive 80 GB 9 5 mm 5 400 rpm 42T1575 7454 CTO 4Gx 7455 CTO 7457 CTO 7458 CTO 7459 CTO 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 1 7470 6Gx 1 2046 CTO 2047 CTO 13 SATA hard disk drive 160 GB 9 5 mm 5 400 rpm 39 2899 7454 CTO 25x 26x 29x 2Gx 2Hx 2Nx 2Rx 2Ux 2Vx 2Xx 2Yx 92x 95x 97x 98x 9Fx 7455 CTO 35x 36x 39x 3Ax 3Dx 3Kx 3Px
86. Universal serial bus USB connectors External monitor connector DisplayPort connector Headphone jack Microphone jack 45 Ethernet connector Security keyhole Security lock key Universal serial bus USB connector Serial Ultrabay Slim device release latch Serial Ultrabay Slim device eject lever Serial Ultrabay Slim device Docking connector pppppecoocosona 134 ThinkPad X200 and X200s Hardware Maintenance Manual Bottom view ThinkPad X200 UltraBase Battery charger behind the flip down door UltraBase eject request button UltraBase eject lever Power button security latch Power button Built in stereo speakers ThinkPad 200 2008 135 Parts list This section contains following lists of the service parts Overall on page 137 LCD FRUs on page 171 Keyboard on page 184 Miscellaneous parts on page 185 AC adapters on page 18 77 Power cords on page 18 Recovery discs on page 187 Common service tools on page 195 o Notes Each FRU is available for all types or models unless specific types or models are specified FRU with specific models listed and described as xxU where U is an example of a country designator should be used for all models ending in U FRU with specific models listed and described as 3Dx where 3D is an example of a unique configuration should be used for all of these models unless spec
87. Web site http w3 01 ibm com pc entitle pg2 Service wss display Home Customers can also access PEW via http www 307 ibm com pc support site wss product do template warranty Important service information 19 warranty vm amp sitestyle lenovo Select Warranty lookup Input the MT and the Serial number and the list of key commodities will be returned in the PEW record under COMPONENT INFORMATION Business Partners using Eclaim will access PEW when performing Entitlement Lookup Business Partners will enter Loc ID MT and Serial and the key commodities will be returned in the Eclaim record under SYSTEM DETAILS Authorized IBM Business Partners can access Eclaim at the following Web site Using eSupport For Key Commodities Examples hard disk drive system board microprocessor LCD and memory eSupport can be used to view the list of key commodities built in a particular machine serial this is the same record found in PEW e eSupport can be accessed at the following Web site http www lenovo To view the key commodities click on PARTS INFORMATION then PARTS LOOKUP Type in the model type and serial number The key commodities will be returned in the eSupport record under PARTS SHIPPED WITH YOUR SYSTEM For the Remaining FRUs the complete list of FRUs at the MT Model level eSupport can be used to view the complete list of FRUs for a machine type and model To view the complet
88. and hold the Shift key and press the NumLk ScrLk key Wireless WAN status Y Green The wireless WAN is on and the radio link is ready for use Blinking green Data is being transmitted Wireless PAN status or UU Green Wireless PAN Bluetooth wireless or Wireless USB is operational This indicator is on when Wireless PAN is on and not in suspend mode Wireless LAN status p Green The wireless LAN feature is on and the radio link is ready for use Blinking green Data is being transmitted 52 ThinkPad X200 and X200s Hardware Maintenance Manual FRU tests The following table shows the test for each FRU Table 9 FRU tests FRU Applicable test System board 1 Diagnostics gt CPU Coprocessor 2 Diagnostics gt Systemboard 3 If the ThinkPad X200 UltraBase is attached to the ThinkPad computer detach it Place the computer on a horizontal surface and run Diagnostics gt ThinkPad Devices gt HDD Active Protection Test Note Do not apply any physical shock to the computer while the test is running Power LCD unit Diagnostics gt ThinkPad Devices gt AC Adapter Battery 1 Battery2 1 Diagnostics gt Video Adapter 2 Interactive Tests gt Video Modem daughter card Make sure the modem is set up correctly Replace the modem jack and the modem card in turn and run the following tests in Diagnostics
89. are not left loose inside the computer Verify this by shaking the computer and listening for rattling sounds Metallic parts or metal flakes can cause electrical shorts Avant de remettre l ordinateur sous tension apr s remplacement d une unit en clientele v rifiez que tous les ressorts vis et autres pi ces sont bien en place et bien fix es Pour ce faire secouez l unit et assurez vous qu aucun bruit suspect ne se produit Des pi ces m talliques ou des copeaux de m tal pourraient causer un court circuit Bevor nach einem FRU Austausch der Computer wieder angeschlossen wird mu sichergestellt werden keine Schrauben Federn oder andere Kleinteile fehlen oder im Geh use vergessen wurden Der Computer mu gesch ttelt und auf Klapperger usche gepr ft werden Metallteile oder splitter k nnen Kurzschl sse erzeugen NTI v FRU 95nn ANNI avnnn NIYIN 392 DIN DIOP DPIN D SSpn 929 AWNN n DYN 023203 pwpw MIP 9999 DPN auman NN 20202 W DISP 01132 NINN gt 22 IN Prima di accendere l elaboratore dopo che 6 stata effettuata la sostituzione di una FRU accertarsi che tutte le viti le molle e tutte le altri parti di piccole dimensioni siano nella corretta posizione e non siano sparse all interno dell elaboratore Verificare ci scuotendo l elaboratore e prestando attenzione ad eventuali rumori eventuali parti o pezzetti metallici possono provocare
90. assembly for 2024 42X5182 R N 20 cover assembly for 7462 45N3239 R N 20 cover assembly for 7465 45N3237 R N 20 cover assembly for 7466 45N3238 N 20 cover assembly for 7469 45N3240 R N 20 cover assembly for 7470 45N3241 N 20 cover assembly for 2046 45N3242 R N 20 cover assembly for 2047 45N3243 R N 21 assembly NV 25 for X200 45N4782 R N 7454 CTO 22x 23x 24x 25x 26x 27x 28x 29x 2Kx 2Lx 2Nx 2Px 20x 2Rx 2Sx 2Fx 2Gx 2Hx 2 x 2Mx 2Tx 2Ux 2Vx 2Wx 2Xx 2Yx 27 92x 93x 94x 95x 96x 97x 98x 9Bx 9Cx 9Fx 9Gx 7455 CTO 32x 33x 34x 35x 36x 38x 39x 3Ax 3Bx 3Cx 3Dx 3Fx 3Gx 3Hx 3Jx 3Kx 3Lx 3Mx 3Nx 3Rx 35 3Tx 3Ux 3Wx 3Xx 3Yx 3Zx D2x D3x D5x 7457 CTO 42x 43x 44x 45x 46x 47x 48x 49x 4Ax 4Bx 4Cx 4Dx 4Ex 4Fx 4Gx 4Hx 4 4Lx 4Mx 4Nx 4Px 4Ox 4Rx 4Sx 4Tx 4Ux 4Vx 4Wx 7458 CTO 52x 53x 54x 55x 56x 57x 58x 59x 5Ax 5Bx 5Cx 5Dx 5Ex 5Fx 5Hx 5 x 5Lx 5Mx 5Nx 5Px 5Ox 5Rx 5Sx 5Tx 69x 72x 73x 74x 76x 77x 78x 79x 7Ax 7Bx 7Cx 7Dx 7Ex 7Fx 7Gx 7Hx 7 x 7Kx 7Lx 7Mx 7Nx 7Px 7 7Rx 7Sx 7Tx 7Ux 7Vx 7Wx 7Xx 7Yx 7Zx 82x 83x 84x 85x 86x 87x 88x 89x 8Ax 8Bx 8Cx 8Dx 8Ex 8Fx 8Gx 8Hx 8 x 8Kx 8Lx 8Mx 8Nx 8Px 8 8Rx 8Sx 8Tx 8Wx 8Xx 8Yx 8Zx E2x F2x F3x F4x F5x F6x F
91. ate one of the following power supply checkouts operational charging Checking the battery pack on page 30 Checking the backup battery on page 31 Checking the ac adapter You are here because the computer fails only when the ac adapter is used f the power problem occurs only when the ThinkPad X200 UltraBase is used replace the UltraBase If the power on indicator does not turn on check the power cord of the ac adapter for correct continuity and installation f the computer does not charge during operation go to Checking operational charging on page 30 To check the ac adapter do the following 1 Unplug the ac adapter cable from the computer 2 Measure the output voltage at the plug of the ac adapter cable See the following figure Pin Voltage V dc 1 20 3 MUT 2 0 2 A 1 3 Ground Note Output voltage of pin 2 of the ac adapter may different from the one you are servicing If the voltage is not correct replace the ac adapter If the voltage is acceptable do the following Replace the system board f the problem persists go to ThinkPad X200 and X200s on page 47 Note Noise from the ac adapter does not always indicate a defect A0 Generalcheckout 29 Checking operational charging To check whether the battery charges properly during operation use a discharged battery pack or a battery pack that has less than 50 of the total p
92. ation EAC power status Green The computer is connected to the power supply ThinkPad X200 and X200s 51 Table 8 Status indicators continued Indicator Meaning Battery status Green The battery is charged between 80 to 100 of the capacity and being discharged between 0 to 80 of the capacity Blinking green The battery is charged between 20 to 80 of the capacity and being charged Orange The battery is charged between 5 and 20 of the capacity and being discharged Blinking orange slow The battery is charged between 5 to 20 of the capacity and being charged Blinking orange rapid The battery is charged between 0 to 5 of the capacity Power on Green The computer is on and ready to use This indicator stays lit whenever the computer is on and is not in standby mode Drive in use Green B Data is being read from or written to the hard disk drive the diskette drive or the drive in the Serial Ultrabay Slim device When this indicator is on do not put the computer into standby mode or turn off the computer Note Do not move the system while the green drive in use light is on Sudden physical shock could cause drive errors n Caps lock Green Caps Lock mode is enabled To enable or disable Caps YAN Lock mode press the Caps Lock key Num lock Green The numeric keypad on the keyboard is enabled To enable or disable the keypad press
93. atterie di alimentazione siano a basso voltaggio una batteria in corto circuito o a massa fornire corrente sufficiente da bruciare materiali combustibili provocare ustioni ai tecnici di manutenzione AAV 7 Th 0 23 ILU Ed EET EO LEAN 424852350244 Aunque las bater as principales tienen un voltaje bajo una bater a cortocircuitada o con contacto a tierra puede producir la corriente suficiente como para quemar material combustible o provocar quemaduras en el personal 12 ThinkPad X200 and X200s Hardware Maintenance Manual Safety notice 8 N DANGER Before removing any FRU power off the computer unplug all power cords from electrical outlets remove the battery pack and then disconnect any interconnecting cables Avant de retirer une unit remplacable en client le mettez le syst me hors tension d branchez tous les cordons d alimentation des socles de prise de courant retirez la batterie et d connectez tous les cordons d interface Die Stromzufuhr muf abgeschaltet alle Stromkabel aus der Steckdose gezogen der Akku entfernt und alle Verbindungskabel abgenommen sein bevor eine FRU entfernt wird AUnnn nx 235 v 17055 FRU 71990 10315 SnwNA pW nunn5233 53 NN PMII DANN VPN 2239 p 35 1 AID NN AINI v ON Prima di rimuovere qualsiasi FRU spegnere il sistema scollegare dalle prese elettriche tutti i cavi di a
94. attery pack first See 1010 Battery pack on page 64 After you finish the servicing make sure that you insert the card back into the slot firmly Notice on disconnecting the cable from flip lock ZIF connector Some cables used in the ThinkPad X200 and X200s are connected to the flip lock ZIF connectors When disconnecting the cable from those connectors do as shown in this figure ThinkPad X200 and X200s 63 1010 Battery pack N DANGER Use only the battery specified in the parts list for your computer Any other battery could ignite or explode Table 11 Removal steps of battery pack Unlock the battery release lever Bj Holding the battery release lever in the unlocked position remove the battery pack in the direction shown by arrow When installing Install the battery pack along the slide rails of the slot Then make sure that the battery release lever is in the locked position 64 ThinkPad X200 and X200s Hardware Maintenance Manual 1020 Hard disk drive HDD cover HDD and HDD rubber rails or solid state drive SSD and storage converter For access remove this FRU e 1010 Battery pack on page 64 Attention Do not drop the hard disk drive or apply any physical shock to it The hard disk drive is sensitive to physical shock Improper handling can cause damage and permanent loss of data Before removing the drive have the user make a backup copy of all the informat
