Kawasaki NINJA B9272 User's Manual
Contents
1. ELECTRICAL HAZARD N WARNING e Battery can fall out and injure a child if vehicle tips over Always use battery clamp e PREVENT FIRE Never modify the electrical system Alterations could cause a fire resulting in serious injury and could also ruin the electrical system Use of the wrong type battery or charger could cause a fire or explosion resulting in serious injury Use of Power Wheels components in products other than Power Wheels vehicles could cause overheating fire or explosion e The battery must be handled by adults only The battery is heavy and contains sulfuric acid electrolyte Dropping the battery could result in serious injury e Never allow children to charge the battery Battery charging must be done by adults only A child could be injured by the electricity involved in charging the battery e Read the safety instructions on the battery e Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery If damage or excessive wear is detected do not use the charger or the battery until you have replaced the worn or damaged part e HOT motors Handle carefully RIDING HAZARD N WARNING e Prevent Injuries and Deaths e Direct Adult Supervision Required e Keep Children Within Safe Riding Areas These areas must be away from swimming pools and other bodies of water to prevent drownings generally level to prevent tipovers away from steps d2. Six month limited warranty on the 12 volt battery For the original purchaser this one year limited warranty covers the Power Wheels ride on vehicle purchased from Power Wheels against defects in materials and workmanship The six month limited warranty applies only to the 12 volt battery included by Power Wheels with the Original purchase of the vehicle This warranty covers normal use and does not cover the Power Wheels vehicle or battery if damaged by unreasonable use neglect accident abuse misuse improper service or other causes not arising out of defects in materials or workmanship Evidence of any attempt at consumer repair will void this warranty THIS WARRANTY DOES NOT COVER AND IS INTENDED TO EXCLUDE ANY LIABILITY ON THE PART OF POWER WHEELS WHETHER UNDER THIS WARRANTY OR IMPLIED BY LAW FOR ANY INDIRECT OR CONSEQUENTIAL DAMAGES FOR BREACH OF WARRANTY SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION SO THIS LIMITATION MAY NOT APPLY TO YOU Should you need service or assistance with your vehicle during the warranty period do not return the vehicle to the store Power Wheels has provided nationwide network of authorized service centers For the location of the authorized service center nearest you please visit us on line at www powerwheels com or call 1 800 348 0751 Power Wheels is continually expanding our Authorized Service Center Network If there is not an authorized service center in yo
3. Do not allow any child to drive the vehicle in the dark A child could encounter unexpected obstacles and have an accident Operate the vehicle only in the daytime or a well lit area 14 to remove the seat Lift the battery clamp to access the battery compartment Pull the motor harness connector from the battery Lift the battery clamp and slowly lower the battery into the compartment Replace the seat on the vehicle How to Operate Your Vehicle IMPORTANT As assembled your vehicle is ready to roll in low speed 21 2 mph maximum When your child is ready to drive the vehicle in high speed 5 mph maximum follow the instructions on this and the next page to connect the high speed hook up and use the power boost button Drive e Press the DRIVE button on the tank e Press the foot pedal The vehicle drives forward at a maximum of 21 2 mph e Help your child practice steering to learn how far and how quickly to turn the handlebar when driving forward in low speed Reverse IMPORTANT To prevent damaging the motors and gears teach your child to stop the vehicle before switching direction Never shift from drive to reverse or from reverse to drive without stopping Reverse e Press the REVERSE button on the tank e Press the foot pedal The vehicle backs up at a maximum of 21 2 mph Note The vehicle is designed to operate in low speed only in reverse e Help your child practice steering t
4. Please read this manual and save it with your original sales receipt Tools needed for assembly Phillips Screwdriver Hammer and Adjustable Wrench all not included Cap Nut Assembly Tool included Use only with a Power Wheels 12 Volt Battery with Built in Thermal Fuse and a Power Wheels 12 Volt Charger both included KAWASAKI AND NINJA ARE TRADEMARKS LICENSED BY KAWASAKI MOTORS CORP U S A WHICH DOES NOT MANUFACTURE OR DISTRIBUTE THIS PRODUCT CONSUMER INQUIRIES SHOULD BE DIRECTED TO FISHER PRICE INC POWER WHEELS www powerwheels com 636 GIRARD AVENUE EAST AURORA NY 14052 POWER Owner s Manual WHEELS with Assembly Instructions n by Fisher Price For Model B9272 Table of Contents A Important Information anaa aaa aaa e BRSEECES eee ek bb SER EERE S ee bok eedeen cee 2 B Warnings and Caution 1 ee eee eee 3 C Fans oeer rosenen ae es eee pee Ley eee eee S ore eee oe Gee ee lata ee eee ee eee eae 4 D Pans Dial apecgetaduesbeseseeucetas oh Oboe Cheah een agee se Swe a tahun 6 oe 2 oe eee eo 5 E Baten Changing s4ec 44 048 teat nae ha ete Ee eee eda Ae ees Pe a ek Ae ee ee 6 gt ASSCMOly erena nae tere pe onan heess sed hea ge badd ee sede ad eed bee heed tb hesapanged ead eas 7 G Label Decoration 34 2 a5 ee ese e hee eb edeo hee tenes ee eee Gb eee saddens besa abbas eee ees Bee 11 H Battery Installation 22025 nnana hed anne b4SCCES Sa Se ee Soe e a ee Oh RO Ee Eee ee ee 12 Battery Care and
5. 12 volt battery with built in thermal fuse Use of any other battery will damage your vehicle Make sure that you charge the battery for at least 18 hours using the enclosed Power Wheels 12 volt charger before operating your vehicle for the first time Charge the battery for at least 14 hours after each use of the vehicle Never charge the battery longer than 30 hours Failure to follow these instructions may damage your battery and will void your warranty e Lift the battery clamp and slowly lower the battery into the compartment e Press the tab under the back edge of the seat and lift to remove the seat Motor Harness Battery Connector Clamp x N N N N N Ss p S XY SS e Fit the tab at the front of the seat into the slot in the vehicle near the handlebars e Snap the tab at the back of the seat into the slot in the rear of the vehicle antl e Lift the battery clamp to access the battery compartment e Place the battery upright in the battery compartment e Plug the motor harness connector into the battery Push firmly to join 12 Battery Care and Disposal Care If a battery leak develops avoid contact with the leaking acid and place the damaged battery in a plastic bag See information below for proper disposal If acid comes in contact with skin or eyes flush with cool water for at least 15 minutes and call a physician If acid is internally ingested giv
6. motors and gears teach your child to stop the vehicle before switching between forward and reverse Do not tow anything behind the vehicle or overload it Do not exceed the maximum weight capacity of 65 Ibs 29 5 kg For safety reasons your vehicle has been pre set so that it will operate at low speed You must disconnect the high speed lock out to allow operation of the vehicle at high speed Please see page 15 for detailed instructions If you have any questions about your Power Wheels vehicle please call our toll free service lines at 1 800 348 0751 from 8 AM to 6 PM EST Monday through Friday Trained customer service representatives are available to take your call in English or French Habla Espanol Si usted tiene alguna pregunta necesita asistencia llame gratis 1 800 348 0755 para los Estados Unidos Tenemos representantes que hablan espanol para atender su llamada For your convenience Power Wheels maintains an independently owned and operated Authorized Service Center Network with more than 400 authorized service centers nationwide The authorized service centers will repair or replace parts under warranty at no extra charge and can perform non warranty repairs for a minimal charge To find the authorized service center nearest to you visit us on line at www powerwheels com or call 1 800 348 0751 If you would like to register your vehicle please visit us on line at www powerwheels com Warnings and Caution
7. not connected Loose wire or connector Motor or electrical switch damage Loose wire or connector Dead Spot on motor Damaged battery Child is switching between FORWARD and REVERSE without stopping warm during use and is not reason for concern Some chargers do not get warm during use It is normal for some batteries to make noise and swell slightly while charging and is not reason for concern Some batteries do not make noise or swell while charging It is normal for some chargers to get 19 Be sure to charge the battery after each use Even with proper care a rechargeable battery does not last forever Average battery life is 1 to 3 years depending on vehicle use and use conditions Replace only with Power Wheels 12 volt battery with built in thermal fuse Do not substitute parts Make sure you do not overload the vehicle by allowing more than 1 rider at one time exceeding the 65 Ib maximum weight capacity or by towing objects behind the vehicle If the vehicle is overloaded the fuse in the battery may trip and automatically shut down operation of the vehicle for approximately 25 seconds Adjust the driving conditions to prevent repeated automatic shutdowns on page 15 to connect High Speed Hook up Note The high speed connectors must be joined to use the high speed grip Check all wires around the motors and all connectors to make sure they are tight Contact your local Pow