95. ault setting Then defaults The checksum of the CRS2 setting save the current setting by pressing F10 in the EEPROM is not correct 2 System board 0185 1 Run BIOS Setup Utility Press F9 and Bad startup sequence settings Enter BIOS Enter to load the default setting Then Setup and load Setup defaults save the current setting by pressing F10 Related service information 39 Table 1 Numeric error codes continued Symptom or error FRU or action in sequence 0187 EAIA data access error The access to EEPROM is failed System board 0188 System board Invalid RFID Serialization Information Area 0189 System board Invalid RFID configuration information area The EEPROM checksum is not correct 0190 1 Charge the battery pack Critical low battery error 2 Battery pack 0191 1 Run BIOS Setup Utility and then save System Security Invalid Remote Change requested current setting by pressing 10 2 System board 0192 System Security Embedded Security hardware tamper detected System board 0199 System Security Security password retry count exceeded 1 Run BIOS Setup Utility and then save the current setting by pressing F10 2 System board 01C8 Two or more modem devices are found Remove all but one of them Press Esc to continue 1 Remove either a Mini PCI Card or a modem daughter card Otherwise press Esc to ignore the warni
96. code is displayed begin the diagnosis with the first error code Whatever causes the first error code may also cause false error codes If no error code is displayed see whether the error symptom is listed in the Symptom to FRU Index for the computer you are servicing 18 ThinkPad X200 and X200s Hardware Maintenance Manual Strategy for replacing FRUs for CMV and GAV Product definition Dynamic Configure To Order CTO This provides the ability for a customer to configure an IBM or a Lenovo solution from an eSite and have this configuration sent to fulfillment where it is built and shipped directly to the customer The machine label Product Entitlement Warehouse PEW eSupport and the HMM will load these products as the 4 digit MT and 3 digit model where model Example 1829 CTO Custom Model Variant CMV This is a unique configuration that has been negotiated between IBM or Lenovo and the customer A unique 4 digit MT and 3 digit model is provided to the customer to place orders Example 1829 W15 A CMV is a special bid offering Therefore it is NOT generally announced The MTM portion of the machine label is the 4 digit MT and 3 digit model where model Example 1829 CTO The PRODUCT ID portion of the machine label is the 4 digit MT and 3 digit CMV model Example 1829 W15 The PEW record is the 4 digit MT and 3 digit model where model Example 1829 CTO e
97. d Key combination Description Fn cursor keys These key combinations work with Windows Media Player Fn down arrow key works for the Play or Pause button arrow key for the Stop button Fn right arrow key for the Next Track button and Fn left arrow key for the Previous Track button ThinkPad X200 and X200s 57 FRU replacement notices This section contains notices related to removing and replacing parts Read this section carefully before replacing any FRU Screw notices Loose screws can cause a reliability problem In the ThinkPad computer this problem is addressed with special nylon coated screws that have the following characteristics They maintain tight connections They do not easily come loose even with shock or vibration They are harder to tighten Each one should be used only once Do the following when you service this machine Keep the screw kit for the P N see Miscellaneous parts on page 185 in your tool bag Always use new screws Use a torque screwdriver if you have one Tighten screws as follows Plastic to plastic Turn an additional 90 degrees after the screw head touches the surface of the plastic part 90 degrees more Cross section Logic card to plastic Turn an additional 180 degrees after the screw head touches the surface of the logic card 180 degrees more
98. d Hardware Maintenance Diskette Version 1 73 or later and restart the computer 2 From the main menu select 6 Set ECA Information 3 To write ECA information select 1 Write ECA rework number from EEPROM and follow the instruction 4 To write box build date select 4 Write box build date from EEPROM and follow the instruction on the screen If the system board is being replaced try to read the ECA information from the old system board and transfer the information to the new system If the system board is inoperable this will not be possible ThinkPad X200 and 2008 61 Removing and replacing FRU This section presents directions and drawings for use in removing and replacing a FRU Be sure to observe the following general rules 1 Do not try to service any computer unless you have been trained and certified An untrained person runs the risk of damaging parts 2 Before replacing any FRU review FRU replacement notices on page 58 3 Begin by removing any FRUs that have to be removed before the failing FRU Any such FRUs are listed at the top of the page Remove them in the order in which they are listed 4 Follow the correct sequence in the steps for removing the FRU as given in the drawings by the numbers in square callouts 5 When turning a screw to replace a FRU turn it in the direction as given by the arrow in the drawing 6 When removing the FRU move it in the direction as given by the arrow in th
99. d X200s Hardware Maintenance Manual Fn key combinations The following table shows the function of each combination of Fn with a function key Table 10 Fn key combinations Key combination Fn F1 Description Reserved Fn F2 Fn F3 Lock the computer Select a power scheme that has been created by Power Manager When you press this combination a panel for selecting a power scheme appears Notes 1 To use the Fn F3 key combination you must have the ThinkPad PM device driver installed on the computer 2 If you have logged on with an administrator user ID and you press Fn F3 the panel for selecting a power scheme appears If you have logged on with another user ID and you press Fn F3 the panel does not appear 3 You cannot turn off the computer display by pressing Fn F3 Fn F4 Put the computer in standby mode To return to normal operation press the Fn key only without pressing a function key Notes 1 To use the Fn F4 key combination you must have the ThinkPad PM device driver installed on the computer 2 This combination of keys also functions as a sleep button If you want to use the combination to put the computer into hibernation mode or shut the computer down change the settings in the Power Manager 5 Enable or disable the built in wireless networking features and the Bluetooth features If you press Fn F5 a list of wireless features is displayed You can quic
100. d expects its suppliers to be ready to support Lenovo s requirements and schedule in the EU Products sold in 2005 and 2006 will contain some RoHS compliant FRUs The following statement pertains to these products and any product Lenovo produces containing RoHS compliant FRUs RoHS compliant FRUs have unique FRU part numbers Before or after the RoHS implementation date failed RoHS compliant parts must always be replaced using RoHS compliant so only the FRUs identified as compliant in the system HMM or direct substitutions for those FRUs may be used Products marketed before June 2006 Products marketed after June 2006 Current or original Replacement FRU Current or original Replacement FRU part part Non RoHS Can be Non RoHS Must be RoHS Must be RoHS Non RoHS Can be RoHS Non RoHS Can sub to RoHS RoHS Must be RoHS Note A direct substitution is a part with a different FRU part number that is automatically shipped by the distribution center at the time of the order Important service information 21 22 ThinkPad X200 and X200s Hardware Maintenance Manual General checkout This chapter presents following information What to do first on page 24 Checkout guide on page 25 Diagnostics using PC Doctor for DOS on page 26 PC Doctor for Windows on page 28 PC Doctor for Rescue and Recovery on page 28 Power system checkout on page 29 The descriptions in this chapt
101. d off To cause the computer to enter hibernation mode do any of the following Press the 12 keys f you are using the APM operating system and have set the mode to Power switch mode Hibernation turn off the power switch f you are using the ACPI operating system and have defined one of the following actions as the event that causes the system to go into hibernation mode perform that action Closing the lid Pressing the power button Pressing Fn F4 keys Also the computer goes into hibernation mode automatically in either of the following conditions f a hibernation time has been set on the timer and if the user does not do any operation with the keyboard the TrackPoint the hard disk drive the parallel connector or the diskette drive within that time If the timer conditions are satisfied in suspend mode f you are using the APM operating system and have set the mode to Hibernate when battery becomes low and the battery charge becomes critically low When the power is turned on the computer returns from hibernation mode and resumes operation The hibernation file in the boot record on the hard disk drive is read and system status is restored from the hard disk drive 38 ThinkPad X200 and X200s Hardware Maintenance Manual Symptom to FRU index This section contains following information Undetermined problems on page 46 The symptom to FRU index in this section lists sympt
102. diskette drive for maintenance diskette 05K9283 USB floppy diskette drive tool kit 27L3452 Test card for integrated Smart Card 42W7820 ThinkPad Hardware Maintenance Diskette Version 1 73 or later Eu Download the file from the following Web site ThinkPad X200 and X200s 195 196 ThinkPad X200 and X200s Hardware Maintenance Manual Notices Copyright Lenovo 2008 Lenovo may not offer the products services or features discussed in this document in all countries Consult your local Lenovo representative for information on the products and services currently available in your area Any reference to a Lenovo product program or service is not intended to state or imply that only that Lenovo product program or service may be used Any functionally equivalent product program or service that does not infringe any Lenovo intellectual property right may be used instead However it is the user s responsibility to evaluate and verify the operation of any other product program Or service Lenovo may have patents or pending patent applications covering subject matter described in this document The furnishing of this document does not give you any license to these patents You can send license inquiries in writing to Lenovo United States Inc 1009 Think Place Building One Morrisville NC 27560 U S A Attention Lenovo Director of Licensing LENOVO GROUP LTD PROVIDES THIS PUBLICATION AS IS WITHOUT WARRANTY OF
103. e M2 x 5 mm wafer head nylon coated 2 Black 0 181 Nm 1 85 kgfcm 92 ThinkPad X200 and X200s Hardware Maintenance Manual Table 23 Removal steps of LCD assembly continued 93 ThinkPad X200 and X200s Table 23 Removal steps of LCD assembly continued When installing 1 Route the antenna cables along the cable guides and secure them with the tapes As you route the cables make sure that they are not subjected to any tension Tension could cause the cables to be damaged by the cable guides or a wire to be broken 2 Make sure that the LCD connector is attached firmly 94 ThinkPad X200 and X200s Hardware Maintenance Manual 1140 Base cover assembly For access remove these FRUs in order 1010 Battery pack on page 64 1020 Hard disk drive HDD cover HDD and HDD rubber rails or solid state drive SSD and storage converter on page 65 1030 DIMM on page 69 1040 Keyboard on page 71 1050 Palm rest or palm rest with fingerprint reader on page 74 1060 Backup battery on page 77 1070 PCI Express Mini Card for wireless LAN on page 79 1080 PCI Express Mini Card for wireless WAN on page 83 1090 Intel Turbo Memory Minicard or wireless USB adapter on page 85 1100 Keyboard bezel on page 87 1110 Speaker assembly on page 88 1120 I O card assembly on page 89 1130 LCD assembly on page 91
104. e Replace only the FRU that changed the symptoms Attention The setup configuration on the computer you are servicing may have been customized Running Automatic Configuration may alter the settings Note the current configuration settings using the View Configuration option then when service has been completed verify that those settings remain in effect Strategy for replacing a hard disk drive Always try to run a low level format before replacing a hard disk drive This will cause all customer data on the hard disk to be lost Be sure that the customer has a current backup of the data before doing this task Attention The drive startup sequence in the computer you are servicing may have been changed Be extremely careful during write operations such as copying saving or formatting If you select an incorrect drive data or programs can be overwritten Important notice for replacing a system board Some components mounted on a system board are very sensitive Improper handling of a system board can cause damage to those components and may cause a system malfunction Attention When handling a system board Do not drop a system board or apply any excessive force to it Avoid rough handling of any kind Avoid bending a system board and hard pushing to prevent cracking at each BGA Ball Grid Array chipset How to use error message Use the error codes displayed on the screen to diagnose failures If more than one error
105. e drawing 7 To put the new FRU in place reverse the removal procedure and follow any notes that pertain to replacement For information about connecting and arranging internal cables see Locations on page 131 8 When replacing a FRU use the correct screw as shown in the procedures N DANGER Before removing any FRU turn off the computer unplug all power cords from electrical outlets remove the battery pack and then disconnect any interconnecting cables Attention After replacing a FRU do not turn on the computer until you have made sure that all screws springs and other small parts are in place and none are loose inside the computer Verify this by shaking the computer gently and listening for rattling sounds Metallic parts or metal flakes can cause electrical short circuits Attention The system board is sensitive to and can be damaged by electrostatic discharge Before touching it establish personal grounding by touching a ground point with one hand or by using an electrostatic discharge ESD strap P N 6405959 62 ThinkPad X200 and X200s Hardware Maintenance Manual Before servicing ThinkPad X200 and X200s Removing the SIM card Some models of the ThinkPad X200 and X200s you are servicing might have the SIM card that the customer has been installed If the computer you are servicing has the SIM card remove it before you start the servicing To remove the SIM card you need to remove the b
106. e 88 74 ThinkPad X200 and X200s 89 Table 22 Removal steps of I O card assembly continued Note The cable is secured with a double faced adhesive tape 51242 3 Gg 8 Qv E gt Bn 2 5 2 Oo Screw quantity M2 x 3 5 mm wafer head nylon coated 1 Step r and then disconnect the cable from the flip lock ZIF Turn the I O card ove connector 90 ThinkPad X200 and X200s Hardware Maintenance Manual 1130 LCD assembly For access remove these FRUs in order 1010 Battery pack on page 64 1040 Keyboard on page 71 palm rest with fing 1070 PCI Express Mini Card for wireless LAN on page 79 1080 PCI Express Mini Card for wireless WAN on page 83 1100 Keyboard bezel on page 87 1090 Intel Turbo Memory Minicard or wireless USB adapter on page 85 Step Screw quantity Color Torque M2 x 5 mm wafer head nylon coated 2 Black 0 181 Nm 1 85 kgfcm ThinkPad X200 and X200s 91 Table 23 Removal steps of LCD assembly continued Step Screw quantity Color Torque M2 x 5 mm wafer head nylon coated 2 Black 0 181 Nm 1 85 kgfcm Before step strip off the tapes securing the antenna cables and release the cables from the cable guides of the frame Step Screw quantity Color Torqu
107. e list of FRUs type in the machine type and model Example 1829 CTO under QUICK PATH Under View by Document Type select PARTS INFORMATION Under Filter by Category select SERVICE PARTS Under Parts Information by Date select SYSTEM SERVICE PARTS The list of service parts by description with applicable machine type model and FRU will be displayed Using the HMM For Key Commodities Examples hard disk drive system board microprocessor LCD and memory Use the HMM as a back up to PEW and eSupport to view the complete list of FRUs at the MT Model level 20 ThinkPad X200 and X200s Hardware Maintenance Manual Important information about replacing RoHS compliant FRUs RoHS The Restriction of Hazardous Substances in Electrical and Electronic Equipment Directive 2002 95 EC is a European Union legal requirement affecting the global electronics industry RoHS requirements must be implemented on Lenovo products placed on the market after June 2006 Products on the market before June 2006 are not required to have RoHS compliant parts If the original FRU parts are non compliant replacement parts can also be non compliant In all cases if the original FRU parts are RoHS compliant the replacement part must also be RoHS compliant Note RoHS and non RoHS FRU part numbers with the same fit and function are identified with unique FRU part numbers Lenovo plans to transition to RoHS compliance well before the implementation date an
108. e those drives Do not open 14 ThinkPad X200 and X200s Hardware Maintenance Manual A CD ROM drive a DVD ROM drive or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode Note the following N DANGER Emits visible and invisible laser radiation when open Do not stare into the beam do not view directly with optical instruments and avoid direct exposure to the beam Radia o por raio laser ao abrir N o olhe fixo no feixe de luz nao olhe diretamente por meio de instrumentos ticos e evite exposi o direta com o feixe de luz WOT RRODKR PS H E H Rayonnement laser si carter ouvert Evitez de fixer le faisceau de le regarder directement avec des instruments optiques ou de vous exposer au rayon Laserstrahlung bei ge ffnetem Ger t Nicht direkt oder ber optische Instrumente in den Laserstrahl sehen und den Strahlungsbereich meiden Kinyit skor l zersug r Ne n zzen bele se szabad szemmel se optikai eszk z kkel Ker lje a sug rnyal bbal val rintkez st Aprendo l unit vengono emesse radiazioni laser Non fissare il fascio non guardarlo direttamente con strumenti ottici e evitare l esposizione diretta al fascio
109. ectrostatic discharges Do not use this type of mat to protect yourself from electrical shock Find the room emergency power off EPO switch disconnecting switch or electrical outlet If an electrical accident occurs you can then operate the switch or unplug the power cord quickly Do not work alone under hazardous conditions or near equipment that has hazardous voltages Disconnect all power before Performing a mechanical inspection Working near power supplies Removing or installing main units Before you start to work on the machine unplug the power cord If you cannot unplug it ask the customer to power off the wall box that supplies power to the machine and to lock the wall box in the off position f you need to work on a machine that has exposed electrical circuits observe the following precautions Ensure that another person familiar with the power off controls is near you Attention Another person must be there to switch off the power if necessary Use only one hand when working with powered on electrical equipment keep the other hand in your pocket or behind your back Attention An electrical shock can occur only when there is a complete circuit By observing the above rule you may prevent a current from passing through your body When using testers set the controls correctly and use the approved probe leads and accessories for that tester Stand on suitable rubber mats obtained
110. ed by the improper insertion of a PC Card or the installation of an incompatible card mproper disc insertion or use of an optical drive Diskette drive damage caused by pressure on the diskette drive cover foreign material in the drive or the insertion of a diskette with multiple labels Damaged or bent diskette eject button Fuses blown by attachment of a nonsupported device Forgotten computer password making the computer unusable Sticky keys caused by spilling a liquid onto the keyboard Use of an incorrect ac adapter on laptop products The following symptoms might indicate damage caused by nonwarranted activities Missing parts might be a symptom of unauthorized service or modification If the spindle of a hard disk drive becomes noisy it may have been subjected to excessive force or dropped 24 ThinkPad X200 and X200s Hardware Maintenance Manual Checkout guide Use the following procedures as a guide in identifying and correcting problems with the ThinkPad computer Note The diagnostic tests are intended to test only ThinkPad products The use of non ThinkPad products prototype cards or modified options can lead to false indications of errors and invalid system responses 1 Identify the failing symptoms in as much detail as possible 2 Verify the symptoms Try to re create the failure by running the diagnostic test or by repeating the operation Generalcheckout 25 Diagnostics using PC Doctor
111. eliminate static on your body Prevent the part from touching your clothing Most clothing is insulative and retains a charge even when you are wearing a wrist strap Use the black side of a grounded work mat to provide a static free work surface The mat is especially useful when handling ESD sensitive devices Select a grounding system such as those listed below to provide protection that meets the specific service requirement Note The use of a grounding system to guard against ESD damage is desirable but not necessary Attach the ESD ground clip to any frame ground ground braid or green wire ground When working on a double insulated or battery operated system use an ESD common ground or reference point You can use coax or connector outside shells on these systems Use the round ground prong of the ac plug on ac operated computers Grounding requirements 6 Electrical grounding of the computer is required for operator safety and correct system function Proper grounding of the electrical outlet can be verified by a certified electrician ThinkPad X200 and X200s Hardware Maintenance Manual Safety notices multilingual translations The safety notices in this section are provided in English French German Hebrew Italian Japanese and Spanish Safety notice 1 Before the computer is powered on after FRU replacement make sure all screws springs and other small parts are in place and
112. er apply to any ThinkPad model that supports the PC Doctor for DOS diagnostics program Some descriptions might not apply to your particular computer Before you go to the checkout guide be sure to read the following important notes Important notes Only certified trained personnel should service the computer Before replacing any FRU read the entire page on removing and replacing FRUs When you replace FRUs use new nylon coated screws Be extremely careful during such write operations as copying saving or formatting Drives in the computer that you are servicing sequence might have been altered If you select an incorrect drive data or programs might be overwritten Replace a FRU only with another FRU of the correct model When you replace a FRU make sure that the model of the machine and the FRU part number are correct by referring to the FRU parts list A FRU should not be replaced because of a single unreproducible failure Single failures can occur for a variety of reasons that have nothing to do with a hardware defect such as cosmic radiation electrostatic discharge or software errors Consider replacing a FRU only when a problem recurs If you suspect that a FRU is defective clear the error log and run the test again If the error does not recur do not replace the FRU Be careful not to replace a nondefective FRU Copyright Lenovo 2008 23 What to do first When you do return a
113. er on a horizontal surface 2 Run Diagnostics gt ThinkPad Devices gt HDD Active Protection Test Attention Do not apply physical shock to the computer while the test is running For access remove these FRUs in order pack on page 64 1020 Hard disk drive HDD cover HDD and HDD rubber rails or solid state drive SSD and storage converter on page 65 i page 69 1040 Keyboard on page 7 1050 Palm rest or palm rest with fingerprint reader on page 74 1060 Backup battery on page 77 1070 PCI Express Mini Card for wireless LAN on page 79 1080 PCI Express Mini Card for wireless WAN on page 83 1090 Intel Turbo Memory Minicard or wireless USB adapter on page 85 1100 Keyboard bezel on page 87 1110 Speaker assembly on page 88 1120 I O card assembly on page 89 1130 LCD assembly on page 91 1140 Base cover assembly on page 95 A nA ies oO J 5 o 5 ThinkPad 200 X200s 101 Table 26 Removal steps of system board DC in connector fan and ExpressCard slot assembly for ThinkPad X200 ThinkPad X200 Following components soldered on the system board are extremely sensitive When you service the system board avoid any kind of rough handling E Accelerometer chip for the HDD Active Protection System n ICH 1 Controller Hub n CPU El MCH Memory Controller Hub Top