8. Disposal 0 cc ee eee eee teens 13 u Cano FOr YOUrVeniCle 2c taeee ener k EE E aa ed ee Rede Eee eh eee eo ee E 13 K Ru les For Sale DIVINO aeane atx oo ee aan Wee ee a Bh ae de he ee Se Se A ow at ake he 14 L How to Operate Your Vehicle 0 0 0 cc ee eens 15 M Statement of Limited Warranty si 244406 400 sae e450 98 one wey edad eee AE ey ead a dws 16 N Problems and Solutions Guide 0 0 0 eee eee 17 Important Information e Your new vehicle requires adult assembly Please set aside at least 30 minutes for assembly e You must charge your battery for 18 30 hours before you use your vehicle for the first time We recommend that you start charging your battery before beginning assembly Please see Battery Charging beginning on page 6 for detailed instructions e Read this manual carefully for important safety information and operating instructions before using your vehicle e This vehicle is designed for use on grass asphalt and other hard surfaces on generally level terrain and by children 3 years of age and up e Use this vehicle ONLY outdoors Most interior floor ing can be damaged by riding this vehicle indoors Fisher Price will not be responsible for damage to floors if this vehicle is used indoors e Make sure children know and follow these rules for safe driving and riding always sit on the seat always wear shoes only 1 one rider at a time e To prevent damaging the
9. LY 7 Do not allow your child to drive on sloped or inclined away from steps driveways cars surfaces Restrict your child s driving to generally roads and alleys level ground ONLY 8 Do not allow your child to drive down or across a i steep slope Teach Safety Rules to Children The vehicle may gain unsafe speed even if the While children can quickly develop the skill necessary to pedal is released to stop drive this vehicle it is important to remember that their The vehicle may tilt and tip over judgment skills are still very immature Unsupervised driving by children can lead to serious injury Before i The wheels could lose traction causing the vehicle children use this vehicle an adult should carefully to slip evaluate the driving area as well as the children s skill 9 Do not allow your child to drive up steep inclines The level and ability to drive this vehicle safely Children are motor may stop and the vehicle could roll backwards at not always able to recognize or anticipate hazards even an unsafe speed when they have been taught about them THERE IS NO 10 Never put anything near any moving parts Rotating ACCEPTABLE SUBSTITUTE FOR DIRECT ADULT parts such as motors gear boxes and wheels can snag SUPERVISION fingers hair etc causing serious injury Do not allow Teach appropriate safety rules to your child before operation of the vehicle when it is on its side or in an allowing operation of this vehicle The
10. UTION Use the charger in dry locations only About Thermal Fuses Your Power Wheels 12 volt battery is equipped with a built in thermal fuse The thermal fuse is a self resetting safety device which automatically trips and shuts down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped it will automatically reset itself after approximately 25 seconds and allow the vehicle to resume normal operations To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 65 Ibs 29 5 kg maximum weight capacity or by towing anything behind the vehicle Avoid severe driving conditions such as driving up very steep slopes or running into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors Make sure your child stops the vehicle before switching speeds or direction Important Notes e Your new battery must be charged for at least 18 hours before you use it in your vehicle for the first time e We recommend that you start charging your battery before beginning assembly of your new vehicle e You do not need to remove the battery from your vehicle to recharge it e The battery must be upright while charging e The charger is not a toy e Do not short circuit the battery e Before charging the battery examine the battery case for cracks and other damage which may cause sulfuric aci