114. for X200s 45N3236 N 7462 CTO 4Dx 4Gx 4Ux 4 4Wx 7465 CTO 2Ex 2Hx 7466 CTO 38x 3Bx 7469 CTO 58x 5Bx 7470 CTO 68x 6Bx 2046 CTO 2047 CTO 22 Speaker kit 44C9551 N 23 ExpressCard slot 4409552 N 24 Palm rest assembly without fingerprint reader with 4534888 ae Logo plate 35W for X200 7454 CTO 2Rx 92x 7455 CTO 39x 3Cx D5x 7457 CTO 4 4Gx 4 4Ux 4Vx AWx 7458 CTO 5Ex 73x 77x 7Ex 7Fx 7Gx 7Hx 7Lx 7 7Vx 8 8Bx 8Nx 85 8Zx F2x M2x X4x X5x 7459 CTO 5Ex 6Fx 6Kx 6Rx 6Yx E3x M2x 2023 CTO 2024 CTO 168 ThinkPad X200 and X200s Hardware Maintenance Manual Table 39 Parts list Overall continued No FRU FRU no RoHS ID ID 24 Palm rest assembly with fingerprint reader with Logo 45 4890 plate 35W for X200 7454 CTO 22x 23x 24x 25x 26x 27x 28x 29x 2Gx 2Hx 2 x 2Kx 2Lx 2 2Nx 2Px 20x 2Sx 2Tx 2Ux 2Vx 2Wx 2Xx 2Yx 2Zx 93x 95x 96x 97x 98x 9Bx 9Cx 9Fx 9Gx 7455 CTO 32x 33x 34x 35x 36x 38x 3Ax 3Bx 3Dx 3Ex 3Fx 3Gx 3Hx 3 3Kx 3Lx 3Mx 3Nx 3Px 3Qx 3Rx 3Sx 3Tx 3Ux 3Wx 3Xx 3Yx 3Zx D2x D3x 7457 CTO 42x 43x 44x 45x 46x 47x 48x 49x 4Bx 4Cx 4Dx 4Ex 4Fx 4Kx 4Lx 4Mx 4Nx 4Px 4 4Rx 4Sx 4Tx 7458 CTO 52x 53x 54x 55x 56x 57x 58x 59x 5Ax 5Bx 5Cx 5Dx 5Fx 5Hx 5 5Lx 5Mx 5Nx 5Px 5Qx 5Rx
115. g Product Recovery discs Passwords on page 34 Power management on page 37 Symptom to FRU index on page 39 Service Web site When the latest maintenance diskette and the system program service diskette become available they will be posted on http www lenovo com sp Restoring the factory contents by using Product Recovery discs Copyright Lenovo 2008 When the hard disk drive HDD or solid state drive SSD is replaced because of a failure no Product Recovery program is on the new drive In this case you must use the recovery discs for the computer Order the recovery discs and the drive at the same time so that you can recover the new drive with the pre installed software when they arrive For information on which discs to order see discs on page 187 To install the factory contents by using Product Recovery discs do the following Note Recovery takes several hours The length of time depends on the method you use If you use recovery discs recovery takes at least five hours 1 Insert the bootable Start Recovery Disc into the DVD drive 2 Select your language and click Next 3 Read the license If you agree with the terms select I accept these terms and conditions and then click Next 4 Insert the Operating System Recovery Disc when prompted and click Yes to begin the operating system recovery process 5 Insert the Product Recovery Disc when prom
116. ield then leave the Enter New Password field blank and press Enter twice In the Changes have been saved window press Enter Press F10 then in the Setup confirmation window select Yes How to remove the hard disk password Attention If User only mode is selected and the user HDP has been forgotten and cannot be made available to the servicer neither Lenovo nor Lenovo authorized servicers provide any services to reset the user HDPs or to recover data from the hard disk drive The hard disk drive can be replaced for a scheduled fee To remove a user HDP that has been forgotten when the SVP and the master HDP are known do the following 1 2 Turn on the computer When the ThinkPad logo comes up immediately press F1 to enterBIOS Setup Utility For models supporting the Passphrase function press F1 while HDP icon is appearing on the screen then enter the master HDP For the other models enter the master HDP Related service information 35 Note To check whether the ThinkPad computer supports the Passphrase function enter the BIOS Setup Utility and go to Security gt Password If Using Passphrase item is displayed in the menu this function is available on the ThinkPad computer 3 Select Security using the cursor directional keys to move down the menu 4 Select Password 5 Select Hard disk x password where x is the letter of the hard disk drive A pop up window opens 6 Select Master HDP 7 Type the cur
117. ific country or region designator is specified e CRU customer replaceable unit is identified by a single asterisk or two asterisks in the CRU ID column N in the CRU ID column means that the part is not a CRU A single asterisk means that the part is a Self service CRU two asterisks means that the part is an Optional service CRU ThinkPad computers contain the following types of CRUs Self service CRUs These CRUs unplug or are held by no more than two screws Examples of these types of CRUs include an AC adapter a power cord a battery and a hard disk drive Other Self service CRUs depending on product design may include a memory a wireless card a keyboard and a palm rest with finger print reader and touchpad Optional service CRUs These CRUs are isolated parts within the computer that are concealed by an access panel that is typically secured by more than two screws Once the access panel is removed the specific CRU is visible A RoHS compliant FRU is identified by an R An N in the RoHS ID column means the part is not a RoHS compliant FRU e FRUs marked with J are available as options 136 ThinkPad X200 and X200s Hardware Maintenance Manual Overall 137 ThinkPad X200 and X200s Table 39 Parts list Overall No FRU FRU no RoHS CRU ID ID See Miscellaneous pars om page 185 1 LCD unit Gee ECD FRUS on page 71 2 bezel assembly 44C9542 R N
118. igure 100 ThinkPad X200 and X200s Hardware Maintenance Manual 1150 Systemboard DC in connector fan and ExpressCard slot assembly Important notices for handling the system board When handling the system board bear the following in mind The system board has an accelerometer which can be broken by applying several thousands of G forces Note Dropping a system board from a height of as little as 6 inches so that it falls flat on a hard bench can subject the accelerometer to as much as 6 000 G s of shock Be careful not to drop the system board on a bench top that has a hard surface such as metal wood or composite If a system board is dropped you must test it using PC Doctor for DOS to make sure that the HDD Active Protection still functions see below Note If the test shows that HDD Active Protection is not functioning be sure to document the drop in any reject report and replace the system board Avoid rough handling of any kind At every point in the process be sure not to drop or stack the system board f you put a system board down be sure to put it only on a padded surface such as an ESD mat or conductive corrugated material After replacing the system board run PC Doctor for DOS to make sure that HDD Active Protection still functions The procedure is as follows 1 Place the comput
119. ing station or the port replicator Printer mouse and other external devices Battery pack Hard disk drive External diskette drive or optical drive DIMM Optical disk or diskette in the internal drive PC Cards 4 Turn on the computer Determine whether the problem has been solved If the problem does not recur reconnect the removed devices one at a time until you find the failing FRU 7 If the problem remains replace the following FRUs one at a time do not replace a nondefective FRU a System board b LCD assembly oon 46 ThinkPad X200 and X200s Hardware Maintenance Manual ThinkPad X200 and X200s This chapter presents following product specific service references and product specific parts information Specifications on page 48 77 Status indicators on page 51 tests on page 53 Locations on page 131 Parts list on page 136 Copyright Lenovo 2008 47 Specifications The following table lists the specifications of the ThinkPad X200 and X200s Table 7 Specifications Feature Description Processor Intel Core 2 Duo processor P8400 2 26 GHz 1066 MHz FSB 3 L2 cache Intel Core 2 Duo processor P8600 2 4 GHz 1066 MHz FSB 3 MB L2 cache Intel Core 2 Duo processor P8700 2 53 GHz 1066 MHz FSB 3 MB L2 cache Intel Core 2 Duo processor T9400 2 53 GHz 1066 MHz FSB 6 L2 cache Intel Core 2 Duo processor
120. ion on it if possible Never remove the drive while the system is operating or is in suspend mode Table 12 Removal steps of HDD cover HDD and HDD drive rubber rails or SSD and storage converter Step Screw quantity Color Torque Hard disk drive screw M3 x 3 mm Black 0 392 Nm wafer head nylon coated 1 4 kgfcm ThinkPad X200 and X200s 65 Table 12 Removal steps of HDD cover HDD and HDD drive rubber rails or SSD and storage converter continued Se When installing Make sure that the HDD connector or SSD connector is attached firmly 66 ThinkPad X200 and X200s Hardware Maintenance Manual Table 12 Removal steps of HDD cover HDD and HDD drive rubber rails SSD and storage converter continued HDD and HDD rubber rails When installing The rubber rails on the hard disk drive must be attached to the replacement drive Otherwise the drive cannot be installed properly SSD and storage converter ThinkPad X200 and X200s 67 Table 12 Removal steps of HDD cover HDD and HDD drive rubber rails SSD and storage converter continued When installing When you install the SSD in the storage converter do as follows 68 ThinkPad X200 and X200s Hardware Maintenance Manual 1030 DIMM For access remove this FRU in order e 1010 Battery pack on page 64 Table 13 Removal steps of dimm Remove the DIMM slot cover as shown in this figure Note Loosen
121. k 0 392 Nm nylon coated 3 4 kgfcm In step B detach the claws Then remove the LCD front bezel When installing Make sure that all the claws are attached firmly 110 ThinkPad X200 and X200s Hardware Maintenance Manual Table 29 Removal steps of LCD front bezel for 12 1 in WXGA LCD model 12 1 in WXGA LCD model Step Screw Screw quantity Color Torque O M2 5 x 4 mm wafer head Black 0 392 Nm nylon coated 2 4 kgfcm BH 25 x A mm wafer head Black 0 392 Nm nylon coated 5 4 kgfcm C M2 x 3 5 mm wafer head Silver 0 181 Nm nylon coated 4 1 85 kgfcm ThinkPad X200 and X200s 111 Table 29 Removal steps of LCD front bezel for 12 1 in WXGA LCD model continued In step W and H detach the claws Then remove the LCD front bezel When installing Make sure that all the claws are attached firmly 112 ThinkPad X200 and X200s Hardware Maintenance Manual 2020 Inverter card For access remove these FRUs in order e 1010 Battery pack on page 64 2010 LCD front bezel on page 110 Table 30 Removal steps of inverter card Note 12 1 in WXGA LCD models do not have the inverter card Step Screw quantity Color Torque M2 x 3 5 mm wafer head nylon coated 1 Silver 0 181 Nm 1 85 kgfcm When installing Make sure that the connector and attached firmly Cabling When replacing the inverter card ro
122. k drive HDD cover HDD and HDD rubber rails or solid state drive storage converter 1030 DIMM 1040 Keyboard 2 1050 Palm rest or palm rest with fingerprint reader 1060 Backup battery 1070 PCI Express Mini Card for wireless LAN 1080 PCI Express Mini Card for wireless WAN 1090 Intel Turbo Memory Minicard or wireless USB adapter 1100 Keyboard bezel 1110 Speaker assembly 1120 I O card assembly 1130 LCD assembly 1140 Base cover assembly 1150 Systemboard DC in connector TA and ExpressCard slot assembly 2010 LCD front bezel 2020 Inverter card 2030 Bluetooth daughter BDC 2 1 2040 Integrated camera 2050 LCD panel LCD brackets LCD cable 2060 Hinges and hinge brackets 2070 LCD rear cover and wireless antena cables Locations Front view Rear view Bottom view Rear view ThinkPad X200 UltraBase Bottom view ThinkPad X200 UltraBase Parts list Overall LCD FRUs Keyboard Miscellaneous parts AC adapters 44 45 46 46 47 48 ol 53 55 58 58 99 62 63 64 65 69 71 74 NU 79 83 85 87 88 89 91 2 99 101 110 113 114 115 116 122 125 131 131 132 133 134 21835 136 137 171 184 185 185 iii Power cords 186 Notices 197 Recovery discs lt s c 187 Trademarks
123. kly change the power state of each feature in the list Note If you want to use 5 to enable the wireless feature the following device drivers must be installed on the computer beforehand ThinkPad Power Management driver OnScreen Display Utility Wireless device drivers Fn F6 Reserved ThinkPad X200 and X200s 55 Table 10 Fn key combinations continued Key combination Description 7 Fn F8 Apply a presentation scheme directly with no need to start Presentation Director To disable this function and use the Fn F7 key combination for switching a display output location start Presentation Director and change the settings Switch a display output location External monitor CRT display Computer display and external monitor LCD CRT display Computer display LCD Notes 1 This function is not supported if different desktop images are displayed on the computer display and the external monitor the Extend desktop function 2 This function does not work while a DVD movie or a video clip is playing To enable this function start Presentation Director and change the Fn F7 settings Note Multiple users can log on to a single operating system by using different user IDs Each user needs to change the settings Change the settings of the input device Fn F9 Open the ThinkPad EasyEject Utility screen Buttons for the following choices are displayed
124. l number of the system unit is listed as follows 20 Serial number Write down that number Note The serial number of the system unit is also written on the label attached to the bottom of the computer After you have replaced the system board restore the serial number by doing the following 1 Install the ThinkPad Hardware Maintenance Diskette Version 1 73 or later and restart the computer 2 From the main menu select 1 Set System Identification 3 Select 1 Add S N data from EEPROM Follow the instructions on the screen If the MTM and Product ID numbers differ from each other on the rear label use what is shown for the Product ID field See example below MTM on rear label TTTT CTO S N SSSSSSS Product ID on rear label TTTI MMM Use this number when setting Serial Number In the example the Serial Number to be input is 1STTTTMMMSSSSSSS Retaining the UUID The Universally Unique Identifier UUID is a 128 bit number uniquely assigned to your computer at production and stored in the EEPROM of your system board The algorithm that generates the number is designed to provide unique IDs until the year A D 3400 No two computers in the world have the same number ThinkPad X200 and X200s 59 When you replace the system board you must set the UUID on the new system board as follows 1 Install the ThinkPad Hardware Maintenance Diskette Version 1 73 or later and restart the computer 2 From the main men
125. la r glementation en vigueur Lorsque vous remplacez la batterie veillez n utiliser que les mod les cit s dans la liste de pi ces d tach es ad quate En effet une batterie inappropri e risque de prendre feu ou d exploser Akkus enthalten geringe Mengen von Nickel Sie d rfen nicht zerlegt wiederaufgeladen kurzgeschlossen oder Feuer oder Wasser ausgesetzt werden Bei der Entsorgung die rtlichen Bestimmungen f r Sonderm ll beachten Beim Ersetzen der Batterie nur Batterien des Typs verwenden der in der Ersatzteilliste aufgef hrt ist Der Einsatz falscher Batterien kann zu Entz ndung oder Explosion f hren 59 705 ADDI 17937119 n551on TANI NN 7499 PR OPATI DN PIVI V AIMN 43525 YN 09199 IN WNI IMN 29 WINI DINDON n551o0n TINNA 155103 p YANYAD DONNA t p5nn m v n svan 5159 NI 55103 19350 AINA SW IN nnsn5 27537 La batteria contiene piccole quantit di nichel Non smontarla gettarla nel fuoco o nell acqua n cortocircuitarla Smaltirla secondo la normativa in vigore DPR 915 82 successive disposizioni e disposizioni locali Quando si sostituisce la batteria utilizzare soltanto i tipi inseriti nell appropriato Catalogo parti L impiego di una batteria non adatta potrebbe determinare l incendio o l esplosione della batteria stessa RIF 1 AMVFV
126. ld cause the cables to be damaged by the cable guides or a wire to be broken 130 ThinkPad X200 and X200s Hardware Maintenance Manual Locations Front view oN EISE aano ThinkLight Integrated camera for some models Status indicators Note For the description of each indicator see Status indicators on page Power switch Security keyhole Hard disk drive HDD or solid state drive SSD RJ 11 modem connector Microphone jack Stereo headphone jack Universal serial bus USB connector TrackPoint pointing stick Fingerprint reader for some models Touch pad buttons Volume control buttons ThinkVantage button Built in microphone ThinkPad X200 and X200s 131 Rear view ExpressCard slot Wireless radio switch Universal Serial Bus USB connector RJ 45 Ethernet connector External monitor connector Universal serial bus USB connector AC power connector Bluetooth antenna for some models Status indicators Note For the description of each indicator see Status indicators on page E 132 ThinkPad X200 and X200s Hardware Maintenance Manual Bottom view Battery pack Battery pack latch Docking connector DIMM slots LCD cover latch Built in speaker 5 in 1 Media Card Reader or 3 in 1 Media Card Reader slot Hard disk drive HDD or solid state drive SSD ThinkPad X200 X200s 133 Rear view ThinkPad X200 UltraBase AC power connector
127. lified Chinese 46V3638 ThinkPad X200 and X200s 193 Windows Vista Ultimate 32 bit DVDs Windows Vista Ultimate 32 bit is preinstalled as the operating system in the following models e 7454 CTO e 7455 7457 7458 CTO 5 x 5Px 51 7Bx F9x 7459 CTO 66x 4 e 2023 CTO e 2024 CTO 7462 7465 7466 CTO 7469 5Wx 7470 2046 CTO e 2047 CTO Table 52 Parts list Windows Vista Ultimate 32 bit DVDs Language P N RoHS CRU ID ID Czech 46V3617 R N Danish 46V3618 English 46V3634 French 46V3619 German 46 3621 Greek 46V3620 Hebrew 46V3622 Hungarian 46V3624 Italian 46V3625 Norwegian 46V3626 Polish 46V3627 Romanian 46V3628 Serbian Latin 46V3632 Simplified Chinese 46V3615 Slovak 46V3629 Slovenian 46V3630 Spanish 46V3631 Traditional Chinese 46V3616 Traditional Chinese Hong Kong S A R 46V3623 Turkish 46V3633 194 ThinkPad X200 and X200s Hardware Maintenance Manual Common service tools Table 53 Parts list Common service tools Tool P N Screwdriver kit 95F3598 1 4 drive spinner handle 1650840 1 4 Sq to 1 4 hex torx adapter 93F2838 TRZ TR 10 tamper resistant torx bits 00P6967 Removal tool antenna RF connector 08K7159 USB 2 0 CD RW DVD ROM combo drive II 40Y8687 USB cable 40Y8704 USB floppy
128. limentazione rimuovere la batteria e poi scollegare i cavi di interconnessione FRU EHX0Fi B ThinkPad O JE WC TX CORBMIA RSV KE 22 9 TV 91 lt Antes de quitar una FRU apague el sistema desenchufe todos los cables de las tomas de corriente el ctrica quite la bater a y a continuaci n desconecte cualquier cable de conexi n entre dispositivos Safety information 13 Laser compliance statement Some models of ThinkPad computer are equipped from the factory with an optical storage device such as a CD ROM drive or a DVD ROM drive Such devices are also sold separately as options If one of these drives is installed it is certified in the U S to conform to the requirements of the Department of Health and Human Services 21 Code of Federal Regulations DHHS 21 CFR Subchapter for Class 1 laser products Elsewhere the drive is certified to conform to the requirements of the International Electrotechnical Commission IEC 825 and CENELEC EN 60 825 for Class 1 laser products If a CD ROM drive a DVD ROM drive or another laser device is installed note the following CAUTION Use of controls or adjustments or performance of procedures other than those specified herein might result in hazardous radiation exposure O uso de controles ajustes ou desempenho de procedimentos diferentes daqueles aqui especificados pode resultar em perigosa exposi o radia
129. lity for DOS The utility is available on the following Web site http www lenovo com support Testing the computer To run the test do as follows Note In the following procedure you can select an item not only with the arrow keys but also with the TrackPoint pointer Instead of pressing Enter click the left button 1 Insert the PC Doctor disk into the diskette drive then power on the computer If the computer cannot be powered on go to Power system checkout on page 29 check the power sources If an error code appears go to Symptom to FRU index on page 39 On the first screen select the model and press Enter Follow the instructions on the screen 2 The main panel of PC Doctor appears 3 Select Diagnostics with the arrow keys and press Enter A pull down menu appears Its exact form depends on the model 26 ThinkPad X200 and X200s Hardware Maintenance Manual Note PC Doctor menu does not mean the formal support device list Some unsupported device names may appear in the PC Doctor menu Diagnostics Interactive Tests Hardware Tnfo Utility Quit Normal Test Run Quick Test CPU Coprocessor Systemboard Video Adapter Serial Ports Parallel Ports Fixed Disks Diskette Drives Other Devices Communication Wireless LAN PM Memory PC DOCTOR 2 0 Copyright 2002 PC Doctor Inc Rights Reserved Use the curso
130. llez n utiliser que les mod les cit s dans la liste de pi ces d tach es ad quate Une batterie ou une pile inappropri e risque de prendre feu ou d exploser Die Bereitschaftsbatterie die sich unter dem Diskettenlaufwerk befindet kann geringe Mengen Nickel und Cadmium enthalten Sie darf nur durch die Verkaufsstelle oder den IBM Kundendienst ausgetauscht werden Sie darf nicht zerlegt wiederaufgeladen kurzgeschlossen oder Feuer oder Wasser ausgesetzt werden Die Batterie kann schwere Verbrennungen oder Ver tzungen verursachen Bei der Entsorgung die rtlichen Bestimmungen f r Sonderm ll beachten Beim Ersetzen der Bereitschafts oder Systembatterie nur Batterien des Typs verwenden der in der Ersatzteilliste aufgef hrt ist Der Einsatz falscher Batterien kann zu Entz ndung oder Explosion f hren mop 922 719220 Na ANNA MINO ninnn NIV p525 yx TP 90990 UNI N 2055 Uh nw YOI n55Yon DN v AMN 4375 YN 07735 MPN n SY WINI DPIN 755103 p vnnuns 5129 TION NI AIDA UVP IDET 20 mssann IN ANAT o5 Alcune batterie di riserva contengono una piccola quantit di nichel e cadmio Non smontarle ricaricarle gettarle nel fuoco o nell acqua n cortocircuitarle Smaltirle secondo la normativa in vigore DPR 915 82 successive disposizioni e disposizioni locali Quando si sostituisce la batteria dell RTC real time clock o la batteria di supporto utilizzare so
131. locali L impiego di una batteria non adatta potrebbe determinare l incendio o l esplosione della batteria stessa 17 52 7 77 41 KR 27 13 05211 DIET NVYIT YA gt RYT V ORB ZOER 5 100 C 2127 F KITT LILA CCK KS VN C YyTU EBE 53 8180 AREORA T EEN 385972 2922 7 7 7540 ES Rok Ay TU ERIT AL NYFF 0 0 BELIEVFAZLLBHVEF La bateria de repuesto es una bateria de litio y puede provocar incendios explosiones quemaduras graves No la recargue ni quite el conector polarizado ni la desmonte ni caliente por encima de los 100 C 212 F ni la incinere ni exponga el contenido de sus celdas al agua Des chela tal como dispone la normativa local 10 ThinkPad X200 and X200s Hardware Maintenance Manual Safety notice 5 If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands immediately wash the affected areas with water for at least 15 minutes Seek medical care if any symptoms from the fluid are present after washing Si le panneau d affichage cristaux liquides se brise et que vous recevez dans les yeux ou sur les mains une partie du fluide rincez les abondamment pendant au moins quinze minutes Consultez un m decin si des sympt mes persistent apr s le lavage Die Leuchtstoffr hre im LCD Bildschirm enth lt Quecksilber Bei der Entsorgung die rtlichen Bestim
132. ltanto i tipi inseriti nell appropriato Catalogo parti L impiego di una batteria non adatta potrebbe determinare l incendio o l esplosione della batteria stessa 7 FR VABEENTWS DORA V X4 172007 T 77 042 BIB KEKIIKOP ORR 7441 12452 072 ESV NY TU ERTS SEO lt RV 1071 70 VAR HOR YT ESV 7 7 797 248 L NYT 0 5 KLEDO BHELEVTSZILERSVEF Algunas bater as de reserva contienen una cantidad de n quel y cadmio No las desmonte ni recargue ni las eche al fuego o al agua ni las cortocircuite Des chelas tal como dispone la normativa local Utilice s lo bater as que se encuentren en 1 lista de piezas La utilizaci n de una bater a no apropiada puede provocar la ignici n o explosi n de la misma ThinkPad X200 and X200s Hardware Maintenance Manual Safety notice 3 N DANGER The battery pack contains small amounts of nickel Do not disassemble it throw it into fire or water or short circuit it Dispose of the battery pack as required by local ordinances or regulations Use only the battery in the appropriate parts listing when replacing the battery pack Use of an incorrect battery can result in ignition or explosion of the battery La batterie contient du nickel Ne la d montez pas ne l exposez ni au feu ni l eau Ne la mettez pas en court circuit Pour la mettre au rebut conformez vous
133. mungen f r Sonderm ll beachten Der LCD Bildschirm besteht aus Glas und kann zerbrechen wenn er unsachgem f behandelt wird oder der Computer auf den Boden fallt Wenn der Bildschirm besch digt ist und die darin befindliche Fl ssigkeit in Kontakt mit Haut und Augen ger t sollten die betroffenen Stellen mindestens 15 Minuten mit Wasser abgesp lt und bei Beschwerden anschlie end ein Arzt aufgesucht werden 2vom aav LCD WN ON 002 DNA DYN DINAN NN oY DDT YN D DY DYIIN 0 n90n ON MNO nw NIAPI 99 mno MPT 15 YOY ANNI DIVNI DMN OY YINI Nel caso che caso l LCD si dovesse rompere ed il liquido in esso contenuto entrasse in contatto con gli occhi o le mani lavare immediatamente le parti interessate con acqua corrente per almeno 15 minuti poi consultare un medico se i sintomi dovessero permanere LCD LCD LERA W EBAY 29272 423515 AVE WELT lt PERV Dev WD C o CHS 2 05E1R23 1 57 Si la LCD se rompe y el fluido de su interior entra en contacto con sus ojos o sus manos lave inmediatamente las reas afectadas con agua durante 15 minutos como m nimo Obtenga atenci n medica si se presenta alg n s ntoma del fluido despues de lavarse Safety information 11 Safety notice 6 N DANGER To avoid shock do not remove the plastic cover that protects the lo