11. _ Authorized Service ceiters Visit us on line at l Power Wheels Consumer Relations WWW powerwheels coin a the location ne 1 800 348 0751 nearest you joe 8 AM 6 PM EST Monday through Friday Or contact your local independently owned and operated Power Wheels Authorized Service Center For the location nearest you visit us on line at www powerwheels com Fisher Price Power Wheels Power Wheels by Fisher Price and Power Lock are U S trademarks of Mattel Inc Fisher Price Inc a subsidiary of Mattel Inc East Aurora New York 14052 U S A 2005 Mattel Inc All Rights Reserved PRINTED IN MEXICO B9272a 0920
12. a problem with your charger contact your local Power Wheels authorized service center They can test your charger for you Each Power Wheels 12 volt battery has a built in thermal fuse A thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe The fuse will automatically reset itself after approximately 25 seconds allowing the vehicle to resume normal operation To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 65 lb maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center Check all wires and connectors Make sure the motor harness connector is tightly plugged into the battery and that there are no loose wires around the motors If your battery is old or if you have not followed Battery Care instructions your battery may be dead If you are unsure whether or not the battery is dead you can have it tested at your local Power Wheels authorized service center The electrical switches can become corroded due to exposure to water or moisture or can jam due to loose dirt sand or gravel Contact your local Power Wheels authorized service center for diagnosis and repair Contac
13. d electrolyte to leak during the charging process lf damage is detected do not charge the battery or use itin your vehicle Battery acid is very corrosive and can cause severe damage to surfaces it contacts e Do not charge the battery on a surface such as kitchen counter tops which could be damaged by the acid contained inside the battery Take precautions to protect the surface on which you charge your battery e Use only a Power Wheels 12 volt charger with type 12V connector 120 VAC 60 Hz 28W with an output of 12 VDC 1200mA to charge your Power Wheels rechargeable 12 volt battery e If your battery is old and will not accept a charge do not leave it in the vehicle Always remove a dead battery from the vehicle Battery Charger Connector e Plug the charger connector into the battery e Plug the charger into a standard 120 volt wall outlet Note If power flow to the wall outlet is controlled by a switch make sure the switch is ON e Before first time use charge the battery for at least 18 hours Never charge the battery longer than 30 hours e Recharge the battery for at least 14 hours after each use of your vehicle Do not charge the battery longer than 30 hours e Once the battery is charged pull firmly on the charger connector to disconnect it from the battery Unplug the charger from the wall outlet The battery is now ready to be installed in your vehicle Assembly N WARNING Childr
14. e water milk of magnesia or egg whites immediately Never give emetics or induce vomiting Call a physician e Charge a new battery for at least 18 hours before first use Never charge the battery longer than 30 hours Overcharging or undercharging the battery may shorten battery life and decrease vehicle running time e After the first charge recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Charge the battery after each use regardless of how long the vehicle was used e The battery must be upright while charging e Do not allow the battery to run down completely before charging e Charge the battery before storing the vehicle e Charge the battery at least once per month even if the vehicle has not been used e Leaving the battery in a discharged condition will ruin it e Always remove an exhausted battery from the vehicle Battery leakage and corrosion can damage the vehicle e Do not store the battery on a surface which could be damaged by the acid contained inside the battery Take precautions to protect the surface such as kitchen counter tops on which you store the battery e Do not store the battery in temperatures above 75 F or below 10 F e Prevent the battery from moving freely inside the battery compartment Always use the battery clamp to secure the battery in the battery compartment e Examine the battery charger and their connectors for exce