134. n abnormal 2 Reseat all LCD connectors Wrong color displayed 3 LCD assembly 4 System board Horizontal or vertical lines displayed on LCD assembly LCD Related service information 45 Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardware defect such as cosmic radiation electrostatic discharge or software errors FRU replacement should be considered only when a problem recurs When analyzing an intermittent problem do the following 1 Run the diagnostic test for the system board in loop mode at least 10 times 2 If no error is detected do not replace any FRUs 3 If any error is detected replace the FRU shown by the FRU code Rerun the test to verify that no more errors exist Undetermined problems If the diagnostic tests did not identify the adapter or device that has failed if wrong devices are installed or if the system simply is not operating follow these procedures to isolate the failing FRU do not isolate FRUs that have no defects Verify that all attached devices are supported by the computer Verify that the power supply being used at the time of the failure is operating correctly Geo Power system checkout on page 25 1 Turn off the computer 2 Visually check each FRU for damage Replace any damaged FRU 3 Remove or disconnect all of the following devices Non ThinkPad devices Devices attached to the dock
135. nform ment la r glementation en vigueur Une pile inappropri e risque de prendre feu ou d exploser Die Systembatterie ist eine Lithiumbatterie Sie kann sich entz nden explodieren oder schwere Verbrennungen hervorrufen Batterien dieses Typs d rfen nicht aufgeladen zerlegt ber 100 C erhitzt oder verbrannt werden Auch darf ihr Inhalt nicht mit Wasser in Verbindung gebracht oder der zur richtigen Polung angebrachte Verbindungsstecker entfernt werden Bei der Entsorgung die rtlichen Bestimmungen f r Sonderm ll beachten Beim Ersetzen der Batterie nur Batterien des Typs verwenden der in der Ersatzteilliste aufgef hrt ist Der Einsatz falscher Batterien kann zu Entz ndung oder Explosion f hren sx39nn5 n2 4v5 Od 735359 00989977 09900 SANNA DN DIVI 7 AMIN 105 PN mug N99 105231205 AMIN DANI IN nw n5V 2092097 PRI n55Y0n NN 41505 PN 099178 70550 100 29 n51yn 09735 n5510n DN v 02025 NN WAT n55103 p Ww OPIN mpna AINA Naw SMSO IN DDAW 3209 01535 53159 NINN La batteria di supporto una batteria al litio e puo incendiarsi esplodere procurare gravi ustioni Evitare di ricaricarla smontarne il connettore polarizzato smontarla riscaldarla ad una temperatura superiore ai 100 gradi centigradi incendiarla o gettarla in acqua Smaltirla secondo la normativa in vigore DPR 915 82 successive disposizioni e disposizioni
136. ng message 2 System board 01C9 More than one Ethernet devices are found Remove one of them Press Esc to continue 1 Remove the Ethernet device that you installed or press Esc to ignore the warning message 2 System board 01CA More than one Wireless LAN devices are found Remove one of them 1 Remove the wireless LAN device that you installed 2 System board 0200 Hard disk error The hard disk is not working 1 Reseat the hard disk drive 2 Load Setup Defaults in BIOS Setup Utility 3 Hard disk drive 4 System board 021x Run interactive tests of the keyboard and Keyboard error the auxiliary input device 0220 Load Setup Defaults in BIOS Setup Utility Monitor type error Monitor type does not match the one specified in CMOS 0230 Shadow RAM error Shadow RAM fails at offset nnnn System board 0231 System RAM error System RAM fails at offset nnnn 1 DIMM 2 System board 0232 Extended RAM error Extended RAM fails at offset nnnn DIMM 2 System board 40 ThinkPad X200 and X200s Hardware Maintenance Manual Table 1 Numeric error codes continued Symptom or error FRU or action in sequence 0250 System battery error System battery is dead 1 Charge the backup battery for more than 8 hours by connecting the ac adapter Replace the backup battery and run BIOS Setup Utility to reset the time and
137. nkPad Devices HDD Active Protection Test 2010 Warning Your internal hard disk drive HDD may not function correctly on this system Ensure that your HDD is supported on this system and that the latest HDD firmware is installed Inform the following information to the customer If in the primary bay the customer is using a non IBM or non Lenovo hard disk drive HDD or an old generation IBM HDD which is not supported by this system with the risk in mind the customer can still use it by pressing ESC If in the primary drive bay the customer is using a supported IBM Lenovo HDD with an old firmware the customer needs to update its firmware to the latest The latest version is available at http www lenovo com support 2100 Initialization error on HDDO Main hard disk drive Reseat the hard disk drive Main hard disk drive System board 2102 Initialization error on HDD1 Ultrabay hard disk drive Reseat the hard disk drive Ultrabay hard disk drive System board 2110 Read error on Main hard disk drive Reseat the hard disk drive Main hard disk drive System board 2112 Read error on HDD1 Ultrabay hard disk drive Reseat the hard disk drive Ultrabay hard disk drive System board e m regem e qe 42 ThinkPad X200 and X200s Hardware Maintenance Manual Error messages Table 2 Error messages Symptom or error FRU or action in sequence
138. o BLS BA WE 1720 RSPR RAR Pour viter tout risque d exposition au rayon laser respectez les consignes de r glage et d utilisation des commandes ainsi que les proc dures d crites Werden Steuer und Einstellelemente anders als hier festgesetzt verwendet kann gefahrliche Laserstrahlung auftreten Az itt el rt elj r sokt l be ll t sokt l s vez rl sekt l elt rni a l zersug rz s vesz lye miatt kock zatos L utilizzo di controlli regolazioni o l esecuzione di procedure diverse da quelle specificate possono provocare l esposizione a Pou itie kontr l prav alebo in ch vykonan od in ch v robcov ako je v tomto pecifikovan mohlo by ma za n sledok nebezpe enstvo vystavenia sa vy iarovaniu BERICLS HIE 71 47 KBE VM EO BR 0978 840450 ET El uso de controles o ajustes la ejecuci n de procedimientos distintos de los aqui especificados puede provocar la exposici n a radiaciones peligrosas Opening the CD ROM drive the DVD ROM drive or any other optical storage device could result in exposure to hazardous laser radiation There are no serviceable parts insid
139. o Web sites are provided for convenience only and do not in any manner serve as an endorsement of those Web sites The materials at those Web sites are not part of the materials for this Lenovo product and use of those Web sites is at your own risk Any performance data contained herein was determined in a controlled environment Therefore the result obtained in other operating environments may 197 vary significantly Some measurements may have been made on development level systems and there is no guarantee that these measurements will be the same on generally available systems Furthermore some measurements may have been estimated through extrapolation Actual results may vary Users of this document should verify the applicable data for their specific environment Trademarks The following terms are trademarks of Lenovo in the United States other countries or both Active Protection System Lenovo Rescue and Recovery ThinkLight ThinkPad ThinkVantage TrackPoint Ultrabay The following terms are trademarks of the International Business Machines Corporation in the United States other countries or both IBM used under license The following terms are trademarks of Microsoft Corporation in the United States other countries or both Windows Windows Vista The following are trademarks of Intel Corporation or its subsidiaries in the United States other countries or both Intel Intel Celeron Intel
140. oms and errors and their possible causes The most likely cause is listed first in boldface type Note Do the FRU replacement or other actions in the sequence shown in the column headed FRU or action in sequence If replacing a FRU does not solve the problem put the original part back in the computer Do not replace a nondefective FRU This index can also help you determine during regular servicing what FRUs are likely to need to be replaced next A numeric error is displayed for each error detected in POST or system operation In the displays n can be any number If no numeric code is displayed check the narrative descriptions of symptoms If the symptom is not described there go to Intermittent problems on page 46 Note For a device not supported by diagnostic codes in the ThinkPad computers see the manual for that device Numeric error codes Table 1 Numeric error codes Symptom or error FRU or action in sequence 0175 System board Bad CRC1 stop POST task The EEPROM checksum is not correct 0176 1 Run BIOS Setup Utility and save the System Security The system has been current setting by pressing 10 tampered with 2 System board 0177 System board Bad SVP data stop POST task The checksum of the supervisor password in the EEPROM is not correct 0182 1 Run BIOS Setup Utility Press F9 and Bad CRC2 Enter BIOS Setup and load Setup Enter to load the def
141. oose clothing that can be trapped in the moving parts of a machine Make sure that your sleeves are fastened or rolled up above your elbows If your hair is long fasten it Insert the ends of your necktie or scarf inside clothing or fasten it with a nonconductive clip about 8 centimeters 3 inches from the end Do not wear jewelry chains metal frame eyeglasses or metal fasteners for your clothing Attention Metal objects are good electrical conductors Wear safety glasses when you are hammering drilling soldering cutting wire attaching springs using solvents or working in any other conditions that might be hazardous to your eyes After service reinstall all safety shields guards labels and ground wires Replace any safety device that is worn or defective Reinstall all covers correctly before returning the machine to the customer Fan louvers on the machine help to prevent overheating of internal components Do not obstruct fan louvers or cover them with labels or stickers 2 ThinkPad X200 and X200s Hardware Maintenance Manual Electrical safety Observe the following rules when working on electrical equipment Important Use only approved tools and test equipment Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents Many customers have near their equipment rubber floor mats that contain small conductive fibers to decrease el
142. ower remaining when installed in the computer Perform operational charging If the battery status indicator or icon does not turn on remove the battery pack and let it return to room temperature Reinstall the battery pack If the charge indicator or icon still does not turn on replace the battery pack If the charge indicator still does not turn on replace the system board Then reinstall the battery pack If it is still not charged go to the next section Checking the battery pack Battery charging does not start until the Power Meter shows that less than 95 of the total power remains under this condition the battery pack can charge to 100 of its capacity This protects the battery pack from being overcharged or from having a shortened life To check your battery move your cursor to the Power Meter icon in the icon tray of the Windows taskbar and wait for a moment but do not click and the percentage of battery power remaining is displayed To get detailed information about the battery double click the Power Meter icon Note If the battery pack becomes hot it may not be able to charge Remove it from the computer and leave it at room temperature for a while After it cools down reinstall and recharge it To check the battery pack do the following 1 Power off the computer 2 Remove the battery pack and measure the voltage between battery terminals 1 and 7 See the following figure Terminal Voltage
143. password The system board must be replaced for a scheduled fee 34 ThinkPad X200 and X200s Hardware Maintenance Manual How to remove the power on password To remove a POP that you have forgotten do the following A If no SVP has been set 1 2 5 Turn off the computer Remove the battery pack For how to remove the battery pack see 1010 Battery pack on page 64 Remove the backup battery For how to remove the backup battery see 1060 Backup battery on page 77 Turn on the computer and wait until the POST ends After the POST ends the password prompt does not appear The POP has been removed Reinstall the backup battery and the battery pack B If an SVP has been set and is known by the servicer 1 2 o ge o N Turn on the computer When the ThinkPad logo comes up immediately press F1 to enterBIOS Setup Utility For models supporting the Passphrase function press 1 while the POP icon is appearing on the screen then enter the POP For the other models enter the POP Note To check whether the ThinkPad computer supports the Passphrase function enter the BIOS Setup Utility and go to Security gt Password If the Using Passphrase item is displayed in the menu this function is available on the ThinkPad computer Select Security using the cursor directional keys to move down the menu Select Password Select Power On Password Type the current SVP in the Enter Current Password f
144. pted and click OK 6 If you have a Supplemental Recovery Disc insert it when prompted and click Yes If you do not have a Supplemental Recovery Disc click No Note Not all recovery disc sets come with a Supplemental Recovery Disc If there is a Supplemental Recovery Disc it will be clearly marked as such 7 When all of the data has been copied from the last disc in the set a message is displayed prompting you to restart the computer Remove the disc and then click Yes Note The remainder of the recovery process is fully automated and no action is required by you The computer will restart into the Windows desktop several times and you might experience periods when no activity is apparent on the screen for several minutes at a time This is normal 33 8 When the recovery process is complete the Welcome to Microsoft Windows screen is displayed Follow the instructions on the screen to complete the Windows setup Passwords As many as three passwords may be needed for any ThinkPad computer the power on password POP the hard disk password HDP and the supervisor password SVP If any of these passwords has been set a prompt for it appears on the screen whenever the computer is turned on The computer does not start until the password is entered Exception If only an SVP is installed the password prompt does not appear when the operating system is booted Power on password power on password POP protect
145. r keys and ESC to move in menus Press ENTER to select The options on the test menu are as follows Diagnostics Interactive Tests Run Normal Test Keyboard Run Quick Test Video CPU Coprocessor nternal Speaker Systemboard Mouse Video Adapter Diskette Serial Ports System Load Parallel Ports Optical Drive Test Fixed Disks ntel 5 WLAN Radio Test Diskette Drives Other Devices ThinkPad Devices Communication Wireless LAN PM Memory Notes n the Keyboard test in Interactive Tests the Fn key should be held down for at least 2 seconds otherwise it cannot be sensed Video Adapter test supports only the LCD display on the ThinkPad computer If you have an external monitor attached to your computer detach it before running PC Doctor for DOS To test Digital Signature Chip the security chip must be set to Active 4 Run the applicable function test 5 Follow the instructions on the screen If there is a problem PC Doctor shows messages describing it 6 To exit the test select Quit Exit Diag To cancel the test press Esc Note After running PC Doctor check the time and date on the system and reset them if they are incorrect Generalcheckout 27 Detecting system information with PC Doctor PC Doctor can detect the following system information Hardware Info System Configuration Memory Contents Physical Disk Drives
146. rdware Maintenance Manual Table 26 Removal steps of system board DC in connector fan and ExpressCard slot assembly for ThinkPad X200 continued Note The ExpressCard slot assembly is attached to the system board Step Screw quantity M2 x 3 5 mm flat head nylon coated 1 Color Silver Torque 0 181 Nm 1 85 kgfcm Turn the system board over and then remove the ExpressCard slot assembly from the system board ThinkPad X200 and X200s 105 Table 27 Removal steps of system board DC in connector fan ExpressCard slot assembly for ThinkPad X200s ThinkPad X200s Following components soldered on the system board are extremely sensitive When you service the system board avoid any kind of rough handling B I O Controller Hub Memory Controller Hub Accelerometer chip for the HDD Active Protection System Top Bottom 106 ThinkPad X200 and X200s Hardware Maintenance Manual Table 27 Removal steps of system board DC in connector fan and ExpressCard slot assembly for ThinkPad X200s continued Note The DC in connector and the fan assembly are attached to the underside of the system board When installing Make sure that the DC in connector and the fan connector are attached to the system board firmly Step Screw quantity Color Torque M2 x 3 5
147. rent master HDP in the Enter Current Password field then leave the Enter New Password field blank and press Enter twice 8 Press F10 9 Select Yes in the Setup Configuration window Both user HDP and master HDP will have been removed 36 ThinkPad X200 and X200s Hardware Maintenance Manual Power management To reduce power consumption the computer has three power management modes screen blank standby and hibernation Screen blank mode If the time set on the Turn off monitor timer in the operating system expires the LCD backlight turns off To put the computer into screen blank mode press the ThinkVantage button and use the ThinkVantage Productivity Center To end screen blank mode and resume normal operation press any key Standby mode When the computer enters standby mode the following events occur in addition to what occurs in screen blank mode The LCD is powered off The hard disk drive is powered off The CPU stops To enter standby mode press Fn F4 Note If you are using the ACPI operating system you can change the action of Fn F4 In certain circumstances the computer goes into standby mode automatically suspend time has been set on the timer and the user does not do any operation with the keyboard the TrackPoint the hard disk the parallel connector or the diskette drive within that time f the battery indicator blinks orange indicating that the battery power is low
148. rews to secure the palm rest 76 ThinkPad X200 and X200s Hardware Maintenance Manual 1060 N DANGER Use only the battery specified in the parts list for your computer Any other battery could ignite or explode For access remove these FRUs in order 1010 Battery pack on page 64 1040 Keyboard on page 71 ThinkPad X200 and 2008 77 Table 16 Removal steps of backup battery continued When installing Make sure that the battery connector is attached firmly 78 ThinkPad X200 and X200s Hardware Maintenance Manual 1070 PCI Express Mini Card for wireless LAN For access remove these FRUs in order 1010 Battery pack on page 64 1040 Keyboard on page 71 1050 Palm rest or palm rest with fingerprint reader on page 74 Table 17 Removal steps of PCI Express Mini Card for wireless LAN Full size PCI Express Mini Card In step unplug the jacks by using the removal tool antenna RF connector P N 08K7159 or pick the connectors with your fingers and gently unplug them in direction of the arrow Note Some models might have two antenna cables in step H Step Screw quantity Color Torque BH M2 x mm wafer head nylon coated 2 Black 0 181 Nm 1 85 kgfcm ThinkPad X200 and X200s 79 Table 17 Removal steps of PCI Express Mini Card for wireless LAN continued When installing n models with wireless LAN card that has
149. s the system from being powered on by an unauthorized person The password must be entered before an operating system can be booted For how to remove the see Hard disk password There are two hard disk passwords HDPs User HDP for the user Master HDP for the system administrator who can use it to get access to the hard disk even if the user has changed the user HDP Note There are two modes for the User only and Master User The Master User mode requires two HDPs the system administrator enters both in the same operation The system administrator then provides the user HDP to the system user Attention If the user HDP has been forgotten check whether a master HDP has been set If it has it can be used for access to the hard disk drive If no master HDP is available neither Lenovo nor Lenovo authorized servicers provide any services to reset either the user or the master HDD or to recover data from the hard disk drive The hard disk drive can be replaced for a scheduled fee For how to remove the POP see How to remove the hard disk password on Supervisor password A supervisor password SVP protects the system information stored in the BIOS Setup Utility The user must enter the SVP in order to get access to the BIOS Setup Utility and change the system configuration Attention If the SVP has been forgotten and cannot be made available to the servicer there is no service procedure to reset the
150. ter 5 Using cursor keys select Main hard disk drive or Ultrabay hard disk drive 6 Press Enter to start the diagnostic program Diskette drive Diagnostics gt Diskette Drives Interactive Tests gt Diskette po ThinkPad X200 and X200s 53 Table 9 FRU tests continued FRU Applicable test Optical drive 1 Diagnostics gt Other Devices gt Optical Drive 2 Interactive Tests gt Optical Drive Test Memory 1 If two DIMMs are installed remove one of them and run Diagnostics gt PM Memory 2 If the problem does not recur return the DIMM to its place remove the other one and run the test again Fan 1 Turn on the computer and check the air turbulence at the louver near the PC Card slot 2 Run Diagnostics gt ThinkPad Devices Fan TrackPoint or pointing device If the TrackPoint does not work check the configuration as specified in the BIOS Setup Utility If the TrackPoint is disabled select Automatic to enable it After you use the TrackPoint the pointer may drift on the screen for a short time This drift can occur when a slight steady pressure is applied to the TrackPoint pointer This symptom is not a hardware problem If the pointer stops after a short time no service action is necessary If enabling the TrackPoint does not correct the problem continue with the following Interactive Tests gt Mouse 54 ThinkPad X200 an
151. the screws but do not remove them ThinkPad X200 and 2008 69 Table 13 Removal steps of dimm continued Note If only one DIMM is used on the computer you are servicing the card must be installed in SLOT 0 E but not in SLOT 1 When installing Insert the notched end of the DIMM into the socket Press the DIMM firmly and pivot it until it snaps into the place Make sure that it is firmly fixed in the slot and does not move easily 70 ThinkPad X200 and X200s Hardware Maintenance Manual 1040 Keyboard For access remove this FRU in order 71010 Battery pack on page 64 Table 14 Removal steps of keyboard 212 io 00 Below x 9 BP og 8152 5163 S RS Y IRE 9 gt 4 gt 6 5 S HB Step 71 ThinkPad X200 and X200s Table 14 Removal steps of keyboard continued Lift the keyboard a little in the direction shown by arrow Dn and then detach the connector 72 ThinkPad X200 and X200s Hardware Maintenance Manual Table 14 Removal steps of keyboard continued When installing 1 Attach the keyboard connector firmly 2 Make sure that the keyboard edges are under the frame as shown in this figure Then press the keys to latch the keyboard firmly in place 3 To make sure that the front side of the keyboard is housed firmly gently press the keys with yo
152. u select 4 Assign UUID A new UUID is created and written If a valid UUID already exists it is not overwritten 60 ThinkPad X200 and X200s Hardware Maintenance Manual Reading or writing the ECA information Information on Engineering Change Announcements ECA are stored in the EEPROM of the system board The electronic storage of this information simplifies the procedure to check if the ECA has been previously applied to a machine The machine does not need to be disassembled to check for the ECA application To check what ECAs have been previously applied to the machine use the ECA Information Read Write function on the ThinkPad Hardware Maintenance Diskette Version 1 73 or later 1 Insert the ThinkPad Hardware Maintenance Diskette Version 1 73 or later and restart the computer 2 From the main menu select 6 Set ECA Information 3 To read ECA information select 2 Read ECA rework number from EEPROM and follow the instruction 4 To read box build date select 5 Read box build date from EEPROM and follow the instruction on the screen After an ECA has been applied to the machine the EEPROM must be updated to reflect the ECA s application Use the ThinkPad Hardware Maintenance Diskette Version 1 73 or later to update the EEPROM Note Only the ECA number is stored in the EEPROM The machine type of the ECA is assumed be the same as the machine type of the machine that had the ECA applied to it 1 Insert the ThinkPa