15. ear wheel driver fits onto the pins in the motor assembly inside the vehicle e Slide the other rear wider wheel onto the rear axle Make sure the ribs on the rear wheel fit into the grooves on the rear wheel driver e Slide a hubcap indented side out onto the rear axle Cap Nut Assembly Tool e Fit a cap nut on the end of the rear axle e Fit the cap nut assembly tool over the cap nut Tap the end of the cap nut assembly tool with a hammer to secure the cap nut on the end of the rear axle Pull on the rear wheel to be sure it is secure Hint You may need the help of another adult to support the other end of the rear axle while you tap the cap nut e Turn the vehicle upright Steering Column Handlebar Connector Large Opening e First fit the handlebar steering column and the handlebar connector down through the large opening in the front end of the vehicle e Now lift the front of the vehicle slightly and push down on the handlebar assembly to snap it in place Hooked End of Steering Column Steering Linkage e Turn the vehicle upside down and straighten the handlebar e Slide a steering linkage under the hooked end of the steering column Hint Only one of the steering linkages will fit under the hooked end of the steering column If the steering linkage does not fit try the other one Assembly Hooked End of the Steering Column Steering Linkage e Slide the other stee
16. en can be harmed by small parts sharp edges and sharp points in the vehicle s unassembled state or by electrical items Care should be taken in unpacking and assembly of the vehicle Children should not handle parts including the battery or help in assembly of the vehicle Rear Axle e Fit a 437 cap nut onto one end of the rear axle e Tap the other end of the rear axle with a hammer to secure the cap nut on the end of the rear axle Hint You may want to position the cap nut on a scrap block of wood to protect the assembly surface Rear Wheel Driver Ring Side Down Rib Up Rear Wheel Hubcap Indented Side Down e Slide a hubcap indented side down onto the rear axle e Locate a rear wheel The rear wheels are wider than the front wheels e Slide a rear wheel onto the rear axle Make sure the ribs on the wheel face up e Slide a rear wheel driver ring side down onto the rear axle Fit the grooves on the rear wheel driver onto the ribs on the rear wheel Rear Axle Assembly e Position the vehicle upside down e Slide the rear axle assembly through the hole in the back end of the vehicle body Make sure the rear wheel driver fits onto the pins in the motor assembly inside the vehicle Assembly Hubcap Indented Side Out Rear Wheel Rear Wheel Driver Ring Side Out we f Rear Axle e Slide the other rear wheel driver ring side out onto the rear axle Make sure the r
17. er Wheels authorized service center for diagnosis and repair Check all wires around the motors and all connectors to make sure they are tight Contact your local Power Wheels authorized service center for diagnosis and repair Contact your local Power Wheels authorized service center for diagnosis and repair Teach your child to stop the vehicle before switching direction Contact your local Power Wheels authorized service center for diagnosis and repair No action required If your charger does not get warm during use it does not mean that it is not working properly No action required If your battery does not make noise or swell slightly during charging it does not mean that it is not accepting the charge IMPORTANT DO NOT use this vehicle for the first time until you have charged the battery for 18 hours Remember to WV charge the battery immediately after each use WV charge the battery once a month during storage even if the vehicle has not been used Failure to follow these instructions will permanently damage your battery and void your warranty Please refer to the Battery Care Section in this manual for more information For high speed operation please refer to the How to Operate Your Vehicle Section in this manual for more information DO NOT Return your Vehicle to the Store A i If you are missing parts or need assistance Over 400 A eh r please call us toll free
18. he first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all wires and connectors Make sure the charger connector is tightly plugged into the battery and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Do not charge the battery longer than 30 hours If you suspect that your battery is damaged as a result of overcharging contact your local Power Wheels authorized service center They can test the battery for you Even with proper care a rechargeable battery does not last forever Average battery life is 1 to 3 years depending on vehicle use and use conditions Replace only with Power Wheels 12 volt battery with built in thermal fuse Do not substitute parts Each Power Wheels 12 volt battery has a built in thermal fuse A thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe The fuse will automatically reset itself after approximately 25 seconds allowing the vehicle to resume normal operation To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 65 lb maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually
19. iagram 12 Volt Battery Rear Axle Bushing 2 12 Volt Charger Rear Wheel Driver 2 Rear Wheel Wide 2 10 x 34 Screw 4 15 16 17 18 The Washer 3 Left Grip with Small Hole 8 x 34 Screw 1 8 Lock Nut Not Shown Label Sheet and Cap Nut Assembly Tool Battery Charging ELECTRICAL HAZARD A N WARNING e Battery can fall out and injure a child if vehicle tips over Always use battery clamp e PREVENT FIRE Never modify the electrical system Alterations could cause a fire resulting in serious injury and could also ruin the electrical system Use of the wrong type battery or charger could cause a fire or explosion resulting in serious injury Use of Power Wheels components in products other than Power Wheels vehicles could cause overheating fire or explosion The battery must be handled by adults only The battery is heavy and contains sulfuric acid electrolyte Dropping the battery could result in serious injury Never allow children to charge the battery Battery charging must be done by adults only A child could be injured by the electricity involved in charging the battery Read the safety instructions on the battery Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery If damage or excessive wear is detected do not use the charger or the battery until you have replaced the worn or damaged part N CA
20. o learn how far and how quickly to turn the handlebar when driving in reverse 15 Stop e Your vehicle has a patented electronic braking system that automatically stops the vehicle when your child s foot is lifted from the pedal e Make sure your child is comfortable with steering the vehicle and automatically knows how to stop High Speed High Speed Hook Up Connectors e Locate the handlebar connector in the opening inside the front end of the vehicle e Plug the handlebar connector into the motor harness connector e Re assemble the seat e To prevent operation of the vehicle in high speed simply disconnect the high speed hook up connectors How to Operate Your Vehicle High Speed IMPORTANT To avoid damaging the motors and gears stop the vehicle before shifting between low and high speed Twist Grip to Activate High Speed N e Turn the right grip to shift the vehicle into high speed The vehicle drives forward at a maximum of 5 mph e Help your child practice steering to learn how far and how quickly to turn the handlebar when driving forward in high speed IMPORTANT Use the vehicle ONLY outdoors Most interior flooring can be damaged by riding the vehicle indoors Fisher Price will not be responsible for damage to floors if vehicle is used indoors 16 Statement of Limited Warranty One year limited warranty from the date of purchase on the Power Wheels vehicle
21. right handlebar Hint If it is difficult to slide the grip onto the handlebar moisten the inside of the grip with water gt gt b ANS 4 e Fit the tab at the front of the seat into the slot in the vehicle near the handlebars Fit a cap nut on the end of the front axle e Snap the tab at the back of the seat into the slot near e Fit the cap nut assembly tool over the cap nut Tap the the rear of the vehicle end of the cap nut assembly tool with a hammer to secure the cap nut on the end of the axle Pull on the front wheel to be sure it is secure e Repeat steps 11 and 12 to assemble a washer bushing front wheel hubcap and cap nut to the other front axle 10 Label Decoration Proper label application will help to keep the labels looking their best When applying labels keep the following guidelines in mind e Wash your hands before applying the labels e Before applying the labels wipe the surface of the vehicle with a clean dry cloth to remove any dust or oils e Place the labels exactly as shown in the illustrations e For best results avoid repositioning a label once it has been applied to the vehicle e After applying a label rub the label firmly with a clean dry cloth to make sure the label is adhered to your vehicle Start at the center of a label and smooth towards the outer edges to remove air bubbles 11 Battery Installation IMPORTANT Use only a Power Wheels
22. ring linkage over the hooked end of the steering column and the other steering linkage e Fit the hooked end of the steering column into the hole in the steering linkage Washer e Slide a washer onto the end of the steering column e Insert the 8 x screw through the hole in the end of the steering column so that the screw head faces the front of the vehicle e Fit the 8 lock nut onto the end of the screw Make sure the rounded side of the lock nut faces the rear of the vehicle e While holding the lock nut steady with an adjustable wrench tighten the screw with a Phillips screwdriver Do not over tighten Steering Linkage Assembly TT ea e Squeeze both steering linkages together e Insert four 10 x s screws into the steering linkage assembly Tighten the screws with a Phillips screwdriver Do not over tighten Assembly Front Axle Front Wheel Bushing Flat Side Ring End First First NNN ia j a Hubcap Indented Side Out e Turn the vehicle upright Note The left and right grips are not interchangeable e Slide a washer onto a front axle The hole in the left grip is smaller than the hole in e Slide a bushing ring end first onto the front axle the right grip e Slide a front wheel flat side first onto the front axle e Fit the left grip on the end of the left handlebar e Slide a hubcap indented side out onto the front axle e Fit the right grip on the end of the