153. ur thumbs and try to slide the keyboard toward you 4 Secure the keyboard by tightening the screws from the bottom side of the computer 73 ThinkPad X200 and X200s 1050 Palm rest or palm rest with fingerprint reader For access remove this FRU in order e 1010 Battery pack on page 64 e 71040 Keyboard on page 71 Note In models with the fingerprint reader the sensor is attached to the palm rest FRU If the fingerprint reader has any defects you can replace it by the procedures given in this section which are the same for a palm rest with or without a fingerprint reader Table 15 Removal steps of palm rest Step Screw quantity Color Torque L1 M2 x 5 mm wafer head Black 0 181 Nm nylon coated 5 1 85 kgfcm 74 ThinkPad X200 and X200s Hardware Maintenance Manual Table 15 Removal steps of palm rest continued Note Step H is only for models with the fingerprint reader For models without the fingerprint reader skip step Hl 75 ThinkPad X200 and X200s Table 15 Removal steps of palm rest continued When installing 1 In models with the fingerprint reader attach the fingerprint reader connector firmly to the system board 2 Press the left and right top edges of the palm rest to fit it into place 3 Push the front side of the palm rest until it clicks into place 4 Close the LCD cover and turn the computer over Then fasten the five sc
154. ute the connector cable as in this figure ga 5 ThinkPad 200 X200s 113 2030 Bluetooth daughter card BDC 2 1 For access remove these FRUs in order e 1010 Battery pack on page 64 2010 LCD front bezel on page 110 Table 31 Removal steps of Bluetooth daughter card When installing Make sure that the connector is attached firmly 114 ThinkPad X200 and X200s Hardware Maintenance Manual 2040 Integrated camera For access remove these FRUs in order 1010 Battery pack on page 64 e 2010 LCD front bezel on page 110 Table 32 Removal steps of Integrated camera Step Screw quantity Color Torque M2 x 3 5 mm wafer head nylon coated 2 Silver 0 181 Nm 1 85 kgfcm ThinkPad X200 and X200s 115 2050 LCD panel LCD brackets and LCD cable For access remove these FRUs in order 1010 Battery pack on page 6 1090 Intel Turbo Memory Minicard or wireless USB adapter on page 85 1100 Keyboard bezel on page 87 1130 LCD assembly on page 91 2010 LCD front bezel on page 110 2020 Inverter card on page 113 2030 Bluetooth daughter card BDC 2 1 on page 114 2040 Integrated camera on page 115 Table 33 Removal steps of LCD panel LCD brackets and LCD cable for 12 1 in WXGA LCD model 12 1 in WXGA LCD model Step Screw
155. verter bracket CCFL Note Italicized letters in parentheses are references to the exploded view in Overall on page 137 Rubber kit 44C9554 R N Rubber foot front Rubber foot rear Left Rubber foot rear Right AC adapters Table 44 Parts list AC adapters FRU P N RoHS CRU ID ID 2 pin 65 W 20 V adapter models CTO xxE xxF xxJ xxL 92 1214 R xxP xxY xxU 2 pin 65 W 20 V adapter models xxE xxF xxL 42T5282 R xxP xxS xxY 2 pin 65 W 20 V adapter models xxE xxF xxL 92P1159 R xxP xxS xxY xxU 3 pin 65W 20 V adapter models CTO xxC xxG 92P1212 R xxH xxK xxM xxT xxV OP 3 pin 65W 20 V adapter models CTO xxB xxC xxG 42T5283 R 5 xxK xxV OP 3 pin 65W 20 V adapter models CTO xxB xxG 92 1157 R xxK xxT xxV J ThinkPad 200 2008 185 Power cords A ThinkPad power cord for a specific country or region is usually available only in that country or region Table 45 Parts list 2 pin power cords Region P N RoHS CRU ID ID Argentina 42T5020 42T5105 R models Brazil 42T5180 42T5183 models CTO xxP Canada U S 42T5008 42T5093 models CTO xxF xxL xxS xxU Japan 42T5014 42T5099 models Exx Jxx
156. wer cord should be the type specified in the parts list C Insulation must not be frayed or worn 4 Check for cracked or bulging batteries Remove the cover 6 Check for any obvious non ThinkPad alterations Use good judgment as to the safety of any non ThinkPad alterations 7 Check inside the unit for any obvious unsafe conditions such as metal filings contamination water or other liquids or signs of fire or smoke damage 8 Check for worn frayed or pinched cables 9 Check that the power supply cover fasteners screws or rivets have not been removed or tampered with Safety information 5 Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits ICs should be considered sensitive to electrostatic discharge ESD ESD damage can occur when there is a difference in charge between objects Protect against ESD damage by equalizing the charge so that the machine the part the work mat and the person handling the part are all at the same charge Notes 1 Use product specific ESD procedures when they exceed the requirements noted here 2 Make sure that the ESD protective devices you use have been certified ISO 9000 as fully effective When handling ESD sensitive parts Keep the parts in protective packages until they are inserted into the product Avoid contact with other people Wear a grounded wrist strap against your skin to
157. wer part of the inverter card Afin d viter tout risque de choc lectrique ne retirez pas le cache en plastique prot geant la partie inf rieure de la carte d alimentation Aus Sicherheitsgr nden die Kunststoffabdeckung die den unteren Teil der Spannungswandlerplatine umgibt nicht entfernen p ov5an NVIN DN PONI PN nm52nunnn 1125 912 FW NANA dy Per evitare scosse elettriche non rimuovere la copertura in plastica che avvolge la parte inferiore della scheda invertitore BRM 7 50 1 1 8 6 7 0 577 7 274 7 I ERT Ei Para evitar descargas no quite la cubierta de pl stico que rodea la parte baja de la tarjeta invertida Safety notice 7 N DANGER Though the main batteries have low voltage a shorted or grounded battery can produce enough current to burn personnel or combustible materials Bien que le voltage des batteries principales soit peu lev le court circuit ou la mise la masse d une batterie peut produire suffisamment de courant pour br ler des mat riaux combustibles ou causer des br lures corporelles graves Obwohl Hauptbatterien eine niedrige Spannung haben k nnen sie doch bei Kurzschluf oder Erdung genug Strom abgeben um brennbare Materialien zu entz nden oder Verletzungen bei Personen hervorzurufen nna soya 7195970 70 ON 702725 0 1 PONT 712159 NPIN IN NIIP 102207 0 5n NALA YN n5 Sebbene le b
158. x 4Bx 4Gx 4 4Px 4 4Ux 4Vx 4Wx 7458 CTO 55x 58x 5Ex 5Fx 73x 79x 7Ex 7Fx 7Gx 7Hx 7Lx 7Mx 7Rx 7Vx 7Wx 7Xx 87x 8Ax 8Bx 8Cx 8Dx 8Ex 8Fx 8Gx 8Hx 8 x 8Kx 8Lx 8 8Nx 85 8Wx 8Yx 8Zx E2x F2x F3x F4x F5x F7x M2x M3x X4x 7459 CTO 5Ex 5Fx 62x 6Cx 6Fx 6Mx 6Rx 6Yx 6Zx E3x H2x M2x M3x 2023 CTO 2024 CTO 7462 CTO 42x 43x 4Dx 4Gx 4Kx 4Lx 4Mx 4Nx 4Px 4 4Rx 4Sx 4Tx 4Vx AWx 7465 CTO 23x 24x 2Ex 2Hx 2Mx 2Nx 2Px 20x 2Rx 25 2Tx 2Ux 2Xx 7466 CTO 32x 33x 38x 3Bx 3Ex 3Fx 3Gx 3Hx 3 3Lx 3Mx 3Nx 3Px 3Tx 3Ux 7469 CTO 52x 53x 58x 5Bx 5Ex 5Fx 5Gx 5 x 75x 78x 7 Ax 7Dx 7Ex 7Gx 7Hx 7 x 7Kx 7Lx 7Mx 7Nx 7 7Rx 75 7Tx 7Ux 7Vx 7Xx 1 7470 5Gx 62x 63x 68x 6Bx 6Fx 6 x 6Kx E1x 2046 CTO 2047 CTO 43Y6493 R ThinkPad X200 and X200 147 Table 39 Parts list Overall continued No FRU FRU no RoHS CRU 8 WiFi Link 5300 43Y6495 R 7454 22x 23x 24x 25x 27x 28x 2 2Kx 2Lx 2 2 2Ux 2Vx 96x 9 9 7455 CTO 32x 33x 34x 35x 38x 3Cx 3Gx 3Hx 3 3Lx 3Mx 3Nx 3Sx 3Tx 3Xx 3Yx 3Zx D2x D3x 7457 CTO 42x 43x 44x 46x 47x 49x ACx 4 4 4Fx 4 4Lx 4Mx 4Rx 4Sx 4Tx 7458 CTO 52x 53x 54x 56x 59x 5Bx 5Cx 5Dx 5Hx 5 x 5Lx 5M
159. x 5Nx 5Px 5Ox 5Rx 5Sx 5Tx 69x 72x 74x 76x 77x 7Cx 7Dx 7 x 7Kx 7Nx 7Px 7Qx 7Sx 7 7Ux 7 7Zx 82x 83x 84x 85x 86x 88x 89x 8Rx 8Tx 8Xx F8x F9x FAx X5x 7459 CTO 63x 64x 65x 66x 67x 68x 69x 6Ax 6Bx 6Dx 6Ex 6Gx 6 x 6Kx 6Nx 6Px 60x 6Tx 6Ux 6Vx 6Wx 6Xx 2023 CTO 2024 CTO 7462 CTO 44x 45x 46x 47x 48x 49x 4Ax 4Bx 4Cx 4Ex 4Fx 4Hx 7465 CTO 25x 26x 27x 28x 29x 2Dx 2Fx 2 x 2Kx 7466 CTO 34x 35x 39x 3Ax 3Cx 3Dx 3Rx 3Sx 7469 CTO 54x 55x 56x 57x 59x 5Ax 5Cx 5Dx 5Hx 5Kx 5Lx 5Mx 5Nx 5Px 5Ox 5Rx 5Sx 5Tx 5Ux 5Vx 5Wx 5Xx 5Yx 5Zx 72x 73x 74x 76x 77x 79x 7Bx 7Cx 7Fx 7Px 7470 CTO 5Hx 64x 65x 69x 6Ax 6Cx 6Dx 6Ex 6Gx 6Hx 2046 CTO 2047 CTO 8 Intel WiMAX WiFi Link 5350 42T0965 R 7454 CTO 9Fx 7455 CTO 7457 CTO 7458 CTO 7Bx 8Px 80x 7459 CTO 4 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 7470 CTO 2046 CTO 2047 CTO 148 ThinkPad X200 and X200s Hardware Maintenance Manual Table 39 Parts list Overall continued No FRU I O card assembly with modem connector with 5 in 1 Media Card Reader slot 7454 CTO 22x 23x 24x 25x 26x 27x 28x 29x 2Gx 2Hx 2 2Kx 2Lx 2 2Nx 2Px 20x 2Sx 2Tx 2Ux 2Vx 2Wx 2Xx 2Yx 2Zx 93x 95x 96x 97x 98x 9Bx 9Cx 9Fx 9Gx 7455 CTO 32x 33x
160. x 5Rx 5Sx 79x 7Px 84x 86x 8Ex 8Hx 8Lx 7459 CTO 66x 6Mx 6Nx 6 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 3Fx 3Gx 3 x 7469 CTO 5Fx 5Lx 5Px 5Vx 73x 7Vx 7470 CTO 6Ex 6 x 2046 CTO 2047 CTO 17 Blu Ray disk drive 9 5 mm 42T2517 7454 CTO 7455 CTO 7457 CTO 7458 CTO 7459 CTO 67x 6Px 6Wx 6Xx 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 7470 CTO 2046 CTO 2047 CTO 18 ThinkPad X200 UltraBase 42 4963 7454 2Hx 2 2Px 2 2Zx 96x 98x 9Gx 7455 CTO 3Sx 3Tx 3Xx 7457 CTO 7458 CTO 5Px 5Rx 5Sx 79x 7 7Px 84x 86x 8Ex 8Hx 8Lx 7459 CTO 66x 67x 6Mx 6 6Px 60x 6Wx 6Xx 4 2023 2024 7462 7465 7466 3Fx 3Gx 3 x 7469 CTO 5Fx 5Lx 5Jx 5 5Vx 5Wx 73x 7Vx 1 7470 6Ex 6 x 1 2046 CTO 2047 CTO 19 20 DIMM door kit 44C9555 Base cover assembly for 7454 44C9559 20 Base cover assembly for 7455 44C9560 20 Base cover assembly for 7457 44C9561 20 Base cover assembly for 7458 44C9562 2 2 21212 166 ThinkPad X200 and X200s Hardware Maintenance Manual Table 39 Parts list Overall continued No FRU FRU no RoHS CRU ID ID 20 cover assembly for 7459 42X5178 R N 20 cover assembly for 2023 42X5180 R N 20 cover
161. x 8 8Yx 8Zx E2x F2x F3x F4x Fox F7x F8x F9x FAx X4x X5x 7459 CTO 5Fx 65x 66x 67x 6Ax 6Bx 6Ex 6Gx 6 x 6Kx 6Nx 6Px 60x 6Vx 6Wx 6Xx E3x 4 2023 CTO 2024 CTO 7462 CTO 43x 44x 45x 46x 47x 48x 49x 4 4 4 4Dx 4 4Fx 4Gx 4Jx 4Rx 4Wx 7465 CTO 24x 25x 26x 27x 28x 29x 2Dx 2Ex 2Fx 2Hx 2Jx 2Kx 2Nx 2Sx 7466 CTO 33x 34x 35x 38x 39x 3Ax 3Bx 3Cx 3Dx 3Fx 3Gx 3Hx 3Lx 3Nx 3Rx 35 3Tx 3Ux 7469 CTO 53x 54x 55x 56x 57x 58x 59x 5Ax 5Bx 5 5Dx 5Ex 5Fx 5Gx 5Hx 5 x 5Kx 5Lx 5Mx 5Nx 5Px 5 5Rx 5Sx 5Tx 5Ux 5Vx 5Wx 5Xx 5Yx 5Zx 72x 73x 74x 78x 79x 7Cx 7Gx 7 x 7Lx 7 7Nx 7 7 7Rx 7Sx 7Tx 7Ux 7Vx 7470 CTO 5Gx 5Hx 63x 64x 65x 68x 69x 6Ax 6Bx 6Cx 6Dx 6Ex 6Fx 6Gx 6Hx 6 x 6Kx 2046 CTO 2047 CTO Qualcomm UNDP Wireless WAN card 7454 CTO 7455 CTO 7457 CTO 7458 CTO 5Hx 89x 7459 CTO 2023 CTO 2024 CTO 7462 CTO 7465 CTO 7466 CTO 7469 CTO 7470 CTO 2046 CTO 2047 CTO FRU no 43R1969 42T0961 RoHS ID R R CRU ID ThinkPad X200 2008 145 Table 39 Parts list Overall continued No FRU FRU no KDDI Wireless WAN Modem Adapter 43Y6476 7454 7455 CTO 7457 CTO 49x 7458 CTO 7459 CTO 2023 CTO 2024 CTO 7
162. y External CRT System board One beep and a blank unreadable or flashing LCD One long and two short beeps and a blank or unreadable LCD System board LCD assembly DIMM o m B II Two short beeps with error codes POST error See Numeric error codes Two short beeps and a blank screen 1 System board 2 DIMM Three short beeps pause three more short 1 DIMM beeps and one short beep 2 System board One short beep pause three short beeps pause three more short beeps and one short beep Only the cursor appears Reinstall the operating system Four cycles of four short beeps and a blank System board security chip screen Five short beeps and a blank screen System board No beep symptoms Table 4 No beep symptoms Symptom or error FRU or action in sequence No beep power on indicator on LCD blank 1 Make sure that every connector is and no POST connected tightly and correctly 2 DIMM 3 System board No beep power on indicator on and LCD Reseat DIMM blank during POST 2 Syete board The power on password prompt appears A power on password or a supervisor password is set Type the password and press Enter The hard disk password prompt appears A hard disk password is set Type the password and press Enter 44 ThinkPad X200 and X200s Hardware Maintenance Manual LCD related symptoms Important The

Lenovo 745068U User's Manual

Contents

Download Pdf Manuals

Related Search

Related Contents