23. riveways cars roads and alleys N CAUTION e In the unassembled state this package contains small parts Adult assembly is required e Use the charger in dry locations only e f you experience a problem with this product or are missing a part please call us at 1 800 348 0751 rather than return this product to the store e Please identify all parts before assembly and save all packaging material until assembly is complete to ensure that no parts are discarded e Some parts were placed under the seat for shipment Press the tab under the back of the seat and lift to access the battery compartment e Metal parts have been coated with a lubricant to protect them during shipment Wipe all metal parts with a paper towel to remove any excess lubricant wp FA A Ez f g 1g E Ei i ft ff Rear Axle 12 Volt Battery 12 Volt Charger a Left Grip with Small Hole C Bushing 2 Right Grip with Seat o f Large Hole Wenhicl g Rear Wheel Driver 2 Rear Wheel 2 Front Wheel 2 Hubcap 4 Note Rear Wheels are wider than Front Wheels Part Not Shown Label Sheet Cap Nut Assembly Tool 8 x 24 Screw 1 8 Lock Nut 1 NY 10 x 3 4 Screw 4 Handlebar All Fasteners Shown Actual Size For your convenience extra fasteners are included Vehicle Handlebar Right Grip with Large Hole Front Wheel 2 Hubcap 4 Cap Nut 4 Seat Parts D
24. se rules should also upside down position be reviewed with neighborhood children or other playmates 11 Do not operate the vehicle near flammable vapors who want to drive this vehicle gasoline paint thinner acetone liquid wax etc Riding Rules The vehicle s electrical switches like most electrical switches emit an internal spark when first turned on or Make sure children know and follow these rules for turned off The presence of flammable liquids or vapors safe driving could cause an explosion or a fire Keep all flammable 1 Always sit on the seat products in tightly sealed containers and away from 2 Always wear shoes the vehicle 12 Do not allow a child to operate the vehicle without 3 Only 1 one rider at a time A child who is not sitting on the seat or who is standing on the vehicle could fall off cause a tip over or block the drivers view A child could be seriously injured direct adult supervision To prevent unsupervised use of the vehicle disconnect the motor harness from the battery when the vehicle is not in use To disconnect the motor harness and battery 4 Do not allow any child to drive the vehicle in the street i or near moving motorized vehicles connector 5 Do not allow any child to drive near bodies of water Press the tab under the back edge of the seat and lift such as pools or creeks obstructions such as furniture low tree limbs or play equipment or drop offs such as stairs or decks
25. ssive wear or damage each time you charge the battery If damage is detected do not use the charger or the battery until you have replaced the worn or damaged part 13 Disposal xd X e Your Power Wheels battery is a sealed lead acid battery It must be recycled or disposed of in an environmentally sound manner e Do not dispose of a lead acid battery in your regular household trash The incineration landfilling or mixing of sealed lead acid batteries with household trash is prohibited by law in most areas e Do not dispose of a lead acid battery in a fire The battery may explode or leak e Return exhausted batteries to a federal or state approved lead acid battery recycler such as a Power Wheels authorized service center or a local seller of automotive batteries For the service center location nearest you please call 1 800 348 0751 Contact your local waste management officials for other information regarding the environmentally sound collection recycling and disposal of lead acid batteries If you live in the State of Florida or Minnesota it is prohibited by law for anyone to throw away lead acid batteries in the municipal waste stream Caring For Your Vehicle e Check all screws cap nuts and their protective coverings regularly and tighten as required Check plastic parts on a regular basis for cracks or broken pieces e During snowy or rainy weather the vehicle should be stored inside or under a protecti
26. t your local Power Wheels authorized service center for diagnosis and repair Problems and Solutions Guide Problem Possible Cause Somin Vehicle was running but suddenly stopped Tripped thermal fuse Short run time less than 1 3 hours per charge Undercharged battery Overcharged battery Battery is old and will not accept full charge Tripped thermal fuse Vehicle runs sluggishly Undercharged battery Loose wire or loose connectors 18 Check all wires and connectors Make sure the motor harness connector is tightly plugged into the battery and that there are no loose wires around the motors Each Power Wheels 12 volt battery has a built in thermal fuse A thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe The fuse will automatically reset itself after approximately 25 seconds allowing the vehicle to resume normal operation To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 65 Ib maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for t
27. trips contact your local Power Wheels authorized service center Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all connectors Make sure the charger connector is tightly plugged into the battery and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Problems and Solutions Guide Vehicle runs sluggishly cont Vehicle runs in low speed but does not run in high speed Note The vehicle is designed to operate in low speed only in reverse Sometimes the vehicle doesn t run but other times it does When the foot pedal is pressed the vehicle won t run without a push Battery s thermal fuse constantly trips but the vehicle is not overloaded nor the driving conditions too severe Loud clacking or grinding noise from a motor gearbox Charger gets warm during use Battery makes a sizzling or gurgling noise when charging Battery needs charging Battery is old and will not accept accept full charge Vehicle is overloaded Driving conditions are too stressful Use only on generally level ground The vehicle was pre set to operate only in low speed until you connect the high speed hook up Follow the instructions High speed hook up
28. ur area please call Consumer Relations for information 1 800 348 0751 THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH MAY VARY FROM STATE TO STATE PLEASE SAVE YOUR ORIGINAL SALES RECEIPT Problems and Solutions Guide IMPORTANT If you experience a problem with your vehicle first check the Problems and Solutions Guide below If you still experience a problem please contact Power Wheels Consumer Relations toll free at 1 800 348 0751 between 8 AM and 6 PM EST Monday through Friday Or contact your local Power Wheels authorized service center For the location nearest to you please visit us on line at www powerwheels com or call 1 800 348 0751 Vehicle does not run Undercharged battery Charger is not working Tripped thermal fuse Loose wire or loose connectors Dead battery Electrical switch damage Motor damage 17 Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all connectors Make sure the battery connector is tightly plugged into the battery and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON There is no sure way to tell if your charger is working unless you have a volt meter If you suspect there is
29. ve cover Remember to charge the battery at least once per month while your vehicle is not in regular use e Avoid operating the vehicle in wet or snowy conditions and do not spray the vehicle with a hose Do not wash the vehicle with soap and water Water or moisture in the motors or electrical switches can cause them to corrode and could cause switch or motor failure e Avoid operating the vehicle on sand loose dirt or gravel Sand loose dirt or gravel in the motors or electrical switches can cause them to jam and could cause switch or motor failure e The vehicle can be wiped down with a soft dry cloth For a shiny finish you can wipe plastic parts with a non wax furniture polish applied to a soft cloth Do not use automotive wax Do not use soap and water or spray the vehicle with a hose e To ensure that your vehicle stays in good operating order we recommend that you periodically have your vehicle checked by a Power Wheels authorized service center For the location of the authorized service center nearest you please visit us on line at www powerwheels com or call 1 800 348 0751 Rules for Safe Driving RIDING HAZARD N WARNING Prevent Injuries and Deaths e Direct Adult Supervision Required e Keep Children Within Safe Riding Areas These areas must be away from swimming pools and other bodies of water to prevent drownings generally level to prevent tipovers Use vehicle on generally level ground ON
Download Pdf Manuals
Related Search